2020 Ford Explorer electrical problems

ELECTRICAL SYSTEM

The contact owns a 2020 Ford Explorer. The contact stated that the vehicle experienced intermittent starting failures, and upon starting the vehicle and shifting into gear, the vehicle shut off. No warning light illuminated. Additionally, the electronic parking brake was unintendely engaged. The contact replaced the battery; however, the failure persisted. The vehicle was not diagnosed or repaired by a dealer or an independent mechanic. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.

NHTSA complaint #11754954 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

My wife was driving and the horn started blowing and the rear wiper started ejecting all the wiper fluid. When I showed up to assist, it smelled super hot and I had to pull the fuse and negative lead to make the wiper pump and horn stop. It was towed to a Ford dealer, who found the main engine harness had MELTED going into the engine compartment fuse box. The horn and wiper fluid pump also had to be replaced. It's fortunate this did not result in a fire. Ford dealer had the vehicle for TWO MONTHS to repair (and we had to take it back for the horn and washer pump). The Ford dealer said they could not give any reason for why this happened. The entire main harness and fuse panel had to be replaced. No check engine or warning lights appeared when this happened. My wife had to pull over on the side of the road.

NHTSA complaint #11753061 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

My driver window won’t stay up once it gets to the top it goes back down. The underbody is starting to detach. It is shifting hard and makes a loud noise. Worse at low speeds and applying brakes . The tire pressure sensors all went out at one time

NHTSA complaint #11747989 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

With people in the backseat, the seats decided to fold out of nowhere from the previous recall where the seat released buttons on the second row get stuck. Even though it’s very clear that these buttons need to be replaced and I took it to a Ford dealership they said that they were fine even though the buttons literally are stuck in no matter what and ever so slightly touching them causes the seats to fold. The passengers in the second row were not injured, but very easily could’ve been.

NHTSA complaint #11747334 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

First the fuel pump control module went out and now for the 3rd time the electrical to the fuel pump control module has faulted

NHTSA complaint #11746795 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The front windshield wiper on my vehicle,may become inoperative. The Ford Motors says that they don't have the part to replace,and when they have it I have to pay for the repair.

NHTSA complaint #11745393 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I am filing a complaint regarding a recurring safety-related electrical and AWD defect in my 2020 Ford Explorer. My vehicle repeatedly displays the following warnings while driving: “4WD Fault Service Required” “Service AdvanceTrac” “Pre-Collision Assist Not Available” “Hill Start Assist Not Available” The issue began about a year ago occurring intermittently every few weeks and disappearing after restarting the vehicle. It has progressively worsened and now appears almost immediately after driving only a few feet. The defect affects multiple critical safety systems including AWD/4WD, traction/stability control, hill assist, and collision avoidance systems. I have contacted Ford multiple times. Ford only opens customer service cases but has not provided a permanent repair. Ford is aware this is a common issue with 2020 Explorers specifically, and later model years appear to have been corrected. Numerous owners report the exact same failures online. Ford has issued service information involving software reprogramming, module communication faults, and wiring harness issues, but only Ford dealerships can perform the required programming. This appears to be a widespread manufacturing or engineering defect and creates a serious safety concern while driving. Vehicle Information: 2020 Ford Explorer Mileage: Under 55,000 miles I respectfully request that NHTSA investigate this issue for a potential recall or mandatory corrective action.

NHTSA complaint #11740378 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Both my passenger and driver headlights have failed. I have paid to have them replaced. The drivers side has failed twice. The passenger side has failed 3 times. I have taken it to the dealership and they “fixed” the issue but it keeps coming back months or weeks later. The low beams are what is failing. The message on the dash says “check headlight assembly see manual” This is a safety risk to me and other people on the road. They have failed while driving. If I am driving early in the morning or late at night I can not see if there are no street lights. People also can’t see me coming. This is a major safety risk. I bought the car in August 2024. Headlights have failed 5 times since then. The dealership helped me with my first four failures. On this last failure, they said it is not covered under warranty and that I need to pay $3000 for the headlight. Five failures of headlights seems like a manufacturer issue and not something. I am doing on my end.

NHTSA complaint #11739255 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2020 Ford Explorer. The contact stated that while driving approximately 65 MPH, the vehicle lost automotive power and stalled. The contact stated that there was an abnormal whining sound coming from the vehicle prior to the vehicle stalling. The vehicle was stopped and there was an abnormal burning rubber odor inside the cabin of the vehicle. The contact stated that the messages “Charging System Fault” and “Service Steering” were displayed. The contact stated that unknown warning lights were illuminated. The vehicle was towed to the residence. The contact stated that her husband replaced the battery and the alternator, however the failure persisted, and the vehicle was losing automotive power. The vehicle had not been taken to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 19V687000 (Electrical System). The manufacturer was informed of the failure, and the contact was informed that the VIN was not included in the recall. The failure mileage was 113,849.

