306 of the
662 complaints filed about the Saab 9-5
are about the electrical system —
46% of everything owners reported.
The worst model year for it is 1999.
I purchased my 2004 Saab 9-5 in 2023. I was under the impression that everything was running and that drivability was proper. When I attempted to drive the automobile it would start, idle 7 minutes and stall. It would not start again for about 35 minutes. I tried to use it, and this behavior continued. Often, in traffic it would stall while I was moving at low speed, and moderate speed: Without warning, it cuts out and won't start for 40 minutes. I have spent money with my mechanic, over $1,000. I personally bought many parts: MAF sensor, fuel pump relay, fuel filter, and fuel pump. I replaced the Coolant Sensor. After all this the vehicle still stalls 5 minutes after warmup. If it drives to warm up, it stalls and won't restart for 40 minutes. After I replaced the Crankshaft Position Sensor, (CPS), it has never restarted. I bought 3, one a Bosch branded model, and It has never restarted. Many other drivers complain in forums, like Saab Forums, that they are experiencing the same problems. As you know, stalling at highway speeds can cause death. Clearly the problems with the Saab motorcars, produced, owned, and sold through General Motors, are something that poses a hazard, and should be repaired at GM dealership's expense. P.S. The vehicle's immobilizer device has caused my vehicle to not start at all. The key fobs have stopped functioning at all. I replaced the batteries, and they won't connect to the engine. The vehicle will crank, but no start. Battery runs down, with crank, but no start behavior. Can General Motors either: 1. replace the entire engine, 2. repair the "stall, no restart" situation, 3. moreover repair my seeming to be, "anti-theft system, no start" situation, called DICE/TWICEsystem, 4. achieving an actual fix for these older, but cherished sporting cars? Please check these links for confirming information: saabforums.com/forum/saab9-5-12/engine-turns-over--but-wont-start-9066/ www.saabcentral.com/threads/cranks-but-wont-start.689898/
NHTSA complaint #11660144 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 1993 BUICK REGAL. THE CONTACT STATED THAT ALL DOOR LOCKS WOULD BECOME STUCK WHEN ACTIVATED BY THE ELECTRONIC DOOR LOCK SYSTEM. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 41,000.
NHTSA complaint #10864571 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2001 SAAB 9-5. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING AND FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS EVENTUALLY ABLE TO RESTART. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V399000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA complaint #10776576 — an unverified report by a vehicle owner.
WHILE TRAVELING ON FREEWAY, IGNITION SUDDENLY SHUT OFF AND CAR LOST ALL POWER. HAD TO STEER TO THE SIDE OF THE ROAD WITHOUT POWER AND THEN RESTART CAR TO CONTINUE.
NHTSA complaint #10614735 — an unverified report by a vehicle owner.
TL* THE CONTACTS OWNS A 2003 SAAB 9-5. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE DIRECT IGNITION CASSETTE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 125,000.
NHTSA complaint #10611334 — an unverified report by a vehicle owner.
I HAVE OWNED A 2004 SAAB 9-5 SPORT COMBI WAGON SINCE 2006. TWICE, OVER THE LAST SEVERAL YEARS (2011, 2014), MY HUSBAND AND I HAVE BEEN ON THE HIGHWAY AND HAD AN IGNITION SWITCH INCIDENT WHERE HE WAS THE DRIVER AND I WAS THE PASSENGER. IN BOTH INCIDENTS, I TURNED AROUND TO TALK TO MY DAUGHTER (2011) AND THEN DAUGHTERS (2014) AND INADVERTENTLY BUMPED THE KEY IN THE IGNITION WITH MY KNEE. THE IGNITION SWITCH IS LOCATED IN THE CENTER OF THE CAR BY THE CONSOLE. IT ONLY TOOK A SLIGHT TAP OF MY KNEE AND MY CAR SHUT OFF WHILE GOING AT SPEEDS OF 75-80 MPH ON THE HIGHWAY. FORTUNATELY, BOTH TIMES MY HUSBAND WAS ABLE TO PUT THE CAR INTO NEUTRAL AND GET THE CAR OFF TO THE SIDE OF THE ROAD.
