1996 Plymouth Voyager suspension problems

SUSPENSION

TL*THE CONTACT OWNS A 1996 PLYMOUTH VOYAGER. SINCE NOVEMBER OF 2003, THE TRANSMISSION HAS BEEN REPLACED THREE DIFFERENT TIMES. AFTER PURCHASING A BRAND NEW TRANSMISSION, IT FAILED AGAIN THE VERY SAME DAY AND NEEDED TO BE REPLACED AGAIN. THE CONTACT HAS HAD THE TOP HALF OF THE ENGINE REBUILT. THE VEHICLE IS STUCK IN DRIVE AND WILL NOT HOLD FLUID. THE FRONT WINDSHIELD WIPERS ACTIVATE WITHOUT A POWER SURGE IN THE VEHICLE. IN ADDITION, THE REAR BOLTS KEEP COMING OUT OF THE SHOCKS. THE CONTACT HAS TAKEN THE VEHICLE TO HAVE THE BOLTS TIGHTENED THREE OR FOUR TIMES. THE ENGINE IS TICKING AND SMOKING. THE SERPENTINE BELT SLIPS OFF IF IT GETS EVEN SLIGHTLY WET FROM SNOW OR RAIN. THE CHECK ENGINE LIGHT SPORADICALLY FLASHES ON AND OFF OR CONSTANTLY REMAINS ILLUMINATED. THE AIR CONDITIONER WAS COMPLETELY SERVICED; HOWEVER, IT CANNOT BE USED BECAUSE OF THE TRANSMISSION FAILURE. THE CURRENT MILEAGE WAS 155,000 AND FAILURE MILEAGE WAS 116,250. UPDATE 09/10/08 *CW UPDATED 09/15/08.

NHTSA complaint #10237372 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:SHOCK ABSORBER

I OWN A 1996 PLYMOUTH VOYAGER AND ON THIS MIN VAN THE WIPERS ACT VERY ERRATIC. THEY WORK WHEN THEY WANT. SOMETIMES THEY WON'T SHUT OFF AND OTHER TIMES THEY WILL NOT COME ON AT ALL OR STOP RIGHT IN THE MIDDLE OF YOUR VIEW. I ALSO HAVE AN ISSUE WITH THE SERPENTINE BELTS POPPING OFF THE DRIVE LINE LEAVING YOU WITH NO POWER STEERING OR POWER BRAKES AND COMPLETELY DISABLES THE VEHICLE. I ALSO EXPERIENCE ISSUES WITH THE REAR SHOCKS. THE BOLTS COME LOOSE AND DETACHES THE REAR SHICK FROM THE VAN LEAVING IT QUITE UNCONTROLLABLE WHILE DRIVING. ALL 3 ISSUES HAPPENS ON MANY OCCASIONS. ALL 4 OF THESE DEFECTS MAKE THIS VAN VERY DANGEROUS TO DRIVE OR TRAVEL WITH. CURRENTLY MY VAN IS SITTING IN MY DRIVE WITH A BAD TRANSMISSION. I HAVE OWNED THE VAN FOR 5 YEARS NOW AND IN 5 YEARS I HAVE BLOWN 3 TRANSMISSIONS.

NHTSA complaint #10209285 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

FRONT STRUT TOWER CORROSION PERFORATING ATTACHMENT SURFACE ON 1996 CHRYSLER GRAND VOYAGER. ATTACHMENT POINT DETERIORATES CAUSING THE FRONT SUSPENSION TO COLLAPSE MAKING THE VEHICLE UNABLE TO STEER CAUSING COLLISION WITH ANOTHER VEHICLE OR OBJECT UNAVOIDABLE.

NHTSA complaint #10156516 — an unverified report by a vehicle owner.

SUSPENSION

THIS IS NO EVENTS LEADING UP TO THIS YET. I OWN A 1996 PLYMOUTH VOYAGER SE, THE STRUT TOWERS ON BOTH DRIVER AND PASSENGER SIDE UNDER THE HOOD ARE RUSTING OUT. THE TOWER HAVE NOT BEEN REPLACED YET DUE TO CHRYSLER TELLING ME THE PARTS FOR THE FIX ARE BACK ORDERED, AND THEY DO NOT KNOW WHEN THE PARTS WILL BE AVAILABLE. IF ONE OF STRUTS WHERE TO COME THROUGH, GOD KNOWS WHAT MIGHT HAPPEN. THIS SEEMS TO BE AFFECTING 96-00 CARAVANS AND VOYAGERS, PERSONALLY SEEN IT AND ON-LINE FORUMS. I HAVE HAD DIFFERENT 96 AND 97 WITH THE SAME PROBLEM, HAVE SINCE SOLD THEM.

