78 of the
669 complaints about the 2004 Volvo XC90 are about the
fuel system — 12% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
98,633 miles.
Unsure of what the issue is with the vehicle but smells like gas in my garage and I found a recall I was never notified about I moved from Washington to Las Vegas and never received any info regarding the fuel pump recall as well as a noise that’s been going on for a year now when I drive at 60 miles an hour I’ve had it looked at and no one seems to know what that issue is
NHTSA complaint #11626848 — an unverified report by a vehicle owner.
Erie, CO
FUEL/PROPULSION SYSTEM
Few days ago I came home, parked the car inside the garage and went inside. An hour later I went to the garage for something and noticed a very strong gasoline odor coming from the car. It is not coming from the reservoir and I did not put any fuel recently, so it can't be explained with a fuel spill. I suspect it is coming from the fuel pump. I as hoping or it to goo away, but it did not. It has been a week already.
NHTSA complaint #11522371 — an unverified report by a vehicle owner.
at 30,000 milesSan Marino, CA
FUEL SYSTEM, GASOLINE
The contact owns a 2004 Volvo XC90. The contact stated that after refueling the vehicle, his wife noticed an abnormally strong gasoline odor. The contact's wife was able to continue driving the vehicle; however, the failure would return after refueling or on rainy days. The contact related the failure to NHTSA Campaign Number: 09V483000 (Fuel System, Gasoline) however, the VIN was not included. The dealer and the manufacturer were notified of the failure and informed the contact that they could not assist as the VIN was not under recall. The vehicle was not diagnosed or repaired. The failure mileage was approximately 30,000.
NHTSA complaint #11492882 — an unverified report by a vehicle owner.
at 212,000 milesMinneapolis, MN
FUEL SYSTEM, GASOLINE
The contact owns a 2004 Volvo XC90. The contact stated that after his wife started the vehicle, she smelled the odor of gasoline. The contact had been advised by his wife that the vehicle was taking longer to start up and sometimes required two or three attempts to start the vehicle. The contact stated no warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The contact had researched online and related the failure to NHTSA Campaign Number: 09V483000 (Fuel System, Gasoline). The failure mileage was approximately 212,000.
NHTSA complaint #11487737 — an unverified report by a vehicle owner.
at 137,000 milesNEW York, NY
FUEL/PROPULSION SYSTEM
INSIDE SMELLS OF GASOLINE AFTER STARTING, AND WHILE DRIVING. PERSISTENT. NAUSEATING WHILE DRIVING. WINDOWS MUST BE LET DOWN WHILE DRIVING.
NHTSA complaint #11407036 — an unverified report by a vehicle owner.
ST Augustine, FL
FUEL/PROPULSION SYSTEM
THE FUEL PUMP UNDER THE BACK SEAT IS CRACKED AND LEAKING FUEL. THIS IS REFERENCED IN NHTSA RECALL NUMBER 09V483000. O'STEEN VOLVO IN JACKSONVILLE REFUSES TO ACKNOWLEDGE THERE WAS EVER A PROBLEM WITH THIS. IT IS ALL OVER THE INTERNET.THE VEHICLE IS NOT DRIVEABLE AS IS. THE CAR IS SOAKED WITH GASOLINE. APPARENTLY THE FUEL PUMP HOUSING DRIES OUT FROM HEAT AND CRACKS. WE NEED SOME HELP HERE. IT WOULD BE BETTER IF SOMEONE IN SAINT AUGUSTINE FLORIDA COULD DO THIS RECALL WORK FOR US AS WE REALLY DON'T WANT TO DEAL WITH O'STEEN AFTER THEY HAVE BLOWN US OFF.
