186 of the 2,451 complaints about the 2007 Toyota Prius are about the body and structure — 8% of everything reported for this model year. Half of the failures with a mileage on record happened before 69,000 miles.
186
Complaints
6
Crashes
4
Fires
5
Injuries
Filed with NHTSA, in their own words.
STRUCTURE:BODY:DOOR:HANDLE:EXTERIOR
Hatch release has melted, see NHTSA ID’s for example: 10511408, 10533059, 10504366, 10496197, 10448470, etc.
NHTSA complaint #11600977 — an unverified report by a vehicle owner.
STRUCTURE:BODY
catalytic converter is easily accessible and there should be a recall to have a safety operation and stop all these cars from being sold in the market because there is a rise in many thefts of the catalytic converter due to it being very easily accusable without any guard in place to prevent thieves from getting to it to remove and sell for parts. Spray paint can be cleaned off and vin numbers can be sanded down. simply trying that will not work. i was unaware that it was stolen off of the vehicle until i drove it a little ways to where the vehicle was then burning and i could smell it catching on fire
NHTSA complaint #11536412 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE MAIN DASH.DISPLAY, SPEEDOMETER, WILL NOT SHOW UP DUE TO ELECTRIC PROBLEM. POWER FROM REAR, AUX, BATTERY IS INTERRUPTED SOME HOW. THE CRUISE CONTROL WILL BE INOP IN THIS SITUATION. THERE IS NO WAY OF KNOWING WHEN THE CONDITION WILL SHOW UP, BUT WHEN DOOR IS OPENED, THE INDICATOR LIGHT WILL NOT COME ON. CAR WILL HAVE BEEN PARKED, TURNED OFF. DIFFERENT FIXES ON THE NET. MY FIX IS TO IN PLUG REAR BATTERY'S 2 CONNECTIONS, WAIT THEN HOPE, AND TRY AGAIN
NHTSA complaint #11316457 — an unverified report by a vehicle owner.
STRUCTURE:BODY
SOMETIMES THE DASH WON'T LIGHT UP OTHER TIMES THE CAR WON'T SHUT OFF PLUS ON THE TAILGATE THE LITTLE ELECTRICAL PIECE FELL OFF WHERE YOU OPEN THE TRUNK
NHTSA complaint #11286524 — an unverified report by a vehicle owner.
STRUCTURE:BODY:TRUNK LID
TL* THE CONTACT OWNS A 2007 TOYOTA PRIUS. THE CONTACT STATED THAT THE TRIM AROUND THE TRUNK LATCH MELTED AND WAS STUCK TO THE VEHICLE, WHICH MADE IT IMPOSSIBLE TO OPEN THE TRUNK. THE VEHICLE WAS TAKEN TO JAY WOLFE TOYOTA OF WEST COUNTY (LOCATED AT 14700 MANCHESTER RD, BALLWIN, MO 63011) WHERE THE TECHNICIAN BROKE THE LATCH IN AN ATTEMPT TO OPEN THE TRUNK. THE TECHNICIAN GLUED THE LATCH BACK AND STATED THERE WAS NO RECALL. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 8,000.
NHTSA complaint #11218562 — an unverified report by a vehicle owner.
