465 of the 7,335 complaints filed about the Chevrolet S10 are about the body and structure — 6% of everything owners reported. The worst model year for it is 2000.
465
Complaints
6%
Share of all complaints
9
Crashes
4
Fires
STRUCTURE:BODY
The door latch, that holds your door shut.The wells on them broke and the passenger door came open while going down the road.Big concern had to get it rewelded
NHTSA complaint #11749851 — an unverified report by a vehicle owner.
STRUCTURE:BODY
I never received Safety Recall# 06020 Galvanized Defective Tailgate Cables that snap/break due to corrosion inside the cable causing the tailgate to fall down while opened. Both my cables have been torn/broken caused by the rust thru for quit some time. My son told me recently, that he had received the Recall Notice a number of years ago and the Chevy Dealer replaced his cables; his S-10 cables are good/solid no problems. I am meticulous with records and surely would have told the Dealer and had them replaced during the recall period. What should I do as I never received the Recall Notice at issue?
NHTSA complaint #11517573 — an unverified report by a vehicle owner.
STRUCTURE:BODY
TRUCK HAS ABS LIGHTS ON WHEN DRIVING AT LOWER SPEEDS AS SOON AS THE FLUIDS ARE NOT COLD THE CHECK GUSHES LIGHT COMES ON AND THE OIL PRESSURE GAUGE NEEDLE DROPS UNTIL THE THROTTLE IS AGAIN DEPRESSED... ALSO ABS IN REAR SHAKES WHOLE TRUCK WHEN GOING BELOW 50MPH AND THEN CONTINUES UP TO 80MPH BEFORE SUBSIDING. THE TRUCK HAS SERIOUS STEERING ISSUES CONSTANT LEAKS CAUSED I'M SURE MY RACK AND PINION ARE WORN DOWN AS WELL AS NOW MY TIRES AND SUPENSION I HAVE SO MANY PROBLEMS LIKE THE INTERIOR IS CRUMBLING TO PIECES THE BODY HAS GIANT HOLES FROM IMPROPER PAINTING OPTIONS ON THIS MODEL I HAVE OVER SIZED TIRE WELLS THAT ARE RUSTED COMPLETELY OUT IT MAKE YOUR COMPANY LOOK SILLY FOR NOT MAKING THESE VEHICLES BETTER WHEN THEY LAST PEOPLE KEEP BUYING THEM AGAIN AND AGAIN! SEEMS LIKE YOU PROBABLY USE PARTS FOR MANY YEARS ON MANY MODELS FUNNY HOW EVERY YEAR INCLUDING THE YEAR IT WAS MANUFACTURERED THERE WERE RECALLS EXCEPT FOR MINE IS THAT JUST BECAUSE IT'S OLDER
NHTSA complaint #11403686 — an unverified report by a vehicle owner.
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
TL* THE CONTACT OWNS A 1997 CHEVROLET S10. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A FLAT TIRE. THE CONTACT WAS UNABLE TO RELEASE THE SPARE TIRE FROM UNDERNEATH THE VEHICLE. THE CONTACT INDICATED THAT THE SPARE TIRE HOIST ASSEMBLY RETAINER HAD MALFUNCTIONED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS NOTIFIED, BUT NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 130,000.
NHTSA complaint #11171457 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE TOP HINGE OF THE DRIVERSIDE DOOR IS WORN ALLOWING AIR AND RAIN TO ENTER THE CABIN. THE SMALL PLASTIC SLEEVE IN THE TOP HINGE APPEARS TO BE BROKEN OR WORN EXCESSIVELY.
NHTSA complaint #11164133 — an unverified report by a vehicle owner.
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
TL* THE CONTACT OWNS A 2000 CHEVROLET S10. UPON INSPECTING THE VEHICLE, IT WAS NOTICED THAT THE FRONT FRAME WAS CRACKED AND DETERIORATED TO THE POINT THAT IT MAY FRACTURE. THE CONTACT STATED THAT CRACKS DEVELOPED ON THE FRAME AND THE MOTOR MOUNT WAS NOT WELDED TO THE FRAME PROPERLY. THE CRACKING PROGRESSED TO THE POINT THAT THE FRAME WAS ALSO DETERIORATING ON THE FRONT DRIVER AND PASSENGER SIDES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE FRAME SHOULD HAVE BEEN WELDED ALL THE WAY AROUND THE VEHICLE AND IT WAS ONLY WELDED AT THE TOP. THE DEALER DIAGNOSED THAT THE FRONT FRAMING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA complaint #10690667 — an unverified report by a vehicle owner.
STRUCTURE
WATER LEAK IN COWL AREA ALLOWED RAIN WATER TO COLLECT UNDETECTED UNDER CARPET MOISTURE BARRIER CAUSING ACCESSORY HANDICAPPED ACCELERATOR PEDAL ASSEMBLY TO CORRODE. CORROSION OF THE PEDAL ARM PIVOT SHAFT EVENTUALLY CAUSED PEDAL TO FREEZE IN A PART THROTTLE POSITION IN TRAFFIC. EVASIVE MANEUVER REQUIRED TO AVOID COLLISION WHILE APPROACHING INTERSECTION.
