207 of the
1,249 complaints filed about the Volkswagen Routan
are about the engine —
17% of everything owners reported.
The worst model year for it is 2009.
loss of steering while driving, fluid loss multiple times since late september 2024(all while driving and no lights or warnings came on), 2 snapped serpentine belts, key ignition sticking(would not turn), dashboard not lighting up, rpm no longer rests below 1.5 - 2, car struggles to accelerate(especially uphill), car turns over and struggles to start, even though has newer battery. 1/9/25 driving to an appointment, upon reaching destination, a pop sound. No smell, no warnings came up on dashboard. Upon leaving, saw fluid leak, headed straight to dealership, at which a massive amount of fluid began pouring out of vehicle..in exact same area as original issue from 8/31/24.
NHTSA complaint #11635180 — an unverified report by a vehicle owner.
I bought this van just a few weeks ago. One day I was driving and all a sudden it lost power while in motion. This has happened 4xs so far. It could've resulted in the inability to stop my vehicle as the brakes are stiff after the power & engine stop working. It could've resulted in either I hit someone or someone could've hit me. My cousins husband had a town and country that did this & it was on a recall for the ignition switch failure. He's a mechanic. He has also stated what is going on is the ignition switch failure going into accessory mode while I'm driving. It's available to be inspected I just don't have the money to have it inspected at this point by a dealership.
NHTSA complaint #11624687 — an unverified report by a vehicle owner.
The contact owns a 2011 Volkswagen Routan. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. Several unknown warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 190,000.
NHTSA complaint #11587480 — an unverified report by a vehicle owner.
The contact owns a 2010 Volkswagen Routan. The contact stated that the vehicle was started and driven to her destination; however, after arriving at her destination she attempted to shut off the vehicle, but the vehicle remained running. The contact stated that she disconnected the battery to shut off the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 155,000.
NHTSA complaint #11531999 — an unverified report by a vehicle owner.
NHTSA Recall 14v396 is probably the best correction to this issue. My van has shut off mid-driving while my children are in the car with me. It is so dangerous in the road. I can't move the steering wheel. Mechanics can't seem to diagnose the problem because the van doesn't give any computer codes when it would shut down. There are similar complaints and I wonder how Volkswagen knows of this issue and has failed to inform the owners of these vehicles. Chrysler had a similar issue and did a recall. I hope Volkswagen would acknowledge this issue.
NHTSA complaint #11528397 — an unverified report by a vehicle owner.
The contact's son owns a 2010 Volkswagen Routan. The contact stated that the vehicle would intermittently fail to start after multiple attempts, with several unknown warning lights illuminated. The contact called the dealer and was informed that they no longer serviced the model vehicle. The vehicle was then taken to an independent mechanic however, the mechanic was unable to determine the cause of the failure. The manufacturer was notified of the failure and informed her that there were no recalls on the vehicle. The vehicle was not repaired. The failure mileage was approximately 95,000.
NHTSA complaint #11514168 — an unverified report by a vehicle owner.
While driving on a highway at 65 Mph, vehicle shut down, lost brakes, steering, and all power, had to coast to a stop, narrowly avoiding a collision. Upon exhaustive review, TIPM was faulty, causing starting issues, intermittent power loss, and fuel pump issues. As this van is manufactured by Chrysler (for VW) and their (identical) model has the same issue, it was known and recalled, it is appalling that no recall exists for this VW model. These vans are being financed and bought by families, and like us driven daily with children in them. The issue is widespread, very well known, but as in our case, not disclosed by dealerships as no official action has ever been taken, and no official record exists. We have learned all about it through trial and error, and are having to pay for possibly fatal errors committed on the part of the manufacturer - who, to state again, has in fact already recalled the vehicles due to it being such a wide spread and dangerous issue with a primarily family vehicle. Again, for clarity, the VW Routan is no longer in production, but when it was it was manufactured by Chrysler for VW, and is part for part a Dodge Grand Caravan/Chrysler Town and Country. Why is this critical recall in existence for only a portion of the vehicles? This has become a major issue as we have to continue reducing this van until we can sell or trade it.
NHTSA complaint #11457492 — an unverified report by a vehicle owner.
This has happened multiple times. The ignition will cut off which make the car engine quit running. Loss of braking, steering, power has left me in the middle of intersections being nearly avoided being ran into. When this happens all the warning lights come on and the engine turns off. The exact problem VW recall number 28H1 is affecting my vehicle.
NHTSA complaint #11455174 — an unverified report by a vehicle owner.
Car is stalling out while driving with no warning. Doesn't matter the rate of speed I'm going it just cuts out. Can't turn steering wheel. No codes pop up. No mechanics can pinpoint issue. I have seen quite a few thousand people complaining of the same issue and reported it to vw as well as nhtsa and NO ONE will do a recall. Chrysler did a recall for this same issue but NOT vw. This is a safety issue for not only the owner but other drivers on the road. If I get into an accident or cause one I WILL BE suing nhtsa as well as vw for no recall being done. I have printed out over 100 pages of complaints from others for evidence of complaints. I have already entered the class action lawsuit with others having the same issue. RECALL THE ISSUE OR FACE LAWSUITS.
NHTSA complaint #11446236 — an unverified report by a vehicle owner.
