Owners have filed 361 complaints
about the 2005 Chevrolet Silverado with NHTSA between 2004 and 2021.
The largest single group is the brakes.
Across this model's run it ranks 14 of 24 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 40
Against the median year of the Chevrolet Silverado. 50 means typical for this
model; 100 means roughly double.
Severity — 50
9.7% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 66
39% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2005 compares with every other Chevrolet Silverado
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
268.4%
1,000 – 9,999 miles
4213.6%
10,000 – 24,999 miles
299.4%
25,000 – 49,999 miles
4815.6%
50,000 – 74,999 miles
5718.5%
75,000 – 99,999 miles
4514.6%
100,000 – 149,999 miles
4815.6%
150,000+ miles
134.2%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Nov 2004peak 13Jul 2021
Recalls on the 2005 Chevrolet Silverado
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
08E050000
EXTERIOR LIGHTING:HEADLIGHTS
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
07E106000
WHEELS:HUB
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Risk: WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
07E066000
EQUIPMENT:ELECTRICAL
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Risk: IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
06V289000
ENGINE AND ENGINE COOLING
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Risk: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
06E064000
EXTERIOR LIGHTING
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
06E060000
EXTERIOR LIGHTING
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
06E023000
EXTERIOR LIGHTING:HEADLIGHTS
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
05V455000
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Risk: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 201449214,242 units in Canada
Accessories
*** This notice is provided for information purposes only as the subject equipment is not regulated under the Motor Vehicle Safety Act *** A safety defect may exist in aftermarket ACDelco brake shoes manufactured between April 1st 2013 to April 19 2014, sold and/or installed as service replacement parts. The lining of the rear brake shoe may detach from the steel shoe during normal service, causing the affected brake to fail. If the lining detaches from the steel shoe, it could cause rear-wheel lockup and it will reduce the available braking force which could lengthen the required stopping distance, and increase the risk of a crash without prior warning. Correction: GM Dealers, ACDelco warehouse distributors and their professional installer customers are to inspect the manufacture date of the rear brake shoes and, if necessary, replace the shoes. Customers of the 125 vehicles that were serviced by GM Dealers with the suspect parts will be notified by first class letter.
Recall 2011074190,310 units in Canada
Heater And Defroster
On certain vehicles, the interface between the electrical terminals of the Heating, Ventilation, and Air Conditioning (HVAC) blower relay resistor module and the wiring connector (which powers the module) may be incapable of conducting higher current levels for sustained periods of operation. In addition, moisture and other contaminants (such as road de-icing materials) may enter the fresh air intake plenum and contact the internal circuit of the module or corrode the terminals. These conditions may cause the relay resistor module or wiring connector to overheat, causing various symptoms such as: the HVAC blower may not function on certain or all blower speed settings; a burning-plastic smell or smoke may be present in the vehicle, or; the HVAC blower may run continually with the ignition in the OFF position. These warning signs could, in certain instances, be leading indicators of an impending vehicle fire, which could result in property damage and/or personal injury. Correction: Owners will be provided with additional warranty coverage for the blower motor resistor module/wiring connector overheating condition. Under this "special warranty coverage", should this condition occur within 10 years or 240,000 km from first vehicle registration, dealers will install a replacement blower motor resistor and resistor module connector.
Recall 20061951,485 units in Canada
Fuel System
On certain vehicles, the engine fuel rail pulse damper retainer clip may fracture, resulting in inadequate retention of the damper. If the damper comes loose, a fuel leak may result. Fuel leakage in the presence of an ignition source could result in a fire. Correction: Dealers will replace the engine fuel rail pulse damper retainer clip.
Recall 20052966,487 units in Canada
Steering
Certain vehicles may have been built with a power steering hose that is not to specification. Under extreme steering manoeuvres, such as turning the steering wheel fully to the left or right while braking, the hose may fracture and leak fluid. If this were to occur, power steering assist would be lost and increased steering effort would be required. On vehicles equipped with hydro-boost power brakes, it could also result in loss of power brake assist and increase braking effort would be required. If power steering fluid were to spray onto hot engine parts, an engine compartment fire could occur. Correction: Dealers will inspect the power steering hose(s) for two suspect date codes and replace them if required.
