Owners have filed 122 complaints
about the 2024 KIA EV6 with NHTSA between 2024 and 2026.
The largest single group is the electrical system.
Across this model's run it ranks 2 of 4 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 29
Against the median year of the KIA EV6. 50 means typical for this
model; 100 means roughly double.
Severity — 89
17.2% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — not reported
Too few complaints recorded a mileage to measure this.
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Mar 2024peak 25Jul 2026
Recalls on the 2024 KIA EV6
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 and 2024 EV9 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.
Risk: A fire increases the risk of injury.
24V867000
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Risk: A loss of drive power increases the risk of a crash.
24V200000
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Risk: A loss of drive power increases the risk of a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202470011,445 units in Canada
High Voltage
Issue: Over time, the integrated charging control unit (ICCU) could become damaged. As a result, the 12 V battery will not charge and could cause the vehicle to enter a reduced power mode. If this happens, and you continue to drive the vehicle, there could be a loss of power to the wheels. Note: This problem will cause a warning light to turn on and warning messages to display before any loss of power. This recall replaces Transport Canada recall no. 2024-173. Vehicles that were repaired under that recall also require this repair. Safety Risk: A loss of power to the wheels could increase the risk of a crash. Corrective Actions: Kia will notify owners by mail and advise you to take your vehicle to a dealership to update the vehicle software. The dealer will also inspect and, if necessary, replace the ICCU and ICCU fuse.
Recall 2024549647,384 units in Canada
Label
Issue: On certain vehicles, the compliance label may be missing information in French. The words listed on the label for "Tires", "Rims", "Front" and "Rear" appear in English only, when they should be listed as "Tires/Pneus", "Rims/Jantes", "Front/Avant" and "Rear/Arriere". Canadian regulations require this information to be listed on the label in both English and French. Safety Risk: These small errors do not affect vehicle safety. Corrective Actions: This is not a recall. Kia has corrected the compliance label for all new vehicles.
Recall 20241736,745 units in Canada
High Voltage
This recall was replaced by Transport Canada recall no. 2024-700. Issue: Over time, the integrated charging control unit (ICCU) could become damaged. As a result, the 12 V battery will not charge and could cause the vehicle to enter a reduced power mode. If this happens, and you continue to drive the vehicle, there could be a loss of power to the wheels. Note: This problem will cause a warning light to turn on and warning messages to display before any loss of power. Safety Risk: A loss of power to the wheels could increase the risk of a crash. Corrective Actions: Kia will notify owners by mail and advise you to take your vehicle to a dealership to update the vehicle software. The dealer will also inspect and, if necessary, replace the ICCU and ICCU fuse.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 20,000 milesStrasburg, COCrash1 injured
AIR BAGS
The contact owned a 2024 Kia EV6 and stated that while driving at 40 MPH, an elk suddenly appeared in front of the vehicle, resulting in a head-on collision that completely crushed the front end of the vehicle with no air bags deployed. The front end of the vehicle was crushed including the windshield. The vehicle continued with the elk after collision dragging it a couple yards ahead. The air bags did not apply. No waring lights were illuminated. No police report was filed. The contact was the only passenger during the collision. The contact suffered a sever neck issue and is not able to move his neck to the right, has chest pain and shoulder pain on both sides, and a head injury. Medical treatment is need but has not gotten any due to insurance issues. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 20,000.
NHTSA complaint #11740227 — an unverified report by a vehicle owner.
The contact owned a 2024 Kia EV6 and stated that while driving at 40 MPH, an elk suddenly appeared in front of the vehicle, resulting in a head-on collision that completely crushed the front end of the vehicle with no air bags deployed. The front end of the vehicle was crushed including the windshield. The vehicle continued with the elk after collision dragging it a couple yards ahead. The air bags did not apply. No waring lights were illuminated. No police report was filed. The contact was the only passenger during the collision. The contact suffered a sever neck issue and is not able to move his neck to the right, has chest pain and shoulder pain on both sides, and a head injury. Medical treatment is need but has not gotten any due to insurance issues. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 20,000.
NHTSA complaint #11740227 — an unverified report by a vehicle owner.
