111 of the
8,703 complaints filed about the Subaru Forester
are about the wheels —
1% of everything owners reported.
The worst model year for it is 2015.
The contact owns a 2016 Subaru Forester. The contact stated that while driving 65 MPH, there was an abnormally loud sound coming from the rear wheels of the vehicle. No warning light was illuminated. A dealer was contacted. The vehicle was taken to a dealer, where it was diagnosed and determined that the hub bearing needed to be replaced. The rear driver’s and passenger’s side hub bearings were replaced twice. The manufacturer was not notified of the failure. The failure mileage was 110,000.
NHTSA complaint #11757935 — an unverified report by a vehicle owner.
Noticeable noise after oil change and tire rotation that became progressively worse over time. Constant humming/growling noise from the rear that increases in volume and intensity with speed. Noticeable at 40 mph and higher and floor vibration present at highway speed, especially under the dead pedal. Droning propeller sound. Upon inspection, both rear hub bearing units were failing prematurely and were replaced at 29,240 miles at no cost under the factory warranty.
NHTSA complaint #11757616 — an unverified report by a vehicle owner.
When I drove the car, All most all light on the dashboard are on onthe road, and when I stop and tried to go, the car is somewhat not controled. I immidieatly went to dealership and dignosed P2764 CVT balve problem. And they add wheel bearing is problem. Subaru noticed these problems but my 88,278 mile 2016 forester has all the lights on and it was very scared and it took 4400 dollars for fixing.
NHTSA complaint #11754563 — an unverified report by a vehicle owner.
2 REAR WHEEL BEARINGS FAILED ON LOW MILAGE VEHICLE.ALTHOUGH CAR IS 10 YEARS OLD IT IS WELL MAINTAINED AND HAS 57K MILES ON OD.nEVER DRIVEN OFF ROAD OR IN WATER. PERHAPS WORSE THREE STUDS AND LUGS HAD TO BE REPLACED DUE TO SNAPPING OFF. APPARENTLY THIS IS COMMON AS THE SAME STORY WAS TOLD TO OTHERS WAITING AT DEALERSHIP
NHTSA complaint #11745979 — an unverified report by a vehicle owner.
I had a tire rotation at my Subaru dealer in 12/2024. Two weeks later I had a flat and could not break two lug nuts. Tire repair dealer found that the lug bolts had been stripped. I had the remaining lug bolts examined by the dealer and a 3rd was found stripped. All three had to be replaced. I underwent tire rotation on 12/11/2025 and dealer found a fourth lug bolt stripped which needed replacement. I was assured this was not the fault of the mechanics and was instead told that this was a manufacturer problem with the lug bolts. If this is true, there are a host of Subaru's out there with lug nuts that cannot be user removed to repair a flat. Although when stripped, the lug nuts are apparently firmly attached, does this represent a wheel / tire failure issue? Thanks for your attention.
NHTSA complaint #11707014 — an unverified report by a vehicle owner.
Wheel studs are of inferior quality, which leads to galling. Replacement of a wheel results in snapped studs. I have replaced three so far on two occasions within a week. Swapping to a spare in an emergency with broken studs will leads to accidents. As of now, I will need to drive with one broken stud to get it fixed. This is a known issue, the lugs were not over-torqued. The softness of the threads results in galling such that the threads tear out and fuse to the lug nut. How they have not issued recall/replacement/upgrades is astounding.
NHTSA complaint #11671436 — an unverified report by a vehicle owner.