STRUCTURE:BODY
FIRST ISSUE IS WITH THE REAR LATCH BEING USELESS SOMETIMES DEPENDING ON THE WEATHER AS THE MOLDING IS ALL MELTED AND ACCESS TO THE TRUNK BEING IMPOSSIBLE. SECOND AND MOST IMPORTANT I'VE NOTICED THE BRAKING ON THIS CAR IS VERY VERY SUSPECT. PURCHASED THIS VEHICLE AROUND 6 MONTHS AGO FROM WESTBURY TOYOTA AND I'VE LEARNED I NEED TO APPLY MY BRAKES AT LEAST A GOOD 50 TO 100 FEET BEFORE THE VEHICLE IN FRONT OF ME. COUPLE MONTHS AGO THE CAR IN FRONT OF ME BRAKED SO SUDDEN THAT I ALSO HIT MY BRAKES, THE ABS SIGN FLASHED AS IF IT "WAS" WORKING BUT THE CAR JUST KEPT GOING, I ENDED UP PRESSING THE BRAKE ALL THE WAY TO THE FLOOR AND STILL NO RESULT. IF I HADN'T KEPT MY DISTANCE I WOULD'VE DEFINITELY ENDED UP IN THAT CARS TRUNK. I CAN SAY FROM ALL MY EXPERIENCE AS A DRIVER AND ALL THE CARS I'VE OWNED THIS CAR HAS THE WORST BRAKING SYSTEM IN THE HISTORY OF MOTOR VEHICLES. FEELS LIKE BRAKING A 747 PLANE. EXTREMELY DANGEROUS BRAKING
NHTSA complaint #11196166 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE REAR HATCH IS EXTREMELY HARD TO OPEN IN THE SUMMER AND NOW IN THE WINTER EVEN HARDER. I FEEL THIS IS A SAFETY HAZARD. MY CAR IS PARKED UNDER A CARPORT WINTER AND SUMMER. I HAVE LESS THAN 80,000 MILES ON THE VEHICLE. I NEED TO BE ABLE TO GET IN THE REAR HATCH TO CHANGE A TIRE OR GET A FIRE EXTINGUISHER IN CASE OF EMERGENCY AND I SOMETIMES CAN'T GET IT TO OPEN. IS THERE SOME WAY TOYOTA CAN HELP MAKE THIS RIGHT. THE RUBBER PART THAT YOU PRESS IS HARDER THAN A STICK AND WON'T RELEASE. THIS HAPPENS SOME TIMES AT THE GROCERY STORE PARKING LOT OR AT ANY STORE PARKING LOT. SOMETIMES IT HAPPENS WHEN I ARRIVE HOME AND CAN'T GET MY GROCERIES OUT BECAUSE THE HATCH WON'T LET IT RELEASE. IS THIS A DEFECT THAT CAN BE CORRECTED?
NHTSA complaint #11165482 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE BACK LATCH TO THE TRUNK/HATCH IS DEFECTIVE. THE RUBBER EXTERIOR PART HAS MELTED AND IS ALL GOOEY AND STICKY. IN THE WINTER TIME IT FREEZES. WE ARE UNABLE TO OPEN OR USE THE TRUNK. THIS IS A SAFETY ISSUE AND ALSO CAN NOT ACCESS SPARE OR COMPARTMENT. THIS IS A FAULTY PART AND THERE HAVE BEEN THOUSANDS OF SIMILAR REPORTS. I WOULD LIKE THIS FIXED AS IS A MANUFACTURING FLAW AND DEFECT.
NHTSA complaint #11115076 — an unverified report by a vehicle owner.
STRUCTURE:BODY
HOOD LATCH WILL NOT OPEN 50, 60% OF THE TIME. MANY PEOPLE ARE HAVING THIS PROBLEM AND I FEEL IT SHOULD BE RECALLED..
NHTSA complaint #11083823 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE REAR LIFT GATE LATCH ON MY TOYOTA PRIUS HAS STOPPED FUNCTIONING. THE EXTERIOR RUBBER OVER THE LATCH MECHANISM/SWITCH HAS MELTED, TURNED GUMMY AND WILL NO LONGER FUNCTION TO OPEN THE LIFT GATE. IN COLD WEATHER THE LATCH HAS BEEN EVEN MORE DIFFICULT TO OPEN AND THE TRIM PIECE CONTAINING THE TRUNK HATCH LATCH BEZEL WHILE TRYING TO GET THE LATCH TO RELEASE BROKE. I CAN NO LONGER OPEN THE TRUNK OF MY CAR FROM THE OUTSIDE. THIS IS A SECURITY AND A SAFETY HAZARD AS I CAN NOT ACCESS THE REAR HATCH OF MY CAR IN UNDER NORMAL USE NOR AN EMERGENCY AND DEFEATS THE PRIMARY PURPOSE OF A HATCHBACK CAR WHICH IS ACCESS TO THE CAR'S INTERIOR. THE CAR JACK AND EMERGENCY SPARE TIRE, BATTERY LOCATED JUST BEHIND THE FAILED HATCH LATCH. I AM DISABLED, I CAN NOT PUT A WHEEL CHAIR IN/OUT. THIS IS UNSAFE AND TOYOTA REFUSES TO ASSIST WITH THE REPAIR. THIS REPLACEMENT PART/SERVICE ONLY IS WARRANTY FOR 1 YEAR AT A PRICE OF $675 TO REPAIR. UNDER THE ADA ACT - PLEASE INVESTIGATE AND ADVOCATE A RECALL.
