2005 Volkswagen Touareg fuel system problems

FUEL SYSTEM, GASOLINE

The contact owns a 2005 Volkswagen Touareg. The contact stated that while driving approximately 30 MPH, the vehicle stalled. The contact pulled over and attempted to restart the vehicle, but the vehicle failed to restart. The contact stated there was no warning light illuminated. The contact had the vehicle towed to the residence. The contact had not taken the vehicle to a dealer or an independent mechanic. The vehicle was not diagnosed nor repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 17V583000 (Fuel System, Gasoline); however, the VIN was not included. The failure mileage was approximately 99,000.

NHTSA complaint #11621518 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

The issue explained in Recall Notice 20Ai has reappeared after being 'fixed'. Issue Summary: On certain vehicles, the fuel pump flange may develop fine cracks or fissures, which could result in a fuel leak. Leaking fuel, in the presence of an ignition source, could lead to a fire causing injury and/or damage to property. Date of Recall Repair: 02/25/2019 Date of noticed failure: 08/07/2023 It has not been communicated that this part will continue to be a hazard, and I have now discovered that even when noted that this recall action has been completed, my vehicle has gasoline leaking into the passenger compartment via the same avenue as Recall 20Ai notes. This is highly concerning as all impacted VW Touaregs that were 'recalled' may still be at risk of vehicle fire or ignition.

NHTSA complaint #11537153 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Gas leak (see pics). I started noticing a strong gasoline smell and my car keeps running out of gas almost immediately after filling up. This has not been inspected nor confirmed by a dealer. This is my only source of transportation and needs to be fixed ASAP. There is not a VW dealership where I live, the closest being in Mario, IL, or St. Louis, MO.

NHTSA complaint #11477238 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

My vehicle is leaking gas, I was told there is a recall on my vehicle so I took it into the volkswagen dealership where I was told that the recall only covers the driver side leak but not the passenger side leak which makes absolutely no sense. Because when I drive off of the service lot the problem still exists which means I could be blown up or cause injury of fire. This recall should cover ALL aspects of the fuel leak! Not just one side! Making customers pay for this is disgusting! I am a single mom and don't have an extra $600 to spend on an issue that should have been corrected by the manufacturer.

NHTSA complaint #11431381 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

PASSENGER AIRBAG WARNING LIGHT ON DASH SHOWS AIRBAG WILL NOT DEPLOY IN A CRASH. WATER COMES FROM BEHIND DASHBOARD ONTO DRIVERS AND PASSENGER SIDE FLOOR BOARD WHEN TURNING WHILE DRIVING LIKELY CAUSE BY CLOGGED AC DRAINS BEHIND WHEEL WELLS. FUEL PUMP PREMATURE FAILURE, AFTER REFUELING. HEADLINER FALLING FROM CEILING ON TO DRIVER AND PASSENGERS WHILE DRIVING ON HIGHWAY, WEATHER WAS HOT AND HUMID.

NHTSA complaint #11291763 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I TOOK MY SUV TO THE DEALERSHIP FOR A FUEL PUMP RECALL, ABOUT 3,000 MILES AFTER MY SUV IS CAUSING PROBLEMS LIKE START BUT TURN OFF WITHIN 40 SECONDS. I TOOK IT TO A LOCAL MECHANIC FOR DIAGNOSIS AND HE SAYS IS THE FUEL PUMP. I CONTACTED THE DEALERSHIP BUT THEY ARE KIND OF UNRESPONSIVE...NO ADVISORS AVAILABLE, NO RETURNED CALLS (VOLKSWAGEN SOUTH COAST SANTA ANA CA).

