Owners have filed 742 complaints
about the 2006 Ford F-150 with NHTSA between 2005 and 2026.
The largest single group is the engine & cooling.
Across this model's run it ranks 17 of 33 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 26
Against the median year of the Ford F-150. 50 means typical for this
model; 100 means roughly double.
Severity — 94
18.2% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 52
31% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
2828.0%
Engine
2020.0%
Frontal
1111.0%
Pedals AND Linkages
99.0%
Power Window Devices AND Controls
99.0%
Hoses, Lines/Piping, AND Fittings
88.0%
Automatic Transmission
88.0%
Exhaust System
77.0%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
375.8%
1,000 – 9,999 miles
538.4%
10,000 – 24,999 miles
6710.6%
25,000 – 49,999 miles
10316.2%
50,000 – 74,999 miles
11918.8%
75,000 – 99,999 miles
9515.0%
100,000 – 149,999 miles
11217.7%
150,000+ miles
487.6%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Nov 2005peak 13Aug 2026
NHTSA investigations into the 2006 Ford F-150
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
EA10001Opened 13 Jan 2010Closed 25 Apr 2011AIR BAGS
Inadvertent airbag deployment
ODI opened this investigation based on reports of inadvertent airbag deployment.Data provided by Ford indicated that the airbag clockspring jumper wire, which is situated inside the steering wheel assembly, was installed in a manner that would allow it to rub (abrade) against a sharp metal edge on the nearby horn plate.Because the horn plate is electrically grounded the abrasion of an airbag wire on the sharp edge could cause a short circuit condition.As a result the airbag light may illuminate and/or the airbag may inadvertently deploy.Inadvertent deployments are most likely to occur during t...
PE08001Opened 8 Jan 2008Closed 9 May 2008SERVICE BRAKES, HYDRAULIC:POWER ASSIST
LOSS OF BRAKE POWER-ASSIST
BY LETTER DATED MAY 5, 2008, FORD MOTOR COMPANY (FORD) NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-208) TO ADDRESS A MANUFACTURING DEFECT IN APPROXIMATELY 605,684 MODEL YEAR (MY) 2005 AND 2006 FORD F-150 AND LINCOLN MARK LT VEHICLES ORIGINALLY EQUIPPED WITH THE 5.4L DISPLACEMENT, 3-VALVE PER CYLINDER, V-8 ENGINE.THE RECALLED VEHICLES WERE BUILT FROM JULY 18, 2004 THROUGH MAY 31, 2006 AT THE DEARBORN TRUCK PLANT; FROM MAY 4, 2004 THROUGH MAY 31, 2006 AT THE KANSAS CITY ASSEMBLY PLANT; AND FROM APRIL 19, 2004 THROUGH MAY 31, 2006 AT THE NORFOLK TRUCK PLANT.T...
Recalls on the 2006 Ford F-150
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
11V107000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
Risk: THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
09E025000
EXTERIOR LIGHTING:HEADLIGHTS
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
09E012000
EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
08V208000
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
Risk: ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
07E089000
EXTERIOR LIGHTING:HEADLIGHTS
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
07E080000
EXTERIOR LIGHTING:HEADLIGHTS
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
07E075000
EXTERIOR LIGHTING:HEADLIGHTS
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
07E066000
EQUIPMENT:ELECTRICAL
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Risk: IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 20110738,780 units in Canada
Airbag
On certain vehicles, the airbag clockspring jumper wire may be oriented in a way that allows contact with the lower horn mounting plate. In this position the wire insulation may chafe, exposing bare copper, and creating the potential for a short circuit. Should this occur, the airbag warning lamp will illuminate, indicating service is required. In some instances, the driver's airbag could inadvertently deploy. Inadvertent deployment in a non-collision (non-impact) situation may create expensive vehicle repair, including replacement of the driver's airbag module. In some instances, inadvertent deployment could cause minor injuries to vehicle occupants. Correction: Dealers will install an updated clockspring jumper wire which incorporates a protective mesh cover.
