508 of the
2,964 complaints filed about the Chevrolet Volt
are about the fuel system —
17% of everything owners reported.
The worst model year for it is 2017.
The vehicle experienced a catastrophic charging system failure. When connected to the wall charger, the charge port becomes hot to the touch within seconds. The charger connector has now cracked from heat stress, and the wall charger itself previously melted due to electrical backfeed from the vehicle. The vehicle refuses to charge at all. This appears to be a thermal event and fire-risk safety defect involving the onboard charger, wiring harness, or battery management system. Insurance refused coverage due to the nature of the electrical failure. The vehicle is unsafe to charge or operate.
NHTSA complaint #11757523 — an unverified report by a vehicle owner.
I was driving on an interstate in Seattle, and the car completely died. A check engine light went on. I had to roll into the shoulder and call for a tow to the dealership's service department. Here is what they found: ----60GCZ ENGINE REPAIR DIAG/ customer reports the ses lamp is on with reduced propulsion message displayed. Check and advise. 1. Tested vehicle and verified reduced propulsion power message and SES light. Scanned vehicle for codes and found multiple P0489, P0030, P0031, P0132, P0135, P0137, P0443, P0458, P0597, P0598, P06DA, P06DB, and P103C. Traced back to no power on circuit 5293. Traced back to blown 15-amp fuse 3 of under hood fuse block. Found bulletin #24-NA-080 stating this can be caused by a short in the EGR valve. Tested circuit 5293 and found short at the EGR valve. Advise EGR valve and cooler replacement then retest.---- We disconnected the EGR valve, which means we are driving only on gas, not electric. We cannot charge it anymore. The cost to replace the valve and cooler is over $4k because Chevrolet does not make the vehicle anymore or the EGR valve part apparently. This is a SIGNIFICANT safety hazard if the car is going to simply die suddenly. It is a miracle I did not get hit.
NHTSA complaint #11757544 — an unverified report by a vehicle owner.
While driving on a highway the car started to hesitate, a message appeared on the console "Propulsion power is reduced" and the engine light turn on. After driving some miles, a new message appeared: "Engine unavailable, service soon" and the car only ran on electric power, no motor engine. I had the same problem 3 year ago and the dealer identified the problem as a shorted EGR valve. This time I knew this shorted EGR valve burns the F3 fuse. I managed to get to a car part shop and bough several fuses (15 amp). After replacing the fuse 3 times I managed to get to the dealer. The repairs cost $3000+ (up from $1000+ 3 years ago). This problem is well documented on the GM service technical bulletin "21-NA-116" dated February, 2023. Three years ago I was in the middle of nowhere in South Texas and it took 6 hours to get a tow truck This time I was lucky enough to be close to to a town that the remain battery power was enough to get to the store where I bought the fuses. GM should recall this part and do a proper fix
NHTSA complaint #11755062 — an unverified report by a vehicle owner.
I was investigating a thumping sound coming from the vehicle when going over bumps. I discovered that the left fuel tank strap had completely broke into two pieces and was no longer holding up the tank. The fuel tank straps are not readily viewed on the vehicle until you lower/remove the underbody aerodynamic material. It appears that the underbody aerodynamic material may have been contributory by retaining dirt and trapping moisture in contact with the tank straps. The failed tank strap parts are available for inspection. No other indication of the failed tank strap other than the minor noise and no other inspections have been performed on the failed component.
NHTSA complaint #11753393 — an unverified report by a vehicle owner.
The Battery Energy Control Module (BECM) failed. Before repair, the check-engine light appeared intermittently, the vehicle sometimes had difficulty starting, and the indicated electric range could suddenly drop from about 30 miles to zero despite a charged high-voltage battery. When this occurred, the gasoline engine started unexpectedly. The air conditioning also intermittently blew warm air until the vehicle was restarted. These symptoms created a safety concern because propulsion mode and indicated range could change without warning, and the vehicle could fail to start in traffic or another unsafe location. An authorized Chevrolet dealer confirmed the problem. The dealer retrieved DTCs U2624 and U2629, performed circuit testing, and diagnosed an internal short in the BECM causing loss of communication with high-voltage battery modules. The dealer stated this failure caused the warning light, starting issue, sudden loss of indicated battery range, and air-conditioning symptoms. The BECM was replaced and programmed after removal of the high-voltage battery assembly. The warning light first appeared about one month before repair, with the other symptoms becoming more apparent in early July 2026. The vehicle had approximately 80,918 miles when inspected. The failed component was retained by the dealership as a core and is not available to me for inspection. To my knowledge, the vehicle was not separately inspected by police, insurance, or GM engineering personnel. My vehicle was excluded from GM Special Coverage N232432680 even though it is a 2018 Chevrolet Volt with the same confirmed BECM failure addressed by that program and NHTSA investigation PE23022. I paid $3,970.56 for the repair. I am filing this complaint because this defect can cause no-start, loss of indicated battery range, warning lights, unexpected propulsion changes, and potentially reduced propulsion, while some affected 2016–2018 vehicles appear excluded from the special coverage.
NHTSA complaint #11752752 — an unverified report by a vehicle owner.
