2022 RAM 2500 engine problems

ENGINE

Lifter failure occurred on dangerous interstate interchange complete loss of power while towing a 14k pound mobile restroom bumper pull trailer in 6 lanes merging traffic from center lane 45 mph exit onto 60 mph interstate speeds XXX going onto XXX/[XXX] my scanner said dpf plugged stellantis mechanic claims lifter failure problem is complete loss of power happened in a dangerous area and waiting for a tow while hooked to a trailer was also dangerous due to high traffic area INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11747488 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2022 Ram 2500. The contact received notification of NHTSA Campaign Number: 25V720000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA complaint #11744944 — an unverified report by a vehicle owner.

ENGINE

The vehicle has experienced repeated failures related to the diesel emissions system despite multiple repair attempts. The primary symptom is an illuminated check engine light accompanied by diagnostic trouble code P2459 (Diesel Particulate Filter Regeneration Frequency). The vehicle frequently enters regeneration cycles and continues to exhibit the same symptoms after major emissions system repairs. The emissions system components, including the Diesel Particulate Filter (DPF) and related DEF system components, were previously replaced by an authorized dealer. Following those repairs, the same warning light and fault code returned. The vehicle was subsequently inspected by another authorized dealer, which was unable to identify a definitive cause of the recurring condition. The check engine light was cleared, but it returned less than a week later with the same symptoms. The failure creates a safety concern because the vehicle may enter reduced-power or limp-home operating modes without warning, potentially limiting acceleration and the ability to maintain traffic speed. This is especially concerning when merging onto highways, crossing intersections, towing loads, or operating in heavy traffic. The recurring nature of the failure has reduced confidence in the reliability and safe operation of the vehicle. The condition has been reproduced multiple times and has been documented by authorized service facilities. Warning lamps and fault codes have repeatedly reappeared following repairs. The vehicle and emissions system components remain available for inspection upon request.

NHTSA complaint #11743315 — an unverified report by a vehicle owner.

ENGINE

I am reporting a recurring safety defect involving hydraulic lifter failure in Ram trucks equipped with the Cummins diesel engine (model years 2019–2024). This issue is widely acknowledged by Stellantis and multiple dealers. It typically begins with a knocking sound and has been documented in many cases to progress to complete engine failure. My vehicle has fewer than 20,000 miles. The lifters were already replaced once, which required the cab to be removed. Within less than 400 miles of that repair, the knocking sound has returned. I brought the truck to a second dealer, who confirmed the problem and informed me that Stellantis has an active STAR case acknowledging the defect. They stated there is currently no known permanent fix. This defect presents a serious safety concern. Sudden engine failure while driving, especially under load or at highway speeds, could lead to loss of power, loss of steering/braking assist, and potential accidents. In my situation, I frequently travel with family members who have medical conditions, and being stranded in hazardous or remote conditions poses significant risk. At this point, my vehicle is not reliable or safe to operate. I am requesting NHTSA investigate the hydraulic lifter defect in 2019–2024 Ram Cummins trucks due to the safety implications and the lack of an available permanent repair.

NHTSA complaint #11702823 — an unverified report by a vehicle owner.

ENGINE

DPF regeneration frequency. Truck began exhaust regeneration at frequent intervals. Truck produced check engine light for "regen frequency P2459". Problem verified by dealer. Cause of the issue is unknown.

NHTSA complaint #11689162 — an unverified report by a vehicle owner.

ENGINE

Truck has had lifters replaced due to tick, sluggish performance and engine vibration. Truck was driven less then 500 miles and problem re-occurred. With research I have learned this is a widespread problem, and ram techs have reported complained there is no fix, and they are just reinstalling parts that will fail again. I feel the engine has had metal ran through it which in my opinion could cause this engine to seize up at. T tow a larch travel trailer with my family an and small pets in this vehicle.i live in the Desert where temperatures reach in the 120s. I can’t have a vehicle that could stop running leave myself and my family in a situation where the truck stops running, to be either hit by another vehicle or on the road side broken down. Problem was documented at 17000 miles and still under the 3 year 36 warranty.

NHTSA complaint #11677472 — an unverified report by a vehicle owner.

