Owners have filed 541 complaints
about the 2005 Dodge RAM 2500 with NHTSA between 2005 and 2026.
The largest single group is the steering.
Across this model's run it ranks 4 of 20 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 65
Against the median year of the Dodge RAM 2500. 50 means typical for this
model; 100 means roughly double.
Severity — 88
17% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 33
19% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Automatic Transmission
3039.0%
Front
1924.7%
Body
810.4%
TIE ROD Assembly
56.5%
Gear Position Indication (Prndl)
56.5%
Engine
45.2%
Upper Ball Joint
33.9%
Column Shift
33.9%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
20.5%
1,000 – 9,999 miles
236.0%
10,000 – 24,999 miles
277.1%
25,000 – 49,999 miles
5815.2%
50,000 – 74,999 miles
6316.5%
75,000 – 99,999 miles
5313.9%
100,000 – 149,999 miles
8221.5%
150,000+ miles
7419.4%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Apr 2005peak 15Jun 2026
NHTSA investigations into the 2005 Dodge RAM 2500
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.C...
EA15001Opened 24 Feb 2015Still openAIR BAGS
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
AQ14003Opened 20 Oct 2014Closed 16 May 2016STEERING:LINKAGES:TIE ROD ASSEMBLY
Chrysler's execution of 13V-528 & 529
RMD opened this audit query (AQ) investigation in order to better understand and evaluate Chrysler's process(es) for timely and efficient execution of its safety recall campaigns, including its oversight and management of its parts division Mopar.Prior to opening this investigation, RMD had raised concerns with the company related to its execution of two safety recalls, 13V-528 and 13V-529, both of which involved safety defects that could cause the involved vehicles, FCA?s heavier Dodge Ram trucks, to lose steering control suddenly and without warning.Specifically, RMD inquired about the avail...
PE14016Opened 11 Jun 2014Closed 2 Mar 2015AIR BAGS
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
PE14013Opened 19 May 2014Closed 23 Dec 2014ELECTRICAL SYSTEM:IGNITION:SWITCH
Clutch Interlock Switch Malfunction
On December 16, 2104, Chrysler Group LLC submitted a Safety Recall Report to NHTSA describing a defect in the clutch ignition interlock switches in approximately 66,819 model year (MY) 2006 through early-2007 Dodge Ram Trucks, Dodge Dakota, and Mitsubishi Raider vehicles equipped with manual transmissions and built between July 1, 2005 and July 31, 2006 (NHTSA Recall No. 14V-795, Chrysler Recall No. P80), including 38,969 MY 2006 Dodge Ram 2500 and 3500 vehicles that are part of the subject vehicle population for PE14-013.Chrysler's Safety Report states that:1) the clutch ignition interlock sw...
EA05018Opened 2 Nov 2005Closed 29 Aug 2007POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
ENGINE STALL
ANALYSIS OF THE COMPLAINT, FIELD REPORT AND WARRANTY DATA SHOWS THAT THE MAJORITY OF STALLING INCIDENTS IN THE SUBJECT VEHICLES APPEAR TO BE RELATED TO THE ENGINE CALIBRATION CONCERNS THAT DAIMLERCHRYSLER ADDRESSED WITH SERVICE BULLETINS RELEASING REVISED PCM SOFTWARE.ANALYSIS OF THE COMPLAINTS AND ODI'S SURVEY OF OWNERS OF VEHICLES THAT RECEIVED ENGINE MANAGEMENT SOFTWARE UPDATES UNDER TSB #18-013-05 SHOW THAT THESE STALLING INCIDENTS HAVE THE FOLLOWING CHARACTERISTICS: - THEY OCCUR AT LOW SPEEDS, OFTEN DURING PARKING LOT ORDRIVEWAY MANEUVERS; - THEY OCCUR DURING DECELERATIONS, SUCH AS BRAKIN...
