Owners have filed 426 complaints
about the 2022 KIA EV6 with NHTSA between 2022 and 2026.
The largest single group is the electrical system.
Across this model's run it ranks 1 of 4 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 100
Against the median year of the KIA EV6. 50 means typical for this
model; 100 means roughly double.
Severity — 42
8.2% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
75% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
1023.8%
Warnings
819.0%
Automatic Emergency Braking
614.3%
Assist
49.5%
Adaptive Cruise Control
49.5%
Blind Spot Detection
49.5%
Warning
37.1%
Warnings
37.1%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
14.2%
1,000 – 9,999 miles
1041.7%
10,000 – 24,999 miles
729.2%
25,000 – 49,999 miles
14.2%
50,000 – 74,999 miles
312.5%
75,000 – 99,999 miles
14.2%
100,000 – 149,999 miles
14.2%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Apr 2022peak 40Aug 2026
NHTSA investigations into the 2022 KIA EV6
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
On July 3, 2023, the Office of Defect Investigation (ODI) opened PE23012 to investigate allegations of loss of motor power on model year (MY) 2022 Kia EV6 vehicles. Some consumers reported loss of motor power immediately after warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charing Unit (ICCU) may become damaged over time from transient high voltage and thermal cycling. A damaged ICCU may not be able to charge the 12-volt battery which can discharge gradually while driving with a reduction of motive power. The...
DP22005Opened 27 Jan 2023Closed 7 Aug 2023ELECTRICAL SYSTEM:PROPULSION SYSTEM
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after Marc...
Recalls on the 2022 KIA EV6
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202470011,445 units in Canada
High Voltage
Issue: Over time, the integrated charging control unit (ICCU) could become damaged. As a result, the 12 V battery will not charge and could cause the vehicle to enter a reduced power mode. If this happens, and you continue to drive the vehicle, there could be a loss of power to the wheels. Note: This problem will cause a warning light to turn on and warning messages to display before any loss of power. This recall replaces Transport Canada recall no. 2024-173. Vehicles that were repaired under that recall also require this repair. Safety Risk: A loss of power to the wheels could increase the risk of a crash. Corrective Actions: Kia will notify owners by mail and advise you to take your vehicle to a dealership to update the vehicle software. The dealer will also inspect and, if necessary, replace the ICCU and ICCU fuse.
Recall 2024549647,384 units in Canada
Label
Issue: On certain vehicles, the compliance label may be missing information in French. The words listed on the label for "Tires", "Rims", "Front" and "Rear" appear in English only, when they should be listed as "Tires/Pneus", "Rims/Jantes", "Front/Avant" and "Rear/Arriere". Canadian regulations require this information to be listed on the label in both English and French. Safety Risk: These small errors do not affect vehicle safety. Corrective Actions: This is not a recall. Kia has corrected the compliance label for all new vehicles.
Recall 20241736,745 units in Canada
High Voltage
This recall was replaced by Transport Canada recall no. 2024-700. Issue: Over time, the integrated charging control unit (ICCU) could become damaged. As a result, the 12 V battery will not charge and could cause the vehicle to enter a reduced power mode. If this happens, and you continue to drive the vehicle, there could be a loss of power to the wheels. Note: This problem will cause a warning light to turn on and warning messages to display before any loss of power. Safety Risk: A loss of power to the wheels could increase the risk of a crash. Corrective Actions: Kia will notify owners by mail and advise you to take your vehicle to a dealership to update the vehicle software. The dealer will also inspect and, if necessary, replace the ICCU and ICCU fuse.
Recall 2022247440 units in Canada
Powertrain
Issue: On certain vehicles, the parking pawl could disengage for a short time just after the vehicle is parked and turned off. As a result, the vehicle could move suddenly if the parking brake isn't used. Safety Risk: A parked vehicle that moves suddenly could create the risk of an injury or a crash. Corrective Actions: Kia will notify owners by mail and instruct you to take your vehicle to a dealership to update the shifter control unit software. To reduce the safety risk, Kia recommends that you should use the parking brake each time that you park.
