The contact owns a 2024 Lincoln Aviator. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed, and there was an abnormal sound coming from the vehicle. No warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a detached adaptive valve. The contact was informed that the adaptive valve needed to be replaced. The vehicle was not repaired. The contact was advised to contact the dealer for assistance. The vehicle was taken to the dealer, where it was confirmed that the adaptive valve had detached. The contact was informed that the exhaust system needed to be replaced. The contact was informed that the adaptive valve was not replaceable as a separate part. The vehicle was not repaired. The contact stated that the failure was a known failure with similar vehicles. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 62,000.
NHTSA complaint #11755880 — an unverified report by a vehicle owner.
My wife went to a friends house to drop something off, pulled in the driveway, pushed the Park button, got out of the vehicle, as she was walking away the car drove through their garage door. We paid about $3300 to have their door replaced. We just recently received a recall 26V402 that talks about this issue and it currently says there is not a remedy for it at this point.
NHTSA complaint #11752488 — an unverified report by a vehicle owner.
The contact owns a 2021 Lincoln Aviator. The contact stated that the vehicle did not start, the vehicle was , the hood was raised, the contact went back to the vehicle to try to start, the vehicle would not turn over with clicking in the engine. the vehicle began to smoke with very thick white smoke, the contact was unable to exit the vehicle of the drivers side front seat. The battery was disconnected and a manual latch was discovered on the drivers side door. The vehicle was towed to the dealer but had not been diagnosed or repaired. The manufacturer was not notified of the issue. The approximate failure mileage was 60,000.
NHTSA complaint #11741858 — an unverified report by a vehicle owner.
2023 Lincoln Aviator was accelerating out of Toll booth to 70mph. Upon acceleration the engine hiccupped but continued to operate. Approximately 2 miles later the low oil pressure indicator and low battery indicator popped up, no prior indications existed. Vehicle stalled within 0.5 miles as I was assessing what to do and to pull off to a safe place. I had the vehicle towed to the dealer at request of my insurance company to assess damage. Dealer found low oil and metal in engine and claimed owner failed to perform maintenance despite records of three oil changes over the last year. Dealer stopped investigation upon low oil finding and performed no other inspections. I am having the vehicle taken to another independent shop for investigation. The vehicle was involved in a low speed passenger side impact the month prior. Vehicle body was repaired but no inspection or work was completed on the engine.
NHTSA complaint #11741279 — an unverified report by a vehicle owner.
Suddenly car is excessively loud when first started for roughly 30 seconds and then quiets to normal. However when placed in Drive there is a loud "clunk" that takes place to allow the car to shift into gear. While driving the car shakes vigorously. These issues all point to the enigine mount recall that did not include my vehicle, but should have. NHTSA Recall Number 20V788000 should be expanded to include my vehicle.
NHTSA complaint #11722352 — an unverified report by a vehicle owner.
The contact owns a 2022 Lincoln Aviator. The contact stated that while driving at 35 MPH and entering the on-ramp, the vehicle stalled. The vehicle was restarted. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). The vehicle was towed to the local dealer, but the vehicle had not been diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 47,000.
NHTSA complaint #11712909 — an unverified report by a vehicle owner.
I have taken my car more times than I can count for recalls in the little time that I have owned my can bought new. My work requires me to drive a lot covering 6 states. Scheduling recall repairs has become a serious issue for me in a two year old car. As it seems that most of the recalls have been fixed except one small one where it sounds like wind is blowing in and the rear view camera and display work whenever it wants. A lot of time the screen just goes dark when it’s needed the most. I just recently took my car to the dealership bec the engine light came on and my car started sputtering g while driving. Ford serviced it and within a week it did the same thing and light was back on. This time it started not cranking easy time I had to get gas. As I was driving on hwy after fuel up my car started jerking and just shut down engine. I rolled over to shoulder and it took a hand full of tries to start and I got it home asap. I took back to ford and they said it was due to a fuel pump and needed to go to Lincoln. It’s been weeks now and my car is getting worse. I dont trust it to drive as I have had now two stalls and multiple hard starts where engine won’t turn over. With me on highway a lot and no recall repairs i. Sore as Lincoln said I’m not sure what to do. This is very dangerous. I was lucky I wasn’t in Heavy traffic or crossing over lanes.
