2005 Chevrolet Silverado electrical problems

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

SPEEDOMETER DOES NOT READ ACCURATE. IT EITHER READS 15 MPH AT HIGHWAY SPEEDS, OR GOES WAY HIGH SUCH AS 120 MPH AT 55 TO 60 MPH. SOMETIMES AT THE HIGHER READING, IT WILL READ 60 MPH WHEN VEHICLE IS STOPPED, IN PARK, AND IGNITION OFF. I WAS TOLD THIS IS A STEPPING MOTOR BUT HARD TO CHANGE AND EXPENSIVE TO CHANGE. I HAVE READ THAT THERE WAS A CLASS ACTION LAWSUIT THAT WAS NEVER BROUGHT UP.

NHTSA complaint #10695278 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

THE DASHBOARD CLUSTER WENT OUT, SPEED ODOMETER STUCK ON 60MPH. HAD TO RACE MOTOR UP UNTIL IT RED LINE RETURNED TO 0. THE ENTIRE ELECTRICAL BOARD STOPPED WORKING, FOUND OUT WAS A RECALL BUT MY VIN WAS NOT INCLUDED. SPOKE TO AUTRY MORLAN DEALERSHIP SEVERAL TIMES. WE PAID OUT OF POCKET TO HAVE REPLACED AND THAT CLUSTER HAS DONE SAME THING. STILL NO RECALL ON OUR TRUCK. WILL COST ANOTHER 200-300 TO FIX OUT OF POCKET. GAS GAUGE DOES NOT WORK, SPEED ODOMETER DOES NOT WORK. RPM WILL WORK AND THAT IS HOW WE JUDGE OUR SPEED ON TRUCK.

NHTSA complaint #10626944 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TURNED KEY ON AND LIGHT SAYING SERVICE AIRBAG CAME ON. LOCAL MECHANIC SAID HE READ THAT THERE WAS GOING TO BE A RECALL ON IT.

NHTSA complaint #10626194 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE DOOR AJAR SAFETY ALARM AND THE SEAT BELT ALARM CHIME FAILED. THE CONTACT INDICATED THAT WHILE THE DOOR WAS OPENED WHILE THE VEHICLE WAS IN MOTION BUT THE CHIME DID NOT ACTIVATE . ADDITIONALLY, THE CHIME DID NOT SOUND WHEN THE SEAT BELTS WERE NOT SECURED WHILE THE VEHICLE WAS IN MOTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000.

NHTSA complaint #10610693 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

BLOWER RESISTER KEEPS BURNING OUT.

NHTSA complaint #10610029 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

THE BRAKE LINES AND FUEL LINES RUSTY TO THE POINT THAT THEY ARE LEAKING NEED TO BE REPLACED.THE BLEND MOTOR FOR HVAC ISN'T WORKING RIGHT.

NHTSA complaint #10608414 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

WAS DRIVING DOWN ROAD LOOKED DOWN AT MY SPEEDOMETER AND IT WAS PEGGED OUT OVER 120 MPH I WAS ONLY GOING ABOUT 15MPH SO I STOPPED AND TURNED OFF TRUCK AND SPEEDOMETER WENT DOWN TO 60 NOT 0 AS IT SHOULD I TURNED IT BACK ON AND TOOK OFF IT DID SAME THING ALL WAY OVER 120 MPH SO WHEN I GOT WHERE I WAS HEADING AND TURNED TRUCK OFF AGAIN SAME THING JUST DROPPED TO 60 SO I KEPT TURNING KEY ON AND OFF AND IT WOULD DROP ABOUT 5MPH EACH TIME UNTIL IT GOT TO 0 WENT TO DEALER HE SAID LOT OF PROBLEMS WITH THIS MODEL TRUCK I WOULD NEED A NEW DASH AND IT WOULD COST ME $1200 I THINK GM SHOULD FIX THESE TRUCK IT THE LAW TO HAVE A WORKING SPEEDOMETER ON YOUR TRUCK THANK YOU.