NHTSA complaint #11255351 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHEN I GET GAS FOR MY TOUAREG 2005 I'LL SHUT THE SUV OFF POP OPEN THE FUEL BOX DOOR AND PUT THE GAS IN THEN AS I PUT CAP BACK ON SHUT DOOR GET IN THE SUV I TRY TO START THE SUV BUT IT SEEMS AS IF THE CARS EITHER OUT OF GAS OR BATTERY HAS DIED SO AFTER THE FIRST LIKE SAY 4-6 TIMES OF THIS HAPPENING TO ME I TRIED TO LEAVE THE CAR RUNNING AS I PUT THE GAS IN THE SUV IN HOPES OF IT STILL REMAIN ON AND RUNNING BUT SURE ENOUGH THE SUVS BATTERY LIGHT WILL POP ON AND THE CAR WILL LOSE LIFE BUT THE LIGHTS AND STUFF STILL REMAIN ON BUT NO DRIVING HAPPENING SO I'D HAVE TO TURN THE KEY OFF THEN TRY AND START IT UP AGAIN BUT AS I TURN THE KEY I'LL HAVE TO PUMP THE GAS PEDDLE A BUNCH TO CATCH THE FLOW I GUESS

NHTSA complaint #11139893 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

OVERALL LIFE OF CAR HAVE HAD TO REPLACE THE MAJORITY OF THE HOSES IN THE ENGINE, THE FUEL LINE, THE EMERGENCY BRAKE RELEASE LEAVOR-3 TIMES, THE HORN ON THE PASSENGER AND DRIVERS SIDE. AND WITH THE RECALL THE GAS FLANGE - CRACKING. THE PRODUCT VW USES IN THIS VEHICLE IS INFERIOR- PLASTIC EXPANDS WHEN HOT AND CONTRACTS WHEN COLD= CRACKING. PLEASE RECALL THIS VEHICLE DUE TO THE POTENTIAL OF THE GAS FLANGE OR WHATEVER ELSE IS RELATED TO THE GAS BEFORE ANYONE IN MY FAMILY OR OTHERS DIE. OR MY CAS GOES UP INTO FLAMES CAUSING SEVERE TRAUMA- ESPECIALLY BECAUSE YOU ALREADY KNOW THERE IS A PROBLEM. WE HAVE PAID THOUSANDS OF DOLLARS IN REPAIR COSTS IN THIS VEHICLE THAT VW OF AMERICA WILL NOT HELP - THE ENTIRE ENTERRIER PLASTIC COATING TO THE VEHICLE HAS MELTED - THE DRIVERS SIDE VISITOR HANGS AS THE SPRING ACTION OR WHAT EVER IT'S CALLED IS BROKEN. WE HAVE OWNED MANY CARS, FORDS, TOYOTA'S, HONDA'S AND SEVERAL VWS. THE TOUAREG AND ALL OF PRIMARY SAFETY FEATURES SHOULD ALWAYS FUNCTION SAFELY-THE GAS ISSUE IS A MAJOR ISSUE THAT SHOULD AUTOMATICALLY BE A RECALL TO SAVE LIVES!

NHTSA complaint #11124546 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:DELIVERY

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN TOUAREG. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V583000. (FUEL SYSTEM, GASOLINE); HOWEVER, THE PARTS TO DO THE RECALL REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VOLKSWAGEN DEALER (PERRY VOLKSWAGEN, 12200 LOS OSOS VALLEY RD, SAN LUIS OBISPO, CA 93405, 805-544-5200) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA complaint #11102984 — an unverified report by a vehicle owner.

FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY

2005 VOLKSWAGEN TOUAREG. CONSUMER WRITES IN REGARDS TO THE FUEL FILTER FLANGE. *LD THE CONSUMER REQUESTED TO BE REIMBURSED FOR THE FUEL FILTER FLANGE RECALL.