I was backing out of my driveway and backed into a vehicle parked directly behind me. The collision avoidance and emergency braking system should have stopped my car before impact but it did not. No sounds other than the normal backing up beeping. Proximity alert did not ping. The vehicle is available for inspection upon request. The safety feature of collision avoidance and emergency breaking did not work. No, the problem has not been reproduced or confirmed by a dealer or independent service center. No, the vehicle component has not been inspected by the manufacturer, police, insurance representative or other. The police were called to the scene, they just looked at the damage on both vehicles. No warning lamps, messages or other symptoms of the problem prior to the failure. They only appeared once on the day of the accident. I can confirm the backup collision avoidance worked after the incident since the emergency breaking stopped my car in a parking lot after the incident of the failure.
NHTSA complaint #11732922 — an unverified report by a vehicle owner.
Venice, CACrash
SERVICE BRAKES
Incident took place 1/31/26. I was pulling into my driveway at approximately 5 mph. Normally, as I approach the wooden driveway gate, sensors would begin to beep and I would be prompted to stop.The car normally would stop itself if a collision was imminent. This did not take place. Instead, the car picked up speed, smashed through the gate proceeded up the driveway, smashed through the garage door and the rear wall of the garage. I was alone and uninjured, but the structure was yellow tagged and there was severe damage to the contents. Airbags were not deployed. The car was towed to Caliber body shop in Santa Monica for repairs to the body. When this has been completed it will be taken to Kia of Santa Monica for analysis of the black box and braking system.
NHTSA complaint #11716470 — an unverified report by a vehicle owner.
Venice, CACrash
FORWARD COLLISION AVOIDANCE: WARNINGS
Incident took place 1/31/26. I was pulling into my driveway at approximately 5 mph. Normally, as I approach the wooden driveway gate, sensors would begin to beep and I would be prompted to stop.The car normally would stop itself if a collision was imminent. This did not take place. Instead, the car picked up speed, smashed through the gate proceeded up the driveway, smashed through the garage door and the rear wall of the garage. I was alone and uninjured, but the structure was yellow tagged and there was severe damage to the contents. Airbags were not deployed. The car was towed to Caliber body shop in Santa Monica for repairs to the body. When this has been completed it will be taken to Kia of Santa Monica for analysis of the black box and braking system.
NHTSA complaint #11716470 — an unverified report by a vehicle owner.
Incident took place 1/31/26. I was pulling into my driveway at approximately 5 mph. Normally, as I approach the wooden driveway gate, sensors would begin to beep and I would be prompted to stop.The car normally would stop itself if a collision was imminent. This did not take place. Instead, the car picked up speed, smashed through the gate proceeded up the driveway, smashed through the garage door and the rear wall of the garage. I was alone and uninjured, but the structure was yellow tagged and there was severe damage to the contents. Airbags were not deployed. The car was towed to Caliber body shop in Santa Monica for repairs to the body. When this has been completed it will be taken to Kia of Santa Monica for analysis of the black box and braking system.
NHTSA complaint #11716470 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Teaneck, NJ
ELECTRICAL SYSTEM
Car was totally dead even with a 68% charge. AAA came out to jump start. The next day while driving on the highway the car started to lose power. A red warning to check the electrical system came on along with "turtle mode". I was able to pull over off the highway, grateful the two small children were not with me. Car was towed to dealer who kept it for the three days. Only after repeated calling could I reach someone who said they couldn't reproduce the problem. I'm afraid to drive the car at this point as I feel it's just unsafe to do so. This seems to be an ongoing issue that Kia can't seem to fix.
NHTSA complaint #11751635 — an unverified report by a vehicle owner.
Arcadia, CA
WHEELS
Rear tires on my 2024 Kia EV6 wore down to the tire wear-bar limit (2/32" remaining tread) at approximately 19,500 miles, while the front tires on the same vehicle measured roughly double that remaining tread (4/32") at the same odometer reading. The factory-installed tires are rated by the manufacturer for approximately 50,000 miles of tread life under normal use, so reaching the wear-out point on the rear tires alone at roughly 39% of that rated mileage is well outside expected wear for this vehicle at this mileage. This is not an isolated event: numerous other EV6 owners have independently reported the same front-to-rear wear disparity and premature rear tire wear online, across different driving styles and regions, which points to a vehicle characteristic (front/rear torque split, alignment or camber specification, or suspension geometry) rather than individual driver behavior. Uneven, accelerated rear tire wear reduces traction and increases stopping distance, and raises the risk of hydroplaning, tread separation, or blowout, particularly in wet weather, since the rear tires lose effective grip well before the front tires or before a typical maintenance interval would flag it. The wear was confirmed and documented, including tread-depth measurements at all four corners, by an independent third-party vehicle condition inspection performed at lease return. There were no dashboard warning lights or driver-facing alerts indicating the wear; it was only discovered through physical tread-depth measurement at that inspection. The tires inspection results are available upon request. This appears to reflect a design or specification issue affecting the vehicle's rear tires disproportionately, rather than a manufacturing defect isolated to one tire.
