63 of the 306 complaints about the 2022 Ford F-150 Hybrid are about the electrical system — 21% of everything reported for this model year. Half of the failures with a mileage on record happened before 24,500 miles.
63
Complaints
1
Crashes
2
Fires
4
Injuries
Filed with NHTSA, in their own words.
ELECTRICAL SYSTEM
Driving along I-15 in vegas. Ambient temp was 112 degrees F. Engine stopped, check engine light came on and a 'stop safely' indicator appeared. Had to have the truck towed from the interstate to a Ford dealership.
NHTSA complaint #11755591 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
Highway Incident: While traveling at highway speeds, a sudden evasive braking maneuver caused the truck to drop power. Upon attempting to re-accelerate, the throttle pedal went to the floor with zero response, and the vehicle continued to decelerate on an active highway. Multiple trailing vehicles had to make emergency maneuvers to swerve around the decelerating truck to avoid a high-speed, rear-end collision. Subsequent Incidents: The vehicle repeatedly forces an uncommanded speed limit of 11 mph while attempting to accelerate from a complete stop or merge from stop signs. This severe lack of predictable acceleration creates an immediate risk of being T-boned or rear-ended by cross-traffic, making the vehicle entirely unsafe to operate in normal traffic conditions. An authorized Ford dealership has confirmed the underlying failure of the hybrid system. They kept the vehicle for approximately one month to replace the entire hybrid drive unit. Following that repair, the vehicle was returned to the dealer a second time, where technicians confirmed a software communication failure between the electric and gas systems, attempting to resolve it by flashing/reprogramming the ECU. The vehicle’s hybrid system and software have been extensively inspected and worked on by manufacturer-certified technicians at an authorized Ford dealership. It has not been inspected by police or insurance, as no physical collision has occurred yet. No warning lamps or messages.
NHTSA complaint #11743367 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
When I started my 2022 Ford F-150 equipped with the Bang & Olufsen (B&O) sound system, a sudden extremely loud “sonic boom” noise came through the speakers without warning. The sound was so intense it caused immediate pain in my ears, and I am concerned about the possibility of permanent hearing damage. This occurred at startup, before I adjusted any audio settings. This is a serious safety hazard because: The volume level was far beyond normal operation. It caused physical harm (ear pain). Such an unexpected loud noise could startle the driver, leading to loss of vehicle control. I believe this defect poses a risk of injury and should be investigated.
NHTSA complaint #11688558 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
On July 30, 2025, as I was pulling onto the highway, my audio system started blaring noise from all the speakers in the vehicle. This noise was unbearably loud to the point I had to pull off the road. The noise coming from the speaker system was so loud that it was visibly shaking the door panels in the vehicle. I tried to turn down the volume, but it didn't help. After this, I tried turning off the vehicle's entertainment system, which still didn't help. I finally turned the car off, opened the door, got out, and then closed the door; however, the noise persisted for about 10 seconds before finally shutting off. Upon restarting the vehicle, the noise stopped, and I was able to drive for about a mile before starting again. At this point, I drove the car to my local Ford garage and, the problem was able to be replicated. They could not figure out how to fix the issue, but pulled the fuse to the audio system to prevent the sound from occurring and scheduled me to come back to inspect the vehicle at a later date.
NHTSA complaint #11677460 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
The contact owns a 2022 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle independently accelerated, and the contact heard an abnormal sound. The contact stated that the transmission upshifted from third gear into fifth gear. The contact stated that occasionally while the accelerator pedal was depressed, the vehicle failed to accelerate as intended. In addition, the low-voltage battery and check engine warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed hybrid EV battery pack. The contact was informed that the hybrid EV battery pack needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle was taken to several dealers due to the persistent failure and the hybrid EV battery pack was replaced twice. The failure reoccurred. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 52,000.