Recall 200511973,473 units in Canada
Seats And Restraints
On certain vehicles, the 2nd row centre occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants. A lap portion of the seat belt routing that is not low and snug on the hips can allow unfavourable occupant kinetics in the event of a crash. Moreover, the higher routing allows the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury. Correction: Dealers will modify the guide loop.
Recall 20051166,920 units in Canada
Brakes
On certain 1999-2002 1500 series and 2001-2005 2500 & 3500 series trucks equipped with a manual transmission, the parking brake friction lining may wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle. Correction: Dealers will install a low-force spring clip retainer on vehicles equipped with PBR parking brake system and install a redesigned parking brake cable assembly on vehicle equipped with a TRW parking brake system.
Recall 2005038260 units in Canada
Lights And Instruments
Certain vehicles equipped with an automatic transmission fail to comply with the requirements of CMVSS 101 - Location, identification and illumination of displays. Under certain vehicle starting conditions, the shift lever position indicator located in the instrument panel cluster may not illuminate. In subsequent vehicle start-ups, this condition may or may not occur again. If the shift lever position indicator does not illuminate, the driver may not know which gear the vehicle is in and the vehicle may move in an unintended direction, resulting in possible injury to others outside of the vehicle. Correction: Dealers will reprogram the instrument panel cluster.
Recall 20050335,014 units in Canada
Brakes
On certain vehicles, the hydraulic brake booster's pressure accumulator may crack and/or separate from the Hydro-Boost assembly during normal vehicle operating conditions. If a separation occurred and the hood of the vehicle was open, fragments from the accumulator could cause injury to people in the immediate area. In addition, the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. The loss of fluid would cause increased steering and braking effort. Correction: Dealers will test and, if necessary, replace the Hydro-Boost assembly.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 281,000 milesRepublic, MOCrash1 injured
SEAT BELTS
The contact owns a 2005 Chevrolet Silverado 1500. The contact stated while driving approximately 50 mph, he lost control of the vehicle due to losing consciousness. The vehicle left the roadway and went airborne and crashed with a road sign landing in a field. None of the airbags deployed and only the seatbelt lap belt tensioned not the shoulder strap. The contact sustained injuries such as several lacerations across the face and inside the mouth, and broken L1 vertebrae. The contact mentioned he fractured the steering wheel with his face during the impact. A police report was filed and the vehicle was towed to a local lot then towed again to the contacts insurance lot where it was awaiting a diagnosis. The manufacturer was not informed of the failure. The failure mileage was approximately 281,000.
NHTSA complaint #11425653 — an unverified report by a vehicle owner.
at 281,000 milesRepublic, MOCrash1 injured
AIR BAGS
The contact owns a 2005 Chevrolet Silverado 1500. The contact stated while driving approximately 50 mph, he lost control of the vehicle due to losing consciousness. The vehicle left the roadway and went airborne and crashed with a road sign landing in a field. None of the airbags deployed and only the seatbelt lap belt tensioned not the shoulder strap. The contact sustained injuries such as several lacerations across the face and inside the mouth, and broken L1 vertebrae. The contact mentioned he fractured the steering wheel with his face during the impact. A police report was filed and the vehicle was towed to a local lot then towed again to the contacts insurance lot where it was awaiting a diagnosis. The manufacturer was not informed of the failure. The failure mileage was approximately 281,000.
NHTSA complaint #11425653 — an unverified report by a vehicle owner.
at 97,000 milesSumpter, SCFire
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE THE VEHICLE WAS PARKED WITH THE AIR CONDITIONER SET ON LEVEL FIVE, THE BLOWER INTERMITTENTLY CLICKED OFF AND ON. THE CONTACT ALSO STATED THAT A BURNING SMELL EMITTED THROUGH THE VENTS OF THE VEHICLE. THE FAILURE RECURRED ON SEVERAL OCCASIONS UNTIL LEVEL FIVE AND FOUR SETTINGS NO LONGER WORKED. THE CONTACT INSPECTED THE CONNECTOR SW/POWER ST ADJUSTER AND DISCOVERED THAT THE WIRES WERE MELTED. THE VEHICLE WAS TAKEN TO THE DEALER AND WAS NOT DIAGNOSED OR REPAIRED. THE DEALER INFORMED THE CONTACT THAT THE CONNECTOR AND RESISTOR FOR THE AIR CONDITIONER AND HEATER AND THE RESISTOR FOR THE HEATER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.