NHTSA complaint #11396519 — an unverified report by a vehicle owner.
at 188,900 milesWilder, ID
FUEL/PROPULSION SYSTEM
A FEW YEARS AGO I RECEIVED A EXTENDED WARRANTY FOR A FUEL PUMP RECALL. MY FUEL PUMP IS NOW LEAKING GAS AND FILLING THE CAR WITH GAS FUMES. WHEN I CALLED THE VOLVO DEALER I WAS TOLD THAT THE EXTENDED WARRANTY WAS NO LONGER VALID AND IT WOULD COST $1,000.00 TO HAVE IT FIXED. I CALLED THE VEHICLE SAFETY HOTLINE AND WAS TOLD THAT MY VIN NUMBER WASN'T INCLUDED IN THE RECALL AND I WOULD NEED TO FILE A COMPLAINT. THE CAR IS 16 YEARS OLD AND IS IN GOOD CONDITION I FEEL THAT AS VOLVO KNOWS THAT THE FUEL PUMP IS A SAFETY ISSUE THAT ALL CARS THAT HAVE THE SAME FUEL PUMP ISSUE THAT ARE STILL DRIVING THE HIGHWAYS SHOULD BE INCLUDED IN THE RECALL. NOTHING HAPPENED OTHER THAN THE HEAVY FUEL SMELL THAT FILLS THE CAR WHEN DRIVING AND THE FUEL CAN BE SMELLED OUTSIDE OF THE CAR AFTER IT HAS BEEN TURNED OFF. I HAVE HAD THE CAR FIXED BUT THINK THAT THE FUEL PUMP ISSUE SHOULD STILL BE ADDRESSED. I DIDN'T HAVE AN ACCIDENT AND THERE WAS NO FIRE, BUT THERE COULD HAVE BEEN.
NHTSA complaint #11269044 — an unverified report by a vehicle owner.
at 74,800 milesBend, OR
FUEL/PROPULSION SYSTEM
RAW GAS SMELL. TOLD BY DEALER MAY BE DANGERS TO DRIVE AND PARK OUT OF GARAGE SO FUMES DON'T ACCUMULATE. GARAGE HAS NATURAL GAS HEAT AND GAS WATER HEATER. SOME CARS SOLD IN OTHER STATES HAVE HAD RECALLS, UNDER VOLVO RECALL # 220. THIS CAR HAS BEEN USED IN SOME STATES NAMED IN SUMMER MONTHS. I AM ORIG OWNER.
NHTSA complaint #11195010 — an unverified report by a vehicle owner.
at 113,223 milesBrooklyn Park, MN
FUEL/PROPULSION SYSTEM
BOUGHT THE VEHICLE WITH 112,000 MILES ON IT, IT HAS A GAS LEAK TRICKLING DOWN THE SIDE OF THE GAS TANK, PROBABLY A BAD SENDING UNIT, FUMES ARE BAD SOME DAYS BUT WORSE ON WARMER DAYS. THE TRANSMISSION FAILED ONE DAY WITH NO WARNING OR LIGHT, IT JUST LOST MOMENTUM AND FAILED TO ENGAGE IN DRIVE. I THINK THIS IS DUE TO THE POOR ENGINEERING DESIGN VOLVO USED. THIS MODEL IS THE T6 WITH THE GM 4T65E TRANSMISSION WHICH IS WIDELY KNOWN TO FAIL EVEN AT LOW MILES. I THINK A FULL SAFETY RECALL SHOULD E SANCTIONED FOR ALL MODEL YEARS WITH THESE HORRIBLE PROBLEMS
NHTSA complaint #11193422 — an unverified report by a vehicle owner.
