Owners have filed 579 complaints
about the 1995 Chevrolet Astro with NHTSA between 1995 and 2017.
The largest single group is the brakes.
Across this model's run it ranks 1 of 13 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 100
Against the median year of the Chevrolet Astro. 50 means typical for this
model; 100 means roughly double.
Severity — 100
23.5% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 0
0% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 1995 compares with every other Chevrolet Astro
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
50,000 – 74,999 miles
37.9%
75,000 – 99,999 miles
821.1%
100,000 – 149,999 miles
2052.6%
150,000+ miles
718.4%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Feb 1995peak 20Jul 2017
NHTSA investigations into the 1995 Chevrolet Astro
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
EA02006Opened 31 May 2002Closed 23 Jul 2003VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
WINDSHIELD WIPER FAILURE
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00008Opened 16 Mar 2000Closed 31 Aug 2001SERVICE BRAKES, HYDRAULIC
LOSS OF POWER ASSIST
RQ99003Opened 8 Mar 1999Closed 31 May 2002VISIBILITY:WINDSHIELD WIPER/WASHER
WINDSHIELD WIPER
Recalls on the 1995 Chevrolet Astro
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
06E049000
EXTERIOR LIGHTING
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
06E043000
FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Risk: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
06E041000
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
CERTAIN R&B, INC. CENTRAL MULTIPORT FUEL INJECTION (CMFI) FUEL RETURN LINES, MODELS HELP 55163, NAPA BALKAMP 700-3270, AND THE CONNECTION 2560001, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE FUEL RETURN LINE HAS A MECHANICAL BLEED VALVE WHICH WAS NOT INSTALLED AT THE PROPER TORQUE.
Risk: A FUEL LEAK CAN OCCUR AT THE VALVE, POSSIBLY RESULTING IN A FIRE.
06E026000
EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
03V159000
VISIBILITY:WINDSHIELD WIPER/WASHER
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Risk: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
95V175000
SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
THESE VEHICLES WERE ASSEMBLED WITH THE LEFT-HAND LOWER CONTROL ARM-TO-FRAME REAR NUT NOT TIGHTENED TO THE SPECIFIED TORQUE.
Risk: LOW TORQUE CAN ALLOW THE ATTACHMENT BOLT TO LOOSEN AND SUBSEQUENTLY FATIGUE AND BREAK. THIS CAN RESULT IN SEPARATION OF THE LEFT-HAND CONTROL ARM FROM THE FRAME INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
THE FUEL LINES ATTACHED TO THE FUEL TANK WERE NOT PROPERLY TIGHTENED.
Risk: THESE FUEL LINES CAN LOOSEN TO THE POINT OF ALLOWING FUEL TO LEAK FROM THE LINES RESULTING IN A VEHICLE FIRE.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2003064323,584 units in Canada
Other
Certain vehicles (not involved in recall 98-150), may experience a windshield wiper failure due to cracked solder joints on the controller circuit board. If this were to occur in a severe weather situation, driver's visibility could be reduced, which could result in a vehicle crash without prior warning. Correction: Dealer will replace defective wiper motor until 7 years or 112 000 km from date vehicle was originally placed into service or for those vehicles currently outside of this coverage, until March 31 2004.
Recall 199516210 units in Canada
Steering
THE LEFT HAND LOWER CONTROL ARM TO FRAME REAR NUT MAY BE TIGHTENED BELOW THE SPECIFIED TORQUE. THIS MAY ALLOW THE ATTACHMENT BOLT TO LOOSEN AND SUBSEQUENTLY FATIGUE AND BREAK. BOLT BREAKAGE COULD RESULT IN SEPARATION OF THE LEFT HAND CONTROL ARM FROM THE FRAME CAUSING LOSS OF VEHICLE CONTROL AND A CRASH WITHOUT PRIOR WARNING. CORRECTION: DEALERS WILL TIGHTEN THE LEFT HAND LOWER CONTROL ARM TO FRAME REAR NUT TO THE PROPER TORQUE SPECIFICATION.