Reports where the owner recorded a crash, a fire, an injury or a death.
Wake Village, TXCrash
SERVICE BRAKES
Most vehicles with ABS experience what I call “ABS shudder/jutter” when applying brakes across a road seam where the road surface is uneven or a rut in the road. In this particular case while applying the brakes across a long rut in the road, the “ABS shudder/jutter” was much worse. NOT SPEEDING and having plenty of distance to stop. With brake pedal to the floor several times, the vehicle continued to move forward. The last few feet before colliding with a pickup truck, although the road was completely dry, the vehicle was driving forward yet sliding forward slowly. Felt no different than being on ice. Collision aversion system did nothing to help avoid. There is also only electronic parking brake and not an emergency brake to pull a handle on to assist in stopping. Dealership wasn’t able to find anything simply by driving around and slamming on the brakes and not finding any error codes. Regional technician currently scheduled to be here the 27th of Jan. Several people online have expressed similar concerns, just haven’t hit anything. I feel that the issue lies with the ABS system specifically braking over uneven road seams or ruts in the road and my experience is being discounted.
NHTSA complaint #11713276 — an unverified report by a vehicle owner.
Most vehicles with ABS experience what I call “ABS shudder/jutter” when applying brakes across a road seam where the road surface is uneven or a rut in the road. In this particular case while applying the brakes across a long rut in the road, the “ABS shudder/jutter” was much worse. NOT SPEEDING and having plenty of distance to stop. With brake pedal to the floor several times, the vehicle continued to move forward. The last few feet before colliding with a pickup truck, although the road was completely dry, the vehicle was driving forward yet sliding forward slowly. Felt no different than being on ice. Collision aversion system did nothing to help avoid. There is also only electronic parking brake and not an emergency brake to pull a handle on to assist in stopping. Dealership wasn’t able to find anything simply by driving around and slamming on the brakes and not finding any error codes. Regional technician currently scheduled to be here the 27th of Jan. Several people online have expressed similar concerns, just haven’t hit anything. I feel that the issue lies with the ABS system specifically braking over uneven road seams or ruts in the road and my experience is being discounted.
NHTSA complaint #11713276 — an unverified report by a vehicle owner.
Shepherdstown, WVCrash
VEHICLE SPEED CONTROL
Prior to midnight on 9/25/2025 I stopped at a Sheetz in Stephen"s City , Va to charge my 2022 Kia EV6. Upon pulling into the charging area I discovered construction fencing around the area with the chargers removed. I then drove to the other side of the store and parked next to the building to take advantage of the lighting as I scanned my phone app for alternative chargers in the area. SUDDENLY, within the blink of an eye, my car lunged forward at MAXIMUM speed. It came to a sudden stop , prior to hitting the glass and brick wall of the building. I was stunned. My first reaction was to try to go into reverse to back away from the building and then I noticed people coming toward me. I rolled the window down and heard them ask if I was ok , if I needed help calling 911, and then they began to insist that I climb down out of the car as they feared it would catch on fire. I did not understand what they meant initially, until I realized I was LOOKING DOWN at them. With assistance, I got out of my car and realized it was impaled upon the metal barrier post located in the middle , front of the parking space. The local sheriff dept responded and after putting me through all the DUI tests/exercises realized that I , indeed , was sober and not responsible for the incident. The deputy called Clem's Garage/Towing who arrived 30-45 min latter with a standard tow truck - I tried to explain that tugging at my car from the rear would not release it from the pole ( the rear of the car pointed toward the pavement while the front pointed toward the sky) and that continuing to tug would only do more damage (I wanted to prevent my car further damage). He eventually called another company who arrived with a large crane-like vehicle that lifted my car off the pole. The top portion of the pole was missing and apparently stuck in my car . My car was then towed to Clem's holding yard.
