2022 RAM 1500 engine problems

ENGINE AND ENGINE COOLING

The contact owns a 2022 Ram 1500. The contact stated that while her daughter was driving approximately 20 MPH, the vehicle shut off unexpectedly and the electronic parking brake unintendedly engaged. The parking brake warning light was illuminated. The driver was able to pull over to the side of the road. The driver was unable to disengage the parking brake, and the vehicle failed to restart immediately. The vehicle was restarted after several attempts and was driven to the destination. The manufacturer was notified of the failure and referred the contact to a dealer for a service appointment. The dealer was contacted and informed the contact that there would be a charge for a diagnostic test and for the repair. The vehicle was not diagnosed or repaired. The contact associated the failure with NHTSA Action Number: PE24018 (Electrical System, Hybrid Propulsion System, Engine, Engine and Engine Cooling). The failure mileage was approximately 60,000.

NHTSA complaint #11755893 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2022 Ram 1500. The contact stated that while her daughter was driving approximately 20 MPH, the vehicle shut off unexpectedly and the electronic parking brake unintendedly engaged. The parking brake warning light was illuminated. The driver was able to pull over to the side of the road. The driver was unable to disengage the parking brake, and the vehicle failed to restart immediately. The vehicle was restarted after several attempts and was driven to the destination. The manufacturer was notified of the failure and referred the contact to a dealer for a service appointment. The dealer was contacted and informed the contact that there would be a charge for a diagnostic test and for the repair. The vehicle was not diagnosed or repaired. The contact associated the failure with NHTSA Action Number: PE24018 (Electrical System, Hybrid Propulsion System, Engine, Engine and Engine Cooling). The failure mileage was approximately 60,000.

NHTSA complaint #11755893 — an unverified report by a vehicle owner.

ENGINE

Twice now my engine has shut off while driving at low speeds under 25mph. When this happens my electric emergency brake engages. Dash tells me to shift to park. The first time this happened my truck was stuck in the middle of an intersection and I almost got hit several times because the truck wasn’t restarting or releasing the electric brake. Took about 7-8 try’s of getting it to start before it finally started then the truck still wouldn’t move because the electric brake wouldn’t disengage even when trying to manually disengage it. I had to turn vehicle off and back on again for the electric brake to manually release. The second time this happened I again was stuck in an intersection but was able to restart on the 2nd try and had to manually release the electric brake. The dealer has told me no codes no problem found the first time this happened. I’m bringing it back to them this weekend. I do not feel safe in this vehicle due to this happening! I feel like I have been lucky that nobody has crashed into me when this happens.

NHTSA complaint #11755355 — an unverified report by a vehicle owner.

ENGINE

Two week Monday July 6, around 3:15pm while driving down on highway passing lane suddenly the vehicle start loosing speed and after few seconds I noticed that the engine stalled. No warning light or anything, the steering wheel turns to very heavy and the break pedal is really hard as well. Fortunately near by there was a U-turn lane for authorized vehicles only and I was able to merge to it and stop. After that I was able to start the vehicle immediately with no issues. Behind me there were at least 10 other cars trying to pass a line of semi trucks and I was lucky to nobody crash on my rear. I took the vehicle to the dealer, they run tests and tried to reproduce but no success. Besides the dealer no one checked anything due to there was no substantial damage or anything. Actually this was the second time that the vehicle engine stalled. First time was couple months back while my wife was driving in low speed trying to move out from a stopping light and the engine stalled.

NHTSA complaint #11750358 — an unverified report by a vehicle owner.

ENGINE

The engine intermittently stalls when I press the accelerator. When this happens, the vehicle loses power, the AutoPark/electronic parking brake engages, and the battery warning light appears. This has happened more than once and creates a serious risk of a collision or being stranded if it occurs in traffic. The vehicle is a 2022 Ram 1500 Rebel with the 5.7L eTorque system. The manufacturer’s records show customer satisfaction campaign Z49 as completed, but the stalling problem continues. The symptoms appear similar to those under NHTSA investigation PE24-018. The vehicle is available for inspection.

NHTSA complaint #11750463 — an unverified report by a vehicle owner.