NHTSA complaint #10151268 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT

WHILE DRIVING A LOUD NOISE WAS HEARD FROM THE REAR. CONSUMER DROVE THE VEHICLE TO THE DEALER, AND MECHANIC DETERMINED THAT BOTH FRONT UPPER BALL JOINTS NEEDED TO BE REPLACED DUE TO CORROSION.

NHTSA complaint #10073750 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:SHOCK ABSORBER

VEHICLE WAS TAKEN TO THE DEALER FOR REGULAR MAINTENANCE, AND TECHNICIAN DETERMINED THAT BOTH STRUT TOWERS WERE RUSTED TO THE POINT THAT IT WAS UNSAFE TO DRIVE THE VEHICLE. DEALER NOTIFIED.

NHTSA complaint #10071476 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:MACPHERSON STRUT

CONSUMER TOOK THE VEHICLE TO THE DEALERSHIP FOR INSPECTION, AND MECHANIC DETERMINED THAT STRUT TOWER HOUSING CORRODED.

NHTSA complaint #10067330 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:MACPHERSON STRUT

THE CONSUMER STATED THE STRUT TOWERS WERE RUSTED. DEALER NOTIFIED.*AK

NHTSA complaint #10032249 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

IN APRIL 2003, THE VEHICLE WAS TAKEN TO AN AUTO BODY SHOP FOR MAINTENANCE ON THE AIR CONDITIONING. THE MECHANIC NOTICED THE STRUT TOWERS WERE RUSTING. THE CONSUMER THEN TOOK THE VEHICLE TO CHRYSLER, WHO STATED THE PROBLEM WAS NOT NORMAL. THE CONSUMER CALLED THE MANUFACTURER, WHO WOULD NOT COVER ANY OF THE COST. *AK

NHTSA complaint #10031538 — an unverified report by a vehicle owner.

SUSPENSION

DEALER SERVICE DEPARTMENT STATED THIS IS NORMAL WEAR CLEVELAND AREA DUE TO SALT. ROTOR WARPAGE, EXTREME VIBRATION AND SWAY BAR BUSHINGS FAILURE AT SUCH LOW MILEAGE REPRESENTS DANGEROUS DESIGN FLAW WHICH IS IMPRACTICAL TO COMPENSATE FOR WITH CONSTANT REPLACING OF POORLY DESIGNED AND MANUFACTURED PARTS. THIS IS IN A VEHICLE WHICH IS TYPICALLY USED TO TRANSPORT FAMILIES AND CHILDREN. THESE DEFECTS CAUSE ACTUAL LOSS OF CONTROL PROBLEMS ON THE ROAD SHOULD BE ADDRESSED URGENTLY. *JB ***DIMSII IVOQ POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS****742642

NHTSA complaint #10006399 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:STABILIZER BAR

WHILE HAVING A ROUTINE OIL CHANGE, THE MECHANIC NOTICE THAT THE STABILIZER BAR WAS SNAPPED IN HALF.

NHTSA complaint #10021583 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

EXCESSIVE RUST DAMAGE TO FRONT STRUT TOWERS. ONE OF THEM HAD TO BE REPAIRED WITH A CAP, THE OTHER TOWER HAD TO BE REPLACED. THE TOWER THAT WAS REPLACED HAD TWO CRACKS, ONE OF THEM FROM THE TOP TO THE BOTTOM OF THE TOWER.

NHTSA complaint #10016868 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:MACPHERSON STRUT

VEHICLE WAS TAKEN TO DEALER FOR SOME REPAIRS. WHILE THERE, CONSUMER WAS TOLD THAT THE STRUT TOWERS WERE RUSTED.ALSO, WAS TOLD NOT TO DRIVE VEHICLE. PLEASE DESCRIBE DETAILS.