Recall 200815450,017 units in Canada
Brakes
On certain vehicles equipped with a 5.4L 3-valve engine, the brake booster vacuum supply hose attached to the intake manifold fitting may swell over time and lose retention force. This could allow the hose to become detached from the fitting during an intake manifold backfire. Should this occur, the driver would only have a few brake applications with power booster assist before the vacuum reserve is depleted. When this happens, foundation brake function would be retained, but will require increased pedal effort. Extended stopping distances may result in a vehicle crash, causing property damage, and/or personal injury or death.. Correction: Dealers will replace the vacuum hose.
Recall 200603217,390 units in Canada
Brakes
Certain vehicles were built with a software error in the instrument cluster. This error could prevent the Antilock Brake System (ABS) warning light from illuminating if the ABS module ever became inoperative. Correction: Dealers will recalibrate the instrument cluster.
Recall 200535613,581 units in Canada
Other
On certain vehicles, the windshield wiper motor may have been produced without grease applied to the output shaft gear. After a period of continuous use on the high-speed setting, lack of grease may cause the gear teeth to distort and/or fracture during operation, resulting in the loss of wiper function. Correction: Dealers will inspect and, if required, apply grease to the output shaft gear.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 200,000 milesAkron, ALCrash
AIR BAGS
The contact owns a 2006 Ford F-150. The contact stated that while the contact's son was driving at an undisclosed speed, there was an abnormal sound coming from the vehicle. No warning lights were illuminated. The contact's son lost control of the vehicle, and the vehicle crashed into a guardrail and landed on its side. The air bags did not deploy. The vehicle was towed to a local tow yard. A Police report was filed; the information was unavailable. No injuries were sustained. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,000. The VIN was unavailable.
NHTSA complaint #11743778 — an unverified report by a vehicle owner.
Oakland, CACrash2 injured
AIR BAGS
I WAS RECENTLY INVOLVED IN AN ACCIDENT IN MY VEHICLE. IT WAS A HEAD ON COLLISION AND MY AIRBAG DID NOT FULLY DEPLOY. THOUGH I WAS TRAVELLING THE SPEED LIMIT, HAD I BEEN ON A FREEWAY AND GOING THE LEGAL SPEED LIMIT I THINK I MIGHT HAVE BEEN SERIOUSLY INJURED. THE LIBABLE INSURANCE COMPANY ENCOURAGED ME TO CONTACT FORD TO SEE IT THIS HAS BEEN AN ISSUE. THERE WERE NOT WARNING LIGHTS OR ANY OTHER SYMPTOMS PRIOR TO THE ACCIDENT.
NHTSA complaint #11720023 — an unverified report by a vehicle owner.
at 174,000 milesVancouver, WAFire
ENGINE
The contact owned a 2006 Ford F-150. The contact stated that while driving at a low rate of speed, an abnormal, popping sound emitted from the vehicle without warning. Soon after he heard the sound, the vehicle caught fire. The contact exited the vehicle and attempted to extinguish the fire with two fire extinguishers. The fire department was called to the scene and they managed to extinguish the fire. No injuries were reported and a police report was not filed. The vehicle was towed to an independent mechanic where it remained in their possession. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle was deemed a total loss. The failure mileage was 174,000.
NHTSA complaint #11526009 — an unverified report by a vehicle owner.
Renton, WACrash1 injured
TIRES:BEAD
5:30 pm 4/12/21 was driving home from umpiring a baseball game, drove threw intersection when suddenly I was thrown into passenger seat of my truck, the next thing I know im stopped in front of a tree with a telephone pole on the hood of my truck with no idea what or how this happened. I was lucky no one was coming the opposite direction on the 2 lane road cause I wouldn't have been able to control truck even at 40mph, another 5min and I would have been on the interstate going 65mph and surely I'd be dead. After a week I was able to go out and look at my truck thats when I noticed the flat front passenger tire was flat and the inner ring of the rim came off. I had an accident investigator look at it , I hired a lawyer and a metallurgical expert to examine rim. There was no warning the rims were still new.