NHTSA complaint #11089391 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

IN JUNE 2017, I NOTICED FUEL SMELL INSIDE THE VEHICLE. ON JULY 1, 2017, I INSPECTED THE ISSUE AND DISCOVERED THAT THE FUEL FILTER FLANGE WAS DAMAGED AND LEAKING FUEL (FUMES) CLOSE TO ELECTRICAL COMPONENTS AND UNDER THE SEAT WHERE MY SON SITS. PLEASE SEE THE ATTACHED PHOTO. I ORDERED THE RETAINER RINGS AND GASKETS (BOTH SIDES) FROM A VW DEALERSHIP. ON JULY 14, 2017, I ORDERED TA NEW FUEL FILTER FLANGE FROM A SELLER ON EBAY THAT SPECIALIZES IN NEW VW PARTS. THE FUEL FILTER FLANGE WAS NEW AND MANUFACTURED BY VDO (CONTINENTAL). I INSTALLED ALL THE PARTS TOWARDS THE END OF JULY 2017 AND THIS FIXED THE PROBLEM. I ACTUALLY REPLACED BOTH SIDES (DRIVER & PASSENGER) BECAUSE BOTH SIDES ARE A PROBLEM. PLEASE KEEP IN MIND THAT I WASN'T OR SHOULDN'T HAVE WAITED UNTIL THE RECALL NOTICE. THIS WAS A SERIOUS SAFETY FLAW AND NEEDED TO BE FIXED IMMEDIATELY. I HAVE A GOOD KNOWLEDGE IN MECHANICS AND CAPABLE TO PERFORM MOST REPAIRS. I DIDN'T DRIVE THE CAR UNTIL I RECEIVED THE PARTS AND FIXED THE ISSUE. I SUBMITTED MY RECEIPTS FOR REIMBURSEMENT UNDER THE RECALL. PLEASE SEE THE LETTER FROM VW DENYING ANY REIMBURSEMENT. THEY CLAIM THAT MY PARTS WERE NOT NEW AND NOT VW APPROVED PARTS. THE RETAINER RING & GASKET WAS PURCHASED BY A VW DEALERSHIP AND THE FUEL FILTER FLANGE WAS NEW AND MANUFACTURED BY VDO, WHICH IS THE OE COMPANY THAT MAKES THEM FOR VW. VOLKSWAGEN OF AMERICA IS CLEARLY NOT TAKING THIS ISSUE SERIOUS AND DOESN'T CARE ABOUT THE SAFETY OF ITS CONSUMERS. THEY ARE DENYING CLAIMS FOR REIMBURSEMENT AND DISREGARDING THIS SERIOUS ISSUE. I HAD NO CHOICE AND FIXED THE ISSUE IMMEDIATELY.

NHTSA complaint #11080663 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

VEHICLE CABIN COULD SMELL GAS, FACTORY ISSUED LETTER TO US WITH RECALL AND FREE REPAIR AND REPLACEMENT, BUT AFTER CONTACT VW DEALERSHIP, THE DEALERSHIP REFUSE TO REPAIR IT FOR FREE, QUOTE 480 DOLLARS FOR FIXING THIS RECALL ISSUE.

NHTSA complaint #11066916 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

GASOLINE LEAKING FROM THE TANK RUNS OVER THE RIGHT-SIDE EXHAUST TUBES TO THE GROUND. THE FLOW OF THE FUEL LEAKAGE IS VERY HIGH AT A DROP-RATE OF MORE THAN ONE DROP PER SECOND WITH THE VEHICLE PARKED AND THE ENGINE RUNNING AT IDLE SPEED. ONCE THE ENGINE IS TURNED OFF THE LEAKAGE STOPS WITHIN SHORT TIME. I GOT AWARE OF THE DEFECT DUE TO THE STRONG GASOLINE SMELL AFTER STOPPING AND GETTING OFF THE VEHICLE. I INVESTIGATED AND SAW GASOLINE DROPPING TO THE GROUND BETWEEN THE REAR WHEELS. THE FACT THAT THE FUEL IS RUNNING OVER THE EXHAUST TUBE MADE ME GROUND THE VEHICLE IMMEDIATELY FOR SAFETY REASONS. ALTHOUGH I NEED THIS VEHICLE I DECIDED TO KEEP IT GROUNDED DUE TO THE HIGH RISK THAT THE GASOLINE GETS IGNITED BY THE HOT EXHAUST TUBE.

NHTSA complaint #11047622 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN TOUAREG. WHILE THE VEHICLE WAS PARKED, THERE WAS AN ODOR OF FUEL EMITTED IN AND AROUND THE VEHICLE, MOSTLY ON THE PASSENGER SIDE AND THE REAR OF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V151000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL AND DID NOT OFFER FURTHER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

NHTSA complaint #11030031 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

FUEL LEAKING AT FUEL PUMP FLANGE. STRONG FUEL VAPOR ODOR IN THE CABIN WHILE DRIVING AND PARKED.