Recall 1994152420 units in Canada
Fuel System
THESE VANS MAY HAVE FUEL LINES ATTACHED TO THE FUEL TANK WITH LESS THAN THE SPECIFIED TORQUE. OVER TIME THESE FUEL LINES MAY LOOSEN TO THE POINT OF ALLOWING FUEL TO LEAK FROM THE LINES WHEN THE FUEL PUMP IS OPERATING. IN THE PRESENCE OF AN IGNITION SOURCE, AN UNDERHOOD FIRE COULD OCCUR. CORRECTION: DEALERS WILL LOWER THE TANK AND TIGHTEN THE FUEL LINES TO THE PROPER TORQUE.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 146,000 milesWashington, DCCrash1 killed
UNKNOWN OR OTHER
WHILE DRIVING ON 2 LANE ROAD HAD DRIVER TO DRIVER FRONT END COLLISION. FRONT VEHICLE GAVE WAY AND CRUSHED. THE DRIVER WAS TRAPPED AND HAD TO BE CUT OUT. THEN TAKEN OUT SIDE SLIDING DOOR. 2ND VEHICLE ALSO AN ASTROVAN SIMILAR DAMAGE THE DRIVER DIED ON THE SCENE.
NHTSA complaint #10616555 — an unverified report by a vehicle owner.
Joliet, ILCrash
TIRES
1995 CHEVROLET ASTRO VAN, RIGHT REAR TIRE BLEW OUT, CAUSING UNIT 1 TO GO OFF THE ROAD STRIKING THE GAURDRAIL. *BF (OHIO TRAFFIC CRASH REPORT # 10-0395-90)*JB UPDATED 08/06/10
NHTSA complaint #10345508 — an unverified report by a vehicle owner.
at 135,000 milesCanton, MICrash1 injured
AIR BAGS
I WAS IN A CAR ACCIDENT GOING 40 MPH AND MY AIRBAG DID NOT DEPLOY. ALTHOUGH THE VEHICLE IS NO LONGER DRIVABLE I FEEL THIS IS A SAFETY ISSUE THAT MAT NEED TO BE CHECKED ON OTHER VEHICLES LIKE MINE.
NHTSA complaint #10218673 — an unverified report by a vehicle owner.
at 67,000 milesLA Crescent, MNCrash
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
DT*: THE CONTACT STATED, INTERMITTENTLY, WHILE THE ROAD CONDITIONS WERE WET AND SNOWY THE BRAKES DID NOT OPERATE CORRECTLY. THERE WAS NO PRESSURE IN THE BRAKE PEDAL AND THE VEHICLE WOULD NOT STOP, RESULTING IN AN ACCIDENT. THE CONTACT'S VEHICLE REAR ENDED A TRUCK. A POLICE REPORT WAS TAKEN. THERE WERE MULTIPLE REPAIRS MADE TO THE VEHICLE AT THE DEALERSHIP, BUT THE PROBLEM PERSISTED. UPDATED 06/07/2006. *AK
NHTSA complaint #10151710 — an unverified report by a vehicle owner.
Clearwater, FLCrash2 injured
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
I HAVE HAD PROBLEMS WITH MY 1995 ASTRO VAN 4.03L FROM THE DAY I BOUGHT IT HARD STARTING ASB LOCKING UP DEALER REPLACED EGR VALUE TWICE TOOK BACK WITH SAME PROBLEM 3 MONTHS LATER WAS TOLD NOTHING WRONG COMPUTER DIGITAL CHECK SAID SO NOW I HAVE GOTTEN 2 MECHANICS TO LOOK AT IT AND SAID THE EGR VALVE FUEL LIND STAYS OPEN POURING OUT GAS THEY WANT TO CHARGE MY 600.00 TO CLEAN OUT THE SLUGE THIS PROBLEM HAS BEEN GOING ON FOR 3 YEARS MY VAN NOW HAS 82000 MILES AND IT SOUNDS AND SMELLS LIKE A MAC TRUCK I ALSO HAS TO REPLACE TO WIPER MOTOR ABOUT 2 YEARS AGO AND I PAID FOR IT I JUST A NOTICE TO REPLACE IT IT NO CHARGE I CANT FIND THE ORGINAL RECEIPT SO I'M OUT ANOTHER120.00 FOR THAT REPAIR ALONG WITH THE 65.00 SO A LOCAL MECHANIC. CAN TELL ME THIS IS A DEFECT FROM CHEVROLET FOR MY ASTRO VAN I HAVE HAD THE BREAKS CHECKED BY THE DEALER ABOUT 6 TIMES THEY INFORMED ME I DIDN'T KNOW HOW TO USE ABS SYSTEM AND THEY WERE FINE IN ALL MY BRAKES LOCKED UP ON I4 IN FLORIDA LAST AUGUST TRYING TO AVOID AN ACCIDENT 4700.00 LATER I WAS IN THE DITCH BECAUSE THE BRAKES LOCKED UP AND MY VAN WENT SLIDING
NHTSA complaint #10041654 — an unverified report by a vehicle owner.