ENGINE

Engine had a tick, dealer said it was lifters. Dealer replaced lifters after having the truck for three weeks. Noise is back 2022 ram 6.7 with 17000 miles. This issue could cause engine failure at any speed and I use this truck to pull a large travel trailer. I’m concerned the noise is back and putting metal shavings into the engine will cause catastrophic engine failure at some point.

NHTSA complaint #11674061 — an unverified report by a vehicle owner.

ENGINE

Hydraulic roller lifter failure. Very common these pickups . Mine went in for a ticking noise hydraulic roller lifter failed got stuck in the bore. They replaced all 16 they test drove it stuck exhaust lifter #2 they replaced that lifter and the camshaft. Engine still has a very loud clatter and ticking noise. Did not do this when it was brand new

NHTSA complaint #11672856 — an unverified report by a vehicle owner.

ENGINE

The Mass Air Flow (MAF) sensor on my 2022 Ram 2500 failed, causing multiple system malfunctions. It triggered inaccurate Diesel Particulate Filter (DPF) codes and showed abnormally high idle hours that do not reflect actual vehicle use. This defect is tied to a known issue identified by Stellantis in Technical Service Bulletin #18-002-24, which acknowledges improper MAF sensor calibration or compatibility on vehicles like mine. The bulletin was verbally confirmed by the dealership as applying to my truck. This faulty sensor caused emissions system errors, degraded engine performance, and may impact emissions compliance. There was a persistent check engine light, reduced fuel economy, and the risk of engine derating. The problem was reproduced and confirmed by Encore Chrysler (Mobile, AL), an authorized Ram dealership. Stellantis has agreed to cover the repair under Goodwill, but the issue appears systemic. Safety was potentially compromised by inaccurate sensor data that may cause sudden engine derate or failure during operation. Additionally, the incorrect idle hour readings could affect warranty determinations and long-term diagnostics if not corrected. The check engine light first appeared on May 21, 2024. The vehicle has been out of service since May 22, 2024, and repairs are still pending. The MAF sensor and affected systems are available for inspection upon request. This issue may affect a broader set of Ram 2500 trucks, and given the manufacturer’s internal bulletin, it may merit a recall review.

NHTSA complaint #11664846 — an unverified report by a vehicle owner.

ENGINE

5th gen ram with the 6.7 Cummins diesel have a massive problem with lifters. Extremely common for trucks with under 10k miles needing the extensive repair done. I’ve read in some cases people whole motors breakdown due to this failure while on the highway pulling a load. My specific truck had to have all the lifters replaced at 76k miles. There needs to be a manufacture recall on these.

NHTSA complaint #11657401 — an unverified report by a vehicle owner.

ENGINE

Stater seized

NHTSA complaint #11642919 — an unverified report by a vehicle owner.

ENGINE

Recall said completed it's not and code is still coming up on reader. So many problems with it. How to find out to get the services I'm paying for.

NHTSA complaint #11632113 — an unverified report by a vehicle owner.

ENGINE

Grid heater nut/bolt has been reported to deteriorate enough to allow the nut to drop into the intake manifold and get sucked into the engine causing catastrophic engine failure. This information comes from shops that have replaced the engines that have had this failure occur

NHTSA complaint #11629570 — an unverified report by a vehicle owner.

ENGINE

Truck would not start or crank over. It had to be towed to a repair shop and the starter had to be replaced.

NHTSA complaint #11618901 — an unverified report by a vehicle owner.

ENGINE

The grid heater bolt can fail and fall into cylinder number 6 and cause catastrophic failure causing an accident. The 68RFE transmission is prone to failure and should be repaired/replaced. The hydraulic liters are subject to failure and should be replaced with solid lifters.

NHTSA complaint #11617070 — an unverified report by a vehicle owner.

ENGINE

The transmission down shifts by itself while driving down the road . You have to stop an change the gears to park then start again.I has happened 3 or 4 times .most of the time when you stop at a light or stop sign and take off when it drops to a lower gear it makes a sudden jerk. Some times tyhe transmission slams in to gear rather hard, I am going to be out of warranty if some one does not fix this problem.It has 12,276.7 miles on it as of right now. Any help would be greatly appreciated. I don,t drive it much but it is going to blow the engine up or the tramission.

