Owners have filed 375 complaints
about the 2008 BMW 328I with NHTSA between 2011 and 2026.
The largest single group is the airbags.
Across this model's run it ranks 4 of 15 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 75
Against the median year of the BMW 328I. 50 means typical for this
model; 100 means roughly double.
Severity — 87
16.8% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 20
11% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Occupant Classification
829.6%
Crankcase (Pcv)
518.5%
Body
414.8%
Front Underhood
311.1%
Front Passenger
27.4%
Cables
27.4%
Door
27.4%
Sensor/Control Module
13.7%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
31.4%
1,000 – 9,999 miles
41.8%
10,000 – 24,999 miles
62.8%
25,000 – 49,999 miles
3516.1%
50,000 – 74,999 miles
4922.5%
75,000 – 99,999 miles
2913.3%
100,000 – 149,999 miles
6931.7%
150,000+ miles
2310.6%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Feb 2011peak 22Mar 2026
Complaints that involved harm
Reports where the owner recorded a crash, a fire, an injury or a death.
Freeport, TXFire
UNKNOWN OR OTHER
My vehicle engine cooling fan caught fire one evening while following behind someone to make sure they made it to a parking lot safely due to their own vehicle having problems requiring them to stay under around 20mph. Once we made it to a parking lot, i exited my vehicle to check on the other person, and realized there was smoke starting to come out from under my hood. My husband waited for me to pull the hood release and then proceeded to lift the hood, only to discover my car was on fire, and it was coming directly from the cooling fan. After almost a minute we were able to put the fire out, and discovered the whole electrical area for the fan was melted and destroyed. There was never any type of warning light or any information at all that would have told me a problem was imminent. Im thankful it wasn;t myself alone or with my kids just driving down the highway because it would have taken over the whole vehicle before i would have known it was having any issues at all. The part is still on the vehicle, which has become inoperable and now any attempts to check the vehicle out have realized that another issues with BMW's is also causing problems with my vehicle. It appears an actual recall was never issued for my actual VIN, rather a collection of years and makes. Any further information or remedy that might get me the ability to actually use my vehicle again would be greatly appreciated. I can also include photos and witness statements if needed,. Thank you for your time.
NHTSA complaint #11581845 — an unverified report by a vehicle owner.
Freeport, TXFire
ELECTRICAL SYSTEM
My vehicle engine cooling fan caught fire one evening while following behind someone to make sure they made it to a parking lot safely due to their own vehicle having problems requiring them to stay under around 20mph. Once we made it to a parking lot, i exited my vehicle to check on the other person, and realized there was smoke starting to come out from under my hood. My husband waited for me to pull the hood release and then proceeded to lift the hood, only to discover my car was on fire, and it was coming directly from the cooling fan. After almost a minute we were able to put the fire out, and discovered the whole electrical area for the fan was melted and destroyed. There was never any type of warning light or any information at all that would have told me a problem was imminent. Im thankful it wasn;t myself alone or with my kids just driving down the highway because it would have taken over the whole vehicle before i would have known it was having any issues at all. The part is still on the vehicle, which has become inoperable and now any attempts to check the vehicle out have realized that another issues with BMW's is also causing problems with my vehicle. It appears an actual recall was never issued for my actual VIN, rather a collection of years and makes. Any further information or remedy that might get me the ability to actually use my vehicle again would be greatly appreciated. I can also include photos and witness statements if needed,. Thank you for your time.
NHTSA complaint #11581845 — an unverified report by a vehicle owner.
Freeport, TXFire
ENGINE
My vehicle engine cooling fan caught fire one evening while following behind someone to make sure they made it to a parking lot safely due to their own vehicle having problems requiring them to stay under around 20mph. Once we made it to a parking lot, i exited my vehicle to check on the other person, and realized there was smoke starting to come out from under my hood. My husband waited for me to pull the hood release and then proceeded to lift the hood, only to discover my car was on fire, and it was coming directly from the cooling fan. After almost a minute we were able to put the fire out, and discovered the whole electrical area for the fan was melted and destroyed. There was never any type of warning light or any information at all that would have told me a problem was imminent. Im thankful it wasn;t myself alone or with my kids just driving down the highway because it would have taken over the whole vehicle before i would have known it was having any issues at all. The part is still on the vehicle, which has become inoperable and now any attempts to check the vehicle out have realized that another issues with BMW's is also causing problems with my vehicle. It appears an actual recall was never issued for my actual VIN, rather a collection of years and makes. Any further information or remedy that might get me the ability to actually use my vehicle again would be greatly appreciated. I can also include photos and witness statements if needed,. Thank you for your time.
