1992 Chevrolet Cavalier problems

TIRES

NEW TIRES AND VALVE STEMS WERE INSTALLED ON MY CAR IN NOVEMBER OF 2007. AFTER ABOUT 8,000 MILES TWO VALVE STEMS HAVE FAILED IN THE COURSE OF TWO WEEKS, ONE ABOUT MAY 7 TH 2009 AND ANOTHER ON MAY 19 2009. FIRST FAILED STEM WAS REPLACED MAY 8TH. AM NO WAITING FOR INFORMATION FROM THE SELLER OF THE STEMS IF THEY WILL COVER THE REPLACEMENT OF THE OTHER THREE UNDER WARRANTY.

NHTSA complaint #10269524 — an unverified report by a vehicle owner.

STRUCTURE:BODY

THE BODY SEAM PUTTY ON AND AROUND THE WINDSHIELD AND FIREWALL DRIES OUT, THEN CRACKS, AND ALLOWS WATER TO ENTER THE INTERIOR OF THE CAR. AS A RESULT, MY FRONT FLOOR PANS ON THE PASSENGER AND DRIVER SIDE ARE RUSTING AS IS MY FIREWALL. MY FRONT CARPET IS MOST ALWAYS WET AND MUSTY SMELLING UNLESS I PULL THE CARPETS BACK AFTER EVERY RAIN TO ALLOW THE INTERIOR MOISTURE TO DRY (THIS HAPPENS WHETHER THE CAR IS DRIVEN IN THE RAIN OR PARKED IN THE RAIN).

NHTSA complaint #10219150 — an unverified report by a vehicle owner.

STEERING: STEERING WHEEL/HANDLE BAR

1992 CHEVROLET CAVALIER. THE PIECE AT THE CENTER OF THE DRIVING WHEEL CAN COME LOOSE, INTERFERE WITH STEERING, AND CAUSE AN ACCIDENT. THE CENTER OF THE DRIVING WHEEL HAS A PIECE WHICH IS OVER THE HORN. HIS CAME OFF AS I WAS MAKING A SHARP U-TURN ON A TWO WAY STREET. IT JAMMED IN BETWEEN THE STEERING WHEEL AND MY TURN SIGNAL LEVER. I TEMPORARILY WAS UNABLE TO TURN THE STEERING WHEEL. IT ALMOST CAUSED AN ACCIDENT. THE PIECE AT THE CENTER OF THE DRIVING WHEEL CAN COME LOOSE, INTERFERE WITH STEERING, AND CAUSE AN ACCIDENT.

NHTSA complaint #10187771 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

THE CONSUMER TOOK VEHICLE TO THE DEALER TO REPAIR THE ABS LIGHT WHICH COST $700.00. THE VEHICLE WAS TAKEN TO DEALER A SECOND TIME BECAUSE THE LIGHT WOULD REMAIN ON. THE DEALER INFORMED THE CONSUMER THAT IT WOULD AGAIN COST HIM $ BECAUSE WARRANTY EXPIRED. *AK *SC

NHTSA complaint #10101990 — an unverified report by a vehicle owner.

STEERING

WHILE DRIVING 35 MPH, THE CONSUMER LOST STEERING CONTROL. THE DEALERSHIP WAS AWARE OF THE PROBLEM. PLASE PROVIDE MORE INFORMATION.