NHTSA complaint #8016720 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:SHOCK ABSORBER

CONSUMER HAD NOTICED RUST AROUND FRONT SHOCK ABSORBER TOWERS, WHERE THESE PARTS ARE COMING APART, AND EVENTUALLY WILL DISATTACH FROM VEHICLE. DEALER AND MANUFACTURER HAD BEEN CONTACTED. *AK

NHTSA complaint #8005867 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:SHOCK ABSORBER

WHILE DRIVING COULD HEAR A LOT OF NOISE COMING FROM SUSPENSION. HAD TO REPLACE SHOCK ABSORBERS. PLEASE PROVIDE MORE INFORMATION.

NHTSA complaint #8002345 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

AT 30 TO 40 MPH THERES VIBRATION IN COMING FROM FRONT END. PLEASE PROVIDE ANY FURTHER INFORMATION.

NHTSA complaint #8001489 — an unverified report by a vehicle owner.

SUSPENSION:REAR

RIGHT SIDE OF SWAY BAR BROKE IN HALF WHERE THE BOLT SECURES SWAY BAR TO THE ARM OFF THE STRUT IT IS DEFINETLY A DEFECT IN THE STEEL OR HARDNESS OR TEMPER OF THE PART NOTE THE BOLT THAT SECURES THE TWO PEICES IS STILL ATTACHED WITH THE TOP BROKEN HALF STILL ON IT I'M GLAD I SAW THIS TODAY WE ARE TO LEAVE ON VACATION ON SATURDAY!

NHTSA complaint #728619 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:MACPHERSON STRUT

TRANSMISSION REPLACED BY DEALER FOR FREE ON 5-1-97, STRUTS REPLACED 11-1-97 FOR 616.01 BY DEALER, WINDSHIELD WIPERS COME ON WHEN NOT IN USE, CYLINDER HEAD LEAKING OIL 4-3-99.

NHTSA complaint #706681 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

BEFORE FOSS ATTEMPTED REPAIR IN JUNE OF 1998, THERE WAS FRONT END WOBBLE (SCALLOPING) AND STEERING WHEEL SHAKE WHEN YOU RECOVERED FROM LEFT OR RIGHT TURN, AND AT SPEEDS BETWEEN 20-30 MPH. THIS PROBLEM WAS REPORTED ON NUMEROUS OCCASIONS SINCE PURCHASE OF THE CAR. SINCE THE ATTEMPT TO FIX IT IS WORSE: STEERING WHEEL SHAKES, FRONT END SHAKES OR WOBBLES FROM 5-40, IT IS SO BAD THAT THE LEGGS OF THE DRIVER AND FRONT PASSENGER SHAKE DURING THIS TIME (FRONT END ALIGNMENT ALWAYS OK), PLUS LOUD HUMMING NOISE FROM BACK END. HAD TO REPLACE STOCK BRIDGESTONE TIRES AT 26000 MILES, PROBLEMS CONT. WITH NEW TIRES.

NHTSA complaint #702295 — an unverified report by a vehicle owner.

SUSPENSION:REAR

WHEN DRIVING THERE IS A CRACKING NOISE AND WHEN HITTING BUMPS THERE IS MORE NOISE INTERMITTENTLY. DEALER CONTACTED NUMEROUS TIMES, ATTEMPTED TO REPAIR THE VEHICLE, REPLACED THE SWAY BAR CUSHION AND BUSHING, AND PROBLEM STILL EXISTS. *AK BRAKES WERE MAKING NOISE FROM THE REAR DUE TO SHOE AND LINING, BRAKE ASSEMBLY FAILURE. REAR RIGHT OR LEFT BRAKE DRUM WORN OUT. THERE IS A DRIPING NOISE FROM ENGINE DUE TO TENSIONER/PULLEY FAILURE.

NHTSA complaint #832603 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

FRONT END WORE OUT.

NHTSA complaint #517503 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

OWNER STATES THAT THE VEHICLE PULLS TO THE RIGHT AND THAT DEALER FOUND THAT VEHICLE MEETS SPECS. OWNER IS VERY CONCERNED ABOUT THIS PROBLEM.V EHICLE PULLS TO THE RIGHT AT ANY SPEED.

NHTSA complaint #812110 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

FRONT END MISALIGNED/CAUSING NOISE.

NHTSA complaint #502220 — an unverified report by a vehicle owner.

SUSPENSION:REAR

THERE SEEMS TO BE SOMETHING LOOSE IN THE VEHICLE, DRIVER FEELS SOMETHING COMING FROM REAR OF VEHICLE.

NHTSA complaint #982205 — an unverified report by a vehicle owner.