NHTSA complaint #11690621 — an unverified report by a vehicle owner.
Shepherdstown, WVCrash
ELECTRICAL SYSTEM
Prior to midnight on 9/25/2025 I stopped at a Sheetz in Stephen"s City , Va to charge my 2022 Kia EV6. Upon pulling into the charging area I discovered construction fencing around the area with the chargers removed. I then drove to the other side of the store and parked next to the building to take advantage of the lighting as I scanned my phone app for alternative chargers in the area. SUDDENLY, within the blink of an eye, my car lunged forward at MAXIMUM speed. It came to a sudden stop , prior to hitting the glass and brick wall of the building. I was stunned. My first reaction was to try to go into reverse to back away from the building and then I noticed people coming toward me. I rolled the window down and heard them ask if I was ok , if I needed help calling 911, and then they began to insist that I climb down out of the car as they feared it would catch on fire. I did not understand what they meant initially, until I realized I was LOOKING DOWN at them. With assistance, I got out of my car and realized it was impaled upon the metal barrier post located in the middle , front of the parking space. The local sheriff dept responded and after putting me through all the DUI tests/exercises realized that I , indeed , was sober and not responsible for the incident. The deputy called Clem's Garage/Towing who arrived 30-45 min latter with a standard tow truck - I tried to explain that tugging at my car from the rear would not release it from the pole ( the rear of the car pointed toward the pavement while the front pointed toward the sky) and that continuing to tug would only do more damage (I wanted to prevent my car further damage). He eventually called another company who arrived with a large crane-like vehicle that lifted my car off the pole. The top portion of the pole was missing and apparently stuck in my car . My car was then towed to Clem's holding yard.
NHTSA complaint #11690621 — an unverified report by a vehicle owner.
Shepherdstown, WVCrash
FORWARD COLLISION AVOIDANCE: WARNINGS
Prior to midnight on 9/25/2025 I stopped at a Sheetz in Stephen"s City , Va to charge my 2022 Kia EV6. Upon pulling into the charging area I discovered construction fencing around the area with the chargers removed. I then drove to the other side of the store and parked next to the building to take advantage of the lighting as I scanned my phone app for alternative chargers in the area. SUDDENLY, within the blink of an eye, my car lunged forward at MAXIMUM speed. It came to a sudden stop , prior to hitting the glass and brick wall of the building. I was stunned. My first reaction was to try to go into reverse to back away from the building and then I noticed people coming toward me. I rolled the window down and heard them ask if I was ok , if I needed help calling 911, and then they began to insist that I climb down out of the car as they feared it would catch on fire. I did not understand what they meant initially, until I realized I was LOOKING DOWN at them. With assistance, I got out of my car and realized it was impaled upon the metal barrier post located in the middle , front of the parking space. The local sheriff dept responded and after putting me through all the DUI tests/exercises realized that I , indeed , was sober and not responsible for the incident. The deputy called Clem's Garage/Towing who arrived 30-45 min latter with a standard tow truck - I tried to explain that tugging at my car from the rear would not release it from the pole ( the rear of the car pointed toward the pavement while the front pointed toward the sky) and that continuing to tug would only do more damage (I wanted to prevent my car further damage). He eventually called another company who arrived with a large crane-like vehicle that lifted my car off the pole. The top portion of the pole was missing and apparently stuck in my car . My car was then towed to Clem's holding yard.
NHTSA complaint #11690621 — an unverified report by a vehicle owner.