NHTSA complaint #10583621 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE VEHICLE FAILED TO START ACCOMPANIED BY THE ILLUMINATION OF THE CHECK ENGINE WARNING LIGHT. THE FAILURE WAS RECURRING AND SPORADIC. ADDITIONALLY, THE INSTRUMENT PANEL FAILED AND THE HEAD LIGHTS WOULD SPORADICALLY FAIL. THE CONTACT ALSO STATED THAT THE ROTORS NEEDED TO BE REPLACED ON A REGULAR BASIS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO WAS NOT ABLE TO DIAGNOSE THE MULTIPLE FAILURES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1000.

NHTSA complaint #10575949 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

INSTRUMENT CLUSTER FAILURE. ODOMETER MILEAGE WIPED CLEAN. DISPLAY READS "ODOMETER ERROR".

NHTSA complaint #10564577 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

WHILE DRIVING NORMALLY I NOTICED MY SPEEDOMETER GIVING ERRONEOUS READINGS AS HIGH AS 120 MPH, AND UPON STOPPING, THE SPEEDOMETER STAYED AT THE 35 MPH. POSITION. AFTER A FEW DAYS, IT RETURNED TO NORMAL. OCCASIONALLY, THE SPEEDOMETER DOES NOT WORK FOR DAYS AT A TIME. I FEEL IT IS DANGEROUS DRIVING WITH A SPEEDOMETER WHICH IS NOT RELIABLE. GM HAS REFUSED TO FIX THE PROBLEM AND TOLD ME I AM FULLY RESPONSIBLE FOR ALL PARTS AND LABOR COSTS BECAUSE MY VEHICLE IS OUT OF WARRANTY. NOW, THE VOLT-METER ALSO DOES NOT WORK AND THE NEEDLE POINTS DOWN AT A "6 O CLOCK" POSITION WHICH IS OFF THE CHART. THIS HAS BEEN BROKEN FOR SEVERAL WEEKS NOW.

NHTSA complaint #10489308 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I WAS DRIVING THE VEHICLE AT NORMAL SPEEDS AND I HAVE HAD THIS VEHICLE FOR ABOUT 6 MONTHS AND NEVER HAVE HAD A PROBLEM WITH IT. ALL THE SUDDEN I GET A MESSAGE THAT SAYS "SERVICE AIR BAG". I TOOK THE TRUCK TO THE DEALER AND THEY DIAGNOSED IT AND THEY SAID THAT THE TRUCK NEEDS A NEW FRONT DRIVERS SIDE IMPACT SENSOR THAT WENT BAD. THIS TRUCK HAS NEVER BEEN IN AN ACCIDENT AND THE AIRBAGS HAVE NEVER BEEN DEPLOYED. THEY TOLD ME THAT IF THIS REPAIR DOES NOT GET DONE, IF I HAVE AN ACCIDENT THE AIRBAGS WOULDN'T DEPLOY.

NHTSA complaint #10486627 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE BACKLIGHT AND THE GAUGE LIGHTS ON THE INSTRUMENT PANEL HAD BECOME ABNORMALLY DARK. THE CONTACT WAS UNABLE TO SEE ANY OF THE GAUGES ON THE INSTRUMENT PANEL, INCLUDING THE TACHOMETER AND SPEEDOMETER, WHICH ALSO FAILED INTERMITTENTLY. THE BATTERY WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO DEALER FOR INSPECTION OR REPAIR. THE VIN WAS UNAVAILABLE.THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 98,000. THE CURRENT MILEAGE WAS 113,000.

