2007 Chevrolet Aveo headlight problems

EXTERIOR LIGHTING

While driving, the vehicle began experiencing repeated electrical failures including blown fuses, inoperative headlights and brake lights, and the transmission becoming locked in PARK. When the fuse blows, the gear shift cannot be moved out of PARK and the ignition key cannot be removed, leaving the vehicle stuck and unable to be driven or safely turned off. The brake lights and daytime running lights also stop working, making the vehicle unsafe to operate in traffic. This condition has been occurring repeatedly and requires frequent fuse replacement just to move or shut off the vehicle. An emergency override hole on the shifter had already been exposed, indicating the problem existed before and the vehicle was previously being forced out of PARK manually. A tow truck driver had to use this override to move the vehicle. The airbag warning light is also illuminated, indicating the safety restraint system may not function properly in a crash. These failures create a serious safety risk due to loss of exterior lighting, inability to shift, inability to turn the ignition off, and possible airbag malfunction. This failure is consistent with a known defect involving the Daytime Running Light (DRL) module overheating and causing electrical shorts, as documented in manufacturer recall and technical service bulletins for this vehicle. The problem has been reproduced multiple times and remains unresolved.

NHTSA complaint #11713135 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

I HAVE PROBLEMS WITH WHENEVER I GO TO PUT GAS IN MY CAR, SOME OF IT GOES ON THE GROUND. NOT ALL OF THE GAS GOES ON THE GROUND, BUT A LITTLE LESS THAN HALF OF WHAT I PURCHASED. MY HEADLIGHTS ARE SO DIM THAT I CAN'T HARDLY SEE WHEN I'M DRIVING AT NIGHT. ALSO, MY PASSENGER SIDE AIR BAG LIGHT IS CONSTANTLY ON? THERE'S ONE THERE AND NOTHING BIGAMY WRONG WITH IT THAT I CAN SEE. THE STEREO.....ONLY THE DRIVER SIDE FRONT SPEAKER WORKS, THE OTHER THREE DOESN'T WORK AT ALL....PLEASE LOOK INTO THESE FEW THINGS OR GIVE ME SOME SORT OF IDEA OF WHAT I CAN DO

NHTSA complaint #11306218 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

VEHICLE HEADLIGHTS FAILED. CAR WAS PARKED IN THE DRIVEWAY. AN HOUR LATER WHEN IT WAS STARTED AGAIN, THE HEADLIGHTS FAILED TO COME ON AND REMAIN INOPERABLE. BULBS, SWITCH, AND RELAY HAVE ALL BEEN CHECKED AND VERIFIED TO BE OPERABLE.

NHTSA complaint #11156513 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

RECALL FOR DAYLIGHT RUNNING LIGHTS OVER HEATING DIDN'T APPLY TO MY PARTICULAR CAR, BUT SEEMS TO BE A PROBLEM IN MY CAR REGARDLESS. GROUND WIRES IN MY HEADLIGHT ASSEMBLY HAVE FRIED AND LEFT SCORCH MARKS ON HEADLIGHT CONNECTION. NO ACTUAL FIRE YET JUST A MELTED PLASTIC UNDER THE HOOD. NOT SURE IF MY CAR IS INVALID AS HAVE BEEN FIXED OR JUST NOT COVERED BUT IN EITHER CASE PART IS FAILING.

NHTSA complaint #11142230 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHEN THE CONTACT PULLED IN THE DRIVEWAY AND ATTEMPTED TO TURN OFF THE VEHICLE, THE ELECTRICAL POWER SHUT OFF. AS A RESULT, THE CONTACT WAS UNABLE TO ROLL THE WINDOWS UP OR DOWN, UNLOCK THE DOOR WITH THE SWITCH, AND THE KEY WOULD NOT TURN TO THE OFF POSITION IN THE IGNITION. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

NHTSA complaint #11094150 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

MY CHEVY AVEO HAS HAD EL CERVICAL ISSUES FOR THE LAST 3 YEARS. I HAVE NOTICED THAT THERE IS A RECALL FOR THIS YEAR ON LIGHTING BUT MY VIN IS NOT ASSOCIATED WITH THIS RECALL AND I AM HAVING THE SAM ISSUES. AND NOW NOTHING ON THE DRIVERS SIDE OF MY CAR IS WORKING. BLINKERS, BRAKE LIGHT AND MORE. MY LIGHT FOR MY RADIO DO NOT WORK AS WELL. I HAVE 2 KIDS AND MY CAR IS NOT SAFE WITH THE ELECTRICAL ISSUES GOING ON WITH IT. I HAVE CALLED THE CHEVROLET GARAGE WHERE IT WAS PURCHASED AND ALL I AM BEING TOLD IS THERE ANYTHING S NOTHING THEY CAN DO CAUSE MY VIN IS NOT LISTED WITH THE RECALLS. I NEED MY CAR FIXED ESPECIALLY WITH IT HAVING THE SAME ISSUES AS THE RECALLED 2007 AVEOS.

