Owners have filed 123 complaints
about the 2020 Tesla Model S with NHTSA between 2020 and 2026.
The largest single group is the driver assist & collision avoidance.
Across this model's run it ranks 7 of 13 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 15
Against the median year of the Tesla Model S. 50 means typical for this
model; 100 means roughly double.
Severity — 100
26% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
97% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Adaptive Cruise Control
1434.1%
Automatic Emergency Braking
1126.8%
Warnings
512.2%
Body
512.2%
Warning
24.9%
Latch
24.9%
Autonomous/Self Driving
12.4%
Warnings
12.4%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
1030.3%
1,000 – 9,999 miles
1648.5%
10,000 – 24,999 miles
39.1%
25,000 – 49,999 miles
39.1%
75,000 – 99,999 miles
13.0%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jun 2020peak 10May 2026
NHTSA investigations into the 2020 Tesla Model S
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
5
investigations are
still open.
EA26002Opened 18 Mar 2026Still openELECTRICAL SYSTEM:ADAS
FSD Collisions in Reduced Roadway Visibility Conditions
The Office of Defects Investigation (ODI) is opening this Engineering Analysis to evaluate Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) degradation detection system. The focus of this investigation will be to assess the system’s ability, when encountering reduced roadway visibility conditions, to detect degradation and alert the driver with sufficient time to respond. ODI will evaluate the performance of FSD in degraded roadway conditions and the updates or modifications by Tesla to the degradation detection system, including the timing, purpose, and ca...
PE25012Opened 7 Oct 2025Still openELECTRICAL SYSTEM:ADAS
Traffic safety violations while Full Self Driving ("FSD") is engaged
The Office of Defects Investigation (“ODI”) is opening this Preliminary Evaluation (PE) to assess the scope, frequency, and potential safety consequences of FSD executing driving maneuvers that constitute traffic safety violations. This investigation concerns versions of FSD that Tesla has labeled as "FSD (Supervised)" and "FSD (Beta)." Tesla characterizes FSD as an SAE Level 2 partial automation system requiring a fully attentive driver who is engaged in the driving task at all times. Level 2 partial automation systems are designed to support and assist the driver in performing certain aspects...
AQ25002Opened 20 Aug 2025Still openELECTRICAL SYSTEM:ADAS
Compliance with Standing General Order 2021-01 Reporting Requirements
The Office of Defects Investigation (“ODI”) has identified numerous incident reports submitted by Tesla, Inc. (“Tesla”) in response to Standing General Order 2021-01 (the “SGO”), in which the reported crashes occurred several months or more before the dates of the reports. The majority of these reports involved crashes in which the Standing General Order in place at the time required a report to be submitted within one or five days of Tesla receiving notice of the crash. When the reports were submitted, Tesla submitted them in one of two ways. Many of the reports were submitted as part of a si...
The Office of Defects Investigation (ODI) is opening a Recall Query to assess the remedy adequacy of Recall 23V838. On December 12, 2023, Tesla filed a Defect Information Report (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot system, which Tesla described as an SAE Level 2 (L2) Advanced Driver Assistance System (ADAS). Autopilot is the simultaneous engagement of Tesla’s Traffic-Aware Cruise Control (TACC) and Autosteer. In describing the safety defect, Tesla’s Defect Information Report (DIR) explained that “the prominence and scope of the...
DP23002Opened 29 Jun 2023Still openVEHICLE SPEED CONTROL
Sudden Unintended Acceleration
The Office of Defects Investigation (ODI) received a petition requesting that ODI reevaluate its decision to deny DP20-001 on the basis that intermittent high electrical current demands on the vehicles' 12VDC systems may have caused some or all of the incidents examined by ODI in DP20-001. The petitioner bases this information on a review of open-source research and the DP20-001 denial. The petition and related materials can be reviewed at NHTSA.gov under the following ODI number: 11528471.
PE24033Opened 6 Jan 2025Closed 3 Apr 2026ELECTRICAL SYSTEM:ADAS:AUTONOMOUS/SELF DRIVING
Actually Smart Summon sessions resulting in low-speed impacts.
On January 6, 2025, the Office of Defects Investigations (ODI) opened Preliminary Evaluation 24003 (PE24033) to investigate Actually Smart Summon (Summon) sessions resulting in crashes during active sessions. According to Tesla, Summon is a short-distance SAE Level 2 system, controlled by the user from a cell phone within a certain distance and intended for use in parking lots and on private property. ODI analyzed complaint data provided by Tesla as well as complaints submitted to ODI from consumers to identify Summon incidents resulting in crashes. ODI's analysis indicates that almost all Sum...
