2005 Toyota Tacoma transmission problems

POWER TRAIN

In May of 2018, I purchased a 2005 Toyota Tacoma. After arrival of new title, I received a safety recall notice from Toyota in regards to possible abnormal frame rust. I was instructed to take my Tacoma to nearest Toyota dealership for frame inspection. Prior to taking Tacoma in for frame inspection, I scoped the frame myself, and noticed abnormal rust forming throughout both sides of the frame. Therefore, I took my Tacoma to Berge Toyota in Mesa AZ. for further inspection and to have some other repairs done. Upon my arrival to Berge Toyota, l informed the service writer of the repairs that were needed done and showed him the request from Toyota for the frame inspection. My vehicle was taken to a lift, where a brief frame inspection was performed with a flashlight only and I was told the frame was fine, and the rust I had witnessed during my personal inspection was within a standard tolerance of "normal". On September 12, 2022 my frame cracked in a horseshoe formation around the driver side motor mount, causing the engine to shift and sink approx. 3/4" towards the driver side. This frame failure has caused numerous problems to occur, such as the fan to continuously rub against the shroud, abnormal shifting of the transmission, ramping up and down of RPM's, vehicle's steering locks up and cannot be safely driven, leaving me without transportation After detailed inspection was performed on my Tacoma, the horseshoe crack around the motor mount was found and it was determined this was the source of all the problems. I contacted Berge Toyota where I was informed by their service manager that Berge Toyota was not certified to do the frame inspection or repair, and further explained the safety recall had expired and instructed me to contact Toyota to see what could be done. The question I had for the Berge Toyota service manager, was if they were not certified to do the frame inspection, or repair why did they inspect my frame and inform me it was fine, when it wasn't?

NHTSA complaint #11490424 — an unverified report by a vehicle owner.

POWER TRAIN

The differential drive housing failed due to corrosion resulting in the differential oil leaking out at a significant rate and in loss of lubrication of the differential gears. The condition was detected before any significant loss of material condition or function but could have lead to a loss of vehicle control if the differential had failed. The local Toyota Dealer has not reviewed the condition as of yet. A review of several Tacoma internet forum sights finds similar corrosion failures described (oil leaking from differential housing). There is no monitoring/warning indicator for the oil level condition in the differential housing in this vehicle.

NHTSA complaint #11452535 — an unverified report by a vehicle owner.

POWER TRAIN

SQUIRK-LIKE SOUND AT THE BEGINNING OF A TRIP, SPECIFICALLY WHEN THE VEHICLE REACHES 5 MPH. THIS NOISE PREVAILS AS LONG AS THE SPEED IS INCREASED, SPECIFICALLY ALONG THE RANGE OF 5 TO 15 MPH. FROM 16 MPH IT STARTS A VIBRATION ALONG THE ENTIRE VEHICLE BODY, WHICH AUGMENTS AS LONG AS THE SPEED IS INCREASED. THESE SYMPTOMS APPEARED FOR FIRST TIME 5 YEARS AGO, APPROXIMATELY. ON THAT FIRST EVENT THE PROPELLER SHAFT SPIDER ANT THEIR BEARINGS WERE REPLACED BY THE TECHNICIAN WHERE THE VEHICLE WAS BOUGHT. NOWADAYS I JUST SCHEDULED AN APPOINTMENT TO BRING THE VEHICLE TO ANOTHER TOYOTA AUTHORIZED SERVICE CENTER FOR PROPER DIAGNOSIS AND REPAIR. IT IS NECESSARY TO HIGHLIGHT THAT THIS AUTOMOTIVE UNIT PRESENTED SYMPTOMS OF VIBRATION AT CRUISE SPEED (55 MPH), SINCE THE VERY FIRST TIME IT WAS DRIVEN ON THE HIGHWAY, FOR THE YEAR OF 2005. WHEN THAT OCCURRED, THIS DRIVER BROUGHT THE UNIT TO THE DEALER. THE RESPONSE WAS THAT THE VIBRATION DESCRIBED IS "NORMAL". THIS STRANGE "SHAKING" AT CRUISE SPEED HAS NOT DISAPPEARED. IT THINK IT IS A DESIGN AND MANUFACTURING DEFECT OF THE PROPELLER SHAFTS AND THEIR JOINTS, WHICH CAUSE A DYSFUNCTIONAL PROPELLER SHAFT RUNOUT (GREATER THAN 0.6MM [0.024 IN.]). OTHER TACOMA 2005 OWNERS HAVE LET ME KNOW THEY HAVE EXPERIENCED THE SAME SITUATION IN THEIR VEHICLES. THIS COULD REPRESENT A POTENTIAL SAFETY RISK FOR ALL VEHICLE OCCUPANTS.

