2007 Chevrolet Aveo engine problems

ENGINE

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE VEHICLE SHUDDERED WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS DUE TO AN UNKNOWN ENGINE CYLINDER FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

NHTSA complaint #11340648 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE DRIVING 55 MPH, THE ACCELERATOR PEDAL FAILED TO OPERATE AND THE GEAR FAILED TO SHIFT AND WENT STRAIGHT INTO NEUTRAL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE COOLANT LEVEL SENSOR MODULE NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

NHTSA complaint #10946321 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE DRIVING 55 MPH, THE ACCELERATOR PEDAL FAILED TO OPERATE AND THE GEAR FAILED TO SHIFT AND WENT STRAIGHT INTO NEUTRAL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE COOLANT LEVEL SENSOR MODULE NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

NHTSA complaint #10946321 — an unverified report by a vehicle owner.

ENGINE

WHILE DRIVING ON I95 MY RPMS DROPPED TO ZERO WITHOUT WARNING AND I WAS ABLE TO GET IT OFF THE ROAD. THE TOW TRUCK DRIVER SAID THE ENGINE WAS BLOWN. IT HAD 63,504 MILES ON IT AND THE REQUIRED MAINTENANCE HAD BEEN DONE LESS THAN 1600 MILES EARLIER. NO LIGHTS OR WARNING. LUCKILY I WAS ABLE TO GET IT OFF THE ROAD SAFELY.

NHTSA complaint #10777949 — an unverified report by a vehicle owner.

ENGINE

THE GEARSHAFT WON'T COME OUT OF PARK. I HAD THIS REPAIRED AT THE DEALERSHIP ABOUT TWO YEARS AGO AND IT IS NOW HAPPENING AGAIN AND PAID $300 FOR A GROUND WIRE. MY CAR CURRENTLY HAS 90000 MILES ON IT. I WOULD LIKE TO FILE A FORMAL COMPLIANT REGARDING THE SAME ISSUE. PLEASE CONTACT ME ASAP I CAN BE REACHED AT [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #10715528 — an unverified report by a vehicle owner.

ENGINE

I WAS DRIVING ON THE HIGHWAY AND THE CAR SMELLED LIKE IT WAS BURNING. AND, SMOKE BEGAN TO COME FROM UNDERNEATH THE HOOD. I GOT OFF THE FREEWAY AND I PARKED THE CAR IN FRONT OF A STORE.. I OPENED THE HOOD AND A MIST OF SMOKE WAS FLOWING FROM THE TRANSMISSION. I THOUGHT MY CAR WAS GOING TO GO UP IN FLAMES BECAUSE IT SMELLED LIKE BURNING WIRES. I DON'T DRIVE MY CAR EVERYDAY SO I SHOULD NOT BE HAVING THESE PROBLEMS WITH MY CAR. I ALSO SAW OIL LEAKING FROM THE MANIFOLD. I ASKED MY BROTHER TO SEE IT AND THAT'SWHAT HE TOLD ME. I WAS AFRAID TO DRIVE MY CAR HOME. I DROVE IT SLOWLY HOME.

NHTSA complaint #10694713 — an unverified report by a vehicle owner.

ENGINE

TIMING BELT BREAKS TOO OFTEN. THE CAR HAS NOW HAD THE TIMING BELT REPLACE 3 TIMES SINCE I HAVE OWNED IT I BOUGHT IT AT 69,000 MILES I WAS REPLACED AT AROUND 74K THEN BROKE AND LEFT ME STRANDED ON THE SIDE OF THE ROAD AT NIGHT TIME AFTER HOURS AT 121K THEN HAS BROKE AGAIN AT 134K THIS IS SUPPOSED TO BE A 60K PART AND IS NOT LASTING LIKE IT SHOULD AND WHEN IT BREAKS CAUSES OTHER STUFF AROUND IT TO BE AFFECTED AS WELL. THE FIRST TIME I HAD TO REPLACE WATER PUMP, THE 2ND TIME WATER PUMP AS WELL AS ENGINE GASKETS AND IT COST ME $2600 TO FIX. THIS LAST TIME JUST THE WATER PUMP AND A WATER HOSE. THIS LAST TIME IT LEFT MY DAUGHTER STRANDED ON THE SIDE OF THE ROAD AFTER DARK ON HER WAY HOME FROM COLLEGE LUCKILY HER BOYFRIEND WAS ABLE TO COME PICK HER UP. THIS CAR IS NOTORIOUS FOR THE TIMING BELT ISSUE. ALL THREE TIMES THIS HAS BEEN REPAIRED BY 3 DIFFERENT SHOPS AND ALL THREE SAY THAT THIS CAR HAS MAJOR ISSUES DUE TO THE TIMING BELTS NOT BEING STURDY. CHEVY SHOULD BE REPLACING THESE CARS OR REFUNDING THE COST OF HAVING THESE REPAIRED YOU CAN'T EVEN RESELL TO PEOPLE DUE TO THIS ISSUE. ALSO I NEVER EVEN GOT A LETTER REGARDING THE HEAD LAMP RECALL. I AM JUST WONDERING IF CHEVY IS WAITING TILL PEOPLE BLOW UP IN THEIR CARS.