NHTSA complaint #10864393 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

SINCE THE DRL MODULE WAS REPLACED AS A RECALL ITEM, I HAVE HAD TO REPLACE EACH HEADLIGHT EVERY 2-8 WEEKS DUE TO BURNING OUT. THERE IS OBVIOUSLY A PROBLEM WITH THE SO-CALLED "REPAIR."

NHTSA complaint #10863481 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

I HAVE A 2007 CHEVY AVEO THAT I'VE HAD TO REPLACE THE DRIVERS SIDE > HEADLIGHT ON 5 TIMES IN THE 4 YRS I'VE HAD IT. ALSO, FOR THE PAST 2 YRS I > HAVEN'T HAD ANY RADIO LIGHTS. THERE'S A RECALL ON THE RUNNING LIGHT > MODULES FOR THIS YEAR, THE CARS CAN CATCH FIRE. RECALL NUMBER: 14V261000. THE MODULE ON MY CAR IS MELTED AND BLACK. I HAVE PICTURES OF THIS. I'VE CALLED CHEVY SEVERAL TIMES > BUT GET TOLD THERE'S NO RECALL ON MY CAR. DO I HAVE TO WAIT UNTIL THE CAR CATCHES FIRE TO DO BE ABLE TO DO SOMETHING ABOUT THIS?

NHTSA complaint #10855311 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

MY HEADLIGHTS ARE COMPLETELY BURNING OUT. I'VE CHANGED THEM A COUPLE TIMES AND MY FATHER TOLD ME MY WIRES KEEP BURNING OUT. ALSO MY FUEL SYSTEM KEEPS NOT GIVING ENOUGH FUEL. I KEEP GETTING A GAS LINE EMISSIONS WHEN I GET A CHECK ON MY CAR. CHECK ENGINE LIGHT ON THEN OFF A FEW DAYS LATER. ALSO MY SEATBELT IN THE BACK KEEP COMING OUT.

NHTSA complaint #10823228 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

HAVE TO CHANGE HEADLIGHTS EVERY OTHER MONTH. WHEN I CHANGE ONE THE OTHER WENT OUT IMMEDIATELLY. SHOULD NOT HAVE TO CHANGE HEADLIGHT BULBS. TOLD DEALER HE SAID BY BULB FROM THEM?? I BOUGHT CORRECT BULB???? THIS HAS BEEN ONGOING SINCE I BOUGHT CAR IN 2010..IVE REPLACED OVER 7/8 TIMES.

NHTSA complaint #10785114 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STATED THAT THE HEADLIGHT HOUSING FRACTURED AND CAUSED THE HEADLIGHTS TO FACE IN AN UPWARD POSITION. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 8/31/15*CN UPDATED 10/14/2015

NHTSA complaint #10726233 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

DASH LIGHTS QUIT WORKING AND COULD SMELL PLASTIC BURNING FROM UNDER THE DASH. ALSO THE TAIL LIGHT ON THE PASSENGER SIDE KEEPS BLOWING FUSES.

NHTSA complaint #10702365 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2007 CHEVROLET AEVO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING); HOWEVER, THE PARTS NEEDED TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 04/06/15*LJ THE CONSUMER ALSO STATED THE VEHICLE STALLED. UPDATED 04/28/15

NHTSA complaint #10691168 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THERE WAS A BURNING SMELL INSIDE THE VEHICLE. AS A RESULT, THE INSTRUMENT PANEL BECAME INOPERABLE. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE FAILED TO SHIFT INTO THE PARK POSITION. ALSO, THE CONTACT MENTIONED THAT THE IGNITION KEY FAILED TO DISENGAGE FROM THE IGNITION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE FUSE BOX WIRING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE FAILURE MILEAGE WAS 71,000. UPDATED 4/29/15

NHTSA complaint #10680451 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

DAYTIME RUNNING LIGHTS SUDDENLY TURNED OFF WHILE DRIVING AND NOW HEADLIGHTS DON'T WORK AT ALL.

NHTSA complaint #10671529 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

HEADLIGHT FAILED. I HAVE OWNED THIS AUTO 4 YEARS AND HAVE HAD TO REPLACE 6 HEADLIGHTS. I JUST GOT A TICKET BECAUSE MY HEADLIGHT WAS OUT, AND I HAD REPLACED A HEADLIGHT LESS THAN 3 MONTHS AGO. I HAVE NEVER HAD TO REPLACE SO MANY HEADLIGHTS IN ONE VEHICLE IN ALL MY 49 YEARS OF DRIVING. THESE HEADLIGHTS CANNOT BE REPLACED BY THE OWNER, BECAUSE IT REQUIRES SPECIALIZED TOOLS. I HAVE TO TAKE MY VEHICLE IN FOR SERVICE EVERY TIME A HEADLIGHT GOES OUT, SO THE COST IN 3X WHAT THE LAMP ALONE COSTS AT A PARTS STORE. SOMETHING IS WRONG WITH THE DESIGN OF THIS VEHICLE.