NHTSA complaint #11233936 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THERE WAS A STRONG VIBRATION COMING FROM THE VEHICLE, THE SERVICE ENGINE INDICATOR ILLUMINATED, AND THE U-JOINTS HAD NOT BEEN PROPERLY LUBRICATED FROM THE MANUFACTURING PROCESS. THE DEALER (LEGACY TOYOTA, 3800 W TENNESSEE ST, TALLAHASSEE, FL 32304, (850) 688-9264) DIAGNOSED THAT THE TIRES WERE THE CAUSE OF THE FAILURES. THE DEALER DID NOT REPLACE THE DRIVETRAIN AND THE U-JOINTS. THE CONTACT CONSTANTLY HAD TO LUBE THE U-JOINTS TO PREVENT DRYNESS, WHICH WOULD HAVE CAUSED THE DRIVETRAIN TO FRACTURE. THE CONTACT, A MECHANIC, REPLACED THE U-JOINTS AND TOOK THE DRIVESHAFT TO THE DEALER TO INSPECT THE PART, BUT NO REMEDY WAS PROVIDED. THE MANUFACTURER ISSUED A SERVICE CAMPAIGN AND INDICATED THAT THE VEHICLE WAS EXCLUDED; THEREFORE, THE DEALER REFUSED TO REPLACE THE U-JOINTS AND THE DRIVESHAFT. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER FOR FURTHER DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND PROVIDED NO REMEDY. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA complaint #11101115 — an unverified report by a vehicle owner.

POWER TRAIN

I HAVE HAD THE REAR END ON MY VEHICLE REPLACED 2X. NO HARD DRIVING. NO SIGNS OF ABUSE OR REGULAR WEAR BUT HAS COST ME OVER 2200 EACH TIME. THE HEAD GASKET HAVE NOW FAILED AND IN READING MANY ONLINE SITES THIS IS A COMMON PROBLEM. MY VEHICLE HAS BEEN SERVICED AND NEVER OVER HEATED. THIS JOB IS NOW GOING TO COST ME 2500. IT STARTED A GURGLING NOISE IN THE DASH AND GOT WARM ONE DAY. THE ENGINE THEN THREW A MISFIRE IN CYLINDER 4 A PRESSURE CHECK CONFIRMED THE HEAD GASKET. THE REAR END IS A CONCERN ALONG WITH THE HEAD GASKETS.

NHTSA complaint #11081730 — an unverified report by a vehicle owner.

POWER TRAIN

2005 TOYOTA TACOMA. CONSUMER WRITES IN REGARDS TO VEHICLE PULLS TO THE LEFT WHILE DRIVING, GEAR SHIFTER PROBLEMS AND STALLING ISSUES. *LD

NHTSA complaint #11005728 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT NOTICED THAT THE CLUTCH PEDAL WAS SOFT. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE CLUTCH PEDAL TURN SPRING WAS DEFECTIVE. AS A RESULT, THE CLUTCH PEDAL CAUSED THE CLUTCH MASTER CYLINDER ROD TO BEND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CLUTCH MASTER CYLINDER ROD NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT DID NOT OFFER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

NHTSA complaint #10983154 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THE TRACTION RE-ENGAGED ON ITS OWN AND THE VEHICLE VEERED TO THE RIGHT WHEN THE STEERING WHEEL WAS TURNED TO THE LEFT. THE FAILURE OCCURRED WHILE DRIVING AT ANY SPEED, WHEN THE GEAR SHIFTER WAS PLACED INTO FOUR WHEEL DRIVE, WHEN THE TRACTION CONTROL WAS DISABLED, AND WHEN DRIVING OVER ICE, SNOW, AND/OR SAND. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 5,000. UPDATED 04/05/17 LJ

NHTSA complaint #10945776 — an unverified report by a vehicle owner.

