2004 Dodge Durango transmission problems

POWER TRAIN

The contact owns a 2004 Dodge Durango. The contact stated while driving approximately 65 mph, the vehicle jerked and automatically engaged into four-wheel drive. The vehicle was taken to the dealer where it was diagnosed that the transfer case needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 100,000.

NHTSA complaint #11419148 — an unverified report by a vehicle owner.

POWER TRAIN

VEHICLE SWITCHING INTO 4LOCK WITHOUT INDICATION ON DASH OR WARNING OF WHEN IT WILL HAPPEN. SVC LIGHT COMING ON AND OFF OFTEN AT LOW SPEEDS TURNING THE VEHICLE IS UNPREDICTABLE AND DANGEROUS TO DRIVE DUE TO THE ADDITIONAL GAS THAT NEEDS TO BE APPLIED TO GET THE CAR TO MOVE... IT THEN JUST SUDDENLY LETS GO.

NHTSA complaint #11321912 — an unverified report by a vehicle owner.

POWER TRAIN

WHILE I WAS DRIVING THE 4 WHEEL DRIVE TURNS ON AND OFF AUTOMATICALLY 1 TIME IN A PARKING LOT GOING 5 MPH AND THE 2 AND TIME DRIVING 30 MPH. THE WHEELS FELT LIKE THEY LOCKED UP HAD TO PULL TO THE SIDE OF THE ROAD

NHTSA complaint #11298537 — an unverified report by a vehicle owner.

POWER TRAIN

ABOUT A WEEK AGO MY ALTERNATOR AND BATTERY HAD TO BE REPLACED, A DAY OR TWO AFTER I HAD THEM REPLACED I WAS PULLING OUT ONTO A STATE ROAD AND I HEARD SOMETHING GOT CRUNCHED, SO I STOPPED AND GOT OUT ANS LOOKED AND NOTHING. GOT BACK IN RHE CAR AND PUT IT IN DRIVE AND I LOOKED DOWN AT MY DASH AND HEART SOMETHING TRYING TO ENGAGE AND ON MH DASH MY SVC 4WD LIGHT STARTED FLASHING.. IM NOT SURE HOW RO FIX IT OR WHAT TO DO, IT DOES IT QUITE FREQUENTLY. I OPENED THE TRUNK AND HEARD IT TRYING TO ENGAGE. STOPPED AT A STOP LIGHT, I CAN HEAR IT TRYING TO ENGAGE TO 4 WD. I HAVE BEEN LOOKING INTO THIA AND I SEE SEVERAL CONSUMERS HAVE HAD THE SAME ISSUES. IT SEEMS DODGE SHOULD BEABLE TO COME UP WITH A PERMANENT FIX, BUT NO RECALLS YET... MY MAIN CONCERN IS, WHAT HAPPENS IF IM DOING 80 MPS ON THE FREEWAY AND IT TRIES TO ENGAGE INTO 4LOW?? THANK YOU FOR YOUR TIME!!

NHTSA complaint #11190143 — an unverified report by a vehicle owner.

POWER TRAIN

THE TRANSFER CASE RANDOMLY SHIFTS INTO 4 WHEEL LOCK AND EVEN 4-LO. THIS HAPPENS EVEN WHEN DRIVING. I CURRENTLY ONLY DRIVE ON CITY STREETS AS I AM CONCERNED THAT IT WILL CAUSE ANY ACCIDENT OR DAMAGE THE VEHICLE IF IT SHIFTS INTO 4-LO AT HIGHER SPEEDS. THE TRANSFER CASE IS CURRENTLY STUCK IN 4 WHEEL LOCK, WHICH MAKES IT VERY HARD TO TURN. I HAVE READ IN FORUMS THAT MOST PEOPLE DISCONNECT THEIR TRANSFER CASE MOTOR, LOSING FUNCTIONALITY BUT MAKING THE TRUCK SAFER. I CANNOT DISCONNECT THE TRANSFER CARE MOTOR WHILE IT IS STUCK IN 4 WHEN LOCK. DODGE SHOULD BE HELD RESPONSIBLE AND FORCED TO FIX ALL THESE VEHICLES.