San Diego, CACrash1 killed
AIR BAGS
I was involved in a fatal head-on collision with a pedestrian while driving my Kia EV6. What component or system failed or malfunctioned, and is it available for inspection upon request? Forward Collision-Avoidance Assist : The FCA system appears to have completely failed. It did not detect the pedestrian, did not provide any audible or visual warnings, and did not initiate automatic emergency braking prior to the collision. Airbag System: The system failed to deploy despite a severe head-on collision. Regarding availability for inspection: The car was impounded by the SDPD and was inspected by both the police and State Farm before being sold to SF after being rendered a total loss. How was your safety or the safety of others put at risk? My Safety: The failure of the airbags to deploy put me at significant risk of serious injury or death in the severe head-on collision. The Safety of Others: While the primary consequence of the FCA failure was the tragic impact with the pedestrian, the malfunction of a safety system designed to prevent or mitigate collisions inherently puts all potential road users at risk. Had the FCA functioned correctly, the collision might have been avoided entirely or the impact speed significantly reduced, potentially altering the outcome for the pedestrian. Has the problem been reproduced or confirmed by a dealer or independent service center? No not to my knowledge. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? As mentioned above, the car was impounded by the SDPD and was fully inspected by both the police and State Farm. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? None.
NHTSA complaint #11655093 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Columbus, OH
ELECTRICAL SYSTEM
I began to drive. The dashboard display read "Check low voltage supply" or something like that and on the opposite side of the display there was a small image that looks like a 12V battery. A moment later the dashboard display changed to read "DO NOT DRIVE." The car was towed to a dealer who reported a "failed ICCU and High Voltage Fuse." The vehicle was towed to a dealership where it is being repaired under warranty. The same parts were replaced on December 26, 2024, that time because the electric vehicle would no longer accept a charge from a 240VAC source, although it continued accept a charge from a high voltage DC source. At that time there was also a software update that was said to correct the defect.
NHTSA complaint #11756667 — an unverified report by a vehicle owner.
Novi, MI
EXTERIOR LIGHTING
The taillight came loose and every time i take it in to get checked or fixed at the dealer they ignore me, so i went in and tightened my self. there were 4 nuts already off and inside my trunk and there was no loctite on the bolts holding the light on. now the lamp is leaking water into the trunk and the tail light has water inside of it.
NHTSA complaint #11753424 — an unverified report by a vehicle owner.
Bentonville, AR
ELECTRICAL SYSTEM
Vehicle Safety Complaint My Kia experienced an ICCU (Integrated Charging Control Unit) failure and was at the dealership for approximately two months while awaiting repairs. The ICCU and related components were replaced, and I was told the vehicle had been repaired. However, immediately after I received the vehicle back, the “Check Electric Vehicle System” warning illuminated again. Since that time, the vehicle has continued to experience serious electrical issues. The vehicle has unexpectedly shut off while stopped at red lights and has failed to restart on multiple occasions, leaving me stranded. This creates a significant safety hazard because the vehicle can lose the ability to move while in traffic, placing me and other motorists at risk. I have returned the vehicle to the dealership twice since the ICCU replacement, but the problem has not been resolved. The dealership has been unable to identify or permanently repair the defect. I have been without my vehicle for nearly three months this calendar year due to this issue. More importantly, I no longer feel safe driving the vehicle because I cannot trust that it will remain operational in traffic. I am submitting this complaint because I believe this represents a serious safety defect involving the vehicle’s electrical system and propulsion system. I request that NHTSA investigate this issue to determine whether other Kia owners are experiencing similar failures and whether additional action is warranted to protect consumers.
NHTSA complaint #11753355 — an unverified report by a vehicle owner.
Bentonville, AR
ENGINE
Vehicle Safety Complaint My Kia experienced an ICCU (Integrated Charging Control Unit) failure and was at the dealership for approximately two months while awaiting repairs. The ICCU and related components were replaced, and I was told the vehicle had been repaired. However, immediately after I received the vehicle back, the “Check Electric Vehicle System” warning illuminated again. Since that time, the vehicle has continued to experience serious electrical issues. The vehicle has unexpectedly shut off while stopped at red lights and has failed to restart on multiple occasions, leaving me stranded. This creates a significant safety hazard because the vehicle can lose the ability to move while in traffic, placing me and other motorists at risk. I have returned the vehicle to the dealership twice since the ICCU replacement, but the problem has not been resolved. The dealership has been unable to identify or permanently repair the defect. I have been without my vehicle for nearly three months this calendar year due to this issue. More importantly, I no longer feel safe driving the vehicle because I cannot trust that it will remain operational in traffic. I am submitting this complaint because I believe this represents a serious safety defect involving the vehicle’s electrical system and propulsion system. I request that NHTSA investigate this issue to determine whether other Kia owners are experiencing similar failures and whether additional action is warranted to protect consumers.