NHTSA complaint #11591052 — an unverified report by a vehicle owner.

ENGINE

This is a safety recall ISSUE, I continue to have a problem with this dealer (Hunter Dodge in Lancaster ca) on resolving 3 safety recalls on my 2022 Ram 2500 I have been on the dealers waiting list for 8 months now. Recently I received a call from Chrysler Co. that the dealer had the parts inhouse and I should call the dealer (Hunter Dodge in Lancaster ca) to set up an appointment. I called the person who is responsible at the dealership to get an appointment, she stated there was no reason for the appointment because she did not have the parts to fix my truck and hung up the phone. I received a call from Chrysler saying the parts are at the dealer, and yet when I call they continue to say the parts are not in. I am planning to go out of town with my family soon and I am VERY worried about this being a SAFTEY issue for 8 months now. I wonder if this problem qualifies as a 'Lemon Law' issue or any other action?, I hope you can help resolve this issue. [XXX] [XXX] 04/17/2024 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11584188 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

See attached document for complaint

NHTSA complaint #11582426 — an unverified report by a vehicle owner.

ENGINE

Service def see dealer and max 5mph in 150 miles. Traveling on I-40 from East Tn heading home. 225 miles to go. On a Friday afternoon. Called dealers in area none could look at it until Monday. Stressing about possibility of going into derate at 5mph on interstate and getting rear ended. Had to rent a car and take to a dealer 160 miles from home. Spoiled my vacation because of a false warning about def level. All that was wrong was the code needed to be cleared.

NHTSA complaint #11558798 — an unverified report by a vehicle owner.

ENGINE

This recall has NOT been fixed by the dealer since I had it there December 20, 2021 with the original recall Y76. I’ve received two more recalls for the Intake Air Grid Heater Relay 13A, have taken it in for service 2x now for it and am told still that parts are on back order. I’ve been told this since December 2021.

NHTSA complaint #11556345 — an unverified report by a vehicle owner.

ENGINE

Two fire related safety recalls ZA3 (10/22/2022) and 13A (2/9/2023) have yet to be resolved due to a lack of parts from the manufacturer with no date available as to the availability of required parts.

NHTSA complaint #11554232 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

The contact owns a 2022 Ram 2500. The contact stated while driving 75 MPH, the “Diesel Exhaust Fluid Low – 5 Miles Before LIMP Mode" message was displayed. The contact stated that the diesel fluid was refilled several times. The vehicle was taken to the dealer and the contact was informed that the exhaust fluid was contaminated and that the tank needed to be replaced, and the O-ring seal needed to be replaced. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was 18,000.

NHTSA complaint #11534777 — an unverified report by a vehicle owner.

ENGINE

Second 2022 ram 2500 tradesman and front end shimming at all speeds. Brakes go to floor. Radio, heater doesn't work all the time. Has a ticking sound until it warms up. Been in shop many times for problems

NHTSA complaint #11524173 — an unverified report by a vehicle owner.

ENGINE

2nd ram tradesman 2500 2022. Front end shakes and goes all over. Shimmer is normal at 65 but it's actually doing it at 35. Brakes are to the floor

NHTSA complaint #11520759 — an unverified report by a vehicle owner.

ENGINE

There is an open recall that is not being taken care of by the manufacture stating my truck engine will catch fire when parked. Seems to me they should fix this as soon as possible.

NHTSA complaint #11512225 — an unverified report by a vehicle owner.

ENGINE

Vehicle has sat for 60 days due no parts available for repair , making the vehicle usable do to fire risk. Both recalls no parts available,

NHTSA complaint #11511179 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

The contact owns a 2022 Ram 2500. The contact received notification of NHTSA Campaign Number: 22V835000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that approximately an hour after driving there would be a burning oil odor inside the cabin of the vehicle. The manufacturer was made aware of the issue. The approximate failure mileage was 4,000. Parts distribution disconnect.

NHTSA complaint #11502799 — an unverified report by a vehicle owner.