12 of the
304 complaints about the 2019 Toyota Tacoma are about the
body and structure — 4% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
7,750 miles.
On 2 seperate occassions I had a wheel on my 2019 Toyota Tacoma come off while driving. Both after Toyota signed off on work orders and bill of sales showing they accessed the wheels. On 4/11/26 the front left drivers side fell off. Upon picking it up after repairs on April 28, May 6th the left rear wheel fell off while driving again. My safety could have been fatal but luckily no injuries for me and a passanger occurred. Toyota used a Certified Toyota body shop to do the repairs on the first incident not sure who worked on the 2nd as I have not yet been notified the truck is ready. The manufacturer has done all the inspecting no other parties have been involved. No warning. Right before each incident the truck would shake then skid along the floor causing sparks.
NHTSA complaint #11737733 — an unverified report by a vehicle owner.
san Pedro, CA
STRUCTURE:BODY
My 2019 Toyota Tacoma (Super White) is experiencing paint chipping and delamination across multiple body panels. Toyota has acknowledged this defect in limited repair programs, but my vehicle is affected beyond the covered areas. Paint loss exposes underlying primer/metal and may lead to corrosion over time. This appears widespread among similar model-year Tacomas.
NHTSA complaint #11722840 — an unverified report by a vehicle owner.
Orlando, FL
STRUCTURE:BODY
On 10/9/25 said vehicle was brought to Central Florida Toyota (CFT) for the investigation of water intrusion into the rear passenger compartment. The cause of water intrusion was due to a defective duct (vent) assy (PN: 62930-04040. There are 2 vents located at the rear of the passenger cab.). The cost for the repair was estimated to be $15,153.39. This exorbitant fee includes the replacement of the entire carpeting system and the need to remove the vehicle bed to access the vents. Based on a musty smell CFT assumed that the carpet had been damaged by molds. Subsequently, CFT was requested to have the 2 vents replaced, only, and not the carpeting. In return, CFT stipulated that I must sign a health hazard waiver due the assumed (no evidence) moldy condition. Now, not only can 2 simple mechanical vents cause such an exorbitant fee to repair it has now evolved into a potential health safety issue. Yet, Toyota has failed to provide any caution/warning to the effect of water intrusion into the rear of the passenger area. No caution/warning in owner's manual that vehicle owner must periodically inspect the rear passenger for water, no warning tags/labels inside vehicle. On the other, my Toyota OEM floor mats have all sorts caution/warning plus installation instruction. It is recommended, as a minimum, Toyota must issue a recall to confirm the integrity of all vents in circulation. On my vehicle, the defective vent was due to bad seal which implies poor manufacturing. Secondly, the location of the vents is simply poor engineering. Even, if there's no damage to the carpeting the cost to replace the 2 vents would be $2,500 due to the need to vehicle bed removed.
NHTSA complaint #11693447 — an unverified report by a vehicle owner.
North Port, FL
STRUCTURE:BODY
The rear cabin pressure vent leaks water into the cabin creating an unsafe vehicle to drive during rainy days. I took the vehicle to Sarasota Toyota and was told that my claim to get it fixed thru the Toyota warranty was denied because it is considered trim. I contacted the warranty company and Toyota about this issue but was told the same.NOT COVERED. I am also concerned that the water intrusion can affect the safety and health hazard of more drivers with this problem if not addressed by Toyota as soon as possible.
NHTSA complaint #11689472 — an unverified report by a vehicle owner.
at 80,000 milesSummerfield, FL
STRUCTURE
The contact owns a 2019 Toyota Tacoma. The contact stated that the rear cabin pressure vent seals had deteriorated, causing rainwater to leak into the rear cabin of the vehicle. The contact stated that there was a mildew odor inside the cabin of the vehicle. The contact was concerned that mold had developed inside the vehicle due to the water inside the vehicle. The vehicle was taken to the local dealer, who indicated that the rear pressure seals were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 80,000.
NHTSA complaint #11686793 — an unverified report by a vehicle owner.
Kapolei, HI
STRUCTURE:BODY
Two of my three 2019 Tacoma’s drivers side door hinges broke clean off the door frame.
NHTSA complaint #11619986 — an unverified report by a vehicle owner.
Kapolei, HI
STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
Two of my three 2019 Tacoma’s drivers side door hinges broke clean off the door frame.