NHTSA complaint #11753355 — an unverified report by a vehicle owner.
Albuquerque, NM
STRUCTURE:BODY
The front lower air dam and felt underguard detached while driving at highway speed on an interstate. The panel dropped and dragged on the pavement. I secured it with duct tape and zip ties at the roadside in order to drive home. There was no collision and no impact with road debris. The bumper fascia directly above the panel is undamaged, with no deformation and no paint transfer, which is not consistent with an impact and is consistent with failure of the panel's mounting fasteners. The panel shows longitudinal drag scoring on the underside and outward flex-fracture of the mounting clips. The right side detached first and the left side remained held by a single screw. The component is available for inspection on request. There were no warning lamps or messages before the failure. I brought the vehicle to a Kia dealer in [XXX] on XXX, at approximately 40,000 miles and within the 5-year/60,000-mile basic warranty. The dealer's technician identified multiple fractured mounting clips, of which only two remain intact. The dealer declined to submit a warranty claim, citing evidence of impact, and reattached the panel using added screws. The fractured clips were not replaced. The dealer's paperwork records the vehicle as repaired, but the technician verbally advised me to drive carefully because the underlying fastener failure was not corrected and the panel is not held by its designed fasteners. I opened a case with the manufacturer's consumer assistance center on June 9, 2026 (case number XXX) and submitted photographs as requested. I have received no substantive response in six weeks. A body panel that detaches at highway speed and drags on the roadway is a hazard to the vehicle behind it and to my control of the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11753114 — an unverified report by a vehicle owner.
Lincoln, CA
UNKNOWN OR OTHER
1. Severe Safety Concerns (Battery Thermal Risk & Component Interdependency) The PTC (Positive Temperature Coefficient) heater in my vehicle has failed. This component failure has completely disabled my vehicle’s air conditioning (AC) system. In the Kia EV6 architecture, the AC compressor loop is not merely a cabin comfort feature; it is intrinsically linked to the vehicle's thermal management system responsible for cooling the high-voltage traction battery pack. California temperatures are projected to hit 110°F immediately. Without a functioning AC system, the vehicle cannot execute critical battery cooling procedures. Yesterday, when plugging the vehicle into a charger, the high-voltage battery became alarmingly hot. Forcing a lithium-ion battery pack to accept high-current DC fast charging without operational coolant loop heat rejection poses an immediate, catastrophic risk of thermal runaway and vehicle fire. I am terrified to operate, park, or charge this vehicle in upcoming extreme summer conditions. 2. Predatory Maintenance Plan Tie-In Offer Yesterday, the dealership called and acknowledged the issue. They offered to cover 70% of the diagnostic and repair labor costs under corporate goodwill, as I am technically out of the standard warranty period. However, they applied an unfair and coercive condition: I am only eligible for this safety assistance if I purchase a mandatory 2-year maintenance contract costing $120 per month (totaling $2,880 over 24 months). Because the EV6 is a fully electric vehicle, its routine maintenance profile is virtually nonexistent. The dealership explicitly stated that this contract would exclusively cover tire rotations. Charging nearly $3,000 for tire rotations as a gatekeeping mechanism to fix a dangerous battery cooling defect is highly exploitative. The cost of this forced maintenance plan essentially equals or exceeds paying for the entire repair out-of-pocket, rendering the "70% goodwill coverage" an empty gesture.
NHTSA complaint #11748279 — an unverified report by a vehicle owner.