NHTSA complaint #11731790 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Three alerts appeared on my dash after starting my car. These alerts are “Pre-Collision Assist Not Available,” “Service AdvanceTrac,” and “4WD Fault Service Required.” This has been an ongoing issue with this vehicle which directly affects the safety of drivers. After discussing with other consumers, this system failure is happening more and more. While these alerts are displayed, the front end collision assist is completely nonfunctional, thus increasing the risk of an accident. The Advanced Traction Control System is also nonfunctional. Based on other consumers with the same experience, the only solution is to replace the AWD module.

NHTSA complaint #11730969 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I previously reported a safety issue re. Brakes not working in park. Vehicle rolled back and car almost hit mom and young daughter walking behind vehicle in parking lot. When I brought it to BellFord in [XXX] they told me it was not covered under the recall since it wasn’t being caused by rear axle. Instead they wanted to charge me $3,000 to diagnose their manufacturing defect. In addition when I notified Ford rep who never said anything other then I must get car diagnosed and pay for it and then “we will see .” Ford complaint XXX and I believe this is the NHTSA Complaint # XXX. Here is my initial Ford complaint Cxh-XXX was closed without explanation no one could tell me why no one had contacted me. I am very concerned that Ford is not taking responsibility for defective cars. My car now has only 47k. Brake issue. I had to replace front boots due to leaking and front axle was leaking. I had that fixed and now rear back up camera isn’t working. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11725306 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The back camera screen went blue, even though I already replaced the camera as per the previous recall. This time, the entire screen went blue.

NHTSA complaint #11716401 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

**Upon request, all failed components can be inspected anytime for any reason. From this date (01/23/26) forward. If any repairs or replacementa had been rectified by Ford, receipts of the repair(s) will be provided regardless. I cannot recall exactly when these issues started so my ball park is 5/11/22. That is literally 2 years of driving the car from the show room. I was getting some lights on my dash that I have lost all functions with the vehicle ...ie: drivers assistance, airbags, up hill decent, pre- collision, no driving modes and the car felt normal. I was still under warranty so the repair that was done was an update to the BCM (is what I am told.) So the mechanic did a reprogram to the module. About a year I noticed I was then getting check headlamp notification pin my dash. I check the lamps and all seemed to be just fine. Also I was dealing with a dead battery all the time. at least once a month. But I was told I needed to drive the car more often. No matter still getting a dead monthly battery and here and there "check headlamp". Approx last year 2025, I realized. it was really dark driving the SUV. I get out and long behold the low beam headlamp was out. Played with switches..nothing. Checked into just getting a new one. its is a STAGGERING 1.5K!!!!PER HEADLamp! Well, the cops pull me over 4 times. For a headlight with LEDs why am I even having to price this? This Platinum trim just h I 5 years old and I cant believe all the problems. Along with that I found that this is considered something for the owner has to replace due to owners maintenance. No. THIS NEEDS TO BE RECALLED. SHOULD HAVE ALREADY BEEN RECALLED. THE DEAD BATTERY. WELL...I know am out of all warranties to the vehicle AND FORD IS SHUTTING THE DOOR IN MY FACE for any "goodwill repairs" (So far) As of this very moment, I have a dead 2020 Ford Platinum Explorer. Heads Lamp is still out. Yet there is a recall on a backup camera. Complete joke and this is literally disappointing.

NHTSA complaint #11712966 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I have a leaking antenna (likely the "shark fin" or roof antenna base) on my 2020 Ford Explorer. This has caused significant electrical issues, leading to safety concerns like malfunctioning lights, infotainment, or even stalling, the water shorting wiring harnesses or modules located in the roof or headliner area. This should be a recall, but rather it is a known problem where water intrusion damages sensitive electronics, necessitating immediate professional inspection and repair to prevent further damage and ensure safety, as electrical failures can be dangerous. My GPS and satellite do not work because of this and I am being charged significantly by the dealership because I have to repair this or the damage will become more severe. The antenna's base seal can fail, allowing water to seep into the roof, drip down the pillars, and saturate the headliner and wiring harnesses. Common Symptoms: Interior lights, instrument cluster, or dashboard warnings. SYNC system freezing or failing. Windows, locks, or other accessories malfunctioning. Even potential water on the front passenger floor. Safety Risks: Loss of Control!!!!!!! Malfunctioning lights (headlights, brake lights) or sudden power loss can create dangerous driving conditions. Reduced Visibility: Issues with the infotainment screen or instrument cluster can distract the driver. System Failures: Critical safety systems, if affected by water, could fail unexpectedly. I barely get car washes or anything. This is certainly a manufacturers issue & poor design or cheap casing/ seals that leak and corrode too easily. This problem is a known weakness for the 2020 Explorer, often requiring a thorough inspection beyond just the antenna itself, as water can travel far from the entry point. And sure enough I have plenty of damage that I should not have to pay for. This is not a fluke, there are forums all across the internet about this. Please help! This is truly unfair to the customers.