I purchased a brand new 2025 Subaru Forester Wilderness and immediately noticed a persistent vibration in the steering wheel, seat, and footwell area. The vibration is present at all times — while driving at various speeds and even while idling. It is very distracting and uncomfortable. This ongoing vibration creates a constant sensation of movement that affects my comfort and ability to stay fully focused on the road. I have arthritis in both hands, and the steering wheel vibration causes physical discomfort, pain, and fatigue, especially on longer drives. I previously owned a 2024 Subaru [same model], which did not have this issue. I have also spoken with other owners of the 2025 model who are not experiencing this problem, so I do not believe this is typical for the vehicle. Subaru of America sent an engineer to inspect the vehicle, but the evaluation was limited to measuring vibration levels. He did not place the vehicle on a lift or inspect any physical components, such as the suspension, wheels, or drivetrain. Despite this limited assessment, he concluded the vibration was “normal.” I respectfully disagree with this conclusion, as the vibration significantly affects the drivability, comfort, and confidence I feel while operating the vehicle. I am reporting this issue because I believe it may indicate a defect that deserves further investigation.
NHTSA complaint #11665933 — an unverified report by a vehicle owner.
The wheel hub bolt stud and nut freeze/lock up. They break apart when the technician attempts to remove to perform tire rotation. It is a common problem with the Subaru Forester. I have had to replace 2, so far. Dealer charges $200+ for replacing it. Subaru has not stepped up to take responsibility for the defect.
NHTSA complaint #11662791 — an unverified report by a vehicle owner.
Bought 2025 Subaru Forester in January 2025. Within 300 miles of driving brought it back to place I bought it, complained about constant vibraton in Sterring wheel at high speeds around 55 - 65 MPH. They said the wheels were out of balance, they re balanced them and the problem was resolved, BUT IT WASN'T. I brought it back to them At 600 miles they looked it over and took it for a ride they said they did NOT feel the wheel vibration. I said how could you NOT feel it. I brought it back a 3rd time at 800 miles. They took it for a ride with me in passanger seat . Even as I told them I could feel it in armrest they still said they did not feel it. I opened a case with Subaru of America Advocates. they advised me to take it to a different dealer which I did. The second dealer acknowledge the wheel vibration at high speeds. They had my SUV for about 10 days they tried several different brands of tires . They same result happended . Then they said one brand of tires the vibration was less but it is NOT less it is about the same. They are trying to get me some new tires but I don't think it is the tires. THe supension has been looked over by both Subaru dealers. They say it is safe to drive. BUT IT STILL VIBRATES it is NOT just road noise. I just want the vehicle fixed properly.
NHTSA complaint #11656309 — an unverified report by a vehicle owner.
First was a control arm bushing and than a rear wheel hub assembly. At around 40000 miles. Both failures created unsafe control of the vehicle. Subaru has a tsb with updated parts, so they know the original are poor quality. It has been confirmed with dealer and independent shops. No warning lamps.
NHTSA complaint #11654898 — an unverified report by a vehicle owner.
Got a notification about a Subaru forester recall for my vehicle VIN that is not being listed on your website regarding my wheels. Subaru OF America, Inc. (Subaru) IS Recalling Certain 2025 Forester Vehicles Equipped With 18" Aluminum Alloy Wheels. THE Wheels MAY Have Been Manufactured With AN Incorrectly Specified LUG Seat Surface, Which CAN Result IN THE Wheel Being Improperly Attached and Cause A Loss OF Vehicle Stability. Consequence A Loss OF Vehicle Stability Increases THE Risk OF A Crash. Remedy Dealers Will Inspect and Replace THE Wheels, AS Necessary, Free OF Charge. Owner Notification Letters Were Mailed February 28, 2025. Owners MAY Contact Subaru Customer Service AT 1-844-373-6614. Subaru's Number FOR This Recall IS Wrb-25.
NHTSA complaint #11649936 — an unverified report by a vehicle owner.
Premature wear on Bridgestone Ecopia Tires. We have had several instances in our company with these tires wearing prematurely, some as low as 12k miles but usually somewhere in the 20's & 30's thousand-wise, these tires exhibit numerous cracks especially on the inner side that is difficult to see unless you pull the tires off. A lot of WEB chatter indicates that they are especially vulnerable in cold weather states. We've informed Subaru several times but are often hushed since they fear a major Recall.