ENGINE

The vehicle shut down and set the emergency parking brake while the vehicle was in motion at a rate of less than 15 mph. This has occurred 5 times. The first time it occurred the dealership said that it just required a software update. Every instance the vehicle was under 15 mph, and in the process of turning onto a road. There were no indications that this was going to happen before it occurred

NHTSA complaint #11744728 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2022 Ram 1500. The contact stated that while driving at an undisclosed speed, there was an abnormal odor inside the vehicle. No warning lights were illuminated. The contact stated that the odor was like antifreeze. The contact attempted to locate and stop the leak using online fixes, but the failure reoccurred. The vehicle was taken to the dealer where it was diagnosed with heater core failure. The contact was informed that the heater core needed to be replaced. The vehicle was repaired. The contact stated that after researching, the contact became aware that the failure was a known failure with similar vehicles. The manufacturer was not made aware of the failure. The failure mileage was approximately 107,000.

NHTSA complaint #11744802 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2022 Ram 1500. The contact stated that while driving at an undisclosed speed, the Check Engine warning light illuminated, and the engine failed, causing the vehicle to become inoperable. The vehicle was able to restart and was taken to a dealer, where it was diagnosed with fuel injector failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 44,000.

NHTSA complaint #11744265 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2022 Ram 1500. The contact stated that while The while driving approximately 75 MPH the check engine light had illuminated and the vehicle stalled. The message "stop vehicle and shift to park and restart" had displayed. After restarting the vehicle the contact drove to the local dealer The cause of the failure was not yet determined. The manufacturer was not yet notified of the failure. The failure mileage was 38,900.

NHTSA complaint #11740140 — an unverified report by a vehicle owner.

ENGINE

Am having issues with my 22 Ram 1500 limited 4x4 with the 5.7 HEMI MDS. there are issues with this engine since 2009. The MDS lifters and cam shaft do not get enough oil. They already replaced the cam shaft and oil pan pickup. Now they have my truck for over 3 weeks to replace the engine. The only problem is that they are replacing it with the same one and hoping again that nothing goes wrong. Called Ram and was basically told too bad. And i have another vehicle with the same engine and it's starting to do the same thing my engine was doing. Asked them to use non MDS so it won't happed again but was basically told too bad. Do not think this is fair since they have known about this problem since 09. If I would have known this,I would have not purchased the 2 vehicles. I think the resolution should be that they install non MDS parts now and when it happens to my 23 JEEP WAGONEER. Thank you and have a great day, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11739041 — an unverified report by a vehicle owner.

ENGINE

The check engine light and the battery warning lights came on. Took it to the dealership and they diagnosed the problem to be the MOTOR GENERATING UNIT (MGU). This is a known problem with the ram truck. The parts to fix it are on back order at a minimum of 45 days.

NHTSA complaint #11737426 — an unverified report by a vehicle owner.

ENGINE

My car just stopped and turned off. On the screen it says service electronic stability control. And power steering unavailable and service immediately. I serviced the car on April 24th. I received the car April 29th and they said they had to flash the computers and it would take 1.5 hours. I paid 330 dollars. I drove the car off and 15-20 min later the car cut off. I called the dealership and told them and they said they have to get the car back in the shop. I have additional documents.

NHTSA complaint #11734526 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2022 Ram 1500. The contact stated that the engine and battery warning lights were illuminated. The vehicle lost automotive power while driving at various speeds. The vehicle was taken to the local dealer, where it was diagnosed and it was determined that the motor generator unit (MGU) had failed. The dealer confirmed the part had been on back order for six months. The vehicle was not repaired. The manufacturer was contacted about a loaner vehicle, but no assistance was provided. The failure mileage was approximately 50,000.

NHTSA complaint #11733358 — an unverified report by a vehicle owner.

ENGINE

Vehicle stalls when trying to accelerate. Stalled in the middle of intersection with on coming traffic numerous times

NHTSA complaint #11732443 — an unverified report by a vehicle owner.

ENGINE

On 3/28/2026 my vehicle decided to engage the emergency brake, shift into park and turn engine off at the intersection with oncoming traffic approaching causing several vehicles to dangerously navigate around my vehicle to avoid an accident

NHTSA complaint #11732066 — an unverified report by a vehicle owner.

ENGINE

Truck has stopped completely including brakes and truck shutting completely off three times, causing almost collisions three times now. This is an extreme safety risk, this vehicle was just purchased from dealer three month ago and all maintenance and recalls thus far have been dealt with

NHTSA complaint #11731783 — an unverified report by a vehicle owner.

ENGINE

Turning left from a stop sign, engine turned off in the middle of the intersection and parking brake was automatically applied. max speed achieved approximately 5mph. Red Battery dash light was illuminated. Dash instructions were to press brake pedal and push park brake release button. after completing I was able to shift to park and restart the vehicle. Red battery dash light remained. After moving vehicle to a safe location I turning off the vehicle, waited ~20 seconds, and restarted it. battery light was good and digital voltage gauge showing 13.9V. no further issues on the commute to work.