NHTSA complaint #11750683 — an unverified report by a vehicle owner.
Santa Rosa, CA
ELECTRICAL SYSTEM
We purchased a certified pre-owned 2024 Kia EV6 GT on 6/5/2026. On 6/6/2026 while driving on city streets, the display screen suddenly displayed a large and flashing red warning message "Stop vehicle and check power supply" in addition to the battery symbol. We took the vehicle to the dealership and they diagnosed that the ICCU had failed and needed to be replaced.
NHTSA complaint #11749585 — an unverified report by a vehicle owner.
West Hartford, CT
ELECTRICAL SYSTEM
Component: ELECTRICAL SYSTEM:12V/LOW VOLTAGE BATTERY, PROPULSION system:Integrated Charging Control Unit (ICCU) Description: This vehicle previously had the mandated safety recall software update (Campaign SC327) applied by an authorized Kia dealership in December 2024 to protect the Integrated Charging Control Unit (ICCU). The corporate recall remedy failed. In January 2026, the vehicle suffered a sudden, catastrophic loss of motive power while driving on a public roadway due to a total ICCU failure, which created an immediate hazard for myself and my young child who was inside the vehicle. When the primary ICCU component failed, it starved the low-voltage system, causing severe deep-discharge damage to the 12V battery. Following the warranty repair of the ICCU in February 2026, the vehicle was returned to me. However, Kia's official corporate diagnostic and repair procedures for this defect are fundamentally flawed and incomplete; they do not mandate a comprehensive load-test or automatic replacement of the 12V battery following an ICCU collapse. Because of this failure in the official repair procedures, the vehicle was returned to service with a critically compromised low-voltage system. This directly resulted in recurring battery warning messages over the subsequent months, culminating on May 29, 2026, in a secondary, total 12V battery failure that completely bricked the vehicle. The failure of the manufacturer's official safety recall remedy and the subsequent inadequacy of their post-failure service protocol left this vehicle in a chronically un-roadworthy and unsafe condition.
NHTSA complaint #11741641 — an unverified report by a vehicle owner.
at 20,000 milesStrasburg, COCrash1 injured
AIR BAGS
The contact owned a 2024 Kia EV6 and stated that while driving at 40 MPH, an elk suddenly appeared in front of the vehicle, resulting in a head-on collision that completely crushed the front end of the vehicle with no air bags deployed. The front end of the vehicle was crushed including the windshield. The vehicle continued with the elk after collision dragging it a couple yards ahead. The air bags did not apply. No waring lights were illuminated. No police report was filed. The contact was the only passenger during the collision. The contact suffered a sever neck issue and is not able to move his neck to the right, has chest pain and shoulder pain on both sides, and a head injury. Medical treatment is need but has not gotten any due to insurance issues. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 20,000.
NHTSA complaint #11740227 — an unverified report by a vehicle owner.
The contact owned a 2024 Kia EV6 and stated that while driving at 40 MPH, an elk suddenly appeared in front of the vehicle, resulting in a head-on collision that completely crushed the front end of the vehicle with no air bags deployed. The front end of the vehicle was crushed including the windshield. The vehicle continued with the elk after collision dragging it a couple yards ahead. The air bags did not apply. No waring lights were illuminated. No police report was filed. The contact was the only passenger during the collision. The contact suffered a sever neck issue and is not able to move his neck to the right, has chest pain and shoulder pain on both sides, and a head injury. Medical treatment is need but has not gotten any due to insurance issues. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 20,000.
NHTSA complaint #11740227 — an unverified report by a vehicle owner.
Pottstown, PA
ELECTRICAL SYSTEM
Does not ac charge and no codes present
NHTSA complaint #11736865 — an unverified report by a vehicle owner.
Green Bay, WI
ELECTRICAL SYSTEM
I had an ICCU failure on 4/12/26. I was fortunate enough to be close to home, so I was able to get back home before the vehicle dropped into reduced power mode. As has been reported many other places, I heard a loud pop and moments later a number or warning messages came up on the display. It was towed to the dealer the following day and has been confirmed to be an ICCU failure.