Clearwater, FLCrash2 injured
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
I HAVE HAD PROBLEMS WITH MY 1995 ASTRO VAN 4.03L FROM THE DAY I BOUGHT IT HARD STARTING ASB LOCKING UP DEALER REPLACED EGR VALUE TWICE TOOK BACK WITH SAME PROBLEM 3 MONTHS LATER WAS TOLD NOTHING WRONG COMPUTER DIGITAL CHECK SAID SO NOW I HAVE GOTTEN 2 MECHANICS TO LOOK AT IT AND SAID THE EGR VALVE FUEL LIND STAYS OPEN POURING OUT GAS THEY WANT TO CHARGE MY 600.00 TO CLEAN OUT THE SLUGE THIS PROBLEM HAS BEEN GOING ON FOR 3 YEARS MY VAN NOW HAS 82000 MILES AND IT SOUNDS AND SMELLS LIKE A MAC TRUCK I ALSO HAS TO REPLACE TO WIPER MOTOR ABOUT 2 YEARS AGO AND I PAID FOR IT I JUST A NOTICE TO REPLACE IT IT NO CHARGE I CANT FIND THE ORGINAL RECEIPT SO I'M OUT ANOTHER120.00 FOR THAT REPAIR ALONG WITH THE 65.00 SO A LOCAL MECHANIC. CAN TELL ME THIS IS A DEFECT FROM CHEVROLET FOR MY ASTRO VAN I HAVE HAD THE BREAKS CHECKED BY THE DEALER ABOUT 6 TIMES THEY INFORMED ME I DIDN'T KNOW HOW TO USE ABS SYSTEM AND THEY WERE FINE IN ALL MY BRAKES LOCKED UP ON I4 IN FLORIDA LAST AUGUST TRYING TO AVOID AN ACCIDENT 4700.00 LATER I WAS IN THE DITCH BECAUSE THE BRAKES LOCKED UP AND MY VAN WENT SLIDING
NHTSA complaint #10041654 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 187,000 milesDarien, IL
SUSPENSION
TAKATA RECALL UPON LEAVING MY CONDOMINIUM PARKING LOT, THERE IS A SLIGHT CURB YOU MUST DRIVE OVER BEFORE EXITING. THE LEFT LOWER CONTROL ARM CAME LOOSE WHILE MAKING A RIGHT TURN ONTO A LOCAL CITY STREET. RESULTING IN THE VEHICAL TO COLLAPSE ON THE DRIVERS SIDE OF THE CAR. THE FRAME IS RESTED ON THE FRONT LEFT TIRE, ALSO DAMAGING THE DRIVERS SIDE DOOR AS A RESULT. CONSIDERING THE FACTS, THE CAR WAS THEN COMPLETELY IMMOBILE. I HAD TO CALL A TOW COSTING $100 IN ORDER TO MOVE IT ABOUT 150 FT. BACK TO MY DESIGNATED PARKING SPACE. RECALL # 95V175000. THIS HAPPENED ON 07/05/2017.
NHTSA complaint #11003667 — an unverified report by a vehicle owner.
at 146,000 milesWashington, DCCrash1 killed
UNKNOWN OR OTHER
WHILE DRIVING ON 2 LANE ROAD HAD DRIVER TO DRIVER FRONT END COLLISION. FRONT VEHICLE GAVE WAY AND CRUSHED. THE DRIVER WAS TRAPPED AND HAD TO BE CUT OUT. THEN TAKEN OUT SIDE SLIDING DOOR. 2ND VEHICLE ALSO AN ASTROVAN SIMILAR DAMAGE THE DRIVER DIED ON THE SCENE.