PE24031Opened 17 Oct 2024Closed 18 Mar 2026ELECTRICAL SYSTEM:ADAS
FSD Collisions in Reduced Roadway Visibility Conditions
On October 17, 2024, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24031) of Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) to assess: the ability of the FSD system to detect and respond appropriately to reduced roadway visibility conditions; whether any other FSD crashes had occurred under degraded roadway visibility conditions that are similar in nature to the four SGO-reported crashes identified in the opening document, and if so, the contributing circumstances for each of those crashes; and any updates or modificatio...
DP23001Opened 7 Apr 2023Closed 18 Mar 2026UNKNOWN OR OTHER
Defect Petition Interlock Request
On March 21, 2023, the Office of Defects Investigation (ODI) received a petition requesting a “recall of all Tesla cars” produced from 2013 to the date on which the petition was filed due to what Petitioner considers to be the increased likelihood of pedal misapplication. Attached to the Petition is a paper authored by Petitioner. According to Petitioner, the differences in the operator controls between the subject Tesla vehicles and internal combustion engine powered vehicles promote driver pedal misapplication, leading to sudden unintended acceleration (SUA) incidents. To fix this alleged de...
Recalls on the 2020 Tesla Model S
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
24V376000
SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Risk: A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Risk: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
24V051000
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Risk: Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
Risk: In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
23V085000
STEERING:AUTOMATED/ADAPTIVE STEERING
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
Risk: FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
22V818000
STEERING:ELECTRIC POWER ASSIST SYSTEM
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S and Model X vehicles. The electronic power assist steering (EPAS) system may experience a loss of power steering assist when driving on rough roads or after hitting a pothole.
Risk: A loss of power steering assist can require greater steering effort, especially at low speeds, increasing the risk of a crash.
22V235000
ELECTRICAL SYSTEM:SOFTWARE
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Risk: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
22V063000
ELECTRICAL SYSTEM:SOFTWARE
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Risk: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2024283109,791 units in Canada
Lights And Instruments
Issue: A previous over-the-air (OTA) software update could cause the vehicle not to display the correct visual warning indicators when there are problems with the brake system or when the parking brake is applied. As a result, the BRAKE, PARK, and antilock brake system (ABS) visual indicators would display as text instead of symbols. Safety Risk: While there is a low risk to safety, Canadian regulations require visual warnings to use common symbols, instead of words, to avoid driver confusion. Corrective Actions: Tesla will notify affected owners by email. Tesla has released an over-the-air software update to fix this problem. There is no further action required if your vehicle has software release 2024.3.25, 2024.14.5, or a release later than 2024.14.5.
Recall 2024130340 units in Canada
Other
Issue: On certain vehicles, a software problem could cause the pedestrian warning system not to work. As a result, the vehicle may not produce enough sound to be detected by other road users. New Canadian regulations require electric vehicles to make a minimum sound level when operating at low speeds. Safety Risk: A pedestrian warning system that doesn't work could create an increased risk of injury for other road users. Corrective Actions: Tesla will notify affected owners by email. Tesla has released an over-the-air software update to fix this problem. There is no further action required if your vehicle has software release 2023.44.30.14 or a software deployed after 2023.44.30.14.
Recall 2023657192,769 units in Canada
Accessories
Issue: On vehicles equipped with the Autosteer advanced driver-assistance feature, when using the feature, the vehicle may not provide strong enough warnings or monitor the driver closely enough to prevent misuse of the feature. Safety Risk: A driver that doesn't pay close attention while using the Autosteer feature or who doesn't react quickly when Autosteer is canceled could have an increased risk of a crash. Corrective Actions: Tesla will notify owners by email and supply an over-the-air software update to improve driver monitoring and alerts while using the Autosteer feature. Tesla advises that you must always pay attention and be ready to take control of the vehicle at any time while using the Autosteer advanced driver-assistance feature.
Recall 202306320,667 units in Canada
Accessories
Issue: In certain traffic situations, when the FSD Beta advanced driver assistance feature is engaged, the vehicle may perform maneuvers that break certain traffic laws, if the driver doesn't intervene and take control. Note: This recall only affects vehicles equipped with the FSD Beta feature. Safety Risk: Certain maneuvers performed by the FSD Beta advanced driver assistance feature may break traffic laws. This could increase the risk of a crash if the driver doesn't intervene. Corrective Actions: Tesla will notify owners by email and supply an over-the-air software update to improve how the FSD Beta feature maneuvers the vehicle in certain traffic situations. Tesla reminds that FSD Beta is only an advanced driver assistance feature, and the driver must pay attention and be ready to take control at all times when the feature is engaged.
