37 of the
1,552 complaints filed about the Subaru Crosstrek
are about the fuel system —
2% of everything owners reported.
The worst model year for it is 2019.
I own a 2019 Subaru Crosstrek Hybrid with recurring fuel-system and EVAP failures that I believe present a serious safety risk. On 12/9/2025, the vehicle experienced a total loss of motive power while I was driving in dense traffic on a busy expressway. The vehicle suddenly lost propulsion in the middle lane and slowed down to a near crawl, creating an immediate risk of being struck. The event was captured on dashcam. The dealer inspected the vehicle but found no cause. On 1/5/2026, the vehicle again lost motive power. It remained at the dealership for approximately two months. Some roughness was noted, but no cause was identified, and I was told to return if the problem became more prominent. I am concerned that an intermittent defect capable of causing sudden loss of propulsion remains unresolved. The vehicle has also had recurring difficulty accepting fuel since it was new, along with check-engine lights and DTC P0452. The refueling problem progressively worsened. On 6/20/2026, the vehicle would not accept fuel normally at all. The pump repeatedly shut off while the tank was still empty or nearly empty, and fuel backed up, spilled, and overflowed from the filler neck. This creates a fire hazard and exposes occupants and bystanders to gasoline. Subaru previously performed TSB 09-82-23 but did not replace the fuel tank. The TSB allows tank replacement when resin residue is found in affected fuel-system components. Fuel was analyzed and found clean, yet multiple downstream EVAP components became clogged or restricted. The dealer later replaced the charcoal canister and EVAP filter but found no cause. I am concerned that the recurring fuel/EVAP restriction, gasoline spill during refueling, and two unexplained losses of motive power may share an unresolved root cause. Subaru has advised me only to return if symptoms recur. I do not believe it is safe to wait for another highway loss-of-power event or another gasoline overflow.
NHTSA complaint #11750700 — an unverified report by a vehicle owner.
I had a frontal accident on March 6, 2025. When I turned to pull into the driveway of my rental apartment, I lost control of the vehicle. It surged forward, climbed a low retaining wall of about 14" and then hit a support post. I sat there stunned thinking "what just happened and how?" At first, I thought it was me, but thinking about it more, I'm wondering if this could be a potential safety problem. I have read several other similar instances on the internet, and someone I know had a similar accident which was attributed to her age. Collision repair for the Crosstrek was $10,358 done by a local facility, not Subaru. Repair of damage to the support post was $1,340. I reported this to Subaru, but after several follow-ups (last one on July 29, 2025), I still have not received a reply from Subaru. I can forward the email string to you if you want. I don't know how to attach it in one of the acceptable formats.
NHTSA complaint #11696641 — an unverified report by a vehicle owner.
The contact owns a 2025 Subaru Crosstrek. The contact stated that while stopped at a gas station, the gas lid failed to open unless the vehicle was unlocked. The contact stated that the vehicle could not be refueled unless it was unlocked, which the contact considered to be a safety concern. The vehicle was taken to an unknown dealer but was not diagnosed or repaired. The contact was provided with training on how to operate the vehicle. The manufacturer was notified of the issue and informed that the vehicle needed to be unlocked while refueling the tank, per the owner's manual. The failure mileage was approximately 250.
NHTSA complaint #11678306 — an unverified report by a vehicle owner.
The 2019-2021 Crosstrek Hybrid has an issue with the fuel tank design. Subaru has finally released a TSB (Reference: 09-82-23R) that explains the issue in more detail and how the defective parts need to be replaced. In short, the fuel tank has a design flaw such that regular fuel corrodes the fuel tank and causes clogging in the vapor vent tubes. Subaru says it's related to fuel with high ethanol content, however I have been filling up with regular fuel and have still experienced the issue. I have personally owned two of these vehicles and experienced the occasional P0452 check engine light which when diagnosed by a licensed shop pointed to this fuel evap system issue. Subaru has finally acknowledged that this is a known issue and issued the TSB, however they have not yet issued a recall. The repairs for this issue are expensive and the symptoms are an occasional check engine light. I am concerned because this issue is not easily detectable and is expensive to repair. Since this involves the fuel tank and fuel vapors tubes I am concerned there might be a fire risk or health risk, but since there is no recall issued I don't know if it can be ignored or needs immediate attention. Subaru does cover this repair under 3 yr / 30k mile warranty but with the irregular symptoms it is hard to detect and diagnose it and Subaru only issued the TSB in Jan 2024 when the 2021 model became 3 years old and out of warranty. It seems like Subaru knew about the issue but didn't want to address it under warranty so they issued the TSB only after all the cars were out of warranty and only now when the consumers have to pay out of pocket are they diagnosing it correctly. Also, this issue triggers the check-engine light only occasionally and at random, and when the light goes on all the vehicle safety aids like pre-collision braking and rear cross traffic warnings are disabled. I think this is dangerous because drivers tend to get used to having those features.
