2023 Lincoln Aviator problems

EXTERIOR LIGHTING

When driving at night the driver side map light will turn on randomly momentarily blinding the driver only way to turn off is to turn on interior lights and turn off may happen again with in seconds or can be minutes but does it 8-10 times in a 30 minute driving time dealership says it’s not covered under warranty because it’s a light issue however acknowledges it’s a common problem and wants $1,727.07 dollars to fix it and seemed to know exactly what the problem is. But is very dangerous to point where my wife refuses to drive the vehicle at night because its bad enough that it blinds you but then you have to take eyes off road to find the button in the dark to turn it off

NHTSA complaint #11758725 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Subject: Request for Investigation / Status Update: Unresolved Safety Recall for 2023, Lincoln Aviator ​To Whom It May Concern, ​I am writing to formally request an update and urge an investigation into the lack of a remedy for an active safety recall on my vehicle. It has now been 10 months since the recall was officially issued, and the manufacturer has still not provided a resolution or made parts available. ​Here are the details of my vehicle and the recall: ​Vehicle: 2023 Lincoln Aviator ​VIN: [XXX] ​NHTSA Recall Campaign Number: 25S75/25V455 ​ ​Date Recall Issued: July 2025, 10 months ago ​Federal law requires manufacturers to remedy safety defects within a reasonable timeframe. Waiting nearly a year for a safety-critical fix leaves me driving a vehicle with a known hazard, which is an unacceptable risk to my safety and the safety of others on the road. ​When I contact the manufacturer or my local dealership, I am repeatedly told that "parts are not available" or that "the remedy is still under development." ​Could you please provide an update on the status of this campaign? Furthermore, I ask that NHTSA review this delay to determine if Lincoln is failing to meet its legal obligation to remedy this defect in a timely manner. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11742296 — an unverified report by a vehicle owner.

ENGINE

2023 Lincoln Aviator was accelerating out of Toll booth to 70mph. Upon acceleration the engine hiccupped but continued to operate. Approximately 2 miles later the low oil pressure indicator and low battery indicator popped up, no prior indications existed. Vehicle stalled within 0.5 miles as I was assessing what to do and to pull off to a safe place. I had the vehicle towed to the dealer at request of my insurance company to assess damage. Dealer found low oil and metal in engine and claimed owner failed to perform maintenance despite records of three oil changes over the last year. Dealer stopped investigation upon low oil finding and performed no other inspections. I am having the vehicle taken to another independent shop for investigation. The vehicle was involved in a low speed passenger side impact the month prior. Vehicle body was repaired but no inspection or work was completed on the engine.

NHTSA complaint #11741279 — an unverified report by a vehicle owner.

POWER TRAIN

My 2023 Lincoln Aviator has a grinding noise when I back up. Also a rattle has begun at all speeds. I had vehicled check and the axles were found to be totally rusted. Prior to having it towed to the detail i did some research and found the following -- A 2023 Lincoln Aviator recall regarding a "rusted" or breaking axle generally refers to a serious issue where the rear axle bolt can fracture, causing the rear subframe to disconnect, potentially leading to a loss of control or rollaway . This issue often stems from stress corrosion, prompting recalls for subframe inspections and repairs. [XXX] +4 Key Information regarding 2023 Lincoln Aviator Recalls: Safety Risk: A fractured rear axle bolt can cause the axle to disconnect, causing sudden power loss, severe vibration, and increased crash risk. Scope: While often associated with the 2020-2022 Ford Explorer/Aviator, owners should check for 2023 model year issues relating to rear axle subframe integrity. What to Do: Visit the official Lincoln Recall Page and enter your 17-digit Vehicle Identification Number (VIN) to check for this or other active recalls. Repair: Authorized Lincoln Dealerships will inspect the axle bolt and rear subframe, performing necessary repairs at no cost to the owner. I had vehicle towed to dealer and was told that there is no recall for this issue. see video link of axles. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11728513 — an unverified report by a vehicle owner.

