2018 Subaru Crosstrek problems

ELECTRICAL SYSTEM

On 06/26/26, while traveling at highway speeds, the vehicle suffered a sudden, catastrophic loss of motive power in active traffic due to a blown out/melted Cylinder 4 ignition coil. This unexpected engine failure forced raw fuel into the exhaust system, causing an immediate internal thermal meltdown of the catalytic converter, rendering the vehicle entirely undriveable and creating a severe highway safety hazard. This vehicle was previously serviced under NHTSA Campaign 21V264000 (Subaru Recall WRE-21), which was intended to permanently remedy an ECM software defect that over-energizes and melts the ignition coils. Subaru of America (Case # 260630-2101598) is denying coverage, claiming that because the recall was executed 90,000 miles/5 years ago, and because the current software Calibration ID (CID) matches their post-recall database, the thermal melting is standard "wear and tear." I am filing this complaint because a safety recall remedy must be permanent and effective. The physical evidence, a melted plastic coil housing with a hole blown through it, is an engineering impossibility under normal wear and tear and proves that the original software patch failed to permanently mitigate the high-voltage overloading defect. Over a 5-year period of gradual thermal degradation, the defect reoccurred, creating the exact highway hazard the recall was mandated to prevent. I request a federal investigation into the long-term efficacy and failure rates of the WRE-21 software reflash.

NHTSA complaint #11748847 — an unverified report by a vehicle owner.

ENGINE

On 06/26/26, while traveling at highway speeds, the vehicle suffered a sudden, catastrophic loss of motive power in active traffic due to a blown out/melted Cylinder 4 ignition coil. This unexpected engine failure forced raw fuel into the exhaust system, causing an immediate internal thermal meltdown of the catalytic converter, rendering the vehicle entirely undriveable and creating a severe highway safety hazard. This vehicle was previously serviced under NHTSA Campaign 21V264000 (Subaru Recall WRE-21), which was intended to permanently remedy an ECM software defect that over-energizes and melts the ignition coils. Subaru of America (Case # 260630-2101598) is denying coverage, claiming that because the recall was executed 90,000 miles/5 years ago, and because the current software Calibration ID (CID) matches their post-recall database, the thermal melting is standard "wear and tear." I am filing this complaint because a safety recall remedy must be permanent and effective. The physical evidence, a melted plastic coil housing with a hole blown through it, is an engineering impossibility under normal wear and tear and proves that the original software patch failed to permanently mitigate the high-voltage overloading defect. Over a 5-year period of gradual thermal degradation, the defect reoccurred, creating the exact highway hazard the recall was mandated to prevent. I request a federal investigation into the long-term efficacy and failure rates of the WRE-21 software reflash.

NHTSA complaint #11748847 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

3/3!2026 while driving heat stop working. Called Milea Saburu spoke to Christian made an appointment for 3/5/2026 they had nothing sooner. Told her what happened. Brought in they gave me loaner 12 days later on 3/18/2026 pick up car. Paid bill they told me everything done no problems. I would get my 250 dollars for the car back in 30 days. Even though they said it was a hold it went through. I live 15 minutes from home. I got in the car heat was blasting turned it off and waited turned it on it worked. Pick up time 4 pm. Drove home parked next day 3/19/2026 turned on car made a tapping nouse after five minutes went away call dealer left message on Andrew manager answering service. Car parked at work 8 15 am to 3 40 pm. Drove home got home at 3 50 am turned off heat heart rushing water like down a creak. Turned off car looked in the front some liquid gushing out car smelled like it was burning. Put paper under car with rock to see color of fluid it was blue new it was coolant call dealer againt went to voice mail manager Andrew hung up went to dealer. Arrived at 4 40 pm Chris service Advisor check said was not save to drive burning smell still there got another loaner another 200 dollar on top of the 250. Called saburu customer advocacy this morning spoke to Latoya 11 15 am 3/20/2026 case number XXX-XXX waiting for someone to call me by Tuesday. I requested a 3 year gold plus warranty as a goodwill gesture to restore my confidence in the vehicle and protect my engine integrity. I am deeply concerned that the gushing coolent damaged the internal engines seals or may have been compromised due to the heat, the hoses or gadgets now or over time. I have puctures and documents that the system won't allow download. If the car continues to have reoccurring issues due to this complete repair failure. I am asking them to replace my 2018 saburu crosstrex that has only 52, 315 miles with an equal value car without issues. My car is 10 years old low mileage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC

NHTSA complaint #11725821 — an unverified report by a vehicle owner.