at 108,000 milesSandy Springs, GA
FUEL/PROPULSION SYSTEM
WE SMELLED A GASOLINE ODOR AND THE "CHECK ENGINE" LIGHT CAME ON SO WE TOOK OUR VOLVO TO A DEALER TO INSPECT. THEY SAID THAT THERE WAS A CRACK IN THE TOP OF THE FUEL TANK. I AM THE ORIGINAL OWNER AND HAVE TAKEN METICULOUS CARE OF THIS VEHICLE SO THAT SOUNDED VERY STRANGE. THE CAR ONLY HAS 108,000 MILES IN 15 YEARS. I NOW SEE WHERE THIS MODEL WAS RECALLED FOR FUEL PUMP REPLACEMENT SEVERAL YEARS AGO BUT IT WAS WHILE I WAS OUT OF THE COUNTRY FOR TWO YEARS (2004-2006) ON A PROJECT FOR MY EMPLOYER. I HAD MY PARENTS KEEP THE CAR WHILE I WAS GONE AND NONE OF US RECEIVED THE NOTICE ABOUT THE RECALL. SHOULDN'T VOLVO STILL HAVE TO HONOR THIS RECALL SINCE I WAS NOT AWARE OF IT AT THE TIME? ACCORDING TO YOUR RECALL CAMPAIGN 09V-483 MY CAR WOULD HAVE BEEN INCLUDED IN THE RECALL GROUP, ALTHOUGH MY VIN NUMBER DOESN'T SHOW UP UNDER THE RECALLS NOW...COULD IT BE THAT THE CAMPAIGN IS OVER SO IT DOESN'T SHOW UP NOW? VOLVO CUSTOMER CARE KNEW ABOUT THIS PROBLEM WHEN I CALLED THEM ON FRIDAY BUT ARE HEMMING AND HAWING ABOUT DOING ANYTHING ABOUT IT. IT SEEMS A CRACKED FUEL TANK COULD CATCH FIRE.
NHTSA complaint #11082389 — an unverified report by a vehicle owner.
at 130,000 milesRoanoke, VA
FUEL/PROPULSION SYSTEM
VEHICLE SMELLS LIKE GASOLINE WHEN STOPPED AND PARKED, AND WHEN DRIVING. THE SMELL SEEMS TO BE STRONGEST AT THE RIGHT REAR OF THE VEHICLE WHEN PARKED OUTSIDE. WHEN PARKED IN THE GARAGE, THE GASOLINE SMELL WOULD BE EXTREMELY STRONG AND START COMING INTO THE HOUSE. IT WAS SEVERE ENOUGH I OPENED THE GARAGE DOOR MANUALLY BECAUSE I WAS AFRAID OF BLOWING UP THE ENTIRE HOUSE. IT IS NOW STAYING PARKED IN THE DRIVEWAY BECAUSE THE SMELL IS SO BAD. THERE IS A RECALL ON CERTAIN VIN NUMBERS, HOWEVER VOLVO SAYS MINE IS NOT AFFECTED BY THE RECALL THAT WOULD FIX THE SMELL. THE RECALL APPEARS TO HAVE BEEN SET UP BY STATE IN WHICH THE VEHICLE WAS ORIGINALLY PURCHASED, NOT NECESSARILY VEHICLES WITH THE PART IN QUESTION. THE STATE WHERE THE VEHICLE HAS BEEN SINCE 2001 IS VIRGINIA. I SPOKE WITH MY LOCAL DEALERSHIP, WHO SIMPLY SAID TO BRING IT IN AND THEY COULD DIAGNOSE IT AT THEIR NORMAL RATES, AND THEY WOULD CHARGE FULL PRICE FOR PARTS AND LABOR. SPEAKING WITH A VOLVO USA REPRESENTATIVE GOT ME A BIT FURTHER WITH A 30% OFF PARTS COUPON. WHILE A NICE GESTURE, IT WOULD HAVE BEEN NICE TO INCLUDE VEHICLES THAT FELL OUTSIDE LISTED RECALLED VIN NUMBERS ON A CASE BY CASE BASIS. AT ANY RATE, THIS IS NOT AN OPTIONAL REPAIR, AS A GAS SMELL INDICATES GASOLINE VAPORS, WHICH ARE HIGHLY EXPLOSIVE.
NHTSA complaint #11078691 — an unverified report by a vehicle owner.
at 129,000 milesParks, AZ
FUEL/PROPULSION SYSTEM
WHEN STATIONARY THE CAR WILL HAVE A WET SPOT OF FUEL UNDER THE TANK AND WHEN WE COME TO A STOP YOU CAN SMELL FUEL. WHEN I LOOKED UNDER THE CAR YOU CAN SEE WHERE THE SIDE OF THE FUEL TANK WAS WET OR DRIPPING FUEL.