Lincoln, CA
ELECTRICAL SYSTEM
1. Severe Safety Concerns (Battery Thermal Risk & Component Interdependency) The PTC (Positive Temperature Coefficient) heater in my vehicle has failed. This component failure has completely disabled my vehicle’s air conditioning (AC) system. In the Kia EV6 architecture, the AC compressor loop is not merely a cabin comfort feature; it is intrinsically linked to the vehicle's thermal management system responsible for cooling the high-voltage traction battery pack. California temperatures are projected to hit 110°F immediately. Without a functioning AC system, the vehicle cannot execute critical battery cooling procedures. Yesterday, when plugging the vehicle into a charger, the high-voltage battery became alarmingly hot. Forcing a lithium-ion battery pack to accept high-current DC fast charging without operational coolant loop heat rejection poses an immediate, catastrophic risk of thermal runaway and vehicle fire. I am terrified to operate, park, or charge this vehicle in upcoming extreme summer conditions. 2. Predatory Maintenance Plan Tie-In Offer Yesterday, the dealership called and acknowledged the issue. They offered to cover 70% of the diagnostic and repair labor costs under corporate goodwill, as I am technically out of the standard warranty period. However, they applied an unfair and coercive condition: I am only eligible for this safety assistance if I purchase a mandatory 2-year maintenance contract costing $120 per month (totaling $2,880 over 24 months). Because the EV6 is a fully electric vehicle, its routine maintenance profile is virtually nonexistent. The dealership explicitly stated that this contract would exclusively cover tire rotations. Charging nearly $3,000 for tire rotations as a gatekeeping mechanism to fix a dangerous battery cooling defect is highly exploitative. The cost of this forced maintenance plan essentially equals or exceeds paying for the entire repair out-of-pocket, rendering the "70% goodwill coverage" an empty gesture.
NHTSA complaint #11748279 — an unverified report by a vehicle owner.
Middletown, DE
ELECTRICAL SYSTEM
ICCU failure caused charger circuit breaker to trip due to sudden fault current situation
NHTSA complaint #11747389 — an unverified report by a vehicle owner.
at 12,000 milesMaple Valley, WA
ELECTRICAL SYSTEM
The contact owns a 2022 Kia EV6. The contact stated that while driving approximately 6-7 MPH in the left-turn lane, the vehicle made an abnormal popping sound and stalled. The vehicle was pushed to the side of the road with assistance. The vehicle failed to restart and was towed to the dealer, where it was diagnosed with Integrated Charging Control Unit (ICCU) failure. The ICCU was replaced, and the vehicle was repaired; however, the failure recurred several times. Additionally, the contact stated that while driving at slow speeds, the messages "Check ABS", "Check ESC", "Check Electronic Parking Brake" and "Pull Over Safely" were displayed, and alarms sounded on several occasions. The vehicle was not repaired. The manufacturer was contacted several times, and a case was filed. The failure mileage was approximately 12,000.
NHTSA complaint #11747419 — an unverified report by a vehicle owner.
Prairie Village, KS
ELECTRICAL SYSTEM
On the night of [XXX], the vehicle was plugged in to AC charge at my home charging at 7.5kw (32 amps/240 volts). The next morning, the dedicated breaker to the EVSE was tripped, and the EVSE was damaged and unusable upon resetting the breaker. The car had charged approximately 20% before cutting off. A new EVSE was ordered and arrived by that night, however the car would not accept a charge, and displayed a "charging failure" message, despite the new EVSE working on two other electric vehicles. Additionally, the vehicle to load (V2L) functionality was compromised, and the vehicle displayed an error message when attempting to use the V2L. The vehicle was taken into Kia service center located in Mission, KS on 6/29, and diagnosed with a broken ICCU, which is scheduled for service on 7/1/2026. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11747190 — an unverified report by a vehicle owner.