NHTSA complaint #10608119 — an unverified report by a vehicle owner.
CAR SHUT OFF TWICE WHILE DRIVING ON HIGHWAY.EACH TIME I WAS ABLE TO PULL OVER TO SHOULDER AND RE START. I TOOK THE CAR TO SAAB DEALER AND THEY COULD NO FIND ANYTHING. I LATER TOOK CAR TO ANOTHER SAAB DEALER AND THEY INSTALLED A NEW DEVICE (BELIEVE SOMETHING TO DO WITH COMPUTER) AND SAID THAT IF THAT DID NOT TAKE CARE OF PROBLEM, THEY DID NOT HAVE AN ANSWER. THERE WERE NO FURTHER ISSUES UNTIL MAYBE 2 YEARS LATER, ALSO SHUT OFF WHILE COMING OFF A RAMP BUT THAT MAY HAVE BEEN DUE TO LOW FUEL ACCORDING TO DEALER (MY FUEL WAS LOW). THERE HAVE NOT BEEN ANY FURTHER INCIDENTS.
NHTSA complaint #10604642 — an unverified report by a vehicle owner.
MY 2001 SAAB 9-5 HAS BEEN EXPERIENCING A CHECK ENGINE LIGHT FOR AWHILE ON AND OFF. THE VEHICLE WILL SOMETIMES STALL RANDOMLY AND NOT START UNTIL ENGINE COOLS DOWN. THE CODES FOR CEL LEAD TO DIRECT IGNITION. A PREVIOUS RECALL ON THESE VEHICLES, ONE MY VEHICLE RECEIVED. I CALLED DEALER AND THEY SAID SEEING AS IT WAS ALREADY TAKEN CARE OF ONCE NOTHING CAN BE DONE. I KNOW I WILL TO HAVE TO GET IT FIXED TO PASS EMISSIONS TESTING DUE TO FAULTY DIRECT IGNITION. NOT TO MENTION HOW UNSAFE IT IS IF IT STALLS.
NHTSA complaint #10597832 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2004 SABB 9-5. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND TOOK IT TO THE DEALER FOR INSPECTION OF THE FAILURE WHERE THE TECHNICIAN REPLACED THE IGNITION MODULE. THE CONTACT WAS MADE AWARE OF A MANUFACTURER'S RECALL FOR THE IGNITION SWITCH BUT WAS ADVISED THAT THE VEHICLE WAS NOT INCLUDED. THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. UPDATED 10/23/2014*LJ THE CONSUMER STATED THE CHECK ENGINE AND NO AUTOMATIC WARNING LIGHTS WOULD ILLUMINATE ON FREQUENTLY. UPDATED 8/10/2015
NHTSA complaint #10586152 — an unverified report by a vehicle owner.
IGNITION SWITCH SHUT OFF WHILE ON A BUSY HIGHWAY TWICE! ONCE IN 2006 AND ONCE LATER ANOTHER YEAR PLUS ONCE IN A DRIVEWAY (CAR PURCHASED USED IN THE FALL OF 2005). THE SAAB SWITCH IS LOCATED IN THE CENTER CONSOLE AND IF IT IS HIT IT SWITCHES OFF AND SHUTS DOWN THE CAR, SAME AS RECALLED SWITCHES IN OTHER GM CARS. VERY DANGEROUS ON THE HIGHWAY, BUT I WAS LUCKY AND ABLE TO STEER TO THE SIDE WITHOUT A CRASH. THERE SHOULD HAVE BEEN A LOCK MECHANISM TO PREVENT IT FROM HAPPENING. IT NEVER OCCURRED TO ME TO REPORT IT THOUGH IT IS DEFINITELY A SAFETY HAZARD IN A WHAT WAS AT THE TIME A GM OWNED PRODUCT. I STILL OWN THE CAR AND DRIVE IT DAILY ON THE SAME HIGHWAY, HOWEVER AM VERY MUCH AWARE OF THE ISSUE. I WASN'T AWARE OF WHAT CAUSED THE SHUT DOWN UNTIL IT HAPPENED THE SECOND TIME A FEW MONTHS AFTER THE FIRST TIME. YOU SHOULD INCLUDE SAAB IN THE RECALL OF GM PRODUCTS.