NHTSA complaint #10091466 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

I OWN A 1992 CHEV CAVALIER Z-24 AND HAVE BEEN READING HORROR STORIES ABOOT THE EXACT WOES I HAVE BEEN SUFFERING SINCE BUYING IT USED IN 1998 WITH ONLY 15K MI ON IT; IT ONLY HAS 30000 ON IT NOW. THE FIRST TO GO WAS THE HEATER CORE AND BELT TENSIONER AND THEN THE COOLANT LEAKS THAT HAS REQUIRED SEVERAL DAYS OF SHOP TIME. I HAVE HAD THE INTAKE REMOVED TWICE, THE HEADS ONCE - THEY ACCUSED ME OF OVERHEATING AND WARPING THEM - THE WATER PUMP REPLACED, 2 WINDOW MOTORS INSTALLED AND THE ALTENATOR REPLACED. I HAVEN'T EVEN GOTTEN TO THE BRAKES - THE ABS SYSTEM ON THIS BUCKET OF JUNK SEEM TO WORK FINE MOST OF THE TIME BUT LOVE TO CHATTER INTERNAL TO THE ELECTRONIC/HYDRAULIC SYSTEM AS IF IT CAN'T MAKE UP ITS MIND. I HAVE DISABLED THE SYSTEM IN DIAGNOSING IT MYSELF AND FOUND THAT THE BRAKES WORK BETTER WITHOUT THE SYSTEM CONTROLLING YOUR BRAKING. THE SYSTEM IS INTACT AS I DON'T WANT TO FOOL AROUND TOO MUCH BUT THIS SHOULD HAVE BEEN A SWITCH ON THE DASH - ABS ON - ABS OFF. I AM IN POOR HEALTH AND HAVEN'T BEEN ABLE TO TAKE THE JALOPY TO OURISMAN CHEVROLET AGAIN - I BOUGHT IT AT OURISMAN'S ROCKVILLE STORE - TO SHOW THEM THE COOLANT IN THE OIL THAT I FOUND RECENTLY. I HAVE USED SYNTHETIC OIL IN IT SINCE I BOUGHT IT BUT I CAN'T VOUCH FOR THE SERVICE DEPT AT OURISMAN. THEY PROBABLY USE GOODWRENCH 5-30 AS IT CAME FROM THE FACTORY. IF THERE ARE THIS MANY REPORTS OF THIS PIECE OF JUNK, WOULDN'T CHEVY BE MORE CONCERNED ABOOT IT? I AM LUCKY TO HAVE GOTTEN A 4 YEAR EXTENDED WARRANTY AS I WOULD NEVER HAVE BEEN ABLE TO AFFORD IT; I WOULD HAVE JUST LEFT THE CAR WITH OURISMAN AND LET THEM DEAL WITH IT. AK

NHTSA complaint #10075338 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

I OWN A 1992 CHEV CAVALIER Z-24 AND HAVE BEEN READING HORROR STORIES ABOOT THE EXACT WOES I HAVE BEEN SUFFERING SINCE BUYING IT USED IN 1998 WITH ONLY 15K MI ON IT; IT ONLY HAS 30000 ON IT NOW. THE FIRST TO GO WAS THE HEATER CORE AND BELT TENSIONER AND THEN THE COOLANT LEAKS THAT HAS REQUIRED SEVERAL DAYS OF SHOP TIME. I HAVE HAD THE INTAKE REMOVED TWICE, THE HEADS ONCE - THEY ACCUSED ME OF OVERHEATING AND WARPING THEM - THE WATER PUMP REPLACED, 2 WINDOW MOTORS INSTALLED AND THE ALTENATOR REPLACED. I HAVEN'T EVEN GOTTEN TO THE BRAKES - THE ABS SYSTEM ON THIS BUCKET OF JUNK SEEM TO WORK FINE MOST OF THE TIME BUT LOVE TO CHATTER INTERNAL TO THE ELECTRONIC/HYDRAULIC SYSTEM AS IF IT CAN'T MAKE UP ITS MIND. I HAVE DISABLED THE SYSTEM IN DIAGNOSING IT MYSELF AND FOUND THAT THE BRAKES WORK BETTER WITHOUT THE SYSTEM CONTROLLING YOUR BRAKING. THE SYSTEM IS INTACT AS I DON'T WANT TO FOOL AROUND TOO MUCH BUT THIS SHOULD HAVE BEEN A SWITCH ON THE DASH - ABS ON - ABS OFF. I AM IN POOR HEALTH AND HAVEN'T BEEN ABLE TO TAKE THE JALOPY TO OURISMAN CHEVROLET AGAIN - I BOUGHT IT AT OURISMAN'S ROCKVILLE STORE - TO SHOW THEM THE COOLANT IN THE OIL THAT I FOUND RECENTLY. I HAVE USED SYNTHETIC OIL IN IT SINCE I BOUGHT IT BUT I CAN'T VOUCH FOR THE SERVICE DEPT AT OURISMAN. THEY PROBABLY USE GOODWRENCH 5-30 AS IT CAME FROM THE FACTORY. IF THERE ARE THIS MANY REPORTS OF THIS PIECE OF JUNK, WOULDN'T CHEVY BE MORE CONCERNED ABOOT IT? I AM LUCKY TO HAVE GOTTEN A 4 YEAR EXTENDED WARRANTY AS I WOULD NEVER HAVE BEEN ABLE TO AFFORD IT; I WOULD HAVE JUST LEFT THE CAR WITH OURISMAN AND LET THEM DEAL WITH IT. AK