POWER TRAIN

I HAD COMPLETE FAILURE TO MY RACK AND PINION STEERING DUE TO EXCESSIVE CORROSION TO THE COMPONENT. I WAS PULLING INTO A BUSINESS DOING ABOUT 10 MPH AND THE STEERING LOCKED UP COMPLETELY. I CHECKED THE POWER STEERING FLUID IN THE RESERVOIR AND IT WAS COMPLETELY EMPTY. I CHECKED UNDER THE TRUCK AND ON THE GROUND WAS A PUDDLE OF STEERING FLUID. THE VEHICLE WAS TAKEN TO A LOCAL GARAGE AND WHEN HE EXAMINED THE TRUCK TO SEE WHAT HAD HAPPENED, HE STATED THAT THE RACK AND PINION HAD COMPLETED ROTTED OUT AND BROKE. I ALSO HAD HIM CHECK THE FRAME ON MY TRUCK, SINCE I RECEIVED A TSB BULLETIN ABOUT THE EXCESSIVE CORROSION DUE TO NOT ENOUGH FRAME UNDERCOATING BEING APPLIED IN COLD STATES. HE FOUND A LARGE HOLE BEHIND THE CATALYTIC CONVERTER IN THE FRAME. THE MECHANIC CHECKED THE REST OF THE FRAME AND FOUND SOME SMALLER PERFORATIONS AS WELL. MY QUESTIONS IS IF THE FRAME IS BEGINNING TO ROT AND THEY ARE SELECTIVELY REPLACING THE FRAMES OR VEHICLE IF THEY ARE A DANGER, WHY ARE NO OTHER COMPONENTS THAT ARE ATTACHED TO THESE FAILING PARTS COVERED AS WELL AND FAILING DUE TO EXCESSIVE ROT OR RUSTING. IF ANY OF THESE COMPONENTS FAILED DURING NORMAL DRIVING CONDITIONS ON THE HIGHWAY AT NORMAL SPEED THE RESULTS COULD HAVE BEEN DEVASTATING TO ALL INVOLVED, POSSIBLY LEADING TO SEVERE INJURY OR DEATH. SOMETHING MORE NEEDS TO BE DONE TO BRING ATTENTION TO THE TOYOTA MOTOR COMPANY NOT STANDING BEHIND THEIR VEHICLES THEY PRODUCE AND THE SAFETY OF THE PEOPLE WHO OWN AND OPERATE THEM. TOYOTA NEEDS TO STOP PLAYING THE "ITS NOT COVERED OR APPLICABLE" GAME AND TAKE OWNERSHIP AND FIX IT BEFORE SOMEONE DOES GET KILLED. I HAVE OWNED 5 TOYOTA'S PREVIOUSLY AND FELT VERY SAFE UP UNTIL NOW, NOW I AM NOT TO SURE!

NHTSA complaint #10727023 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE:DRIVESHAFT

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. WHILE DRIVING 50 MPH, THE REAR OF THE VEHICLE BEGAN TO VIBRATE. IN ADDITION, THE BRAKE PEDAL WAS DEPRESSED AND IT TOOK A LONGER DISTANCE TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE DRIVESHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE FAILURE MILEAGE WAS 79,000.

NHTSA complaint #10722205 — an unverified report by a vehicle owner.

POWER TRAIN

MY FATHER HAS AN '05 TACOMA SR5 V6 WITH THE TRD OFF-ROAD PACKAGE. HIS TRUCK IS A 6-SPEED MANUAL. WHEN PRESSING THE GAS PEDAL 1/2 WAY, THE ENGINE RESPONDS WITH A SEMI-VIOLENT JERK, AND THEN GOES. THIS SCARES ME, AS I COULDN'T EVEN IMAGINE MY FATHER GOING FULLY DOWN ON THE PEDAL. THIS IS VERY UNSAFE. PLEASE FIX THIS TOYOTA.

NHTSA complaint #10704875 — an unverified report by a vehicle owner.