NHTSA complaint #10616555 — an unverified report by a vehicle owner.
at 220,000 milesAnderson, AL
ELECTRICAL SYSTEM
PULLED INTO SHOPPING CENTER PARKING LOT ( 35MPH SLIGHT RIGHT TURN) STARTED TO TURN LEFT TO PARKING SPACE AND ENGINE CUT-OUT SUDDENLY WITHOUT WARNING. INCIDENT WAS RECORDED BY MY DASH CAM: HTTP://S247.PHOTOBUCKET.COM/USER/HCHICKPEA/MEDIA/VANPOWERCUTOUT_ZPSB0E071E6.MP4.HTML YOU CAN SEE THE FLASH OF A POLICE CAR GOING IN THE OPPOSITE DIRECTION AT ALMOST THE EXACT TIME OF THE ENGINE STOPPING. NO APPARENT IGNITION SWITCH PROBLEMS, NO ENGINE CHUGGING OR SOUNDS, LIGHTWEIGHT KEYCHAIN.
NHTSA complaint #10569448 — an unverified report by a vehicle owner.
at 220,000 milesAnderson, AL
ENGINE
PULLED INTO SHOPPING CENTER PARKING LOT ( 35MPH SLIGHT RIGHT TURN) STARTED TO TURN LEFT TO PARKING SPACE AND ENGINE CUT-OUT SUDDENLY WITHOUT WARNING. INCIDENT WAS RECORDED BY MY DASH CAM: HTTP://S247.PHOTOBUCKET.COM/USER/HCHICKPEA/MEDIA/VANPOWERCUTOUT_ZPSB0E071E6.MP4.HTML YOU CAN SEE THE FLASH OF A POLICE CAR GOING IN THE OPPOSITE DIRECTION AT ALMOST THE EXACT TIME OF THE ENGINE STOPPING. NO APPARENT IGNITION SWITCH PROBLEMS, NO ENGINE CHUGGING OR SOUNDS, LIGHTWEIGHT KEYCHAIN.
NHTSA complaint #10569448 — an unverified report by a vehicle owner.
at 200,000 milesStruthers, OH
STEERING
TL* THE CONTACT OWNS A 1995 CHEVROLET ASTRO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THERE WAS A SUDDEN LOSS OF POWER STEERING ASSIST. THE VEHICLE FAILED TO DECELERATE AS THE BRAKES WERE APPLIED. IN ORDER TO STOP THE FAILURE, THE CONTACT HAD TO POWER OFF THE ENGINE HOWEVER, THE FAILURE RECURRED TWICE ONCE RESTARTED. THE VEHICLE WAS TOWED TO THE CONTACT?S RESIDENCE WHERE THE CONTACT INDEPENDENTLY REPLACED THE POWER STEERING LINE. IN ADDITION, THE FUEL PUMP WAS FOUND TO BE FAULTY AND WAS ALSO REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. ...UPDATED 11-12-13 *BF THE FUEL PUMP WIRE CONNECTOR ON TOP OF THE FUEL PUMP INSIDE OF THE GAS TANK MELTED AND THE FUSE NEVER BLEW. THE CONSUMER ALSO STATED THE SECOND TIME THE POWER STEERING LINE BROKE, HE ALMOST CRASHED INTO A HOSPITAL.
NHTSA complaint #10548074 — an unverified report by a vehicle owner.
at 200,000 milesStruthers, OH
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1995 CHEVROLET ASTRO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THERE WAS A SUDDEN LOSS OF POWER STEERING ASSIST. THE VEHICLE FAILED TO DECELERATE AS THE BRAKES WERE APPLIED. IN ORDER TO STOP THE FAILURE, THE CONTACT HAD TO POWER OFF THE ENGINE HOWEVER, THE FAILURE RECURRED TWICE ONCE RESTARTED. THE VEHICLE WAS TOWED TO THE CONTACT?S RESIDENCE WHERE THE CONTACT INDEPENDENTLY REPLACED THE POWER STEERING LINE. IN ADDITION, THE FUEL PUMP WAS FOUND TO BE FAULTY AND WAS ALSO REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. ...UPDATED 11-12-13 *BF THE FUEL PUMP WIRE CONNECTOR ON TOP OF THE FUEL PUMP INSIDE OF THE GAS TANK MELTED AND THE FUSE NEVER BLEW. THE CONSUMER ALSO STATED THE SECOND TIME THE POWER STEERING LINE BROKE, HE ALMOST CRASHED INTO A HOSPITAL.