SUSPENSION

My 2023 Lincoln Aviator has a grinding noise when I back up. Also a rattle has begun at all speeds. I had vehicled check and the axles were found to be totally rusted. Prior to having it towed to the detail i did some research and found the following -- A 2023 Lincoln Aviator recall regarding a "rusted" or breaking axle generally refers to a serious issue where the rear axle bolt can fracture, causing the rear subframe to disconnect, potentially leading to a loss of control or rollaway . This issue often stems from stress corrosion, prompting recalls for subframe inspections and repairs. [XXX] +4 Key Information regarding 2023 Lincoln Aviator Recalls: Safety Risk: A fractured rear axle bolt can cause the axle to disconnect, causing sudden power loss, severe vibration, and increased crash risk. Scope: While often associated with the 2020-2022 Ford Explorer/Aviator, owners should check for 2023 model year issues relating to rear axle subframe integrity. What to Do: Visit the official Lincoln Recall Page and enter your 17-digit Vehicle Identification Number (VIN) to check for this or other active recalls. Repair: Authorized Lincoln Dealerships will inspect the axle bolt and rear subframe, performing necessary repairs at no cost to the owner. I had vehicle towed to dealer and was told that there is no recall for this issue. see video link of axles. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11728513 — an unverified report by a vehicle owner.

SERVICE BRAKES

My 2023 Lincoln Aviator has a grinding noise when I back up. Also a rattle has begun at all speeds. I had vehicled check and the axles were found to be totally rusted. Prior to having it towed to the detail i did some research and found the following -- A 2023 Lincoln Aviator recall regarding a "rusted" or breaking axle generally refers to a serious issue where the rear axle bolt can fracture, causing the rear subframe to disconnect, potentially leading to a loss of control or rollaway . This issue often stems from stress corrosion, prompting recalls for subframe inspections and repairs. [XXX] +4 Key Information regarding 2023 Lincoln Aviator Recalls: Safety Risk: A fractured rear axle bolt can cause the axle to disconnect, causing sudden power loss, severe vibration, and increased crash risk. Scope: While often associated with the 2020-2022 Ford Explorer/Aviator, owners should check for 2023 model year issues relating to rear axle subframe integrity. What to Do: Visit the official Lincoln Recall Page and enter your 17-digit Vehicle Identification Number (VIN) to check for this or other active recalls. Repair: Authorized Lincoln Dealerships will inspect the axle bolt and rear subframe, performing necessary repairs at no cost to the owner. I had vehicle towed to dealer and was told that there is no recall for this issue. see video link of axles. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11728513 — an unverified report by a vehicle owner.

BACK OVER PREVENTION

The contact owns a 2023 Lincoln Aviator. The contact stated that while attempting to reverse, the rear-view camera displayed a glitching screen. The vehicle was serviced under the NHTSA Campaign Number: 23V022000 (BACK OVER PREVENTION) by the previous owner; however, the repair failed to fix the vehicle. The contact stated that failure had occurred after the recall repair the first time, and the failure had occurred on several occasions. The manufacturer was not notified of the failure. The failure mileage was 43,300.

NHTSA complaint #11709130 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I have taken my car more times than I can count for recalls in the little time that I have owned my can bought new. My work requires me to drive a lot covering 6 states. Scheduling recall repairs has become a serious issue for me in a two year old car. As it seems that most of the recalls have been fixed except one small one where it sounds like wind is blowing in and the rear view camera and display work whenever it wants. A lot of time the screen just goes dark when it’s needed the most. I just recently took my car to the dealership bec the engine light came on and my car started sputtering g while driving. Ford serviced it and within a week it did the same thing and light was back on. This time it started not cranking easy time I had to get gas. As I was driving on hwy after fuel up my car started jerking and just shut down engine. I rolled over to shoulder and it took a hand full of tries to start and I got it home asap. I took back to ford and they said it was due to a fuel pump and needed to go to Lincoln. It’s been weeks now and my car is getting worse. I dont trust it to drive as I have had now two stalls and multiple hard starts where engine won’t turn over. With me on highway a lot and no recall repairs i. Sore as Lincoln said I’m not sure what to do. This is very dangerous. I was lucky I wasn’t in Heavy traffic or crossing over lanes.

