343 of the
7,335 complaints filed about the Chevrolet S10
are about the fuel system —
5% of everything owners reported.
The worst model year for it is 1997.
I'm having a problem with I believe it's the fuel sensor my truck gets up to a certain temperature and it just dies and it's not just my truck it's in a lot of the newer model Colorado's as well I have a friend who's having the same exact problem as I am when it gets up past 95 degrees, the truck just all of a sudden stops in the engine turns off, and you have to try and steer your truck without any power steering, the reason I am filing this is if this happens in the middle of the road it could possibly cause an accident and that would be no good and it only happens when it is hot outside in the winter time or when it's cold I have no issues whatsoever
NHTSA complaint #11539247 — an unverified report by a vehicle owner.
TRUCK WAS PURCHASED 7/7/20. SEEMED TO WORK FINE, BUT STARTED NOTICING ENGINE TROUBLE ON 9/10/20. HAD ONLY DRIVEN IT ~150 MILES SINCE PURCHASE, NEVER ANY STRENUOUS DRIVING. TOOK IT IN TO GET SERVICED ON 9/21/20, WHERE SEVERAL PROBLEMS WERE SPOTTED, ONE OF WHICH IS TRACEABLE TO THE DEALER: 1) THE DISTRIBUTOR CAP WAS BEING HELD ON ONLY BY TWO ZIPTIES. THIS IS WHY IT SEEMED TO RUN FINE ON THE DATE OF PURCHASE, BUT CAUSED ENGINE MISFIRES WITHIN A FEW MONTHS OF LIGHT USE. THE DEALERSHIP NOTIFIED ME THE DAY BEFORE I PURCHASED IT THAT THE DISTRIBUTOR WAS BEING FIXED, BUT THEY FAILED TO NOTIFY ME THAT IT WASN'T FIXED PROPERLY. TRUCK NOW MISFIRES, HAS AN ARCING WIRE, AND IS UNSAFE TO DRIVE. 2)TRUCK WAS SOLD WITH NO PARKING BRAKE, AND NO WARNING THAT IT WAS NOT INSTALLED. THIS INFORMATION HAS OMITTED WHEN I ASKED ABOUT SAFETY ISSUES BEFORE PURCHASING. NEVER NOTICED BECAUSE PHX IS SO FLAT. HAD I NEEDED TO USE THE PARKING BRAKE, NOT HAVING ONE INSTALLED IS A SIGNIFICANT SAFETY ISSUE. 3) AN IMPACT SENSOR WAS LEFT HANGING FROM THE REAR OF THE VEHICLE. A LARGE ENOUGH BUMP OR A ROCK COULD SET OFF AIRBAGS WHILE DRIVING, PUTTING MY PASSENGERS, MYSELF, AND OTHER DRIVERS AND PEDESTRIANS AT SERIOUS RISK. THIS TRUCK IS VERY UNSAFE TO DRIVE, AND I WAS NOT RESPONSIBLE FOR ANY OF THE ISSUES THAT MADE IT UNSAFE. THE FIRST ISSUE WAS CAUSED BY A BAD REPAIR MADE BY THE DEALERSHIP, AND THE OTHER TWO NOTED ISSUES WERE NOT NOTED IN THE CARFAX OR BY THE SALESPERSON WHEN I ASKED ABOUT SAFETY ISSUES.
NHTSA complaint #11360475 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2000 CHEVROLET S10. WHILE DRIVING THE VEHICLE, AN ABNORMAL FUEL ODOR WAS NOTICED FROM THE REAR OF THE VEHICLE. THE CONTACT NOTICED A LEAK FROM THE FUEL TANK. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 262,870.
NHTSA complaint #10899099 — an unverified report by a vehicle owner.
THE FUEL TANK ON MY TRUCK HAS CRACKED WHERE THE INLET TUBE CONNECTS TO THE TANK , CAUSING A FUEL LEAK. THERE IS A RECALL BY CHEVROLET FOR THE SAME CONDITION ON 2004 CHEVROLET TAHOE WITH THE PLASTIC TANK. GENERAL MOTORS HAS DISCONTINUED THE TANK FOR REPLACEMENT AND WILL NOT VERIFY THERE IS A PROBLEM WITH THIS TANK ALSO. THE TANK EMITS GAS FUMES OUT OF THE CRACKS DUE TO EGR PRESSURE REQUIREMENTS.
NHTSA complaint #10846432 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 1993 CHEVROLET S10. THE CONTACT STATED THAT WHILE DRIVING AFTER THE VEHICLE WAS REFUELED, THE FUEL EMITTED FROM THE FILLER NECK WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.
NHTSA complaint #10809087 — an unverified report by a vehicle owner.
