2009 Dodge RAM 2500 problems

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

The contact owns a 2009 Dodge Ram 2500. The contact stated that there was an abnormal odor coming from the exhaust at start-up. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where the vehicle was diagnosed, and the contact was informed that the exhaust manifold bolts needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 140,000. The VIN was not available.

NHTSA complaint #11649217 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2009 Dodge Ram 2500. The contact stated while operating the vehicle, the check engine warning light remained illuminated, the headlights flashed off and on, and the battery failed to remain charged. The contact diagnosed an electrical ground short, a low voltage to the intake air heater relay, and the engine grid heater was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the Extended Warranty coverage for the failure. The failure mileage was 162,000.

NHTSA complaint #11615213 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2009 Dodge Ram 2500. The contact stated while operating the vehicle, the check engine warning light remained illuminated, the headlights flashed off and on, and the battery failed to remain charged. The contact diagnosed an electrical ground short, a low voltage to the intake air heater relay, and the engine grid heater was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the Extended Warranty coverage for the failure. The failure mileage was 162,000.

NHTSA complaint #11615213 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2009 Dodge Ram 2500. The contact stated while driving 20-60 MPH, the front end of the vehicle, the steering column, and the steering wheel were shuddering significantly. The contact stated that the vehicle had experienced the death wobble. The contact stated that the failure increased significantly while driving on bumpy road surfaces. The vehicle was taken to several independent mechanics, where the vehicle was diagnosed but the cause of the failure could not be determined; however, the failure persisted. The contact stated that the tires were replaced twice by two tire facilities; however, the failure persisted. The vehicle was previously taken to an unknown dealer; however, the cause of the failure could not be determined. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA complaint #11544367 — an unverified report by a vehicle owner.

STRUCTURE:BODY

The contact owns a 2009 Dodge Ram 2500. The contact stated that the vehicle was corroded. The vehicle was severely corroded at the rear passenger’s side door frame and a half of the subframe located at the rear passenger’s side was also severely corroded. The center of the main subframe exhibited had holes. The contact stated that the corrosion was not due to salt on the road. The vehicle was not repaired. The manufacture was contacted. The failure mileage was 140,000.

NHTSA complaint #11434700 — an unverified report by a vehicle owner.

STEERING

VEHICLE SWAYS BACK AND FORTH DUE TO STEERING LINKAGE

NHTSA complaint #11352235 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

WENT OUT TO START AND IT WOULD CRANK OVER BUT NOT START UP IT WAS SITTING IN MY DRIVEWAY ON FAIRLY LEVEL SURFACE THEN THIS MORNING IT STARTED UP IMMEDIATELY WITH NO TROUBLE. SECOND TIME THIS HAS HAPPENED.

NHTSA complaint #11311577 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

IN MOTION THE BLINKERS WOULD TURN ON WITHOUT ME TOUCHING THE SWITCH. WHEN I APPLIED THE LEFT BLINKER THE RIGHT ONE WOULD TURN ON AND VICE VERSA. FINALLY THE FLASHERS TURNED ON AND I COULDN'T TURN OFF. IT STARTED MALFUNCTIONING WHILE I WAS DRIVING DOWN THE HIGHWAY AT 60MPH.

NHTSA complaint #11289925 — an unverified report by a vehicle owner.

