28 of the 1,219 complaints filed about the Toyota FJ Cruiser are about the electrical system — 2% of everything owners reported. The worst model year for it is 2007.
28
Complaints
2%
Share of all complaints
2
Crashes
5
Fires
ELECTRICAL SYSTEM
Mice or rats consume the soy-based wires. They consumed one of the fuel injection wires on my 2014 FJ. The Toyota dealership charged me $896 for the new connector that was located under the intake manifold.
NHTSA complaint #11695714 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
I was driving the vehicle to work and was unable to stop. I had to use the emergency brake system.
NHTSA complaint #11686892 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
THE HEATING UNIT UNDER BOTH FRONT SEATS ARE COMING ON WITHOUT THE SWITCH ON. AFTER TUNING SWITCH ON AND OFF SEVERAL TIMES IT WILL GO OFF,BUT IT COMES BACK ON. ON 11/19/14 THERE WAS A RECALL ON THIS VEH. RECALL #14V743000. THIS HAS BEEN GOING ON FOR A COUPLE MONTHS.
NHTSA complaint #11387657 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
BROUGHT CAR INTO DEALER LAST MONTH FOR NEW HORN AS IT WAS A WEAK VOLUME AND WOULD NOT PASS INSPECTION IN MASSACHUSETTS. WAS REPLACED. WORKED FOR A WEEK OR TWO THEN CEASED TO COMPLETELY FUNCTION. BROUGHT BACK IN TODAY AND WAS TOLD BY DEALER CLOCK SPRING/SPIRAL CABLE WAS CORRODING. REMINDED OF OLD RECALL ON VARIOUS PAST TOYOTAS.
NHTSA complaint #11384336 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
DRIVER SEAT AND PASSENGER SEAT HEATING UNIT IS COMING ON WITHOUT THE SWITCH TURNED ON.
NHTSA complaint #11383872 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
MY PROBLEM MY TOYOTA FJ CRUISER BURNED 12 AM MIDNIGHT OCTOBER 18 2020 WAS PARKING AT FRONT AT MY HOUSE IT BURNED COMPLETELY IN THE ENGINE AREA I WANT TO KNOW WHAT HAPPENED. IF THIS ELECTRICAL PROBLEMS. I WANT TO KNOW IF OTHERS VANS EXPERIENCES PROBLEMS.
NHTSA complaint #11372541 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
I REAR ENDED SOMEONE AND I WAS GOING 30MPH APPROX AND MY AIRBAGS DID NOT DEPLOY AND THE CAR ENGINE AREA AND BATTERY CAUGHT ON FIRE
NHTSA complaint #11325596 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
I BOUGHT MY 2014 FJ CRUISER BRAND NEW WITH 5 MILES ON IT. 6 MONTHS INTO OWNING IT THE DRIVER DOOR LOCKS STOPPED WORKING. THE DEALER REPLACED IT UNDER WARRANTY. ABOUT A YEAR LATER THE PASSENGER LOCKS STOPPED WORKING AND THEY REPLACED THOSE UNDER WARRANTY. ABOUT 1-1/2 YEARS LATER THE DRIVER LOCK (THAT WAS ALREADY REPLACED) STOPPED WORKING AGAIN. I HAD 34,000 MILES ON IT AND THEY TOLD ME THAT IT'S NO LONGER COVERED UNDER WARRANTY. I TOLD THEM THAT THE LOCK THEY REPLACED WENT OUT BUT THE DEALER SAID THE REPLACEMENT WARRANTY IS ONLY GOOD FOR 1 YEAR AFTER THE REPAIR! SHORTLY AFTER THE PASSENGER LOCK WENT OUT AGAIN AS WELL. AND NOW THE BACK DOOR WONT EVEN UNLOCK WITH THE KEY FOB OR EVEN MANUALLY WITH THE KEY. THE DOOR LOCK ACTUATORS ON THE CARS ARE TERRIBLE! I WENT TO THE DEALER AND THE SERVICE MANAGER TOLD ME THEY WERE HAVING A LOT OF ISSUES WITH THE TOYOTA LOCKS AND FOR ME TO KEEP AN EYE OUT FOR A RECALL! IT'S BEEN 3 YEARS NOW THAT I'VE BEEN WITHOUT LOCKS AND NO RECALL! DEALER QUOTED ME $900 TO FIX ONE DOOR! $360 FOR THE PART AND THE REST LABOR. RIDICULOUS ESPECIALLY BECAUSE THEY HAVE ALREADY REPLACED THESE PARTS IN THE PAST UNDER WARRANTY!! WHAT GOOD IS IT TO PAY FOR THE SAME PART THEY ALREADY 'REPLACED' JUST FOR THEM TO GO OUT SO SOON!!!