NHTSA complaint #10790722 — an unverified report by a vehicle owner.
at 77,000 milesBaltimore, OHCrash
SERVICE BRAKES
WHILE DRIVING AT 55 MPH, I APPLIED THE BRAKES TO COME TO A STOP. THE BRAKES BEGAN TO SLOW THE TRUCK THEN THE PEDAL WENT CLEAR TO THE FLOOR AND ALL BRAKING ACTION WAS LOST. THIS CAUSED ME TO STRIKE THE VEHICLE IN FRONT OF ME. AFTERWARDS I OBSERVED BRAKE FLUID DRIPPING FROM THE LINES FORWARD OF THE REAR AXLE AND NEAR THE FIREWALL AREA. I WAS VERY LUCKY TO ESCAPE INJURY TO MYSELF AND THE OTHER DRIVER THAT I STRUCK. MY TRUCK SUSTAINED EXTENSIVE DAMAGE TO THE FRONT END. I HAVE NOT GOTTEN ESTIMATES FOR REPAIRS YET.
NHTSA complaint #10631711 — an unverified report by a vehicle owner.
at 101,097 milesMineral Wells, WVCrash
SERVICE BRAKES
APPROACHING A TRAFFIC LIGHT AT THE BOTTOM OF A STEEP GRADED HIGHWAY, I NOTICED THE BRAKE PEDAL FELT SPUNGEY AND NEAR THE BOTTOM THE BRAKE PEDAL WENT CLEAR TO THE FLOOR BOARD. I WAS FORCED TO LEAVE THE HIGHWAY TO PREVENT A REAR END COLLISION WITH THE STOPPED VEHICLE IN FRONT OF ME RESULTING IN NO REAL DAMAGE TO THE VEHICLE ITSELF. IT COULD HAVE BEEN MUCH WORSE. THE BRAKE LINES (4 OF THEM) HAVE RUSTED OUT SO MUCH THAT THEY COULD NOT CONTAIN PRESSURE OF THE FLUID WHEN APPLYING THE BRAKE AND BURSTED. MY MECHANIC TELLS ME THIS WILL BE IN EXCESS OF $600.00 TO REPAIR DO TO THE CAB HAVING TO BE UNBOLTED AND LIFTED FROM THE CHASSIS TO ACCESS THE LINES FOR REPLACING. HE ALSO TELLS ME THAT MANY GM MODELS, NEW AND OLD HAVE THIS PROBLEM WITH RUSTING BRAKE LINES. GM IS AWARE OF THESE PROBLEMS. WHY HAS THIS NOT BEEN ADDRESSED? WHY HAVE THESE MODELS NOT BEEN RECALLED? SUBARU RECENTLY RECALLED OVER 660,000 VEHICLES FOR THE SAME PROBLEM; #DOINGTHERIGHTTHING. I AM NOT AT ALL HAPPY ABOUT THIS.
NHTSA complaint #10608756 — an unverified report by a vehicle owner.
at 102,000 milesGrasonville, MDCrash
SERVICE BRAKES
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH AND DEPRESSING THE BRAKES, THE BRAKE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE CONTACT APPLIED THE EMERGENCY BRAKE. THE CONTACT CRASHED AND REAR ENDED ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES WERE CORRODED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT HE WAS ADVISED THAT THE PARTS WERE ON A NATIONAL BACK ORDER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 102,000.