STEERING

UNCONTROLLABLE STEERING OR FRONT END WOBBLING. AKA DEATH WOBBLE, ACCORDING TO MY VEHICLE HISTORY THERE ARE RECALLS THAT ARE FOR STEERING AND THE DESCRIPTION OF ALL THOSE RECALLS SAY WHAT COULD HAPPEN WHICH IS A LOSS OF STEERING CONTROL RESULTING IN A CRASH. ALL THE RECALLS THAT I KNOW OF HAVE BEEN REPLACED. BUT I STILL HAVE INCIDENTS WHERE I LOSE CONTROL OF STEERING AND IN ORDER FOR IT TO STOP, I HAVE TO STOP THE VEHICLE. I HAVE HAD MANY MANY CLOSE CALLS, AND HOPING THAT THIS DOESN'T RESULT IN A LOSS OF A VEHICLE OR EVEN DEATH. IT'S A VERY BIG CONCERN TO ME CONSIDERING THERE HAS BEEN RECALLS FOR THE STEERING AND FRONT END. IT WILL OCCUR AS SOON AS I HIT A BUMP JUST RIGHT NOT EVEN AT HIGH SPEED IT HAPPENS AT 35-70 MPH NO MATTER IF IT'S FLAT GROUND OR NOT. THE ENTIRE TRUCK SHAKES AND FEELS LIKE THE WHEELS ARE BOUNCING OFF THE GROUND. AT THAT POINT BEING ON THE FREEWAY HAVING NO CONTROL OF MY STEERING THE ONLY OPTION I HAVE IT TO SLAM ON MY BREAKS, IT'S A MATTER OF TIME BEFORE SOMETHING REALLY BAD HAPPENS

NHTSA complaint #11204944 — an unverified report by a vehicle owner.

ELECTRONIC STABILITY CONTROL (ESC)

UNCONTROLLABLE STEERING OR FRONT END WOBBLING. AKA DEATH WOBBLE, ACCORDING TO MY VEHICLE HISTORY THERE ARE RECALLS THAT ARE FOR STEERING AND THE DESCRIPTION OF ALL THOSE RECALLS SAY WHAT COULD HAPPEN WHICH IS A LOSS OF STEERING CONTROL RESULTING IN A CRASH. ALL THE RECALLS THAT I KNOW OF HAVE BEEN REPLACED. BUT I STILL HAVE INCIDENTS WHERE I LOSE CONTROL OF STEERING AND IN ORDER FOR IT TO STOP, I HAVE TO STOP THE VEHICLE. I HAVE HAD MANY MANY CLOSE CALLS, AND HOPING THAT THIS DOESN'T RESULT IN A LOSS OF A VEHICLE OR EVEN DEATH. IT'S A VERY BIG CONCERN TO ME CONSIDERING THERE HAS BEEN RECALLS FOR THE STEERING AND FRONT END. IT WILL OCCUR AS SOON AS I HIT A BUMP JUST RIGHT NOT EVEN AT HIGH SPEED IT HAPPENS AT 35-70 MPH NO MATTER IF IT'S FLAT GROUND OR NOT. THE ENTIRE TRUCK SHAKES AND FEELS LIKE THE WHEELS ARE BOUNCING OFF THE GROUND. AT THAT POINT BEING ON THE FREEWAY HAVING NO CONTROL OF MY STEERING THE ONLY OPTION I HAVE IT TO SLAM ON MY BREAKS, IT'S A MATTER OF TIME BEFORE SOMETHING REALLY BAD HAPPENS

NHTSA complaint #11204944 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

TL* THE CONTACT OWNS A 2009 DODGE RAM 2500. WHILE DRIVING APPROXIMATELY 60 MPH AT NIGHT, THE INSTRUMENT PANEL LIGHTING WENT OUT. THE INSTRUMENT PANEL WAS CHANGED THREE OTHER TIMES BY BRYANT MOTORS (2901 S LIMIT AVE, SEDALIA, MO 65301), BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED FOR THE RECENT FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 49,000.

NHTSA complaint #11183131 — an unverified report by a vehicle owner.

STEERING

AFTER HITTING A BUMP IN THE ROAD AT HIGHWAY SPEED THE TRUCK BEGAN SHAKING VIOLENTLY. REFERRED TO AS A DEATH WOBBLE. NEEDED TO SLOW TRUCK TO BRING IT BACK UNDER CONTROL.

NHTSA complaint #11180559 — an unverified report by a vehicle owner.

SERVICE BRAKES

BRAKES FAILED DUE TO A CORRODED BRAKE LINES AT THE MASTER CYLINDER. HAPPENED IN DRIVEWAY BEFORE I GOT TO THE HIGHWAY.

NHTSA complaint #11099436 — an unverified report by a vehicle owner.