NHTSA complaint #10075338 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

I OWN A 1992 CHEV CAVALIER Z-24 AND HAVE BEEN READING HORROR STORIES ABOOT THE EXACT WOES I HAVE BEEN SUFFERING SINCE BUYING IT USED IN 1998 WITH ONLY 15K MI ON IT; IT ONLY HAS 30000 ON IT NOW. THE FIRST TO GO WAS THE HEATER CORE AND BELT TENSIONER AND THEN THE COOLANT LEAKS THAT HAS REQUIRED SEVERAL DAYS OF SHOP TIME. I HAVE HAD THE INTAKE REMOVED TWICE, THE HEADS ONCE - THEY ACCUSED ME OF OVERHEATING AND WARPING THEM - THE WATER PUMP REPLACED, 2 WINDOW MOTORS INSTALLED AND THE ALTENATOR REPLACED. I HAVEN'T EVEN GOTTEN TO THE BRAKES - THE ABS SYSTEM ON THIS BUCKET OF JUNK SEEM TO WORK FINE MOST OF THE TIME BUT LOVE TO CHATTER INTERNAL TO THE ELECTRONIC/HYDRAULIC SYSTEM AS IF IT CAN'T MAKE UP ITS MIND. I HAVE DISABLED THE SYSTEM IN DIAGNOSING IT MYSELF AND FOUND THAT THE BRAKES WORK BETTER WITHOUT THE SYSTEM CONTROLLING YOUR BRAKING. THE SYSTEM IS INTACT AS I DON'T WANT TO FOOL AROUND TOO MUCH BUT THIS SHOULD HAVE BEEN A SWITCH ON THE DASH - ABS ON - ABS OFF. I AM IN POOR HEALTH AND HAVEN'T BEEN ABLE TO TAKE THE JALOPY TO OURISMAN CHEVROLET AGAIN - I BOUGHT IT AT OURISMAN'S ROCKVILLE STORE - TO SHOW THEM THE COOLANT IN THE OIL THAT I FOUND RECENTLY. I HAVE USED SYNTHETIC OIL IN IT SINCE I BOUGHT IT BUT I CAN'T VOUCH FOR THE SERVICE DEPT AT OURISMAN. THEY PROBABLY USE GOODWRENCH 5-30 AS IT CAME FROM THE FACTORY. IF THERE ARE THIS MANY REPORTS OF THIS PIECE OF JUNK, WOULDN'T CHEVY BE MORE CONCERNED ABOOT IT? I AM LUCKY TO HAVE GOTTEN A 4 YEAR EXTENDED WARRANTY AS I WOULD NEVER HAVE BEEN ABLE TO AFFORD IT; I WOULD HAVE JUST LEFT THE CAR WITH OURISMAN AND LET THEM DEAL WITH IT. AK