NHTSA complaint #11581845 — an unverified report by a vehicle owner.
at 12,000 milesAlexandria, LAFire
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
The contact owns a 2008 BMW 328i. The contact stated upon turning off the vehicle after driving for approximately 2-3 hours, she smelled a burning plastic odor inside and outside of the vehicle. There were no warning lights illuminated. The contact stated that the failure had been reoccurring. The dealer and the manufacturer were not notified of the failure. The contact referenced NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The vehicle was not diagnosed or repaired. The approximate failure mileage was 12,000.
NHTSA complaint #11460178 — an unverified report by a vehicle owner.
at 102,000 milesDaly City, CAFire
ENGINE
The contact owns a 2008 328i. The contact stated while driving 30 MPH, the vehicle was making abnormal sounds. There was no warning light illuminated. The contact stated he smelled a burning odor and parked the vehicle. The contact looked under the hood and did not see any damage. The contact restarted the vehicle to drive home and heard a loud noise coming from the engine and vehicle started overheating. After arriving home, the contact opened the hood and became aware that the hood insulation was missing, and the PCV hose was leaking oil. The vehicle was towed to an independent mechanic and the vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 102,000.
NHTSA complaint #11456653 — an unverified report by a vehicle owner.
at 102,300 milesFresno, CAFire
ENGINE AND ENGINE COOLING
The contact owns a 2008 BMW 328i. The contact stated while driving at 25-30 MPH for 10 minutes, the engine started misfiring, went on overheating mode and stalled. The coolant temperature warning light illuminated. The contact was able to veer to the side of the road. The contact stated that he turned off the vehicle for some time; however, when he restarted the vehicle, the coolant temperature warning light was still illuminated. Additionally, the contact noticed white smoke coming from underneath the hood of the vehicle. The contact drove back to his residence. The contact stated that the failure had been reoccurring while driving and he could smell a burning odor . The contact became aware that his VIN was included in NHTSA Campaign Number: 22V119000 (ENGINE AND ENGINE COOLING), which he associated with the failure. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 102,300.
NHTSA complaint #11456353 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Alexandria, VA
AIR BAGS
RECALL OMISSION & SAFETY DISPUTE (Case #10683843): I am reporting two documented safety defects in my 2008 BMW 328i (N51 engine) that are identical to existing Federal Safety Recalls but have been omitted from the recall VIN list for this model year. 1. AIRBAG SYSTEM FAILURE (Recall 17V-428): The vehicle has a confirmed Fault Code 93C3 (Passenger Seat Occupancy Mat). This is the exact failure mode described in Recall 17V-428. This defect has deactivated the front passenger airbag system, as indicated by the red SRS warning light. The manufacturer has refused to address this as a safety recall, despite the component failing in the identical manner described in the 2006 model year recall. This creates an immediate risk of injury or death to front-seat passengers in the event of a crash. 2. ENGINE STALL RISK (Recall 23V-707): This vehicle utilizes the same aluminum VANOS housing bolts that are currently under Safety Recall 23V-707 for 2010–2012 models. These bolts are known to loosen and shear, causing sudden engine stalling while in motion. Despite the high risk of a high-speed stall and loss of power steering/braking, the manufacturer is excluding 2008 models from the recall remedy. DEALER/MANUFACTURER RESPONSE: The vehicle was inspected by a dealer in October 2024 (Invoice #156201), but the safety warning light was not documented on the repair order. A subsequent formal request for assistance (Case #10683843) was denied verbally by the manufacturer's regional management, who stated the vehicle is excluded from the recall based on its VIN, regardless of the active safety system failure. I am requesting a formal investigation into this Recall Omission to ensure these safety-critical repairs are provided to all affected vehicles.
NHTSA complaint #11721868 — an unverified report by a vehicle owner.