NHTSA complaint #11707659 — an unverified report by a vehicle owner.
On July 25, 2025 my 2022 Lincoln Aviator Hybrid Grand Touring Edition stalled while driving on Interstate 25 in Colorado Springs. I lost partial control of the vehicle but was able to guide it onto the shoulder and allow it to coast to a stop. I had this vehicle towed to the dealership (where it was purchased new): Phil Long Lincoln, Motor City in Colorado Springs, Colorado. It has been there ever since (almost 5 months) and has not been repaired. The service department suspects that the current safety recall issued July 8, 2025 (NHTSA Recall number: 25V455) was the root cause. They claim they could find nothing in the logs but they cannot rule out this as a problem. This is a life threatening issue with this vehicle and I have also been without my car for almost 5 months with repair available or capable by the dealer or Lincoln. This a very unreasonable amount of time and has been an undue burden upon me. I have sought to get a vehicle buy back under both the Lemon Law and the duration of this safety recall and they have refused (Lincoln corporate and the dealership). Please help.
NHTSA complaint #11706296 — an unverified report by a vehicle owner.
1.) Exhaust System Failure (Flex Pipe / Catalytic Converter) The vehicle’s exhaust system—specifically the flex pipe connected to the catalytic converter—cracked and malfunctioned. This component is available for inspection upon request. As a result of the failure, exhaust fumes entered the cabin, creating a significant safety risk due to potential exposure to carbon monoxide. Prior to the failure, I noticed a persistent rattling noise at low speeds and while the vehicle was idling. The issue was inspected and confirmed by the dealership; however, I was informed that the repair falls outside of warranty coverage. I would like to know if this falls under safety hazard for emissions. 2.) Sunroof Glass Shattering Incident While driving, the sunroof glass suddenly shattered and appeared to implode outward. According to the dealership technicians, this may have been caused by thermal stress or frame-related tension. The glass is no longer intact but the remaining components and frame can be inspected upon request. The incident posed an immediate safety hazard to both myself and other road users due to the sudden loss of glass and the potential for debris. I did not observe any warning lamps, messages, or symptoms prior to the failure. After researching the issue, I found that similar sunroof glass failures have been reported across various Ford/Lincoln models, suggesting this may be a known manufacturer defect. The dealership has confirmed the damage but no inspection by the manufacturer, police, or insurance representatives has been conducted at this time.
NHTSA complaint #11702357 — an unverified report by a vehicle owner.
high voltage alert and vehicle shuts down and unable to drive and car locks up Should be recall# 23s53 and NHTSA campaign # 23v-626 It has not been repaired yet and this is very frustrating has happened 4-5 times Last incident happened on 11/7/2025 inside of a car wash & had to get towed
NHTSA complaint #11698286 — an unverified report by a vehicle owner.
This vehicle continues to randomly stall upon acceleration from a dead stop. There have been numerous times this has created a near- miss accident. It has been in for service on several occasions since owning it with no resolve. This issue has been ongoing since owning it and only getting worse. Current mileage is approx 23,000 miles.
NHTSA complaint #11696698 — an unverified report by a vehicle owner.
The contact owns a 2023 Lincoln Aviator. The contact stated that after parking the vehicle in the garage, the garage became extremely hot, and the fans underneath the vehicle activated. The contact opened the garage. The vehicle was towed to the local dealer, who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. While driving at an undisclosed speed, the “Service Engine Now” message was displayed. The powertrain control module had detected a fault with the high-voltage system, and a message was displayed. After researching, the contact linked the failure to NHTSA Campaign Number: 23V626000 (Electrical System); however, the VIN was not included. The manufacturer was not contacted. The failure mileage was approximately 20,990.
NHTSA complaint #11688868 — an unverified report by a vehicle owner.
I did an inspection of my exhaust system and saw numerous carbon deposits along both pipes at different joints. I brought this to the attention of the dealer and they repaired only one (1) leaking joint at the tailpipe. They told me the other leaking joints are normal and are of no concern. I have a video, pictures and the dealer inspection/repair forms from two (2) different service dates.
NHTSA complaint #11679615 — an unverified report by a vehicle owner.