NHTSA complaint #11021518 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

THE TOP OF THE FUEL FILTER HOUSING CRACKED AND WAS LEAKING FUEL. THIS HOUSING IS UNDERNEATH THE REAR SEAT BEHIND THE DRIVER'S SEAT. THE CRACKS WEREN'T RELATED TO USAGE OF THE VEHICLE OR AN ACCIDENT. IT APPEARS TO BE GENERAL DETERIORATION OF THE PLASTIC. THIS IS THE SAME PROBLEM COVERED BY VW RECALL 20Z4 OR NHTSA REFERENCE #17V151000. HOWEVER THOSE ONLY COVER VEHICLES BACK TO 2007.

NHTSA complaint #10995705 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

SMALL CRACKS DEVELOPED IN THE FUEL FILTER FLANGE ON THE FUEL TANK RESULTING IN FUEL LEAKING OUT WHEN THE DRIVERS DOOR WAS OPENED OR WHEN THE CAR WAS RUNNING. THIS RESULTED IN LARGE AMOUNTS OF GASOLINE LEAKING ONTO MY GARAGE FLOOR. THE FLANGE WAS REPLACED. THIS IS AN IDENTICAL PROBLEM THAT IS BEING EXPERIENCED BY THE AUDI Q7 WHICH HAS THE IDENTICAL VW PART NUMBER FOR THE AFFECTED PART. THE NHTSA RECALL NUMBER FOR THAT PROBLEM IS 16V60000 IF YOU HAVE A TOUAREG, PORSCHE CAYENNE, OR AUDI Q7 (THEY ALL HAVE THE SAME PART) AND YOU SMELL GASOLINE, DO NOT OPEN THE DRIVERS DOOR. DOING SO PRIMES THE FUEL SYSTEM PUTTING THE FLANGE UNDER PRESSURE CAUSING LARGE AMOUNTS OF FUEL TO LEAK OUT.

NHTSA complaint #10917541 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN TOUAREG. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE FUEL GAUGE DISPLAYED AN INACCURATE READING. IN ADDITION, THE FUEL TANK LEAKED GASOLINE CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS, WHO RECOMMENDED THAT THE VEHICLE BE INSPECTED BY AN AUTHORIZED DEALER. THE VEHICLE WAS NOT INSPECTED BY AN AUTHORIZED DEALER NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 141,323.

NHTSA complaint #10564758 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

SMELL OF GAS AFTER REFUELING -- APPARENTLY SIMILAR TO MERCEDE BENZ --DEALER REPORTS THE GASKETS AT THE TOP OF THE FUEL TANK HAVE FAILED FOR A REPAIR COST OF $8-900.00: WATER COOLED ALTERNATOR FAILURE REQUIRING $8-900.00

NHTSA complaint #10504036 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

VEHICLE HAS BEEN EMITTING AN ODOR OF GAS FOR SOME TIME. UPON INVESTIGATION, I FOUND THAT THE FUEL FILTER (ACCESSED UNDER THE REAR SEAT BUT PART OF THE FUEL TANK) HAD A 1/8" CRACK IN THE TOP OF THE FILTER ASSEMBLY. THIS CRACK WOULD LEAK GASOLINE WHILE THE ENGINE WAS RUNNING AND EVEN AFTER THE ENGINE STOPPED (LIKELY DUE TO THE FUEL SYSTEM STILL BEING PRESSURIZED). LEAKED GASOLINE WAS FOUND THROUGHOUT THE TOP OF THE GAS TANK OBSERVED THROUGH TWO PORTS UNDER THE REAR BENCH SEAT. I DID SOME RESEARCH ON A POPULAR TOUAREG WEBSITE AND FOUND THAT 1 OR 2 OTHER PEOPLE HAVE EXPERIENCED THE SAME PROBLEM. I SUSPECT THIS IS A FIRE HAZARD GIVEN THE AMOUNT OF FUEL THAT HAS BEEN LEAKED. AND OTHERS HAVE EXPERIENCED A LEAK EMANATING FROM THE SAME LOCATION.

NHTSA complaint #10482487 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

FUEL SUPPLY LINE SEPARATED AT A CONNECTION BETWEEN HOSE AND FITTING THAT IS SECURED BY A PRESSURE CRIMP. LOCATION IS DIRECTLY ADJACENT TO AND ABOVE ENGINE BLOCK. MY ENGINE WAS COOL ENOUGH THAT A FIRE WAS NOT STARTED, BUT HAD THE ENGINE BEEN HOT IT CERTAINLY WOULD HAVE BEEN DISASTROUS.