NHTSA complaint #10637826 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, AN UNUSUAL SMELL WAS EMITTED INTO THE VEHICLE. THE CONTACT WAS ABLE TO MANEUVER THE VEHICLE TO THE SIDE OF ROAD. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THE BURNING SCENT WAS OF OIL AND ANTIFREEZE. THE PROBLEM OCCURRED TWICE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED ABOUT THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 75, 000.

NHTSA complaint #10622554 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE DRIVING 10 MPH, THE ENGINE WARNING INDICATOR ILLUMINATED AND THE VEHICLE'S SPEED DECREASED. THE DEALER STATED THAT THE THROTTLE BODY SHORTED OUT. THE MECHANIC REPLACED THE THROTTLE BODY, PERFORMED A DOUBLE INTAKE SERVICE, AND TREATED THE FUEL WITH ETHANOL. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 10,966.

NHTSA complaint #10621692 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STATED THAT THERE WAS ENGINE OIL MIXING WITH THE ANTIFREEZE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE THROTTLE BODY SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 84,000.

NHTSA complaint #10609871 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

SEVERAL INCIDENTS OF ENGINE DYING WHILE TRAVELING AT FULL SPEED ON OPEN HIGHWAY. WITH POWER STEERING, BRAKES, ETC. SOMETIMES DIFFICULT TO GET OUT OF THE WAY OF TRAFFIC WITHOUT BEING HIT. HAVE TRIED NEW IGNITION SWITCH, NEW KEY. STILL DOING IT.

NHTSA complaint #10607417 — an unverified report by a vehicle owner.

ENGINE

ENGINE SHUTS DOWN WHILE DRIVING AS IF IGNITION TURNED OFF. CANNOT GET OUT OF PARK. AIR CONDITIONER STOPPED IN 2010, 2011, 2013 AIR BAG LIGHTS ON DASHBOARD ON SINCE 2010.

NHTSA complaint #10598692 — an unverified report by a vehicle owner.

ENGINE

I WAS DRIVING THROUGH TOWN,ALL OF A SUDDEN I HAD NO RPM'S AND THE CAR CAME TO A COMPLETE STOP . CALLED A TOW SERVICE AND HAD IT TOWED, THE MECHANIC EXPLAINED TO ME THAT THE TIMING BELT HAD SNAPPED AND IT HAS CAUSED INTERNAL DAMAGE TO THE ENGINE. FROM THE RESEARCH I HAVE DONE ONLINE, THIS SEEMS TO BE AN ONGOING PROBLEM WITH CHEVROLET, I JUST HATE TO THINK WHAT WOULD HAVE HAPPENED HAD IT BEEN ON A BUSY HIGHWAY, BECAUSE I HAD NO WARNING.

NHTSA complaint #10461116 — an unverified report by a vehicle owner.

ENGINE

I WAS DRIVING 65 MPH ON THE HIGHWAY, WHEN ALL OF A SUDDEN MY RPMS DROPPED TO ZERO AND I COULD NO LONGER ACCELERATE. I HAD TO CUT ACROSS TWO LANES OF TRAFFIC TO SAFELY MAKE IT TO THE SHOULDER OF THE ROAD. I LATER FOUND OUT THAT MY TIMING BELT HAD SNAPPED, CAUSING INTERNAL DAMAGE TO MY ENGINE AND CAUSING MY CAR TO BREAK DOWN IN THE MIDDLE OF CRUISING ON THE HIGHWAY.