NHTSA complaint #11182180 — an unverified report by a vehicle owner.

POWER TRAIN

KEY FHOB'S HAVE NOT BEEN WORKING FOR A WHILE. REPLACE BATTERY STILL NOT WORKING. NOW MY SHIFT MOTOR ON THE TRANSFER CASE IS RANDOMLY SHIFTING AND LOCKING IN 4WD HIGH. THIS HAPPENS WHILE DRIVING DOWN THE ROAD. IT HAPPENS WHILE PARKED IN THE PARKING LOT THEN WHEN YOU GO TO DRIVE HARD TO TURN OR GET OUT OF 4WD. WHEN IT LOCKS IN 4WD IT IS NEARLY IMPOSSIBLE TO BACK UP. IT DOESN'T SEEM TO MATTER WHETHER YOU'RE PARKED DRIVING ON CITY STREETS OR ON THE HIGHWAY. HOWEVER, WHEN IT HAPPEN IT CAN LEAD TO INABILITY TO STEER AND CONTROL THE VEHICLE. THIS IS VERY DANGEROUS AND CAN ALSO LEAD TO SUBSTANTIAL COSTLY REPAIRS FROM BEING IN 4WD AND NOT ON THE CORRECT SURFACE. REVIEWING MANY ON-LINE FORUMS I'M FINDING THAT THERE ARE SEVERAL OTHERS THAT ARE EXPERIENCING THE SAME ISSUE. ALTHOUGH THERE HAVE BEEN MANY ATTEMPT TO CORRECT THE PROBLEM THERE SEEMS TO BE AN UNWILLINGNESS TO HELP OR DIAGNOSE THE ISSUE. MANY REPAIRS HAVE BEEN DONE AND HAS NOT RESOLVED THE ISSUE OR TEMPORARILY FIXS IT AND THEN RIGHT BACK TO THE SAME ISSUE.

NHTSA complaint #11180537 — an unverified report by a vehicle owner.

POWER TRAIN

THE 4WHEEL/AWD VEHICLES WILL SELF ENGAGE TRANSFER CASE CAUSING EQUIPMENT MALFUNCTION OR SERIOUS BODILY INJURY DO TO POSSIBLY VEHICLES CRASH DO TO EQUIPMENT MALFUNCTION IT NEEDS TO BE ADDRESSED BY CHRYSLER BUT THE REFUSE TO MY OPTION THERE FOR WOULD CAUSE A MASSIVE RECALL IN NUMEROUS YEARS THAT WOULD CAUSE THE COMPANY A LARGE FINANCIAL BACK SET THIS ISSUE NEEDS TO BE ADDRESSED BEFORE IT TAKES LIVES OF IT HASN'T ALREADY SEARCH THE WEB FOR THIS ISSUE THERE'S NUMEROUS SITES WITH FORUMS REGARDING THIS EXACT ISSUE NUMEROUS VEHICLES

NHTSA complaint #11179809 — an unverified report by a vehicle owner.

POWER TRAIN

TRUCK SWITCHES TO 4WD ON ITS OWN AND DOES NOT ALLOW ME TO SWITCH BACK TO REGULAR AWD. THE "SERVICE 4WD" LIGHT COMES ON. MECHANICS HAVE INDICATED THE TRANSFER CASE SHIFT MOTOR MAY NEED TO BE REPLACED; BUT, NONE ARE AVAILABLE. ALSO, THERE IS NO GUARANTEE THAT WOULD FIX THE DANGEROUS PROBLEM OF SWITCHING TO 4WD.

NHTSA complaint #11153483 — an unverified report by a vehicle owner.

POWER TRAIN

THE VEHICLE RANDOMLY SWITCHES FROM AWD TO 4WD LOCK, DOES NOT SEEM TO BE ANY ONE THING THAT CAUSES IT. ALSO HAVE LOOKED UP HUNDREDS OF OTHER REPORTS ON THIS FROM OTHER PEOPLE. EVERYONE SAYS THAT DODGE DEALERS CLAIM THEY HAVE NEVER HEARD THIS BEFORE. [XXX]. DODGE IS TRYING NOT TO HAVE TO DO A RECALL. THAT IS OBVIOUS. SHAME ON DODGE. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #11110391 — an unverified report by a vehicle owner.