PE05027Opened 16 May 2005Closed 3 Nov 2005POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
ENGINE STALL
ON MAY 16, 2005,ODI OPENED PRELIMINARY EVALUATION PE05-027 TO INVESTIGATE COMPLAINTS OF ENGINE STALLING IN MODEL YEAR 2004-05 DODGE DURANGO SUVS AND RAM 1500 SERIES PICKUPS EQUIPPED WITH THE 5.7L V8 ENGINE.INFORMATION PROVIDED BY DAIMLERCHRYSLER DURING PE05-027 INDICATED THAT A LARGE PERCENTAGE OF THE COMPLAINTS ARE RELATED TO AN IDLE UNDERSHOOT CONDITION THAT MAY CAUSE THE ENGINE TO STALL DURING TURNING MANEUVERS.IN FEBRUARY 2005, DAIMLERCHRYSLER REVISED THE POWERTRAIN CONTROL MODULE SOFTWARE IN PRODUCTION VEHICLES AND ISSUED A TECHNICAL SERVICE BULLETIN (TSB 18-013-05) RELEASING THE NEW SOFT...
EA04025Opened 26 Aug 2004Closed 22 Dec 2005POWER TRAIN:AUTOMATIC TRANSMISSION
FALSE PARK
THE SUBJECT VEHICLES ARE HEAVY DUTY PICKUP TRUCKS WITH DIESEL ENGINES AND AUTOMATIC TRANSMISSIONS COMMONLY USED FOR COMMERCIAL AND WORK PURPOSES.A COLUMN MOUNTED SHIFT LEVER IS USED FOR GEAR SELECTION AND AN ELECTRONIC PRNDL ON THE INSTRUMENT PANEL PROVIDES GEAR POSITION INFORMATION TO THE DRIVER.THE SUBJECT VEHICLES ARE ALSO EQUIPPED WITH A BRAKE-TRANSMISSION SHIFT INTERLOCK THAT PREVENTS THE SHIFT LEVER FROM BEING MOVED FROM THE PARK POSITION (WHEN THE ENGINE IS ON) UNLESS THE BRAKE PEDAL IS DEPRESSED AND AN IGNITION-SHIFT INTERLOCK THAT PREVENTS KEY REMOVAL UNLESS THE TRANSMISSION IS IN THE...
Recalls on the 2005 Dodge RAM 2500
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
16V352000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mits
Risk: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
15V313000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
14V770000
AIR BAGS
Chrysler Group LLC (Chrysler) is recalling certain model year 2004-2005 Dodge Ram 1500, 2500, and 3500, 2004-2005 Dodge Durango, 2005 Dodge Dakota, 2005 Dodge Magnum and 2005 Chrysler 300, 300C and 300 SRT8 vehicles originally sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Alabama, Florida, Georgia, Hawaii, Louisiana, Mississippi, Texas, Puerto Rico, U.S. Virgin Islands, Saipan, Guam, and American Samoa are addressed by this recall. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the passengers frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
13V528000
STEERING:LINKAGES:TIE ROD ASSEMBLY
Chrysler Group LLC (Chrysler) is recalling certain model year 2003-2008 Dodge RAM 2500 4x4 and 3500 4x4, model year 2007-2008 Dodge RAM 3500 4x2 Cab Chassis and model year 2006-2008 Dodge RAM 1500 Mega Cab 4x4 trucks manufactured February 12, 2002, through February 13, 2008. The left tie rod assembly may break.
Risk: A failure of the tie rod assembly may result in a loss of steering control, increasing the risk of a crash.
11V350000
STEERING:LINKAGES:TIE ROD ASSEMBLY
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008-2011 DODGE RAM 2500/3500 4X4, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH MARCH 28, 2011; MODEL YEAR 2008-2011 DODGE RAM 3500 CAB CHASSIS 4X2, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH MARCH 28, 2011; AND MODEL YEAR 2008 DODGE RAM 1500 MEGA CAB 4X4, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH AUGUST 15, 2008, BECAUSE THE LEFT TIE ROD BALL STUD MAY FRACTURE. THIS CONDITION TENDS TO OCCUR DURING LOW SPEED PARKING LOT TYPE MANEUVERS WHEN THE CUSTOMER IS MAKING A TIGHT TURN. ADDITIONALLY, MODEL YEAR 2003-2008 DODGE RAM 2500/3500 VEHICLES MAY HAVE RECEIVED THE AFFECTED TIE ROD ASSEMBLY AS A REPLACEMENT PART DURING NORMAL SERVICE.
Risk: THIS CONDITION COULD RESULT IN THE POTENTIAL LOSS OF DIRECTIONAL STABILITY IN THE LEFT HAND FRONT WHEEL, INCREASING THE RISK OF A CRASH.