NHTSA complaint #11619986 — an unverified report by a vehicle owner.
Panama City Beach, FL
STRUCTURE:BODY
Paint is starting to come off in different areas of the truck, left front fender and right front area of the bed. Toyota dealer inspected the truck and checked for recalls which Toyota has on earlier white vehicles but stated this vehicle was not in the year or vin range of affected vehicles. I have checked online and multiple owners of white Toyota Tacomas are having the same issue and appears to be trucks built at their Mexico plant.
NHTSA complaint #11546811 — an unverified report by a vehicle owner.
Wesley Chapel, FL
STRUCTURE:BODY
Toyota has a campaign to address white paint flaking/chipping on numerous vehicles, with the exception of Tacomas. My truck is a 2019 with 34k miles and the paint is chipping and flaking off. This is a known problem with this paint, so I am not sure why they don't address it with Tacomas. I would like Toyota to take care of this for me. It is not fair for me to pay out of pocket to address a defect in their paint.
NHTSA complaint #11525833 — an unverified report by a vehicle owner.
at 10,000 milesPembroke Pines, FL
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2019 TOYOTA TACOMA. THE CONTACT STATED THAT THE CENTER CONSOLE BY THE AUXILIARY PORTS BECAME OVERHEATED AND A BUBBLE WAS FORMED. THE CONTACT WAS CONCERNED ABOUT A POSSIBLE CAR FIRE DUE TO THE HEAT DISCHARGED FROM THE CHARGING PORTS. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED NOR NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 10,000.
NHTSA complaint #11362994 — an unverified report by a vehicle owner.
at 5,500 milesPaintsville, KYCrash
STRUCTURE:BODY
I STARTED TO NOTICE WHEN YOU WOULD STOP AT A RED. LIGHT AND APPLY THE BRAKES THE PEDAL WOULD SLOWLY EASE OFF LIKE IT HAD AIR IN THE BRAKE LINE.THIS WENT ON FOR A COUPLE OF MONTHS.I HAD A DOCTORS APPOINTMENT AND WHEN I GOT TO THE OFFICE AND WAS PULLING IN THE PARKING SPACE I PRESSED THE BRAKE AND IT WENT TO THE FLOOR SO I PRESSED THE SECOND TIME AND THE SAME THING I DIDN'T HAVE TIME TO TRY THE THIRD TIME BECAUSE I HIT THE CONCRETE WALL AND DID APPROXIMATELY $5200 DAMAGES TO MY VEHICLE.THE ENGINE HAS A NOISE IN ENGINE COMPARTMENT ON THE PASSENGER SIDE THAT SOUNDS LIKE A LIFTER MAKING A NOISE THAT CAN BE HEARD OVER THE ENGINE RUNNING.THE BRAKE PROBLEM I BELIEVE HAS TO DO WITH THE BOOSTER.
NHTSA complaint #11329562 — an unverified report by a vehicle owner.
at 5,000 milesAlburtis, PA
STRUCTURE
EXTERIOR HEADLIGHTS ARE INADEQUATE AS THE ILLUMINATION IS INADEQUATE AND DOESN'T MEET MINIMUM SAFETY STANDARDS FOR A VEHICLE ON COUNTRY ROADS. THE INTERIOR SWITCHES ARE NOT ILLUMINATED AND DURING EVENING OPERATION MAKING SAFE ADJUSTMENTS AN IMPOSSIBILITY. AUTO-DIM OVERRIDES NORMAL SAFE HIGH BEAM OPERATION AS SENSOR IS ACTIVATED FROM ANY ROADSIDE REFLECTIVE SURFACE WHILE VEHICLE IS IN MOTION. THE PROBLEM ALMOST MANIFESTED IN SEVERAL NEAR ACCIDENTS. THIS IS A MAJOR LATENT DESIGN AND EQUIPMENT DEFECT AND IS UNSAFE IN NIGHTTIME OPERATION. *JS THE CONSUMER STATED THAT ON THE COMPUTER SCREEN THE LEFT SIDE INDEX WAS MASKED DURING THE DAY TIME. THE VEHICLE DID NOT INCLUDE A TRANSFER CASE SKID PLATE. THE STEERING HAD ISSUES AND WAS NOISY AS IF DRIVING OVER A RUMBLE STRIP. *JS
NHTSA complaint #11288430 — an unverified report by a vehicle owner.