2006 Ford F-150 electrical problems

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

Odometer Fraud. The contact sold a 2006 Ford F-150. The contact stated that the vehicle was sold with approximately 212,000 miles but later discovered that the buyer had relisted the vehicle for sale with an advertised mileage of 135,713. The vehicle was a private sale. Local authorities had been notified.

NHTSA complaint #11656585 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

while in drive, accelerating to highway speeds or cruising around 30 mph it will downshift and jump to about 4000 PMS's and not shift up into 3rd gear. It blown 1 engine and I have replaced the transmissions, taken it to a Ford dealership and they weren't able to help me. I've replaced the ECM and anti-theft modal also and the symptoms still persist. i am i in for over 11K for the new engine and transmission, and another $100 on the ECM and anti-theft modal plus the shop charges. The truck has under 190,000 miles before any of this started. I am the 2nd owner an had for less than 3k miles before any of the problems started. Now I see the 2015-2017 F-150s are having the same problems getting recalled. is there anything involving the earlier Triton's engines?

NHTSA complaint #11651426 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

broken fuses baks air conditioning

NHTSA complaint #11465059 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

There is a very common problem with the brake light always being on due to a short circuit in the cluster, many owners have reported this problem for several manufacturing years, the brake light is always on even though there is no problem with the brakes. This creates a great hazard because if you do have a brake problem since the light is always on you will never know, and you may be in a fatal vehicle accident. Ford motor company should replace or repair all clusters that have this problem.I just purchased this vehicle with this very common problem. Your inspector can google it and will find this is indeed a very common problem.

NHTSA complaint #11419376 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

COMPUTER KEEPS THROWING CODE FOR INTERMITTENT CAM SHAFT POSITION SENSOR CIRCUIT A BANK 1. CAUSE TRUCK TO RUN ON ONLY HALF POWER. POOR MPG. NO HORSEPOWER. HESITATION IN SHIFTING.

NHTSA complaint #11384906 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

MY 2006 F150 FORD LARIAT. IT STARTED WITH THE FRONT MAP LIGHT ARE SOME LIGHT NOT SURE WHAT IT'S CALLED. IT WOULD COME ON BY ITSELF JUST SITTING STILL WITH ENGINE OFF. AND NO ONE IN THE TRUCK. IT WOULD DO THIS ALL HOURS OF DAY AND NIGHT. THEN THE DOOR JAR LIGHT CAME ON GOING DOWN THE HWY. AND WOULD NOT GO OFF. WE STOP TO CHECK ALL DOES AND THEY ALL WAS SHUT. IT STAYS ON AND WANT GO OFF. THEN WITH ALL THAT GOING ON ALL MY POWER WINDOWS STOP WORKING. THEY WAS WORKING FINE BUT WHEN THE DIME LIGHT PROBLEM. AND THE DOOR A JAR LIGHT ON WHEN YOU GET IN THE TRUCK AND TURN KEY ON. I HAVE TALK TO PEOPLE THAT OWN A FORD AND MOST ALL FORD'S HAVE HAD THIS PROBLEM. I ALSO HAVE GOOGLED THESE PROBLEMS AND A LOT OF PEOPLE HAVE HAD THE SAME PROBLEMS. BUT IT HASN'T BEEN ANY RECALL ON THESE PROBLEMS. IT REALLY NEEDS TO BE A RECALL FOR THESE PROBLEMS ON FORD'S. IT'S A ELECTRICAL PROBLEM.

NHTSA complaint #11374196 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

BRAKE LIGHT CONTINUOUSLY ON DUE TO FAULT IN CLUSTER PANEL. SAFETY ISSUE IN NOT KNOWING WHEN THERE ARE BRAKING PROBLEMS.