Alexandria, VA
ENGINE
RECALL OMISSION & SAFETY DISPUTE (Case #10683843): I am reporting two documented safety defects in my 2008 BMW 328i (N51 engine) that are identical to existing Federal Safety Recalls but have been omitted from the recall VIN list for this model year. 1. AIRBAG SYSTEM FAILURE (Recall 17V-428): The vehicle has a confirmed Fault Code 93C3 (Passenger Seat Occupancy Mat). This is the exact failure mode described in Recall 17V-428. This defect has deactivated the front passenger airbag system, as indicated by the red SRS warning light. The manufacturer has refused to address this as a safety recall, despite the component failing in the identical manner described in the 2006 model year recall. This creates an immediate risk of injury or death to front-seat passengers in the event of a crash. 2. ENGINE STALL RISK (Recall 23V-707): This vehicle utilizes the same aluminum VANOS housing bolts that are currently under Safety Recall 23V-707 for 2010–2012 models. These bolts are known to loosen and shear, causing sudden engine stalling while in motion. Despite the high risk of a high-speed stall and loss of power steering/braking, the manufacturer is excluding 2008 models from the recall remedy. DEALER/MANUFACTURER RESPONSE: The vehicle was inspected by a dealer in October 2024 (Invoice #156201), but the safety warning light was not documented on the repair order. A subsequent formal request for assistance (Case #10683843) was denied verbally by the manufacturer's regional management, who stated the vehicle is excluded from the recall based on its VIN, regardless of the active safety system failure. I am requesting a formal investigation into this Recall Omission to ensure these safety-critical repairs are provided to all affected vehicles.
NHTSA complaint #11721868 — an unverified report by a vehicle owner.
Alexandria, VA
SEATS
The vehicle’s "Passenger Airbag Off" light and dashboard SRS warning lamp are illuminated. A diagnostic scan using a BMW-specific tool confirms manufacturer Fault Code 93C3 (Passenger Seat Occupancy Detector). This indicates a hardware failure of the OC3 internal seat sensor mat. Safety Risk: The failure of this sensor prevents the vehicle from correctly identifying if an adult is in the passenger seat. This compromises the Supplemental Restraint System (SRS) and may result in the passenger airbag failing to deploy during a collision, posing a significant risk of injury or death to the occupant. Confirmation of Problem: The fault was confirmed via a digital diagnostic system (Foxwell NT510) which identified the specific "Open Circuit" within the seat mat. The component is currently installed in the vehicle and is available for inspection. Connection to Existing Recalls: This failure is identical in symptoms and fault code to those described in NHTSA Safety Recall 17V-428. Although this vehicle is the same year and model (2008 BMW 3-Series) as those covered in the recall, the VIN was excluded from the initial recall range. This appears to be a recall omission of a known manufacturing defect, as the failure occurred despite minimal use of the passenger seat.
NHTSA complaint #11711445 — an unverified report by a vehicle owner.
Alexandria, VA
AIR BAGS
The vehicle’s "Passenger Airbag Off" light and dashboard SRS warning lamp are illuminated. A diagnostic scan using a BMW-specific tool confirms manufacturer Fault Code 93C3 (Passenger Seat Occupancy Detector). This indicates a hardware failure of the OC3 internal seat sensor mat. Safety Risk: The failure of this sensor prevents the vehicle from correctly identifying if an adult is in the passenger seat. This compromises the Supplemental Restraint System (SRS) and may result in the passenger airbag failing to deploy during a collision, posing a significant risk of injury or death to the occupant. Confirmation of Problem: The fault was confirmed via a digital diagnostic system (Foxwell NT510) which identified the specific "Open Circuit" within the seat mat. The component is currently installed in the vehicle and is available for inspection. Connection to Existing Recalls: This failure is identical in symptoms and fault code to those described in NHTSA Safety Recall 17V-428. Although this vehicle is the same year and model (2008 BMW 3-Series) as those covered in the recall, the VIN was excluded from the initial recall range. This appears to be a recall omission of a known manufacturing defect, as the failure occurred despite minimal use of the passenger seat.
NHTSA complaint #11711445 — an unverified report by a vehicle owner.
Columbus, MS
VISIBILITY/WIPER
The wipers will wipe 5-6 times then stop. Sometimes mid windshield. Does not reset at any setting on the washer arm. Leads to an urgent stop on side of the road. It is available for inspection. I have tested while sitting in driveway and it does every time (of the 4 times I tested). Only way to reset is to turn off motor and remove key. No confirmation by mechanic. Reading online similar happenings and people replacing wiper relay. No inspection by dealer or others yet. No warning lights before.
NHTSA complaint #11695666 — an unverified report by a vehicle owner.