Recall 20217837,604 units in Canada
Structure
Issue: On certain vehicles, the front trunk (frunk) hood latch may not be positioned properly. As a result, the secondary latch may not hold the hood closed. This could cause the hood to open suddenly while driving if the primary hood latch is released. Safety Risk: A hood that opens suddenly while driving could block the driver's view and increase the risk of a crash. Corrective Actions: Tesla will notify owners by e-mail and arrange for an inspection of the secondary hood latch. If the hood doesn't latch properly, Tesla Service will reassemble and reposition the latch mechanism.
Recall 202049749,984 units in Canada
Lights And Instruments
Issue: On certain vehicles, when switching the distance display setting from kilometers to miles, the speedometer displays the vehicle speed in miles per hour (mph) only. Canadian regulations require that speed be displayed in either kilometers per hour (km/h) or in both km/h and mph. Safety Risk: This small error does not affect vehicle safety. Corrective Actions: This is not a recall. Tesla has made changes to ensure that all new vehicle speedometers display mph and km/h when the display distance is set to miles. In addition, this change was sent to all vehicles in firmware update 2020.36.11.
Recall 202043518,187 units in Canada
Lights And Instruments
Issue: Certain vehicles do not have the correct warning indicator to show when the passenger airbag is turned off. Recent changes to Canadian regulations require all companies to use a symbol to show when the passenger airbag is turned off instead of text. This change can help to avoid confusion. Safety Risk: This small error does not affect the function of the airbag system or the accuracy of the information displayed to the occupant. Corrective Actions: This is not a recall. Tesla has made changes to ensure that all new vehicles display the correct symbol when the passenger airbag is turned off. In addition, this change was sent to all vehicles in firmware update 2020.36.
Reports where the owner recorded a crash, a fire, an injury or a death.
Louisville, KYCrash
UNKNOWN OR OTHER
On 09/18 , I was using the Smart Summon feature of my Tesla Model S in the parking lot of Costco, Greenwood (Indianapolis, IN). The intent was to have the vehicle autonomously navigate from its parked spot toward my location, as designed and advertised by Tesla. During the Summon operation: 1.The vehicle failed to correctly detect and avoid a fixed obstacle (the cart return stand where shopping carts are housed). 2.Instead of stopping or rerouting safely, the car collided with the structure, causing visible damage to the front of the vehicle. 3.While there was no damage to public property or injury to people, the incident demonstrated a serious safety risk, since pedestrians or nearby vehicles could have been struck had they been present. 4.The Smart Summon system did not provide sufficient warning or correction during this event, despite being marketed as capable of safely maneuvering in such environments. This failure shows that the Smart Summon feature did not perform as intended and behaved in an unsafe manner in a real-world public parking environment.
NHTSA complaint #11689122 — an unverified report by a vehicle owner.
Louisville, KYCrash
BACK OVER PREVENTION: WARNINGS
On 09/18 , I was using the Smart Summon feature of my Tesla Model S in the parking lot of Costco, Greenwood (Indianapolis, IN). The intent was to have the vehicle autonomously navigate from its parked spot toward my location, as designed and advertised by Tesla. During the Summon operation: 1.The vehicle failed to correctly detect and avoid a fixed obstacle (the cart return stand where shopping carts are housed). 2.Instead of stopping or rerouting safely, the car collided with the structure, causing visible damage to the front of the vehicle. 3.While there was no damage to public property or injury to people, the incident demonstrated a serious safety risk, since pedestrians or nearby vehicles could have been struck had they been present. 4.The Smart Summon system did not provide sufficient warning or correction during this event, despite being marketed as capable of safely maneuvering in such environments. This failure shows that the Smart Summon feature did not perform as intended and behaved in an unsafe manner in a real-world public parking environment.
NHTSA complaint #11689122 — an unverified report by a vehicle owner.
Louisville, KYCrash
LANE DEPARTURE: WARNING
On 09/18 , I was using the Smart Summon feature of my Tesla Model S in the parking lot of Costco, Greenwood (Indianapolis, IN). The intent was to have the vehicle autonomously navigate from its parked spot toward my location, as designed and advertised by Tesla. During the Summon operation: 1.The vehicle failed to correctly detect and avoid a fixed obstacle (the cart return stand where shopping carts are housed). 2.Instead of stopping or rerouting safely, the car collided with the structure, causing visible damage to the front of the vehicle. 3.While there was no damage to public property or injury to people, the incident demonstrated a serious safety risk, since pedestrians or nearby vehicles could have been struck had they been present. 4.The Smart Summon system did not provide sufficient warning or correction during this event, despite being marketed as capable of safely maneuvering in such environments. This failure shows that the Smart Summon feature did not perform as intended and behaved in an unsafe manner in a real-world public parking environment.
NHTSA complaint #11689122 — an unverified report by a vehicle owner.