NHTSA complaint #11731029 — an unverified report by a vehicle owner.

ENGINE

Truck shut off and emergency brake came on the truck finally restarted after a few minutes i released parking brake and drove home luckily it happened in a empty parking lot

NHTSA complaint #11731182 — an unverified report by a vehicle owner.

ENGINE

[XXX] I was local driving and my Ram truck got silent and engine died. I still had power steering. When I rolled to a stop the message said "press brake and put in park". The truck put itself in park before I pressed the brake pedal. It took 3 attempts to get my truck started. I drove to Walker dealer in Alexandria, La., and reported problem. Service advisor put a computer on the truck and it had a code. We made an appointment for 4-7-26 to get it resolved. I left my truck at the dealership at 8:30am and picked it up at 5pm. Advisor said they fixed a code and everything else checked out in OK status. That part was under warranty so no charge. The same thing happened last summer but I did not report it as I was able to start the truck and thought I had done something wrong. I am scared to make a trip anywhere and leave me stranded. I now make sure I have towing coverage. Because it is something that has to do with computers, I have to stay close to a dealership because their computer tools are proprietary. The truck gave no warning or indication of any kind. It just died. I keep all my paperwork from the dealership. I bought the truck with 2000 miles on it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11730334 — an unverified report by a vehicle owner.

ENGINE

I was driving my Ram 1500 5.7L eTorque this morning (2022, ~36k miles). About 10 minutes in, I was stopped at a light and the truck shut down completely (engine, electric, etc.) There was no prior notice, nor was it having problems. When I tried to go as the light turned green, obviously the truck did not go. I noticed several panel lights come on, including the battery light. There was also a message that said something to the extent that the emergency brake had automatically engaged and needed to be released. After a minute, I was able to re-start the car and drive home. Cars behind me honked, and eventually went around me. I have an appointment to take the truck in, but no diagnosis as of now. I did research and read that this a known problem with the 5.7L eTorque, and that some trucks have been recalled (NHTSA Recall 23V-235) for similar issues, and there is also on ongoing investigation for others that were not part of the recall. My experience is similar to everything I've seen/read reported by other drivers (e.g., seemingly random stall with no prior warning, certain dash lights coming on, auto-engagement of the parking break).

NHTSA complaint #11729910 — an unverified report by a vehicle owner.

ENGINE

2022 Ram 1500 Laramie 5.7l Hemi coolant system issues. Every time I get out of my truck I smell coolant. Took it to Crain Dodge Ram & Jeep Benton, AR. The first time they pressure tested system and found no leaks. Told me it was normal! 1 week later, it's back and they could smell how bad it was.Still no leaks. I dropped it off and after 2 weeks, they haven't touched it. Finally after 3 weeks they send me a text saying that there is dirt in the coolant and needs to be flushed and will cost $400. Truck is still under the 60k mile bumper to bumper warranty. I told them that if there were no leaks, and my truck has never seen mud and rarely sees gravel, I did some research and found several TSB's on the coolant system being contaminated by engine oil and that there is also an issue with casting sand being left in the engine blocks after manufacturing process, and contaminats the coolant system and Jeep is having the same issue which is causing engine fires! I took screenshots of the TSB's I found online and sent them to the dealership. They refuse to address the issue and have not made any attempts to resolve the issue! I should not be held responsible for the engine manufacturer leaving casting sand in the block and is causing coolant issues in my truck! Why would a dealership, that I have bought 3 Ram trucks from, 2 suv's from, not even attempt to investigate the issues of coolant contamination that seems to be a recurring problem in these trucks! And how many other people have they scammed and made them pay for coolant flush and new coolant? And just how much damage has been done to the aluminum heads, thermostat, heater core, and radiator after coolant has circulated through the system like a sand blaster, eating away at all of the interior coolant parts and cylinder heads and gaskets! And what kind of permanent damage to the engine and water pump do I have to worry about in the future, that will most likely occur after the factory warranty has expired!

NHTSA complaint #11729941 — an unverified report by a vehicle owner.

ENGINE

While driving at low speeds twice now my ram 1500 has stalled and engaged the parking break. Once coming to a stop and another time making a turn onto a road. Once I turn the truck back on there is a battery light on the dash and I’m allowed to drive to a safe place and restart the truck and the battery light goes away. Very concerned for my safety due to living next to a busy road.