NHTSA complaint #10075338 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

I OWN A 1992 CHEV CAVALIER Z-24 AND HAVE BEEN READING HORROR STORIES ABOOT THE EXACT WOES I HAVE BEEN SUFFERING SINCE BUYING IT USED IN 1998 WITH ONLY 15K MI ON IT; IT ONLY HAS 30000 ON IT NOW. THE FIRST TO GO WAS THE HEATER CORE AND BELT TENSIONER AND THEN THE COOLANT LEAKS THAT HAS REQUIRED SEVERAL DAYS OF SHOP TIME. I HAVE HAD THE INTAKE REMOVED TWICE, THE HEADS ONCE - THEY ACCUSED ME OF OVERHEATING AND WARPING THEM - THE WATER PUMP REPLACED, 2 WINDOW MOTORS INSTALLED AND THE ALTENATOR REPLACED. I HAVEN'T EVEN GOTTEN TO THE BRAKES - THE ABS SYSTEM ON THIS BUCKET OF JUNK SEEM TO WORK FINE MOST OF THE TIME BUT LOVE TO CHATTER INTERNAL TO THE ELECTRONIC/HYDRAULIC SYSTEM AS IF IT CAN'T MAKE UP ITS MIND. I HAVE DISABLED THE SYSTEM IN DIAGNOSING IT MYSELF AND FOUND THAT THE BRAKES WORK BETTER WITHOUT THE SYSTEM CONTROLLING YOUR BRAKING. THE SYSTEM IS INTACT AS I DON'T WANT TO FOOL AROUND TOO MUCH BUT THIS SHOULD HAVE BEEN A SWITCH ON THE DASH - ABS ON - ABS OFF. I AM IN POOR HEALTH AND HAVEN'T BEEN ABLE TO TAKE THE JALOPY TO OURISMAN CHEVROLET AGAIN - I BOUGHT IT AT OURISMAN'S ROCKVILLE STORE - TO SHOW THEM THE COOLANT IN THE OIL THAT I FOUND RECENTLY. I HAVE USED SYNTHETIC OIL IN IT SINCE I BOUGHT IT BUT I CAN'T VOUCH FOR THE SERVICE DEPT AT OURISMAN. THEY PROBABLY USE GOODWRENCH 5-30 AS IT CAME FROM THE FACTORY. IF THERE ARE THIS MANY REPORTS OF THIS PIECE OF JUNK, WOULDN'T CHEVY BE MORE CONCERNED ABOOT IT? I AM LUCKY TO HAVE GOTTEN A 4 YEAR EXTENDED WARRANTY AS I WOULD NEVER HAVE BEEN ABLE TO AFFORD IT; I WOULD HAVE JUST LEFT THE CAR WITH OURISMAN AND LET THEM DEAL WITH IT. AK

NHTSA complaint #10075338 — an unverified report by a vehicle owner.

SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE

I OWN A 1992 CHEV CAVALIER Z-24 AND HAVE BEEN READING HORROR STORIES ABOOT THE EXACT WOES I HAVE BEEN SUFFERING SINCE BUYING IT USED IN 1998 WITH ONLY 15K MI ON IT; IT ONLY HAS 30000 ON IT NOW. THE FIRST TO GO WAS THE HEATER CORE AND BELT TENSIONER AND THEN THE COOLANT LEAKS THAT HAS REQUIRED SEVERAL DAYS OF SHOP TIME. I HAVE HAD THE INTAKE REMOVED TWICE, THE HEADS ONCE - THEY ACCUSED ME OF OVERHEATING AND WARPING THEM - THE WATER PUMP REPLACED, 2 WINDOW MOTORS INSTALLED AND THE ALTENATOR REPLACED. I HAVEN'T EVEN GOTTEN TO THE BRAKES - THE ABS SYSTEM ON THIS BUCKET OF JUNK SEEM TO WORK FINE MOST OF THE TIME BUT LOVE TO CHATTER INTERNAL TO THE ELECTRONIC/HYDRAULIC SYSTEM AS IF IT CAN'T MAKE UP ITS MIND. I HAVE DISABLED THE SYSTEM IN DIAGNOSING IT MYSELF AND FOUND THAT THE BRAKES WORK BETTER WITHOUT THE SYSTEM CONTROLLING YOUR BRAKING. THE SYSTEM IS INTACT AS I DON'T WANT TO FOOL AROUND TOO MUCH BUT THIS SHOULD HAVE BEEN A SWITCH ON THE DASH - ABS ON - ABS OFF. I AM IN POOR HEALTH AND HAVEN'T BEEN ABLE TO TAKE THE JALOPY TO OURISMAN CHEVROLET AGAIN - I BOUGHT IT AT OURISMAN'S ROCKVILLE STORE - TO SHOW THEM THE COOLANT IN THE OIL THAT I FOUND RECENTLY. I HAVE USED SYNTHETIC OIL IN IT SINCE I BOUGHT IT BUT I CAN'T VOUCH FOR THE SERVICE DEPT AT OURISMAN. THEY PROBABLY USE GOODWRENCH 5-30 AS IT CAME FROM THE FACTORY. IF THERE ARE THIS MANY REPORTS OF THIS PIECE OF JUNK, WOULDN'T CHEVY BE MORE CONCERNED ABOOT IT? I AM LUCKY TO HAVE GOTTEN A 4 YEAR EXTENDED WARRANTY AS I WOULD NEVER HAVE BEEN ABLE TO AFFORD IT; I WOULD HAVE JUST LEFT THE CAR WITH OURISMAN AND LET THEM DEAL WITH IT. AK

NHTSA complaint #10075338 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

WHILE MAKING A RIGHT TURN A LOUD KNOCKING NOISE WAS HEARD FROM STEERING WHEEL COLUMN. THEN, VEHICLE STALLED. CONSUMER RESTARTED VEHICLE, AND PULLED OVER. CONSUMER HAD VEHICLE TOWED TO THE DEALER FOR REPAIRS.

NHTSA complaint #10075730 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

I OWN A 1992 CHEVY CAVALIER. I HAVE HAD TO REPLACE THE HEATER CORE 3 TIMES. ONCE A YEAR EVERY YEAR SINCE 2001. I AM REQUESTING A RECALL ON THIS ISSUE DUE TO THE NUMBER OF COMPLAINTS I HAVE READ ABOUT THIS PROBLEM. I DON'T THINK THAT I OR ANYONE ELSE SHOULD HAVE TO REPLACE A HEATER CORE/ BLOWN HEAD GASKET ONCE A YEAR. I WOULD LIKE TO HEAR FROM YOU OR CHEVY ABOUT THIS PROBLEM. THIS IS RIDICULOUS AND VERY VERY COSTLY. I BELIEVE THAT THE MANUFACTURER SHOULD BE RESPONSIBLE FOR THE COSTS INCURRED AND TO FIX THIS PROBLEM. I LOVE MY CAR AND TAKE VERY GOOD CARE OF IT. I HAVE INCURRED COSTS OF OVER $2000 AND AM SICK AND TIRED OF HEARING THAT I HAVE BLOWN A HEAD GASKET DUE TO HEATER CORE\COOLING FAILURE. PLEASE CONTACT ME ABOUT THIS MATTER ASAP. THANK YOU. SHERI MADRID

NHTSA complaint #10062742 — an unverified report by a vehicle owner.