NHTSA complaint #11074179 — an unverified report by a vehicle owner.
STRUCTURE:BODY
AFTER I NOTICED THAT THE SUV SUFFICIENTLY AHEAD OF ME IN THE SAME LANE WAS STOPPING TO MAKE A LEFT TURN, I STARTED SLOWING DOWN WITH PLENTY OF SPACE. I GLANCED FOR A SECOND TO MY RIGHT SIDE TO CHECK SAFETY AROUND ANOTHER SET OF HEADLIGHTS. WHEN I FACED FORWARD I COULD SEE THAT I WAS GETTING TOO CLOSE TO THE ABOUT-TO-TURN CAR AHEAD OF ME. I IMMEDIATELY SLAMMED ON THE BRAKES, BUT THE CAR KEPT MOVING FORWARD AND SLAMMED INTO THE SUV'S REAR END. THANKFULLY THERE WERE NO PHYSICALLY INJURIES, BUT THE COLLISION CAUSED LOW/MODERATE DAMAGE TO THE SUV AND MAJOR DAMAGE TO MY PRIUS -- ENOUGH THAT THE RADIATOR WAS CLOBBERED, AND THAT MY CAR HAD TO BE TOWED. AT THE TIME OF THIS POST, THE REPAIR SHOP HAS NOT YET FINISHED EVALUATING IT AND REPORTING ON ALL THE DAMAGED PARTS AND THE ESTIMATE COSTS. PRIOR TO PURCHASING THIS VEHICLE ABOUT 9 MONTHS AGO, I HAD CHECKED FOR ACTIVE RECALLS BUT FOUND NONE, AND I CONFIRMED THE SAME SHORTLY AFTER THE PURCHASE. APPARENTLY, THOUGH, TOYOTA HAS NOT YET ISSUED A RECALL ON THE BRAKE SYSTEM EVEN AFTER MANY SIMILAR COMPLAINTS ABOUT SUCH A FAILURE DURING AN EMERGENCY NEED FOR A TOTAL STOP. I AM REALLY INTERESTED IN PURSUING FURTHER ACTION, POSSIBLY THROUGH LEGAL AVENUES.
NHTSA complaint #11048273 — an unverified report by a vehicle owner.
STRUCTURE:BODY
WHEN THE TEMPERATURE DIPS BELOW 40 F, THE REAR GATE DOES NOT OPEN. THE RUBBER COVERING OF THE SWITCH TO LIFT THE GATE GETS VERY HARD AND DOES NOT RESPOND TO PRESSURE TO OPEN THE REAR LIFT GATE.
NHTSA complaint #11045190 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE RUBBER HANDLE OF THE REAR LIFTGATE LATCH HAS "MELTED" INTO THE OPERATING PART OF THE LATCH, MAKING IT TOTALLY INOPERABLE IN THE WINTER, AND COOLER MONTHS. THIS IS NOT DUE TO EXPOSURE TO HEAT EXTREMES - THE CAR HAS ALWAYS BEEN GARAGED IN A NORTHERN PART OF THE US, WHERE SUMMER TEMPERATURES RARELY EXCEED 80 DEGREES. IN AN EMERGENCY IN THE WINTER, THERE IS NO WAY TO MAKE USE OF THE HATCHBACK. THE OPERATION IS PROBLEMATIC IN THE SUMMER - SOMETIMES IT CAN BE FORCED OPEN, SOMETIMES NOT. IT HAS TAKEN A FEW YEARS FOR THE LATCH TO BECOME INOPERATIVE; IT BECAME INCREASINGLY DIFFICULT TO OPEN OVER THE LAST SEVERAL YEARS, AND STICKY BLACK RESIDUE TRANSFERRED TO HANDS TOUCHING IT FOR THOSE YEARS. THIS IS NOT NORMAL WEAR AND TEAR; CLEARLY DEFECTIVE RUBBER WAS USED.