NHTSA complaint #11053743 — an unverified report by a vehicle owner.
at 52,000 milesMount JOY, PA
FUEL/PROPULSION SYSTEM
A FEW DAYS AGO I BEGAN TO SMELL FUEL IN THE REAR SEAT OF THE VEHICLE AND ON THE OUTSIDE. THE SMELL BEGAN TO GET WORSE AND LINGER FOR DAYS AFTER OPERATING IT. AFTER SOME RESEARCH I DETERMINED IT TO BE THE FUEL PUMP ISSUE THAT SIMILAR YEARS AND MODELS WERE RECALLED FOR IN 2009. MY VEHICLE WASN'T ON THE RECALL SINCE IT WAS PURCHASED IN PA RATHER THAN IN ONE OF THE SOUTHERN STATES. I TOOK IT TO THE DEALER AND THEY CONFIRMED IT WAS THE FUEL PUMP. VOLVO AGREED TO PAY FOR THE PART BUT NOT THE LABOR WHICH AMOUNTS TO $800. THESE FUELS PUMPS PRESENT AN EXTREME RISK FOR FIRE AND INJURY AND ALL VEHICLES SHOULD HAVE BEEN RECALLED AT VOLVOS EXPENSE. VOLVO SHOULD DO THE RIGHT THING AND PAY FOR THE REPAIRS OR NHTSA SHOULD FORCE THEM TO. JUST BECAUSE OF VEHICLE WAS PURCHASED IN ONE STATE VERSUS ANOTHER SHOULD NOT DICTATE WHETHER THEY ARE RECALLED OR NOT.
NHTSA complaint #11051486 — an unverified report by a vehicle owner.
Pasadena, CA
FUEL/PROPULSION SYSTEM
HI, WHEN DRIVING MY CAR UP ANY SLIGHT LITTLE HILL, I HAVE NO POWER AND IT DOESN'T SEEM TO WANT TO DRIVE. IT'S VERY FRUSTRATING!! I HAVE READ THERE ARE RECALLS IN THE FUEL PUMPS AND ALSO OTHER RECALLS WITH THE MODEL VOLVO XC90. I HOPE THEY CAN REPAIR IT AND PAY FOR IT!!
NHTSA complaint #11021310 — an unverified report by a vehicle owner.
at 170,000 milesChicago, IL
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING AT ANY SPEED, THE ODOR OF FUEL WAS PRESENT AND AN UNEXPLAINED WARNING INDICATOR ILLUMINATED. THE CONTACT ALSO STATED THAT THE VEHICLE LEAKED FUEL. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 170,000.
NHTSA complaint #10995338 — an unverified report by a vehicle owner.
at 170,000 milesWhite Salmon, WA
FUEL/PROPULSION SYSTEM
TL* THE CONTACT SERVICED A 2004 VOLVO XC90. WHILE PARKED, THE VEHICLE EMITTED A STRONG FUEL ODOR AND THERE WAS FUEL VISIBLE ABOVE THE FUEL PUMP. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP HOUSING AND FLANGE WERE DAMAGED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MAUFACTURER WAS MADE AWARE OF THE ISSUE. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
NHTSA complaint #10957849 — an unverified report by a vehicle owner.
at 114,000 milesMadison, WI
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
THERE IS A VERY STRONG SMELL OF GAS WHILE DRIVING AT ALL SPEEDS. THE SMELL GETS WORSE ON THE RIGHT HAND REAR PASSENGER SEAT WHEN PARKED. I TOOK IT IN FOR DIAGNOSIS AND WAS TOLD THERE IS A LEAK ON TOP OF THE FUEL PUMP. I CALLED TO VOLVO OF NORTH AMERICA SEE IF THERE IS A RECALL. THE LADY I TALKED TO WAS VERY NICE AND SEAMED KNEW EXACTLY WHAT I WAS TALKING ABOUT. IF THIS A PROBLEM WHY IS THERE NO RECALL IN ALL STATES IN USA.
NHTSA complaint #10923903 — an unverified report by a vehicle owner.
at 132,000 milesClinton, NC
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING, THERE WAS A STRONG ODOR OF FUEL IN THE VEHICLE. THE CONTACT NOTICED FUEL LEAKING ONTO THE GROUND. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM). THE FAILURE MILEAGE WAS 132,000.