NHTSA complaint #10460918 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE DRIVING 40 MPH, THE CONTACT STATED THAT THE TIMING BELT FRACTURED WITHOUT WARNING CAUSING THE VEHICLE TO LOSE ALL POWER. THE DEALER INFORMED THE CONTACT THAT THE TIMING BELT NEEDED TO BE REPLACED SINCE IT FRACTURED AND CAUSED DAMAGE TO THE HEAD, VALVE, AND PISTONS. THE MANUFACTURER WAS AWARE OF THE FAILURE BUT FAILED TO OFFER ANY ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 25,000. THE VIN WAS UNAVAILABLE. UPDATED 05/11/12*LJ THE CONSUMER PROVIDED A VIN THAT BELONGS TO A SUBARU. UPDATED 05/15/12

NHTSA complaint #10452806 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT STATED THAT THE VEHICLE WOULD CONTINUE TO MAINTAIN SPEED FOR MILES AS PRESSURE WAS REMOVED FROM THE ACCELERATOR PEDAL. THE CONTACT STATED THAT THE FAILURE WOULD RECUR AT ANY SPEED. THE VEHICLE ALSO STALLED APPROXIMATELY FIFTY TIMES WITHOUT WARNING. IN ADDITION, THE VEHICLE WOULD DECELERATE INDEPENDENTLY, THE RPMS WOULD FLUCTUATE AND THE VEHICLE WOULD JERKS FORWARD ERRATICALLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DISCOVERED THAT WHILE THE TRANSMISSION WAS IN NEUTRAL, THE TIRES WOULD CONTINUE TO SPIN EXCESSIVELY ON WITHOUT DEPRESSING THE ACCELERATOR PEDAL. THE MECHANIC WAS UNABLE TO DIAGNOSE OR REPAIR THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 51,000. UPDATED 6/8/11 *CN THE CONSUMER STATED THE CASE WAS CLOSED. 06/13/11

NHTSA complaint #10400624 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STATED THAT STEAM BEGAN EMITTING FROM THE EXHAUST SYSTEM. THE CONTACT THEN NOTICED THAT ANTIFREEZE WAS ABNORMALLY LEAKING INTO THE OIL. THE DEALER ADVISED THE CONTACT THAT THE HEAD GASKET WOULD NEED REPLACING AND PERFORMED THE REPAIRS. THE CURRENT MILEAGE WAS 137,000 AND THE FAILURE MILEAGE WAS 122,000.

NHTSA complaint #10393504 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

2007 AVEO 5 , NEW PURCHASE IN APRIL 2008. 1. HIGHWAY DRIVING IS EXTREMELY SCARY, CANNOT DRIVE AT "POSTED SPEED LIMITS IN NORTH AMERICA.ROOF HOWLS & VIBRATES, WE FEAR THAT ROOF WILL DETACH & BLOW OFF.TECH: UNABLE TO REPRODUCE. 2. FREEZING OUTDOOR TEMPERATURES, DEFROSTER FAILS, NEEDS HAND TOWELING, EXCESSIVE MOISTURE & FROZEN ICE ON ALL INSIDE WINDOWS SET ON "DEFROST/ FRESH AIR/ HIGH FAN/ MEDIUM HIGH HEAT, EVEN AFTER 1 HOUR STILL VERY HUMID & WET. DIFFICULT TO SEE CLEARLY WHILE DRIVING. TECH:NO FAULT FOUND 3.AIR BAG WARNING LIGHT GOES OFF & ON WHEN IT WANTS, WITH PEOPLE IN BOTH FRONT SEATS. TECH: UNABLE TO DUPLICATE 4. FRONT END GROANS HARSHLY WHEN DRIVING OVER DIPS IN ROAD OUR SPEED BUMPS. TECH LUBRICATED. 11 FAILED ATTEMPTS ON OUR PART/IN LETTERS TO GM CEO'S ABOUT OUR SAFETY CONCERNS-NO RESPONSE, INTEREST OR REPLY BACK. SERVICE REFUSED VIEWING OUR VIDEO OF OUR HIGHWAY DRIVING, TIRED OF GM SERVICE "LOOP HOLE EXCUSES" GAMMOT RUNAROUND SYSTEM & GETTING KNOW RESULTS. PLEASE HELP US, WE BOUGHT THIS CAR FOR ROAD TRIPS AROUND NORTH AMERICA, WE CLEARLY WOULD BE RISKING OUR LIVES DOING HWY POSTED SPEEDS THAT ARE AS HIGH AS 80 MILES PER HOUR IN SOME STATES. WE ARE DONE WITH THIS AVEO 5!