NHTSA complaint #10475981 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

THIS TRUCK HAS EXPERIENCED TWO FUSE BLOCK FAILURES SINCE NEW. THE SYMPTOM, IN BOTH CASES, WAS THE TRUCK WOULD NOT START. BOTH REPAIRS WERE ACCOMPLISHED AT BROWN AND BROWN CHEVROLET IN MESA ARIZONA. THE FIRST REPAIR OCCURRED IN 2008 AND THE SECOND REPAIR OCCURRED IN 2012. WHEN REIMBURSEMENT WAS REQUESTED FOR THE SECOND FAILURE, THE BROWN AND BROWN SERVICE PERSON AND THE GM CUSTOMER CARE PERSON BOTH DENIED WARRANTY COVERAGE BECAUSE THERE ARE THIRD-PARTY DEVICES INSTALLED IN THE VEHICLE. THERE IS AN ALARM SYSTEM AND A KENWOOD STEREO, WITH A GM MODULE, INSTALLED THAT WERE DEEMED THIRD-PARTY. THERE IS ALSO A CB RADIO BUT IT WAS NOT CITED. ALL VEHICLE EQUIPMENT IS POWERED THROUGH FUSES ON THE FUSE BLOCK. NONE OF THE FUSES WERE FOUND TO BE BLOWN BY BROWN AND BROWN, INCLUDING THE ONES POWERING THE THIRD-PARTY EQUIPMENT. THE FUSE BLOCK?S INTENT IS TO DISTRIBUTE POWER TO SUCH DEVICES AND PROTECT THE WIRING WITH ITS INSTALLED FUSES. PROPERLY CONNECTED EQUIPMENT MAY BLOW A FUSE BUT CANNOT STRESS THE FUSE BLOCK TO FAILURE. I REQUESTED THE ?BAD? FUSE BLOCK IN BOTH CASES AND HAVE DISASSEMBLED THE SECOND ONE. I FOUND LOOSE POWER PINS AND NO EVIDENCE OF BURNING OR ARCING. THE DESIGN PERMITS THE POWER PINS TO LOOSEN OVER TIME, CAUSING INTERMITTENT CONNECTIONS. THIS INTERMITTENT CONNECTION WAS VERIFIED BY BROWN AND BROWN; THEY SAID THAT SIMPLY LEANING ON THE FUSE BLOCK WOULD CAUSE THE ENGINE TO STOP. THIS IS NOT AN EFFECT OF THIRD PARTY EQUIPMENT BUT IS A DESIGN DEFECT OF THE FUSE BLOCK.

NHTSA complaint #10475534 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

THE INSTRUMENT CLUSTER WENT OUT AND RESET MY ENGINE HOURS, ODOMETER IS ERROR, AND WON'T CHANGE ANYTHING.I TOOK IT TO THE DEALER AND THEY SAID ABOUT $600 TO FIX.THERE IS ALOT OF PROBLEMS WITH THESE AND THEY SHOULD BE FIXED FOR FREE.

NHTSA complaint #10468142 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

SPEEDOMETER STARTED STICKING AT 60MPH AND THEN IF THE TRUCK WAS RESTARTED IT WOULD GO BACK TO 0 AND START WORKING AGAIN AND THEN WOULD STICK AGAIN LATER. WELL NOW IT'S JUST STUCK AT 0 AND DOESN'T MOVE AT ALL. ALL THE OTHER GAUGES WORK PROPERLY THOUGH.

NHTSA complaint #10460903 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

SPEEDOMETER STOPPED FUNCTIONING. IT DISPLAYS I'M DRIVING @ 120 MPH AND GETS STUCK THERE, WHEN I'M ONLY GOING APPROXIMATELY 30-40 MPH. THIS IS RIDICULOUS THAT THERE IS NO RECALL ON THIS MALFUNCTION AS I SEE THERE ARE PLENTY OF COMPLIANTS WITH SAME ISSUE. HOW CAN I DRIVE SAFELY WITHOUT KNOWING THE SPEED LIMIT I'M GOING.