AIR BAGS

DODGE. CONSUMER WRITES IN REGARDS TO PROBLEMS WITH THE AIRBAG CLOCKSPRING. *LD THE CONSUMER STATED THE CLOCKSPRING WAS REPLACED ON THREE SEPERATE OCCASIONS, BUT THERE IS STILL A RECURRING PROBLEM WITH THE VEHICLE.

NHTSA complaint #11080528 — an unverified report by a vehicle owner.

STEERING

DODGE. CONSUMER WRITES IN REGARDS TO PROBLEMS WITH THE AIRBAG CLOCKSPRING. *LD THE CONSUMER STATED THE CLOCKSPRING WAS REPLACED ON THREE SEPERATE OCCASIONS, BUT THERE IS STILL A RECURRING PROBLEM WITH THE VEHICLE.

NHTSA complaint #11080528 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

CPSC: THE TRUCK BROKE DOWN IN THE MIDDLE OF THE HIGHWAY ENDANGERING MY YOUNG CHILD AND MYSELF. DT THE CONSUMER STATED THE VEHICLE WAS UNDER WARRANTY AND IN POSSESSION OF THE DEALER UNTIL IT CAN BE REPAIRED. THE MANUFACTURER WAS NOTIFIED.

NHTSA complaint #11083048 — an unverified report by a vehicle owner.

STEERING

WHILE DRIVING AT HIGHWAY SPEED TERRIBLE FRONT END WOBBLE, VERY SCARY. HAS HAPPENED ON MULTIPLE OCCASIONS. HUSBAND NORMALLY DRIVES TRUCK THIS IS FIRST TIME THIS HAS HAPPENED TO ME WHILE DRIVING ON THE INTERSTATE.

NHTSA complaint #11020540 — an unverified report by a vehicle owner.

STEERING

TRACK BAR MOUNT CAME OFF OF THE FRAME OF THE TRUCK ......PULLING ONTO ROAD FROM DRIVEWAG

NHTSA complaint #11014222 — an unverified report by a vehicle owner.

STEERING

MY 2009 DODGE RAM 2500 STARTED HOPPING AFTER I HIT A SLIGHT BUMP IN THE ROAD. I WAS GOING ABOUT 50MPH WHEN THUS HAPPENED. I COULD DO NOTHING BUT TAKE MY FOOT OFF THE GAS TO SLOW THE TRUCK DOWN. IT LITERALLY HOPPED DOWN THE ROAD , IT FELT LIKE WE WERE IN A PAINT MIXER BOUNCING DOWN THE ROAD. THIS HAS HAPPENED SEVERAL TIMES BEFORE BUT WAS NEVER AS BAD AS THIS TIME. MY WIFE WAS WITH ME THIS TIME AND COULD NOT BELIEVE WHAT IT WAS DOING. SHE TOLD ME IF SHE HAD BEEN DRIVING SHE WOULD HAVE PANICKED AND MOST LIKELY WRECKED THE TRUCK. EVERYTHING IN THE TRUCK WAS BEING TOSSED AROUND. THIS ISSUE MUST BE CORRECTED BEFORE SOMEONE GETS HURT OR WORSE.

NHTSA complaint #11003856 — an unverified report by a vehicle owner.