NHTSA complaint #10891587 — an unverified report by a vehicle owner.
Fairhaven, MA
FUEL/PROPULSION SYSTEM
ON THE RIGHT REAR SIDE A SMELL OF GAS IS PRESENT WHEN I'M OUT SIDE THE CAR THE I CAN SMELL IT MORE
NHTSA complaint #10871969 — an unverified report by a vehicle owner.
Trenton, NJ
FUEL/PROPULSION SYSTEM
THERE HAS BEEN PROBLEMS WITH STEERING THE DRIVER SHAFTS THE FUEL PUMP AIRBAGS AND WHEELS MAKING A CLICKING NOISE WHILE DRIVING ON HIGHWAY. THE GAS SMELL IS ALWAYS INSIDE THE CAR AND MECHANIC HAS SAID IT'S FROM THE FUEL PUMP DEFECT DURING MANUFACTURER. ALONG WITH THE OTHER FORE-MENTION DEFECTS .VOLVO DOES NOT WANT TO ADDRESS ISSUES BECAUSE AGE OF CAR. THERE IS A DEFECTIVE SUNROOF THAT ALLOWS WATER TO LEAK INSIDE THE CAR DURING RAIN FALL . THERE HAS BEEN A TOP CLASS ACTION PLACED AGAINST VOLVO FOR THIS . THEY WANTED TO CHARGE ME $700 TO $800 FOR THIS DEFECT AND $1200 TO $1500 FOR FUEL PUMP .
NHTSA complaint #10861611 — an unverified report by a vehicle owner.
at 140,000 milesLemont, IL
FUEL/PROPULSION SYSTEM
FUEL LEAK AND SMELL PASSENGER REAR VEHICLE
NHTSA complaint #10840063 — an unverified report by a vehicle owner.
at 75,000 milesST Louis, MO
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE PARKED, THERE WAS A STRONG ODOR OF FUEL COMING FROM THE VEHICLE. THE SMELL WORSENED WHILE DRIVING. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPAIRED. THE REPAIRS WERE NOT PERFORMED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.
NHTSA complaint #10838975 — an unverified report by a vehicle owner.
at 69,000 milesBroadway, NJ
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT AFTER THE VEHICLE WAS PARKED, THERE WAS A FUEL ODOR EMITTING INSIDE THE REAR OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE AND THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 69,000.
NHTSA complaint #10823403 — an unverified report by a vehicle owner.
at 101,000 milesFort Thomas, KY
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHEN THE CONTACT ENTERED THE VEHICLE, THERE WAS AN ODOR OF FUEL INSIDE AND OUTSIDE THE VEHICLE. THE ODOR OF FUEL COULD BE SMELLED WHENEVER THE VEHICLE WAS DRIVEN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND IT WAS DISCOVERED THAT FUEL WAS LEAKING FROM THE VEHICLE, HOWEVER, THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 101,000.
NHTSA complaint #10806469 — an unverified report by a vehicle owner.