POWER TRAIN

THE TRANSFER CASE WILL MAKE NOISE WHEN UNLOCKING THE DOORS, IT WILL ALSO ENGAGE AND CHANGE THE AWD BY ITSELF TO 4LOCK WHEN DRIVING ON THE ROAD. IT CAN CAUSE SERIOUSE HARD OR ACCIDENT. THE AIRBAGS ON BOTH DRIVER AND PASSENGER SIDE LIGHT WILL ENGAGE AND CAN CAUSE SERIOUSE HARM. THE FUEL PUMP SEEMS LIKE IT HAS AN AIR BUBBLE INSIDE AND SHOOTS OUT GASOLINE AND ALSO CAN CAUSE SERIOUSE HARM. ALL OF THESE PROBLEMS OCCURS WHEN THE VEHICLE IS IN MOTION AND STATIONARY. PLEASE FIX!!! RECALL!!! YOU HAVE TO HEAR THE NOISE AND DRIVE WHEN IT HAPPENS.

NHTSA complaint #11088986 — an unverified report by a vehicle owner.

POWER TRAIN

DODGE DURANGO LIMITED 4X4 ENGAGES 4 WHEEL DRIVE RANDOMLY ON THE FREEWAY AT HIGH SPEEDS, WITHOUT BEING TOLD TO. THIS IS A HUGE SAFETY ISSUES AND I SEE MANY PEOPLE COMPLAIN ABOUT IT ONLINE.

NHTSA complaint #11046579 — an unverified report by a vehicle owner.

POWER TRAIN

I HAVE AN AWD VEHICLE. THIS VEHICLE HAS A KNOB THAT YOU CAN SWITCH TO GO TO 4 LOCK. MY TRUCK HAS BEEN SHIFTING INTO THIS MODE ALL BY ITSELF. THIS IS VERY DANGEROUS AS WHEN IT DOES THE VEHICLE KIND OF LOCKS UP AND BECOMES VERY DIFFICULT/IMPOSSIBLE TO MOVE. I HAVE 4 CHILDREN AND THIS IS OUR MAIN VEHICLE THAT WE USE. THIS IS RIDICULOUS. WHEN RESEARCHING THIS ISSUE, THERE ARE A TON OF COMPLAINTS FOR THE SAME THING. DODGE NEEDS TO TAKE RESPONSIBILITY AND FIX THIS ISSUE BEFORE SOMEONE GETS HURT. THIS HAS HAPPENED TO ME ON MORE THAN ONE OCCASION. HAS HAPPENED AT HIGH SPEED, LOW SPEED, AND STATIONARY.

NHTSA complaint #10939748 — an unverified report by a vehicle owner.

POWER TRAIN

WHILE DRIVING, THE 4WD ENGAGES ON ITS OWN AND WILL NOT GET OUT OF POSITION. IT IS STUCK IN 4WD. "SVC 4WD" LIGHT ON THE DASH APPEARS. TRIED DOING A BATTERY RESET AND THE PROBLEM PERSISTS.

NHTSA complaint #10937451 — an unverified report by a vehicle owner.

POWER TRAIN

TRUCK SVC 4WD LIGHT ON. TRUCK GOES INTO 4LO BY ITSELF WHILE I'M DRIVING. LATER WHEN I WENT OUT IN TRUCK SVC.4WD IS OFF I GET TO STOPLIGHT & I FEEL A LOUD THUD LIKE I'M BEING HIT FROM BEHIND. NOW SVC.4WD LIGHT STAYS ON & CAR IS HARD TO TURN.

NHTSA complaint #10930314 — an unverified report by a vehicle owner.

POWER TRAIN

AWD TRUCK PUTS ITSELF INTO 4 WD FOR NO REASON. CAUSES VEHICLE TO BECOME HARD TO DRIVE. THIS IS REDICULOUS. TONS OF COMPLAINTS OF THE EXACT SAME ISSUE ON FORUMS. DOES IT WHILE JUST IDLING IN PARK AND WHILE DRIVING DOWN THE ROAD. VERY DANGEROUS, ESPECIALLY WITH MY 4 KIDS IN THE CAR!