POWER TRAIN

MY TRUCK HAS BEEN AT [XXX] FOR 2 MONTHS TO BE WORKED ON AND I FEEL THAT THIS IS NOT RIGHT I COUNT ON MY TRUCK. WE HAD TO [XXX] AND WE COULDN'T COUNT ON THEM EITHER THE TRANSMISSION WENT OUT OF ONE LEFT US WAKING AND WE TRADE IT IN ON OTHER ONE BECAUSE IT WAS GONE OUT AGAIN SO THE NEW ONE WE JUST LET GO BACK BECAUSE THE SAME THING WAS HAPPEN TO IT REALLY DID MESSED UP OUR CREDIT I KNOW YOU DON'T CARE ABOUT ANY OF THIS BUT I WOULD LIKE MY TRUCK SOON AND I WON'T BUY NO MORE TOYOTA AND WON'T TELL ANYONE ELSE TO EITHER THANK YOU AS IF YOU CARE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #10689750 — an unverified report by a vehicle owner.

POWER TRAIN

THE FRAME IS RUSTING. THERE ARE HOLE STARTING TO FORM.

NHTSA complaint #10662408 — an unverified report by a vehicle owner.

POWER TRAIN

I HAVE 2005 TACOMA 4X4 WITH A FRAME THAT CRACKED AND COLLAPSED INTO ITS SELF WERE THE LEFT MOTOR MOUNT IS WELDED TO THE FRAME. THE MOTOR CAME TO REST ON THE STEERING SHAFT KNUCKLE @ THE RACK AND PINION MAKING IT DIFFICULT TO STEER. I CALLED TOYOTA SERVICE CENTER THEY TOLD ME IT WAS THE FIRST TIME THEY HAD HEARD ABOUT THIS PROBLEM. UPON RESEARCHING THE PROBLEM ON THE WEB THERE ARE WELL OVER 200 COMPLAINTS SAME PROBLEM. IT IS SUCH A PROBLEM THAT A FABRICATION COMPANY DMZ MAKES A GUSSET REPAIR KIT TO REPAIR AND REINFORCE THE FRAME. IT'S A BOUT A 10 HOUR REPAIR. HTTP://DMZFAB.COM/PRODUCT/TACOMA-MOTOR-MOUNT-GUSSET-KIT/. TOYOTA SHOULD CONTACT THEM FOR THE CURE.

NHTSA complaint #10644864 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 60 MPH, THE CLUTCH FAILED TO SHIFT AND CAUSED AN ABNORMAL ODOR. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TOWED TO THE DEALER. THE DEALER REPLACED THE CLUTCH, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 4,000.

NHTSA complaint #10622032 — an unverified report by a vehicle owner.

POWER TRAIN

I HAVE NOTICED EXCESSIVE RUST ON THE FRAME OF MY 2005 TOYOTA TACOMA AND ALSO RUST HOLE THROUGH THE FRAME/LEAF SPRING MOUNT ON THE RIGHT SIDE. I DID CONTACT AND SEND PICTURES TO TOYOTA CUSTOMER EXPERIENCE CENTER FILE# STATING THAT THE VEHICLE IS OUT OF WARRANTY AND THEY WONT REPAIR THIS UNSAFE CONDITION THAT SO MANY TACOMA'S ARE HAVING. WHEN ONE OF THESE TACOMA'S GETS INTO AN ACCIDENT WITH THE FRAMES COMPROMISED BY THE RUST IT WILL CAUSE SEVERE INJURY OR DEATH TO THE OCCUPANTS AND THIS HAS TO BE FIXED NOW.

NHTSA complaint #10575560 — an unverified report by a vehicle owner.