10E013000
STEERING:GEAR BOX:SHAFT PITMAN
FABTECH IS RECALLING CERTAIN AFTERMARKET REPLACEMENT PITMAN ARMS, P/NOS. FTS93001 AND FT44039, INSTALLED FOR USE ON CERTAIN 2003 THROUGH 2008 DODGE 2500 4WD, 3500 4WD, AND 1500 4WD MEGA CAB VEHICLES. THE PITMAN ARM CAN FRACTURE AND BREAK AWAY FROM THE STEERING BOX CAUSING TOTAL LOSS OF STEERING CONTROL.
Risk: STEERING LOSS COULD RESULT IN A VEHICLE CRASH POSSIBLY RESULTING IN PROPERTY DAMAGE, INJURY OR DEATH.
07E104000
VISIBILITY:GLASS, SIDE/REAR
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
Risk: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
07E009000
SUSPENSION
CERTAIN LKI ENTERPRISES, INC., BRAND NAME SUPERLIFT SUSPENSION, PITMAN ARMS SOLD AS REPLACEMENT EQUIPMENT FOR 2003-2007 DODGE RAM 2500 AND 3500 4X4 LIGHT TRUCKS. DUE TO INADEQUATE HEAT TREATMENT DURING PRODUCTION, THE AFFECTED PITMAN ARMS MAY DEVELOP CRACKS IN THE UPPER SPLINED ATTACHMENT ATTACHMENT TO THE STEERING OUTPUT SHAFT. MOVEMENT BETWEEN THE PITMAN ARM AND THE OUTPUT SHAFT MAY DEFORM SPLINES, RESULTING IN PREMATURE WEAR AND FATIGUE FAILURE OF THE AFFECTED PITMAN ARM.
Risk: PITMAN ARM WEAR OR FAILURE MAY LEAD TO LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Reports where the owner recorded a crash, a fire, an injury or a death.
Creswell, ORCrash
STEERING
STEERING WENT OUT AND TRUCK ROLLED. VERIFIED PER MECHANIC FAILURE ON RECALLED PART/S
NHTSA complaint #11573673 — an unverified report by a vehicle owner.
at 203,300 milesKooskia, IDCrash
POWER TRAIN
THE TRUCK WITH ATTACHED TRAILER WAS PARKED ON AN INCLINED DRIVEWAY. THE TRUCK WAS PLACED IN PARK AND THE KEY WAS REMOVED FROM THE IGNITION. I PROCEEDED TO LOAD A COMPACT TRACTOR APPROXIMATELY 2500 LBS. THE TRUCK STARTED TO ROLL DOWN THE HILL AND CRASHED THRU A FENCE DOING EXTENSIVE DAMAGE TO THE TRUCK. I DID NOT TRY TO START THE TRUCK AND WAITED FOR MECHANIC TO ASSESS ANY MECHANICAL DAMAGE. THE MECHANIC CAME TO MY PLACE AND WHEN HE GOT IN THE TRUCK THE TRANSMISSION INDICATED THAT IT WAS STILL IN PARK. DODGE TOLD ME THAT THERE WAS NO RECALL ON THIS TYPE VEHICLE WITH THE TRANSMISSION NOT HOLDING. THE REPRESENTATIVE TOLD ME THAT THERE HAD BEEN SIMILAR PROBLEMS WITH GAS POWERED ENGINES BUT NOT THE DIESEL. I WOULD LIKE TO KNOW IF THIS CAN BE EVALUATED FOR RECALL. NO ONE GOT HURT IN THIS INSTANCE BUT CAUSED EXTENSIVE DAMAGE TO THE TRUCK MECHANICALLY AND COSMETICALLY.
NHTSA complaint #11355102 — an unverified report by a vehicle owner.
at 79,000 milesBoyne City, MIFire
ENGINE
TRUCK BURST INTO FLAMES JUST SITTING IN THE DRIVEWAY. TRUCK HAD BEEN PARKED AND NOT STARTED IN 5 DAYS.
