2021 Subaru Outback other reported problems

UNKNOWN OR OTHER

I am reporting a serious and intermittent steering safety issue with my 2021 Subaru Outback. On two separate occasions, the vehicle suddenly lost what appeared to be power-steering assistance while the vehicle was in motion, causing the steering wheel to become extremely difficult to turn. The first incident occurred while I was driving on the highway and going down a ramp. The steering suddenly became extremely difficult to operate and a warning symbol illuminated on the dashboard. I was able to maintain enough control of the vehicle to safely pull over to the side of the road. I turned the vehicle off and restarted it, and the warning light disappeared and normal steering operation returned. The second incident occurred while I was making a turn into a neighbor. The same problem occurred: the steering suddenly became extremely difficult to turn and a warning light appeared on the dashboard. After turning the vehicle off and restarting it, the steering returned to normal. The intermittent nature of this problem is concerning because restarting the vehicle temporarily restores normal steering, but the failure has now occurred more than once without warning. One of the incidents occurred while traveling on the highway, creating a significant risk of loss of vehicle control and a collision. I am concerned that this may involve the vehicle’s electric power-steering system or related electrical components. I am reporting this to NHTSA because a sudden loss of steering assistance while a vehicle is moving presents a serious safety risk, particularly while turning or traveling at highway speeds. I am requesting that NHTSA document this complaint and evaluate whether similar steering failures have been reported by other owners of 2021 Subaru Outback vehicles.

NHTSA complaint #11757279 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

My 2021 Subaru Outback suffered a failure of the Oil Control Valve (OCV), a sealed Subaru component with no maintenance interval, no inspection procedure, and no preventative service. This failure allowed engine oil to migrate into multiple wiring harnesses and modules, causing extensive electrical contamination. This is not normal wear and tear. It is a latent defect in a Subaru component. Due to the failure of this sealed component the Subaru dealership and a second independant shop have recommended replacing the entire electrical wiring harness at over and estimated $15,000. Even if the entire harness is repalaced the extensive contamination may find its way into electrical connectors even after replacement of the harness. The fact that this contamination was so wide spread, and there were absolutly no warnings that indicated the widespread contamination is alarming. I guess the thought is that different electrical components could just stop working. This seems like a serious safety concern. It is impossible to know how long the contamination was spreading through the car since there are no errors or warnings that indicated an issue.

NHTSA complaint #11754037 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

First battery drain in car. Bought a new battery and it drained again for the second time. Called Suburu to ask about a parasitic drain from the DCM and they said it was likely that and told me to call Suburu America. Did that but they wanted me to take it to a Suburu dealer to get the problem verified. I don’t have the $ to do that. I notice there is a class action in court right now for this exact problem.

NHTSA complaint #11744188 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The battery zapped out in December of 2024 in the wintertime and left me stranded. Subaru towed it the next morning and replace for free only bc I mentioned the previous law suit but the battery issue is the same

NHTSA complaint #11736398 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I am filing this complaint regarding multiple serious safety defects in my 2021 Subaru Outback purchased in July 2021, currently at 48000 miles THERMO CONTROL VALVE FAILURE (26,307 miles) While traveling in the center lane on [XXX] southbound in [XXX] the evening of 1/6/2024 my vehicle suddenly experienced a complete loss of control. It seemed that the car was accelerating and braking at the same time without driver input making it impossible to operate safely. It started shaking and several lights were illuminated on the dashboard, power steering was not working. The car coasted to the right shoulder and starlink was used to call for help. The car was towed to the dealership for repairs. The diagnosis was a failed thermo control valve and related sensor circuit. There were no dashboard lights before the incident that fore shadowed this event. This failure rendered the vehicle completely inoperable at highway speed and posed and extreme risk to the safety of the driver, passenger and other motorists. I am aware that Subaru has extended the warranty on the thermo controls valve to 15 years/150000 miles for 2020-2022 Outback’s which suggests that Subaru had knowledge of the defect. Since the incident several other premature “wear” defects have presented under 48000 miles on a 2021 vehicle: - 41,402 miles: driver side rear strut replaced - 41,402 miles: rear brake pads and rotors - 41,402 miles: driver side front window motor, regulator and run Chanel - 41808 miles: rear knuckle assembly, rear wheel bearing and backing plate replaced - 45,768 miles: front brake pads and and rotors replaced - 48,000 miles: complete exhaust system - 48,000 miles: passenger side front window motor, regulator and run chanel This vehicle has proven to be uncharacteristically unreliable for a Subaru Outback. The intended use for this vehicle is for my children to drive to college nearly 600 miles from home in the fall. This car is not appropriate for this purpose. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