NHTSA complaint #11650867 — an unverified report by a vehicle owner.
Per NHTSA Product Campaign Bulletin WRE-21, all ignition coils on my 2019 Subaru Crosstrek Premium were replace on August 9th, 2021. On November 26th 2024, the same vehicle experienced a total loss of motive power on a 50 mph, 2-lane road, resulting in emergency action to move the car off of the right-of-way. All occupants of the car were not injured. After the vehicle was towed to a Subaru Dealership, the service notes stated “DIAGNOSED NO START SCANNED AND FOUND P1604 STARTABILITY MALFUNCTION, AND P0304 CYLINDER 4 MISFIRE, CHECKED FUEL PRESSURE AND FOUND IT WAS WITHIN SPEC, FOUND THE IGNITION COIL FUSE WAS BLOWN AND UPON FURTHER INSPECTION FOUND THE CYL 4 COIL PACK SHORTED INTERNALLY AND THE PRIMARY AND SECONDARY CIRCUITS CONNECTED BLOWING THE FUSE, COIL PACK AND FUSE WILL NEED TO BE REPLACED.” The wording of the technician’s notes mirror the wording of the WRE-21. The dealership offered a one-time free “goodwill replacement” of the part in question, but only for 1 cylinder. I believe further corrective action needs to be taken by the NHTSA to prevent total loss of motive power in affected Subaru crosstreks.
NHTSA complaint #11627701 — an unverified report by a vehicle owner.
On two incidents randomly and without warning the car failed to accelerate while driving in traffic on an open road and I had to coast to safety and put in park, then drive, then travel less than five miles home. Both times I immediately scheduled service with suburu with appointments about a week out. The car drove without incident while awaiting service. Service failed to replicate the problem, diagnose or remedy it after having the car a week and I was told“vehicle is operating properly at that time”. The second occurrence at the end of June was far more dangerous as I was traveling at a higher speed in heavy traffic on a multi lane road when it occurred Car is unsafe for me, passengers and other drivers. I risk being stranded. I have no sense of reliability or safety and the car is just now at 30k
NHTSA complaint #11603340 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
The contact's significant other owns a 2020 Subaru Crosstrek. The contact stated while his significant other was driving from a complete stop, several unknown warning lights illuminated. The contact stated that the failure had been recurring. The vehicle was taken to the dealer several times. The dealer replaced the battery, the fuel cap, and cleared the warning lights; however, the failure persisted. The vehicle was towed to the dealer, where it was being diagnosed. The vehicle was not yet diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 51,000.
NHTSA complaint #11595485 — an unverified report by a vehicle owner.
In three separate incidents while car only shows 70 in fuel indicator, my 2016 Crosstrek stalled while driving on a highway. I have brought my car to Subaru dealer, but they cannot find anything wrong with my 2016 Crosstrek. In each of the three separate instances after waiting on the side road for 30 minutes, I was able to restart the car and drive home. My car just had a new engine air filter replaced.
NHTSA complaint #11563783 — an unverified report by a vehicle owner.
Car was at a stop light, went to accelerate and car would not accelerate- all the lights came on. I had to put it in park and turn it off and back on, then it accelerated and there were no other issues.
NHTSA complaint #11547198 — an unverified report by a vehicle owner.
The car's hybrid system failed. The problem was a poorly protected electrical cable and connector that is exposed under the car. It corroded and failed. The dealer cleaned it and it works again, but they think the issue will be ongoing. May be related to Manufacturer Recall Number: WRD23 / NHTSA Recall Number:23V080000
NHTSA complaint #11511935 — an unverified report by a vehicle owner.
My car has stopped working while driving 70 mph on the interstate in so separate occasions. Both times it has been driving fine, with fuel in the tank, and all of the sudden it shuts off and completely loses power. All of the warning lights on the dash light up and the only thing to do is to coast to the shoulder of the highway. Couldn’t start the car back up (cranked, no start). Battery is fine. Fuel level is fine. First time it happened it had to be towed. Towed to mechanic who ran diagnostics on it the next day but nothing threw a code. It started fine the next day. I’ve had certified Subaru mechanics tear this thing apart trying to figure out what causes the issue but they can’t find anything wrong. I’m scared this is going to happen again and will put me in a dangerous situation in the middle of a highway or on the side of the road. This is definitely an issue putting myself and others at risk. It seems similar to other issues Subaru crosstreks have had in close model years to mine (20 where recalls have been issued for fuel pump malfunctions etc. Please look into this, this could cause a terrible wreck and needs to be resolved ASAP.