NHTSA complaint #10548074 — an unverified report by a vehicle owner.
at 105,000 milesHendersonville, TN
STRUCTURE:BODY:DOOR
THIS VEHICLE AMONG OTHER VEHICLES MADE BY GM AND GMC HAVE A DEFECTIVE DOOR LATCH THAT FAILS AND WILL NOT ALLOW THE DRIVER OR PASSENGER TO BE ABLE TO OPEN THE DOOR FROM THE INSIDE OR OUTSIDE TO GET OUT IN THE CASE OF AN ACCIDENT OR VEHICLE FIRE. THIS PROBLEM FOR SEVERAL YEARS AND GM DID NOTHING TO RECALL AND FIX THIS PROBLEM. THIS IS AN EXTREME SAFETY HAZARD THAT SHOULD HAVE BEEN CORRECTED. OWNERS ARE PUT AT EXTREME RISK FOR LOSING THEIR LIFE IN AN EVENT WHERE THEY NEED TO EXIT THE VEHICLE. PLEASE FORCE A RECALL SO THAT NO ADDITIONAL LOSE OF LIFE WILL OCCUR.
NHTSA complaint #10532015 — an unverified report by a vehicle owner.
at 105,000 milesHendersonville, TN
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
THIS VEHICLE AMONG OTHER VEHICLES MADE BY GM AND GMC HAVE A DEFECTIVE DOOR LATCH THAT FAILS AND WILL NOT ALLOW THE DRIVER OR PASSENGER TO BE ABLE TO OPEN THE DOOR FROM THE INSIDE OR OUTSIDE TO GET OUT IN THE CASE OF AN ACCIDENT OR VEHICLE FIRE. THIS PROBLEM FOR SEVERAL YEARS AND GM DID NOTHING TO RECALL AND FIX THIS PROBLEM. THIS IS AN EXTREME SAFETY HAZARD THAT SHOULD HAVE BEEN CORRECTED. OWNERS ARE PUT AT EXTREME RISK FOR LOSING THEIR LIFE IN AN EVENT WHERE THEY NEED TO EXIT THE VEHICLE. PLEASE FORCE A RECALL SO THAT NO ADDITIONAL LOSE OF LIFE WILL OCCUR.
NHTSA complaint #10532015 — an unverified report by a vehicle owner.
at 105,000 milesHendersonville, TN
STRUCTURE
THIS VEHICLE AMONG OTHER VEHICLES MADE BY GM AND GMC HAVE A DEFECTIVE DOOR LATCH THAT FAILS AND WILL NOT ALLOW THE DRIVER OR PASSENGER TO BE ABLE TO OPEN THE DOOR FROM THE INSIDE OR OUTSIDE TO GET OUT IN THE CASE OF AN ACCIDENT OR VEHICLE FIRE. THIS PROBLEM FOR SEVERAL YEARS AND GM DID NOTHING TO RECALL AND FIX THIS PROBLEM. THIS IS AN EXTREME SAFETY HAZARD THAT SHOULD HAVE BEEN CORRECTED. OWNERS ARE PUT AT EXTREME RISK FOR LOSING THEIR LIFE IN AN EVENT WHERE THEY NEED TO EXIT THE VEHICLE. PLEASE FORCE A RECALL SO THAT NO ADDITIONAL LOSE OF LIFE WILL OCCUR.
NHTSA complaint #10532015 — an unverified report by a vehicle owner.
at 125,810 milesNewark, NJ
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1995 CHEVROLET ASTRO. THE CONTACT SMELLED A STRONG GASOLINE FUEL ODOR AND THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC TEST. THE FAILURE WAS LOCATED AT THE FUEL INJECTOR. THE MANUFACTURER WAS CONTACTED BUT WOULD NOT ASSIST WITH THE REPAIR BECAUSE THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 06E041000 (FUEL SYSTEM, GASOLINE: DELIVERY: HOSES, LINES/PIPING, AND FITTINGS). THE VEHICLE WAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 125,810.
NHTSA complaint #10397462 — an unverified report by a vehicle owner.
at 175,000 milesRidgeland, WI
ELECTRICAL SYSTEM
TL*THE CONTACT OWNS A 1995 CHEVROLET ASTRO VAN. THE CONTACT STATED THAT WHENEVER THE BATTERY MALFUNCTIONED THE DOORS DO NOT UNLOCK FROM THE INSIDE OF THE VEHICLE. THE FAILURE WAS NOT DIAGNOSED BY A DEALER. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 175,000.