NHTSA complaint #11316902 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
THERE APPEARS TO BE A SHORT IN SOME WIRING. MY TURN SIGNAL/HAZARDS FUSE BLOWS EVER TIME I TRY TO TURN THEM ON.
NHTSA complaint #11217826 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
REVIEW MIRROR FAILING TO AUTOMATICALLY DIM UNDER ANY LIGHTING, INCLUDING SUN, DIRECTLY ENTERING THROUGH THE REAR WINDOW OF THE VEHICLE. THIS HAS ALWAYS BEEN LIKE THIS, IT IS JUST WITH THESE NEW HIGH-INTENSITY LIGHTS ON THE NEW, 2016-2019, THAT IT HAS BECOME MORE OF A HAZARD AT NIGHT. THIS OCCURS ON ALL ROADWAYS.
NHTSA complaint #11204168 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
CRUSE CONTROLL QUIT WORKING IN MOTION.
NHTSA complaint #11112846 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
MASTER CYLINDER FAILED - HAVE TO SLAM THE BRAKE PEDAL ALL THE WAY TO THE FLOOR AND THEN I WAS STILL UNSURE IF THE CAR WOULD ACTUALLY STOP. HAD TWIN 3 YEAR OLD BOYS IN THE CAR, SCARED FOR OUR LIVES. DASHBOARD LITE UP LIKE A CHRISTMAS TREE. SECOND SHOP DIAGNOSED IT AS A FAILED MASTER CYLINDER. PARTS PLUS LABOR = $3,066. I WORK FOR THE SCHOOL SYSTEM AND WE DON'T HAVE THAT SORT OF MONEY. WILL TOW IT HOME, HOPEFULLY FIND A USED PART, AND TRY TO REPLACE IT OURSELVES. THE ONLY REASON I'M LOGGING A COMPLAINT (BECAUSE CARS NEED REPAIRS AND I UNDERSTAND THAT) IS BECAUSE I'M SEEING THE EXACT SAME COMPLAINT OVER AND OVER AGAIN "MASTER CYLINDER TOYOTA FJ CRUISER 2007". HOW CAN SO MANY OF THE SAME COMPLAINTS ON THE EXACT SAME VEHICLE GO UNHEARD? PLEASE HELP, MAKE THE MASTER CYLINDER RECALL APPLY TO THE FJ CRUISER. IT OBVIOUSLY SHOULD BE INCLUDED. THANK YOU FOR YOUR TIME.
NHTSA complaint #11022634 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
THE VEHICLE WAS PARKED IN MY DRIVE WAY. SQUIRRELS CHEWED THE WIRING HARNESS CAUSING LOSS OF ABS BRAKING, STABILITY CONTROL AND LOSS OF WINDSHIELD WIPERS (DURING A RAIN). I UNDERSTAND TOYOTA USES FOOD BASED INSULATION IN THE 2010 FJ CRUISER. A NICE SOURCE OF SQUIRREL FOOD. FROM THE BARE WIRES AND SQUIRREL NESTING, IT IS A WONDER MY ENGINE COMPARTMENT DIDN'T CATCH FIRE. I BELIEVE THE SQUIRREL NEST BUILDING WAS DUE TO THE CLOSE FOOD SOURCE.