NHTSA complaint #11321027 — an unverified report by a vehicle owner.
at 213,548 milesBenton City, WACrash1 injured
SEAT BELTS
TAKARA INFLATORS APRIL 28TH 2019 WE TOOK OUR TRUCK TO THE DODGE DEALERSHIP TO HAVE THE RECALLS FIXED AS THEY REQUESTED. MAINLY THE AIRBAGS AND THEY DID A 28 POINT INSPECTION. JULY 1ST 2019 SOMEONE PULLED OUT IN FRONT OF MY HUSBAND AND THEY WERE INVOLVED IN A BAD ACCIDENT. THE AIRBAGS NEVER WENT OFF. MY HUSBAND HIT THE STEERING WHEEL SO HARD THERE'S A BRUISE AND MARK ON HIS CHEST AND THE SHAPE OF THE STEERING WHEEL. IT ALSO MESSED UP THE STEERING COLUMN AND THE GEAR SELECTOR. THE TRUCK IS TOTALED THE FRAME IS BENT THE SUSPENSIONS RIPPED OFF BUT WE CAN'T FIGURE OUT WHY THE AIRBAGS DIDN'T GO OFF. INSURANCE IS BEING A PAIN. DODGE SAID THEY'D SEND OUT AN INVESTIGATOR SO FAR NO ONE SHOWED UP. SOMETHING SHOULD BE DONE ABOUT THIS.
NHTSA complaint #11231156 — an unverified report by a vehicle owner.
at 213,548 milesBenton City, WACrash1 injured
AIR BAGS
TAKARA INFLATORS APRIL 28TH 2019 WE TOOK OUR TRUCK TO THE DODGE DEALERSHIP TO HAVE THE RECALLS FIXED AS THEY REQUESTED. MAINLY THE AIRBAGS AND THEY DID A 28 POINT INSPECTION. JULY 1ST 2019 SOMEONE PULLED OUT IN FRONT OF MY HUSBAND AND THEY WERE INVOLVED IN A BAD ACCIDENT. THE AIRBAGS NEVER WENT OFF. MY HUSBAND HIT THE STEERING WHEEL SO HARD THERE'S A BRUISE AND MARK ON HIS CHEST AND THE SHAPE OF THE STEERING WHEEL. IT ALSO MESSED UP THE STEERING COLUMN AND THE GEAR SELECTOR. THE TRUCK IS TOTALED THE FRAME IS BENT THE SUSPENSIONS RIPPED OFF BUT WE CAN'T FIGURE OUT WHY THE AIRBAGS DIDN'T GO OFF. INSURANCE IS BEING A PAIN. DODGE SAID THEY'D SEND OUT AN INVESTIGATOR SO FAR NO ONE SHOWED UP. SOMETHING SHOULD BE DONE ABOUT THIS.
NHTSA complaint #11231156 — an unverified report by a vehicle owner.
at 308,233 milesBuhl, IDCrash
WHEELS
DODGE DEATH WOBBLE HAS HAPPENED NUMEROUS TIMES THE LAST TIME IT BROKE THE TIE ROD END AND THREW ME OFF THE ROAD
NHTSA complaint #11184457 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Little Falls, NY
AIR BAGS
The dealer has told me for years that the air bad can not be found...there out of stock
NHTSA complaint #11745872 — an unverified report by a vehicle owner.
at 88,000 milesClarence Center, NY
AIR BAGS
The contact owns a 2005 Dodge Ram 2500. The contact stated that while driving at an undisclosed speed, the steering wheel wobbled, and the air bag warning light illuminated. The vehicle was taken to the dealer; however, the contact was informed that parts were not available to repair the vehicle. The contact stated that the vehicle remained with the dealer for 45 days; however, the vehicle was not repaired. An alternate dealer was contacted. The contact was informed that the parts were ordered to repair the vehicle and would be notified when the parts were delivered. The dealer had not notified the contact if the parts were delivered. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notifications of NHTSA Campaign Numbers: 13V528000 (Steering), 16V352000 (Air Bags), and 15V313000 (Air Bags); however, the vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact other local dealers for possible assistance. The failure mileage was approximately 88,000.
NHTSA complaint #11718754 — an unverified report by a vehicle owner.
at 88,000 milesClarence Center, NY
STEERING
The contact owns a 2005 Dodge Ram 2500. The contact stated that while driving at an undisclosed speed, the steering wheel wobbled, and the air bag warning light illuminated. The vehicle was taken to the dealer; however, the contact was informed that parts were not available to repair the vehicle. The contact stated that the vehicle remained with the dealer for 45 days; however, the vehicle was not repaired. An alternate dealer was contacted. The contact was informed that the parts were ordered to repair the vehicle and would be notified when the parts were delivered. The dealer had not notified the contact if the parts were delivered. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notifications of NHTSA Campaign Numbers: 13V528000 (Steering), 16V352000 (Air Bags), and 15V313000 (Air Bags); however, the vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact other local dealers for possible assistance. The failure mileage was approximately 88,000.