NHTSA complaint #11735647 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

This 021' outback XXX purchased in 023'/ 24k Mi Freehold subaru. freehold NJ 'if purchased new would've been on the desk of a local lemon law attorney by now. Over the few years the lock unlock function of key fobs stubbornly, randomly & repeadedly dont work. Freehold subaru saw no problem. Front passenger window months ago wouldn't go up. Freehold subaru supposed repaired at a cost to me. Recent cold weather with a brand new battery of 6 Mos old rendered the car unable to start or boost. Vehicle towed to Freehold tire center st freehold NJ, replaced a $400 battery. brought the 6 mo. old battery back to auto zone who load tested and advised nothing Wrong w battery? Not to mention the sub standard BS feature of coming to a stop, foot on brake & engine stopping-starting when proceeding? this is something of concern of being rolled over by an approaching truck in the rear of this 021' outback because 3 times when stopping at a red light the engine shut off and when proceeding, foot off the brake the engine wouldn't re-start & all the indicators on instrument cluster lit up, had to restart the car. Recent event where my wife, [XXX] old legally disabled- primary driver comes out of a store, starts the outback, puts in reverse to back out of a spot and the car dies. This vehicle is being brought into Freehold subaru south st. Freehold NJ Tues morning Apr. 21st 026' south st and is not being picked up due to it being unsafe to operate. Until all the issues are corrected. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11732036 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I was stopped at a stop sign and the car shut off as the auto on/off function. When I went to drive the car did not re-start as the battery needed replaced. I was left stranded in an intersection. The battery did need to be replaced. The auto start/stop feature is a saftey hazzard on any vehicle

NHTSA complaint #11697533 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Sunroof exploded driving home in 90 degree sunny and clear weather. It sounded like a gun went off right over my head. It scared me so bad I jerked my steering wheel into the other lane. Thank God no one was in that lane. I had to get it replaced at Mid State Glass company. according to what I found on the internet this happens rather frequently. No notification by Subaru that this was even a possibility. I have the receipt the replaced sunroof and photos of the sunroof after it exploded.

NHTSA complaint #11690946 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

SUDDEN AACCELERATION: Cold started the car in garage, all OK. Then backed out and into turn around where I placed foot on the brake. At that moment suddenly accelerated and engine revved to 2000rpm (sounded like). I had to push down very hard on the brake pedal (where my foot already was) to stop the car before crashing into a tree. Foot was clearly on brake pedal at incident (that was the only way I could stop the car). It was not on or close to accelerator pedal and no floor mat or other objects was on or near the accelerator pedal. Very concerned about safe vehicle with this sudden acceleration. Appointment with Subaru dealer made for full diagnostic check. Dealer is White Bear Subaru, [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11689866 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The rear driver side window shattered while I was driving. There was no outside influence, and I was driving around 35-40 miles/hour. I am reporting this because Subaru had the same incident happen multiple times on another model of their vehicles. If there was anyone sitting in the back, they would have most likely been injured.

NHTSA complaint #11662765 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Purchased used with just over 60k miles & have had less than a year. Vehicle still under 80k miles. Told transmission needs replaced but found service records from previous owner which shows fuel pump replaced twice at about 20k mile intervals & I am just under 20k miles past previous pump replacement. Vehicle does not run at the moment & warranty company refusing to help.

NHTSA complaint #11654281 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The auto restart does not work and requires a car restart to fix. The latest software update caused this is to happen.

NHTSA complaint #11614261 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Today while waiting at a stop light the auto start stop engaged. When the light went green I put my foot on the gas and the vehicle stalled. The car was on but not running, several alarms were on the dashboard. I had to put the car in park, turn it off and then restart the car. This is a repeated issue and has been going on at least once a month since we purchased the car in 2021. We've brought it to the dealer and they said there was nothing wrong because there was no OBD code. I have checked myself and I have not found any code. This is extremely unsafe

NHTSA complaint #11608885 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

2021 Subaru Outback Limited | ~13000 miles | Component: Battery | Car suddenly stopped and ALL warning lights started flashing at a busy traffic signal, while I was waiting to take a left turn (lucky to have escaped safely from that situation). I had to turn the car off and restart it. 2 days later, the car would not start at all. Tried jumping it multiple time in vain. Had to tow the car to the nearest Subaru service center. Technician ran a diagnostic and concluded that the battery was not holding any charge at all and it was deemed faulty. Reading many posts on reddit and other forums of many Subaru owners facing the same issue from older (2015) to newer models. Many of them also complained of Parasitic drain on the battery due to faulty DCM on Starlink. Note: there was no warning lights/messages or any other symptom before this. This was a Subaru certified pre-owned car that went through a 152 point inspection in 2023.

NHTSA complaint #11607996 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Front windshield on my 2021 outback has numerous large cracks for no reason. This is a known issue via Google and class action law suits for windshields. This is a safety issue and needs to be addressed. I emailed Subaru and filed a complaint with them, Case#240708-220236. Asking them to replace windshield with new one that won't crack like this one. i have photos if needed.