NHTSA complaint #11254970 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

FORD F-150 FX4 140,000.0 MILES. BRAKE LIGHT HAS BEEN ON FOR SEVERAL YEARS STARTING AROUND 2010 WITH 76,000.0 MILES. THE BRAKES WERE REPLACED AND FLUSHED MULTIPLE TIMES SINCE THE PROBLEM STARTED. REPLACED BRAKE CABLE E-BRAKE SWITCH ETC... EVERYTHING POINTS TO THE CLUSTER AND THERE ARE MULTIPLE WEBSITES THE VERIFY THE SAME EXACT PROBLEM WITH THE BRAKE LIGHT BEGINNING FROM 2004-2010. IN SOME STATES THIS IS AN INDPECTABLE ITEM ADDING ADDITIONAL AND MANDATORY REPAIRS TO BE MADE. THE CLUSTER REPAIR PART COST ANYWHERE FROM $400.00-$600.00 AND WITH LABOR COULD RUN WELL OVER $1000.00 PENDING ON THE MODEL OF THE F-150. MY BOTTOM LINE IS THAT THIS ISSUE HAS GONE WITHOUT A RECALL FROM FORD OR THE NHTSA.

NHTSA complaint #11217744 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

INTERIOR LIGHTS DO NOT LIGHT UP ON OPENING THE DOOR. ADDITIONALLY, UPON STARTING THE ENGINE, THE ELECTRICAL PANEL BLINKS, FIZZLES, DEMANDS RESET, WHICH DOESN'T RESET, AND EVENTUALLY CORRECTS ITSELF SOMETIMES AFTER 15 MINUTES OF BLINKING. ADDITIONALLY, THE HIGH BEAMS IMPLEMENT AND THEN YOU CANNOT MAKE THE HIGH BEAMS TURN OFF. MAY ALL BE RELATED BUT, SEEMS LIKE 3 SEPARATE ISSUES, ALL SEEM TO BE RELATED TO THE ELECTRICAL PANEL. BLINKING BEGINS WHILE STATIONARY UPON STARTING TRUCK AND CONTINUES WHILE IN MOTION, INDICATES PROBLEM WITH EVERYTHING ELECTRICAL INCLUDING SPEEDOMETER AND STATES AUTO LOCKS FAIL, ALONG WITH BLINKING FAILURE OF ALL SYSTEMS STATING RESET BUT PUSHING RESET DOES NOT APPEAR TO FIX ANYTHING.....ONLY TIME FIXES IT.

NHTSA complaint #11193476 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

MOTOR IS MISSING AND THE CODES ARE P0345, P0349 AND P0171

NHTSA complaint #11163346 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TAKATA RECALL. FOR THREE YEARS OF ELECTRICAL ISSUES, BEEPING ELECTRICAL DASH PANEL AND LIGHTS IN TRUCK HARDLY EVER WORK. THE TRUCKS DEPENDABILITY AT MOMENT ISN'T GREAT DUE TO THESE ISSUES. CAN'T AFFORD A NEW TRUCK AT TIME BEING .. THIS TRUCK TRANSPORTS MY TODDLERS AROUND. THIS TYPICALLY HAPPENS WHEN TURNING ON CAR AND OPENING DOORS WE NEVER SEE LIGHTS ON. IT DOES HAPPEN ALSO WHEN DRIVING AT RANDOM TIMES. NOT SURE IF IT HAS ANYTHING TO DO WITH STOPPING OR TURNING. WILL HAPPEN AT ANY RATE OF SPEED.

NHTSA complaint #11128177 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

SMART JUNCTION BOX FAILED. CAUSING INTERIOR, DASH AND BACK LIGHTS NOT TO LIGHT AND INCLUDING THE HORN NOT TO WORK. WHEN TRYING TO REPLACE THE FUSE IT WOULD BLOW THE FUSE AND SMOKE. IT IS IN THE SHOP NOW TO HAVE THE SMART JUNCTION BOX REPLACED. FUSES STARTED BLOWING. AT FIRST IT WAS THE RADIO AND THE FUSE WAS REPLACED THEN THE OTHERS STARTED TO BLOW.

NHTSA complaint #11044742 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2006 FORD F-150. AFTER TAKING THE VEHICLE TO A DRIVE THRU CAR WASH SERVICE, WATER ENTERED THE PASSENGER SIDE. THE INTERIOR OF THE PASSENGER SIDE BECAME WET AND THE AIR BAG WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

NHTSA complaint #10934613 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 15 MPH, THE VEHICLE MADE A LOUD POPPING NOISE AND THE INSTRUMENT PANEL BECAME INOPERABLE. IN ADDITION, THE REAR WINDOWS AND POWER LOCKS FAILED TO OPERATE AND THE VEHICLE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 150,000.