NHTSA complaint #10576665 — an unverified report by a vehicle owner.
IGNITION SWITCH SHUT OFF WHILE ON A BUSY HIGHWAY TWICE! ONCE IN 2006 AND ONCE LATER ANOTHER YEAR PLUS ONCE IN A DRIVEWAY (CAR PURCHASED USED IN THE FALL OF 2005). THE SAAB SWITCH IS LOCATED IN THE CENTER CONSOLE AND IF IT IS HIT IT SWITCHES OFF AND SHUTS DOWN THE CAR, SAME AS RECALLED SWITCHES IN OTHER GM CARS. VERY DANGEROUS ON THE HIGHWAY, BUT I WAS LUCKY AND ABLE TO STEER TO THE SIDE WITHOUT A CRASH. THERE SHOULD HAVE BEEN A LOCK MECHANISM TO PREVENT IT FROM HAPPENING. IT NEVER OCCURRED TO ME TO REPORT IT THOUGH IT IS DEFINITELY A SAFETY HAZARD IN A WHAT WAS AT THE TIME A GM OWNED PRODUCT. I STILL OWN THE CAR AND DRIVE IT DAILY ON THE SAME HIGHWAY, HOWEVER AM VERY MUCH AWARE OF THE ISSUE. I WASN'T AWARE OF WHAT CAUSED THE SHUT DOWN UNTIL IT HAPPENED THE SECOND TIME A FEW MONTHS AFTER THE FIRST TIME. YOU SHOULD INCLUDE SAAB IN THE RECALL OF GM PRODUCTS.
NHTSA complaint #10576665 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2008 SAAB 9-5. THE CONTACT STATED THAT WHEN HE WOULD REMOVED THE KEY OUT OF THE IGNITION, THE VEHICLE WOULD NOT TURN OFF. THE DEALER WAS CONTACTED AND THE TECHNICIAN DIAGNOSED THAT THE IGNITION SWITCH WAS DEFECTIVE AND NEEDED TO BE REPLACED. IN ADDITION, THE AIR BAG WARNING LAMP ILLUMINATED SPORADICALLY. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSED THE FAILURE FOR THE AIR BAG WARNING LAMP . THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED FOR THE IGNITION SWITCH. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 52,000.
NHTSA complaint #10573937 — an unverified report by a vehicle owner.
I WAS DRIVING THE CAR WHEN SUDDENLY THE CAR WHEN DEAD WHILE I WAS DRIVING IT.I WAS LUCKY THAT I WAS ABLE TO RESTART IT AND THERE WAS A GAS STATION RIGHT NEAR BY. IT DID NOT START UP NORMALLY AND WAS VERY SLUGGISH. I WAS IN THE MIDDLE OF TRAFFIC WHEN THIS HAPPENED BUT FORTUNATELY NOT HEAVY TRAFFIC AND IN THE RIGHT LANE. IT WAS VERY SCARY. THEY TOWED MY SAAB TO A SAAB DEALER FOR ME WHO HAD TO INSTALL A NEW IGNITION. THIS HAPPENED ABOUT 4-5 YEARS AGO ON MY SAAB 2003 9-5 STATION WAGON WHICH WAS BUILT BY GM. I BELIEVE IT WAS BUILT ON THE SAME PLATFORM OF ONE OF THE CADILLACS THAT IS UNDER RECALL.
NHTSA complaint #10573322 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2004 SAAB 9-5. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE CRANK SHAFT POSITION SENSOR, FUEL PUMP, AND THE TWICE UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 51,108.