STEERING

2009 DODGE RAM 2500 HAS WHAT IS DESCRIBED BY MANY AS "DEATH WOBBLE". AT FREEWAY SPEEDS (70MPH HERE IN MI) IF SOME EVEN MINOR BUMPS, POT HOLES ARE RUN OVER THE FRONT END OF THE TRUCK STARTS TO SHAKE UNCONTROLLABLY. TO GET CONTROL OF THE VEHICLE AGAIN YOU MUST SLOW TO BELOW 55MPH. MANY TIMES JUST THE DRIVERS SIDE FRONT TIRE AS BOUNCING OR WOBBLING, RECENTLY THE ENTIRE FRONT END. VEHICLE HAS HAD BOTH PRIOR RECALLS FOR TIE-ROD ENDS COMPLETED. HAD FRONT SHOCKS CHANGED IN CASE THEY WERE THE ISSUE NO CHANGE, HAD TIRES CHANGED IN CASE THERE WAS AN ISSUE WITH ANY OF THE TIRES, NO CHANGE. HAD BELLE TIRE TECHS LOOK FOR ISSUE WITH BOUNCING/WOBBLING TIRES THEY SAID EVERYTHING WAS TIGHT AND IN WORKING ORDER. ALSO HAS ANOTHER GARAGE LOOK AT IT FOR THE SAME ISSUE THEY DID NOT FIND ANY ISSUES. THIS PROBLEM THAT LOOKS TO BE PRETTY WIDESPREAD WITH OWNERS OF 2009 RAM 2500S MAKES THIS VEHICLE UNSAFE AT HIGHWAY SPEEDS UNTIL A FIX IS FOUND. I WILL ASK DEALER ABOUT BOUNCING/WOBBLING FRONT END AGAIN BUT IF THIS IS ON MANY OF THESE TRUCKS THE PROBLEM WILL END UP RESULTING IN ACCIDENTS SHOULD A DRIVER NOT BE ABLE TO SLOW DOWN QUICKLY TO REGAIN CONTROL OF THE STEERING. THIS PROBLEM HAS BEEN HAPPENING FOR OVER A YEAR ON AND OFF, I HAD AVOIDED DRIVING ON THE FREEWAY UNTIL THE LAST REPAIRS WHERE THE TIRES WERE CHANGED AND THE TECHS SAID EVERYTHING WAS GOOD WITH THE FRONT END. FIRST TIME ON THE FREEWAY AT 70MPH IT HAPPENED AGAIN WHEN A FEW SMALL BUMPS WERE RUN OVER, THE ENTIRE CAB OF THE TRUCK WAS SHAKING, OTHER DRIVERS BEHIND AND AROUND ME SLOWED AS I AM GUESSING THEY THOUGHT I WAS GOING TO LOOSE CONTROL AND CRASH. I HAD TO SLOW BELOW 50MPH BEFORE THE SHAKING WAS UNDER CONTROL AND BECAUSE THE OTHER DRIVERS SLOWED IT ALLOWED ME TO GET TO THE RIGHT AND AVOID AN ACCIDENT. SO I WILL NO LONGER USE THE TRUCK AT ANYTHING OVER 45MPH AND ONLY USE SPARINGLY UNTIL THE ISSUE IS IDENTIFIED AND REPAIRED.

NHTSA complaint #11003905 — an unverified report by a vehicle owner.

SUSPENSION

MY 2009 DODGE RAM 2500 STARTED HOPPING AFTER I HIT A SLIGHT BUMP IN THE ROAD. I WAS GOING ABOUT 50MPH WHEN THUS HAPPENED. I COULD DO NOTHING BUT TAKE MY FOOT OFF THE GAS TO SLOW THE TRUCK DOWN. IT LITERALLY HOPPED DOWN THE ROAD , IT FELT LIKE WE WERE IN A PAINT MIXER BOUNCING DOWN THE ROAD. THIS HAS HAPPENED SEVERAL TIMES BEFORE BUT WAS NEVER AS BAD AS THIS TIME. MY WIFE WAS WITH ME THIS TIME AND COULD NOT BELIEVE WHAT IT WAS DOING. SHE TOLD ME IF SHE HAD BEEN DRIVING SHE WOULD HAVE PANICKED AND MOST LIKELY WRECKED THE TRUCK. EVERYTHING IN THE TRUCK WAS BEING TOSSED AROUND. THIS ISSUE MUST BE CORRECTED BEFORE SOMEONE GETS HURT OR WORSE.

NHTSA complaint #11003856 — an unverified report by a vehicle owner.