NHTSA complaint #10390347 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:COOLING SYSTEM

I BOUGHT THIS 2007 CHEVY AVEO BRAND NEW WITH ONLY 9 MILES ON IT. AFTER I PUT ABOUT 33,000 MILES THE A/C WENT OUT... ON A BRAND NEW CAR! THEN THE CONSOLE WITH THE SHIFTERS LIGHTS WENT OUT, BLINKERS WOULD STOP BLINKING AND JUST STAY GREEN. I WENT TO START MY CAR AT 10PM AND IT WOULDN'T START IT ACTED LIKE IT WAS GOING TO BE THEN KEPT CLICKING. SO I JUMPED IT AND DROVE AROUND TO CHARGE THE BATTERY. I HAD THE BATTERY TESTED AND THEY SAID EVERYTHING WAS FINE. GO BACK AND THE NEXT MORNING IT DOESN'T START AGAIN, ALL I GOT WAS A CLICKING SOUND WHEN TRYING TO START THE CAR. I TOOK IT TO A MECHANIC AND HE SAID THAT IT COULD BE THE STARTER OR THE ALTERNATOR AND THAT I SHOULD PAY TO GET THEM BOTH TESTED AND REPLACED IF NEEDED. THERE HAS GOT TO BE SOME TYPE OF A RECALL IF I GOOGLE IT AND EVERYONE HAS THE SAME ELECTRICAL AND ENGINE PROBLEMS. THERE IS NO WAY THAT A 3 YEAR OLD CAR SHOULD BE NEEDING MAJOR A/C REPAIRS, ELECTRICAL, AND ENGINE REPAIRS SO SOON. PLEASE PLEASE PLEASE LOOK INTO THIS!!

NHTSA complaint #10350067 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

WHILE DRIVING THE THROTTLE IS SOMETIMES STUCK IN A LOWER GEAR CAUSING ME TO MOVE AT A LIMITED SPEED WHILE ON THE ROAD. THERE HAS ALWAYS BEEN A PROBLEM WITH THE THROTTLE SUCH AS ERRATIC ACCELERATION, BUT ONLY RECENTLY IT HAS BECOME STUCK.

NHTSA complaint #10330547 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

MY ENGINE LIGHT STARTED COMING ON, SO I TOOK IT TO MY MECHANIC AND THEY DID A DIAGNOSTIC TEST ON MY 2007 CHEVY AVEO. THEY FOUND THAT IT HAD THE SAME PROBLEM THE TOYOTAS HAD WHEN RECALLED. IT IS THE THROTTLE POSITION SENSOR ACCELERATOR POSITION SENSOR. I WAS TOLD THAT IF IT DON'T GET FIXED, EITHER THE GAS PEDAL WILL STICK OR IT COULD JUST STOP AND NOT GO ANYWHERE. I HAVE ONLY HAD THE CAR ALMOST 1 YR. AND IT ONLY HAS 44,000 MILES ON IT.

NHTSA complaint #10328294 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

SPARK PLUG CABLES RUBBING ON ENGINE BOLT WHICH CAUSED CABLE TO ARC AND BURN ADDITIONAL CABLE. HAS FIRST TOLD THE VIBRATION OF THE ENGINE CAUSED CABLE TO WEAR. CAR MISFIRED AND SPURTED WHILE IN TRAFFIC, WHICH CAUSED SERIOUS TRAFFIC BACKUP. TOOK DIRECTLY TO DEALERSHIP, CABLES WERE ORDERED & REPLACE AT OWNERS EXPENSE.