NHTSA complaint #10985832 — an unverified report by a vehicle owner.
STRUCTURE:BODY:DOOR
TL* THE CONTACT OWNS A 2007 TOYOTA PRIUS. THE CONTACT STATED THAT A PLASTIC PIECE FROM THE DOOR PREMATURELY MELTED FROM AN UNKNOWN LOCATION, WHICH MELTED INTO THE DOOR LATCH. THE FAILURE MADE IT EXTREMELY DIFFICULT TO USE THE LATCH. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA complaint #10972212 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE TRUNK LATCH ON MY '07 PRIUS HAS "MELTED" AND IS NO LONGER WORKING. SINCE THE LATCH IS NO LONGER WORKING, THE TRUNK IS UNABLE TO OPEN, AND ALSO UNABLE TO REMAIN IN A FULLY LATCHED, CLOSED POSITION. BECAUSE OF THIS, I AM UNABLE TO LOCK THE DOORS. SOMETIMES, I CAN GIVE THE TRUNK DOOR AN EXTRA PUSH TO TURN OFF THE "DOOR OPEN" SENSOR TO LOCK THE VEHICLE, BUT BECAUSE IT IS NOT FULLY LATCHING AND THE VEHICLE IS BEING LOCKED FROM THE OUTSIDE, THE ANTI-THEFT ALARM WILL GO OFF.
NHTSA complaint #10938964 — an unverified report by a vehicle owner.
STRUCTURE:BODY
HATCHBACK WILL NOT UNLOCK. THE RUBBER THAT COVERS THE LATCH HAS DEGRADED TO THE POINT WHERE IT IS STICKY IN THE WARM WEATHER AND ROCK SOLID IN THE COLD WEATHER WHERE YOU CAN NO LONGER PRESS IT TO OPEN THE TRUCK.
NHTSA complaint #10937226 — an unverified report by a vehicle owner.
STRUCTURE:BODY
HATCHBACK DOOR DOES NOT OPEN IN COLD WEATHER.
NHTSA complaint #10935573 — an unverified report by a vehicle owner.
STRUCTURE:BODY
REAR HATCH DOOR LATCH FAILURE, STARTING WITH SOFTENING AND THEN COMPLETE MELTING OF THE RUBBER COVER AND FINALLY TO LATCH NOT OPERATING AT ALL, ESPECIALLY IN COLD WEATHER.
NHTSA complaint #10935312 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE RUBBER COVER ON THE HATCH RELEASE HANDLE (THE EXTERIOR HANDLE OF THE REAR HATCH) OF OUR 2007 TOYOTA PRIUS, MELTED INTO A STICKY TARRY BLACK RUBBERY GOOEY MESS. I CAN BEST DESCRIBE IT AS BEING A VISCOUS BLACK GLOB LIKE ROOFING TAR. TO OPEN THE HATCH, YOU HAVE TO TOUCH THIS BLACK GOO EACH TIME, WHICH MAKES IT DIFFICULT TO OPERATE THE HATCH RELEASE. I THOUGHT THAT THIS MIGHT BE A SINGULAR ISSUE, BUT HAVE FOUND THAT THIS HAS HAPPENED TO SEVERAL CAR OWNERS. TOYOTA KNOWS ABOUT THIS, AND IS SELLING THE ENTIRE WIRING HARNESS FOR $96 PLUS REPAIR COSTS, AND HAS DONE NOTHING ABOUT RECALLING THIS. FROM A SAFETY PERSPECTIVE, THIS MEANS YOU CAN EXPERIENCE EXTREME DIFFICULTY OPENING THE REAR HATCH (A LIFE SAFETY ACCESS POINT), AND WILL GET STICKY BLACK TAR ON YOU FROM THE MELTED DOWN RUBBER COVER OF THE EXTERIOR HATCH RELEASE HANDLE. TO