NHTSA complaint #11457926 — an unverified report by a vehicle owner.
at 203,344 milesBelleville, ILCrash
SUSPENSION
IT WAS HARD TO STOP
NHTSA complaint #11387300 — an unverified report by a vehicle owner.
at 203,344 milesBelleville, ILCrash
SERVICE BRAKES
IT WAS HARD TO STOP
NHTSA complaint #11387300 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Mark Center, OH
STRUCTURE:BODY
The dealership sold this vehicle to me with a rusted frame
NHTSA complaint #11754518 — an unverified report by a vehicle owner.
at 200,000 milesAkron, ALCrash
AIR BAGS
The contact owns a 2006 Ford F-150. The contact stated that while the contact's son was driving at an undisclosed speed, there was an abnormal sound coming from the vehicle. No warning lights were illuminated. The contact's son lost control of the vehicle, and the vehicle crashed into a guardrail and landed on its side. The air bags did not deploy. The vehicle was towed to a local tow yard. A Police report was filed; the information was unavailable. No injuries were sustained. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,000. The VIN was unavailable.
NHTSA complaint #11743778 — an unverified report by a vehicle owner.
Ceiba, PR
UNKNOWN OR OTHER
The problem is that the paint in the cargo area is peeling or fading, and I think that problem is a factory defect. That part of the cargo area is galvanized, I need to know if that is in a recall, thank you.
NHTSA complaint #11729958 — an unverified report by a vehicle owner.
Roanoke, VA
VISIBILITY/WIPER
Around the 1st of February 2026 the weather had turned cold around 6 degrees Fahrenheit and I had just had my vehicle inspected in January so I know everything was fine then. My wife and I had driven to her office about 2 miles from our home and I of course had the heat on and defrost on. We went into the office to clean because that a weekly job for us usually under an hour. When we came out my windshield was cracked on the passenger side starting at the bottom going straight up about 8” long. The weather stayed cold and a few days later it cracked more and then more and then more. It’s moving over towards the drivers side horizontally about eye level. There is no rock strike where the crack started, it seems to me that when heat was applied to the windshield something expanded or contracted or flexed while we were inside the office because it was cracked when we came out to leave. I haven’t taken it to a Ford dealership to have it looked at or filed an insurance claim. It’s been about two months now I need to get it fixed before the whole windshield collapses into my lap. I realize the safety issue with a cracked windshield and it could cause me and others on the road to get hurt. I’ve only driven it to doctors appointments and to pick up medication at the store a mile away. I’ve never had a vehicle that has had the windshield crack due to clod weather when it was heated up and then cooled back down. Either the glass was manufactured incorrectly or it was installed incorrectly or the framing expanded or contracted causing it to bind the glass. If you could please look into this for me it would be greatly appreciated.
NHTSA complaint #11727945 — an unverified report by a vehicle owner.
Oakland, CACrash2 injured
AIR BAGS
I WAS RECENTLY INVOLVED IN AN ACCIDENT IN MY VEHICLE. IT WAS A HEAD ON COLLISION AND MY AIRBAG DID NOT FULLY DEPLOY. THOUGH I WAS TRAVELLING THE SPEED LIMIT, HAD I BEEN ON A FREEWAY AND GOING THE LEGAL SPEED LIMIT I THINK I MIGHT HAVE BEEN SERIOUSLY INJURED. THE LIBABLE INSURANCE COMPANY ENCOURAGED ME TO CONTACT FORD TO SEE IT THIS HAS BEEN AN ISSUE. THERE WERE NOT WARNING LIGHTS OR ANY OTHER SYMPTOMS PRIOR TO THE ACCIDENT.
NHTSA complaint #11720023 — an unverified report by a vehicle owner.
Robertsdale, AL
ENGINE
Received notification by mail from your department about a recall on my trucks spark plugs breaking in the head .Took vehicle to local ford dealer and was told the vehicle was required to have over 100 thousand miles before the plugs would be replaced under recall . Now my vehicle has over 150 thousand miles and when I went to the same dealer I was told there wasn’t a recall on this truck . My documents I received from your department was lost during hurricane Sally. This is a well known recall every local mechanic knows about .
NHTSA complaint #11692320 — an unverified report by a vehicle owner.
Odometer Fraud. The contact sold a 2006 Ford F-150. The contact stated that the vehicle was sold with approximately 212,000 miles but later discovered that the buyer had relisted the vehicle for sale with an advertised mileage of 135,713. The vehicle was a private sale. Local authorities had been notified.
NHTSA complaint #11656585 — an unverified report by a vehicle owner.
