101 of the
883 complaints filed about the Mercedes Benz C230
are about the fuel system —
11% of everything owners reported.
The worst model year for it is 2007.
The contact owns a 1997 Mercedes-Benz C230. The contact stated that on several occasions while driving at various speeds, the contact heard fluttering sounds coming from the engine compartment. The contact stated that on two occasions, the vehicle stalled. The contact was able to restart the vehicle each time. The vehicle was towed to an independent mechanic, where it was diagnosed and determined that the fuel pump needed to be replaced. The vehicle was repaired; however, the failure reoccurred approximately two months later. The manufacturer was not notified of the failure. The failure mileage was approximately 300,000.
NHTSA complaint #11604264 — an unverified report by a vehicle owner.
My car went into limp mode. Well after I spend 2000. And 2 years trying to figure out what was going on with my car. Come to find out. Water was getting in and it messed up my whole system. I just put every part on this car is brand new. Trying to figure this out. Now for nothing. I read somewhere. That I'm not the only one with this issue. That mercedes. Needs to make it right. What do u think
NHTSA complaint #11587082 — an unverified report by a vehicle owner.
My 2007 c230 has a problem with the smell of gasoline when you fill up. I have seen alot of complaints about the gas tank and its system on line. An when I talked to medcedes I was told they have had alot of issues with the mercedes in the past and that issue. They replaced alot of them at one time I dont know which model. I have seen alot of people with my style of mercedes with similiar issues. This type of thing should be taken care of by the dealer.
NHTSA complaint #11526629 — an unverified report by a vehicle owner.
After filling the gas tank over the three quarters(3/4) mark, there is an extreme of gas. No leaks are seen and a garage found no leaks. The odor is so bad/strong that the car can not be placed in the garage. The odor remain until the fuel level is at or below the three quarters level.
NHTSA complaint #11501648 — an unverified report by a vehicle owner.
I have an issue that when you fill up the car you will smell a strong gas odor outside of the car. as soon as the fuel level drops down the odor gets less and less. looked under rear seat and no fuel leaks. also i see a lot of posts about this same issue with this same type of car. 2007 c230 sport. please look into this. i even changed out gaskets and fuel pumps. just in case.
NHTSA complaint #11473307 — an unverified report by a vehicle owner.
Have a code p0016 p0017 I replace the camshaft balance sensor but it’s not that. I found out it’s balance shaft and I found out a lot of the people have the same problem
NHTSA complaint #11432854 — an unverified report by a vehicle owner.
MY CAR HAS A COMPUTER SYSTEM PROBLEM. IT HAS TO BE RESET TO WHERE IT WONT ERASE WHAT IS ALREADY ON THE COMPUTER SYSTEM. I CAN'T DRIVE IT BECAUSE ITS STALLING OR IT SHAKES TO MUCH WHEN U ARE STOPED AT A RED LIGHT IT GIRKS ALOT AND I CAN'T DRIVE IT CUZ IT DOESN'T HAVE A LOT OF POWER TO GET SPEED WHEN USING IT ON THE HIGHWAY I HAVE HAD A SECOND OPINION ON WHAT IS WRONG WITH AND ITS THE COMPUTER SYSTEM SO PLEASE HELP I NEED ASSISTANCE MY HUSBAND AND I ARE DISABLED ALSO THE SPEEDOMETERS IS NOT WORKING.
NHTSA complaint #11396734 — an unverified report by a vehicle owner.
WHEN I FILL UP WITH GAS, THE CAR SALON FILLS UP WITH THE GAS SMELL. THE PROBLEM SHOULD BE IN THE FUEL PUMP OR SO. THE SMELL IS PERSISTENT IN THE GARAGE. WHILE DRIVING, I DID NOT NOTICE. WHEN THE AMOUNT OF GAS IN THE FUEL TANK DECREASES, THE SMELL GOES AWAY. I REMOVED THE BACK SEAT AND SO THE GAS RESIDUE OVER THE PUMP.
NHTSA complaint #11331122 — an unverified report by a vehicle owner.
NHTSA RECALL 08V303000. MY CAR FUEL GAUGE MISREADS WHAT IS NOT THERE. STALLS AND NOT RESTART WITHOUT TAPPING THE FUEL PUMP. FUEL LIGHT INDICATES FUEL SENSOR NEED TO BE REPLACED. AFTER PAYING $327.00 STILL CONTINUES TO MALFUNCTION. STOPPED SEVERAL TIMES ON STREET AND PARKING LOTS. TOWED SEVERAL TIMES. REFUSES TO START WITHOUT NOTICE. HARNESS FOR IT NOT FOUND. IMPACT OF ACCIDENT LOST FUEL. SINCE ACCIDENT TOWED THREE TIMES STALLED AND TOWED ONCE AND TWICE BY MERCEDES BENZ. REPLACEMENT COST $1051.00.
NHTSA complaint #11218767 — an unverified report by a vehicle owner.