NHTSA complaint #10434387 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

THE PROBLEM IS THE FAN ON GM TRUCKS BURNS OUT. WE WERE TOLD BY THE SERVICE DEPT THAT THE WIRES WERE BURNED UP AND THAT THIS REQUIRED MORE PARTS AND SERVICE. NEEDED RESISTOR, CONNECTOR AND BLOWER TO REPAIR. THIS IS A POTENTIAL FIRE HAZARD WHICH IS NOT BEING ADDRESSED BY GM. APPARENTLY THIS IS AN ISSUE THAT MANY VEHICLE OWNERS HAVE EXPERIENCED BUT SINCE NO ONE HAS BEEN KILLED I GUESS THERE IS NOT REASON TO MANDATE A RECALL. WE WERE TOLD BY THE SERVICE DEPT. THAT MANY VEHICLES ARE BEING BROUGHT IN FOR SERVICE BECAUSE OF THIS PROBLEM. THIS SHOULD BE LOOKED INTO. OUR VEHICLE HAS 38,000 MILES. WE HAVE A FRIEND WHO LIVES IN NJ THAT HAD THE SAME PROBLEM WITHIN A YEAR OF PURCHASING HIS NEW TRUCK.

NHTSA complaint #10399156 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I ALSO HAVE A 2005 SILVERADO AN THE SPEEDOMETER IS STUCK AT 120 IT HAS GONE DOWN AS FAR AS 60 BUT WHEN YOU DRIVE IT PEGS OUT AND REMAINS THERE. THERE WERE NO WARNINGS JUST HAPPENED AROUND 82,000 NOW AT 86,000 AND 6,000 MILES OUT OF WARRANTY. I FEEL THAT THIS IS A SAFETY HAZARD BECAUSE I DON'T KNOW MY SPEED BUT I AM LUCKY ENOUGH TO HAVE BEEN GIVEN A GPS TO DO THAT. I LOOKED AT GM WEBSITE BUT THEY SAY I AM OVER MILEAGE FOR REPAIR AND I DON'T HAVE THE MONEY FOR THE REPAIRS MYSELF AN FEEL THIS SHOULD BE REMEDIED BY THE MANUFACTURER SINCE IT IS A WELL KNOW PROBLEM OF THEIRS AND THIS DEFECTIVE EQUIPMENT.

NHTSA complaint #10379483 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

SPEEDOMETER NOT SHOWING CORRECT SPEED.

NHTSA complaint #10376288 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

AIR BLOWS COLD ON DRIVER SIDE AND EXTREMELY HOT ON DRIVERS SIDE WITH DUAL CONTROLS BOTH SET TO COOL. SEEMS TO BE A VERY COMMON PROBLEM ACCORDING TO MANY PEOPLE ON THE FOLLOWING WEBSITE AND UNABLE TO BE FIXED BY DEALERS. HTTP://AUTOFORUM.CLASSIFIEDS1000.COM/CHEVROLET-SILVERADO_1500_PICKUP/DUAL_AC_BLOWS_COLD_AIR_ON_PASSENGER_BUT_HOT_ON_DRIVER.

NHTSA complaint #10350433 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I HAVE A 2005 CHEVROLET SILVERADO. I KEPT SMELLING AN ODOR OF SOMETHING BURNING BUT COULD NOT FIND WHERE IT WAS COMING FROM UNTIL RECENTLY WHEN MY FAN MOTOR STOPPED WORKING. I HAD BEEN HAVING PROBLEMS WITH THE SWITCH NOT WORKING IN ALL POSITIONS. I CALLED THE DEALERSHIP TO INQUIRE ABOUT THE PRICE AND AVAILABILITY OF THE SWITCH. THE PARTS DEPT. INFORMED ME THAT IT WAS MOST LIKELY THE FAN RESISTOR OR THE PLUG BECAUSE THEY HAVE HAD SEVERAL THAT NEEDED REPLACED. WHEN I LOOKED UNDER THE DASH I FOUND WHAT HAD BEEN CAUSING THE SMELL. THE RESISTOR SHOWED SIGNS OF BEING OVERHEATED AND THE WIRE HARNESS WAS BURNT FOR APPROXIMATELY 6 INCHES. THIS IS A FIRE HAZARD AND IT IS ONLY A MATTER OF TIME BEFORE SOMEONE IS EITHER INJURED OR KILLED DUE TO THIS DEFECTIVE RESISTOR/PLUG.