Fort Myers, FLCrash
UNKNOWN OR OTHER
Vehicle was tested for concern about self driving after test drive with tech told ok 3 days later Summoned car and immediately turned into adjacent vehicle all captured on video in 1-2 seconds. No issues with summons for over 4 years $2200 damage to adjacent vehicle but Tesla no damage left front wheel caused damage on start.
NHTSA complaint #11641683 — an unverified report by a vehicle owner.
Fort Myers, FLCrash
FORWARD COLLISION AVOIDANCE: WARNINGS
Vehicle was tested for concern about self driving after test drive with tech told ok 3 days later Summoned car and immediately turned into adjacent vehicle all captured on video in 1-2 seconds. No issues with summons for over 4 years $2200 damage to adjacent vehicle but Tesla no damage left front wheel caused damage on start.
NHTSA complaint #11641683 — an unverified report by a vehicle owner.
Henderson, NVCrash
UNKNOWN OR OTHER
While attempting to park car ,the car accelerated on it own despite me hitting the brakes causing the car to hit a wall.
NHTSA complaint #11594303 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Daytona Beach, FL
SEAT BELTS
The vehicle has been taken to Tesla multiple times due to ongoing controllability and safety concerns. The Autopilot system will occasionally brake unexpectedly at green lights or when another vehicle is passing on the right side. The vehicle has also experienced repeated drivetrain issues, including the half shafts failing at least four times within a short period. During acceleration, the vehicle can be difficult to control at times, and the wheels exhibit noticeable vibration. Despite replacing two full sets of tires within two years and completing multiple balancing and service attempts, the issue has not been resolved. These ongoing problems have contributed to premature tire wear and reduced stability, particularly in wet or rainy driving conditions. The vehicle has been serviced by Tesla at least 10 times, and each visit has resulted in replacement of half shafts or other drivetrain components. At one point, Tesla indicated that the drive module was “off center,” though no clear explanation was provided. These issues have been present since the vehicle was purchased in May 2024. In several instances, the vehicle was returned after service without the problem being resolved, requiring additional return visits. More recently, Tesla has suggested the issue may be related to tires and wheels. However, this contradicts earlier assurances that those components were not the root cause. All tires and two wheels have already been replaced, yet the same issues continue to occur. Months go by without any resolution and then when the tires go bad again, they tried to sell me on that when that never resolved the issue. They tried to force me to buy new tires and wheels for $8000 claiming that to be the issue. The main has fell twice in the last year and was replaced with a battery that was not of light kind. When the battery failed at a Tesla supercharger, the door would not open momentarily. I will estimate the date of the last service. Cannot open due to open ticket
NHTSA complaint #11736972 — an unverified report by a vehicle owner.
Daytona Beach, FL
SUSPENSION
The vehicle has been taken to Tesla multiple times due to ongoing controllability and safety concerns. The Autopilot system will occasionally brake unexpectedly at green lights or when another vehicle is passing on the right side. The vehicle has also experienced repeated drivetrain issues, including the half shafts failing at least four times within a short period. During acceleration, the vehicle can be difficult to control at times, and the wheels exhibit noticeable vibration. Despite replacing two full sets of tires within two years and completing multiple balancing and service attempts, the issue has not been resolved. These ongoing problems have contributed to premature tire wear and reduced stability, particularly in wet or rainy driving conditions. The vehicle has been serviced by Tesla at least 10 times, and each visit has resulted in replacement of half shafts or other drivetrain components. At one point, Tesla indicated that the drive module was “off center,” though no clear explanation was provided. These issues have been present since the vehicle was purchased in May 2024. In several instances, the vehicle was returned after service without the problem being resolved, requiring additional return visits. More recently, Tesla has suggested the issue may be related to tires and wheels. However, this contradicts earlier assurances that those components were not the root cause. All tires and two wheels have already been replaced, yet the same issues continue to occur. Months go by without any resolution and then when the tires go bad again, they tried to sell me on that when that never resolved the issue. They tried to force me to buy new tires and wheels for $8000 claiming that to be the issue. The main has fell twice in the last year and was replaced with a battery that was not of light kind. When the battery failed at a Tesla supercharger, the door would not open momentarily. I will estimate the date of the last service. Cannot open due to open ticket
NHTSA complaint #11736972 — an unverified report by a vehicle owner.