NHTSA complaint #10359272 — an unverified report by a vehicle owner.
Joliet, ILCrash
TIRES
1995 CHEVROLET ASTRO VAN, RIGHT REAR TIRE BLEW OUT, CAUSING UNIT 1 TO GO OFF THE ROAD STRIKING THE GAURDRAIL. *BF (OHIO TRAFFIC CRASH REPORT # 10-0395-90)*JB UPDATED 08/06/10
NHTSA complaint #10345508 — an unverified report by a vehicle owner.
at 132,889 milesLivingston, MT
TIRES
IRREGULAR RIDE AND TIRE LOSING AIR, SEPERATED W/ VISIBLE STEEL INSIDE SEARS AUTO BILLINGS,MT 2/18 WOULD NOT WARRANTY OR EXCHANGE TIRE WITH 9/32S MEASURED TREAD I NEED AN OUTLET IN 59047 OR 59718 AS SEARS IS 135 MILES AWAY.
NHTSA complaint #10260828 — an unverified report by a vehicle owner.
at 135,000 milesCanton, MICrash1 injured
AIR BAGS
I WAS IN A CAR ACCIDENT GOING 40 MPH AND MY AIRBAG DID NOT DEPLOY. ALTHOUGH THE VEHICLE IS NO LONGER DRIVABLE I FEEL THIS IS A SAFETY ISSUE THAT MAT NEED TO BE CHECKED ON OTHER VEHICLES LIKE MINE.
NHTSA complaint #10218673 — an unverified report by a vehicle owner.
Fairport, NY
TIRES
WHILE DRIVING ON AN INTERSTATE AT ABOUT 65 MILES PER HOUR, ONE OF OUR FIRESTONE FR 410 TIRES EXPLODED IN BUSY TRAFFIC, PLACING US IN A VERY DANGEROUS SITUATION. THE TIRE BLEW OUT ON BOTH SIDES, AND THE TREAD SEPARATED. THIS WAS A FRONT TIRE ON AN ALL-WHEEL-DRIVE VAN. PUTTING ON THE SPACE-SAVER SPARE IN THE DARK ON THE SHOULDER OF THE INTERSTATE WAS VERY NERVE-WRACKING AND HAZARDOUS. A STATE TROOPER GAVE US ADVICE AND WARNED US ABOUT HOW DANGEROUS THE SITUATION WAS. THE OTHER FRONT TIRE, UPON EXAMINATION AT A TIRE DEALER, ALSO HAD SEPARATING TREAD. THE TIRES ARE P21575R15. WE HAVE NEVER HAD A BLOWOUT OR TIRE PROBLEM THIS SEVERE. OF COURSE WE HAD TO BUY 2 NEW TIRES. WE WONDER IF THESE TIRES HAVE BEEN RECALLED OR IF THERE IS ANY WAY TO GET A REMEDY FOR OURSELVES AND WARN OTHERS WHO MAY HAVE THESE TIRES. WE FEEL WE COULD EASILY HAVE BEEN IN A VERY SERIOUS ACCIDENT. WE ARE ANGRY, NERVOUS, AND DISGUSTED.
NHTSA complaint #10197310 — an unverified report by a vehicle owner.
at 135,000 milesScarbro, WV
SUSPENSION
TL*THE CONTACT OWNS A 1995 CHEVROLET ASTRO. THE CONTACT STATED THAT THE TORSION BAR FAILED, WHICH INCREASED THE RISK OF A CRASH. THE DRIVER SIDE TORSION BAR WAS REPLACED PREVIOUSLY AND NOW THE PASSENGER SIDE HAS FAILED. THE VEHICLE IS UNABLE TO BE DRIVEN. THE WHEEL SCRAPES AGAINST THE FENDER WHEN ATTEMPTING TO MAKE A TURN. THE DEALER STATED THAT THEY UPGRADED THE PART BECAUSE THE BAR WAS TOO LONG. THE TORSION BAR FOR HIS VEHICLE HAS A NEW SIZE, THEREFORE, THE CONTACT WOULD NEED TO REPLACE BOTH SIDES. HE IS NOT WILLING TO PAY FOR THE REPLACEMENT. THE CURRENT MILEAGE IS 175,000 AND FAILURE MILEAGE WAS 135,000.