NHTSA complaint #11667369 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
On Sunday, [XXX], my truck spontaneously burst into flames while parked in my front yard. I had just returned from doing a number of errands. The truck had been running fine with no indications of a problem. I was outside tending to my smoker when I heard a sort of popping/crackling noise. I looked up at my truck approximately 40 feet away and saw flames shooting out from the engine bay through the hood gaps. I called 911 and attempted to douse the flames with a powder fire extinguisher with no luck. By the time the fire department arrived 15 minutes later or so, the truck was fully involved and burnt to the frame. I didn't smell gasoline during the initial startup, but a strong smell of burning wires. The concerns are of course for my safety and that of my family. It was just luck that the truck was parked in the front yard rather than next to my house where it's normally parked. We were have a sidewalk put in and thus my normal parking space wasn't available. I could've been driving at the time and with the speed of this fire, I'm not confident I would've been able to get out. The truck has been seen by the insurance company and is being towed out of my yard sometime today May 29th, 2025. I don't know where it will towed to. I have pictures and videos detailing the fire and it's progression. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11663633 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
Vehicle started screeching at a high pitch deafening tone. It terrified me and has made my ears ring and hurt all day....went and had a hearing test done and I now have mild hearing loss...will go back in two weeks to test it again. I pulled over and turned radio and truck off....and it still keep screaming. I disconnected the battery and it also still kept doing it. I drove to the dealership while.trying to plug ears shut with fingers.. After a hour there setting up to pay and leave the truck with them, it stopped. I did do the hearing test after it happened because my ears hurt and kept on ringing. I also recorded a video on my phone of the sound that was blasting out. I thought I smelt burning wires but realized later that the sound was way higher than the radio turned all the way up and the smell was coming from all the speakers being pushed over their max decimal compasity. I have a video but it will not let me upload it in the file section.
NHTSA complaint #11661950 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
Unbearably loud ear piercing static from speakers. Unable to turn it off or lower volume. Volume controls didn’t work. Ears in major pain from the noise. I have video of the noise but don’t seem able to upload.
NHTSA complaint #11656948 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
After driving home from work on 12/20/24 the truck was parked at ~10pm. At ~1AM on 12/21/24, I was alerted that the truck was on fire. I found the vehicle fully engulfed in the hood and cab area. There was no prior indication of a problem or issue. The truck was fully destroyed and my home and Jeep were damaged. My home was damaged and only saved because I brought my garden hose out and sprayed the house until the local FD arrived. The local Fire Investigator and the Insurance Fire investigator could it definitively identify how/why the truck caught fire and burned up.
NHTSA complaint #11650194 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
The 7 pin trailer connecton doesn't work properly. The trailer clearance lights are on all the time. Even with the truck lights off. The electric brake controller pulses electric to the trailer brakes. Even when there is no trailer connected and the truck not running. The trailer brakes locked up. The lane centering is so sensitive the steering wheel shimmies. This makes the trailer sway.
NHTSA complaint #11643674 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
The navigation, information, and control screen in this vehicle randomly shuts down and reboots. often when using the reverse and 360 camera system. Ford has said they will not work on these systems as they are faulty, and has promised a software revision for over 6 months. The dealers report that they are not allowed to work on this until the new software comes from Ford. At least one time the instrument cluster also went blank during driving. this is a safety concern that the ntsb should be aware of, in addition to the faulty/dangerous bluecruise and advance self driving features that put folks in peril.
NHTSA complaint #11641182 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
Driving down the highway and all of a sudden the speakers made a sound like a gun going of then they all started popping at a deafening level. Was unable to focus or hear anything and almost was hit by another car before I could get safely pulled over, sat for nearly 2 hours turning on ignition periodically to see if it would stop finally it did. Looked online and there are numerous posts about this issue. This vehicle is not safe to drive as problem happens without any notice.
NHTSA complaint #11640236 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
This is the 3rd time this has happened since purchasing this vehicle. Purchased on 7/27/24. The previous 2 times it resolved itself and the vehicle started and ran with no apparent issues afterwards.1st was on 8/05/24, 2nd was on 10/14/24. On this 3rd and current time I went to start the vehicle and vehicle would not start. The lights and radio work but the vehicle did not start. Only displayed a stop safely now message on the instrument panel. This is one of my worse fears happening as I type this. I'm stranded with a vehicle that will not start and my father is on his death bed with no way to get to him....
