311 of the
2,964 complaints filed about the Chevrolet Volt
are about the airbag system —
10% of everything owners reported.
The worst model year for it is 2013.
The passenger presence sensor is failing or failed because every time someone sit in there the airbag turns on and off repeatedly every 2-3 mins and gives a service airbag warning and if no one is sitting in the passenger seat then it just stays on. Could be really dangerous if a wreck happens while it’s glitching in the off mode and could cause death. Multiple people have had this problem with the volts and there is even a thing you can by to completely bypass the airbag going off which shows how common the problem is if there is a solution to eliminate it in an unsafe/not factory manner
NHTSA complaint #11720796 — an unverified report by a vehicle owner.
The passenger occupancy sensor gives a false positive. The only way I can get rid of the beeping is plug in the seatbelt. I have read on Reddit forums that this is a very common problem with 2013 volts, but for some reason there isn't a recall. This is a safety issue. Thank you!
NHTSA complaint #11695594 — an unverified report by a vehicle owner.
Front passenger seat sensor intermittently fails, causing the Passenger Airbag indicator to switch to OFF (even if a passenger is present) with an accompanying "Service Airbag" message on the dashboard and illumination of the service airbag light. This occurs usually driving above 25mph, but can happen stationary, and lasts for anywhere from 5 seconds to a minute (more commonly shorter). The issue appears some weeks more than others, usually activating most days a week but sometimes have a week or two where it does not happen.
NHTSA complaint #11676789 — an unverified report by a vehicle owner.
passenger presence detection system is malfunctioning, and causing a "service airbag" warning. This is a huge safety issue that could be detrimental or deathly in the event of an accident. This is a common issue among generation 1 volt owners, and should be considered for a recall or warranty coverage. The passenger presence detection system parts are discontinued, and even if I found the part the dealership cannot confirm for the pricey repair, that the airbag / sensor will not simply malfunction again -- which makes this a persistent safety concern and huge owner inconvenience to say the least.
NHTSA complaint #11644947 — an unverified report by a vehicle owner.
Passenger presence does not detect people in it and makes it unsafe for passenger without airbags. This got closed and was state that there was a Chevy program to fix this as cited in the closing . I have called all over Chevy and there is no one who knows anything about this at all. If you know it or if they just started it to make it go away, please tell with with whom I can contact within Chevy to start the process
NHTSA complaint #11636406 — an unverified report by a vehicle owner.
Airbag warning light illuminated on dash. Vehicle no longer registered the passenger in the front passenger seat. Dealer states diagnostic code indicates OCCUPANT POSITION DETECTION SYSTEM SENSOR is faulty. None in stock and no expected delivery date. Until part is repaired/replaced the vehicle will not detect a front seat passenger so the front seat passenger airbags will NOT deploy in a collision. Dealer states cost of repair to be in excess of $1,100!!
NHTSA complaint #11617102 — an unverified report by a vehicle owner.
The contact owns a 2017 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the contact became aware that the air bag warning light illuminated. The vehicle was taken to the dealer however, the vehicle was not diagnosed, or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 20,000.
NHTSA complaint #11608316 — an unverified report by a vehicle owner.
Repeats constantly..."service airbag". Appears to stop for somewhat variable lengths of time with passenger in front seat. Seems to be related to presence sensor.
NHTSA complaint #11603460 — an unverified report by a vehicle owner.
In September 2019, the Office of Defects Investigation (ODI) opened [XXX] to assess the malfunction of the Passenger Sensing System (PSS) in the 2012-2013 Chevrolet Volt vehicles. Due to that malfunction, the air bag system malfunction indicator light is activated. This could cause the passenger airbag to be suppressed in a crash. In July 2021, the ODI closed [XXX] after GM instituted a cost reduction program for the repair/replacement of the PSS in the subject vehicles. In July 2023, I took my 2012 Volt to a local dealer to correct this problem, only to learn that the necessary replacement part has been DISCONTINUED by GM and is no longer available. That is, frankly, unconscionable. I am requesting that ODI reopen the investigation and take further action to compel GM to make this repair available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11583704 — an unverified report by a vehicle owner.
This issue has been reported extensively: NHTSA PE19013. The passenger seat sensor has failed leading to the airbag turning on and off rapidly while driving. This is available for inspection upon request. I worry about the safety of occupants in the car. If the airbag is turned off despite a passenger sitting in the seat that is a problem. The price of repair at a dealer is very high considering that this is a very clear quality control issue by GM that has been acknowledged by both GM and NHTSA. This warning light has turned on before and then went away for a long time. Now it has returned and after some research it is clearly an issue that many other 2012-2013 volt owners have experienced.