NHTSA complaint #10884754 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

AFTER COUNTLESS HOURS SPENT DIAGNOSING A DASH BRAKE LITE WARNING. THESE VEHICLES FACTORY DEFECT IS THE ELECTRONICS BOARD OR SPEEDOMETER CLUSTER. COUNTLESS PEOPLE ARE DRIVING WITH A BRAKE LIGHT ON WITH NOTHING POSSIBLY WRONG.WHEN SOMETHING DOES GO WRONG THEY MAY NOT HAVE A CLUE UNTIL THE VEHICLE HAS NO BRAKES.

NHTSA complaint #10872470 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

WHILE DRIVING INSTRUMENT PANAL SHUTS DOWN, RADIO SHUTS OFF, AIRBAG INDICATOR COMES ON, WINDOWS DON'T WORK, IF SHUT OFF LASTS MORE THAN 5 MINUTES SEAT BELT CHIME GOES OFF, TWICE WORD TEST CAME ON IN MILEAGE INDICATOR WINDOW. SOMETIMES GOES ON AND OFF WHILE TURNING OR HITTING BRAKES, OTHER TIMES JUST WHILE DRIVING.

NHTSA complaint #10787572 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

SPARK PLUGS ON THE 5.3 LITER ENGINE WHEN REPLACED BREAK--IN RETURN THE BOOK SAID PULL ENGINE AND PULL HEADS TO REPLACE SPARK PLUGS. THE LAW SUIT FILLED FORD ADMITS TO BAD DECISION ON SPARK PLUGS AND WILL REIMBURSE SOME OF THE COST. THE COST IS VERY HIGH--THE BOOK AND FORD'S SHOP SAID THE ENGINE NEEDS TO BE PULLED TO PULL THE HEADS TO REPLACE THE SPARK PLUGS. THERE WAS NEVER ANY SOFTWARE UPDATES, AND NOW THE VEHICLE REQUIRES THEM. THE ERROR IN THE CLUSTER SOFTWARE RECALL WAS SUPPOSE TO BE REPAIRED AND I READ FROM THE EXPERTS ALL SOFTWARE SHOULD HAVE BEEN UPGRADED WITH THE CLUSTER ERROR. THERE ARE 42 P.M. FORD AND NHSTA KNEW OR KNOWS ABOUT ON MY VEHICLE AND NOTHING HAS BEEN DONE, I AM A 100% DAV AND MY VEHICLE HAS BEEN BROKEN DOWN. THE 2006 HARLEY DAVIDSON F-150 THAT COST SO MUCH WITH IT'S ON BOARD COMPUTER SYSTEM DOES NOT WORK. I HAVE READ MANY COMPLAINTS ABOUT THE F-150 ENGINE CUTTING OUT, I PULLED OUT TO PASS ON A TWO LANE ROAD AND ALMOST GOT KILLED WHEN MINE CUT OUT SO BAD. A TWO CYLINDER WOULD HAVE DONE BETTER THAN THAT V-8.

NHTSA complaint #10776527 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING AT 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO A MECHANIC WHERE IT WAS DISCOVERED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. AFTER THE VEHICLE WAS REPAIRED, THE FAILURE CONTINUED WITH A TICKING NOISE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