NHTSA complaint #10294351 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

ON DECEMBER 8, 2007 I TOOK THE 2007 CHEVY AVEO INTO THE DEALERSHIP BECAUSE THE CHECK ENGINE LIGHT WAS ON AND THE CAR WOULD ACT LIKE IT WAS GOING TO STALL. THE DEALER HAD MY VEHICLE 11 DAYS AND REPLACED 3 GASKETS, 2 VALVES 4 SEALS AND CHANGED THE FLUIDS, VEHICLE WAS AT 13,143 MILES. VEHICLE WAS THEN TAKEN BACK IN FEBRUARY X 2 AND MARCH TO DEALERSHIP IN WHICH I BOUGHT VEHICLE FOR THE SAME PROBLEM CHECK ENGINE LIGHT ON AND ALL 3 TIMES THE COMPUTER WOULD REGISTER IT WAS THE THROTTLE BODY AND THEY DID NOTHING AND THEY TREATED ME WITH NO RESPECT. I THEN TOOK TO ANOTHER DEALER AND THEY COULD NOT DO ANYTHING UNTIL THE LIGHT CAME BACK ON. AS ANYONE KNOWS IT TAKES THE COMPUTER SOMETIMES UP TO 300 MILES TO RESET ITSELF. SO WHEN THE CHECK ENGINE LIGHT CAME BACK ON 3 WEEKS LATER I TOOK BACK TO DEALER AND THEY STATED THAT IT WAS THE TROTTLEBODAY AND IT WAS JUST RECALLED 2 WEEKS PRIOR. ALL THE WASTED GAS AND TIME. I WAS IN CONTACT WITH GENERAL MOTORS THE WHOLE TIME AND THEY DID NOTHING FOR ME I HAD THE SUPERVISOR TELL ME AFTER THE THROTTLEBODY WAS REPLACED THEY WOULD NOTHING FOR MY TIME AND WASTED GAS AND VERY RUSE MAN. AND NOW MY VEHICLE IS BACK IN THE SHOP FOR THE 6TH TIME IN THE LAST 2 MONTHS BECAUSE THE CHECK ENGINE LIGHT WAS BACK ON AND SHE WAS LOSING POWER AGAIN. THEY HAVE NOW REPLACED SPARK PLUGS, WIRES, IGNITION COIL, FUEL INJECTORS., VALUES AND CAM SHAFT. SO NOW AFTER 12 VISITS TO THE SHOP ALMOST 35 DAYS WITHOUT MY VEHICLE BEING IN COMMISSION I AM FILING FOR THE LEMON LAW. I WILL NEVER PURCHASE ANOTHER GM VEHICLE AGAIN. ANYONE WHO IS HAVING ANYTYPE OF PROBLEMS WITH THEIR VEHICLE THERE ARE LAWS OUT THERE THAT PROTECT YOU. YES IT WILL COST ME MONEY TO FILE IT , BUT IT WILL BE WORTH IT IN THE END. AND WORD OF WISE ALWAYS KEEP DOCUMENTATION ON ANYTHING YOU HAVE DONE TO YOUR VEHICLE YOU NEVER KNOW WHEN YOU ARE GOING TO NEED IT.

NHTSA complaint #10266742 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:COOLING SYSTEM

BACK IN MAY OF 2008 I PICKED MY SON UP FROM SCHOOL, I SMELLED A SMELLED LIKE ANTIFREEZE. I STOPPED AT THE STORE BUT I DIDN'T THINK IT WAS MY CAR. ABOUT AN HOUR LATER, WHEN WE WENT TO CHURCH, I SMELLED THE SAME SMELL, BEING WE WERE THE ONLY CAR IN THE PARKING LOT, I KNEW THEN IT HAD TO BE MY CAR. WE PUT WATER IN IT AND WAITED UNTIL THE NEXT MORNING TO TAKE TO THE DEALERSHIP WE PURCHASED THE CAR FROM. THEY SAID IT APPEARED THAT I HAD HIT SOMETHING AND THE BOTTOM OF THE RADIATOR WAS DAMAGED HOWEVER I KEPT SAYING I DIDN'T HIT ANYTHING AND THEY TOLD ME TO TRY TO TURN IT IN TO MY INSURANCE AND SEE IT THEY WOULD COVER IT. ONE MAN EVEN WALKED ME TO THE CAR AND SAID IF I NEEDED HELP THAT "HELP ME OUT". THAT AFTERNOON I WAS ON THE PHONE WITH THE INSURANCE COMPANY TELLING THEM EXACTLY WHAT THE DEALERSHIP SAID THAT I HAD TO HAVE HIT SOMETHING BUT I DIDN'T REMEMBER HITTING ANYTHING WOULD THEY COVER IT. IN THE END THE INSURANCE COMPANY COVERED THE REPAIR OF THE RADIATOR PLUS 5 DAYS OF RENTAL CAR. WHEN WE WENT TO HAVE THE REPAIR DONE ON THE RADIATOR, WE ASKED FOR THE OLD RADIATOR BACK. MY HUSBAND TOOK IT BACK TO HIS SHOP AND DID A PRESSURE TEST ON IT. THE HOLE WAS ACTUALLY IN THE MIDDLE OF IT NOT IN THE BOTTOM AND YOU COULD SEE WHERE THE FAN SHROUD LINED UP WHERE THE RADIATOR MOUNTS TO IT AND IT HAD RUBBED A HOLE IN IT CAUSING THIS WHOLE PROBLEM. EVEN THOUGH THE INSURANCE COVERED THIS, I STILL THOUGHT RETRIBUTION NEEDED TO BE MADE BECAUSE PERHAPS THIS WAS A LEMON CAR OR EITHER A RECALL NEEDED TO BE DONE. THIS HAPPENED AT 23,000 MILES APPROXIMATELY. THEN THE FOLLOWING MONTH THE SAME FAN SHROUD RUBBED A HOLE IN THE AIR CONDITION LINE AND WE WERE WITHOUT AIR ABOUT 2,000 MILES LATER AND THE DEALERSHIP TOOK RESPONSIBILITY FOR THIS AND COVERED THIS UNDER THE WARRANTY. IT REALLY DIDN'T MAKE ANY SENSE. I HAVE CALLED GMAC AND THEY HAVE SAID THE DEALERSHIP ARE THEIR EYES AND EARS AND WE HAVE GIVEN THEM THE OLD RADIATOR BACK SO THEY COULD SEE WHAT WE SAW .