NHTSA complaint #11510909 — an unverified report by a vehicle owner.
I was driving my 2021 Subaru Crosstrek slowly in a parking lot when it unexpectedly accelerated on its own without me pressing the gas pedal. I believe the Crosstrek was now going 40mph. I tried to shut off the engine and brake at the same time but neither one had any effect. I thought maybe I had two options. Either hit another vehicle or pedestrian or turn my car into the curb. I decided to turn into the curb which resulted in the breaking of both axels, flattening all the tires, and sustaining damage to the front fender and headlight. The car was then towed to a garage we’re it was declared totaled. I checked the internet to see if this had occurred to any other Crosstrek. It turns out their is a class action suit pending for the same reason. Police records will show I was not drunk, sleeping, and the car mat was off gas pedal.12
NHTSA complaint #11504276 — an unverified report by a vehicle owner.
12042022 - not sure of cause, could be multiple as all systems just shut down for seconds, the car goes dead while driving down I235 at 70mph, first the radio turns off, then the car seemed to go to lower gear rpm to zero and just shut off at a high speed, NO POWER on anything, then about 2.5 seconds later it restated and continued, sputtered off again then powered back off and on again as i got off the highway, many warning lights came on including the lane warning, brake light, it was very scary at such a high speed. this car now seems to have little continued incidents of the same behavior for what has seemed to be spuratic but regular fits now and I have to have dependable transportation. very easily could have caused an accident if the traffic was heavier when the incident occured.
NHTSA complaint #11495958 — an unverified report by a vehicle owner.
This morning August 29 2022 I started my 2018 Subaru Crosstrek, when I put it in gear the car just took off before I could stop it. The idle when about 5000 RPM and then up and down. I was able to get the vehicle stopped and parked. I tried starting the vehicle again and the same. The vehicle is on its way to Crews Subaru North Charleston. Even the tow truck driver wouldn't drive the vehicle. This makes the vehicle unsafe. What if someone was walking past my driveway when this happen? It took about 40 feet to get the car stopped with my foot on the brake hard and to park the car. I have a video showing the RPM at 3900 but could upload it to your site. The consumer stated he would like the complaint removed, the floor mat holding the accelerator down was the problem.
NHTSA complaint #11481793 — an unverified report by a vehicle owner.
Upon accelerating, the engine seems to bog down and I lose speed. It has happened under many conditions—after turning a corner, going down a straightaway, and when accelerating to merge on a highway. This puts people in the car at risk and others traveling behind me. I took it to the dealer and they said that since they could not replicate it, there was nothing they could do. No warning lights seem to be involved. On the internet, posters refer to this as a "known problem" but no one has come up with a solution, nor have their dealers. It's troublesome. I know the 2018s have had a related problem. It's happened on many dates.
NHTSA complaint #11432735 — an unverified report by a vehicle owner.
I was crossing two lanes of a very busy ocean front street when the engine “bogged down” . I let off on the gas pedal and then depressed it again, which then caused the engine to go off. I the quickly restarted the engine and was able to get out of the way of oncoming traffic. This was the only time the engine failed, but on about three or four previous times, the engine “bogged down” when I depressed the gas pedal, but recovered after I quickly depressed the pedal again.
NHTSA complaint #11431202 — an unverified report by a vehicle owner.
CAR HESITATES ON ACCELERATION PERSISTS AFTER RECALL (REPLACEMENT OF IGNITION COILS). CONDITION PERSISTS SINCE PURCHASE (NOV, 2019). NUMEROUS REPAIR ORDERS DID NOT CORRECT PROBLEM.
NHTSA complaint #11425427 — an unverified report by a vehicle owner.
UNKNOWN My Subaru has always had a little hesitation when accelerating. I brought this up to the dealer and they are telling me it is normal. However, in the last few months, it has gotten worse. Sometimes, when trying to accelerate into traffic, the car feels like it's going to stall or die, then it kicks in and I am able to accelerate. This is intermittent, so I never know when it's going to happen. This is a safety issue, since the hesitation could cause me to get hit.
NHTSA complaint #11421279 — an unverified report by a vehicle owner.