While driving down highway rapidly slowed to 15mph. "reduced propulsion" was displayed with significant battery and gas left. Caused cars to swerve and pile up behind me. The car was inspected by dealer and received a variety of U26XXX codes. Dealer states its a faulty BECM. There was no warning lights on before the incident and have had no issues till then. We were lucky this was during the day. Nighttime would have been a terrible accident with oncoming traffic. Dealer is not wanting to cover BECM repair from GM Special Coverage Bulletin N232432680 that was investigated by your organization a couple of years ago.
NHTSA complaint #11752213 — an unverified report by a vehicle owner.
In March 2026, our 2017 Chevrolet Volt (89,300 miles) would not charge nor start, and had to be towed to an authorized Chevrolet dealership in Portland, Oregon. The dealership diagnosed an internal fault in the Battery Energy Control Module (BECM) producing U26XX diagnostic trouble codes, per GM bulletin #18-NA-261, and replaced the BECM under GM Special Coverage N232432680 — GM's field remedy for a known BECM defect affecting 2016–2019 Volts that causes reduced power, no-start, or no-charge conditions (the subject of NHTSA investigation PE23022).The remedy failed immediately. On the day the vehicle was returned to us (March 26, 2026), the check engine light illuminated while driving home on public roads, and the vehicle failed to charge that same night — the identical condition it had before. It was towed back to the dealership. The dealership's second work order confirms in writing that the vehicle "will not start after previous repairs and is having the same issues," and attributes the failure to the high-voltage battery contactor. The dealership informed us the part is no longer produced and cannot be obtained, advising that the vehicle be scrapped. Safety concerns: (1) after the repair, the dealership returned the vehicle to us as fixed, and we drove it approximately 26 miles home on public highways in traffic, unaware the defect was still present — the check engine light illuminated during that drive. This defect is the subject of NHTSA investigation PE23022 into sudden loss of propulsion, we unknowingly operated a defective vehicle in conditions where that failure could have occurred at highway speed; (2) GM's official field remedy for this known defect (Special Coverage N232432680) failed within hours of being performed; and (3) the parts required to complete the remedy are reportedly discontinued, leaving a known safety defect permanently unrepairable. Supporting documents uploaded: dealer repair orders, and the GM warranty history of the N232432680 repair
NHTSA complaint #11751708 — an unverified report by a vehicle owner.
The car suddenly lost power and produced error messages on the screen. I had to quickly change lanes to get out of traffic on the highway. My dealer diagnosed the issue as a BECM malfunction and quoted a repair cost of approximately $3500. However, due to my car originally being registered in California, this failure is not covered under GM Special Coverage Bulletin N232432680 (issued March 2024), which provides an extended warranty for BECM issues on affected 2016-2018 Volts up to 15 years or 150,000 miles. My VIN does not qualify for this coverage despite the vehicle being within the model years affected by known BECM soldering/connection failures. This appears to be part of a broader pattern of BECM defects in 2016-2019 Volts that can lead to sudden loss of propulsion, as previously investigated by NHTSA. GM should extend coverage or issue a recall for all affected vehicles, as this defect compromises vehicle safety and leaves owners with expensive out-of-pocket repairs for a known issue.
NHTSA complaint #11748652 — an unverified report by a vehicle owner.
The Battery Energy Control Module (BECM) on my 2016 Chevrolet Volt has failed. The vehicle and the component are currently located at my home address and are available for inspection upon request. As of writing this now. This failure caused the vehicle to enter a "reduced power mode" and subsequently resulted in a no-start and no-charge condition. The sudden loss of propulsion power presents a severe safety and crash risk, as the vehicle can lose motive power and stall unexpectedly while in transit. Prior to the complete failure, the vehicle displayed a Check Engine Light and a "Reduced Propulsion Power" message on the dashboard. The local Chevrolet dealership has inspected the vehicle, pulled the associated diagnostic trouble codes, and officially confirmed that the BECM has failed. General Motors has already acknowledged this specific safety defect through Special Coverage Bulletin N232432680, which extends BECM warranty coverage to 15 years or 150,000 miles to prevent sudden loss of propulsion. However, GM corporate and the dealership are refusing to honor this bulletin. They are denying coverage due to an administrative database flaw because my vehicle's under-hood VECI label designates it as an original California (CARB/PZEV) vehicle, GM's system excluded my VIN from the Special Coverage bulletin automation. Furthermore, because the vehicle is currently registered in a non-CARB state (Texas), the original CARB warranty is considered void. GM is using this internal database loophole to deny repairing a documented safety defect.
NHTSA complaint #11747550 — an unverified report by a vehicle owner.
While driving at highway speeds over 100 miles away from home with my child in the vehicle, the car experienced a sudden, catastrophic loss of propulsion power and entered 'Propulsion Power Reduced' mode, dropping vehicle speed immediately and creating an extreme hazard with high-speed highway traffic. A full computer scan revealed active diagnostic codes U2603 through U2624, confirming an internal hardware communication failure of the Battery Energy Control Module (BECM). This matches GM Technical Service Bulletin 18-NA-261. The vehicle has over 150,000 miles, but I have only owned the car since January. This is a known, systemic manufacturing defect (cracked internal circuit board solder joints) that creates a critical safety liability regardless of vehicle mileage. GM has refused to remedy the safety defect due to the mileage limit.