NHTSA complaint #10649891 — an unverified report by a vehicle owner.
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2001 CHEVROLET S10. WHILE DRIVING APPROXIMATELY 5 MPH, THE SPARE TIRE CARRIER DETACHED FROM THE VEHICLE. THE CONTACT WAS A CERTIFIED MECHANIC AND REPAIRED THE SPARE TIRE HOIST ON SEVERAL OCCASIONS. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.
NHTSA complaint #10643768 — an unverified report by a vehicle owner.
STRUCTURE:BODY
CABLE STRAPS THAT HOLD THE TAILGATE HORIZONTAL TO THE GROUND WHEN THE TAILGATE IS IN THE DOWN POSITION HAVE RUSTED THROUGH AND WILL NO LONGER HOLD THE TAILGATE IN THE HORIZONTAL POSITION. THERE WAS A RECALL ON THIS IN APPROXIMATELY JUNE OF 2006. I RECEIVED A CARD IN THE MAIL, TOOK THE VEHICLE IN TO THE CHEVROLET DEALER, AND THEY ADVISED ME THAT PARTS WERE NOT AVAILABLE. THIS HAPPENED TWICE. I KIND OF GAVE UP, UNTIL I DISCOVERED THE PART FAILURE EARLIER THIS YEAR. UNFORTUNATELY I HAVE MISPLACED MY CARD THAT THEY SENT IN THE MAIL. UPON FAILURE OF THIS PART, I TOOK MY VEHICLE IN TO A CHEVROLET DEALER IN SEPTEMBER OF 2014. THEY KNEW ABOUT THE RECALL, SO RAN MY VIN # AND SAID MY VEHICLE VIN# WAS NOT PART OF THE RECALL. PERHAPS GENERAL MOTORS DIDN'T RECALL ENOUGH OF THE VIN#S TO FIND ALL OF THE PART FAILURES.
NHTSA complaint #10643652 — an unverified report by a vehicle owner.
STRUCTURE
TL* THE CONTACT OWNS A 2002 CHEVROLET S-10. WHILE REFUELING THE VEHICLE, THE CONTACT NOTICED THAT FUEL WAS LEAKING. THE DEALER STATED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 86,000. UPDATED 11/26/14*CN THE CONSUMER STATED THE VEHICLE HAD TWO GAS LEAKS. UPDATED 10/5/2015
NHTSA complaint #10643390 — an unverified report by a vehicle owner.
STRUCTURE:BODY
ENGINE FAILURE - HAD TO BE REBUILT AT APP. 75000 MILES - BOTH SIDES OF CAB BOTTOM REAR RUSTED OUT - FIRST TIME BRAKE FAILURE 2013 - PUT BRAKE ON TO PUT THE TRUCK IN DRIVE NO BRAKES FRONT RIGHT - AUG 2014 BRAKE FAILURE - PUT BRAKE ON TO PUT IN DRIVE NO BRAKES.
NHTSA complaint #10619222 — an unverified report by a vehicle owner.
STRUCTURE:BODY
A JEEP WITH A BIKE MOUNTED ON A BIKE RACK STOPPED QUICKLY IN FRONT OF ME. I HIT MY BRAKES, BUT QUICKLY LOST BRAKING EFFECTIVENESS AND THE BRAKE PEDAL WENT TO THE FLOOR. I TRIED TO SWERVE, BUT HIT THE REAR OF THE JEEP, DAMAGING THE BIKE AND BIKE RACK. SEVERE DAMAGE TO MY GRILLE, DRIVERS SIDE FRONT FENDER AND HEADLIGHT, AND RADIATOR MOUNT. AFTER EXCHANGING INSURANCE INFORMATION, I NOTICED BRAKE FLUID ON GROUND, BY THE FUEL TANK ON DRIVERS SIDE. LIMPED HOME (ABOUT 2 BLOCKS). NO BRAKES OTHER THAN EMERGENCY BRAKE. SUBSEQUENT INSPECTION REVEALED FAILED BRAKE LINE AND SEVERE RUST ON MOST BRAKE LINES.
NHTSA complaint #10572700 — an unverified report by a vehicle owner.
STRUCTURE:BODY
TL* THE CONTACT OWNS A 1999 CHEVROLET S10. THE CONTACT STATED THAT HE NOTICED THAT THE SPARE TIRE BECAME DETACHED FROM THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE SPARE TIRE CABLE HAD FRACTURED PREMATURELY. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 60,620.
NHTSA complaint #10565676 — an unverified report by a vehicle owner.