NHTSA complaint #11718754 — an unverified report by a vehicle owner.
Orange Park, FL
STRUCTURE:BODY
White paint job from the factory has totaly failed down to the bare metal in some places and has cracks all over the truck. I understand that their was a formula change in the paint for a couple years. My truck is one of them . The paint job is totaly failed. This a factory defect. Can you help me with this issue. This was my first new truck ever and have cared for it to the best ability. The cost of a paint job is scary. Thanks
NHTSA complaint #11622875 — an unverified report by a vehicle owner.
Creswell, ORCrash
STEERING
STEERING WENT OUT AND TRUCK ROLLED. VERIFIED PER MECHANIC FAILURE ON RECALLED PART/S
NHTSA complaint #11573673 — an unverified report by a vehicle owner.
at 138,000 milesSaint Joseph, MO
STEERING
The contact owns a 2005 Dodge Ram 2500. The contact stated that on several occasions while driving approximately 70 MPH, the vehicle drove over a bump in the roadway and the steering wheel started to shake violently. Additionally, the contact stated that while the brake pedal was depressed, the vehicle started to shake violently. The contact decelerated to slower speeds to stop the vehicle from shaking. No warning lights was illuminated. As a result, the contact stated that the last failure caused the vehicle to shake off the roadway. The contact was able to drive the vehicle to safety. The vehicle was not diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 138,000.
NHTSA complaint #11543351 — an unverified report by a vehicle owner.
Lincoln, NE
STEERING
Steering is not as good as it should be. Has 83,000 miles and steering seems very loose, seems to wander from left to right, and hard to control, on Highway or city streets.
NHTSA complaint #11516215 — an unverified report by a vehicle owner.
Hollywood, FL
CHILD SEAT:SHELL:HEADREST
The contact owns a Britax car seat, Model Name: Advocate ClickTight, Manufacture Date: August 26, 2016, installed in a 2005 Dodge Ram 2500. The contact stated that a crack on the right side of the headrest had formed without incident. The manufacturer had yet to be notified of the failure. The car seat had yet to be repaired or replaced. The purchase date of was August 2017.
NHTSA complaint #11470842 — an unverified report by a vehicle owner.
at 55,000 milesBailey, CO
POWER TRAIN
The contact owns a 2005 Dodge Ram 2500. The contact stated that after starting the vehicle, the gear shifter was shifted to the selected gear, but the vehicle would not move. Additionally, the vehicle made an abnormal sound. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 55,000.
NHTSA complaint #11454555 — an unverified report by a vehicle owner.
Novinger, MO
EXTERIOR LIGHTING
The room fcm power distribution module corrodes and causes electrical problems. Headlights can go out while driving, taillights, break lights etc. There is many complaints on the web about this issue and dodge has not fixed the problem. I was driving at night and my headlights went completely out. Luckily I was able to avoid any accident and come to a controlled stop. If I had been on a curve I would have lost sight of the road. This is a well known issue among dodge trucks. This is a safety recall as it can cause an accident and death.
NHTSA complaint #11421213 — an unverified report by a vehicle owner.
Novinger, MO
ELECTRICAL SYSTEM
The room fcm power distribution module corrodes and causes electrical problems. Headlights can go out while driving, taillights, break lights etc. There is many complaints on the web about this issue and dodge has not fixed the problem. I was driving at night and my headlights went completely out. Luckily I was able to avoid any accident and come to a controlled stop. If I had been on a curve I would have lost sight of the road. This is a well known issue among dodge trucks. This is a safety recall as it can cause an accident and death.
NHTSA complaint #11421213 — an unverified report by a vehicle owner.
at 50,000 milesButner, NC
POWER TRAIN
ENGINES NEEDING CAM SHAFTS LIFTERS TIMING CHAINS THEY OVER HEAT ELECTRIC FANS NOT WORKING BATTERIES EXPLODE TRANSMISSIONS STOP SHIFTING BAD VALVE BODIES BAD ELECTRICAL PARTS THESE TRUCKS ARE DRIVEN AROUND ONE LOCATION AT 35 MPH OR LESS 24-7 AND PARKED FOR LONG TIMES AT IDLE. NO CITY OR HWY DRIVING 4 DIFFERENT TRUCKS AT DEALERSHIPS SINCE 9/16/2020 STILL NOT REPAIRED
NHTSA complaint #11394625 — an unverified report by a vehicle owner.