The transmission on our 2012 VW Routan has completely failed. The car will not go into gear and left my wife in a position where she was stranded in traffic. We are the original owners of this vehicle and have followed the recommended maintenance schedule. The engine in this vehicle is a Chrysler Pentastar V6. (The vehicle was built as a joint venture between VW and Chrysler) According to online research Chrysler has recognized a “fatal flaw” in this engine and has extended warranty to customers in order to cover repairs beyond 100,000 miles. We only have 72,000 on our vehicle. I have spoken with VW North America, they told me to plead my case with Chrysler. I spoke with Chrysler and they told me to plead my case with VW. Neither company is willing to recognize that a total transmission failure at 72k miles is [their] responsibility. I am asking for the drivetrain warranty on our vehicle to be extended, due to the “fatal flaw” which has already been identified by Chrysler on the Pentastar V6. VW service is asking me to pay more than $6,000 to repair the vehicle.
NHTSA complaint #11445020 — an unverified report by a vehicle owner.
Thé engine malfunction was observed and confirmed by the Mecanicien and the cause was from the manufacture. I'm willing to submit the car for any inspection. The car is still drivable, but I have to report it. I have been trying to call since longtime in vain. Thank
NHTSA complaint #11442427 — an unverified report by a vehicle owner.
The contact owns a 2009 Volkswagen Routan. The contact stated while at a stoplight, the vehicle stalled. There was an abnormally high pitch noise detected. There were no warning lights illuminated. The vehicle was jump-started by the police and was restarted. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The vehicle was taken to an independent mechanic and the contact was informed that the starter needed to be replaced. The failure mileage was approximately 54,000.
NHTSA complaint #11440823 — an unverified report by a vehicle owner.
The ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which then depowers various key safety systems including, but not limited to, air bags, power steering, and power braking. This has happened to me several times including while driving on the interstate and in traffic. I was able to pull over but it is very difficult when power steering and power breaking goes out. I had children in the vehicle several times when this has happened. Per Volkswagon website, I removed all keychains or anything that would cause the key fob to be weighed down. When I contacted them, they said my van is not under recall even though it is the same exact issue previous models had been recalled for. The only symptom prior was the check engine light was on.
NHTSA complaint #11439049 — an unverified report by a vehicle owner.
The van totally looses all power while driving. It happens multiple times per week. While driving the van dies, it takes about 3-5 seconds then the power comes back, we can then drive again. When it happens, sometimes the power doesn't come back on its own, we then have to put it in neutral and restart it, then can drive as normal.
NHTSA complaint #11426965 — an unverified report by a vehicle owner.
2010 VW Routan VIN:[XXX] We purchased the vehicle used in November of 2018. From November 2018 through early 2020, I experienced the car turning off while driving it about once every 4-6 months. When researching this issue we found that extra weight from other keys or keychains could be affecting it so we separated the car key from my house keys. This showed no improvement. From early 2020 through early 2021, the issue increased in frequency. Instead of once every 4-6 months it became once a month. And, unfortunately in the past 3 months, it has started occurring several times a week (sometimes multiple times a day). This has been a safety concern for our family and we are very nervous that this could cause a serious accident. Luckily the other vehicles around us when this occurs have been alert drivers that were able to give us the extra time to restart our vehicle. We realize that this won’t always be the case and need to get it fixed. The issues we are experiencing as outlined above are in line with the issues listed in NHTSA Campaign ID: 11V151000 for other 2010 VW Routans. However, for whatever reason, our VIN number is not included in the recall. I would like to make a formal appeal with nhtsa that our vehicle be included in this recall and that it be repaired by VW as it is quite clear that what we are experiencing is from the issue in this NHTSA Recall Campaign. We are disappointed to be in a position to fight for something to get fixed that is quite clearly caused by a defaulted part, but remain hopeful that this will be resolved in a timely manner. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11425845 — an unverified report by a vehicle owner.
When driving for about 25 and then getting to a stop light. As I slow down and start to come to a stop the car shakes very roughly and turns right off. The first time this happened was 3 days after getting car from Carmax. It had not happened again until this week.
NHTSA complaint #11417965 — an unverified report by a vehicle owner.
THANK GOD I WAS NOT GOING FAST. VEHICLE SHUT DOWN COMPLETELY WHILE DRIVING. WAS ABLE TO PUT IN PARK AND WAS ABLE TO START IT BACK UP. APPARENTLY, THE ROUTAN IS MANUFACTURED BY CRYSLER AND THIS ISSUE ALSO HAPPENS WITH THE 09 TOWN AND COUNTRIES AS WELL.
NHTSA complaint #11412826 — an unverified report by a vehicle owner.
VAN HAS STALLED WHILE DRIVING ON MULTIPLE OCCASIONS. POWER STEERING IS LOST. VEHICLE WILL THEN START RIGHT BACK UP. THIS IS EXTREMELY DANGEROUS FOR A MINIVAN USED TO TRANSPORT MULTIPLE CHILDREN. NO CODES OR FAULTS ARE RECORDED.
NHTSA complaint #11383517 — an unverified report by a vehicle owner.
THE VEHICLE WAS IN A PARKING LOT AND WOULD NOT START AFTER REPEATED TRIES. IT WOULD START AS NORMAL AND IMMEDIATELY SHUT OFF. HAD TO TAKE IT TO THE DEALERSHIP WHO ADVISED THE TIPM IS FAULTY. FAULTY TIPMS IN THESE VEHICLE WITH 55K-70K MILEAGE SEEMS TO BE A VERY COMMON PROBLEM. THERE ARE MANY SHOPS WHO WILL REBUILT THESE TIPMS AS ITS A VERY KNOWN ISSUE. THIS IS ALSO A SERIOUS PROBLEM AS IT WOULD SHUT OFF THE VEHICLE AND HOW START, LEAVING PASSENGERS STRANDED
NHTSA complaint #11376951 — an unverified report by a vehicle owner.