I PURCHASE THIS VEHICLE IN APRIL 2015 (USED) I DROVE THE VEHICLE HOME AND IT REGISTERED A HALF A TANK OF GAS, I DROVE IT A FEW DAYS AND THE GAS GAUGE NEEDLE DID NOT MOVE. I NOTIFIED THE AUTO CENTER WHERE I PURCHASE THE VEHICLE AND TOOK IT BACK FOR REPAIRS. FIVE WEEKS AFTER THE REPAIR THE GAS GAUGE IS STILL FAULTY. I WAS DRIVING ON THE HIGHWAY AND THE VEHICLE SHUT DOWN (OUT OF GAS) THE GAS GAUGE NEEDLE READ A QUARTER TANK OF GAS. I CONTACTED THE AUTO CENTER WHERE I PURCHASE THE VEHICLE AND I WAS TOLD THE S10 AND THE GMC MODEL OF THIS VEHICLE HAS A HISTORY OF FAULTY GAS GAUGE'S. MY ONLY RECOURSE IS TO HAVE THIS ITEM REPAIRED AGAIN WITHOUT ANY GUARANTEE THE SAME PROBLEM WILL HAPPEN AGAIN.----2001 CHEVROLET S10 FUEL SDYSTEM, OTHER BULLETIN 13599---ACTION NUMBER 10001283 REPORT DATE MAR 01,2003 THANK YOU [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'
NHTSA complaint #10730793 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2002 CHEVROLET S-10. WHILE REFUELING THE VEHICLE, THE CONTACT NOTICED THAT FUEL WAS LEAKING. THE DEALER STATED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 86,000. UPDATED 11/26/14*CN THE CONSUMER STATED THE VEHICLE HAD TWO GAS LEAKS. UPDATED 10/5/2015
NHTSA complaint #10643390 — an unverified report by a vehicle owner.
I PURCHASED THIS VEHICLE FROM OUR LOCAL CHEVROLET DEALER ON 10/04/2014. I FILLED THE FUEL TANK ON 10/06/2014 AND DROVE IT TO MY RESIDENCE (ABOUT 15 MILES.) WHEN I GOT HOME, I NOTICED THERE WAS A STREAK OF A LIQUID ON MY DRIVEWAY WHEN I WAS BACKING INTO MY GARAGE. I GOT OUT OF MY TRUCK AND NOTICED A FUEL SMELL AND GOT A TROUBLE LIGHT TO SEE IF I COULD DETERMINE THE SOURCE. IT WAS RUNNING OUT BELOW THE FUEL TANK. I THEN TOOK MY FLOOR JACK AND JACKED UP THE VEHICLE SO I COULD GET A BUCKET UNDER IT TO CATCH THE FUEL THAT WAS RUNNING ON TO THE FLOOR. I COLLECTED ABOUT 1 1/2 GALLONS. I CALLED THE DEALER THE NEXT MORNING AND THEY SAY I AM OBLIGATED TO PAY TO REPAIR THE TRUCK.
NHTSA complaint #10643080 — an unverified report by a vehicle owner.
OCCASIONALLY ABOUT 5 OR 6 TIMES AND COUNTING WHEN INITIALLY APPLYING THE BRAKE AT EITHER 45MPH OR 10 MPH MY 1997 CHEVY S10 VEHICLE STARTS TO ACCELERATE WITH MY FOOT OFF THE GAS AND CRUISE CONTROL OFF AT WHAT APPEARED TO BE FULL SPEED/THROTTLE. MY FIRST REACTION WAS TO BRAKE EVEN HARDER, BUT THEN THE ANTILOCK BRAKES KICKED IN AND SEEMED TO REDUCE THE STOPPING FORCE BY NOT LETTING THE WHEELS LOCK. THE VEHICLE CONTINUED TO ACCELERATE UNTIL I PLACED THE CAR IN NEUTRAL AND THEN THE VEHICLE STOPPED AND ALSO STOPPED ACCELERATING.
NHTSA complaint #10641808 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2000 CHEVROLET S10. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 65 MPH WITH THE CRUISE CONTROL ACTIVATED, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE ELECTRIC FUEL PUMP WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 15,000. UPDATED 11/20/14*LJ..UPDATED 11/24/14 *BF UPDATED 05/4/02015 *JS UPDATED 08/30/2017
NHTSA complaint #10641245 — an unverified report by a vehicle owner.
SEVERELY CORRODED BRAKE LINES, LINES BLEW. NEAR MISS ACCIDENT. THIS IS A COMMON COMPLAINT ACROSS MFRS. . WELL MAINTAINED CARS WITH SEVERELY CORRODED FUEL AND BRAKE LINES. I BET IT CAN BE TRACED TO A CHEAP SUPPLIER THAT SUPPLIED THE BIG 3 FOR A PERIOD OF YEARS. NO CORROSION RESISTANCE ON THE STEEL. CAN'T BLAME THIS ON NE WINTER SALT. MY OEM 1964 LOOKS BETTER THAN MY LATE MODEL VEHICLES.
NHTSA complaint #10629435 — an unverified report by a vehicle owner.