NHTSA complaint #11010821 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
KNOWN PROBLEM BY MANUFACTURERS. EXTREME DAMAGE TO WIRING HARNESS AND COMPONENTS WITHIN ENGINE COMPARTMENT BY RODENT. VEHICLE HAS 13,837 MILES ONLY. NEW WIRING STANDARDS REPORTEDLY DRAW RODENTS AND/OR INCREASE AMOUNT OF DAMAGE TO VEHICLE SYSTEMS. VEHICLE WAS PARKED LESS THAN 7 HOURS AND WHEN TURNED IGNITION TO VEHICLE, INSTRUMENT PANEL ILLUMINATED EVERY SAFETY WARNING TO INCLUDE ENGINE LIGHT FLASHING. ENGINE SPUTTERED AND REQUIRED TOW. INSURANCE COMPANY REPORTS HIGH NUMBER OF CLAIMS ESPECIALLY RELATED TO NEWER CARS WITH WIRING. DAMAGE TO WIRING IF DRIVEN COULD CAUSE VEHICLE SYSTEMS TO FAIL, FIRE AND COULD CAUSE GRAVE RISK OF INJURY OR DEATH TO OPERATOR AND PASSENGERS. MANUFACTURER DOES NOT COVER IN WARRANTY NOR PROVIDES PREVENTIVE REMEDY TO ISSUE.
NHTSA complaint #10839755 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
WINDSHIELD WIPERS HAVE FAILED TO WORK FOR LONG PERIODS OR HAVE TO PLAY WITH SWITCH TO WORK RIGHT. TOOK CAR IN YEARS AGO WHILE UNDER WARRANTY TO FIX AND RESOLVED PROBLEM FOR A FEW YEARS BUT IS NOW REOCCURRING. ALSO DRIVERS SIDE DOOR WINDOW SWITCH INTERMITTENLY WORKS. I DONT KNOW IF THIS IS CONNECTED TO WIPER SWITCH BUT HAVE SEEN RECALLS ON OTHER TOYOTAS THAT HAVE THIS PROBLEM AND HAD A RECALL BUT NONE FOR FJ. SPECIFICS TURN ON CAR, TURN ON SLECTOR SWITCH FOR WIPERS "SLOW THRU HIGH IT DONT MATTER". WIPERS DONT WORK.
NHTSA complaint #10816628 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
BOTH PASSENGER AND DRIVER AIR BAGS DID NOT DEPLOY AT THE IMPACT OF A HEAD ON COLLISION WHICH TOTALLED THE CAR MY SON WAS DRIVING,AND HE SUSTAINED HEAD,BACK AND NECK INJURIES BECAUSE OF THAT.THE CAR LOCKED UP AFTER THE CRASH,DISABLING HIM TO EXIT THE CAR AND HAD TO BE PULLED OUT FROM THE PASSENGER SIDE OF THE CAR.
NHTSA complaint #10640284 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
WHEN TRYING TO PUT MY CAR IN REVERSE I COULD NOT MOVE THE GEAR SHIFT LEVER. IT WAS FROZEN. THE ABS, ALL THE TRAC ANNUNCIATOR LIGHTS STAYED ON. I HAD TO BYPASS THE GEAR SHIFT TO BE ABLE TO MOVE THE CAR. I WENT ON LINE TO LOOK UP POSSIBLE CAUSES AND WAS TOLD TO CONTACT SOME OF THE AUTO PARTS COMPANIES LIKE AUTO ZONE ETC. AND HAVE THEM HOOK UP THEIR COMPUTER TESTER TO TROUBLESHOOT THIS PROBLEM. I HAVEN'T HAD A CHANCE TO TAKE IT BY YET.