Roswell, GA
ELECTRICAL SYSTEM
ICCU electrical system failed while driving (~1mi from house). Warning messages popped up and caused me to pull over and drive back to house under reduced speed. Kia told me car was not safe to drive and to tow car for repair under warranty. ICCU failure was confirmed by service provider and repaired after 2 weeks (diagnosis, part order, and replacement).
NHTSA complaint #11746073 — an unverified report by a vehicle owner.
Cumming, GA
ELECTRICAL SYSTEM
Vehicle ICCU unit failed resulting in inability to charge at level 1/2 on AC power and would have ultimately led to failure of the 12v battery, which results in the car shutting down. Posing a safety risk. Resulting repair led to coolant level issue. Currently the only solution to the problem is replacement of the unit, with the exact same unit model. Leaving the possibility of it happening again. The manufacturer has not developed a long term solution to the problem, which is common and affects a large percentage of the vehicles. Previous software update recall did not correct the issue.
NHTSA complaint #11744666 — an unverified report by a vehicle owner.
Mercer Island, WA
ELECTRICAL SYSTEM
My car was in my garage and charging with my home's level-2 charger on June 1 2026 in standard fashion. At 2am the charging was interrupted by the car (per charger log) and stopped at 68% charge (set to fully charge to 100%). Subsequently the car could not charge any more, and I tested this with two independent level-2 charging units. Both of these chargers are confirmed operational with another electric car in my garage. I took the car to Kia Service on June 4 and they confirmed it was a failed ICCU.
NHTSA complaint #11742188 — an unverified report by a vehicle owner.
Guilderland, NY
POWER TRAIN
On [XXX] while traveling to NJ, the vehicle displayed "check electrical system" and would not accept a charge. With only 40 miles of range remaining, I drove the vehicle to Jack Daniels KIA. It is STILL at the dealership, and neither the dealer nor KIA Corp has provided a date that the car will be repaired. The dealer told me that it is covered under the 100kmi powertrain warranty, but that KIA corp must direct how and what to fix. They continue to supposedly try different things to fix the car, but either are not applying resources or are ignorant in how to fix the vehicle. KIA will also not compensate me $1308.99 to cover my current losses (car note, uber to get home when it died, and fuel costs) to date. The car has been out of my possession now for 44 consecutive days straight without any end in sight, compensation, or expected repair date. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11739629 — an unverified report by a vehicle owner.
Guilderland, NY
ELECTRICAL SYSTEM
On [XXX] while traveling to NJ, the vehicle displayed "check electrical system" and would not accept a charge. With only 40 miles of range remaining, I drove the vehicle to Jack Daniels KIA. It is STILL at the dealership, and neither the dealer nor KIA Corp has provided a date that the car will be repaired. The dealer told me that it is covered under the 100kmi powertrain warranty, but that KIA corp must direct how and what to fix. They continue to supposedly try different things to fix the car, but either are not applying resources or are ignorant in how to fix the vehicle. KIA will also not compensate me $1308.99 to cover my current losses (car note, uber to get home when it died, and fuel costs) to date. The car has been out of my possession now for 44 consecutive days straight without any end in sight, compensation, or expected repair date. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11739629 — an unverified report by a vehicle owner.
Chicago, IL
ELECTRICAL SYSTEM
Integrated Charging Control Unit (ICCU )failure on the high voltage battery leading to also the 12v battery failure.
NHTSA complaint #11738042 — an unverified report by a vehicle owner.
Santa Maria, CA
ELECTRICAL SYSTEM
Lost power while driving. 12Vbattery low voltage on dash. ICCU not responding. Dealership replaced ICCU and told me it wasn't under warranty. Had to pay out of pocket.
NHTSA complaint #11738175 — an unverified report by a vehicle owner.
Phoenix, AZ
POWER TRAIN
Vehicle would not start/drive. Vehicle was parked in garage at time of failure. Kia dealership said the ICCU needed to be replaced along with the 12V battery. Prior to the failure, audio was not working in the car for several weeks. Kia stated that was due to the ICCU issues and that the 12V was most likely also failing due to the ICCU. ICCU was covered by KIA, but owner of the vehicle had to pay for the replacement of the 12V battery. Vehicle was inspected by manufacturer at the local Kia dealership.