Daytona Beach, FL
ELECTRICAL SYSTEM
The vehicle has been taken to Tesla multiple times due to ongoing controllability and safety concerns. The Autopilot system will occasionally brake unexpectedly at green lights or when another vehicle is passing on the right side. The vehicle has also experienced repeated drivetrain issues, including the half shafts failing at least four times within a short period. During acceleration, the vehicle can be difficult to control at times, and the wheels exhibit noticeable vibration. Despite replacing two full sets of tires within two years and completing multiple balancing and service attempts, the issue has not been resolved. These ongoing problems have contributed to premature tire wear and reduced stability, particularly in wet or rainy driving conditions. The vehicle has been serviced by Tesla at least 10 times, and each visit has resulted in replacement of half shafts or other drivetrain components. At one point, Tesla indicated that the drive module was “off center,” though no clear explanation was provided. These issues have been present since the vehicle was purchased in May 2024. In several instances, the vehicle was returned after service without the problem being resolved, requiring additional return visits. More recently, Tesla has suggested the issue may be related to tires and wheels. However, this contradicts earlier assurances that those components were not the root cause. All tires and two wheels have already been replaced, yet the same issues continue to occur. Months go by without any resolution and then when the tires go bad again, they tried to sell me on that when that never resolved the issue. They tried to force me to buy new tires and wheels for $8000 claiming that to be the issue. The main has fell twice in the last year and was replaced with a battery that was not of light kind. When the battery failed at a Tesla supercharger, the door would not open momentarily. I will estimate the date of the last service. Cannot open due to open ticket
NHTSA complaint #11736972 — an unverified report by a vehicle owner.
Frankfort, KY
STRUCTURE:BODY
The rear doors have emergency release cables in case the power is cut during a collision. These cables are hidden, not glowing, and have a small square pull on the end that is difficult to find and pull. I had great difficulty in testing the function to ensure the emergency cable pulls worked. They need to have a glowing T-handle on the end to facilitate location and movement, and the emergency cable location should be marked and visible in the car, just like the emergency hood and truck release are.
NHTSA complaint #11703010 — an unverified report by a vehicle owner.
Santa Cruz, CA
UNKNOWN OR OTHER
Rear emergency release cable does not open the trunk. The latch mechanism failed with a trunk full of groceries, I pushed down the rear setts to access the trunk compartment and crawled back and popped open the emergency release cable and it did not function. I have a service for the car scheduled for Dec 2nd to repair/replace the latch mechanism.
NHTSA complaint #11702039 — an unverified report by a vehicle owner.
Santa Cruz, CA
ELECTRICAL SYSTEM
Rear emergency release cable does not open the trunk. The latch mechanism failed with a trunk full of groceries, I pushed down the rear setts to access the trunk compartment and crawled back and popped open the emergency release cable and it did not function. I have a service for the car scheduled for Dec 2nd to repair/replace the latch mechanism.
NHTSA complaint #11702039 — an unverified report by a vehicle owner.
Lake Charles, LA
WHEELS
Wheels: From the original purchase of the vehicle, I had a small air leak from the right rear tire. I addressed this with Tesla and they said nothing was wrong. I lived with it adding pressure from time to time. When it was time to replace the tires because the originals were only good for 20,000 miles at most. Upon replacing the tires, it was discovered that the right rear rim was cracked which explained why it was leaking all this time. Not long after the tire replacement, I experienced another leak on the right front. I brought it back in to check for a leak in the tire and again discovered it was cracked also, but had 2 cracks in this one 😡. I discussed this with the tire shop and he stated he sees this very often with the Model S. He seems to believe the car is too heavy for the particular turbine wheels selected for the car. These wheels are a factory purchase upgrade. I called Tesla to address my concerns for feedback. They denied ever hearing of this issue as common. I did the research and lo and behold this defect is very common and people are very unhappy regarding this issue and the fact Tesla is blatantly being dishonest about it. For the foundation and a major component that binds a vehicle to the road should be taken seriously. In my opinion, a vehicle that has the potential for the wheels to crack and maybe just come apart is critical. And that depends on the actual speed of travel. This could be very bad.
NHTSA complaint #11696968 — an unverified report by a vehicle owner.
Louisville, KYCrash
UNKNOWN OR OTHER
On 09/18 , I was using the Smart Summon feature of my Tesla Model S in the parking lot of Costco, Greenwood (Indianapolis, IN). The intent was to have the vehicle autonomously navigate from its parked spot toward my location, as designed and advertised by Tesla. During the Summon operation: 1.The vehicle failed to correctly detect and avoid a fixed obstacle (the cart return stand where shopping carts are housed). 2.Instead of stopping or rerouting safely, the car collided with the structure, causing visible damage to the front of the vehicle. 3.While there was no damage to public property or injury to people, the incident demonstrated a serious safety risk, since pedestrians or nearby vehicles could have been struck had they been present. 4.The Smart Summon system did not provide sufficient warning or correction during this event, despite being marketed as capable of safely maneuvering in such environments. This failure shows that the Smart Summon feature did not perform as intended and behaved in an unsafe manner in a real-world public parking environment.