NHTSA complaint #11643956 — an unverified report by a vehicle owner.
We have had numerous problems with the wheel lug stems on this car. One issue was very serious. We were driving from New Jersey down to Florida, and two of the lug stems snapped off.. we had to have these replaced in South Carolina. I’ve looked on many websites and this is a well known problem with the 2016 Subaru Forrester. I don’t know why you do not think this is a big safety problem as losing a wheel driving at 70 miles an hour on [XXX] is very serious. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11641195 — an unverified report by a vehicle owner.
The Vehicle was sold to me by a local dealership not SUBARU Manufacturer themselves with the conditions marked above and more, the wheels when purchased as i turned any corners it would sound like the underside of the vehicle would explode even when driving straight it was just less frequent and caused the ABS system to activate and would pull one way or another. the Transmission has never been inspected by the dealership that sold it to me and the manufacturer seal was broken so it had leaked and caused major lack of power resulting in many close calls due to lose of forward propulsion it is a closed transmission without a dip stick and the dealership refused to do anything about it. the Airbag system has never worked at all and the dealership knew this and same with the Reverse hazard warning detection system or the TPMS and again i was told that i just needed to drive it and it would work itself out by the owner of the dealership who test drove it 3 times and refused to do anything about the obvious issues and now it has been a little over a year i’m in debt and basically out of a vehicle and can man as well as personal money sunk into this vehicle that I would consider beyond a lemon
NHTSA complaint #11638241 — an unverified report by a vehicle owner.
Wheel lug nuts are frozen and cannot be removed without breaking the stud in many cases. TSB 05-79-20 mentions that Subaru was aware but offers no warranty for this issue.
NHTSA complaint #11628536 — an unverified report by a vehicle owner.
When the car accelerates to around 70 mph, the right front side starts to shake and vibrate, giving the impression of driving on a bumpy road. The issue becomes noticeably worse when changing lanes to the right. Both wheel alignment and tire balancing have been checked and found to be fine. After researching online, many Subaru owners have reported similar issues caused by problems with the lower control arm or wheel bearing, leading to shaking at high speeds. However, when contacting Subaru of America about this, they declined responsibility, citing an expired warranty.
NHTSA complaint #11626190 — an unverified report by a vehicle owner.
My wife's Subaru Forester (2017, VIN [XXX] ) at 70,131 miles started to have a loud droning sound from the rear of the vehicle on [XXX]. I took the SUV to a local mechanic, and they diagnosed the problem as two faulty rear wheel bearings. They removed the old bearings on September 4, 2024 (I have the faulty parts if needed) and placed new bearings. The mechanic warned me that the faulty wheel bearings can seize and cause an accident if they are not replaced. The repair resulted in the disappearance of the droning sound from the rear of the car, so it was clearly a correct diagnosis. In looking online, I have learned that many 2017 Subaru Foresters have a problem with rear wheel bearing failures. The company has expressed no interest in my concern about this incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11621046 — an unverified report by a vehicle owner.
My wife’s 2015 Subaru Forester is reported to have a bad rear driver side wheel bearing from our mechanic. She only has 58,464 miles at the time of the incident/ diagnosis. I believe this wheel bearing has prematurely failed. We both drive normally and are not reckless. Please look into the batches/ lot# of the wheel bearings that went into their vehicles around the 2015 models and who makes them. Even multiple manufacturers or mixed batches being installed into new vehicles. They refuse to cover this as our new vehicle warranty has expired.
NHTSA complaint #11619479 — an unverified report by a vehicle owner.
Upon getting a flat tire on the front passenger side tire, two of the vehicles wheel studs and lug nuts were seized together and broke off when using hand tools to remove the lug nuts. The metal was extremely soft and broke off easily. All 5 lugs and nuts needed replacement.
NHTSA complaint #11604646 — an unverified report by a vehicle owner.