NHTSA complaint #10908214 — an unverified report by a vehicle owner.

POWER TRAIN

THE TRANSFER CASE WILL SHIFT INTO 4 WHEEL DRIVE ON IT'S ON. THIS HAPPENS WHEN THE VEHICLE IS OFF AND I UNLOCK OR LOCK THE DOORS WITH THE KEY FOB. IT ALSO HAPPENS WHEN THE VEHICLE IS IN MOTION. IT IS UNPREDICTABLE AND HAPPENS VERY FREQUENTLY. THIS IS NOT VERY SAFE AND CAN ALSO CAUSE VERY EXPENSIVE DAMAGE TO THE POWERTRAIN.

NHTSA complaint #10904970 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2004 DODGE DURANGO. WHILE DRIVING AT APPROXIMATELY 70 MPH, THE FOUR WHEEL DRIVE ENGAGED INDEPENDENTLY. THE VEHICLE SHOOK VIOLENTLY, VEERED TO THE RIGHT, AND THE SERVICE FOUR WHEEL DRIVE WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THERE WAS AN OPEN SHORT IN THE ELECTRICAL SYSTEM THAT NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000. THE VIN WAS UNAVAILABLE.

NHTSA complaint #10885644 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2004 DODGE DURANGO. WHILE DRIVING VARIOUS SPEEDS WHILE IN TWO WHEEL DRIVE, THE TRANSMISSION WOULD SUDDENLY SWITCH TO NEUTRAL, THE VEHICLE WOULD STOP, AND THE FOUR WHEEL DRIVE SENSOR LIGHT WOULD ILLUMINATE. AFTER SHUTTING OFF AND RESTARTING THE VEHICLE, THE TRANSMISSION WOULD MAKE A GRINDING NOISE WHILE IN FOUR WHEEL DRIVE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSFER CASE SHIFT MOTOR WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 150,000.

NHTSA complaint #10851216 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2004 DODGE DURANGO. THE CONTACT STATED THAT THE 4-WHEEL DRIVE ENGAGED INDEPENDENTLY WITHOUT WARNING. AS A RESULT OF THE FAILURE, THE WHEELS LOCKED AND IT WAS EXTREMELY HARD TO MAKE ANY TURNS. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 115,000.

NHTSA complaint #10837866 — an unverified report by a vehicle owner.

POWER TRAIN

DURANGO DECIDES TO GO INTO 4 WH DRIVE AT RANDOM WITHOUT INPUT FROM THE DRIVER TO DO SO. STEERING BECOMES HEAVY ... OFTEN THIS OCCURS WHEN THE DRIVER IS MAKING A TURN AT SLOW SPEEDS. DEPENDING OF THE STRENGTH OF THE DRIVER THIS CAN EASILY CAUSE A CRASH. THE MOTOR RPMS ARE PULLED DOWN AS THE DRIVER MAKES THE TURN AND CAN CAUSE THE CAR TO STALL...MAKING THE STEERING VERY HEAVY. THIS IS A KNOWN PROBLEM WITH THE DURANGO... FAULTY TRANSFER CASE MOTOR. THIS SHOULD BE REPLACED BY CHRYSLER.

NHTSA complaint #10807186 — an unverified report by a vehicle owner.