NHTSA complaint #10239689 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

REAR WIPER MOTOR MAKES VERY LOUD VIBRATION NOISE; REPLACED UNDER WARRANTY FRONT HEADLAMP HAD CONDENSATION INSIDE; REPLACED UNDER WARRANTY. REAR WIPER BLADE NO LONGER CONTACTED REAR WINDOW; REPLACED UNDER WARRANTY. CLOCK QUIT WORKING, THEN WORKED ONLY INTERMITTENTLY, RESETTING AT 1:00; REPLACED UNDER WARRANTY. RADIO QUIT WORKING; REPLACED UNDER WARRANTY. RPM SURGES DURING UPSHIFT WITH POOR FUEL ECONOMY (26-27 AVERAGE); DEALER NOT ABLE TO DIAGNOSE.

NHTSA complaint #10223159 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

TL*THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE MAKING A TURN BETWEEN 5-10 MPH, THE CONTACT HEARD A GRINDING NOISE COMING FROM THE FRONT END OF THE VEHICLE. THE DEALER REPLACED THE FRONT WHEEL BEARINGS AND CHECKED THE AIR PRESSURE, BUT THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN TO ANOTHER DEALER AND THEY PERFORMED AN UNKNOWN REPAIR. THE DEALER STATED THAT THE GRINDING NOISE WOULD RETURN IN A FEW MONTHS BECAUSE THE FAILURE WAS NORMAL. THE CONTACT NOTICED OIL LEAKING ONTO THE GROUND. THE DEALER CONFIRMED THAT THE OIL PUMP GASKET WAS LEAKING AND THE DEALER REPLACED THE GASKET. THE FAILURE MILEAGE WAS 6,751 AND CURRENT MILEAGE WAS 18,000.

NHTSA complaint #10216406 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

2007 CHEVROLET AVEO THAT MAKES STRANGE NOISES CUSTOMER STATES THAT THE VEHICLE HAS BEEN A PROBLEM FROM DAY ONE**CC THE CONSUMER STATED WITHIN THE FIRST FEW MONTHS HE DISCOVERED VEHICLE MAKES STRANGE NOISES AND DOES NOT HAVE MUCH POWER, THE OIL LIGHT ILLUMINATED AND WAS INFORMED BY THE DEALER THAT THE OIL PAN WAS MAKING THE NOISE BECAUSE THE VEHICLE WAS OUT OF OIL, BECAUSE THE PAN WAS LEAKING. THE OIL PRESSURE GAUGE WAS FAULTY AND NEEDED TO BE REPLACED. THE CONSUMER FURTHER STATED THE VEHICLE HAS BEEN IN AND OUT OF THE REPAIR SHOP AND THIS IS A BRAND NEW VEHICLE WITH LESS THAN 5,000 MILES. THE CONSUMER IS REQUESTING AN UPGRADED REPLACEMENT VEHICLE DUE TO THE FACT THIS VEHICLE IS NOT RELIABLE AND THE REPAIR MECHANIC CAN NOT ASSESS THE PROBLEM OF THE CURRENT VEHICLE.

NHTSA complaint #10202648 — an unverified report by a vehicle owner.