at 140,000 milesSAN Jose, CA
FUEL/PROPULSION SYSTEM
LOOKING FOR REPAIRS ON FUEL ISSUES,I READ IMPORTANT INFORMATION ON WHAT I WAS LOOKING FOR. MY VOLVO HAD STARTED TO SMELL LIKE GAS, MORE IN THE REAR RIGHT SIDES OR BACK SIDE. I HAD READ THAT IT MAYBE OR IS A RECALL ISSUE . I BOUGHT MY VOLVO IN 4/28/15 BEING ONLY THE SECOND OWNER,I NOTICED THE SMELL CALLED THE DEALER WHERE I BOUGHT THE CAR, THEY SUGGESTED A DIAGNOSTIC CHECK. CAME UP AS POSSIBLE VOLVO RECALL, SINCE A BOUGHT THE CAR AS IS THEY DIDN'T FIX IT, THEY DID SUGGEST ON CALLING VOLVO DIRECT FOR THIS ISSUE. I MADE A APPOINTMENT WITH AUTONATION VOLVO IN SAN JOSE CA ON 6/15/2015. WHEN SHOWING UP FOR SERVICE THEY DENIED THAT MY CAR WAS NOT A RECALL ON THAT PARTICULAR PROBLEM FUEL ISSUES, IT WAS A RECALL ON 157. I WAS SURPRISED BECAUSE I HAD GONE FOR A FUEL ISSUE NOT A SUSPENSION ISSUE. SO MY FUEL ISSUE IS STILL PRESENT. SO ALL I CAN SAY IS THAT MY ISSUE WITH MY VOLVO IS A RECALL WITCH VOLVO OF SAN JOSE CA DON'T WANT TO FIX BECAUSE ITS NOT IN THE YEAR, MODEL, MAKE. CLEARLY I HAVE THE MOBIL MAKE AND YEAR, 2004 XC90 VOLVO DO TO ALL THE INFORMATION FOUND. MYSELF AND MY HUSBAND DRIVE THIS CAR EVERY DAY PLUS MY 7 YR. OLD WITH MY NEWBORN PASSENGERS BEING A HAZARD TO MY FAMILY.WE TOOK IN THE VOLVO IN ON SATURDAY THE 10/17 OF 2015 BECAUSE THE SMELL IS REALLY BAD, WE NEED TO DRIVE WITH THE AC AT ALL TIMES BECAUSE THE SMELL OUTSIDE IS SO BAD. WE GOT REJECTED AGAIN, SAYING THE SAME MY CAR DOES NOT FALL IN THAT RECALL ALSO DO TO MY VIN NUMBER NOT MATCHING WHO KNOWS WHAT, I NEED THIS FIXED BAD. WE HAVE ALSO HAD PEOPLE TELL US ABOUT THE SMELL BEING STRONG. AS YOU CAN SEE ITS A SAFETY AND FIRE HAZARD FOR MY FAMILY'S SAFETY, AND AT THIS TIME FINANCIAL HARDSHIP IS IN ISSUE DO TO MATERNITY LEAVE TO BE PAYING SOMETHING THAT CLEARLY ITS A VOLVO ISSUE , I THINK VOLVO SHOULD TAKE THIS AS A BIG CONCERN. I DO HOPE THIS PROBLEM GETS RESOLVED AND DONE. THANK YOU FOR YOUR TIME AND WORK.
NHTSA complaint #10783188 — an unverified report by a vehicle owner.
Hoffman Estates, IL
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE IN PARK, THE CONTACT HEARD A NOISE. ALL THE WARNING LIGHTS ON THE INSTRUMENT PANEL FAILED TO ILLUMINATE AND THE VEHICLE STALLED. IN ADDITION, THE CONTACT STATED THAT THE ODOMETER DISPLAYED AN INCORRECT READING AND THERE WAS A FUEL ODOR IN THE VEHICLE. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BATTERY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TOWED BACK TO THE INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE VEHICLE WAS TAKEN TO ANOTHER INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CENTRAL ELECTRONIC MODULE AND THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #10716499 — an unverified report by a vehicle owner.
at 215,000 milesMiami Lakes, FL
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE THE VEHICLE WAS PARKED, AN EXTREMELY STRONG ODOR OF FUEL EMITTED NEAR THE FUEL TANK ON THE REAR PASSENGER SIDE. THE FUEL TANK EXHIBITED FUEL LEAKAGE, BUT THERE WAS NO FUEL VISIBLE ON THE GROUND. THE CONTACT EXPERIENCED THE SAME FAILURE AS MENTIONED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 215,000.