NHTSA complaint #10669943 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

IN JULY 2014, I RECEIVED A RECALL NOTICE #14093 FROM CHEVROLET/GM ADVISING OF A FIRE HAZARD INVOLVING MY DAYTIME RUNNING HEADLIGHTS. THE NOTICE ADVISED THE PARTS ARE NOT CURRENTLY AVAILABLE... I CALLED THEIR 800 NUMBER SEVERAL TIMES UP THROUGH TODAY TO CHECK ON GETTING THIS HAZARD FIXED. UNFORTUNATELY, TODAY IS 11-22-14, AND THEY STILL ARE NOT READY TO REMEDY THE HAZARD. IN ADDITION, MY INTERIOR LIGHT STOPPED WORKING A FEW MONTHS AGO, AND IT'S NOT THE LIGHT BULB BECAUSE I REPLACED IT. I WOULD LIKE THIS REPAIRED TOO. I DO NOT FEEL SAFE IN MY CAR, AND IN LIGHT OF THE FACT THAT FOUR MONTHS HAVE NOW GONE BY SINCE THE RECALL NOTICE, I STRONGLY FEEL THAT CHEVROLET/GM SHOULD OFFER/PAY FOR A SAFE LOANER VEHICLE UNTIL THEY REMOVE THE FIRE HAZARD. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #10660269 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

UNSURE WHAT IS GOING O. BUT TURNED ON RUNNING LIGHTS AND ONE HEAD LIGHT COMES ON WITH IT AND TURN IT TO AUTO FOR THE LIGHTS AND THE OTHER SIDE TURNS ONE AND THE OTHER SIDE ISN'T WORKING.

NHTSA complaint #10627656 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING: HEADLIGHTS); HOWEVER, THE PART NEEDED FOR THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA complaint #10617730 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

THE DASHBOARD OVER THE SPEEDOMETER BECOMES VERY HOT AND THE KEY IS HOT WHEN REMOVED. I FEEL THIS MAY BE RELATED TO RECALL 14236 REGARDING RUNNING LIGHTS. I AM CONCERNED ABOUT THE RECALL 06133 REGARDING FUEL LINE/FUSE BLOCK AS WELL.

NHTSA complaint #10610799 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

MY HEADLIGHTS ARE GREY ON THE BOTTOM SO I CAN'T SEE TO DRIVE AT NIGHT. I CHANGED HEADLIGHTS BUT THERE APPEARED TO BE A BIG PROBLEM INSTALLING THE NEW LIGHTS. I PAID $60.00 FOR THE NEW LIGHTS. THERE WAS NO IMPROVEMENT. I STILL CAN'T SEE TO DRIVE AT NIGHT.

NHTSA complaint #10593886 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

WHEN THE CAR STARTS AIR BAG LIGHT GETS DEPLOYED THIS HAS BEEN HAPPENING SINCE 2011. THE FRONT PANEL GETS OVERHEATED- DAYTIME RUNNING LIGHT.

NHTSA complaint #10593215 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STATED THE FRONT HEADLIGHTS MALFUNCTIONED. THE CONTACT STATED THAT THE HIGH BEAMS AND THE DAYTIME RUNNING LIGHTS WERE OPERABLE BUT NOT THE HEADLIGHTS. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE THE BULB AND FUSE REPLACED BUT THE REPLACEMENT DID NOT REMEDY THE ISSUE. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER A THIRD TIME AND THE DEALER STATED THAT THE ENTIRE FUSE BOX NEEDED TO BE REPLACED. THE CONTACT WAS UNABLE TO HAVE THE FUSE BOX REPLACED BECAUSE THE PART WAS NO LONGER BEING MANUFACTURED AND THERE WAS NOT AN AFTERMARKET PART AVAILABLE FOR PURCHASE. THE CONTACT BELIEVED THE VEHICLE WAS UNSAFE TO DRIVE BECAUSE THE HEADLIGHTS CONTINUOUSLY MALFUNCTIONED WHILE DRIVING AT NIGHT. THE FAILURE MILEAGE WAS 75,000.

NHTSA complaint #10406804 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

BRAKE LIGHTS DO NOT OPERATE. THEY JUST QUIT WORKING. CHECKED ALL FUSES AND LIGHTS. CRUISE CONTROL NO LONGER WORKS--JUST STOPPED.

NHTSA complaint #10393513 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

BOTH HEADLIGHTS ON THE LOW BEAM SETTING FAILED TO WORK. HIGH BEAMS WORKED AS THEY SHOULD. FUSES, HEADLIGHT SWITCH, PARKING BRAKE SWITCH, AND RELAYS CHECKED OUT OK. THE ASSUMPTION IS THAT A VOLTAGE SPIKE BURNED OUT THE LOW SIDE OF THE BULBS AT THE SAME TIME WITHOUT BLOWING ANY FUSES. THIS WAS DISCOVERED DURING THE DAY RATHER THAN AT NIGHT.

NHTSA complaint #10226360 — an unverified report by a vehicle owner.