STRUCTURE:BODY
TL* THE CONTACT OWNS A 1998 CHEVROLET S-10. THE CONTACT STATED THAT THERE WAS A CRACK IN THE FRAME, BEHIND THE DRIVER'S SIDE LOWER CONTROL ARM. THE VEHICLE WAS TAKEN TO A DEALER, WHO STATED THAT THERE WAS NO CORROSION OR IMPACT THAT COULD HAVE CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE WAS REPORTED TO THE MANUFACTURER, WHO REFUSED TO PROVIDE ASSISTANCE FOR THE REPAIR. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 47,000. THE CURRENT MILEAGE WAS 48,000.
NHTSA complaint #10522134 — an unverified report by a vehicle owner.
STRUCTURE
UPON PERSONAL INSPECTION OF MY VEHICLE I DISCOVERED MY SPARE TIRE WAS MISSING AND THE CABLE HAD SNAPPED DUE TO CABLE FRAYING OR CORROSION. THE EXACT TIME AND SPEED OF THIS FAILURE IS UNKNOWN BUT THE DANGER COULD BE POTENTIALLY HAZARDOUS FOR THE FOLLOWING REASONS A: THE TIRE COULD POSE A HAZARD TO TRAFFIC BEHIND THE VEHICLE. B: THE TIRE COULD ROLL INTO LANES OF TRAFFIC OR PEDESTRIANS. C: THE TIRE COULD FALL AT SUCH AN ANGLE TO LIFT AND DEFLECT THE REAR END OF THE VEHICLE CAUSING DAMAGE AND UNEXPECTED LOSS OF CONTROL. D: THE OPERATOR COULD FIND THEMSELVES STRANDED WITHOUT A SPARE TIRE.
NHTSA complaint #10503416 — an unverified report by a vehicle owner.
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2002 CHEVROLET S10. THE CONTACT STATED THAT WHILE OPENING THE REAR TAILGATE DOOR, THE DOOR FRACTURED BECAUSE THE HINGES AND THE CABLES WERE SEVERELY RUSTED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 89,000. THE VIN WAS UNAVAILABLE.
NHTSA complaint #10502812 — an unverified report by a vehicle owner.
STRUCTURE:BODY
I HAVE READ OF A SAFTEY RECALL ON THIS VEHICAL WITH THE EXACT DESCRIPTION OF WHAT HAPPENED TO ME, I SHOULD HAVE HAD PLENTY OF DISTANCE TO STOP, IT'S ONLY A SMALL PICK UP, I KNOW FOR CERTIAN I HAVE A FULLY LOADED WORK TRUCK A FORD 3/4 TON ECONOLINE VAN AND I KNOW I COULD HAVE STOPPED THAT VEHICLE IN TIME. I WAS STANDING ON THE BRAKES, THEY JUST WOULDNT DO ANYTHING , IN AN EMERGENCY THEY JUST DON'T CUT THE MUSTARD. I HAD EXTENSIVE FRONT END DAMAGE, AND MY NEEK HAS BEEN NOT FEELING GOOD EVER SINCE. MY FATHER IN LAW GAVE THIS TRUCK TO MY WIFE HEN HE WAS NO LONGER ABLE TO DRIVE, AND IT WAS TOLD TO ME HE HAD THE TRUCK INTO THE SHOP REPEATEDLY FOR THE SAME THING SINCE IT WAS NEW. SEEMS TO ME GM SHOULD MAKE IT RIGHT AND THE BODY COLLISION, BEINGS THEY HAVE KNOWN ABOUT IT AND HAVENT DONE SQUAT, AND PAY FOR MY PAIN AND MEDICAL.
NHTSA complaint #10499787 — an unverified report by a vehicle owner.
STRUCTURE
CABLE RUSTED UNDERNEATH TRUCK, SPARE TIRE CAME OFF, CAUSED TRAFFIC TIE-P.
NHTSA complaint #10492917 — an unverified report by a vehicle owner.
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2004 CHEVROLET S10. THE CONTACT STATED THAT THE LIFT GATE COLLAPSED ABNORMALLY. THE CONTACT STATED THAT THE CABLES WERE FRACTURED AND CAUSED THE LIFT GATE TO STRIKE THE BUMPERS. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND CONFIRMED THAT THERE WERE NO RECALLS FOR THE VEHICLE. THE FAILURE MILEAGE WAS 75,000.
NHTSA complaint #10485304 — an unverified report by a vehicle owner.
STRUCTURE:BODY:DOOR
THE DOOR PINS ARE FAULTY ON THESE TRUCKS AND BLAZERS AND MY DOOR DOES NOT SHUT SOMETIMES BECAUSE OF IT AND IT FLEW OPEN ON A TURN ALMOST CAUSING ME TO FLY OUT TOO. I WENT AND BOUGHT THE PART THAT WEEKEND BUT THEY SHOULD BE RECALLED THIS IS DANGEROUS!
NHTSA complaint #10475734 — an unverified report by a vehicle owner.