NHTSA complaint #11707659 — an unverified report by a vehicle owner.

ENGINE

I have taken my car more times than I can count for recalls in the little time that I have owned my can bought new. My work requires me to drive a lot covering 6 states. Scheduling recall repairs has become a serious issue for me in a two year old car. As it seems that most of the recalls have been fixed except one small one where it sounds like wind is blowing in and the rear view camera and display work whenever it wants. A lot of time the screen just goes dark when it’s needed the most. I just recently took my car to the dealership bec the engine light came on and my car started sputtering g while driving. Ford serviced it and within a week it did the same thing and light was back on. This time it started not cranking easy time I had to get gas. As I was driving on hwy after fuel up my car started jerking and just shut down engine. I rolled over to shoulder and it took a hand full of tries to start and I got it home asap. I took back to ford and they said it was due to a fuel pump and needed to go to Lincoln. It’s been weeks now and my car is getting worse. I dont trust it to drive as I have had now two stalls and multiple hard starts where engine won’t turn over. With me on highway a lot and no recall repairs i. Sore as Lincoln said I’m not sure what to do. This is very dangerous. I was lucky I wasn’t in Heavy traffic or crossing over lanes.

NHTSA complaint #11707659 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I have taken my car more times than I can count for recalls in the little time that I have owned my can bought new. My work requires me to drive a lot covering 6 states. Scheduling recall repairs has become a serious issue for me in a two year old car. As it seems that most of the recalls have been fixed except one small one where it sounds like wind is blowing in and the rear view camera and display work whenever it wants. A lot of time the screen just goes dark when it’s needed the most. I just recently took my car to the dealership bec the engine light came on and my car started sputtering g while driving. Ford serviced it and within a week it did the same thing and light was back on. This time it started not cranking easy time I had to get gas. As I was driving on hwy after fuel up my car started jerking and just shut down engine. I rolled over to shoulder and it took a hand full of tries to start and I got it home asap. I took back to ford and they said it was due to a fuel pump and needed to go to Lincoln. It’s been weeks now and my car is getting worse. I dont trust it to drive as I have had now two stalls and multiple hard starts where engine won’t turn over. With me on highway a lot and no recall repairs i. Sore as Lincoln said I’m not sure what to do. This is very dangerous. I was lucky I wasn’t in Heavy traffic or crossing over lanes.

NHTSA complaint #11707659 — an unverified report by a vehicle owner.

ENGINE

This vehicle continues to randomly stall upon acceleration from a dead stop. There have been numerous times this has created a near- miss accident. It has been in for service on several occasions since owning it with no resolve. This issue has been ongoing since owning it and only getting worse. Current mileage is approx 23,000 miles.

NHTSA complaint #11696698 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

This vehicle continues to randomly stall upon acceleration from a dead stop. There have been numerous times this has created a near- miss accident. It has been in for service on several occasions since owning it with no resolve. This issue has been ongoing since owning it and only getting worse. Current mileage is approx 23,000 miles.

NHTSA complaint #11696698 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2023 Lincoln Aviator. The contact stated that after parking the vehicle in the garage, the garage became extremely hot, and the fans underneath the vehicle activated. The contact opened the garage. The vehicle was towed to the local dealer, who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. While driving at an undisclosed speed, the “Service Engine Now” message was displayed. The powertrain control module had detected a fault with the high-voltage system, and a message was displayed. After researching, the contact linked the failure to NHTSA Campaign Number: 23V626000 (Electrical System); however, the VIN was not included. The manufacturer was not contacted. The failure mileage was approximately 20,990.