Hollister,, CA
ENGINE AND ENGINE COOLING
The contact owns a 2008 BMW 328I. The contact stated while driving 40 MPH, the check engine warning light illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic where it was diagnosed that the PCV heater needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 22V119000 (ENGINE AND ENGINE COOLING); however, the VIN was not included in the recall. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was unavailable.
NHTSA complaint #11669558 — an unverified report by a vehicle owner.
Grand Rapids, MI
ENGINE
My vehicle was not included in BMW Recall "23V-707: Replace Vanos Adjustment Unit Screw Connection" but has suffered the same failure described in this recall. My VANOS adjustment unit screws came loose and caused my engine to completely stall in the middle of traffic on a very busy road [XXX] ). I lost some braking ability and narrowly avoided a major collision. I've been having issues with misfires related to my VANOS system and today I found that despite being told my vehicle wasn't affected by the recall, it is experiencing the same issue as the recall above mentioned. My vanos adjustment unit bolts on both exhaust and intake sides of the engine were all much more loose than factory specification, so much so that I was able to remove 6 of them with my fingers alone. I think there should be a full safety recall on this issue as it seems to affect a much wider variety of cars than initially thought. I was able to re-tighten them to factory specs, but I have no confidence that it will stay that way. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11616928 — an unverified report by a vehicle owner.
at 170,000 milesRoyse City, TX
LATCHES/LOCKS/LINKAGES
The contact owns a 2008 BMW 328I. The contact stated while the vehicle was parked, the contact stated that the manual door locks became inoperable. The contact had to climb out of the driver's side window to exit the vehicle. The contact was able to enter the vehicle by using the key fob. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 170,000.
NHTSA complaint #11613049 — an unverified report by a vehicle owner.
Freeport, TXFire
UNKNOWN OR OTHER
My vehicle engine cooling fan caught fire one evening while following behind someone to make sure they made it to a parking lot safely due to their own vehicle having problems requiring them to stay under around 20mph. Once we made it to a parking lot, i exited my vehicle to check on the other person, and realized there was smoke starting to come out from under my hood. My husband waited for me to pull the hood release and then proceeded to lift the hood, only to discover my car was on fire, and it was coming directly from the cooling fan. After almost a minute we were able to put the fire out, and discovered the whole electrical area for the fan was melted and destroyed. There was never any type of warning light or any information at all that would have told me a problem was imminent. Im thankful it wasn;t myself alone or with my kids just driving down the highway because it would have taken over the whole vehicle before i would have known it was having any issues at all. The part is still on the vehicle, which has become inoperable and now any attempts to check the vehicle out have realized that another issues with BMW's is also causing problems with my vehicle. It appears an actual recall was never issued for my actual VIN, rather a collection of years and makes. Any further information or remedy that might get me the ability to actually use my vehicle again would be greatly appreciated. I can also include photos and witness statements if needed,. Thank you for your time.
NHTSA complaint #11581845 — an unverified report by a vehicle owner.
Freeport, TXFire
ELECTRICAL SYSTEM
My vehicle engine cooling fan caught fire one evening while following behind someone to make sure they made it to a parking lot safely due to their own vehicle having problems requiring them to stay under around 20mph. Once we made it to a parking lot, i exited my vehicle to check on the other person, and realized there was smoke starting to come out from under my hood. My husband waited for me to pull the hood release and then proceeded to lift the hood, only to discover my car was on fire, and it was coming directly from the cooling fan. After almost a minute we were able to put the fire out, and discovered the whole electrical area for the fan was melted and destroyed. There was never any type of warning light or any information at all that would have told me a problem was imminent. Im thankful it wasn;t myself alone or with my kids just driving down the highway because it would have taken over the whole vehicle before i would have known it was having any issues at all. The part is still on the vehicle, which has become inoperable and now any attempts to check the vehicle out have realized that another issues with BMW's is also causing problems with my vehicle. It appears an actual recall was never issued for my actual VIN, rather a collection of years and makes. Any further information or remedy that might get me the ability to actually use my vehicle again would be greatly appreciated. I can also include photos and witness statements if needed,. Thank you for your time.
NHTSA complaint #11581845 — an unverified report by a vehicle owner.