FUEL SYSTEM IS LEAKING GETTING CHECK ENGINE LIGHTS CAN'T PASS SMOG AND EGR HOSES THAT RUN DOWN BY THE SUPER CHARGER ARE LEAKING CAUSE THE RUBBER THEY USED KNOWING THIS WOULD HAPPEN ALL HAVE TO DO WITH THE CHECK ENGINE LIGHT ON
NHTSA complaint #11180615 — an unverified report by a vehicle owner.
FOR LAST THREE PLUS YEARS, WHENEVER GAS TANK IS FILLED OVER THE 3/4 FULL MARK THERE IS A HEAVY GAS ODOR BUT I HAVE NOT SEEN LEAKING GAS. I ONLY PUT IN LESS THAN 9 GALLONS OF GAS AT A TIME FEARING AN EXPLOSION IN MY GARAGE WHERE WATER HEATER IS LOCATED.
NHTSA complaint #11083248 — an unverified report by a vehicle owner.
ONE WEEKEND WE WOKE UP IN THE MORNING TO GO WASH, AND AS SOON AS WE OPENED OUR DOORS TO THE VEHICLE A STRONG ODOR OF GASOLINE CAME OUT OF THE VEHICLE. INSIDE OF THE VEHICLE AND IN THE TRUNK IT SMELLED A LOT LIKE GASOLINE, IT'S BEEN LIKE THIS NOW FOR ABOUT 4 DAYS AND THE ODOR IS STILL STRONG. IT WORRIES ME BECAUSE I HAVE KIDS. WE'VE BEEN DRIVING AROUND WITH OUR WINDOWS SLIGHTLY DOWN, EVEN AFRAID TO TURN ON THE HEATER OR AC
NHTSA complaint #11064299 — an unverified report by a vehicle owner.
I HAVE MY CAR IN THE AUTO REPAIR SHOP AND THE MECHANIC TELLS ME I NEED A PVC HOSE AND A OXYGEN SENSOR AND BOTH THOSE ITEMS ARE ON A RECALL LIST. HE ASKED ME TO CALL THE DEALER I WAS TOLD BY THE DEALER THAT THOSE ARE RECALL ITEMS BUT NOT FOR MY CAR. MY COMPLAINT IS WHY IF THIS IS A RECALL ITEM IT SHOULD BE FOR ALL CARS. THOSE ARE THE ONLY 2 THINGS WRONG WITH MY CAR. I NEED HELP.
NHTSA complaint #10981056 — an unverified report by a vehicle owner.
MY 2007 MERCEDES BENZ C230 SPORT CONTINUALLY RELEASES STRONG GASOLINE SMELL AFTER EACH GAS TANK FILL-UP. THIS OCCURRED CONSISTENTLY FOR THE LAST FOUR MONTHS. I'VE TAKEN MY CAR TO THE MERCEDES BENZ DEALERSHIP LOCAL IN MY AREA ONLY FOR THEM TO SAY THERE IS NO REPORTED RECALL OR THE COST TO FIX THIS MATTER IS SIGNIFICANTLY COSTLY. AFTER RESEARCHING THIS MATTER, I DISCOVERED THERE IS A REASONABLE NUMBER OF OWNERS WITH A SIMILAR MODEL AND YEAR THAT HAVE REPORTED THE SAME SERIOUS RISK OF GASOLINE SMELL. EMBEDDED IS A LINK TO THE ONLINE SITE WHERE THESE REPORTINGS ARE CAPTURED. HTTP://M.CARCOMPLAINTS.COM/MERCEDES-BENZ/C230/2007/FUEL_SYSTEM/FUEL_PROPULSION_SYSTEM.SHTML DUE TO THE NATURE AND PROBABLE SERIOUS HAZARD OF FUMES EXPOSURE WITHIN THE FAMILY HOUSEHOLD LET ALONE OTHER SIGNIFICANT HEALTH RISK, I'M REQUESTING IMMEDIATE ASSISTANCE FROM THE NHTSA TO BRING THIS MATTER TO A RESOLVE. ACCORDING TO PUBLIC DATA, MERCEDES BENZ HAS RECALL NUMEROUS OTHER VEHICLE MODELS FOR THE SAME DEFECT WHICH UNFORTUNATELY DID NOT INCLUDE THE 2007 C230 SPORT MODEL. PLEASE ADVISE.
NHTSA complaint #10969979 — an unverified report by a vehicle owner.
FUEL TANK LEAKS GASOLINE INTO THE BACK SEAT AREA FROM THE FUEL TANK MODULE IF FILLED MORE THAN ABOUT 3/4 FULL. FUEL TANK LEAK ALSO CAUSES P0442 CODE FOR LEAK IN EVAP EMISSIONS CONTROL SYSTEM. THIS IS THE SAME PROBLEM THAT RESULTED IN THE RECALL/WARRANTY EXTENSION ON 2003-09 E CLASS AND CLS CLASS MERCEDES BENZ, BUT MB REFUSES TO ACCEPT RESPONSIBILITY FOR C CLASS VEHICLES
NHTSA complaint #10928781 — an unverified report by a vehicle owner.