NHTSA complaint #11737371 — an unverified report by a vehicle owner.
Phoenix, AZ
ELECTRICAL SYSTEM
Vehicle would not start/drive. Vehicle was parked in garage at time of failure. Kia dealership said the ICCU needed to be replaced along with the 12V battery. Prior to the failure, audio was not working in the car for several weeks. Kia stated that was due to the ICCU issues and that the 12V was most likely also failing due to the ICCU. ICCU was covered by KIA, but owner of the vehicle had to pay for the replacement of the 12V battery. Vehicle was inspected by manufacturer at the local Kia dealership.
NHTSA complaint #11737371 — an unverified report by a vehicle owner.
Tempe, AZ
ELECTRICAL SYSTEM
Car lost power and stopped Diagnosed iccu failure Now reporting coolant issue following repair
NHTSA complaint #11736300 — an unverified report by a vehicle owner.
Cypress, TX
ELECTRICAL SYSTEM
The Integrated Charging Control Unit (ICCU) failed twice within four weeks. The first failure occurred in March 2026 and was repaired under recall SC327 with a replacement ICCU and fuse. The second failure occurred April 7, 2026, approximately 12 days after pickup. Symptoms: Vehicle failed to charge overnight on Level 1 and Level 2 circuits despite being plugged in. Later that day, while driving, a “Check Electrical System” warning appeared on the dashboard followed by sudden loss of power and acceleration. Vehicle fluctuated between 25-45 mph and could not maintain speed. Vehicle was driven approximately 2.2 miles to the dealership under its own power after warning onset. Safety risk: Sudden loss of power and acceleration while driving created a hazardous condition for myself. Dealer confirmation: The authorized Kia dealer confirmed a DTC for battery overheating and acknowledged the ICCU coolant was not fully topped off after the first replacement, suggesting the recall remedy was incompletely performed. The vehicle has remained at the dealer unrepaired since April 10, 2026. Component available for inspection: Yes, vehicle is currently at the dealership. Recall remedy concern: The SC327 recall remedy did not resolve the ICCU failure. A second failure occurred within two weeks of the repair. The dealer’s subsequent diagnosis of owner-caused undercarriage battery damage is contradicted by their own signed inspection report documenting all undercarriage items as passed with no damage noted
NHTSA complaint #11733353 — an unverified report by a vehicle owner.
Cassadaga, NY
ELECTRICAL SYSTEM
ICCU failed after 49,059 miles. Levels 1&2 charging do not work. I must use DCFC to charge the car.
NHTSA complaint #11732905 — an unverified report by a vehicle owner.
Cassadaga, NY
FUEL/PROPULSION SYSTEM
ICCU failed after 49,059 miles. Levels 1&2 charging do not work. I must use DCFC to charge the car.
NHTSA complaint #11732905 — an unverified report by a vehicle owner.
Newalla, OK
POWER TRAIN
This make/model has a known ICCU issue. Ours went out just after warranty expired and the cost is $4,000. The EU and some Asian countries have extended the warranty of this fault due to how prevalent it is.
NHTSA complaint #11730936 — an unverified report by a vehicle owner.
Roscoe, IL
ELECTRICAL SYSTEM
ICCU failure at 16k miles. The ICCU was replaced at the dealership on January, 29th of this year, so it is not available for inspection. The failure tripped a breaker at my home while it was charging possibly indicating a short circuit. The short circuit could have potentioally overheated and caught fire in my home. I took the vehicle to the dealership and they confirmed it was the ICCU and replaced it under warranty. I have a copy of the invoice received after the replacement was installed. I do not know what they did with the old ICCU after it was placed. There was no indication of pending failure that I noticed prior to this incident occuring.
NHTSA complaint #11729952 — an unverified report by a vehicle owner.