NHTSA complaint #11581443 — an unverified report by a vehicle owner.
Chevy Volts from 2016 - 2019 all have a manufacturing defect which can prevent the driver from powering - the error message is "Shift to Park". GM released a Volt Service Bulletin in May 2021 but offered no assistance to replace the defective part. On [XXX] I was driving home on [XXX] headed [XXX] from Santa Cruz in fair weather in the afternoon. This highway can be dangerous with limited shoulders and poor visibility, making it an unsafe place to pull over. While traveling at about 55 mph, the car made an alert sound and illuminated the check engine light and presented a message "Shift to Park". I was running out of room on the shoulder to pull off safely so I had to make the quick decision to pull off to the left-hand shoulder. I followed the instructions on the display which said to shift into park, followed by shifting back into drive. During this time I had my foot on the brake, but after removing my foot from the break, the vehicle began to roll towards traffic, so I put my foot back on the break. I tried powering the car off/on multiple times and tried to get the car to go back into drive but was unsuccessful. Eventually, I put the car back into park, called a tow truck driver, and waited for over an hour to have my car safely towed off [XXX]. Prior to this, I had not experienced any of these or similar symptoms. An OBD code scan was done (screenshot attached). Once at the Chevy dealership, they confirmed that the car could, at that time, shift into park and were not able to reproduce the "Shift into Park" issue. However, they reported that the car was revving high and the transmission would not shift into the proper gear ratio. The dealership was not able to fully diagnose the problem and instead suggested to replace the entire transmission as assembly and then continue investigating. We reached out to the manufacturer, Chevrolet/GM, about the issue(s) and were ed case # [XXX] while they work with the dealership to investigate further. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (F
NHTSA complaint #11576031 — an unverified report by a vehicle owner.
I have a 2013 Volt. Passenger Presence pad in the passenger front seat caused the "Airbag Service" warning light. It is very common. So many people have suffered from it. It cost over $1000. But it is not a recall.
NHTSA complaint #11574144 — an unverified report by a vehicle owner.
The passenger side seat airbag sensor is malfunctioning. A message displaying “Service Airbag” comes up and the airbag light comes on. This happens numerous times during a typical drive (around 20 minutes) The airbag is turned off while the message and light is displayed. This issue has been occurring for about a year or two now. Starting around 90k miles, currently has 111k miles. I’ve done my research on this issue and many other Volt owners have this issue. Which is caused by a defect in the passenger side sensor mat in the seat that can fold over itself with normal use, causing the issue.
NHTSA complaint #11566665 — an unverified report by a vehicle owner.
The contact owns a 2012 Chevrolet Volt. The contact stated while operating the vehicle, the front passenger’s side air bag warning light remained illuminated. The vehicle was taken to the local dealer who determined that the front passenger’s side air bag Passenger Sensor System was faulty and needed to be replaced. The vehicle was not repaired. The contact was informed that the part to repair the vehicle had been discontinued and no repair was available. The manufacturer was contacted and confirmed that the part was discontinued. The failure mileage was 100,000.
NHTSA complaint #11562249 — an unverified report by a vehicle owner.
Front passenger airbag sensor is off even when there is no person sitting in the front passenger seat. It is off also when adult passenger is seating in the seat. It looks by pages of manual folded that previous owner had similar problem. That could possibly impact non-deployment of air-bag in a case of collision. My google search shows there was a recall of Volt 2013 models for that problem.
NHTSA complaint #11561687 — an unverified report by a vehicle owner.
The contact owns a 2012 Chevrolet Volt. The contact stated while driving at various speeds, the "Service Air Bag" warning light intermittently illuminated. The contact notified a dealer about the failure and was provided a diagnostic fee. The manufacturer was also notified of the failure and the contact was provided the same information. Upon investigation, the contact discovered NHTSA Action Number: PE19013 which was linked to the failure. The NHTSA investigation was later closed. The vehicle was not diagnosed or repaired. The failure mileage was approximately 127,000.
NHTSA complaint #11550205 — an unverified report by a vehicle owner.
Intermittent warning for front passenger airbag. Module saying service airbag comes on and off when front passenger is occupying seat. Just a quick anecdote just had car inspected warning does not appear while someone is occupying front seat, nor does it appear if someone is occupying rear seats.
NHTSA complaint #11546243 — an unverified report by a vehicle owner.