NHTSA complaint #11735651 — an unverified report by a vehicle owner.
University Heights, OH
POWER TRAIN
2024 Kia EV6 leased January 2025. Vehicle is subject to NHTSA Recall 24V-867 / Kia campaign SC327 for the Integrated Charging Control Unit (ICCU). The recall remedy was performed at an authorized Kia dealer in July 2025 (software / operational logic update). The defect was not cured. Three months after the recall remedy was performed, the vehicle suffered complete loss of electrical power and would not move. It was towed to the Kia dealer. The dealer's own diagnostic recorded code P1A9096 — the exact diagnostic code Kia's recall instructs technicians to check for — and replaced the ICCU and high-voltage fuse. This is the recall-defined failure occurring AFTER the recall remedy was applied. Approximately three months later, the vehicle again suffered total loss of power and would not start in cold weather. It was towed in. The dealer replaced only the 12-volt battery and did not address the ICCU, despite the documented prior ICCU failure on this VIN. The 12V battery failure is a known downstream symptom of ICCU failure on this platform. Approximately one month after that, the vehicle returned for charging system failure ("vehicle charges briefly then stops") and a "check electrical/hybrid system" warning that appeared while driving. Diagnosed as charging port failure. Vehicle was out of service approximately 27 consecutive days. Total cumulative days out of service across four visits: approximately 35-40. Two safety-related stranding incidents resulted from these failures. Both occurred in winter conditions in Pennsylvania. In the first, the driver was stranded in a parking lot at night during a snowstorm in sub-zero conditions; three tow trucks were dispatched before a flatbed could recover the vehicle because the EV could not be towed conventionally with no power. In the second, the vehicle died in a school parking lot during a snowstorm; the first dispatched tow truck could not recover an EV with no power, and the driver had to walk multiple miles home in freezing
NHTSA complaint #11734168 — an unverified report by a vehicle owner.
University Heights, OH
ELECTRICAL SYSTEM
2024 Kia EV6 leased January 2025. Vehicle is subject to NHTSA Recall 24V-867 / Kia campaign SC327 for the Integrated Charging Control Unit (ICCU). The recall remedy was performed at an authorized Kia dealer in July 2025 (software / operational logic update). The defect was not cured. Three months after the recall remedy was performed, the vehicle suffered complete loss of electrical power and would not move. It was towed to the Kia dealer. The dealer's own diagnostic recorded code P1A9096 — the exact diagnostic code Kia's recall instructs technicians to check for — and replaced the ICCU and high-voltage fuse. This is the recall-defined failure occurring AFTER the recall remedy was applied. Approximately three months later, the vehicle again suffered total loss of power and would not start in cold weather. It was towed in. The dealer replaced only the 12-volt battery and did not address the ICCU, despite the documented prior ICCU failure on this VIN. The 12V battery failure is a known downstream symptom of ICCU failure on this platform. Approximately one month after that, the vehicle returned for charging system failure ("vehicle charges briefly then stops") and a "check electrical/hybrid system" warning that appeared while driving. Diagnosed as charging port failure. Vehicle was out of service approximately 27 consecutive days. Total cumulative days out of service across four visits: approximately 35-40. Two safety-related stranding incidents resulted from these failures. Both occurred in winter conditions in Pennsylvania. In the first, the driver was stranded in a parking lot at night during a snowstorm in sub-zero conditions; three tow trucks were dispatched before a flatbed could recover the vehicle because the EV could not be towed conventionally with no power. In the second, the vehicle died in a school parking lot during a snowstorm; the first dispatched tow truck could not recover an EV with no power, and the driver had to walk multiple miles home in freezing
NHTSA complaint #11734168 — an unverified report by a vehicle owner.