POWER TRAIN

STARTED HEARING RUBBING/GRINDING TYPE NOISE COMING FROM FRONT END. INSPECTED AND FOUND LF CV AXLE LEAKING GREASE, SO THOUGHT THE NOISE WAS COMING FROM THERE. REPLACED LF CV AXLE, AND THE NOISE DID NOT GO AWAY. INSPECTED FURTHER AND FOUND DRIVERS SIDE FRAME WHERE THE MOTOR MOUNT BRACKET IS WELDED TO CRACKED, CAUSING THE MOTOR TO FLEX AND THE FAN TO RUB ON THE FAN SHROUD. CONTACTED TOYOTA, WHO INSTRUCTED ME TO GET IT INSPECTED AT A DEALERSHIP. TOOK TO TOYOTA DEALER, WHO TOLD ME THERE WAS NO EVIDENCE OF DRIVER ABUSE, NO RUST, NOT REALLY ANYTHING THAT SHOWED WHY THE WELD HAD BROKEN, BUT THAT TOYOTA DID NOT WANT TO DO ANYTHING DUE TO AFTERMARKET LIFT AND OVERSIZED TIRED. LIFT WAS ALREADY INSTALLED ON VEHICLE WHEN PURCHASED AT A TOYOTA DEALERSHIP. TOYOTA CORPORATE TOLD ME THEY DID NOT WANT TO HELP BECAUSE VEHICLE IS OUT OF FACTORY WARRANTY. THE STEERING SHAFT IS DIRECTLY UNDER THE PART OF THE MOTOR THAT IS SAGGING DOWN, AND I AM AFRAID IF IT WERE TO BREAK COMPLETELY IT MIGHT STOP THE VEHICLE FROM BEING ABLE TO TURN. ALSO, IS THERE NOW EXTRA STRESS ON ANY OF THE WIRING? IS IT FLEXING AND POTENTIALLY BREAKING ANY FUEL LINES? I HAVE DONE SOME REASEARCH ON THIS, AND FOUND A LOT OF PEOLPLE HAVING THE SAME ISSUES WITH THEIR TRUCKS. TOYOTA HAS STARTED PUTTING UPDATED FRAMES WITH MORE SUPPORT FOR THE MOTOR MOUNTS ON THE 2007 MODELS, KNOWING THERE WERE ISSUES WITH THE 05/06S, BUT ARE REFUSING TO ACKNOWLEDGE THE PROBLEM AND FIX THE ONES THAT HAVE BROKEN.

NHTSA complaint #10559528 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT A LOUD NOISE WAS EXHIBITED FROM UNDER THE HOOD WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. THE FAILURE WAS LOCATED AT THE TRANSMISSION BELL HOUSE, WHICH WAS MADE OF ALUMINUM AND CAUSING THE ABNORMAL NOISE. THE DEALER REPLACED THE TRANSMISSION BELL HOUSE SEVERAL TIMES UNDER THE WARRANTY BUT THE FAILURE WAS NOT CORRECTED. THE BELL HOUSE CONTINUED TO EXHIBIT THE LOUD NOISE. THE CONTACT ALSO STATED THAT THE SUB FRAME WAS CORRODED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 35,000 AND THE CURRENT MILEAGE WAS 92,000.

NHTSA complaint #10456528 — an unverified report by a vehicle owner.

POWER TRAIN

MY 2005 TOYOTA TACOMA QUAD CAB SR5 HAS AN ISSUE WITH THE TRANSMISSION. AT A COMPLETE STOP WITH MY FOOT FIRMLY ON THE BRAKE MY TRUCK LUNGES FORWARD IN A VERY DANGEROUS ABRUPT MANNER AS THOUGH SOMEONE REAR ENDED ME. THIS HAPPENS OFTEN AT STOP LIGHTS A FEW SECONDS AFTER I COME TO A COMPLETE STOP. A SECOND ISSUE IS THAT MY PAINT IS CRACKING AND PEELING ON MY ROOF AND MY CLEAR COAT IS NOTICEABLY BAD ON THE EDGES OF MY HOOD AND DOORS. MY TRUCK IS NOT OF APPROPRIATE AGE OR WEATHER CONDITIONS TO HAVE THESE TYPES OF PAINT PROBLEMS. TOYOTA REFUSES TO INVESTIGATE OR PAY FOR MY ISSUES AND JUST RECOMMENDS THAT I GO PAY A DEALER TO FIX IT OUT OF MY POCKET. I SEE SEVERAL OTHERS WITH THE EXACT SAME PROBLEMS ON MANY BLOGS, CLASS ACTION ANYONE?