POWER TRAIN

MY 2004 DODGE DURANGO 5.7L AWD IS ENGAGING IN FOUR WHEEL DRIVE AT HIGH SPEEDS ON ITS OWN ON THE INTERSTATE. IT MADE A VERY LOUD GRINDING AND CLUNKING NOISE, THE SERVICE 4WD LIGHT WILL COME ON AND THEN TURN OFF AND THEN THE 4WD LO LIGHT WILL COME ON AND TURN OFF. I WAS FORCED TO PULL OFF THE ROAD AND IT FELT LIKE THE CAR WAS STUCK IN FOUR WHEEL DRIVE AND WILL NOT COME OUT. I TRIED TO PUT IT IN GEAR WHILE JUST SITTING STILL AND IT JUST MAKES THAT GRINDING NOISE. I HAD TO HAVE THE CAR TOWED AS I AM AFRAID THAT DRIVING IT WOULD CAUSE MYSELF OR OTHERS PHYSICAL HARM. PLEASE CONSIDER LOOKING INTO THIS MATTER BECAUSE AS I AM READING ON SEVERAL DODGE FORUMS THIS IS A COMMON PROBLEM AND CAN BE VERY SERIOUS TO DRIVERS AND OTHERS. I HAVE READ THAT THERE ARE SEVERAL PROBLEMS WITH THE TRANSFER CASE IN 2004 AND 2005 DODGE DURANGO. A BIG COMPANY SUCH AS DODGE SHOULD INVESTIGATE THE NEED FOR A POSSIBLE RECALL SINCE THESE PROBLEMS ARE BEING ADDRESSED ON DODGE FORUMS. AS FAR AS GETTING IT FIXED OR TRYING TO FIGURE OUT HOW TO GET IT FIXED IS THE NEXT PROBLEM.

NHTSA complaint #10786184 — an unverified report by a vehicle owner.

POWER TRAIN

SERVICE 4WD LITE CAME ON, TRUCK STARTED JERKING AND BINDING ON TURNS. CYCLED SWITCH THRU AWD, 4LOCK AND 4 LO, SEEMED TO BE OK FOR AWHILE THEN LOCKED IN 4LOCK AND STAYED THERE UNTIL DRIVEN A MILE DOWN A BUMPY DIRT ROAD. REPAIR SHOP SERVICED TRANSFER CASE BUT NOW ITS STUCK IN 4LOCK, THEY SUSPECT SHIFT MOTOR BUT NONE ARE AVAILABLE. INTERNET COMPLAINTS SEEM TO POINT TO ELECTRICAL ISSUE, TEMPORARY FIX IS TO UNPLUG SHIFT MOTOR IF YOU CAN GET IT INTO AWD BUT DODGE NEEDS TO COME UP WITH A PERMANENT FIX FOR THIS.

NHTSA complaint #10764248 — an unverified report by a vehicle owner.

POWER TRAIN

MY 2004 DODGE DURANGO LIMITED 4X4 5.7 HEMI HAS EXPERIENCED THE SAME TRANSFER CASE ISSUES THAT MANY OTHER OWNERS HAVE EXPERIENCED. THE VEHICLE WILL RANDOMLY TRY TO SHIFT ITSELF INTO 4 WHEEL DRIVE LOW WITHOUT THE DRIVER CHANGING THE SWITCH FROM THE AWD TO THE 4LO POSITION. FORTUNATELY WE WERE MOVING SLOWLY WHEN IT OCCURRED BUT THIS COULD BE VERY DANGEROUS AT HIGHER SPEEDS AS ALL FOUR WHEELS LOCK UP AND THE VEHICLE CANNOT BE TURNED. AFTER READING ALL OF THE COMPLAINTS ABOUT THIS ISSUE I DECIDED NOT TO ATTEMPT TO HAVE IT REPAIRED AS MANY OWNERS HAVE STATED THAT DEALERS HAVE REPLACED VERY EXPENSIVE PARTS SUCH AS THE TRANSFER CASE, TRANSFER CASE SHIFT MOTOR, AND TRANSMISSION CONTROL COMPUTER WITHOUT THE PROBLEM BEING RESOLVED. I ELECTED TO DISCONNECT THE TRANSFER CASE WIRING HARNESS AS I WAS 1000 MILES AWAY FROM HOME ON VACATION WITH MY FAMILY AT THE TIME AND NEEDED TO DRIVE HOME SAFELY. IT HAS BEEN DISCONNECTED EVER SINCE THEN AND I AM AFRAID TO RECONNECT IT AS I AM AFRAID THAT I WILL LOSE CONTROL OF THE VEHICLE IF IT OCCURS AT A HIGHER RATE OF SPEED. IF I COULD BE SURE THAT THE DEALER COULD DEFINITELY CORRECT THE PROBLEM I WOULD CONSIDER PAYING TO HAVE IT FIXED, BUT IT IS EVIDENT THAT DODGE/CHRYSLER IS REALLY NOT SURE WHAT THE CAUSE OF THE PROBLEM REALLY IS AND IS JUST GUESSING AT THE PROPER REPAIRS. I BELIEVE THAT THIS SHOULD BE CONSIDERED FOR RECALL AS IT POSES A SERIOUS SAFETY CONCERN. I AM NOT SURE IF ANY SERIOUS ACCIDENTS OR DEATHS HAVE RESULTED FROM THIS ISSUE BUT IT SHOULD BE ADDRESSED BEFORE A FATALITY OR SERIOUS INJURY OCCURS.