University Heights, OH
FUEL/PROPULSION SYSTEM
2024 Kia EV6 leased January 2025. Vehicle is subject to NHTSA Recall 24V-867 / Kia campaign SC327 for the Integrated Charging Control Unit (ICCU). The recall remedy was performed at an authorized Kia dealer in July 2025 (software / operational logic update). The defect was not cured. Three months after the recall remedy was performed, the vehicle suffered complete loss of electrical power and would not move. It was towed to the Kia dealer. The dealer's own diagnostic recorded code P1A9096 — the exact diagnostic code Kia's recall instructs technicians to check for — and replaced the ICCU and high-voltage fuse. This is the recall-defined failure occurring AFTER the recall remedy was applied. Approximately three months later, the vehicle again suffered total loss of power and would not start in cold weather. It was towed in. The dealer replaced only the 12-volt battery and did not address the ICCU, despite the documented prior ICCU failure on this VIN. The 12V battery failure is a known downstream symptom of ICCU failure on this platform. Approximately one month after that, the vehicle returned for charging system failure ("vehicle charges briefly then stops") and a "check electrical/hybrid system" warning that appeared while driving. Diagnosed as charging port failure. Vehicle was out of service approximately 27 consecutive days. Total cumulative days out of service across four visits: approximately 35-40. Two safety-related stranding incidents resulted from these failures. Both occurred in winter conditions in Pennsylvania. In the first, the driver was stranded in a parking lot at night during a snowstorm in sub-zero conditions; three tow trucks were dispatched before a flatbed could recover the vehicle because the EV could not be towed conventionally with no power. In the second, the vehicle died in a school parking lot during a snowstorm; the first dispatched tow truck could not recover an EV with no power, and the driver had to walk multiple miles home in freezing
NHTSA complaint #11734168 — an unverified report by a vehicle owner.
Kansas City, MO
POWER TRAIN
Vehicle display showed a message stating 12 volt battery was low and to pull over immediately, the car the died in a parking lot. I called KIA roadside service and they connected a battery pack to the 12 volt battery and got the car started. This could have been a serious problem if I was on travelling on a public street or highway and suddenly lost power.
NHTSA complaint #11733902 — an unverified report by a vehicle owner.
Bakersfield, CA
EXTERIOR LIGHTING
Listing as all 3. ICCU/fuse went out, car decelerated to 45 MPH max and flashed a warning to pull over. The bottom left battery indicator for the 12v battery also changed to red, indicating it was not regaining power from the main EV battery. Currently in shop hoping to get part in soon
NHTSA complaint #11733307 — an unverified report by a vehicle owner.
Bakersfield, CA
ENGINE
Listing as all 3. ICCU/fuse went out, car decelerated to 45 MPH max and flashed a warning to pull over. The bottom left battery indicator for the 12v battery also changed to red, indicating it was not regaining power from the main EV battery. Currently in shop hoping to get part in soon
NHTSA complaint #11733307 — an unverified report by a vehicle owner.
Bakersfield, CA
FUEL/PROPULSION SYSTEM
Listing as all 3. ICCU/fuse went out, car decelerated to 45 MPH max and flashed a warning to pull over. The bottom left battery indicator for the 12v battery also changed to red, indicating it was not regaining power from the main EV battery. Currently in shop hoping to get part in soon
NHTSA complaint #11733307 — an unverified report by a vehicle owner.
Chatham, NJ
POWER TRAIN
The vehicle’s ICCU unit stopped working out of the blue. This happened on a busy intersection and the car came to a sudden and violent halt. Luckily we were not involved in an accident. It’s a very well known issue with these vehicles and it’s really criminal that Kia has done nothing to fix it. They just change the ICCU unit and then it happens again.
NHTSA complaint #11732893 — an unverified report by a vehicle owner.
Chatham, NJ
ELECTRICAL SYSTEM
The vehicle’s ICCU unit stopped working out of the blue. This happened on a busy intersection and the car came to a sudden and violent halt. Luckily we were not involved in an accident. It’s a very well known issue with these vehicles and it’s really criminal that Kia has done nothing to fix it. They just change the ICCU unit and then it happens again.
NHTSA complaint #11732893 — an unverified report by a vehicle owner.
Chatham, NJ
ENGINE
The vehicle’s ICCU unit stopped working out of the blue. This happened on a busy intersection and the car came to a sudden and violent halt. Luckily we were not involved in an accident. It’s a very well known issue with these vehicles and it’s really criminal that Kia has done nothing to fix it. They just change the ICCU unit and then it happens again.
NHTSA complaint #11732893 — an unverified report by a vehicle owner.