Freeport, TXFire
ENGINE
My vehicle engine cooling fan caught fire one evening while following behind someone to make sure they made it to a parking lot safely due to their own vehicle having problems requiring them to stay under around 20mph. Once we made it to a parking lot, i exited my vehicle to check on the other person, and realized there was smoke starting to come out from under my hood. My husband waited for me to pull the hood release and then proceeded to lift the hood, only to discover my car was on fire, and it was coming directly from the cooling fan. After almost a minute we were able to put the fire out, and discovered the whole electrical area for the fan was melted and destroyed. There was never any type of warning light or any information at all that would have told me a problem was imminent. Im thankful it wasn;t myself alone or with my kids just driving down the highway because it would have taken over the whole vehicle before i would have known it was having any issues at all. The part is still on the vehicle, which has become inoperable and now any attempts to check the vehicle out have realized that another issues with BMW's is also causing problems with my vehicle. It appears an actual recall was never issued for my actual VIN, rather a collection of years and makes. Any further information or remedy that might get me the ability to actually use my vehicle again would be greatly appreciated. I can also include photos and witness statements if needed,. Thank you for your time.
NHTSA complaint #11581845 — an unverified report by a vehicle owner.
Hazel Crest, IL
UNKNOWN OR OTHER
The vehicle, stopped while driving, overheating, no heat/ ac. It's winter, car stopped at night in an unknown location fory safety. Had it inspected by 2 different auto shops and was confirmed of the issue. Warning lights came on right before the car failed.
NHTSA complaint #11579798 — an unverified report by a vehicle owner.
Hazel Crest, IL
ENGINE
The vehicle, stopped while driving, overheating, no heat/ ac. It's winter, car stopped at night in an unknown location fory safety. Had it inspected by 2 different auto shops and was confirmed of the issue. Warning lights came on right before the car failed.
NHTSA complaint #11579798 — an unverified report by a vehicle owner.
Hazel Crest, IL
FUEL/PROPULSION SYSTEM
The vehicle, stopped while driving, overheating, no heat/ ac. It's winter, car stopped at night in an unknown location fory safety. Had it inspected by 2 different auto shops and was confirmed of the issue. Warning lights came on right before the car failed.
NHTSA complaint #11579798 — an unverified report by a vehicle owner.
Birmingham, AL
ENGINE AND ENGINE COOLING
The contact owns a 2008 BMW 328I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. An undisclosed dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11551066 — an unverified report by a vehicle owner.
West Melbourne, FL
ELECTRICAL SYSTEM
ON ALL E90 SERIES 3 (2008 BMW 328i), the PCV VALVE FAILS AND IS WELDED INTO THE VALVE COVER, THUS IF IT LEAKS OR GETS CRACKS IN THE ORANGE MEMBRANE, IT WILL CAUSE CAR TO STALL.. I ALMOST CRASHED 2x and this part should be recalled..IT AFFECTS THE FUEL AIR RATIO IN BMW E90, AND THE CAR WILL RUN LEAN AND NOT RECEIVE ENOUGH GAS AS AIR IS LEAKING FROM THE BROKEN MEMBRANE IN THE PVC VALVE. BMW WILL THROW ENGINE CODES WITH LIT CHECK ENGINE LIGHT ON DASH. THIS SHOULD BE A RECALL AS THE WHOLE VALVE COVER HAS TO BE REPLACED TO REPLACE A DEFECTIVE $10 PCV VALVE WHICH IS LUDICROUS...THE DEALER CHARGES thousand dollars and up to replace a ten dollar part. THE CAR HAS ROUGH IDLE AND WILL STALL, CREATING A DANGEROUS DRIVING SITUATION AND FATAL ACCIDENT . PLEASE RECALL to HAVE BMW DEALER FIX ThESE PLASTIC PVC VALVES ON E90S...I HAVE ENCLOSED PIC OF THE VALVE ..IT ALSO HAS A SPRING BUT THE PLASTIC ORANGE MEBRANE CRACKS, BREAKS AND LEAKS AIR INSIDE VALVE, CAUSING CHECK ENGINE CODES, ROUGH IDLE AND STALLING OF VEHICLE.. THE VALVE IS LOCATED ON TOP OF VALVE COVER, WELDED INTO VALVE COVER. PLEASE HELP..THANK YOU STATE FLORIDA P.S. HEAT CAUSES THE PCV MEMBRANE TO CRACK MORE~~PIC ENCLOSED OF PCV VALVE ITS WELDED INTO TOP VALVE COVER..NO OTHER CAR HAS A PCV VALVE MOUNTED THIS WAY SO WHOLE VALVE COVER NEEDS TO BE REPLACED~ THANK U
NHTSA complaint #11535228 — an unverified report by a vehicle owner.