NHTSA complaint #10233756 — an unverified report by a vehicle owner.

FUEL SYSTEM, OTHER

2005 V W TOUREG STALLED MANY TIMES, WHILE MAKING A TURN AT INTERSECTIONS AT LOWER SPEEDS, ESPECIALLY WHEN I AM TRYING TO ACCELERATE IT STALLS OR HESITATES. I CAME VERY CLOSE TO GETTING KILLED AT LEAST 5 TIMES, I TOOK IT TO MY LOCAL DEALER TO CHECK THIS PROBLEM, BUT ALWAYS CAME OUT EMPTY. THEY SAY THEY HAVE FOUND NO PROBLEM. I THINK IT IS VERY SERIOUS PROBLEM, AND IT SHOULD BE ADDRESSED PROMPTLY BEFORE PEOPLE LOOSE THEIR LIVES. I HAVE TALKED TO OTHERS WHO ARE DRIVING THIS KIND OF VEHICLE; AT LEAST HALF OF THEM HAD THE SAME KIND OF PROBLEM, AND WERE GETTING NO HELP FROM THEIR DEALERS.

NHTSA complaint #10208234 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

I CURRENTLY OWN A 2005 V-6 VOLKSWAGEN TOUAREG. THE VEHICLE HAS LESS THAN 15,000 MILES. APPROXIMATELY 3 MONTHS AFTER OWNING VEHICLE, THE VEHICLE EXEMPLIFIED OBVIOUS SHIFTING CONCERNS AS WELL AS POOR GAS MILEAGE. THE TRANSMISSION WAS REPLACED IN HOPES TO CORRECT THE ISSUES DESCRIBED ABOVE, HOWEVER, IT HAS NOT IMPROVED. I WAS ASKED TO DRIVE THE VEHICLE FOR AT LEAST ANOTHER 6 MONTHS TO A YEAR, TO BREAK IT IN. IN THIS TIME, MY CAR HAS WORSENED. THE SHIFTING IS MORE ERRATIC, LOSING POWER, JUMPING GEARS, AND NEARLY STALLING WHEN TAKING OFF FROM A STOP AND AT INTERSECTIONS. AS A RESULT OF THE ERRATIC SHIFTING, I HAVE BEEN NEARLY REAR-ENDED. MY CAR HAS BEEN IN 5 TIMES FOR 3 TO 8 DAYS AT A TIME. THE DEALERSHIP HAS NOT BEEN ABLE TO DUPLICATE THIS ISSUE, SINCE IT HAS REPLACED THE TRANSMISSION. THE ONLY SERVICE THE MANUFACTURER HAS DONE TO MY VEHICLE IN HOPES TO CORRECT THE POOR SHIFTING AND POOR GAS MILEAGE (11-12 MPG) IS COMPUTER SOFTWARE UPDATES. NONE OF WHICH HAVE EVER FIXED THE PROBLEMS. IN ADDITION, WITH EACH MONTH THAT PASSES, NEW MECHANICAL PROBLEMS ARISE. THE SEAT ADJUSTMENTS FAIL, ALONG WITH THE RADIO, THE TRUNK HATCH, THE AIRBAG, ETC. THE CAR OVERHEATS AND SMOKE COMES FROM THE TIRES & WHEELS, OF WHICH THE MANUFACTURER TOOK NOTICE TO, BUT COULD NOT DETERMINE THE CAUSE. THE SERVICE DEPARTMENT AT VOLKSWAGEN HAS HAD 5-6 ATTEMPTS TO SERVICE THE MULTIPLE PROBLEMS SINCE MAY 2005 AND IT IS NOW JANUARY 07 AND MY CAR IS STILL IN THE SHOP FOR THE SAME PROBLEMS. IN ADDITION, THE TIRES (W/ PADS/ROTORS (SP?) ARE COMPLETELY WORN, AND THE VEHICLE HAS ONLY 12K MILES.

NHTSA complaint #10180801 — an unverified report by a vehicle owner.