NHTSA complaint #10558374 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 281,000 milesRepublic, MOCrash1 injured
SEAT BELTS
The contact owns a 2005 Chevrolet Silverado 1500. The contact stated while driving approximately 50 mph, he lost control of the vehicle due to losing consciousness. The vehicle left the roadway and went airborne and crashed with a road sign landing in a field. None of the airbags deployed and only the seatbelt lap belt tensioned not the shoulder strap. The contact sustained injuries such as several lacerations across the face and inside the mouth, and broken L1 vertebrae. The contact mentioned he fractured the steering wheel with his face during the impact. A police report was filed and the vehicle was towed to a local lot then towed again to the contacts insurance lot where it was awaiting a diagnosis. The manufacturer was not informed of the failure. The failure mileage was approximately 281,000.
NHTSA complaint #11425653 — an unverified report by a vehicle owner.
at 281,000 milesRepublic, MOCrash1 injured
AIR BAGS
The contact owns a 2005 Chevrolet Silverado 1500. The contact stated while driving approximately 50 mph, he lost control of the vehicle due to losing consciousness. The vehicle left the roadway and went airborne and crashed with a road sign landing in a field. None of the airbags deployed and only the seatbelt lap belt tensioned not the shoulder strap. The contact sustained injuries such as several lacerations across the face and inside the mouth, and broken L1 vertebrae. The contact mentioned he fractured the steering wheel with his face during the impact. A police report was filed and the vehicle was towed to a local lot then towed again to the contacts insurance lot where it was awaiting a diagnosis. The manufacturer was not informed of the failure. The failure mileage was approximately 281,000.
NHTSA complaint #11425653 — an unverified report by a vehicle owner.
at 105,000 milesOswego, IL
SERVICE BRAKES
THE VEHICLES BRAKES ARE CORRODING AND FAILED ALMOST CAUSING AN ACCIDENT ON 2/09/2016 WHEN THE VEHICLE WAS IN MOTION (AT THE INTERSECTION OF IL ROUTE 34 AND WOLFS CROSSING)
NHTSA complaint #10825082 — an unverified report by a vehicle owner.
Mcconnelsville, OH
SERVICE BRAKES
PEDAL GOES ON DOWN WHEN PRESSED -- SEEMS LIKE ABS ISN'T WORKING PROPERLY
NHTSA complaint #10816342 — an unverified report by a vehicle owner.
at 160,000 milesBlaine, MN
SERVICE BRAKES
BREAK LINES CORRODED THROUGH TO FAILURE. THE FAILURE OCCURRED JUST AFTER EXITING A HIGHWAY. ABS ENGAGED DUE TO ICY CONDITIONS THE NEXT TIME I DEPRESSED THE BREAK PEDDLE IT WENT TO THE FLOOR WITHOUT THE BREAKS ENGAGING. TO THE BEST OF MY KNOWLEDGE NO WARNING LIGHT WAS PRESENT ON THE DASHBOARD. THE BREAKS FAILED WHILE DRIVING AND RESULTED IN ME RUNNING A RED LIGHT. LUCKILY IT WAS EARLY IN THE MORNING AND NO ACCIDENT OCCURRED.
NHTSA complaint #10807596 — an unverified report by a vehicle owner.
at 97,000 milesSumpter, SCFire
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE THE VEHICLE WAS PARKED WITH THE AIR CONDITIONER SET ON LEVEL FIVE, THE BLOWER INTERMITTENTLY CLICKED OFF AND ON. THE CONTACT ALSO STATED THAT A BURNING SMELL EMITTED THROUGH THE VENTS OF THE VEHICLE. THE FAILURE RECURRED ON SEVERAL OCCASIONS UNTIL LEVEL FIVE AND FOUR SETTINGS NO LONGER WORKED. THE CONTACT INSPECTED THE CONNECTOR SW/POWER ST ADJUSTER AND DISCOVERED THAT THE WIRES WERE MELTED. THE VEHICLE WAS TAKEN TO THE DEALER AND WAS NOT DIAGNOSED OR REPAIRED. THE DEALER INFORMED THE CONTACT THAT THE CONNECTOR AND RESISTOR FOR THE AIR CONDITIONER AND HEATER AND THE RESISTOR FOR THE HEATER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.