West Melbourne, FL
ENGINE
ON ALL E90 SERIES 3 (2008 BMW 328i), the PCV VALVE FAILS AND IS WELDED INTO THE VALVE COVER, THUS IF IT LEAKS OR GETS CRACKS IN THE ORANGE MEMBRANE, IT WILL CAUSE CAR TO STALL.. I ALMOST CRASHED 2x and this part should be recalled..IT AFFECTS THE FUEL AIR RATIO IN BMW E90, AND THE CAR WILL RUN LEAN AND NOT RECEIVE ENOUGH GAS AS AIR IS LEAKING FROM THE BROKEN MEMBRANE IN THE PVC VALVE. BMW WILL THROW ENGINE CODES WITH LIT CHECK ENGINE LIGHT ON DASH. THIS SHOULD BE A RECALL AS THE WHOLE VALVE COVER HAS TO BE REPLACED TO REPLACE A DEFECTIVE $10 PCV VALVE WHICH IS LUDICROUS...THE DEALER CHARGES thousand dollars and up to replace a ten dollar part. THE CAR HAS ROUGH IDLE AND WILL STALL, CREATING A DANGEROUS DRIVING SITUATION AND FATAL ACCIDENT . PLEASE RECALL to HAVE BMW DEALER FIX ThESE PLASTIC PVC VALVES ON E90S...I HAVE ENCLOSED PIC OF THE VALVE ..IT ALSO HAS A SPRING BUT THE PLASTIC ORANGE MEBRANE CRACKS, BREAKS AND LEAKS AIR INSIDE VALVE, CAUSING CHECK ENGINE CODES, ROUGH IDLE AND STALLING OF VEHICLE.. THE VALVE IS LOCATED ON TOP OF VALVE COVER, WELDED INTO VALVE COVER. PLEASE HELP..THANK YOU STATE FLORIDA P.S. HEAT CAUSES THE PCV MEMBRANE TO CRACK MORE~~PIC ENCLOSED OF PCV VALVE ITS WELDED INTO TOP VALVE COVER..NO OTHER CAR HAS A PCV VALVE MOUNTED THIS WAY SO WHOLE VALVE COVER NEEDS TO BE REPLACED~ THANK U
NHTSA complaint #11535228 — an unverified report by a vehicle owner.
West Melbourne, FL
FUEL/PROPULSION SYSTEM
ON ALL E90 SERIES 3 (2008 BMW 328i), the PCV VALVE FAILS AND IS WELDED INTO THE VALVE COVER, THUS IF IT LEAKS OR GETS CRACKS IN THE ORANGE MEMBRANE, IT WILL CAUSE CAR TO STALL.. I ALMOST CRASHED 2x and this part should be recalled..IT AFFECTS THE FUEL AIR RATIO IN BMW E90, AND THE CAR WILL RUN LEAN AND NOT RECEIVE ENOUGH GAS AS AIR IS LEAKING FROM THE BROKEN MEMBRANE IN THE PVC VALVE. BMW WILL THROW ENGINE CODES WITH LIT CHECK ENGINE LIGHT ON DASH. THIS SHOULD BE A RECALL AS THE WHOLE VALVE COVER HAS TO BE REPLACED TO REPLACE A DEFECTIVE $10 PCV VALVE WHICH IS LUDICROUS...THE DEALER CHARGES thousand dollars and up to replace a ten dollar part. THE CAR HAS ROUGH IDLE AND WILL STALL, CREATING A DANGEROUS DRIVING SITUATION AND FATAL ACCIDENT . PLEASE RECALL to HAVE BMW DEALER FIX ThESE PLASTIC PVC VALVES ON E90S...I HAVE ENCLOSED PIC OF THE VALVE ..IT ALSO HAS A SPRING BUT THE PLASTIC ORANGE MEBRANE CRACKS, BREAKS AND LEAKS AIR INSIDE VALVE, CAUSING CHECK ENGINE CODES, ROUGH IDLE AND STALLING OF VEHICLE.. THE VALVE IS LOCATED ON TOP OF VALVE COVER, WELDED INTO VALVE COVER. PLEASE HELP..THANK YOU STATE FLORIDA P.S. HEAT CAUSES THE PCV MEMBRANE TO CRACK MORE~~PIC ENCLOSED OF PCV VALVE ITS WELDED INTO TOP VALVE COVER..NO OTHER CAR HAS A PCV VALVE MOUNTED THIS WAY SO WHOLE VALVE COVER NEEDS TO BE REPLACED~ THANK U
NHTSA complaint #11535228 — an unverified report by a vehicle owner.
at 100,000 milesCarson, CA
ENGINE AND ENGINE COOLING
The contact owns a 2008 BMW 328I. The contact stated while driving at various speeds, she noticed an abnormally strong burning odor coming from under the hood. There was no warning light illuminated. The contact stated that an independent mechanic had previously repaired the vehicle for a similar failure. The contact later received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) that she related to the failure. The local dealer was not contacted. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.