NHTSA complaint #10439055 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE

THIS IS THE 3RD OR 4TH TIME MY REAR END IN MY 2005 TOYOTA TACOMA HAS BLOWN. EVERYTIME I HAVE A PROBLEM WITH TOYOTA AND IT REACHES THREE COMPLAINTS OR REPAIRS THEY DENY THE CLAIM SO IT DOESN'T GO AGAINST THEIR INCIDENTS FOR RECALLS. THE LAST REAR END WENT IN APPROX 4000 MILES AGO FROM ROHRICH TOYOTA. SOMEONE REALLY SHOULD INVESTIGATE THE PRACTICES THAT TOYOTA AND THEIR DEALERSHIPS HAVE. I HAVE 77000 MILES AND AN EXTENDER WARRANTY 10 YEAR 100000 WARRANTY THE OEM JUST RAN OUT BUT I'M STILL WITHIN MY MILEAGE AND AGE.

NHTSA complaint #10348459 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

2005 TOYOTA TACOMA LUNGES OR SURGES WHILE HOLDING THE BRAKE AT LIGHT. IF I DON'T HOLD THE BRAKE FIRM IT COULD REAR END VEHICLE IN FRONT OF ME. DEALER SAYS ITS NORMAL. AND CHARGED ME TO INSPECT. AIRBAG LIGHT CAME ON DEALER TOLD ME IT WAS A PART IN THE AIRBAG AND WANTED 612.00 TO REPLACE STATING THAT IT MAY GO OFF WHILE DRIVING.CAUSING A CRASH .SHOULDN'T A PART THIS CRITICAL BE COVERED FOR LIFE OF TRUCK?

NHTSA complaint #10335062 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA WITH MANUAL TRANSMISSION. THE CONTACT STATED THAT WHEN DRIVING AT ANY RATE OF SPEED IN FOURTH GEAR, THE TRANSMISSION WOULD INTERMITTENTLY SWITCH INTO NEUTRAL WITHOUT WARRANT. WHEN PLACED BACK INTO FOURTH GEAR, THE VEHICLE WOULD FUNCTION AS NORMAL UNTIL THE FAILURE WOULD RECUR. THE CONTACT STATED HE WOULD EXPERIENCE THE FAILURE AT LEAST ONCE EACH TIME THE VEHICLE WAS OPERATED. THE DEALER ADVISED THE VEHICLE WAS NOT UNDER RECALL AND WOULD NOT OFFER ANY ASSISTANCE. THE CONTACT PARKED THE VEHICLE AND WAS NO LONGER OPERATING IT. THE FAILURE MILEAGE WAS APPROXIMATELY 1,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 15,000.

NHTSA complaint #10332231 — an unverified report by a vehicle owner.

POWER TRAIN

MY WIFE AND I BOUGHT A "CERTIFIED USED" 2005 TOYOTA TACOMA LAST YEAR. AUTO 4X4 EXT CAB TRD WITH 42K... GREAT TRUCK BUT WE HAVE THE SAME ISSUE THAT I'VE HEARD SO MUCH ABOUT. AFTER STOPPING AT A RED LIGHT, SEVERAL SECONDS LATER IT WANTS TO LUNGE FORWARD. NOT EVERY TIME BUT PROBABLY 1 OUT OF 5 STOPS. AS ONE OWNER PUT IT, IT FEELS AS THOUGH AS SOMEONE IS TRYING TO PUSH YOU WITH THEIR CAR. NO, ITS NOT THE FLOOR MATS OR ONE FOOT ON BOTH PEDALS. SO FAR IT HASN'T JUMPED FORWARD AND HIT ANYONE BUT I HAVE READ THAT IT'S HAPPENED.. PLAN ON TAKING IT IN TO THE DEALER SO THEY CAN GIVE ME THE RUN AROUND...

NHTSA complaint #10320541 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

MY 2005 TOYOTA TACOMA USED TO LUNGE FORWARD AND ACCELERATE WHILE STOPPED. IT HAPPENED OVER THE SEVERAL YEARS I OWNED IT. I REPORTED THIS TO THE DEALER AND THEY IGNORED ME. I WOULD ALWAYS MAKE SURE I HAD THE BRAKE DEPRESSED HARD WHILE STOPPED.