at 50,000 milesButner, NC
ENGINE
ENGINES NEEDING CAM SHAFTS LIFTERS TIMING CHAINS THEY OVER HEAT ELECTRIC FANS NOT WORKING BATTERIES EXPLODE TRANSMISSIONS STOP SHIFTING BAD VALVE BODIES BAD ELECTRICAL PARTS THESE TRUCKS ARE DRIVEN AROUND ONE LOCATION AT 35 MPH OR LESS 24-7 AND PARKED FOR LONG TIMES AT IDLE. NO CITY OR HWY DRIVING 4 DIFFERENT TRUCKS AT DEALERSHIPS SINCE 9/16/2020 STILL NOT REPAIRED
NHTSA complaint #11394625 — an unverified report by a vehicle owner.
at 192,000 milesElwood, IL
VISIBILITY/WIPER
THE HEATER IN THE TRUCK WILL NOT THROW OUT HEAT IN VENTS ON TOP OF DASH AND ONLY PUT HEAT OUT ON DRIVERS SIDE IN OTHER VENTS FOR FLOOR OR PANEL. SO THERE IS NO HEAT COMING OUT OF DEFROSTER VENTS. WILL NOT DEFROST FRONT WINDSHIELD. CANNOT SEE OUT OF WINDSHIELD CANNOT SAFELY DRIVE VEHICLE. THIS IS A WIDE SPREAD PROBLEM WITH THESE TRUCKS.
NHTSA complaint #11383673 — an unverified report by a vehicle owner.
at 203,300 milesKooskia, IDCrash
POWER TRAIN
THE TRUCK WITH ATTACHED TRAILER WAS PARKED ON AN INCLINED DRIVEWAY. THE TRUCK WAS PLACED IN PARK AND THE KEY WAS REMOVED FROM THE IGNITION. I PROCEEDED TO LOAD A COMPACT TRACTOR APPROXIMATELY 2500 LBS. THE TRUCK STARTED TO ROLL DOWN THE HILL AND CRASHED THRU A FENCE DOING EXTENSIVE DAMAGE TO THE TRUCK. I DID NOT TRY TO START THE TRUCK AND WAITED FOR MECHANIC TO ASSESS ANY MECHANICAL DAMAGE. THE MECHANIC CAME TO MY PLACE AND WHEN HE GOT IN THE TRUCK THE TRANSMISSION INDICATED THAT IT WAS STILL IN PARK. DODGE TOLD ME THAT THERE WAS NO RECALL ON THIS TYPE VEHICLE WITH THE TRANSMISSION NOT HOLDING. THE REPRESENTATIVE TOLD ME THAT THERE HAD BEEN SIMILAR PROBLEMS WITH GAS POWERED ENGINES BUT NOT THE DIESEL. I WOULD LIKE TO KNOW IF THIS CAN BE EVALUATED FOR RECALL. NO ONE GOT HURT IN THIS INSTANCE BUT CAUSED EXTENSIVE DAMAGE TO THE TRUCK MECHANICALLY AND COSMETICALLY.
NHTSA complaint #11355102 — an unverified report by a vehicle owner.
at 142,000 milesHatton, ND
STEERING
TRUCK EXPERIENCES THE "DEATH WOBBLE". IT HAS HAD THE FRONT END REDONE TWICE, STILL HAS THE PROBLEM. WHEN I'M DRIVING ABOVE 50MPH, AND HIT A BUMP, SOMETIMES THE FRONT END AND STEERING WHEEL BEGIN TO VIOLENTLY SHAKE AND WOBBLE. WHEN IT OCCURS, IT IS EXTREMELY DANGEROUS, AND VERY DIFFICULT TO STOP. IT HAPPENED 4 TIMES ON A SINGLE TRIP.
NHTSA complaint #11354504 — an unverified report by a vehicle owner.
at 348,000 milesSouth Easton, MA
SERVICE BRAKES
BRAKE PEDAL MOVES SIDE TO SIDE WHEN APPLYING THE BRAKE. THE VEHICLE HAS POWER ADJUSTABLE BRAKE AND ACCELERATOR PEDALS. FIRST NOTICED SLIGHT MOVEMENT WHILE DRIVING AND IS NOW ABOUT HALF TO THREE QUARTERS OF AN INCH PLAY.