ENGINE

Dangerous stall in traffic due to ignition coil failure. Ignition coils and spark plugs were replaced during the WRE21 recall campaign only 13k miles ago back in 2021. Stopped at red light awaiting to turn left when the vehicle started shaking violently. No check engine light came on though. When the light turned green, the vehicle was barely able to move forward then it completely stalled before pulling over to the curb. Since the tail of the car was sticking out into traffic a bit, it was a downright dangerous situation. Car had to be towed to dealership and took them 5 days to diagnose and fix the problem. Ignition coil and spark plug replacements costed $1500. Don't think the recall fixed the root problem and this could potentially happen again.

NHTSA complaint #11723589 — an unverified report by a vehicle owner.

SUSPENSION

Starting at around 75,000 mileage on my 2018 Subaru Crosstrek, a persistent howling noise is heard while driving. This noise comes from the rear of the vehicle and occurs at nearly all driving speeds, measuring at around 90.0dB while on a highway (a dangerous level for prolonged exposure). A service shop and the dealership have both diagnosed the noise as an issue with the rear wheel bearings (consistent with Subaru Service Bulletin 05-70-19R). In January 2026, my low tire pressure warning light appeared on my dashboard. I checked the tire pressure with a gauge and found no issue. I assumed (and later confirmed while getting a tire changed) that the tire pressure sensor had a dead battery, and that the warning light was related to this dead sensor rather than an issue with the tire pressure. Before getting the sensors replaced, I drove for a week with the low tire pressure warning light on my dashboard. I ignored this sensor because I confirmed daily with a pressure gauge that the tire pressure was fine. However, one day while driving in February 2026, I got a flat tire on the front passenger side. I drove with this flat tire for at least six miles, not knowing I had a flat. The howling noise from the rear wheel bearings masked the noise from the flat tire, and I could not audibly distinguish anything out of the ordinary with my car. Unfortunately, this occurred in the same period of time that my tire pressure warning light was giving false flags for low tire pressure. I feel it important to log this issue because - had my rear wheel bearings not been making a howling noise - I would have noticed the flat tire immediately and would not have posed a safety risk to myself or other vehicles.

NHTSA complaint #11723204 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The contact owns a 2018 Subaru Crosstrek. The contact stated that while driving at an undisclosed speed, the headlight warning light illuminated, and the contact noticed that the passenger's side LED headlight had become inoperable. The vehicle was taken to an independent mechanic, where a headlight assembly replacement was recommended. The vehicle was not yet repaired. The manufacturer was not contacted. The failure mileage was approximately 90,000.

NHTSA complaint #11722003 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Wheel bearing issue in 2018 Subaru Crosstrek Identified by Subaru but not full recall We were not informed Risk REAR WHEELS WILL FALL OFF Contacted Subaru Advocacy after determining the backing plate was modified due to risk of failure Internet indicated courtesy repair for vehicles under 100,000 miles with new corrected part Repair was denied without full payment not even willing to supply NON DEFECTIVE part at no cost

NHTSA complaint #11720935 — an unverified report by a vehicle owner.

POWER TRAIN

Vehicle was maintained by dealer and out of the blue, started bucking intermittently while driving resulting in an unsafe driving experience. took it to the dealer to evaluate, told us, "They could change the transmission fluid and filter to see if that fixes the problem." they were not sure that would fix the issue. After researching issue, saw there were numerous complaints about the transmission in the 2018 crosstreks. Call a professional transmission shop and will be making an appointment with them in the near future. They told me (and I found out through my own research) if is was the transmission filter and fluid, it would act up all the time, not just intermittently. And... the dealer wanted to charge me $665 to change the filter/fluid and not sure it would fix the problem, seriously? so now I have to wait and see what the transmission shop says. I have also seen post about the ignition box also gives issues, so who knows, maybe it is the ignition cutting out causing it to "buck" every here and there. Either way, the vehicle is unsafe to drive and could potentially cause a major accident if the transmission locks up or the ignition totally cuts out. Should be a recall either way and Subaru should be responsible for it. This is nothing we have done that could've prevented this issue.

NHTSA complaint #11718031 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

The front windshield spontaneously developed a crack about 5 inches long which later suddenly increased to about 15 inches in length. It is our understanding that this problem has occurred in the windshields of other Subaru models. The internet states that Subaru windshields have had a tendency to crack without impact due to the windshield's angle or thinness to accommodate Eyesight technology.