NHTSA complaint #11635564 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
on January 20, 2024 I serviced my F-150 due to a malfunction. The DTC code came back as P0A1E-00. This is for the Starter/Generator Control Module. The belt and starter were reaplaced. The code appeared again on 12/21/24 2 times, 12/25/24, 12/26/24 2 times. I brought this back to the dealer on 12/19/2024. 12/26/2024, 12/27/2024. Somehow there was a TSB which I cannot acces that information, but this mentioned to test the battery. My battery failed. I paid for the diagnostics and battery. Then 3 hours later on 12/26 my Tuck went into a powersave mode. This time I brought it back on 12/27/2024, and got a call form the dealer on 12/31 that the replacement battery was defective. This was replaced. I am trying to find out why my battery died after only 2 years. Also since my DTC is related to the charging system, this could ptentially damage my battery. And they also replaced it with a defective battery. Ironically, there is a current recall of over 20,000 batteries being defective from Ford. I mentioned all of this to dealer and Ford directly, and no one can give me a straight answer of what it says to fix my issue.
NHTSA complaint #11633654 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
While driving my entire dashboard went off. No speedometer, No Tach, No fuel gauge, No odometer, nothing. Replaced appropriate fuse still out. Vehicle has just over 36,000 miles
NHTSA complaint #11630473 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER:SENSOR/SENDING UNIT
While driving my entire dashboard went off. No speedometer, No Tach, No fuel gauge, No odometer, nothing. Replaced appropriate fuse still out. Vehicle has just over 36,000 miles
NHTSA complaint #11630473 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
I started my 2022 F150 with B/O Audio and an extremely loud blast that sounded like a cannon shot out of the speakers. My volume dial didn't work and loud crackling and popping sounds were coming out of the tweeter speakers. This has been reported many times already. Turning the audio and the entire vehicle off did nothing. Crackling actually would continue when vehicle was turned all the way off for at least 2 minutes, which would indicate some power was still being fed to the speakers for some reason. No warning lamps/messages appeared.
NHTSA complaint #11614226 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
Another Ford F150 Supercrew leak from the front cowling area into the passenger floorboards. This is a 2022 Hybrid F150 Supercrew built during COVID and purchased March 9, 2022. There are too many reports online of leaks due to lack of sealing components where large aluminum parts meet. For example the fender and the cowling area. This particular leak is having a dealership spend 17 book hours at $215 per hour plus parts to fix a defect in workmanship. Ford is offering to partailly pay for the fix since the vehicle is 6000 miles out of warranty. The fact it is a defect in workmanship is not a consideration. It was never sealed. Thank you
NHTSA complaint #11610077 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
The contact owns a 2022 Ford F-150. The contact stated while driving approximately 15 MPH, the message "Failure Trailer Brake Module" was displayed on the instrument panel. The contact stated that the turn signal was flashing constantly. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the trailer brake module was unresponsive. The vehicle was not repaired. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 42,000.
NHTSA complaint #11603797 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
Reduce power warning, instrument cluster is black, extremely loud pulse noise from radio that can not be turned off , catalytic converter issue ( ck engine light ) stalled in traffic. and horrible fuel mileage. Nothing resolved from the dealer.
NHTSA complaint #11599706 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
I am having multiple electrical glitches with the vehicle. While I was in bluecruise the self driving mode the vehicle warned me to take control and when I did the vehicle was stuck in a loop on the highway with notifications alarms. I was able to take a video one of the times. I took it to the ford dealer and they said they needed me to bring it back when an engineer was available. While waiting to go back had another serious issue with the head unit/audio system when I started up the vehicle. Ear damaging sounds came on and I lost control of the head unit. Shut the truck off and turned it back on and the ear piercing noises persisted. I made a video of this too. My head unit randomly reboots while driving the vehicle. Went back to ford and they did an update instead of having engineers diagnose the problem. Audio system still doesn’t work right and I think it is damaged from the event.