NHTSA complaint #10569393 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS 2004 SAAB 9-5. THE CONTACT STATED THAT SHE WAS TRAVELING 55 MPH WITH HER PURSE ON THE PASSENGER'S SIDE SEAT. THE CONTACT PROCEEDED TO EXIT THE HIGHWAY WHEN THE WATER BOTTLE THAT WAS IN HER PURSE TOPPLED OVER AND STRUCK THE IGNITION SWITCH, CAUSING THE VEHICLE TO STALL. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 95,000.
NHTSA complaint #10567631 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2003 SAAB 9-5. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE STALLED. THE CONTACT STATED THAT THE STEERING WHEEL AND THE BRAKES SEIZED AS THE ENGINE STALLED. THE CONTACT WAS ABLE TO STOP THE VEHICLE WITH THE EMERGENCY BRAKE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC, WHO PERFORMED A DIAGNOSTIC TEST AND DISCOVERED THAT THE IGNITION DISCHARGE MODULE WAS DEFECTIVE. THE CONTACT REFERENCED NHTSA CAMPAIGN I.D. NUMBER: 06V410000 (ELECTRICAL SYSTEM) AND CALLED THE MANUFACTURER, WHO ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 100,000.
NHTSA complaint #10562209 — an unverified report by a vehicle owner.
THE HORN OFTEN FAILS TO WORK WHEN THE STEERING WHEEL MOUNTED AIRBAG COVER IS PRESSED. THIS IS AN ONGOING, UNRESOLVED PROBLEM. A DEALER REPLACED A PART UNDER WARRANTY BUT THAT DID NOT FIX THE PROBLEM. I HAVE SEEN SEVERAL OTHER 2002+ 9-5S WITH THE SAME HORN FAILURE ISSUE.
NHTSA complaint #10558046 — an unverified report by a vehicle owner.
THE HORN OFTEN FAILS TO WORK WHEN THE STEERING WHEEL MOUNTED AIRBAG COVER IS PRESSED. THIS IS AN ONGOING, UNRESOLVED PROBLEM. A DEALER REPLACED A PART UNDER WARRANTY BUT THAT DID NOT FIX THE PROBLEM. I HAVE SEEN SEVERAL OTHER 2002+ 9-5S WITH THE SAME HORN FAILURE ISSUE.
NHTSA complaint #10558046 — an unverified report by a vehicle owner.
I JUST BOUGHT THIS CAR. THE CHECK ENGINE LIGHT COMES ON INDICATING A SERIOUS PROBLEM. I HAD THE ERROR CODES CHECKED. THEY ARE P1312 AND P1334. THESE CODES INDICATE A PROBLEM WITH THE "DIC" (DIRECT IGNITION CONTROLLER). EARLIER MODELS WERE SUBJECT TO RECALL. THERE IS APPARENTLY STILL A PROBLEM. I KEEP CLEARING THE WARNING SIGNAL, BUT IT KEEPS RECURRING.
NHTSA complaint #10521786 — an unverified report by a vehicle owner.
UNKNOWN- DIRECT IGNITION CASSETTE UNIT HAS BEEN REPLACED THREE TIMES. EACH TIME OF REPLACEMENT THE ACTUAL PART HAS MELTED, BURNED OUT CAUSING THE CAR TO AUTOMATICALLY SHUT DOWN. THE CAR ONLY HAS 72,000 MILES. THE PART IS MELTING AGAIN MAKING THIS THE FOURTH REPLACEMENT IN A 3 MONTH PERIOD. ENGINE - EXHAUST MANIFOLD/CATALYTIC CONVERTER NEEDS TO BE REPLACED AND ALL SAAB AUTHORIZED DEALERS IN NORTHERN CA. STATE THEY ARE UNABLE TO GET PART DUE TO BEING ON BACK ORDER AND NO IDEA WHEN THE PART WILL BE AVAILABLE. BUT I WAS ABLE TO FIND THE PART OUT OF STATE IN CHICAGO AT QUALITY AUTO PARTS.
NHTSA complaint #10510972 — an unverified report by a vehicle owner.