Billings, MT
POWER TRAIN
while in drive, accelerating to highway speeds or cruising around 30 mph it will downshift and jump to about 4000 PMS's and not shift up into 3rd gear. It blown 1 engine and I have replaced the transmissions, taken it to a Ford dealership and they weren't able to help me. I've replaced the ECM and anti-theft modal also and the symptoms still persist. i am i in for over 11K for the new engine and transmission, and another $100 on the ECM and anti-theft modal plus the shop charges. The truck has under 190,000 miles before any of this started. I am the 2nd owner an had for less than 3k miles before any of the problems started. Now I see the 2015-2017 F-150s are having the same problems getting recalled. is there anything involving the earlier Triton's engines?
NHTSA complaint #11651426 — an unverified report by a vehicle owner.
Billings, MT
ELECTRICAL SYSTEM
while in drive, accelerating to highway speeds or cruising around 30 mph it will downshift and jump to about 4000 PMS's and not shift up into 3rd gear. It blown 1 engine and I have replaced the transmissions, taken it to a Ford dealership and they weren't able to help me. I've replaced the ECM and anti-theft modal also and the symptoms still persist. i am i in for over 11K for the new engine and transmission, and another $100 on the ECM and anti-theft modal plus the shop charges. The truck has under 190,000 miles before any of this started. I am the 2nd owner an had for less than 3k miles before any of the problems started. Now I see the 2015-2017 F-150s are having the same problems getting recalled. is there anything involving the earlier Triton's engines?
NHTSA complaint #11651426 — an unverified report by a vehicle owner.
at 145,000 milesMorgan Hill, CA
SERVICE BRAKES, HYDRAULIC
The contact owns a 2006 Ford F-150. The contact stated that while coming to a stop, the brake pedal was depressed but failed to function as intended. The contact stated that the vehicle failed to stop and continued rolling forward. The contact stated that the vehicle came to a stop once the brake pedal was depressed to the floorboard. No warning lights were illuminated. The contact stated that the vehicle returned to normal function afterwards. The local dealer was contacted; however, the dealer refused to diagnose the vehicle because of its age of the vehicle. The vehicle was not repaired. The contact stated that on a separate occasion, while the contact's husband was driving at a slow speed, the brake pedal was depressed but failed to function as intended. The contact stated that the vehicle failed to stop and continued rolling forward. The contact's husband stated that the vehicle came to a stop once the brake pedal was depressed to the floorboard. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 145,000.
NHTSA complaint #11651318 — an unverified report by a vehicle owner.
Billings, MT
ENGINE
while in drive, accelerating to highway speeds or cruising around 30 mph it will downshift and jump to about 4000 PMS's and not shift up into 3rd gear. It blown 1 engine and I have replaced the transmissions, taken it to a Ford dealership and they weren't able to help me. I've replaced the ECM and anti-theft modal also and the symptoms still persist. i am i in for over 11K for the new engine and transmission, and another $100 on the ECM and anti-theft modal plus the shop charges. The truck has under 190,000 miles before any of this started. I am the 2nd owner an had for less than 3k miles before any of the problems started. Now I see the 2015-2017 F-150s are having the same problems getting recalled. is there anything involving the earlier Triton's engines?
NHTSA complaint #11651426 — an unverified report by a vehicle owner.
Staten Island, NY
STRUCTURE:FRAME AND MEMBERS
See attached document for complaint.
NHTSA complaint #11628862 — an unverified report by a vehicle owner.
Staten Island, NY
STRUCTURE
See attached document for complaint.
NHTSA complaint #11628862 — an unverified report by a vehicle owner.
at 138,000 milesJefferson, WI
STRUCTURE:FRAME AND MEMBERS
The contact owns a 2006 Ford F-150. The contact stated while the vehicle was parked, the contact became aware that the middle sub frame structure was severely rusted. The local dealer was not contacted, and the vehicle was not inspected or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 138,000.
NHTSA complaint #11601609 — an unverified report by a vehicle owner.
at 230,774 milesBirmingham, AL
ENGINE AND ENGINE COOLING
The contact owns a 2006 Ford F-150. The contact stated that while driving at various speeds, the vehicle lost motive power with an abnormal popping sound coming from the engine compartment. The failure occurred more often while attempting to accelerate or driving uphill. The vehicle occasionally stalled during the failure. The contact released the accelerator pedal slowly and the vehicle then started driving normally. There were no warning lights illuminated. The vehicle was taken to the dealer where it was diagnosed and determined that the cam phaser had failed and needed to be replaced. The vehicle was not repaired due to the cam phaser part no longer being manufactured. The contact stated that the part was no longer in production because the replacement part was defective and failed to fix the vehicle. The contact was informed by the dealer that a newer version of the cam phaser needed to be purchased and was not covered under warranty. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that the repair was not covered under the Warranty. The contact was referred to the NHTSA Hotline to file a complaint. The failure mileage was 230,774.