NHTSA complaint #10761499 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

IN JUNE 2015, THE AIR BAG LIGHT IN MY FORD F150 ILLUMINATED, INDICATING A PROBLEM. I TOOK MY VEHICLE TO A FORD DEALERSHIP. THEY TOLD ME THAT THE DEPLOYABLE RESTRAINT SYSTEM, SPECIFICALLY THE PRETENSIONER, HAD MALFUNCTIONED AND POSSIBLY WOULD FAIL TO FUNCTION AS INTENDED IN THE EVENT OF A CRASH. THE SERVICE TECHNICIAN INDICATED THAT THE RESTRAINT SYSTEM IS CONNECTED TO MY AIR BAGS, WHICH MIGHT FAIL TO WORK IN A CRASH, INCREASING THE RISK OF INJURY. AFTER PAYING THE DIAGNOSTIC FEE, I WAS GIVEN A REPAIR ESTIMATE OF AN ADDITIONAL $392.21. NOT WANTING TO RISK INJURY IN THE EVENT OF A CRASH, I HAD THE PRETENSIONER REPLACED. THE BUCKLE PRETENSIONER IS A CRITICAL SAFETY DEVICE THAT SHOULD NEVER FAIL UNDER NORMAL USE. MY VEHICLE HAS NEVER BEEN IN AN ACCIDENT. IT IS MY UNDERSTANDING THAT SOME PRETENSIONERS HAVE FAILED DUE TO SIMPLE SEAT POSITION ADJUSTMENTS, WHICH, TO ME, IS EVIDENCE OF A POOR DESIGN. FORD HAS RECENTLY RECALLED MANY 2013 ' 2014 VEHICLES FOR POORLY MADE PRETENSIONERS, RECOGNIZING THE SAFETY ISSUE SURROUNDING THEM. I REQUESTED THAT FORD REIMBURSE ME FOR THE COST OF THE PRETENSIONER BUCKLE; HOWEVER, FORD DENIED THIS REQUEST. I HAVE THE ORIGINAL PRETENSIONER AND ALL RECEIPTS AVAILABLE.

NHTSA complaint #10758652 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

MORNING OF JULY 23,2015, I WAS DRIVING ABOUT 25 MPR SPEED WHEN NUMBER THREE SPARK PLUG BLOW OUT OF THE CYLANDERHEAD ON MY F-150 TRITON V8. TOOK IT TO THE LOCAL MACHANIC SHOP WALTON'S. THREE HOURS LATER, WALTON'S HAD TO REPLACE AND RESLEEVE NUMBER THREE CYLANDERHEAD AND REPLACED ELECTRICAL SPARKPLUG WIRE, PLUS REPLACED ALL EIGHT SPARK PLUGS. ALL AT A COST OF $543.00. NOT ONLY THIS HAPPENED TO ME BUT WALTON'S STATED THAT I WAS THE 10TH PERSON THIS WEEK THIS HAS HAPPENED TOO. I PRESENTED THE PART TO MY LOCAL FORD DEALERSHIP WHERE WE BOUGHT THE TRUCK (HALL'S FORD MOTOR COMPANY) BRAND NEW IN 2006 AND PAID CASH TO THE SUM OF $30,000.00. I ASKED THEM IF THEY KNOW OF THIS PROBLEM WITH TRITON V8'S. THEY STATED THEY DID BUT NO KNOW RECALLS AND THEY TOO HAD SEVERAL REPAIRS COME IN FOR THE SAME THING IN THE PASS WEEK. THEY ALSO STATED THAT THE FORD MOTOR COMPANY WAS AWARE OF THIS MATTER BUT NEVER LET THERE CUSTOMERS KNOW ABOUT THIS PROBLEM YET BECAUSE THERE WAS NO RECALL ON FILE TO LET THEM KNOW. THIS THING WHERE THE SPARK PLUGS COME FLYING OUT OF AN ENGINE CAN BE VERY HAZARDS, IT COULD CAUSE A CRASH OR EVEN GIVE A PERSON A HEART ATTACK BECAUSE THE TRUCK SOUNDS LIKE WORLD WAR III GOING OFF UNDER THE HOOD AND IT MAY EVEN START A FIRE. THIS MATTER NEEDS TO BE TAKEN CARE OF BY FORD.

NHTSA complaint #10747937 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE. WHILE AT THE INDEPENDENT MECHANIC, THE CONTACT WAS NOTIFIED THAT SEVEN OF THE EIGHT SPARK PLUGS IN THE VEHICLE WERE FRACTURED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT ONE OF THE FRACTURED SPARK PLUGS REMAINED IN THE CYLINDER HEAD. THE MECHANIC STATED THAT THE CYLINDER HEAD HAD TO BE REMOVED FROM THE ENGINE TO REMOVE THE FRACTURED SPARK PLUG. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE; HOWEVER, THE CONTACT WAS NOT OFFERED A REMEDY FOR THE FAILURE. THE FAILURE MILEAGE WAS 84,000.