NHTSA complaint #10790722 — an unverified report by a vehicle owner.
at 130,000 milesNaples, FL
SERVICE BRAKES
SITTING AT BURGER KING DRIVE THRU WHEN BRAKE PEDAL WENT TO THE FLOOR. BRAKE LINES HAD RUPTURED DUE TO CORROSION. VEHICLE ONLY 10 YEARS OLD AND 130,000 MILES. HAD BRAKES CHECKED OFTEN AT SERVICE CENTERS, NO MENTION OF PROBLEM. GLAD THIS DIDN'T HAPPEN LAST MONTH WHEN I WAS BARRELING DOWN THE TENNESSEE HIGHWAY WITH A FULL LOAD IN THE BACK OF MY TRUCK. NHTSA AND GM SHOULD BE ASHAMED FOR ALLOWING THIS TO CONTINUE. I AM SURE PEOPLE ARE DYING DUE TO THIS NEGLIGENCE AND FAULTY MATERIALS BEING USED.
NHTSA complaint #10790118 — an unverified report by a vehicle owner.
at 79,500 milesDodgeville, WI
SERVICE BRAKES
SUDDEN LOSS OF BRAKING POWER DUE TO BRAKE LINE RUPTURE WHILE ON THE EXIT RAMP OF THE FREEWAY. FOUND BRAKE LINES COMPLETELY RUSTED AND THEY WERE PAPER THIN IN MULTIPLE SPOTS. WILL HAVE TO REPLACE ALL BRAKE LINES ON THE VEHICLE. ALMOST LOST CONTROL OF THE VEHICLE. NOTE THAT VEHICLE HAS ALWAYS BEEN MAINTAINED BY DEALERSHIP.
NHTSA complaint #10785511 — an unverified report by a vehicle owner.
at 89,000 milesLansing, MI
SERVICE BRAKES
THE BRAKE PEDAL WENT COMPLETELY TO THE FLOOR WHEN OUR FRIEND TRIED TO STOP THE VEHICLE. A BRAKE LINE RUNNING ON TOP OF THE FRAME BEHIND THE RADIATOR HAD COMPLETELY RUSTED THRU, ALLOWING ALL OF THE BRAKE FLUID TO PUMP OUT OF THE SYSTEM. ALL OF THE STEEL BRAKE LINES ARE EXTREMELY RUSTY AND PROBABLY NEAR FAILURE.
NHTSA complaint #10782875 — an unverified report by a vehicle owner.
at 160,000 milesNorth Branford, CT
SERVICE BRAKES
THESE PAST COUPLE OF WEEKS THE BRAKES ARE SHAKING WHEN I GO TO STOP. I HAVE C HANGED THE FRONT CALIPERS SINCE THIS IS WHERE IT IS HAPPENING SINCE THE CALIPERS WENT BAD SO DID THE ROTERS AN PADS SO THOSE NEEDED TO BE CHANGED ALSO...WHICH IS MONEY I DON'T HAVE .....IT WORKED FOR A TOTAL OF 4 DAYS THEN PROBLEM BEGAN AGAIN. PLEASE INFORM ME OF OTHER ISSUES AND WHAT CAN BE DONE TO RESOLVE THIS PROBLEM ESPECIALLY SINCE I DRIVE THIS TRUCK TO EARN A LIVING FOR MY FAMILY EVERYDAY.. THANK YOU FOR YOUR ATTENTION TO THIS MATTER.
NHTSA complaint #10747254 — an unverified report by a vehicle owner.
at 135,000 milesPickerington, OH
ENGINE
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT NOTICED THERE WAS A ENGINE LEAK AND NOTICED THAT A FEW BOLTS THAT HOLD THE EXHAUST PIPE WERE MISSING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE.
NHTSA complaint #10747067 — an unverified report by a vehicle owner.
at 135,000 milesPickerington, OH
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT NOTICED THERE WAS A ENGINE LEAK AND NOTICED THAT A FEW BOLTS THAT HOLD THE EXHAUST PIPE WERE MISSING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE.