NHTSA complaint #11700276 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

All four tire pressure monitoring sensors failed on my 2018 Subaru Crosstrek at approximately 69,000 miles. The TPMS light remains illuminated, and the system no longer provides low-tire-pressure warnings. Subaru of America acknowledged the issue but declined full repair coverage, offering only partial “Goodwill assistance.” Because TPMS is a federally mandated safety system, a full-system failure poses the risk of operating the vehicle without tire-pressure warning capability. The dealership quoted approximately $1,000 to restore the system. Subaru’s decision to deny full coverage leaves the safety defect uncorrected.

NHTSA complaint #11697529 — an unverified report by a vehicle owner.

SEATS

Driver seat has came loose from its structure, this has been reported by many other owners, the seat track fail and the seat rock back, hopefully it don't fall off track while driving and injure someone, VERY UNSAFE! the other SAFETY issue with our Subaru is the Infotainment system goes on and off intermit with no warning while driving and radio goes on HIGH VOLUME creating health and HEARING damage, very unhealthy for anyone in vehicle when this happens, Dealership says there is no recall for these items, well there should be, let's keep AMERICA safe again, thanks!

NHTSA complaint #11680430 — an unverified report by a vehicle owner.

LANE DEPARTURE: BLIND SPOT DETECTION

Driver seat has came loose from its structure, this has been reported by many other owners, the seat track fail and the seat rock back, hopefully it don't fall off track while driving and injure someone, VERY UNSAFE! the other SAFETY issue with our Subaru is the Infotainment system goes on and off intermit with no warning while driving and radio goes on HIGH VOLUME creating health and HEARING damage, very unhealthy for anyone in vehicle when this happens, Dealership says there is no recall for these items, well there should be, let's keep AMERICA safe again, thanks!

NHTSA complaint #11680430 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

factory alarm is triggered late in the evening while in my garage regardless if vehicle is locked or unlocked

NHTSA complaint #11668419 — an unverified report by a vehicle owner.

ENGINE

I have a 2018 Subaru Crosstrek, I am the second owner, the first owner bought it in 2019, I am having acceleration problems, I have already taken it to two different mechanics, they say it is a problem with the computer, they have already checked and scanned it and they tell me that you have to reprogram the ECM for DTC P1603 / Engine idle drop or stall, when the car accelerates it makes a jerky or knocking noise when I go 15 miles or stop and move forward again the car locks, this only happens when the car is already warm and has been used for about 10 minutes

NHTSA complaint #11647243 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I have had my car jumped twice in the last 7 days. Today I will be replacing the battery with AAA. Is there a recall on my vehicle? I saw an article there is a recall for starting issues and the coils. Please advise. Thank you.

NHTSA complaint #11646465 — an unverified report by a vehicle owner.

POWER TRAIN

I am writing to formally raise a significant safety concern regarding my 2018 Subaru Crosstrek. I recently discovered a malfunction in the transfer case (pictures attached), specifically involving the center differential gear set, which necessitated immediate replacement. This issue first became apparent while driving at low speeds when I heard a loud, distinctive "clunking" noise, indicating a possible malfunction within the transmission. As a precaution, I took the vehicle to my service mechanic for further diagnosis. After thorough inspection, my mechanic at Roberts Auto Shop (invoice attached) promptly identified the transfer case as the source of the problem. Subsequently, I contacted my local Subaru dealership, North Tampa, where I have previously serviced my vehicle, to inquire whether this issue is known to affect earlier models of the Crosstrek. The service manager expressed surprise that this problem occurred in my manual transmission vehicle, noting that it is typically documented in vehicles with CVT transmissions but rarely in manual models. I further inquired about the availability of any extended warranties or safety recalls related to this known issue. The manager informed me that the vehicle's powertrain warranty covers only up to 60,000 miles or five years, both of which I have exceeded, as my vehicle currently has just over 70,000 miles. My primary safety concern arises from the discovery of metal shavings inside the defective transfer case during its replacement. While the amount is currently minimal, there is a significant risk that this could quickly escalate into a complete transmission failure, posing a considerable safety hazard. I am planning to report this issue to Subaru of America for further investigation and would appreciate your assistance in investigating this matter. I also request that Subaru be held accountable for this known defect, particularly given its potential to jeopardize vehicle safety. Thank you for your support.

NHTSA complaint #11640184 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

My car randomly blows white smoke put of the exhaust and supposedly had the PCV valve replaced in Jan 2020 by the Subaru service center. I am noticing drastically lower mileage as more white smoke seems to be coming out of the exhaust and cannot help but feel these are all related.