NHTSA complaint #11600428 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

On[XXX] while accelerating to travel speed (45 mph) on a rural Maine highway, the little used glass moon roof of our 2021 Subaru Outback Touring with 24,100 miles on the odometer exploded with a huge, shocking BANG!. Weather was clear and bright, wind ~5 mph, temperature about 68ºF, no traffic. We never saw or heard anything strike the car, either from the road or falling down from the trees at or prior to this incident. We had the interior shade closed so no glass fell into passenger compartment thankfully. Upon inspection at the road side and discovery of the problem, the glass panel had a large hole in the middle and the edges of the remaining glass looked like it had been blown upward. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11591890 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Windshield breaks way too easy. Rock chips happen easily, then they spread across the whole windshield. I am on my 2nd one and this one needs to be replaced too.

NHTSA complaint #11587146 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The windshield is very light and delicate. I have had two cracked windshields in less that two years, Also, the glass is so soft that it gets tons of micro-pits from sand. At night they each disperse lights and make it difficult to see.

NHTSA complaint #11581651 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Defective windshield. Car purchased in 6/2021 and as of 2/16/24, windshield has been replaced 3 times which would make it my 4th windshield total. No off-road use. Car driven locally. Insurance is dropping me due to excessive windshield replacement.

NHTSA complaint #11572331 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I have had 3 windshields crack spontaneously during normal use in the past year. Each incident was repaired by a certified repair shop and at time the damage was noticed, no chips, signs of damage, or impacts were noted. The crack appeared to be internal and was not able to be felt from outside or within. In each incident the crack began near the edge of the glass and spread across the entire length of the windshield. The most recent was 12/27/2023, the approximate dates of the previous are 12/2022, and 03/2023. All three occurred in periods of clear weather, no ice, or snow present, although all three occurred in the cold, while parked outside overnight either at work or home.

NHTSA complaint #11562714 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

While my husband was driving up a hill at low speed (25-30miles/hr) the car lost power, struggled and felt like it was going to stall. 5 days later, I was driving up a hill going 25miles/hr, the car lost acceleration the stalled, was unreponsive to gas pedal being depressed, the car then started again on its own. I brought the car to Subaru but they couldn't find anything wrong. Luckily nobody was behind me when the car stalled.

NHTSA complaint #11559703 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The windshield has spontaneously cracked on 4 separate occasions. Subaru denies this is a defect and claims all have been caused by rock chips. This is not true. The cracked windshield has caused the vehicle on numerous occasions to slam on its breaks while traveling at 55 mph or greater as it “senses” a collision. This has nearly caused 3 accidents so far.

NHTSA complaint #11538618 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I just had my second windshield failure in 2 years on this vehicle. The first time a rock hit me, but today a ~ 12" crack appeared out of nowhere while I was driving down the highway with no impact. The windshields on this vehicle seem overly prone to cracking, whether or not any impact is applied. I'm worried this will interfere with the eyesight functionality.

NHTSA complaint #11529285 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

My windshield has cracked 3 times since vehicle was purchased, the last time within 2 months of replacement. The first 2 times the windshield was replaced by the dealership with OEM glass. There was no visible crack from rocks, etc in the last two incidences...went out in the morning to find that the windshield was cracked across half the windshield after it had been parked and no visible damage had occured beforehand in both cases. ( I have taken pictures of this last incident... insurance notified, but no inspections took place. no warning lights, etc appeared pryor to cracks)

NHTSA complaint #11526368 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Both passenger and driver doors leak water onto floor while using the car wash. The dealership has replaced the door moldings but it still leaks.

NHTSA complaint #11517713 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The moonroof glass exploded yesterday in my parking lot. I contacted local dealers and they refused to cover it under factory warranty.

NHTSA complaint #11517236 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Defective windshield. I purchased my Subaru Outback XT from the Subaru dealership in Shoreline, Washington in October 2020. Since then, the windshield has cracked 4 times beyond repair. Each time, a small hairline fracture develops and quickly spreads across the windshield until the windshield has to be replaced. I have taken the car to the Subaru dealership each time to replace the windshield. The car remains under warranty. I reached out to Subaru of America after the windshield cracked for the 4th time, but I was told that the crack was a result of "outside influence". I have never had a car windshield crack until I purchased the Subaru, and 4 cracked windshields in about 2 years is beyond excessive. After doing additional research online, it appears that this is a frequent and ongoing issue with newer Subaru models possibly because the windshield used now is of a thinner material.

NHTSA complaint #11512862 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The front windshield of my vehicle cracked excessively after being hit by a pea sized piece of gravel while traveling less than 50 MPH. I felt that the safety of my family was put at risk as the crack quickly spread to over 8 inches in length by the end of that same day.

NHTSA complaint #11508205 — an unverified report by a vehicle owner.