ME, THIS IS BOTH A SERIOUS LIFE SAFETY ISSUE AND A SERIOUS QUALITY DEFECT THAT TOYOTA IS OPTING TO IGNORE AND ONLY FIXING ON VEHICLES WITH EXTENDED WARRANTIES, SINCE THE FAILURE APPEARS TO OCCUR AT AROUND THE 3 YEAR MARK. I AM AWARE OF THE OUTSTANDING WORK DONE BY NHTSA ON OTHER SAFETY ISSUES, INCLUDING THE PROBLEM WITH RUSTY FRAMES ON 02 ISUZU AXIOMS, AND I FIND THIS PROBLEM TO BE SIMILAR IN NATURE, SO I AM ASKING FOR YOUR AGENCY TO TAKE A LOOK AT THESE INSTANCES AND ALSO TO INQUIRE FROM TOYOTA WHY THEY ARE NOT RECALLING THESE HANDLES THAT ARE MELTING. IT'S OUTRAGEOUS. I THINK A DOOR HANDLE OR HATCH HANDLE SHOULD BE MADE TO LAST MORE THAN 3 YEARS. PLEASE REVIEW THESE FORUM COMMENTS OF OTHER INCIDENTS: HTTP://PRIUSCHAT.COM/FORUMS/GEN-II-...RUNK-HATCH-RELEASE-RUBBER-PIECE-MELTED-4.HTML
NHTSA complaint #10930345 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE TRUNK OPENER SWITCH ON MY 2007 PRIUS NO LONGER WORKS RELIABLY BECAUSE IT IS MADE OF A DEFECTIVE RUBBER WHICH HAS AT THIS POINT MELTED INTO A GOOPY MESS. THIS MEANS THAT THE OPENER SWITCH CAN BECOME STUCK IN THE CLOSED POSITION, RENDERING IT IMPOSSIBLE TO OPEN THE TRUNK UNTIL THE RELEASE MECHANISM OF THE SWITCH OVERCOMES THE TENSILE STRENGTH OF THE GOOP. AS A CURSORY GOOGLE SEARCH SHOWS, THIS IS A COMMON PROBLEM WHICH TOYOTA ROUTINELY REFUSES TO REPAIR. IT IS A POTENTIAL SAFETY ISSUE BECAUSE A PET OR CHILD COULD BE DIFFICULT TO RETRIEVE FROM THE TRUNK AREA IF THE TRUNK CANNOT BE OPENED. AN UNEXPECTED HAZARD SUCH AS A LEAKING PROPANE TANK OR A BATTERY FIRE IN THE TRUNK AREA COULD SIMILARLY BE DIFFICULT TO MITIGATE.
NHTSA complaint #10918022 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE REAR LIFT GATE LATCH ON MY TOYOTA PRIUS HAS STOPPED FUNCTIONING. THE EXTERIOR RUBBER OVER THE LATCH MECHANISM/SWITCH HAS MELTED, TURNED GUMMY AND WILL NO LONGER FUNCTION TO OPEN THE LIFT GATE. IN COLD WEATHER THE LATCH HAS BEEN EVEN MORE DIFFICULT TO OPEN AND THE TRIM PIECE CONTAINING THE TRUNK HATCH LATCH FRACTURED IN SUB-FREEZING WEATHER WHILE TRYING TO GET THE LATCH TO RELEASE. THE CAR WAS PARKED WITH LIGHT SNOW FALLING. I CAN NO LONGER OPEN THE TRUNK OF MY CAR FROM THE OUTSIDE. THIS IS A SAFETY HAZARD AS I CAN NOT ACCESS THE REAR HATCH OF MY CAR IN AN EMERGENCY AND DEFEATS THE PRIMARY PURPOSE OF A HATCHBACK CAR WHICH IS ACCESS TO THE CAR'S INTERIOR. THE CAR JACK AND EMERGENCY SPARE TIRE LOCATED JUST BEHIND THE FAILED HATCH LATCH. I HAD TO PAY OVER $500+ TO HAVE TOYOTA REPLACE THE FAILED HATCH LATCH SWITCH AND SURROUNDING TRIM PIECE.