SUSPENSION

2009 DODGE RAM 2500 HAS WHAT IS DESCRIBED BY MANY AS "DEATH WOBBLE". AT FREEWAY SPEEDS (70MPH HERE IN MI) IF SOME EVEN MINOR BUMPS, POT HOLES ARE RUN OVER THE FRONT END OF THE TRUCK STARTS TO SHAKE UNCONTROLLABLY. TO GET CONTROL OF THE VEHICLE AGAIN YOU MUST SLOW TO BELOW 55MPH. MANY TIMES JUST THE DRIVERS SIDE FRONT TIRE AS BOUNCING OR WOBBLING, RECENTLY THE ENTIRE FRONT END. VEHICLE HAS HAD BOTH PRIOR RECALLS FOR TIE-ROD ENDS COMPLETED. HAD FRONT SHOCKS CHANGED IN CASE THEY WERE THE ISSUE NO CHANGE, HAD TIRES CHANGED IN CASE THERE WAS AN ISSUE WITH ANY OF THE TIRES, NO CHANGE. HAD BELLE TIRE TECHS LOOK FOR ISSUE WITH BOUNCING/WOBBLING TIRES THEY SAID EVERYTHING WAS TIGHT AND IN WORKING ORDER. ALSO HAS ANOTHER GARAGE LOOK AT IT FOR THE SAME ISSUE THEY DID NOT FIND ANY ISSUES. THIS PROBLEM THAT LOOKS TO BE PRETTY WIDESPREAD WITH OWNERS OF 2009 RAM 2500S MAKES THIS VEHICLE UNSAFE AT HIGHWAY SPEEDS UNTIL A FIX IS FOUND. I WILL ASK DEALER ABOUT BOUNCING/WOBBLING FRONT END AGAIN BUT IF THIS IS ON MANY OF THESE TRUCKS THE PROBLEM WILL END UP RESULTING IN ACCIDENTS SHOULD A DRIVER NOT BE ABLE TO SLOW DOWN QUICKLY TO REGAIN CONTROL OF THE STEERING. THIS PROBLEM HAS BEEN HAPPENING FOR OVER A YEAR ON AND OFF, I HAD AVOIDED DRIVING ON THE FREEWAY UNTIL THE LAST REPAIRS WHERE THE TIRES WERE CHANGED AND THE TECHS SAID EVERYTHING WAS GOOD WITH THE FRONT END. FIRST TIME ON THE FREEWAY AT 70MPH IT HAPPENED AGAIN WHEN A FEW SMALL BUMPS WERE RUN OVER, THE ENTIRE CAB OF THE TRUCK WAS SHAKING, OTHER DRIVERS BEHIND AND AROUND ME SLOWED AS I AM GUESSING THEY THOUGHT I WAS GOING TO LOOSE CONTROL AND CRASH. I HAD TO SLOW BELOW 50MPH BEFORE THE SHAKING WAS UNDER CONTROL AND BECAUSE THE OTHER DRIVERS SLOWED IT ALLOWED ME TO GET TO THE RIGHT AND AVOID AN ACCIDENT. SO I WILL NO LONGER USE THE TRUCK AT ANYTHING OVER 45MPH AND ONLY USE SPARINGLY UNTIL THE ISSUE IS IDENTIFIED AND REPAIRED.

NHTSA complaint #11003905 — an unverified report by a vehicle owner.

AIR BAGS

TL* TAKATA RECALL. THE CONTACT OWNS A 2009 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V352000 (AIR BAGS) AND STATED THAT THE PART WAS NOT AVAILABLE WITHIN A REASONABLE TIME FRAME TO SCHEDULE THE RECALL REPAIR. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE SO THE CONTACT WAS UNABLE TO DETERMINE WHEN THE VEHICLE WOULD BE REPAIRED. THE MANUFACTURER WAS CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE CONTACTS VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE CONTACT WAS NOT EXPERIENCING A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA complaint #10946988 — an unverified report by a vehicle owner.

AIR BAGS

TAKATA RECALL - WE RECEIVED NOTICE DATED 7/1/2016 REGARDING PASSENGER BAG RECALL. WE HAVE NOT RECEIVED INFORMATION REGARDING THIS RECALL. 6 MONTHS IS A LONG TIME, IS THERE A TIME FRAME LIMIT?

NHTSA complaint #10939261 — an unverified report by a vehicle owner.