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE

I OWN A 1992 CHEVY CAVALIER. I HAVE HAD TO REPLACE THE HEATER CORE 3 TIMES. ONCE A YEAR EVERY YEAR SINCE 2001. I AM REQUESTING A RECALL ON THIS ISSUE DUE TO THE NUMBER OF COMPLAINTS I HAVE READ ABOUT THIS PROBLEM. I DON'T THINK THAT I OR ANYONE ELSE SHOULD HAVE TO REPLACE A HEATER CORE/ BLOWN HEAD GASKET ONCE A YEAR. I WOULD LIKE TO HEAR FROM YOU OR CHEVY ABOUT THIS PROBLEM. THIS IS RIDICULOUS AND VERY VERY COSTLY. I BELIEVE THAT THE MANUFACTURER SHOULD BE RESPONSIBLE FOR THE COSTS INCURRED AND TO FIX THIS PROBLEM. I LOVE MY CAR AND TAKE VERY GOOD CARE OF IT. I HAVE INCURRED COSTS OF OVER $2000 AND AM SICK AND TIRED OF HEARING THAT I HAVE BLOWN A HEAD GASKET DUE TO HEATER CORE\COOLING FAILURE. PLEASE CONTACT ME ABOUT THIS MATTER ASAP. THANK YOU. SHERI MADRID

NHTSA complaint #10062742 — an unverified report by a vehicle owner.

STRUCTURE:BODY

MOISTURE COLLECTS INSIDE MY VEHICLE, WHENEVER IT RAINS THERE IS WATER STANDING IN MY FLOOR BOARDS.

NHTSA complaint #10062304 — an unverified report by a vehicle owner.

SUSPENSION:REAR

VEHICLE REAR SHOCK MOUNTS RUSTED OUT AND THE SHOCKS BROKE FREE OF WHAT REMAINED OF THE WHEEL WELL. *MR *SCC

NHTSA complaint #10050083 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TRANSMISSION LOCK-UP TORQUE CONVERTER WILL NOT RELEASE WHEN VEHICLE WARM. VEHICLE STARTS, BUT WILL ABRUPTLY STALL WHEN PLACED IN GEAR. WHEN VEHICLE COOLS, TRANSMISSION OPERATIONAL UNTIL VEHICLE WARMS BACK UP. THIS IS THE 5TH GM VEHICLE THAT I HAVE OWNED THAT EXHIBITS THIS PROBLEM. IT USUALLY OCCURS AT OR NEAR 100,000 MILES. THIS COULD POTENTIALLY BECOME A SAFETY HAZARD IF VEHICLE STALLS IN MIDDLE OF INTERSECTION AS THERE IS NO WAY TO MOVE THE VEHICLE. I HAVE HAD 1 VEHICLE STALL ON THE INTERSTATE WHEN I HAD TO STOP FOR TRAFFIC. AFTER 5 VEHICLES IT SEEMS TO BE A COMMON PROBLEM AND NOT JUST RELATED TO 1 VEHICLE. ACQUAINTANCES WITH DIFFERENT MANUFACTURER VEHICLES HAVE REPORTED NO SIMILAR PROBLEMS. DT

NHTSA complaint #769384 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

WHILE DRIVING AT ANY SPEED AND APPLYING BRAKES REAR BRAKES WILL LOCK UP. ANTI-LOCK BRAKING SYSTEM WILL ENGAGE, WHICH AFFECTS VEHICLE STOPPING. DEALER CONTACTED.PLEASE ADD VIN.

NHTSA complaint #8002613 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM

INTAKE MANIFOLD IS DEFECTIVE AND VEHICLE WILL STALL AT ANY SPEED. VEHICLE WILL START BACK UP ONCE IT SHUTS OFF. CONTACTED DEALER AND DEALER WAS NOT WILLING TO DO ANYTHING, CONSUMER HAD ANOTHER DEALERSHIP INSTALL NEW INTAKE MANIFOLD GASKET. *AK

NHTSA complaint #899198 — an unverified report by a vehicle owner.

SEATS:FRONT ASSEMBLY:RECLINER

WHILE DRIVING DRIVER'S SEATBACK COLLAPSED. DEALER HAS BEEN NOTIFIED.*AK DRIVER WAS LEFT IN A PRONG POSITION AND HAD TO FIND THE BRAKE PEDAL, CONSUMER WAS ADVISED BY DELAER THAT THIS IS NOT A DEFAULT.

NHTSA complaint #888811 — an unverified report by a vehicle owner.