I was backing out of my driveway and backed into a vehicle parked directly behind me. The collision avoidance and emergency braking system should have stopped my car before impact but it did not. No sounds other than the normal backing up beeping. Proximity alert did not ping. The vehicle is available for inspection upon request. The safety feature of collision avoidance and emergency breaking did not work. No, the problem has not been reproduced or confirmed by a dealer or independent service center. No, the vehicle component has not been inspected by the manufacturer, police, insurance representative or other. The police were called to the scene, they just looked at the damage on both vehicles. No warning lamps, messages or other symptoms of the problem prior to the failure. They only appeared once on the day of the accident. I can confirm the backup collision avoidance worked after the incident since the emergency breaking stopped my car in a parking lot after the incident of the failure.
NHTSA complaint #11732922 — an unverified report by a vehicle owner.
Went to charge my vehicle in my garage on 4/15/26. When it was fully charged, I reached to disconnect the charger from the vehicle and the connector was hot to the touch; the charging hub on the vehicle was also hot, the charger had a slight plastic burning smell. I immediately tried to contact the company and learned that they had unbeknownst to me, ceased conducting operations in the US. So I ordered a new charger. I also tried it again on 4/17/26; and the heat was higher faster than it was on 4/15/26; so I hav disconnected the device and installed a new one. The electrician noted that the breaker was damaged and had to be replaced. I also recall, that a few months after the initial install of the charger, there was an incident where my wife saw sparks in the garage from the breaker and we heard a large pop; and then the charger went out. The company sent us a new one then that worked fine for a few years.
NHTSA complaint #11732119 — an unverified report by a vehicle owner.
Wheaton, IL
ELECTRICAL SYSTEM
Issue was diagnosed as ICCU failure.
NHTSA complaint #11731325 — an unverified report by a vehicle owner.
Whittier, AR
ELECTRICAL SYSTEM
Known ICCU issue by manufacturer. While driving get alert on screen the check electrical system. Had to pull over and call tow truck for safety reasons. Charging system is not working properly and 12v battery can die at anytime.
NHTSA complaint #11729356 — an unverified report by a vehicle owner.
Boise, ID
UNKNOWN OR OTHER
I had just finished charging the vehicle overnight on a Level 2 charger at a family members home. After leaving the driveway and driving a few hundred feet, an error message showed on the vehicle screen saying "Check Electric Vehicle" system, and then later a second message that said to stop the vehicle. I immediately turned the car around parked it in the driveway again and called roadside assistance to have it towed to the Kia service center. The Kia service center confirmed that it was an ICCU (integrated charging control unit) failure, which they replaced 4-5 days later after ordering the part. These error messages were the first and only indicator of the problem, there were no smaller issues leading up to the issue. Because the failure happened within a block of a family member's home, I was able to get to safety. But it could have been a completely different situation had the failure occurred even a few minutes later when I was on the freeway.
NHTSA complaint #11728963 — an unverified report by a vehicle owner.
Boise, ID
ELECTRICAL SYSTEM
I had just finished charging the vehicle overnight on a Level 2 charger at a family members home. After leaving the driveway and driving a few hundred feet, an error message showed on the vehicle screen saying "Check Electric Vehicle" system, and then later a second message that said to stop the vehicle. I immediately turned the car around parked it in the driveway again and called roadside assistance to have it towed to the Kia service center. The Kia service center confirmed that it was an ICCU (integrated charging control unit) failure, which they replaced 4-5 days later after ordering the part. These error messages were the first and only indicator of the problem, there were no smaller issues leading up to the issue. Because the failure happened within a block of a family member's home, I was able to get to safety. But it could have been a completely different situation had the failure occurred even a few minutes later when I was on the freeway.
NHTSA complaint #11728963 — an unverified report by a vehicle owner.
Monument, CO
FUEL/PROPULSION SYSTEM
Was backing out of a parking lot space when a loud popping sound was heard from the right rear portion of the car. Shortly after a check electrical system message was displayed and to pull over. Then eventually had a power limited message pop up after 12V battery charging status/condition was checked by roadside service. Would turn out to be the ICCU (Integrated Charging Control Unit) after dealership nearby (Peak Kia) was able to diagnose the problem. Unknown if the failed part is available for inspection. I wouldn't say my safety or others safety was put at immediate risk, but could have been since the car did eventually completely shut down right as I was able to get home only about 1-2 miles away. Vehicle was seen by dealership a few days later and as far as I'm aware are the only entity to do an inspection on the vehicle. No prior warning of any kind before the ICCU failed, and car had complied with all recalls that were supposed to prevent or at least reduce chances of ICCU issues.
NHTSA complaint #11726159 — an unverified report by a vehicle owner.