NHTSA complaint #11326626 — an unverified report by a vehicle owner.
at 79,000 milesBoyne City, MIFire
ENGINE
TRUCK BURST INTO FLAMES JUST SITTING IN THE DRIVEWAY. TRUCK HAD BEEN PARKED AND NOT STARTED IN 5 DAYS.
NHTSA complaint #11321027 — an unverified report by a vehicle owner.
Salinas, CA
UNKNOWN OR OTHER
DASH IS CRACKING IN MULTIPLE AREA. SEEMS TO BE GETTING PROGRESSIVELY WORSE. DEFROST VENTS ARE FALLING APART AND BECOMING LODGED IN THE VENTS. WORRIED ABOUT THESE PIECES BREAKING AND BECOMING SHARPS PROJECTILES IN THE EVENING OF A COLLISION. NOT SAFE.
NHTSA complaint #11319174 — an unverified report by a vehicle owner.
at 60,000 milesSpringville, UT
ENGINE
TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE DRIVING AT A NORMAL RATE OF SPEED, VARIOUS FUEL INJECTORS BURNED THE PISTONS WITHOUT WARNING AND DAMAGED THE MOTOR. THE CONTACT TOOK THE VEHICLE TO KEN GARFF WEST VALLEY CHRYSLER JEEP DODGE RAM FIAT (4175 W 3500 S, WEST VALLEY CITY, UT 84120) AND DOUG SMITH CHRYSLER DODGE JEEP RAM (523 W MAIN ST, AMERICAN FORK, UT 84003) WHERE THE INJECTORS AND ENGINE WERE REPLACED ON VARIOUS OCCASIONS UNDER WARRANTY. THE FAILURE RECURRED AND THE ENTIRE ENGINE BLEW UP. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC AND PAID $15,000 TO HAVE THE MOTOR REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000.
NHTSA complaint #11296738 — an unverified report by a vehicle owner.
at 223,443 milesNewark, NJ
STEERING
SWAY AND BODY ROLL
NHTSA complaint #11283090 — an unverified report by a vehicle owner.
at 223,443 milesNewark, NJ
SUSPENSION
SWAY AND BODY ROLL
NHTSA complaint #11283090 — an unverified report by a vehicle owner.
at 250,000 milesSalt Lake City, UT
SUSPENSION
TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE DRIVING 60 MPH OVER A BUMP IN THE ROAD, THE VEHICLE VIOLENTLY VIBRATED. THE FAILURES CEASED ONCE THE VEHICLE WAS STOPPED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE FAILURE OCCURRED BECAUSE THE VEHICLE DROVE OVER A POTHOLE. THE FAILURE MILEAGE WAS 250,000.
NHTSA complaint #11266096 — an unverified report by a vehicle owner.
Riverside, CA
SUSPENSION
TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE DRIVING 65 MPH, THE VEHICLE BEGAN TO VIBRATE UNCONTROLLABLY. THE CONTACT EXITED THE HIGHWAY AND THE VEHICLE BEGAN TO RESUME NORMAL OPERATION. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT DROVE TO AN INDEPENDENT MECHANIC AND WAS INFORMED THAT THE UPPER AND LOWER BUSHING KITS NEEDED TO BE REPLACED. THE CONTACT WAS ALSO INFORMED THAT THE TIE ROD NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #11253723 — an unverified report by a vehicle owner.
at 195,000 milesCosta Mesa, CA
SUSPENSION
TL* THE CONTACT OWNED A 2005 DODGE RAM 2500. WHILE EXITING THE FREEWAY AT 65 MPH, THE CONTACT ATTEMPTED TO MAKE A LEFT TURN AND THE VEHICLE SHOOK VIOLENTLY. THE CONTACT VEERED THE VEHICLE TO THE SHOULDER OF THE ROAD WHERE IT CAME TO A COMPLETE STOP. THE VEHICLE RESUMED NORMAL OPERATION AND WAS TAKEN TO ORANGE COAST CHRYSLER JEEP DODGE RAM FIAT (2929 HARBOR BLVD, COSTA MESA, CA 92626, (714) 549-8023) WHERE IT WAS DIAGNOSED THAT THE FRONT END LINKAGES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 195,000.
NHTSA complaint #11240272 — an unverified report by a vehicle owner.