NHTSA complaint #10747067 — an unverified report by a vehicle owner.
at 107,000 milesSaint Georges, DE
SERVICE BRAKES
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING AT APPROXIMATELY 30 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE CONTACT HAD TO TAKE THE VEHICLE OUT OF GEAR IN ORDER TO STOP. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES WERE CORRODED AS A RESULT THE PRESSURE OF THE BRAKE FLUID CAUSED THE LINES TO FRACTURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 107,000. THE VIN WAS NOT AVAILABLE.
NHTSA complaint #10724230 — an unverified report by a vehicle owner.
at 135,254 milesPetoskey, MI
SERVICE BRAKES
ANOTHER DRIVER NOTIFIED US THAT OUR BRAKE LIGHTS WERE NOT WORKING. WE STOPPED TO CHECK THE SITUATION AND MY WIFE APPLIED THE BRAKES AS I CHECKED THE LIGHTS, WHICH WERE NOT WORKING. I THEN MOVED THE TRUCK ABOUT 50 YARDS AND AS I APPLIED THE BRAKES THE PEDAL WENT TO THE FLOOR. WHEN I GOT OUT THERE WAS A PUDDLE OF BRAKE FLUID ON THE GROUND. THE BRAKE LINE HAD RUSTED OUT AND WHEN I APPLIED PRESSURE TO STOP, IT GAVE OUT. I TOOK THE VEHICLE TO A NEARBY DEALER AND THEY REPLACED ALL THE BRAKE LINES DUE TO THE RUST. TOTAL COST $1050. THIS IS A MAJOR SAFETY ISSUE. LUCKILY I WAS STOPPED WHEN THE FAILURE OCCURRED AND NO ONE WAS INJURED. IF THIS HAD HAPPENED WHILE MOVING IN TRAFFIC THE RESULT COULD HAVE BEEN SERIOUS.
NHTSA complaint #10723860 — an unverified report by a vehicle owner.
at 71,000 milesCitrus Heights, CA
ELECTRONIC STABILITY CONTROL (ESC)
DASH LIGHTS GO OUT WHILE DRIVING DOWN THE ROAD HAVE TO PUSH ON DASHBOARD TO MAKE THEM COME BACK CONCERNED THAT THIS MAY BE A FIRE HAZARD
NHTSA complaint #10717743 — an unverified report by a vehicle owner.
at 52,521 milesLatrobe, PA
SERVICE BRAKES
BRAKE LINE BROKE. BRAKE LINES ARE SEVERELY CORRODED. I LOST MY BRAKES WHILE DRIVING. THE PEDAL WENT TO THE FLOOR.
NHTSA complaint #10713086 — an unverified report by a vehicle owner.
at 98,750 milesDysart, IA
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
SPEEDOMETER DOES NOT READ ACCURATE. IT EITHER READS 15 MPH AT HIGHWAY SPEEDS, OR GOES WAY HIGH SUCH AS 120 MPH AT 55 TO 60 MPH. SOMETIMES AT THE HIGHER READING, IT WILL READ 60 MPH WHEN VEHICLE IS STOPPED, IN PARK, AND IGNITION OFF. I WAS TOLD THIS IS A STEPPING MOTOR BUT HARD TO CHANGE AND EXPENSIVE TO CHANGE. I HAVE READ THAT THERE WAS A CLASS ACTION LAWSUIT THAT WAS NEVER BROUGHT UP.
NHTSA complaint #10695278 — an unverified report by a vehicle owner.
at 30,567 milesChester, NH
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
FRAME IS ROTTED,WONT PASS INSPECTION,BRAKE LINES ARE ALSO ROTTED HAD TO REPLACE TWICE.
NHTSA complaint #10683617 — an unverified report by a vehicle owner.
at 30,567 milesChester, NH
SERVICE BRAKES
FRAME IS ROTTED,WONT PASS INSPECTION,BRAKE LINES ARE ALSO ROTTED HAD TO REPLACE TWICE.
NHTSA complaint #10683617 — an unverified report by a vehicle owner.
at 113,000 milesWentworth, NC
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING AT APPROXIMATELY 65 MPH, THE SPEEDOMETER REMAINED AT 120 MPH AND FAILED TO PROVIDE AN ACCURATE READING. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.