I came to a stop a light in a busy intersection. The auto start/stop feature turned off the engine. When the light turned green, the car would not start and put us in danger from traffic approaching from the rear. When trying to start the car with the push button, it made one click and nothing more. The lights and other electrical systems seemed to behave and appear as normal. No warning lights or messages about errors or failures. I turned the car completely off, opened and closed the door to "reset" the car and still would not start. I tried this four times. I then opened the hood, got out of the car (all while at this busy intersection of multiple lanes of traffic, now working their way around me) and checked the battery connection just to be sure. Both positive and negative leads checked solidly connected. I then got back in the car and was able to start the car and move out of the way of traffic. I have not yet had it repeat and have not taken it to a service center yet. Very concerning to be stuck at that busy light with what appears to be a fully functioning car that would not restart after the auto start/stop feature activated.
NHTSA complaint #11653006 — an unverified report by a vehicle owner.
We have been experiencing multiple electrical and mechanical issues with our brand new 2025 Lincoln Aviator since we bought it approximately 4 months ago. The car frequently fails to start, with at least ten or more instances of this problem. We have taken it to the dealership two or three times, but despite their claims that the issue has been fixed, the problem recurs within a week or two from picking the car up from the dealer. There was a time when the car has shut off while stopped at a traffic light, and when the light turns green, it won’t restart. In some cases, it has taken anywhere from 30 minutes to two hours before the car would finally start again. Additionally, various warning signals appear on the dash cluster, including alerts about the emergency brakes and collision warning system not functioning properly. Additionally, we experienced issues where the car doors won't open right away due to this mechanical issue. This is a serious safety hazard, as the car shutting off unexpectedly in traffic puts us at significant risk. It is especially concerning because this is our family vehicle, and we frequently travel with two infants in car seats and our elderly parents. Despite multiple visits to the dealership, the issue persists. We even reached out to the parent company, Lincoln/Ford, and they essentially told us that there is nothing they can do, this is a "known issue with the 2025 Lincoln Aviator". After researching online, we found that other 2025 Lincoln Aviator owners have reported similar electrical and mechanical problems. We are extremely concerned for our safety and fear that this issue could lead to a serious accident. However, this is our only vehicle, leaving us with no alternative but to continue driving it despite the risks. Please note, as I type this message, we have an appointment this week to drop the car off again for service.
NHTSA complaint #11644862 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
The contact owns a 2020 Lincoln Aviator. The contact stated that while reversing, the vehicle independently engaged the automatic braking feature and the vehicle stopped. The contact stated that there were no objects behind the vehicle. The contact stated that the failure was intermittent and there was no warning light illuminated. Additionally, the contact stated that the vehicle was locking all the doors independently with the key fob still inside the vehicle. The contact stated that the failure was intermittent. The contact stated that during one of the failures, her infant child was locked inside the vehicle and she and her other children were forcibly pulling on the door handles on all four doors. The contact stated that the vehicle side view mirrors at one point folded inward and the passenger front door unlocked, the other doors remained locked. The contact also stated that while cold starting the vehicle, the vehicle was making an abnormal rattling sound coming from the engine compartment. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the rear-view camera needed to be replaced, that the rattling sound was due to a failure of the catalytic converter and that exhaust fumes were entering the cabin of the vehicle. The contact had not noticed the odor, but her children had complained of a gasoline odor in the rear of the vehicle. The vehicle was repaired; however, the contact stated that the vehicle had another electrical and mechanical failure. The manufacturer was informed of the failure. The failure mileage was approximately 79,000.
NHTSA complaint #11639614 — an unverified report by a vehicle owner.
FIRST THE ENGINE BROKE (CRITICAL DAMAGE) WAS REPLACED SECOND THE TURBOS WERE JAMMED, WEREREPLACED THIRD THE THROTTLE WAS INOPERATIVE STIL UNATTENDED FOURTH THE TRANSMISSION AILED STIL UNATTENDED
NHTSA complaint #11632947 — an unverified report by a vehicle owner.
While turning a corner or going up a slight incline I lose power and the pedal becomes unresponsive for a few seconds. Then the car jutts forward and clunks.
NHTSA complaint #11612474 — an unverified report by a vehicle owner.