NHTSA complaint #11689122 — an unverified report by a vehicle owner.
Louisville, KYCrash
BACK OVER PREVENTION: WARNINGS
On 09/18 , I was using the Smart Summon feature of my Tesla Model S in the parking lot of Costco, Greenwood (Indianapolis, IN). The intent was to have the vehicle autonomously navigate from its parked spot toward my location, as designed and advertised by Tesla. During the Summon operation: 1.The vehicle failed to correctly detect and avoid a fixed obstacle (the cart return stand where shopping carts are housed). 2.Instead of stopping or rerouting safely, the car collided with the structure, causing visible damage to the front of the vehicle. 3.While there was no damage to public property or injury to people, the incident demonstrated a serious safety risk, since pedestrians or nearby vehicles could have been struck had they been present. 4.The Smart Summon system did not provide sufficient warning or correction during this event, despite being marketed as capable of safely maneuvering in such environments. This failure shows that the Smart Summon feature did not perform as intended and behaved in an unsafe manner in a real-world public parking environment.
NHTSA complaint #11689122 — an unverified report by a vehicle owner.
Louisville, KYCrash
LANE DEPARTURE: WARNING
On 09/18 , I was using the Smart Summon feature of my Tesla Model S in the parking lot of Costco, Greenwood (Indianapolis, IN). The intent was to have the vehicle autonomously navigate from its parked spot toward my location, as designed and advertised by Tesla. During the Summon operation: 1.The vehicle failed to correctly detect and avoid a fixed obstacle (the cart return stand where shopping carts are housed). 2.Instead of stopping or rerouting safely, the car collided with the structure, causing visible damage to the front of the vehicle. 3.While there was no damage to public property or injury to people, the incident demonstrated a serious safety risk, since pedestrians or nearby vehicles could have been struck had they been present. 4.The Smart Summon system did not provide sufficient warning or correction during this event, despite being marketed as capable of safely maneuvering in such environments. This failure shows that the Smart Summon feature did not perform as intended and behaved in an unsafe manner in a real-world public parking environment.
NHTSA complaint #11689122 — an unverified report by a vehicle owner.
Evansville, IN
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
The contact owns a 2020 Tesla Model S. The contact stated that while the vehicle was parked, the driver’s side door failed to open from the inside as intended. The vehicle was restarted, but the failure persisted. The contact rolled down the driver’s side window and attempted to unlock the door from the outside; however, the failure persisted. The contact was trapped inside the vehicle. The contact climbed over to the passenger’s seat and exited the passenger’s side door without issue. The vehicle was taken to a dealer where it was determined that the door handle had an electrical issue, and an undisclosed part needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was unknown.
NHTSA complaint #11687625 — an unverified report by a vehicle owner.
at 32,807 milesChattaroy, WA
POWER TRAIN
The contact owns a 2020 Tesla Model S. The contact stated while driving at various speeds, the vehicle started to vibrate in the shutter shaft unit. There were no warning lights illuminated. The vehicle was taken to the dealer and was diagnosed with front CV axle failure. The vehicle was repaired; however, the failure persisted. On a separate occasion, the vehicle started to shudder, and the vehicle was taken back to the dealer. The vehicle was repaired for the most recent failure however, the contact stated the vehicle had been repaired three times, for the CV axle failure. The manufacturer was made aware of the failure. The failure mileage was approximately 32,807.
NHTSA complaint #11652390 — an unverified report by a vehicle owner.
Fort Myers, FLCrash
UNKNOWN OR OTHER
Vehicle was tested for concern about self driving after test drive with tech told ok 3 days later Summoned car and immediately turned into adjacent vehicle all captured on video in 1-2 seconds. No issues with summons for over 4 years $2200 damage to adjacent vehicle but Tesla no damage left front wheel caused damage on start.
NHTSA complaint #11641683 — an unverified report by a vehicle owner.
Fort Myers, FLCrash
FORWARD COLLISION AVOIDANCE: WARNINGS
Vehicle was tested for concern about self driving after test drive with tech told ok 3 days later Summoned car and immediately turned into adjacent vehicle all captured on video in 1-2 seconds. No issues with summons for over 4 years $2200 damage to adjacent vehicle but Tesla no damage left front wheel caused damage on start.
NHTSA complaint #11641683 — an unverified report by a vehicle owner.
at 75,000 milesBrookfield, WI
LATCHES/LOCKS/LINKAGES:HOOD:LATCH
The contact owns a 2020 Tesla Model S. The contact stated that while driving on the highway at 35 MPH, the front hood latch unexpectedly opened, causing the hood to rise up. No warning lights were illuminated. The contact immediately stopped and parked on the side of the road, and the contact closed the trunk and continued driving. The local dealer was contacted; however, the vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 75,000.