NHTSA complaint #11521668 — an unverified report by a vehicle owner.
at 170,000 milesSanta Maria, CA
ENGINE AND ENGINE COOLING
The contact owns a 2008 BMW 328I. The contact stated that after starting the vehicle, the check engine warning light illuminated. There was smoke coming from the engine compartment while the vehicle was shuddering. The vehicle was taken to an independent mechanic, where it was diagnosed that the PCV stem seals and cap needed to be replaced. The vehicle was repaired. The contact then received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) and took the vehicle to a local dealer for the repair; however, the contact was informed he would be responsible for the cost of the recall repair. The vehicle was not repaired. The manufacturer was made aware of the issue and advised the contact to seek legal advice to have the repair completed. The approximate failure mileage was 170,000.
NHTSA complaint #11518311 — an unverified report by a vehicle owner.
Laguna Beach, CA
ENGINE
2008 BMW 328I. CONSUMER WRITES IN REGARD TO LOSS OF POWER AND STEAM COMING FROM THE ENGINE. THE CONSUMER HAD THE VEHICLE TOWED TO THE NEAREST BMW TO PERFORM A RECALL. ON MARCH 13, 2023 THE VEHICLE WAS PICKED UP AFTER REPAIRS AND THE RED WARNING LIGHT ILLUMINATED AND ENGINE WAS STEAMING ONCE AGAIN.
NHTSA complaint #11516276 — an unverified report by a vehicle owner.
at 208,000 milesFresno, CA
STEERING
You guys have aluminum bolts that hold down the cylinder head they corrode or become loose thus pulling up the cylinder head and the head gasket is protruding out the front of the cylinder head causing oil and coolant to leak on to the belt causing the serpentine belt to slip off while it's raining and eventually causing a blown head gasket it's because of the aluminum bolts on the top of the engine that hold the cylinder head down the head gasket protrudes out the sides on the front where the camshaft sensors are and leaks onto the belt plus causing the belt to come off the track and possibly get sucked into the engine it's not something easy to get to or to fix for a person with low income
NHTSA complaint #11514696 — an unverified report by a vehicle owner.
at 208,000 milesFresno, CA
ENGINE
You guys have aluminum bolts that hold down the cylinder head they corrode or become loose thus pulling up the cylinder head and the head gasket is protruding out the front of the cylinder head causing oil and coolant to leak on to the belt causing the serpentine belt to slip off while it's raining and eventually causing a blown head gasket it's because of the aluminum bolts on the top of the engine that hold the cylinder head down the head gasket protrudes out the sides on the front where the camshaft sensors are and leaks onto the belt plus causing the belt to come off the track and possibly get sucked into the engine it's not something easy to get to or to fix for a person with low income
NHTSA complaint #11514696 — an unverified report by a vehicle owner.
at 114,000 milesVirginia Beach, VA
ELECTRICAL SYSTEM
The contact owned a 2008 BMW 328I. The contact stated while driving at an undetermined speed, there was smoke coming from the vehicle. The contact stated that the vehicle overheated. The check engine warning light was illuminated. The contact stated that the engine was misfiring. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the PCV valve heater was melted. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The contact stated that the vehicle had since been sold. The manufacturer was not notified of the failure. The failure mileage was approximately 114,000.
NHTSA complaint #11511586 — an unverified report by a vehicle owner.
at 114,000 milesVirginia Beach, VA
ENGINE AND ENGINE COOLING
The contact owned a 2008 BMW 328I. The contact stated while driving at an undetermined speed, there was smoke coming from the vehicle. The contact stated that the vehicle overheated. The check engine warning light was illuminated. The contact stated that the engine was misfiring. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the PCV valve heater was melted. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The contact stated that the vehicle had since been sold. The manufacturer was not notified of the failure. The failure mileage was approximately 114,000.
NHTSA complaint #11511586 — an unverified report by a vehicle owner.