NHTSA complaint #10683053 — an unverified report by a vehicle owner.
at 110,000 milesWhiting, NJ
SERVICE BRAKES
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE HAVING REGULAR MAINTENANCE PERFORMED ON THE VEHICLE, THE CONTACT WAS NOTIFIED THAT THE BRAKE LINES WERE RUSTED. THE BRAKE LINES WERE NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
NHTSA complaint #10680840 — an unverified report by a vehicle owner.
at 96,263 milesChesapeake, VA
SERVICE BRAKES
BACKING-UP INTO MY GARAGE IN REVERSE MODE, PRESSED THE BRAKE PEDAL AND IT WENT RIGHT TO THE FLOOR.
NHTSA complaint #10671521 — an unverified report by a vehicle owner.
at 130,000 milesNEW Egypt, NJ
SERVICE BRAKES
THE BRAKE LINES ARE VERY RUSTED AND I AM VERY CONCERNED THIS CAN LEAD TO A SERIOUS INJURY FOR MYSELF OR OTHERS. I KNOW OF MANY OTHER OWNERS OF SIMILAR MODEL TRUCKS WITH THE SAME PROBLEM. THIS IS A VERY REAL SAFETY THREAT AND GM SHOULD REPAIR UNDER WARRANTY AS THIS IS A SERIOUS DEFECT.
NHTSA complaint #10671238 — an unverified report by a vehicle owner.
at 50,250 milesBrentwood, CA
AIR BAGS
SRS WARNING CAME ON. HAD FAULT CODE. CALLED CHEVY DEALER AND THEY SAID I WOULD NEED A NEW AIRBAG. I RESEARCHED AND FOUND THAT GM DOES KNOW ABOUT THIS AND EVEN PUT OUT A TSB. IT IS A CONNECTOR TO THE AIRBAG ITSELF LOCATED IN THE LEFT KICK PANEL. THE FIX IS TO CLEAN THE CONNECTOR OR REPLACE IT. NO NEW AIRBAG IS NEEDED BUT IT DID REOCCUR ABOUT A YEAR LATER. RECLEANED AND OK AGAIN. THIS IS A SAFETY ITEM AND SHOULD BE A RECALL. SINCE GM KNEW IT I MUST ASSUME THAT NHTSA KNEW IT ALSO. I CAN SEE WHERE A LOT OF PEOPLE WOULD NOT FIX THIS AND JUST DRIVE LIKE THIS SINCE A LOT OF TECHNICIANS THINK YOU NEED A NEW AIRBAG WHEN IT IS IN FACT POOR WIRING BY GM.
NHTSA complaint #10669755 — an unverified report by a vehicle owner.
at 49,550 milesWestbrook, CT
SERVICE BRAKES
SEVERE CORROSION AFFECTED BRAKE LINE. PEDAL WENT TO THE FLOOR AND I WENT THROUGH INTERSECTION. USING MY E-BRAKE I WAS FORTUNATE TO STOP AND NOT HIT ANYTHING. I FEAR IF MY 16 YEAR OLD SON, OR MY WIFE WOULD NOT OF FARED SO WELL IN THIS SITUATION. NOW I HAD TO ABSORB A 800.00 REPAIR FOR NEW BRAKE LINES. NOW 1.5 YEARS LATER I NEED TO REPLACE FUEL LINES AS WELL AS TRANSMISSION LINES DUE TO CORROSION. MY 16 YEAR OLD DRIVES THIS PIECE OF JUNK, AND NOW THERE IS A SAFETY ISSUE WITH FUEL LINES. FIRE!!! NOW NEED TO INCUR ADDITIONAL REPAIRS. WHY NO RECALL? THIS IS A LAWSUIT IN THE MAKING IF THERE WERE TO BE AN ACCIDENT DUE TO GM'S IRRESPONSIBILITY. I WILL NEVER BUY A GM PRODUCT AGAIN. NEED A RECALL... [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #10668119 — an unverified report by a vehicle owner.