NHTSA complaint #10733630 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

FORD'S IWE SOLENOID HAS A TENDENCY TO MALFUNCTION DUE TO A POOR DESIGN. TSB 06-8-15 WAS ISSUED TO REPLACE THESE SOLENOIDS, BUT ONLY IF THERE WAS A PROBLEM AND ONLY IF IT WAS GIVING A PROBLEM. MY VEHICLE WAS IN STORAGE FOR 5 YEARS AND AFTER IT WAS BROUGHT OUT AND TO NY, THE WATER LEAKED ON THE SOLENOID DUE TO THE INADEQUATE DESIGN, CAUSING THE IWE'S TO MALFUNCTION. I STILL DON'T KNOW WHAT EXACTLY IT DID BUT DRIVING THE CAR DOWN THE ROAD, IT CAUSED ME TO FEEL LIKE I WAS DRIVING OVER SMALL SPEED BUMPS WITH THE FRONT DRIVERS SIDE TIRE. I'M AFRAID THAT IF THIS FAILED AT A HIGH RATE OF SPEED IT COULD CAUSE THE IWE TO ENGAGE AND POSSIBLY LOCK UP ONE OF THE FRONT TIRES.

NHTSA complaint #10681530 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

VEHICLE STARTED LOSING POWER AND UNABLE TO RUN CORRECTLY. TOOK TO GARAGE AND FUEL PUMP DRIVE MODULE WAS RUSTED WITH CIRCUITS BEING EXPOSED TO THE SALT AND MOISTURE ELEMENTS WHERE THERE WAS A LARGE HOLE IN BACK OF UNIT. NEW ONE WAS INSTALLED WITH SPACERS TO HELP PREVENT SALT AND MOISTURE FROM COLLECTING WHERE BACK OF MODULE MOUNTS ONTO AXLE BRACKET. VEHICLE RAN BETTER BUT ALSO HAD TO INSTALL NEW COIL DUE TO A CYLINDER MISSING. RUNS OK WITH WORK THAT WAS PERFORMED. MODULE SHOULD NOT HAVE BEEN INSTALLED AGAINST THE BRACKET SO SALT AND MOISTURE COULD COLLECT AND RUST IT SO BADLY AND CAUSE IT TO FAIL. FORD SHOULD PAY FOR THIS REPAIR DUE TO THE WAY IN WHICH THE MODULE WAS INSTALLED SO IT WOULD RUST SO BADLY.

NHTSA complaint #10680168 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE FAILED TO ACCELERATE AND THE SERVICE VEHICLE WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT A SENSOR WAS FAULTY. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 89,069. UPDATED 04/10/15*LJ UPDATED 11/5/2015

NHTSA complaint #10676932 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

THE ELECTRIC WINDOWS AND DOOR LOCKS AND MIRROR ADJUSTMENTS ALL STOPPED WORKING ON MY 2006 F150. AFTER DOING SOME LOOKING I FOUND THAT THE WIRE HARNESS THAT RUNS TO THE DOOR HAS MOST OF THE WIRES BROKEN OR BREAKING IN HALF THUS LEAVING BARE WIRES EXPOSED AND A POSSIBLE FIRE HAZARD THE WAY IT LOOKS TO ME.

NHTSA complaint #10631076 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

WENT TO STOP FOR TRAFFIC LIGHT APPLIED THE BRAKES AND VEHICLE TOOK OFF///////SLAMMED ON BRAKES TO TRY TO STOP AND SLAMMED IN PARK .CAME WITH IN INCHES OF CRASHING INTO CAR IN FRONT OF ME. TODAY IS SEPT.1ST HAVE NOT DRIVEN TRUCK AGAIN////// CALL FORD CORP. THEY WILL NOT PAY TO CHECK OUT TRUCK. AT 3100 MILES HAD TO REPLACE TIRES. ORIG. HAD DRY ROT,,,,,,