NHTSA complaint #10193568 — an unverified report by a vehicle owner.
at 103,234 milesKing George, VA
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
TL*THE CONTACT OWNS A 1995 CHEVROLET ASTRO. WHILE IN MOTION THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO COAST THE VEHICLE OFF THE ROAD. THE VEHICLE WAS TOWED TO A REPAIR SHOP AND THE FAILURE WAS DIAGNOSED AS NEEDING A NEW FUEL PUMP AND HARNESS. THE CONTACT HAS THE REPAIR INVOICE. THE CURRENT AND FAILURE MILEAGE WERE 103234.*AK UPDATE *4/23/07TR
NHTSA complaint #10185890 — an unverified report by a vehicle owner.
at 97,000 milesBuffalo Grove, IL
SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
DT*: THE CONTACT STATED WHILE DRIVING 40 MPH ON NORMAL ROAD CONDITIONS AN UNSUCCESSFUL ATTEMPT WAS MADE TO MAKE A RIGHT TURN. THERE WERE NO WARNING LIGHTS ILLUMINATED PRIOR THE INCIDENT. THE VEHICLE WAS TOWED TO THE NEAREST DEALERSHIP WHICH WAS NOT A GENERAL MOTORS DEALERSHIP. THEY DETERMINED THE LOWER ARM WAS DISENGAGED FROM THE FRAME DUE TO MATERIAL FATIGUE. THE MANUFACTURER WAS CONTACTED WHO INDICATED THE VEHICLE MUST BE TAKEN TO ANY GENERAL MOTORS DEALERSHIP TO PRODUCE A DIAGNOSIS. THE VEHICLE HAS NOT BEEN TAKEN TO THE GM DEALERSHIP YET. THE CONTACT EXPRESSED CONCERN BECAUSE THERE WAS A RECALL # 95V175000 AND A RECALL LETTER NEVER RECEIVED. THE VEHICLE WAS NOT DRIVABLE.
NHTSA complaint #10173399 — an unverified report by a vehicle owner.
Jackson, WI
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
FUEL PUMP FAILED 3 TIMES IN 3 YEARS TWICE WHILE DRIVING CAUSING LOSS OF CONTROL OF VEHICLE, NEARLY CAUSING A ACCIDENT.
NHTSA complaint #10166050 — an unverified report by a vehicle owner.
at 67,000 milesLA Crescent, MNCrash
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
DT*: THE CONTACT STATED, INTERMITTENTLY, WHILE THE ROAD CONDITIONS WERE WET AND SNOWY THE BRAKES DID NOT OPERATE CORRECTLY. THERE WAS NO PRESSURE IN THE BRAKE PEDAL AND THE VEHICLE WOULD NOT STOP, RESULTING IN AN ACCIDENT. THE CONTACT'S VEHICLE REAR ENDED A TRUCK. A POLICE REPORT WAS TAKEN. THERE WERE MULTIPLE REPAIRS MADE TO THE VEHICLE AT THE DEALERSHIP, BUT THE PROBLEM PERSISTED. UPDATED 06/07/2006. *AK
NHTSA complaint #10151710 — an unverified report by a vehicle owner.
at 133,000 milesPrinceton, IN
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
MY WIFE WAS TRAVELING SOUTHBOUND ON ROUTE 41 IN PRINCETON, INDIANA, AT APPROXIMATELY 55 - 60 M.P.H. UNEXPECTEDLY, AND WITHOUT HER COMMAND, THE CRUISE CONTROL ENGAGED ITSELF AND FORCED THE VEHICLE TO ACCELERATE RAPIDLY. PLEASE NOTE THAT SHE WAS NOT UTILIZING THE CRUISE CONTROL FUNCTION AT THE TIME. APPLYING THE BRAKES DID NOT HAVE THE EFFECT OF DISENGAGING THE CRUISE CONTROL. DRIVER WAS FIGHTING THE FORCE OF THE DRIVE TRAIN UNINTENDED ACCELERATION WITH FULL BRAKE FORCE, BUT THE VEHICLE WOULD NOT COME TO A SAFE STOP. FINALLY, MY WIFE HAD THE PRESENCE OF MIND TO PUT THE VEHICLE IN NEUTRAL TO DISENGAGE POWER TO THE REAR DRIVE WHEELS. SHE ACTIVATED THE PARKING BRAKE AND THE PRIMARY BRAKES TO STOP THE VEHICLE. ONCE FULLY STOPPED AT THE SIDE OF THE ROAD, SHE CALLED ME AT WORK FOR ASSISTANCE. WE HAD THE VEHICLE TAKEN TO A REPAIR SHOP AND WERE INFORMED THAT THE CRUISE CONTROL MODULE ON THE ENGINE FIREWALL HAD MALFUNCTIONED. THE TECHNICIAN UNPLUGGED THE ELECTRICAL CONNECTORS TO THE MODULE TO PERMANENTLY DISABLE IT.