NHTSA complaint #11589276 — an unverified report by a vehicle owner.
New Orleans, LA
ENGINE
The vehicle will hesitate once it comes to a stop after several hesitations it would just shut down you have to keep restarting it, the restart get harder and harder.
NHTSA complaint #11582411 — an unverified report by a vehicle owner.
Bensalem, PA
POWER TRAIN
Rotted and bent frame realized after purchase on February 22 at nj car and driver (Cadillacs Plus) for $3500.00 Continues to stall and feels like it’s going to crack in two. Stalled a few times while driving and had to put it in neutral to start back up
NHTSA complaint #11575216 — an unverified report by a vehicle owner.
Bensalem, PA
STRUCTURE:BODY
Rotted and bent frame realized after purchase on February 22 at nj car and driver (Cadillacs Plus) for $3500.00 Continues to stall and feels like it’s going to crack in two. Stalled a few times while driving and had to put it in neutral to start back up
NHTSA complaint #11575216 — an unverified report by a vehicle owner.
Bensalem, PA
ENGINE
Rotted and bent frame realized after purchase on February 22 at nj car and driver (Cadillacs Plus) for $3500.00 Continues to stall and feels like it’s going to crack in two. Stalled a few times while driving and had to put it in neutral to start back up
NHTSA complaint #11575216 — an unverified report by a vehicle owner.
at 124,000 milesSpringfield, WV
STRUCTURE:FRAME AND MEMBERS
The contact owns a 2006 Ford F-150. The contact stated that the vehicle was towed to an independent mechanic to replace the starter, the mechanic observed corrosion on the frame near both rear doors. Additionally, the mechanic noticed that the sub frame was bent near the rear doors. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 124,000.
NHTSA complaint #11544577 — an unverified report by a vehicle owner.
at 124,000 milesSpringfield, WV
STRUCTURE:BODY
The contact owns a 2006 Ford F-150. The contact stated that the vehicle was towed to an independent mechanic to replace the starter, the mechanic observed corrosion on the frame near both rear doors. Additionally, the mechanic noticed that the sub frame was bent near the rear doors. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 124,000.
NHTSA complaint #11544577 — an unverified report by a vehicle owner.
Gilbert, SC
TIRES
Tire is dry rotting at the sidewall all around. 32 x 12.5
NHTSA complaint #11536454 — an unverified report by a vehicle owner.
at 174,000 milesVancouver, WAFire
ENGINE
The contact owned a 2006 Ford F-150. The contact stated that while driving at a low rate of speed, an abnormal, popping sound emitted from the vehicle without warning. Soon after he heard the sound, the vehicle caught fire. The contact exited the vehicle and attempted to extinguish the fire with two fire extinguishers. The fire department was called to the scene and they managed to extinguish the fire. No injuries were reported and a police report was not filed. The vehicle was towed to an independent mechanic where it remained in their possession. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle was deemed a total loss. The failure mileage was 174,000.
NHTSA complaint #11526009 — an unverified report by a vehicle owner.
at 165,000 milesGarden City, MI
STRUCTURE:FRAME AND MEMBERS
The contact owns a 2006 Ford F-150. The contact stated that the subframe was rusted and the rear driver’s and passenger’s side doors. Additionally, the wheel well was rusted. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 165,000.
NHTSA complaint #11502329 — an unverified report by a vehicle owner.
Glen Burnie, MD
STEERING
When is some one going to do something about the faulty steering column in 2006 Ford F150 pick ups and similar model years? It is all over the internet about the grinding and catching of the steering column. In some cases can't steer at all. There is tons of information on this problem. I have a 2006 Ford F150. It is starting with the problem and it only has 82,000 miles. This should not be happening some one is going to get hurt or killed !
NHTSA complaint #11501366 — an unverified report by a vehicle owner.