NHTSA complaint #10346092 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

SPEEDOMETER INOPERATIVE. EVERYTIME THE VEHICLE IS DRIVEN I HAVE NO WAY OF TELLING HOW FAST I AM TRAVELING.

NHTSA complaint #10335777 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

AT AROUND 37,000 MILES THE SPEEDOMETER STARTED STICKING AND AROUND 45,000 MILES IT COMPLETELY WENT OUT AND HAS BEEN STUCK AT 120 MPH EVER SINCE. I TOOK IT TO THE CHEVY DEALERSHIP AND THEY TOLD ME IT WOULD COST AROUND 800.00 DOLLARS TO FIX. I CALLED AND COMPLAINED TO GM CUSTOMER SERVICE, AT WHICH TIME THEY DID NOTHING BUT TOLD ME TO TAKE IT IN AND GET IT REPAIR AT MY EXPENSE. I HAVEN'T HAD THE MONEY TO HAVE IT REPAIRED SO FAR SO I HAVE BEEN DRIVING WITHOUT IT. I THINK CHEVY SHOULD RECALL THE INSTRUMENT CLUSTERS AND FIX THE PROBLEM AT THEIR OWN EXPENSE.

NHTSA complaint #10331800 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

SPEEDOMETER FAILS TO REGISTER ACTUAL SPEED OF DRIVING -- WILL SHOW 120 WHEN DRIVING 70, 90 MPH WHEN DRIVING 30MPH, 15 MPH WHEN STOPPED AT A LIGHT. MAKES HIGHWAY DRIVING HAZARDOUS BECAUSE I AM PRONE TO DRIVING SLOWER THAN TRAFFIC. ALSO CONCERNS ABOUT ACCURACY OF THE ODOMETER BECAUSE OF THIS PROBLEM.

NHTSA complaint #10325694 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHEN DRIVING THE VEHICLE THE CONTACT NOTICED THAT THE SPEEDOMETER WOULD DISPLAY A SPEED OF 120 MPH WHEN THE CONTACT WAS ACTUALLY TRAVELING AT A SPEED OF 45 MPH. THE DEALERSHIP WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS ON HIS VEHICLE. THE VEHICLE WAS NOT REPAIRED AT THE TIME OF COMPLAINT. THE FAILURE AND CURRENT MILEAGES WERE 90000. UPDATED 07/19/10 *BF UPDATED 07/21/10.

NHTSA complaint #10319985 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM:WIRING

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO DIESEL ENGINE . WHILE DRIVING AT SPEEDS AS LOW AS 50 MPH, THE VEHICLE SPEEDOMOTER WOULD INDICATE THE VEHICLE WAS TRAVELING AT SPEEDS OF 120 MPH AND WOULD STICK AT THIS MILEAGE. THE VEHICLE WAS TAKEN TO THE DEALER, HOWEVER NO REPAIRS WERE MADE TO THE VEHICLE. THE CONTACT WAS NOT PRESENT AT THE TIME THE VEHICLE WAS TAKEN TO THE DEALER AND WAS UNSURE AS TO WHAT WAS ADVISED IN REFERENCE TO THE VEHICLE. THE FAILURE PERSISTED. THE FAILURE AND CURRENT MILEAGES WERE 96,000. UPDATED 06/02/10. *LJ THE CONSUMER WAS INFORMED THE PROBLEM WAS CAUSED BY A WIRING CLUSTER IN THE DASH. UPDATED 06/28/10

NHTSA complaint #10317056 — an unverified report by a vehicle owner.