NHTSA complaint #10715374 — an unverified report by a vehicle owner.
at 143,000 milesRaleigh, NC
FUEL/PROPULSION SYSTEM
MY 2004 VOLVO XC90 WITH A 2.5T ENGINE, 7 PASS, INTERMITTENTLY AND INADVERTENTLY STALLS WHILE DRIVING IT. IT IS SCARY BECAUSE ALL ELECTRICAL GOES OFF, INSTRUMENT PANEL, RADIO, LIGHTS, ETC, SEVERAL WARNING MESSAGES APPEARS, SUCH ABS, AIR BAGS FAILURE, BRAKE FAILURE, ENGINE FAILURE, ETC. IT WON'T RESPOND TO ACCELERATION AND BRAKES ARE VERY HARD TO PUSH, THE ENGINE DOES NOT STOP. I HAVE TO STOP, TURN IT OFF, WAIT FEW MINUTES, THEN START IT, EVERYTHING COMES TO NORMAL AGAIN BUT WITH THE CHECK ENGINE AND THE AIR BAGS MESSAGE, THEN AFTER SOME MINUTES OF DRIVING THE SAME STALLING AND ELECTRICAL ISSUES HAPPEN AGAIN. THIS IS SERIOUS BECAUSE YOU ARE ON FREEWAY AND YOU LOOSE BRAKES AND ENGINE CONTROL, NO INFORMATION IN INSTRUMENT PANEL, ETC. I FOUND THAT THE RELAYS IN THE CEM (CONTROL ELECTRONICS MODULE) ARE SUPER HOT POSSIBLY DUE TO LOOSE CONNECTIONS, IN THE VIDEO BELOW YOU WILL SEE THE PROBLEMS AND INFRARED PICTURES OF THE CEM. PLEASE HELP!!!!!! PLEASE HELP!!!!!! PLEASE HELP!!!!!! PLEASE HELP!!!!!! PLEASE SEE MY YOUTUBE VIDEO AND OTHER VIDEOS WITH THE SAME ISSUE SEARCH FOR XC90 ISSUES, XC90 STALLING, XC90 ELECTRICAL PROBLEMS, ETC. HTTPS://WWW.YOUTUBE.COM/WATCH?V=FWULB1SKSIE&FEATURE=YOUTU.BE THANK YOU
NHTSA complaint #10713394 — an unverified report by a vehicle owner.
at 126,000 milesFair Lawn, NJ
FUEL/PROPULSION SYSTEM
TO WHOM IT MAY CONCERN: I CURRENTLY OWN A 2004 XC90 T6, AND HAVE NOW ENCOUNTERED THE SAME ISSUE TWICE WITH MY VEHICLE. LAST YEAR AROUND THE SAME TIME FRAME, THERE WAS A TERRIBLE SCENT OF GASOLINE FUMES THROUGHOUT THE CABIN AND EXTERIOR OF THE VEHICLE. THE STRONGEST CONCENTRATION OF THE ODOR OCCURRED AROUND THE BACKSEAT, PASSENGER SIDE. I TOOK THE VEHICLE TO MY MECHANIC AND IT WAS CONCLUDE THAT THE WAS A FUME LEAK OCCURRING FROM THE SEAL AROUND THE FUEL PUMP. I PURCHASED A NEW PUMP AND SEAL FROM VOLVO AND HAD THE UNIT REPLACED. EXACTLY AROUND THE SAME TIME OF THE YEAR, A YEAR LATER, I AM ENCOUNTERING THE SAME EXACT ISSUE AGAIN. THERE IS AN OFFENSIVELY STRONG ODOR FROM GASOLINE FUMES IN AND AROUND THE VEHICLE ORIGINATING IN THE SAME PLACE. I DID SOME RESEARCH ON THE WEB, AND IT LOOKS LIKE THERE HAVE BEEN HUNDREDS OF SIMILAR ISSUES REPORTED.
NHTSA complaint #10695100 — an unverified report by a vehicle owner.
SAN Marcos, CA
FUEL SYSTEM, GASOLINE
2004 VOLVO XC90. CONSUMER WRITES IN REGARDS TO A BROKEN FUEL PUMP AND LEAKING GAS. *SMD THE CONSUMER NOTICED A STRONG GAS SMELL IN THE GARAGE. THE CONSUMER DISCOVERED RECALL # 09V483000. HOWEVER, HE WAS NEVER INFORMED.
NHTSA complaint #10677140 — an unverified report by a vehicle owner.