NHTSA complaint #11639728 — an unverified report by a vehicle owner.
Lafayette, LA
WHEELS
I have only about 40,000 miles on the car. But I've had to change the tires twice because the tires wear out quickly, lose air, or go flat. With my second set of tires, I am now told that the tires are so worn that I may need another set of tires. I was told by the last tire shop that the car is too heavy for the tires and that it needs some type of special tires. None of this was disclosed when I purchased the vehicle. I've noticed on the Internet that many people complain of this same problem. I also had the tire pressure stem go out on one of the tires and had to get Tesla to send a replacement, for which I was charged.
NHTSA complaint #11636364 — an unverified report by a vehicle owner.
Cupertino, CA
FORWARD COLLISION AVOIDANCE: WARNINGS
Since the installation of software version 2024.27.25, which includes FSD version 12.5.4, on Sept 26, 2024, any driving which occurs on FSD results in emergency braking events for Green Lights, unprotected/unsignaled crosswalks without pedestrians present, Parallel Parked Cars not encroaching on the lane of travel, vehicles traveling the same direction and similar speed (+/- 5mph), not encroaching on my lane. These frequently reoccurring events were not remedied by any of the subsequent updates received: v2024.32.10 (FSD v12.5.4.1) on Oct 8, 2024 v2024.33.5 (FSD v12.5.4.2) on Nov 2, 2024 2024.44.25.2 (FSD v12.5.4.2) on Dec 10, 2024 While not all events occurred with surrounding traffic, those that did posed a hazard to not just occupants of my vehicle, but those in and around other vehicles, including pedestrians. Most other drivers do not expect and are unprepared for a vehicle to apply panic-level emergency braking and come to full stop at green lights, before unprotected crosswalks with no pedestrians present, or along well-traveled streets without significant errant other drivers. No warning lights, chimes, or other indications ever appeared on any of the displays or instrument clusters within the vehicle during any of the events. The FSD traffic display did not indicate or highlight any features of the surrounding area that were causing it to slow or stop. The problem has been regularly experienced by many other drivers, as evidenced by the large number of similar reports across the various Tesla driver communities online. I and my vehicle are available for inspection and I'm additionally willing to take an inspector on a ride-along to demonstrate the issue.
NHTSA complaint #11631709 — an unverified report by a vehicle owner.
Cupertino, CA
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Since the installation of software version 2024.27.25, which includes FSD version 12.5.4, on Sept 26, 2024, any driving which occurs on FSD results in emergency braking events for Green Lights, unprotected/unsignaled crosswalks without pedestrians present, Parallel Parked Cars not encroaching on the lane of travel, vehicles traveling the same direction and similar speed (+/- 5mph), not encroaching on my lane. These frequently reoccurring events were not remedied by any of the subsequent updates received: v2024.32.10 (FSD v12.5.4.1) on Oct 8, 2024 v2024.33.5 (FSD v12.5.4.2) on Nov 2, 2024 2024.44.25.2 (FSD v12.5.4.2) on Dec 10, 2024 While not all events occurred with surrounding traffic, those that did posed a hazard to not just occupants of my vehicle, but those in and around other vehicles, including pedestrians. Most other drivers do not expect and are unprepared for a vehicle to apply panic-level emergency braking and come to full stop at green lights, before unprotected crosswalks with no pedestrians present, or along well-traveled streets without significant errant other drivers. No warning lights, chimes, or other indications ever appeared on any of the displays or instrument clusters within the vehicle during any of the events. The FSD traffic display did not indicate or highlight any features of the surrounding area that were causing it to slow or stop. The problem has been regularly experienced by many other drivers, as evidenced by the large number of similar reports across the various Tesla driver communities online. I and my vehicle are available for inspection and I'm additionally willing to take an inspector on a ride-along to demonstrate the issue.
NHTSA complaint #11631709 — an unverified report by a vehicle owner.