NHTSA complaint #11579403 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
Vehicle's engine will not start. When attempting to start, it will turn on all usual electrical components, but will immediately show an warning message to "Stop Safely Now" along with an engine light of a red outlined truck with exclamation mark. Followed by a message of accessory mode on, however the engine will not start with no access to power steering or shifting gears. Normal attempts to jump start or charge the battery will not work. All fuses and harness connections appear to be normal. After researching Ford community forums, this appears to be a common complaint in the Powerboost Hybrid 2021-2022 Ford F-150s. Extremely inconvenient as this situation has left us stranded several hours from home with no reasonable solution other than to tow to a dealership. We hope our message helps encourage Ford Motor to continue researching the issue and come with a reasonable solution for all effected.
NHTSA complaint #11574139 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
Vehicle will not start. Get "Stop safely now" message. It is 16 degrees outside. What if this had happened while I was out. This would be a life threatening problem. This appears to be a known issue, but Ford has not fixed it. There are hundreds of reports on various forums of the same problem.
NHTSA complaint #11565951 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
Loud popping coming from the pillar and roof speakers after shutting the vehicle off, it scared me to death, this can cause accidents.
NHTSA complaint #11565575 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
Again today 12/3/23 the sync 4 screen upon startup froze in a gray screen for minutes then restated rendering the Federally Mandated Tear Camera 100% inoperable. Nothing worked for minutes a safety hazard not being able to see and move
NHTSA complaint #11558235 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
This horrifyingly loud rhythmic noise came out of my speakers yesterday. I have a F-150 Platinum with B&O Stereo system. My ears felt like they were bleeding and I actually experienced pain due to how loud the noise was. It happened when my truck was parked and I went to start it and the deafening noise hit. No matter what I did, turned the volume down, radio power off, turned the truck ignition off - it still made the noise. I also smelled a very strong burning smell that smelled like burning wires or transmission fluid. I have a video of it. I walked away to call Ford service and came back in about 5 minutes and the noise had stopped. When I opened the drive door, the noise started up again. I left and came back again and noise had stopped and didn't start up again. Had it towed to the dealer who said they had never heard of this before. They have it now and I sent them a link to the Ford F-150 forum and articles that are online talking about it from back in August. Extremely frustrating!!!
NHTSA complaint #11557199 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
Loud pop from sound system is back again, and did it so loud scared the crap out of a passenger, this is beyond dangerous, the software update didn’t work, Ford denies any issues at all exist on anything.
NHTSA complaint #11556580 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
Parked running boards do. Or always go up, lighting stays on for 10 min, have to go play with on/off over and over and to get it to shutoff. On the HwY BC shuts off out of nowhere, and ping pongs back and forth. Get messages saying drivetrain failure, steering failure go to the Dealer naturally. Nothing wrong. This is a big [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11556583 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
I had warranty work done on a trailer brake module on October 23, 2023. About 3 weeks after that it seemed like my transmission was a little rough. Then Nov. 6, I had several incidences where I was at a stop, and it felt like someone hit me from behind and lurch my truck forward a little bit. It seems very dangerous. In case someone in a crosswalk is walking in front of me I could possibly hit them up. My Ford diagnostic tells me that it is the electric transmission fluid pump. There was no warning no lights lit up on my dashboard warning me that this would happened. After I started the motor the next morning, the check engine light came on. The next day I drove it for a short time around the block and the check engine light was not on. I drove it straight to the dealership and made an appointment to take it in. I have read several articles and forums complaining about the exact same thing recently. It seems as if there should be a recall on this issue. Another issue since I’ve had the truck brand new in July 2023 is it always skipped second gear which kind of makes it a little rough starting off.
NHTSA complaint #11556173 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
B&O sound system loud scary pops and static, Sync 4 screen goes blank while driving, also blank sometimes for minutes at startup, I have had it come on, watch the 360 camera begin to backup and look in the mirror the camera lags not showing the car behind me. Constant messages of steering failure, catalytic converter failure drivetrain failure dealer says nothing wrong.
NHTSA complaint #11555651 — an unverified report by a vehicle owner.