IT JUST STALLED AND THE RADIO KEEPS GOING ON AND OFF ONCE IN A WHILE, ALSO THE TIRES KEEP GOING FLAT ON ME AND I PUT FIX A FLAT IN THEM AND THEY STILL DO THE SAME. ELECTRIC PROBLEM I THINK IT MIGHT BE THE RELAY NOT SURE. BUT IT HAS ELECTRIC PROBLEMS.
NHTSA complaint #10504072 — an unverified report by a vehicle owner.
I BACKED OUT OF MY DRIVEWAY. BEGAN SLOWLY TRAVELING DOWN THE HILL THAT I LIVE ON. THE BRAKES COMPLETELY FAILED. THE BRAKE WARNING LIGHT WAS NOT ON PRIOR TO THIS OCCURING. THE ENGINE ALSO STALLED. I HAD NO WAY TO SLOW OR STOP SAFELY, AS THE PARKING BRAKE CABLE WAS RUSTED AND DID NOT WORK. I MADE IT TO THE BOTTOM OF THE HILL. ENDED UP DRIVING OFF OF A SMALL EMBANKMENT CAUSING DAMAGE TO THE FRONT BUMPER AND OTHER EXTERNAL AREAS IN THE FRONT. THE HOOD AND DRIVER SIDE DOOR ARE NO LONGER SEALING VERY GOOD. A REPAIR SHOP HAD TO REPLACE MUCH OF THE BRAKE LINES DUE TO FAILURE CAUSED BY RUST. THE MECHANIC ALSO FOUND FUEL LINE DAMAGE DUE TO RUST AND REPLACE THEM AS WELL. I COULD HAVE EASILY BEEN INJURED OR DIED THAT DAY, OR HAVE CAUSED INJURY OR DEATH. WHY HAS CHEVROLET NOT BEEN REQUIRED CORRECT THESE PROBLEMS?
NHTSA complaint #10497757 — an unverified report by a vehicle owner.
FUEL TANK LEAKING-NO IMPACT. NOTED THE FUEL TANK IS SEPARATING FROM THE FUEL FILLER NECK. PLASTIC FUEL TANK IS CRACKING WITHOUT ANY IMPACT TO THE TANK.
NHTSA complaint #10472838 — an unverified report by a vehicle owner.
MYSELF AND TWO FRIENDS HAVE HAD PROBLEMS WITH BAD GASONLINE CAPS AT APPROXIMATELY 10 YEARS OF VEHICLE LIFE. THE WEAR AND TEAR OVER 10 YEARS HAS DIMINISHED THE SEAL CAPACITY OF THE GASOLINE CAP. THE GASOLINE CAP DEFECT OR NORMAL WEAR/TEAR SEEMS TO RESULT IN EVAP CANNISTERS BECOMING SATURATED, WHICH RESULTS IN AN IDENTIFIED SMALL LEAK IN THE SYSTEM DURING SMOG CHECK IN CA. PERHAPS, THE COINCIDENCE OF GAS CAPS SEALS WORN AND EVAP CANNISTER NEEDING REPLACEMENT AT THE SAME TIME WITH A FEW PEOPLE IS STATISTICALLY INSIGNIFICANT, BUT THE COST TO REPLACE A GAS CAP ~$30.00 AND EVAP CANNISTER ~$300.00 IS SIGNIFICANT. WHAT ADVISORIES OR IMPROVEMENTS MAY BE MADE IN THIS AREA? I RECOMMEND THREE SOLUTIONS: 1. REPLACEMENT GASOLINE CAP SCHEDULE BY MANUFACTURER; 2. NOTIFICATION TO CAR OWNER TO REGULARLY CHECK GASOLINE CAP SEALS AFTER 7 YEARS BY MANUFACTURER; AND/OR 3. FEDERAL GOVERNMENT SUPPORT MANUFACTURERS TO IMPROVE THE DESIGN OF GASOLINE CAPS TO LAST LONGER.
NHTSA complaint #10462455 — an unverified report by a vehicle owner.
FUEL GAUGE GIVES FLUCTUATING READINGS AT ALL SPEEDS AND AT STOPLIGHT, RESULTING IN RUNNING OUT OF FUEL ONCE AND A NEAR CRASH. ALSO, I HAVE TALKED WITH SEVERAL PEOPLE WHO HAVE SIMILAR VEHICLES AND THEY HAVE THE SAME PROBLEM.
NHTSA complaint #10405450 — an unverified report by a vehicle owner.
1999 CHEVROLET S10. CONSUMER STATES THAT HE HAD A FUEL PUMP REPLACED AFTER THE ORIGINAL FAILED. THE REPLACEMENT PART FAILED AFTER LESS THAN A YEAR. *KB THE CONSUMER ALSO STATED THE SECOND FUEL PUMP WAS DEFECTIVE. THE CONSUMER IS REQUESTING REIMBURSEMENT FOR THE SECOND DEFECTIVE FUEL PUMP.
NHTSA complaint #10370156 — an unverified report by a vehicle owner.