NHTSA complaint #10886076 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE HEADLIGHTS WORK INTERMITTENTLY AND HAVE NEEDED BULB REPLACEMENT 3 TIMES SO FAR. ALSO ALL THE TAIL LIGHT AND THE TAG LIGHTS WENT OUT AT THE SAME TIME RECENTLY AND REQUIRED BULB REPLACEMENT. WHEN DRIVING WE HAD NO IDEA THE LIGHTS WERE OUT AND ONLY FOUND OUT WHEN WE WERE PULLED OVER BY POLICE. THIS CONSTITUTES A VERY DANGEROUS SITUATION IN MY OPINION. ALSO THE HATCHBACK HANDLE SOMETIMES FAILS TO WORK DUE TO THE RUBBER COVER DETERIORATION.
NHTSA complaint #10870142 — an unverified report by a vehicle owner.
STRUCTURE:BODY
ANOTHER COMPLAINT REGARDING THE RUBBER COVER OF THE 2007 PRIUS HATCH RELEASE/LATCH. THE RUBBER COVERING HAS DETERIORATED AND DEGRADED IN A WAY THAT CAUSES IT TO MELT AND BECOME STICKY IN WARM OR HOT WEATHER; TOUCHING THE COVER CAUSES THE MATERIAL TO STICK TO FINGERS, AND IS VERY DIFFICULT TO REMOVE, REQUIRING THE USE OF A SOLVENT CLEANER. IN COLD AND FREEZING WEATHER, THE COVER BECOMES VERY STIFF AND NOT FLEXIBLE, AND IS IMPOSSIBLE TO PRESS, CAUSING THE HATCH TO BE IMPOSSIBLE TO OPEN. THIS IS A BASIC OPERATIONAL PROBLEM, RENDERING THE HATCHBACK NON-FUNCTIONAL - IT CAN'T BE OPENED, OR IF IT CAN BE OPENED IT LEAVES A SUBSTANCE ON THE DRIVER'S BODY. ALSO A SAFETY ISSUE, AS WHEN THE HATCH CAN'T BE OPENED THIS IS ESSENTIALLY BEING LOCKED OUT OF THE TRUNK WHERE THE SPARE TIRE AND SAFETY EQUIPMENT ARE LOCATED. DEALER WILL CHARGE APPROXIMATELY $300 FOR PART AND LABOR TO REPAIR THIS. I'VE CALLED TOYOTA CUSTOMER SERVICE, AND THEIR RESPONSE WAS: "IT IS NO LONGER COVERED UNDER THE WARRANTY, AND THERE IS NO RECALL FOR THIS, SO TOYOTA WILL NOT BE COVERING THIS REPAIR." I DID A SEARCH IN THE NHTSA COMPLAINT DATABASE AND FOUND 147 OWNERS WITH THE EXACT SAME PROBLEM. VERY DISCOURAGING AND IRRESPONSIBLE THAT TOYOTA WILL NOT TAKE RESPONSIBILITY AND ASSIST OWNERS WITH RESOLVING THIS ISSUE.
NHTSA complaint #10861324 — an unverified report by a vehicle owner.
STRUCTURE:BODY
BACK HATCH HANDLE MELTS IN HOT WEATHER AND GETS TAR ON FINGERS AND DRIPS ON CAR BODY. THE ONLY WAY TOYOTA HAS TO FIX THIS IS TO MAKE CONSUMER PAY FOR A NEW REAR HANDLE ASSEMBLY.
NHTSA complaint #10853174 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE REAR HATCH LATCH RUBBER COVER HAS DISSOLVED OVER THE LAST COUPLE YEARS TO THE POINT YOU CAN NO LONGER OPEN FROM OUTSIDE. IF SOMEONE WAS IN AN ACCIDENT YOU COULD NOT OPEN THE REAR HATCH DOOR AND YOU ARE TRAPPED INSIDE OF THE VEHICLE WITH NO TIME TO GET YOURSELF OUT OR PULL ANYONE ELSE OUT, I HAVE SEEN ONLINE COMPLAINTS ABOUT THIS GOING BACK INTO 2011. THIS IS HAPPENING ON A LOT OF CARS, ESPECIALLY TOYOTA PRIUS'S. AS OF RIGHT NOW I CAN NOT OPEN THE HATCH DOOR ON MY 2007 PRIUS. IT HAS JUST GOTTEN WORSE UNTIL NOW WHEN IT WILL NOT OPEN. I USED TO HAVE TO FIGHT BY PUSHING DOWN AND PULLING UP, BUT IT WILL NOT OPEN AT ALL NOW.