NHTSA complaint #11745949 — an unverified report by a vehicle owner.
I purchased the above-listed 2016 Chevrolet Volt through Carvana, relying on the contractual promise that the BECM was covered under Special Coverage N232432680 for up to 15yrs or 150k miles. The vehicle has suffered persistent, severe mechanical and electrical issues resulting in a prolonged loss of use: 1. Initial Breakdown and Delivery: The vehicle originally had a Reduced Propulsion Power Alert on Monday [XXX] around 8pm and nearly caused me to be rear ended on a major road due to accelration issues. It then officially broke down on Tuesday, [XXX]. It was then delivered to Vic Koenig Chevrolet (1040 E Main St, Carbondale, IL 62901) via Tow By Freedom Towing the following Friday, May 29, 2026. 2. Delayed Work Start & Shop Stay: Vic Koenig Chevrolet was able to officially begin diagnostic and repair work on Wednesday, June 3, 2026. The facility held the vehicle for several weeks to address the failures. 3. Brief Release and Immediate Re-Breakdown: I picked up the vehicle upon its supposed completion on Tuesday, June 16, 2026. Then less than 24 hours later, on Wednesday, [XXX], the vehicle suffered a recurring breakdown and had to be returned to the dealership immediately. 4. Wrongful Coverage Denials: On Thursday June 19, 2026, Silver Rock claims representatives issued explicit coverage denials to me via text message. That same day, service representatives from Vic Koenig Chevrolet phoned Silver Rock multiple times to provide diagnostic evidence, But SilverRock repeatedly issued oral denials over the phone. They stated the PCM and BECM were not included in the contract, screenshots of the vontract state the opposite. SilverRock sent this refusal via email to me on June 19. I also contacted GM by phone on Wednesday 5/27/26 and so did the dealership and they refused to cover my vehicle under the Special Warranty for the known issue. I tried to request a cost reduction and they denied it again on 6/22/26. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11745571 — an unverified report by a vehicle owner.
Received "reduced propulsion" message, with no engine detected. Car slowed to a near stop while driving on the Interstate highway. Very dangerous to have that suddenly happen. Message popped up randomly with no prior warning.
NHTSA complaint #11745522 — an unverified report by a vehicle owner.
I was not going to put in a complaint about this failure but after learning about GM creating a special extended warranty program for this issue, I felt it should be addressed and treated as a recall. The battery energy control module (BECM) failed on my 2017 Chevrolet Volt at exactly 170,000 miles in December of 2024, leaving me in a dangerous position on the roadway and almost causing me to be rear ended due to losing the ability to accelerate. I had no choice but to have the vehicle towed to a dealership where it was eventually repaired with an out of pocket cost of $1900. My vehicle was not eligible for the extended warranty program which I find to be unacceptable.
NHTSA complaint #11742228 — an unverified report by a vehicle owner.
Message on dash "Service High Voltage charging system" . Code cleared by inexperienced mechanic. Stalled on the side of the road with "Engine not available" , "Low propulsion" . My local Chevy dealership confirmed a high volt battery leak its now at risk for catching on fire
NHTSA complaint #11742075 — an unverified report by a vehicle owner.
My 2016 Chevy Volt started experiencing the "Propulsion Power is Reduced" issues associated with a faulty BCEM unit. I brought my vehicle in for service at a Chevy dealer and they confirmed that the BCEM needed to be replaced. This is a known issue resulting in special coverage under N232432680. Chevy is not honoring the special coverage for my vehicle despite my vehicle being less that 15 years old and having fewer than 150,000 miles. According to the service manager after talking to someone higher up the food chain at Chevy, "they're no longer covering this service."
NHTSA complaint #11737027 — an unverified report by a vehicle owner.
I was driving my 2018 Chevy Volt at about 30 mph on EV mode. The battery was at 50%, the car was performing normally. Then the battery jumped to 100%, the check engine light came on, and the vehicle lost power. I was in rush hour traffic and unable to get the vehicle to go faster than 5-10 mph. I switched to "normal" mode to engage the gasoline engine, hoping this would help but it did not. The gas engine RPM fluctuated wildly and did not restore the ability to accelerate the vehicle. I was still unable to go faster than 5-10 mph. I was a few blocks from home and managed to get home safely. The engine code was P1E00. I put the vehicle on the charger and it seemed fine the next day. This exact situation I ran into - reduced engine power - is addressed in Special Coverage N232432680, which includes this vehicles VIN. I took the car to the GM dealer today and they are telling me that the car is fine, they can find no problems. I mentioned that this issue is covered under Special Coverage N232432680, and was told that unless they can reproduce the issue in the shop, that they cannot apply Special Coverage N232432680.
NHTSA complaint #11735155 — an unverified report by a vehicle owner.
The vehicle losses power on high speed, check engine comes on, low propulsion massage displays. Vehicle does not charge. Issues similar to the investigation DCS6812.
NHTSA complaint #11726565 — an unverified report by a vehicle owner.