NHTSA complaint #11688868 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

The contact owns a 2023 Lincoln Aviator. The contact stated that after parking the vehicle in the garage, the garage became extremely hot, and the fans underneath the vehicle activated. The contact opened the garage. The vehicle was towed to the local dealer, who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. While driving at an undisclosed speed, the “Service Engine Now” message was displayed. The powertrain control module had detected a fault with the high-voltage system, and a message was displayed. After researching, the contact linked the failure to NHTSA Campaign Number: 23V626000 (Electrical System); however, the VIN was not included. The manufacturer was not contacted. The failure mileage was approximately 20,990.

NHTSA complaint #11688868 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2023 Lincoln Aviator. The contact stated that after parking the vehicle in the garage, the garage became extremely hot, and the fans underneath the vehicle activated. The contact opened the garage. The vehicle was towed to the local dealer, who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. While driving at an undisclosed speed, the “Service Engine Now” message was displayed. The powertrain control module had detected a fault with the high-voltage system, and a message was displayed. After researching, the contact linked the failure to NHTSA Campaign Number: 23V626000 (Electrical System); however, the VIN was not included. The manufacturer was not contacted. The failure mileage was approximately 20,990.

NHTSA complaint #11688868 — an unverified report by a vehicle owner.

ENGINE

I did an inspection of my exhaust system and saw numerous carbon deposits along both pipes at different joints. I brought this to the attention of the dealer and they repaired only one (1) leaking joint at the tailpipe. They told me the other leaking joints are normal and are of no concern. I have a video, pictures and the dealer inspection/repair forms from two (2) different service dates.

NHTSA complaint #11679615 — an unverified report by a vehicle owner.

SEATS

The contact owns a 2023 Lincoln Aviator. The contact received notifications of NHTSA Campaign Numbers: 25V407000 (Structure), 25V393000 (Seats), 25V455000 (Fuel System, Gasoline); however, the parts to do the recall repairs were not yet available. The dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The VIN was not available.

NHTSA complaint #11679071 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2023 Lincoln Aviator. The contact received notifications of NHTSA Campaign Numbers: 25V407000 (Structure), 25V393000 (Seats), 25V455000 (Fuel System, Gasoline); however, the parts to do the recall repairs were not yet available. The dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The VIN was not available.

NHTSA complaint #11679071 — an unverified report by a vehicle owner.

STRUCTURE

The contact owns a 2023 Lincoln Aviator. The contact received notifications of NHTSA Campaign Numbers: 25V407000 (Structure), 25V393000 (Seats), 25V455000 (Fuel System, Gasoline); however, the parts to do the recall repairs were not yet available. The dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The VIN was not available.

NHTSA complaint #11679071 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I had all recalls taken care of for my new vehicle I purchased yet I am still having issues with the screen going all black and not working when having my cellphone plugged in. Usually it will come back on once I unplug it but not always.

NHTSA complaint #11627814 — an unverified report by a vehicle owner.

SEATS

The contact owns a 2023 Lincoln Aviator. The contact stated that while the vehicle was parked and attempting to press the button to raise the level of the third-row seats, the contact and her daughter were ejected from the seats. The contact stated that there were no injuries sustained. There was no warning light illuminated. The contact stated that there resistance while attempting to raise the seats. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 18,000.

NHTSA complaint #11599285 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The backup camera glitches while backing up and turning the steering wheel causing issues with visibility. This is a safety issue because it affects your ability to see where you are going while in reverse. This is a brand new car and this issue should not be occurring.

NHTSA complaint #11593202 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

360 degree camera glitch is not resolved despite replacement of cameras & image processing module based on recent recall. This continues to be a safety issues & Lincoln needs to find a permanent fix.

NHTSA complaint #11589800 — an unverified report by a vehicle owner.

BACK OVER PREVENTION

The contact owns a 2023 Lincoln Aviator. The contact received notification of NHTSA Campaign Number: 23V598000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The contact stated that the back over prevention system remained activated showing the rearview of the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was not made aware of the issue. The failure mileage was 8,000. Parts distribution disconnect.

NHTSA complaint #11577938 — an unverified report by a vehicle owner.