NHTSA complaint #11709031 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Air Conditioner turns ON by itself even after being manually TURNED OFF, happened multiple times. This occurred with the manual start and the vehicle running / moving.

NHTSA complaint #11696925 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

What component or system failed or malfunctioned, and is it available for inspection upon request? Sunroof headliner assembly failed. The headliner fabric detached and came off the track without an prior misuse or manual operation, it simply fell loose on its own. The material is now sagging and when trying to use the sunroof the fabric hangs in the line of vision causing a safety hazard. How was your safety or the safety of others put at risk? While the issue did not cause an immediate accident, the loose headliner obstructs visibility while trying to use could become a distraction to the driver.IT blocks the driver's line of sight or interferes with airbags in an emergency. Has the problem been reproduced or confirmed by a dealer or independent service center?The failure occurred spontaneously and I have a appointment to take the dealership for further inspection. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No formal inspection has been completed at this time. The issue will be presented to a Ford service center for further evaluation. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning lights or messages appeared prior to the failure. The issue occurred suddenly and without any prior indication. The fabric and track system separated unexpectedly during normal stationary conditions.

NHTSA complaint #11696011 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

When driving the vehicle's instrument panel cluster randomly goes blank. When it does so, all of the items related to speed control, lighting, turn signals, etc. become non-operational. Additionally, the driver has no idea what his/her speed is nor any other information about the operation of the vehicle. It is very unsafe.

NHTSA complaint #11695888 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Ford ST 2020 just 37000 miles, the window from driver side can’t complete close when you try to roll up. When it all most close- it will automatically roll down. TPMS fails cause 4WD fault, ABS turn off and a lot of warning symbol turn on like pre-collision…etc. Dealer can’t fix and claim for client need to paid for 4WD program.

NHTSA complaint #11695707 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Vehicle: 2020 Ford Explorer XLT Date of Incident: October 24 2025 Approx. Mileage: 82000 Affected Component: Visibility / Defroster / Rear Window Glass Description of Problem: While the rear defroster was on, the rear window of my 2020 Ford Explorer XLT suddenly made a popping noise and began to spider-crack from a point near the defroster grid. There was no external impact to the glass. The cracking continued slowly across the entire rear window after the noise. The event occurred on October 24 2025. The vehicle was parked outdoors in normal fall weather conditions in Pennsylvania, and the rear defroster had been turned on to clear condensation. This appears to be a rear defroster thermal event, similar to issues described in Ford’s Customer Satisfaction Program N192265660, which addressed defroster overheating and rear-window damage in certain Ford vehicles. The defect presents a safety concern, as the rear glass integrity is compromised and visibility is reduced. I have photographs of the crack pattern and plan to have the the window replaced by safelite. It is not safe to drive to a dealership. Please investigate this potential manufacturing or electrical defect affecting 2020 Ford Explorer models.

NHTSA complaint #11695423 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Car vibrate and jerk when switching gears randomly. Also the control panel has went out twice. I read everywhere these vehicles have issues with transmission problems on all the 2020 and there is no recall this is. Ridiculous.

NHTSA complaint #11691127 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I recently had my vehicle serviced for reprogramming of the AWD control module after it failed. When the dealer returned the vehicle, I expected the issue to be resolved. Instead, I immediately noticed a new check engine light with code C00A6, related to the front axle disconnect. This was concerning because the dealer had assured me there were no active codes after programming the new module. After driving with the new fault, it became clear the vehicle was operating only in rear-wheel drive. I contacted Ford and was quoted $4,030 for repairs to the front axle disconnect. Given the cost, I researched whether this issue had a recall but found none, despite widespread reports from other owners experiencing the same failure. My main frustration is that this problem stems from Ford’s design of the intermittent AWD system, which engages the front wheels only when needed to improve fuel economy. The official “fix” eliminates this design entirely—converting the vehicle into a full-time AWD system. This requires removal of the front axle disconnect shaft, installation of a standard shaft, and reprogramming to support permanent AWD. The Technical Service Bulletin (TSB 23-2174) even directs technicians to cut and discard the electrical connector for the front axle disconnect actuator, confirming that the original intermittent system is abandoned rather than repaired. This is a major concern for owners. Many of us are facing the same issue, yet Ford’s solution shifts the burden of an expensive design flaw onto customers. I strongly urge Ford to address this problem responsibly and provide coverage for affected vehicles, rather than leaving owners to pay thousands for what appears to be a widespread defect.