NHTSA complaint #11729318 — an unverified report by a vehicle owner.

ENGINE

Im driving vehicle and randomly the vehicle will shut off when making turns. It is random every so many months. But it has done in major intersections. It will immediately start back up so that’s good. But there are no engine lights. And dealership Does not seam like they can do a whole lot with engine no lights on. But it seems common when doing research online The vehicle is a 2022 Ram 1500 with 55,000 miles

NHTSA complaint #11728606 — an unverified report by a vehicle owner.

ENGINE

While driving on the 60 East highway (approximately 65-68 mph), the vehicle did not accelarate and became completely non-responsive. Each time I pressed on the gas pedal, the RPM needle started trembling between 600-1100, which is much lower than where it should be while the vehicle was in Drive and traveling at this speed. This was an extremely dangerous situation as I had my wife and 5 month old daughter in the vehicle, and other vehicles were traveling significantly faster than me. I noticed some engine vibrations, and the digital gauge cluster screen presented information on the screen as if the vehicle was "off." It instructed me to push the gear lever into Park. It then instructed me to press the brake pedal and push the iginition button. All of this occurred as the vehicle was still coasting (likely around 40 mph). I pulled over on to the shoulder to see what occurred. After coming to a complete stop the engine cut out. I was able to restart the vehicle and drove approximately 10 minutes before it occurred again on the surface streets. At that point the ignition did not catch and it sounded very much like the engine was not able to turn on at all. The check engine light turned on at this point. I called AAA for tow services shortly thereafter, and the vehicle was dropped off at the dealership. I have not received any followup from the dearlership yet.

NHTSA complaint #11727941 — an unverified report by a vehicle owner.

ENGINE

SMELL OF COOLANT THROUGH OUT THE CAB OF THE TRUCK. TOOK THE VEHICLE TO THE REPAIR SHOP AND AFTER A PRESSURE TEST WAS CONDUCTED, IT WAS FOUND TO BE A BAD HEATER CORE. APPARENTLY THIS IS A KNOWN ISSUE AND HAS BEEN WIDELY REPORTED. THE TRUCK ONLY HAS 40,000 MILES AND HAS BEEN WELL MAINTAINED.

NHTSA complaint #11724856 — an unverified report by a vehicle owner.

ENGINE

SMELL OF COOLANT THROUGHOUT THE CAB OF THE TRUCK. TOOK THE VEHICLE TO THE SHOP WHERE A PRESSURE TEST WAST CONDUCTED. IT WAS DETERMINED TO BE A BAD HEATER CORE. APPARENTLY THIS IS A KNOWN ISSUE FOR THE RAM TRUCK. THIS WAS AMENDED FROM A EARLIER REPORT. SENT THE WRONG DOCUMENT FROM THE SHOP.

NHTSA complaint #11724862 — an unverified report by a vehicle owner.

ENGINE

With auto start stop system turned off the engine will die when coming to a stop. The truck then shifts into park and brakes auto apply. No check engine lights no failure indications. Starts up and runs everything fine afterwards. Happens at first 3 stops and then will not happen again unless truck sits for more then 2 hours. Dealers unable to fix cause no check engine lights and nothing recorded in computer. This is a software problem they say wait for a recall.

NHTSA complaint #11724585 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2022 Ram 1500. The contact received notification of NHTSA Campaign Number: 25V720000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA complaint #11723889 — an unverified report by a vehicle owner.

ENGINE

When coming to a stop at a stop sign, my truck randomly shut off while in gear, automatically shifted to park and put the ebrake on. I restarted my truck and shut off the ebrake and drove fine the rest of the way.

NHTSA complaint #11723382 — an unverified report by a vehicle owner.

ENGINE

The part on my truck in question is the "OEM Actuator Manifold Runner", or "ISV Actuator", or "Swirl Valve Actuator". I've seen the part called several things online. My mechanic and dealerships I've visited with tell me this part is on major back order and 300+ individuals nationwide are also waiting on the part. I'm told there is no open recall for this part. My truck is currently not safe to drive and the part is unavailable. There needs to be a recall placed on this part that so many people are having the same issue with and cannot obtain the parts needed to repair the issue. This is costing me thousands of dollars worth of rental car fees, and I still have no estimated timeframe on when this part will be available. Again, there should be a recall on this part. Based on what I've read online this part availability issue is not new. If not a recall, this part must be under warranty after the abundance of cases related to this part. How can I get a solution to this issue?

NHTSA complaint #11722331 — an unverified report by a vehicle owner.