NHTSA complaint #10629943 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

ALL THE GAUGES IN MY TRUCK STOPPED WORKING. FIRST THE SPEEDOMETER THEN ALL THE GAUGES. AT FIRST THEY JUST FLUCTUATED THEN THEY ALL STOPPED. THEN THE LIGHTS STARTED FLASHING ON AND OFF INSIDE THE VEHICLE. THEN THE FUEL SENSOR WARNING STARTED BEEPING FOLLOWED BY THE SEATBELT BEEPER. OCCASIONALLY THE ENTIRE DASH GOES BLANK FOLLOWED BY A TEST SCREEN ON THE DASH. ALL INTERIOR ELECTRICAL SYSTEMS SHUT OFF FOR ABOUT TWO TO THREE SECONDS THEN COME BACK ON WHILE DRIVING. VERY WORRIED THAT THE VEHICLE WILL JUST STOP WHILE DRIVING.

NHTSA complaint #10595714 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

WENT TO START TRUCK AND ENGINE WOULD CRANK BUT WOULD NOT FIRE. I TRIED THE STARTING FLUID TEST TO SEE IF IT WAS AN IGNITION PROBLEM OR FUEL PROBLEM. GAVE A LITTLE SHOT OF STARTING FLUID INTO THE INTAKE AND THEN TRIED TO START. MOTOR ACTED LIKE IT WAS GOING TO START BUT NEVER STARTED BEINGS I DIDN'T GIVE IT ENOUGH STARTING FLUID TO START BECAUSE I'M NOT A FAN OF USING IT. WITH THAT I ELIMINATED THE IGNITION HAD TO BE FUEL. I GOT ON THE INTERNET AND SEARCHED NO START PROBLEM FOR 2006 F-150 AND FOUND A YOU TUBE VIDEO OF THE FUEL PUMP CONTROL MODULE RUSTING OUT. WENT OUT AND DROPPED SPARE TIRE AND TOOK THE CONTROL MODULE OFF THE CROSS MEMBER AND NOTICED THE HOLE CORRODED THROUGH THE HOUSING JUST LIKE THE VIDEO. I GOT THE UPGRADED PART FROM A FORD DEALER FOR $163 AND INSTALLED. RUNS FINE NOW. MY BIGGEST COMPLAINT IS FORD KNOWS THERE'S A PROBLEM SINCE THE HAVE CAME OUT WITH AN UPGRADED CONTROL MODULE SO WHY ISN'T THIS A RECALL? I LIVE IN A STATE THAT TEMPERATURES IN THE WINTER MONTHS CAN BE BELOW 0 DEGREES FAHRENHEIT AND DRIVE AN HOUR ONE WAY TO WORK, THIS COULD HAVE HAPPENED WHEN I WAS ON THE ROAD IN EXTREME COLD, COULD OF HAD MY TWO CHILDREN WITH ME BROKE DOWN ON THE SIDE OF THE ROAD AND COLD OUT. LUCKILY IT HAPPENED AT HOME BUT STILL IT WAS 4 DEGREES OUT AND LAYING UNDER MY TRUCK TAKING THE MODULE OFF WAS NOT VERY PLEASANT. THINK THIS IS SOMETHING THAT FORD NEEDS TO DO SOMETHING ABOUT.

NHTSA complaint #10561160 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

WHILE APPROACHING A STOP THE TRUCK GAUGES STARTED GOING CRAZY. TRUCK STALLED BUT RESTARTED WITH GAUGES STILL ACTING CRAZY. ALL GAUGES WOULD BOTTOM OUT AND COME BACK UP AND RADIO WAS TURNING ON AND OFF. REPLACED BATTERY BUT ONLY STALLING ISSUE WAS RESOLVED. TOOK TO LOCAL FORD DEALER BUT SINCE THE TRUCK ONLY DOES THIS RANDOMLY, THEY WERE NOT ABLE TO DIAGNOSE THE PROBLEM. TRUCK RUNS PERFECTLY BUT GAUGES AND RADIO STILL GO ON AND OFF MAKING IT EXTREMELY ANNOYING TO DRIVE. VERY FRUSTRATING TO KNOW THAT SO MANY OTHER FORD OWNERS HAVE THE SAME PROBLEM BUT NO SOLUTION HAS BEEN OFFERED FROM FORD.

NHTSA complaint #10544648 — an unverified report by a vehicle owner.