NHTSA complaint #11617374 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The main head unit display (8") that controls the climate, audio and other control functions as well as the backup camera video feed is poorly made and subject to rapid delamination at edges and center. We reported and showed this problem to a Subaru dealer multiple times in past and they simply indicated it as 'temporary moisture' yet it is NOT moisture related and a design/manufacturing flaw. The car is now out of warranty and the problem only exacerbated with time to point where rear view camera functionality / visibility is impaired ... not ot mention the unsightly look of the main center display. This is a common widespread problem among many Subaru users as reported in various online forums, however, Subaru continues to deny fault/liability with fixing what is surely inferior design/quality on their side.

NHTSA complaint #11607107 — an unverified report by a vehicle owner.

LANE DEPARTURE: BLIND SPOT DETECTION

The main head unit display (8") that controls the climate, audio and other control functions as well as the backup camera video feed is poorly made and subject to rapid delamination at edges and center. We reported and showed this problem to a Subaru dealer multiple times in past and they simply indicated it as 'temporary moisture' yet it is NOT moisture related and a design/manufacturing flaw. The car is now out of warranty and the problem only exacerbated with time to point where rear view camera functionality / visibility is impaired ... not ot mention the unsightly look of the main center display. This is a common widespread problem among many Subaru users as reported in various online forums, however, Subaru continues to deny fault/liability with fixing what is surely inferior design/quality on their side.

NHTSA complaint #11607107 — an unverified report by a vehicle owner.

BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING

The main head unit display (8") that controls the climate, audio and other control functions as well as the backup camera video feed is poorly made and subject to rapid delamination at edges and center. We reported and showed this problem to a Subaru dealer multiple times in past and they simply indicated it as 'temporary moisture' yet it is NOT moisture related and a design/manufacturing flaw. The car is now out of warranty and the problem only exacerbated with time to point where rear view camera functionality / visibility is impaired ... not ot mention the unsightly look of the main center display. This is a common widespread problem among many Subaru users as reported in various online forums, however, Subaru continues to deny fault/liability with fixing what is surely inferior design/quality on their side.

NHTSA complaint #11607107 — an unverified report by a vehicle owner.

SEATS

The driver seat has been rocking back and forth a bit for a for a couple of weeks and lately started rocking a lot, enough that it rocks back while accelerating and rocks forward while braking causing unintentional excessive breaking. This feels like a safety issue. This is a 2018 car and my previous car (Audi A4) that I had for 14 years never had such a thing ever happen, so this is not normal. Here's a video of the rocking: [XXX] I called the dealer (Eastside Subaru, Kirkland WA, phone: (425) 820-8993) to see if there are any safety recalls about it but they said there are not any, and they are not providing priority appointment to inspect/fix even though I told them . I feel there should be a recall for this .. if the seat breaks while driving, it can cause accidents. A google search reveals a few others complaining about it as well. [XXX] Can you please look into this issue, and if you also feel it is a safety problem, ask Subaru to investigate, recall and fix? Thanks, INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11600484 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I was driving to a friends house . When the engine started sputtering billowing blue smoke , the engine just stopped . I had it towed to my mechanics shop.maui fix auto 808-877-3731 Wailuku Maui Hawaii . He told me engine failed , extended warranty thru geico would not cover. I work as the equivalent of a park ranger. For the state of Hawaii being a first responder this is techically my 3 Subaru purchased from the dealer . This vehicle died at 60,000. Miles and 5 years I bought this car for reliability , to get to work and respond asap . My car is dead I wish some one in Subaru had “love “ like they do in commercials. I need help fixing my car please .

NHTSA complaint #11598100 — an unverified report by a vehicle owner.

ENGINE

I was driving to a friends house . When the engine started sputtering billowing blue smoke , the engine just stopped . I had it towed to my mechanics shop.maui fix auto 808-877-3731 Wailuku Maui Hawaii . He told me engine failed , extended warranty thru geico would not cover. I work as the equivalent of a park ranger. For the state of Hawaii being a first responder this is techically my 3 Subaru purchased from the dealer . This vehicle died at 60,000. Miles and 5 years I bought this car for reliability , to get to work and respond asap . My car is dead I wish some one in Subaru had “love “ like they do in commercials. I need help fixing my car please .

NHTSA complaint #11598100 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The passenger window switch on the drivers side door panel is loose and is jammed (will not depress). Nearly impossible to get passenger window to go down.

NHTSA complaint #11589529 — an unverified report by a vehicle owner.