NHTSA complaint #10845786 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE RUBBER COVER ON THE REAR HATCH LATCH HAS DETERIORATED SO SEVERELY THAT THE LATCH HANDLE WILL NO LONGER WORK. THE RUBBERIZED COVER HAS BECOME GOOEY AND STICKY, AND COMES OFF ON YOUR HANDS WHEN YOU TOUCH IT. THERE IS NO ALTERNATE TRUNK RELEASE ON THIS VEHICLE, SO WITH THE HANDLE MECHANISM GUMMED UP BY THE DETERIORATING RUBBER COVER, THERE IS NO WAY TO ACCESS THE TRUNK OF THE VEHICLE. THIS PIECE HAS BEEN DETERIORATING OVER THE PAST THREE TO FOUR YEARS. WE'VE BEEN TRYING TO HOLD OFF FOR A TOYOTA RECALL ON THIS PIECE, BUT NOW WE HAVE NO CHOICE BUT TO PAY TO HAVE IT FIXED.
NHTSA complaint #10826036 — an unverified report by a vehicle owner.
STRUCTURE:BODY
FAULTY LIFTGATE HANDLE. THE RUBBER MELTS IN WARM WEATHER, LEAVING A STICKY BLACK TAR ON YOUR FINGERS THAT WILL NOT WASH OFF. THIS RUBBER MELTS INTO THE MECHANISM SUCH THAT THE LIFTGATE IS NO LONGER OPERATIONAL. TOYOTA KNOWS ABOUT THIS FAULTY BATCH OF RUBBER THAT WAS USED, BUT SO FAR REFUSES TO RECALL THE FAULTY MECHANISM IN THE US. THE LIFTGATE WOULD ONLY OPEN INTERMITTANTLY, WITH A LOT OF EFFORT ABOUT A YEAR AGO. NOW, IT WILL NOT OPEN AT ALL, SO WE ARE TAKING IT TO THE DEALER FOR REPAIR.
NHTSA complaint #10824384 — an unverified report by a vehicle owner.
STRUCTURE:BODY
I GOT UNINTENDED HIGH SPEED AND I COULD NOT STOP THE CAR. IT STOPPED BECAUSE THE WHEEL WAS HIT BY THE CURBE
NHTSA complaint #10809920 — an unverified report by a vehicle owner.
STRUCTURE:BODY
READ HATCH DOOR LATCH SWITCH FAILURE DUE TO RUBBER COVER THAT HAS DETERIORATED AND MELTED INTO STICKY GOO. THE SWITCH NOW IS INTERMITTENT. BLACK TARRY RUBBER GETS ON MY HANDS WHEN I TRY TO USE IT. THE PRICE TO REPAIR WAS QUOTED AS $350
NHTSA complaint #10809239 — an unverified report by a vehicle owner.
STRUCTURE:BODY
LIFTGATE HANDLE LATCH MECHANISM DETERIORATED (INSIDE THE EXTERIOR HANDLE, NOT THE ACTUAL CONNECTION DOWN NEAR THE BUMPER). THIS IS A KNOWN 2007 PRIUS PROBLEM BOTH WITHIN THIS DATABASE AND IN ONLINE FORUMS, IF YOU SEARCH. PROBABLY PART OF THE 'RUBBER PARTS / GASKET TURNING INTO GOOP' PROBLEM DISCUSSED ELSEWHERE. SHOULD BE A DEALER WARRANTY REPAIR AS IT IS EXPENSIVE DEFECT TO FIX, $600 OR SO, ENTAILING REMOVING PANELS FROM THE INSIDE ETC AND REPLACING THE SWITCH. I CALLED TOYOTA AND THEY GAVE ME A CASE NUMBER BUT THAT IS ALL THUS FAR. LEXINGTON TOYOTA DEALER (MASS.) SAID THEY HAD NEVER HEARD OF IT, WHICH SEEMS UNLIKELY.
NHTSA complaint #10807840 — an unverified report by a vehicle owner.