NHTSA complaint #11688028 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Transmission gears were not running properly. On a Saturday evening the car was sleeping when slowing down and the following morning it completely died. Ford is reporting to me that I need a new transmission and I am only 1K miles over the warranty. i have read on line from several others with the 2020 explorer having this issue or the tranny dieing within 10-20K miles after warranty.

NHTSA complaint #11685856 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

At this time, I am unsure if there is some kind of recall, but my alarm is going off alerting me that the lift gate opened but that isn't true once my vehicle is locked. Also, the headlights turn on by themselves as if i have pressed on the keyfob. I then get an alert stating that the remote features disabled to preserve battery. These are just a few of the issues that i am having with this vehicle at this moment. I am a mother to 3 kids and i need to have a reliable vehicle and I don't have time to stress about not locking my vehicle at night jus to avoid my alarm going off. This is insane.

NHTSA complaint #11684919 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

On [XXX], after starting my vehicle, I received multiple safety warnings, prompting the check engine light and a wrench icon on the dashboard. The alerts included issues with the anti-collision system, hill assist, traction control, lane departure, and adaptive cruise control, as well as my drive modes which were also unavailable. I contacted Raceway Ford in Riverside, CA, and dropped off the vehicle that day, reporting the errors. The dealership informed me the next day that the Half Shaft Speed Sensor had failed and would cost $870.52 to replace. Since the warranty had expired a month earlier on [XXX], this was no longer covered under the drivetrain warranty. I agreed to the repairs. After installing the new sensor, and conducting a test drive, additional errors appeared. After two weeks in the shop and multiple follow-ups, the dealership concluded that the AWD/FWD sensor had also failed and replaced both sensors. The repair documentation references TSB 21-2270, SSM 49045, and C0631. I believe this raises serious safety concerns and should warrant a recall, especially since other vehicles are experiencing similar issues just a month after warranty expiration. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11684735 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

While driving, vehicle gave Powertrain malfunction, downhill assist unavailable and Pre-collision warning system unavailable faults. The vehicle then came to a stop and would not move. Turning the ignition off and on allowed the vehicle to be safely parked in a nearby parking lot.

NHTSA complaint #11680683 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

[XXX] . Twice rats have destroyed the electrical wiring under the hood and chasey. While some of these wires do not affect safety, the wires that control and power the crash airbags do. Plus this may create a fire hazard. This also includes hoses. My reach revealed that these components and wire insulation are made from soy-based polyurethane which the rats see as food. This is a safety issue with the air bags and fire hazard. Other affected safety items would include blind spot detection and back up. Also the customer service hotline I was hung up up on twice and could not get through. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11680206 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2020 Ford Explorer. The contact stated that while attempting to start the vehicle, several unknown warning lights were illuminated. The contact stated that after inspecting the vehicle, the contact became aware that rodents had eaten through the wiring harness. In addition, the contact stated several of the safety features in the vehicle were inoperable. The vehicle was taken to the dealer, where it was confirmed that rodents had eaten through the wiring harness. The contact was informed that the wiring harness needed to be replaced. The vehicle was repaired. The contact stated that it was the second time that the failure had occurred due to the rodents. The manufacturer was not made aware of the failure. The failure mileage was approximately 15,000.

NHTSA complaint #11680212 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

1. What component or system failed or malfunctioned, and is it available for inspection upon request?
The issue pertains to a water leak in the rear liftgate area and/or water accumulation in the spare tire area, potentially accompanied by a lack of audio functionality in my 2020 Ford Explore ST as outlined in TSB 24-2044 (NHTSA ID: 102514). The affected component is the rear liftgate structure and associated seals, which allow water ingress, particularly noticeable after car washes or rainfall. The entire sound system to include any collision and impact warnings have failed to chime. 2. 
The water leak in the rear liftgate and spare tire area poses potential safety risks. Accumulated water can damage electrical components, such as wiring or audio systems, which may lead to malfunctions in critical vehicle systems. For example, water ingress could affect rear lighting, sensors, or other electronic modules, potentially compromising visibility or functionality during operation. Additionally, water accumulation may contribute to corrosion or mold growth, posing long-term structural or health risks for occupants. These issues could reduce vehicle reliability and increase the risk of accidents, especially in adverse weather conditions. 3.The issue has been acknowledged by Ford in TSB 24-2044, which provides a service procedure to identify and address the leak path. The Bill Currie Ford dealership in Tampa, FL has inspected my vehicle on several occasions, recently July 15, 2025 and confirmed water leakage in the rear liftgate area consistent with TSB 24-2044.The dealer will not repair unless I pay over $2200 for the repair, which I refuse for a manufacture defect. 4. To date, the vehicle has not been inspected by the police or insurance representatives, but the issue align with the TSB report. 5. Water observed in the spare tire & tailgate area every time since purchase. A loss of audio back in July 2023 and numerous occasions since complete failure as of January 3 2024

NHTSA complaint #11679932 — an unverified report by a vehicle owner.