Cupertino, CA
LANE DEPARTURE: ASSIST
Since the installation of software version 2024.27.25, which includes FSD version 12.5.4, on Sept 26, 2024, any driving which occurs on FSD results in emergency braking events for Green Lights, unprotected/unsignaled crosswalks without pedestrians present, Parallel Parked Cars not encroaching on the lane of travel, vehicles traveling the same direction and similar speed (+/- 5mph), not encroaching on my lane. These frequently reoccurring events were not remedied by any of the subsequent updates received: v2024.32.10 (FSD v12.5.4.1) on Oct 8, 2024 v2024.33.5 (FSD v12.5.4.2) on Nov 2, 2024 2024.44.25.2 (FSD v12.5.4.2) on Dec 10, 2024 While not all events occurred with surrounding traffic, those that did posed a hazard to not just occupants of my vehicle, but those in and around other vehicles, including pedestrians. Most other drivers do not expect and are unprepared for a vehicle to apply panic-level emergency braking and come to full stop at green lights, before unprotected crosswalks with no pedestrians present, or along well-traveled streets without significant errant other drivers. No warning lights, chimes, or other indications ever appeared on any of the displays or instrument clusters within the vehicle during any of the events. The FSD traffic display did not indicate or highlight any features of the surrounding area that were causing it to slow or stop. The problem has been regularly experienced by many other drivers, as evidenced by the large number of similar reports across the various Tesla driver communities online. I and my vehicle are available for inspection and I'm additionally willing to take an inspector on a ride-along to demonstrate the issue.
NHTSA complaint #11631709 — an unverified report by a vehicle owner.
Frankfort, KY
VEHICLE SPEED CONTROL
In all assisted driving modes except Full Self Driving (FSD), the car properly displays the speed Limit it has determined either by Map data or visual confirmation. In FSD, apparently only on pre-2021+ Model S cars, the determined speed limit is not displayed. In my town we have a US60 route. The car sees these signs and determines the speed limit is 60, even though it is only 35. The driver notices a rapid acceleration and may observe the set FSD speed has changed to 60. There is no Speed Limit displayed in this mode. Very dangerous to go this fast on a 35 MPH road. When not using FSD, the car does show this error in the speed limit as being 60, even though the car determined speed limit itself is in error.
NHTSA complaint #11618590 — an unverified report by a vehicle owner.
Frankfort, KY
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
In all assisted driving modes except Full Self Driving (FSD), the car properly displays the speed Limit it has determined either by Map data or visual confirmation. In FSD, apparently only on pre-2021+ Model S cars, the determined speed limit is not displayed. In my town we have a US60 route. The car sees these signs and determines the speed limit is 60, even though it is only 35. The driver notices a rapid acceleration and may observe the set FSD speed has changed to 60. There is no Speed Limit displayed in this mode. Very dangerous to go this fast on a 35 MPH road. When not using FSD, the car does show this error in the speed limit as being 60, even though the car determined speed limit itself is in error.
NHTSA complaint #11618590 — an unverified report by a vehicle owner.
Henderson, NVCrash
UNKNOWN OR OTHER
While attempting to park car ,the car accelerated on it own despite me hitting the brakes causing the car to hit a wall.
NHTSA complaint #11594303 — an unverified report by a vehicle owner.
Austin, TX
SUSPENSION
After getting new tires installed at Walmart I heard a loud knocking noise when turning the steering wheel. The Walmart tech thought that it was because the tires were too big/wide. Tesla said they probably forgot to put the car in Jack Mode and the air suspension fully deflated. Once the sir suspension return to normal the knocking noise is still there, although not as loud and not as frequent. Both the Walmart technician and Tesla technician confirmed the noise. Tesla said my front fore and aft links (aka Control Arms) are worn and in need of replacement. I read that this is a common issue and that Tesla has done a lot of repairs both in and out of warranty (Some goodwill repairs). [XXX] technician talks as if the parts are wear items. I asked why they don't have them in the service manual and I wasn't given a good answer. The technician said that the bushings and ball bearings are wear items and that the fore and aft links get replaced along with them. I was given an estimate of $2,330.69 for the repair. Attached is the invoice. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11588549 — an unverified report by a vehicle owner.
at 100 milesKelseyville, CA
FORWARD COLLISION AVOIDANCE
The contact owns a 2020 Tesla Model S. The contact stated that while driving at various speeds between 40-50 MPH, the vehicle experienced phantom braking, causing the vehicle to abruptly stop in the middle of the road. The contact indicated that the failure had occurred on multiple occasions at the same road location. Also, the contact indicated that the vehicle had erroneously attempted to switch lanes and at one time attempted to switch lanes into oncoming traffic. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 100.
NHTSA complaint #11577081 — an unverified report by a vehicle owner.
at 100 milesKelseyville, CA
LANE DEPARTURE
The contact owns a 2020 Tesla Model S. The contact stated that while driving at various speeds between 40-50 MPH, the vehicle experienced phantom braking, causing the vehicle to abruptly stop in the middle of the road. The contact indicated that the failure had occurred on multiple occasions at the same road location. Also, the contact indicated that the vehicle had erroneously attempted to switch lanes and at one time attempted to switch lanes into oncoming traffic. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 100.
NHTSA complaint #11577081 — an unverified report by a vehicle owner.