NHTSA complaint #10543353 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
THE ISSUE STARTED ON 8/23/2012 WHILE DRIVING ON I-95 IN SC, MY 2011 FJ CRUISER TRAIL TEAMS EDITION TIRE PRESSURE WARNING INDICATOR LIGHT CAME ON. THE VERY NEXT DAY, I TOOK MY VEHICLE TO A TOYOTA DEALERSHIP IN WEST COLUMBIA, SC TO HAVE IT INSPECTED. THE DEALERSHIP COULD NOT FIND ANYTHING WRONG WITH THE VEHICLE AS THE LIGHT HAD TURNED OFF THAT NIGHT. HOWEVER, THEY DID DISCOVER AN UNUSUAL AMOUNT OF ERROR CODE MESSAGES FROM THE CPU SYSTEM AND THOUGHT THIS MAY HAVE CAUSED THE LIGHT TO INTERMITTENTLY TURN ON/OFF. THE DEALERSHIP RESET ALL ERROR MESSAGES AND RELEASED THE VEHICLE BACK TO ME. AS IT WAS AN ISOLATED INCIDENT, I THOUGHT THERE WAS NO REASON TO WORRY ABOUT IT. A WEEK LATER, WHILE DRIVING MY VEHICLE ON I-95 IN NC, THE SAME INDICATOR LIGHT TURNED BACK ON, THIS TIME FOR THE REMAINDER OF MY TRIP HOME TO MD. AFTER CONTACTING TOYOTA OF BOWIE TO INSPECT THE ISSUE, THEY FOUND NOTHING WRONG WITH IT AND RELEASED THE VEHICLE BACK TO ME. SOON THEREAFTER, THE SAME INDICATOR LIGHT TURNED BACK ON UNTIL MID-JANUARY 2013 WHEN DRIVING THE VEHICLE TO GA, THE INDICATOR LIGHT TURNED OFF. I HAD THE VEHICLE SERVICED AT I-95 TOYOTA (NEAR BRUNSWICK, GA) AND THEY INDICATED NO ISSUES WERE FOUND WITH THE VEHICLE EVEN THOUGH I ADVISED THEM OF THE INCIDENTS. THEY CONCLUDED THAT WHEN I RETURN HOME TO HAVE THE VEHICLE LOOKED AT THEN. WHILE RETURNING HOME TO MD, THE INDICATOR LIGHT TURNED BACK ON AND HAS STAYED ON EVER SINCE. CONSIDERING I HAVE NOT RECEIVED NOTICE FROM TOYOTA FOR THE SAFETY RECALLS FOR THE VEHICLE, I DISCOVERED THEM THROUGH THE NHTSA WEBSITE AND I HAVE AN APPOINTMENT FOR THIS MORNING TO HAVE A FEW CURRENT RECALLS THAT THE DEALERSHIP KNOWS ABOUT TO BE FIXED AND WILL ADVISE TOYOTA OF ANNAPOLIS (KOON'S) (WHERE I ORIGINALLY PURCHASED THE VEHICLE) OF THE INDICATOR LIGHT ISSUE AND CONCERN. IF ANY FURTHER INFORMATION IS NEEDED, PLEASE DO NOT HESITATE TO CONTACT ME.
NHTSA complaint #10509216 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING
CPSC: I1330412A. 2013 TOYOTA FJ CRUISER. CONSUMER STATED THAT RODENTS HAVE BEEN EATING THE WIRES UNDER THE HOOD OF HER VEHICLE. *LN THE CONSUMER WAS INFORMED THE WIRES WERE MADE WITH SOME TYPE OF SOY, THAT ATTRACTED THE RODENTS AND SO FAR IT HAS COST $800 IN THE PAST TWO MONTHS.
NHTSA complaint #10506123 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE INSTRUMENT PANEL LIGHTING AND GAUGES BEGAN TO FLUCTUATE ERRATICALLY AS THE VEHICLE SUDDENLY STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THAT THE ABS SYSTEM WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. IN ADDITION, THE INSTRUMENT PANEL LIGHTING WOULD NOT ILLUMINATE AND GAUGES WOULD NOT PROVIDE A READING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT THE BRAKES WOULD NOT RESPOND. AFTER SHUTTING THE ENGINE OFF THE VEHICLE COULD NOT BE RESTARTED. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THAT THE BATTERY WAS MELTED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THAT THE BATTERY, WIRING HARNESS, ALTERNATOR AND THE FUSE BOX WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.
NHTSA complaint #10494414 — an unverified report by a vehicle owner.