NHTSA complaint #10734019 — an unverified report by a vehicle owner.

POWER TRAIN

AS I WAS TURNING FROM THE LIGHT AND PRECEDED TO ACCELERATE NOT EVEN DOING 5-10 MPH, I HEARD A SOUND, WHICH I THOUGHT WAS A BLOWN TIRE. I TURNED OFF THE TRUCK TO SEE IF I HAD A FLAT TIRE. NONE OF THE TIRES WHERE FLAT. SO I CALLED MY HUSBAND, HE LOOKED AT IT, THINKING IT WAS THE THROTTLE BODY, DUE TO THE LIGHT THAT FLASHED ON THE DASH. SO HE BOUGHT A NEW THROTTLE, THAT AS WELL AS NEW SPARK PLUGS, AND STILL NOTHING. IT SEEMS IT WANTS TO START, BUT ISN'T STARTING. SO IF THIS IS THE HYDOLOCK THAT IS CAUSING WATER TO FLOW INTO THE ENGINE, YOU ALL NEED TO PAY FOR THIS. I HAVE HEARD THAT YOU ALL KNOW ABOUT THIS ISSUE AND HAS DONE NOTHING ABOUT IT. LAWSUIT? I HOPE NOT. I JUST WANT MY TRUCK FIXED, BECAUSE I REALLY LIKE. PLEASE GET IN TOUCH WITH ME AS SOON AS POSSIBLE.

NHTSA complaint #10706571 — an unverified report by a vehicle owner.

POWER TRAIN

I WAS ENTERING INTERSTATE 25 NORTH FROM DENVER COLORADO'S 19TH STREET WHEN I HEARD A BANG AND MY 04 DURANGO BEGAN TO SHAKE VIOLENTLY. I BELIEVED IT WAS A TIRE THAT POPPED EVEN THOUGH I HAVE NEW ONES AND SO I CONTINUED DOWN THE RAMP TO A SAFE PLACE WHERE I PULLED OVER AND STOPPED. THAT'S WHEN I NOTICED THE VEHICLE WAS STILL SHAKING AND I THEN BELIEVED IT TO BE A SERPENTINE BELT UNTIL I TURNED THE VEHICLE OFF. I OPENED THE HOOD AND FOUND THE BELT INTACT. I THEN LOOKED UNDER THE VEHICLE AND COULD SEE ENGINE OIL DRIPPING OFF THE BACK OF THE ENGINE BLOCK & ONTO THE GROUND FROM SOME UNKNOWN LOCATION OF THE MOTOR. I ATTEMPTED TO PULL THE DIPSTICK OUT OF THE ENGINE BUT WAS UNABLE TO BECAUSE IT WAS STUCK UNTIL I TRIED CRANKING THE MOTOR ONCE AGAIN WHICH ALLOWED ME TO THEN PULL THE DIPSTICK OUT, BUT I WAS NEVER ABLE TO GET IT BACK IN. I HAD THE VEHICLE TOWED TO MY HOUSE AND THEN EVENTUALLY TO A DEALERSHIP AFTER THE MOTOR WAS ATTEMPTED TO BE STARTED AGAIN. FLAME SHOT OUT FROM UNDERNEATH THE HOOD ALONG WITH SMOKE AND A LOT OF WHITE SMOKE FROM THE TAILPIPE. THE ENGINE IS BLOWN IT WOULD HAVE TO BE REPLACED AND I HAD 12 PAYMENTS LEFT FOR ABOUT $5000. I WAS IN A NEGATIVE EQUITY SITUATION WITH THIS VEHICLE NOW & I DIDN'T HAVE WARRANTIES OR ANY ABILITY TO GET HELP FROM CHRYSLER OR DODGE. THERE HAVE BEEN ALMOST A THOUSAND OTHER PEOPLE TO REGISTER COMPLAINTS FOR THE SAME PROBLEM. THE ENGINE HYDROLOCKED BECAUSE WATER LEAKS THROUGH THE COWLING BETWEEN THE WINDSHIELD AND THE HOOD AND DRAINS ALL OVER THE ENTIRE ENGINE. IT HAPPENS AT APPROXIMATELY A HUNDRED TWENTY THOUSAND MILES, ALLOWING WATER TO GET INSIDE THE MOTOR EVENTUALLY. I TOOK CARE OF THIS VEHICLE BETTER THAN ANY OTHER VEHICLE I'D EVER OWNED.