NHTSA complaint #10314110 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE:DRIVESHAFT

MY SON WAS DRIVING HIS 2005 TOYOTA TACOMA WHEN SUDDENLY HE HEARD AND FELT A SUDDEN LOUD NOISE LIKE A GUN SHOT. HE LOST ALL POWER IN HIS TRUCK. HE WAS ABLE TO GET HIS TRUCK OFF THE INTERSTATE. HE DISCOVERED HIS DRIVE SHAFT HAD FALLEN OUT! IT IS A MIRACLE HE WAS NOT KILLED! IT IS ONLY BY GOD'S GRACE THAT WHEN THE FRONT U-BOLT BROKE, THE DRIVE SHAFT BROKE INTO TWO PIECES. THE REAR PIECE CAUGHT ON THE REAR AXLE. WE ARE PLEASED HE WAS NOT HURT, BUT IS THIS SAME PROBLEM TOYOTA HAS WITH ITS 2010 TOYOTA TACOMA? PLEASE LOOK INTO THIS PROBLEM BEFORE SOMEONE IS KILLED. *TR UPDATED 09/23/10 * BF THE DRIVESHAFT HAD TO BE REPLACED. UPDATED IVOQ 09/24/10

NHTSA complaint #10313377 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

2005 TOYOTA TACOMA AUTOMATIC LURCHES FORWARD AT STOP AFTER COMING TO A COMPLETE STOP. WIFE COMPLAINED THAT SOMETIMES IT FELT LIKE SHE HAD BEEN HIT IN REAR END. I HAVE NOTICED THE SAME WHILE DRIVING HER TRUCK. SHE SAYS IT HAS BEEN DOING THIS FOR A LONG TIME. WITH ALL THE REPORTS ON THIS PROBLEM, SEEMS LIKE TOYOTA WOULD DO SOMETHING ABOUT IT.

NHTSA complaint #10310642 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TRUCK LURCHES FORWARD AFTER COMPLETE STOP.

NHTSA complaint #10263963 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

I BOUGHT MY 2005 TACOMA ABOUT 2 MONTHS AGO. I HAVE EXPERIENCED THIS PROBLEM THREE TIMES NOW. THE LAST TIME BEING TONIGHT AFTER PICKING UP MY DAUGHTER AT WORK. THE TRUCK WAS ACCELERATING AND I WAS LITERALLY STANDING ON THE BRAKE AND THE ENGINE WAS RACING AND WOULD NOT STOP. I THROUGH IT INTO NEUTRAL AND IT SOUNDED LIKE IT WAS GOING TO EXPLODE! I HAVE NO RUGS IN MY VEHICLE, IT DID NOT COME WITH ANY, AND I WAS GOING TO GET THE ALL WEATHER MATS, BUT HAVE NOT BOUGHT THEM YET. THE CRUISE CONTROL WAS NOT ENGAGED. I DO CONSIDER MYSELF TO BE A FAIRLY EXPERIENCED DRIVER, I USE TO RACE A 70 CHEVELLE IN THE 1/4 MILE (THIS WAS MANY YEARS AGO.), IF I DID NOT HAVE SUCH EXPERIENCE I AM SURE I WOULD HAVE RAN THE CAR UP A TREE OR SOMETHING. I AM SCARED, I HAVE BEAT CANCER TWICE AND I'LL BE '!@#$% IF I AM GOING TO LET A FAULTY TACOMA TAKE ME OUT!

NHTSA complaint #10263227 — an unverified report by a vehicle owner.

POWER TRAIN

MY 2005 TOYOTA TACOMA ENGINE SUDDENLY ACCELERATED. THE PEDAL MOVED TO FLOOR AND STAYED THERE. I IMMEDIATELY PUSHED IN THE CLUTCH. I CHECKED TO MAKE SURE THERE WAS NO INTERFERENCE FROM THE RUBBER MAT AND PUMPED THE PEDAL SEVERAL TIMES WHILE COASTING. AFTER ABOUT FIVE SECONDS, THE ENGINE DROPPED FROM REDLINE AND RESUMED NORMAL IDLE. IN AN AUTOMATIC TRANSMISSION THIS WOULD HAVE BEEN A HIGHLY DANGEROUS CONDITION.

NHTSA complaint #10256970 — an unverified report by a vehicle owner.