NHTSA complaint #10146047 — an unverified report by a vehicle owner.
at 99,132 milesStevens Point, WI
SUSPENSION:FRONT:SPRINGS:TORSION BAR
I HAD JUST PARKED MY CHEVROLET ASTRO AWD IN THE GARAGE AND AFTER A FEW MINUTES THE DRIVERS SIDE TORSION BAR SNAPPED. THE FRONT END WAS SITTING ON THE SUSPENSION STOPS. I AM LUCKY THIS DIDN'T HAPPEN 10 MINUTES EARLIER WHILE I WAS DRIVING. IT COULD HAVE CAUSED AN ACCIDENT OR INJURIES. THE VEHICLE IS CURRENTLY SITTING IN THE GARAGE AWAITING REPAIR. THE UPDATED PARTS ARE GOING TO RUN ME $600 PLUS INSTALLATION. I CURRENTLY HAVE THE BROKEN TORSION BAR. I VEHICLE RESIDED IN UTAH AND DID NOT SEE WISCONSIN SALT UNTIL COUPLE YEARS AGO. THE BAR APPEARS TO BE SEVERELY CORRODED/PITTED AT THE BREAK.
NHTSA complaint #10137501 — an unverified report by a vehicle owner.
at 100,000 milesWyonna, MN
SUSPENSION:FRONT:SPRINGS:TORSION BAR
DT: THE TORSION BARS ARE BREAKING AND IT DROPS THE SUSPENSION. DO NOT HAVE ANY STEERING. CONSUMER'S WIFE WAS COMING OUT OF THE DRIVEWAY AND THE TORSION BAR. THE CONSUMER CONTACTED GM, THEY SAID THERE WAS NOT ENOUGH CAUSE. CONSUMER BELIEVED THAT THE SALT ON ROADWAY CAUSED THEM TO RUST. THIS HAPPENED ON JUNE 15, 2002. DID HAVE BOTH BARS REPAIRED AND SOLD THE VEHICLE.*AK
NHTSA complaint #10136168 — an unverified report by a vehicle owner.
at 66,000 milesFleetwood, PA
SUSPENSION:FRONT:SPRINGS:TORSION BAR
DT: WITHOUT WARNING THE TORSION BAR BROKE AND DROVE ITSELF INTO THE AXLE SHAFT WHICH ALSO HAD TO REPLACED.. THE DEALER FIXED THE PART, AND SAID IT WAS FORTUNATE THAT NO ONE WAS DRIVING WHEN IT HAPPENED. THE MANUFACTURER HAS NOT BEEN CONTACTED YET. THE REPAIR INCLUDED ALL FOUR OF THE TORSION BARS AND THE BRACKETS THEY FIT INTO. *AK THE FRONT LEFT SIDE AXLE SHAFT WAS REPLACED. (THE FRONT LEFT OF THE VAN DROPPED TO THE GROUND)
NHTSA complaint #10125471 — an unverified report by a vehicle owner.
Pensacola, FL
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
THE FUEL PUMP WENT OUT WHILE DRIVING DOWN THE ROAD AT 40MILES PER HOUR, THEREBY LOSING ALL POWER STEERING, BRAKES ETC. IS THE 3RD TIME IN 3 YEARS THIS HAS HAPPENED. FIRST TIME STOPPED AT RED LIGHT, STALLED AND REFUSED TO RESTART, 2ND TIME WAITING FOR BRIDGE TO CLOSE, TODAY GOING DOWN ROAD. COULD HAVE BEEN VERY SERIOUS. HAS BEEN REPLACED EACH TIME.
NHTSA complaint #10124251 — an unverified report by a vehicle owner.