NHTSA complaint #10692857 — an unverified report by a vehicle owner.

POWER TRAIN

WAS SLOWING DOWN TO MAKE A RIGHT TURN AND THE CAR SHUDDERED AND CAME TO A HALT. THEN WOULD NOT MOVE . LOOKING UNDER THE CAR FOUND THAT THE DRIVE SHAFT HAD FALLEN OUT OF THE REAR AXLE AREA. HAD IT TOWED TO SHOP.

NHTSA complaint #10692274 — an unverified report by a vehicle owner.

POWER TRAIN

STARTED CAR FOR FIRST TIME AFTER BAD RAINSTORM OVER WEEKEND. HEARD VERY LOUD CLANGING NOISE. HOLE IN OIL PAN, OIL LEAKED OUT EVERYWHERE. AFTER TAKING APART THE MOTOR, SERVICE CENTER DISCOVERED A ROD SHAFT HAD SHEARED IN HALF AND SHOT THROUGH THE ENGINE BLOCK AND OIL PAN. DISCOVERED IT WAS CAUSED BY WATER GETTING INTO ENGINE THROUGH SPARK PLUGS. BECAUSE OF THIS, THE WARRANTY COMPANY WON'T COVER AN ENGINE REPLACEMENT. WE HAVE TAKEN IN THIS VEHICLE TO SAME SERVICE STATION BEFORE OVER THE TWO YEARS WE HAVE OWNED IT BECAUSE IT WOULD STALL WHILE DRIVING IN BAD RAINSTORM. COULD NEVER FIND A PROBLEM. READ A LOT OF ARTICLES ONLINE ATTRIBUTING ALL OF THIS TO A DESIGN FLAW IN THE HOOD OF THIS VEHICLE. I KNOW WE ARE NOT THE ONLY OWNERS OF A 2004 DODGE DURANGO WHO HAVE EXPERIENCED THIS. SOMETHING NEEDS TO BE DONE TO RESOLVE THE DESIGN FLAW AND COMPENSATE US FOR HAVING TO REPLACE AN ENGINE THAT, APART FROM BEING IN A POORLY DESIGNED CAR, IS OTHERWISE IN GREAT CONDITION.

NHTSA complaint #10680682 — an unverified report by a vehicle owner.

POWER TRAIN

NOTICED THE SVC 4WD LIGHT CAME ON THE DASH BOARD AND THEN THE VEHICLE'S REAR WHEELS LOCKED WHEN MAKING A TIGHT TURN INTO A PARKING SPACE. THE VEHICLE STOPPED AND WAS UNABLE TO MOVE AS IF BRAKE HAD BEEN APPLIED VERY HARD. UNPLUGGED THE BATTERY FOR ABOUT A MINUTE TO ALLOW THE SYSTEM TO RESET. THE SVC 4WD LIGHT DOESN'T COME ON. HOWEVER, THE VEHICLE STILL LOCKS ITS REAR WHEELS WHEN MAKING A TIGHT TURN INTO A PARKING SPACE.

NHTSA complaint #10671898 — an unverified report by a vehicle owner.

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

2004 DODGE DURANGO, 5.7 HEMI. THE TRANSFER CASE MOTOR FAILING AND THE SERVICE 4WD LIGHT STARTING OFF BLINKING HERE AND THERE. THEN WENT STEADY AND LOCKED IN 4WD.

NHTSA complaint #10652713 — an unverified report by a vehicle owner.