1999 Ford F-350 transmission problems

POWER TRAIN

TAKATA RECALL. I WAS DRIVING DOWN THE ROAD AND MY TRUCK SHUT OFF RANDOMLY MY OVERDRIVE LIGHT STARTED FLASHING AFTER THIS AND CONTINUED TO FLASH AND STILL SHUTS OFF SO I REPLACED MY FUEL FILTER, CPS SENSOR AND IT STILL SHUTS OFF. IT'S LIKE I'M GOIN DOWN THE ROAD AND IT STALLS. IT DOES IT MORE THAN ONCE WHEN I'M DRIVING I JUST SHUT IT OFF AND START IT AGAIN.

NHTSA complaint #11111085 — an unverified report by a vehicle owner.

POWER TRAIN:AXLE ASSEMBLY

TL* THE CONTACT OWNS A 1999 FORD F-350. WHILE THE VEHICLE WAS AT THE DEALER FOR ROUTINE MAINTENANCE, THE MECHANIC INDICATED THAT THE REAR AXLE WAS FAULTY AND WOULD NEED TO BE REPLACED. ALTHOUGH THE VEHICLE HAD NOT EXPERIENCED ANY FAILURES, THE REAR AXLE WAS REPLACED. THE CONTACT INDICATED THAT APPROXIMATELY 30,000 MILES, LATER THE MECHANIC INDICATED THAT THE REAR AXLE WAS FAULTY AGAIN AND THE AXLE WAS REPLACED A SECOND TIME. AFTER HAVING THE AXLE REPLACED, THE CONTACT WAS UNABLE TO SHIFT TO THE SIXTH GEAR WHILE DRIVING APPROXIMATELY 65 MPH. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 363,000. UPDATED 7/14/15*CN UPDATED 10/16/2017

NHTSA complaint #10716116 — an unverified report by a vehicle owner.

POWER TRAIN

LARGE AMOUNT OF TRANSMISSION FLUID LEAKED OUT ON DRIVEWAY MAKING TRUCK UNABLE TO DRIVE.

NHTSA complaint #10605850 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

WHEN ACCELERATING VEHICLE SLIPPED GEAR OR JERKED FORWARD. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM.

NHTSA complaint #10103252 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

THE VEHICLE'S CLUTCH MECHANISM FAILED WHILE DRIVING. AS A RESULT THE VEHICLE WAS UNABLE TO COME TO AN COMPLETE STOP. PLEASE PROVIDE ANY ADDITIONAL INFORMATION.

NHTSA complaint #10064832 — an unverified report by a vehicle owner.

POWER TRAIN

DEFECTIVE TRANSMISSION IN 1999 F350 SERIES TRUCKS. *MR THE CONSUMER REPLACED THE FIRST TRANSMISSION WHILE THE VEHICLE WAS STILL UNDER WARRANTY, AT THE TIME, FORD INSTALLED A RE-MANUFACTURED TRANSMISSION PER COMPANY POLICY. FOR THAT TRANSMISSION THE CONSUMER PURCHASED AN EXTENDED WARRANTY. ALMOST ONE YEAR LATER A SECOND TRANSMISSION WAS PLACED IN THE VEHICLE. ANOTHER FORD DEALER IN IOWA STATED THAT THE RE-MANUFACTURED TRANSMISSION WAS DEFECTIVE FROM THE START AND THAT A PART OF IT WAS EGGING WHEN IT SHOULD HAVE BEEN ROUND. THE POWER STEERING PUMP HAD TO BE REPLACED WITHIN THE FIRST 2K MILES. THE CONSUMER REQUESTED THAT FORD SHOULD COVER THE COST SPENT ON THE REPAIR(S). *SCC

NHTSA complaint #10044155 — an unverified report by a vehicle owner.

POWER TRAIN

THE VEHICLES GEAR SHIFT BROKE OFF THE TRANSMISSION. *NLM

NHTSA complaint #10012241 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

VEHICLE WOULD ROLL IN PARKING GEAR. DEALER SAID THAT BEARINGS IN TRANSMISSION WERE WORN COMPLETELY OUT LETTING GEARS BYPASS EACH OTHER. DAMAGE WAS ALSO DONE TO THE TRANSMISSION INTERNAL CASING AND THE GEARS PICTURES ARE AVAILABLE. DEALER PICKED UP 1/2 OF REPAIR COST. HE SAID HE HAD NEVER SEEN THIS PROBLEM BEFORE. DT

NHTSA complaint #770325 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

CONSUMER HAS DIFFICULTY GETTING THE TRANSMISSION INTO GEAR AND WHEN SHIFTING, WHEN THE TRANSMISSION DOES SHIFT GEARS, THERE IS A GRINDING NOISE, THE FREE PLAY IN THE CLUTCH IS ALWAYS DIFFERENT, SOMETIMES THE CLUTCH WOULD ENGAGE WHEN THE CLUTCH PEDAL WAS NEAR THE TOP , OTHER TIMES THE CLUTCH WOULD ENGAGE WHEN THE CLUTCH PEDAL WAS PUSHED ALL THE WAY. THE CONSUMER WAS INFORMED THAT THERE WAS A 6 INCH PIECE OF RUBBER HYDRAULIC HOSE IN THE HYDRAULIC LINE OF THE CLUTCH ASSEMBLY, SO WHEN THE VEHICLE WAS WARMED UP, IT EXPANDED INSTEAD OF STAYING RIDGED. FORD IS AWARE OF THE PROBLEM AND UPDATED THE CLUTCH ASSEMBLY, HOWEVER, THE CONSUMER WAS TOLD THAT PROBLEM IS CONSIDERED A WEAR ITEM. *JB *SCC

NHTSA complaint #8021542 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

WE FEEL THIS TRUCK IS A LEMON AND WE WANT SOMEONE TO BE RESPONSIBLE FOR WHAT WE HAVE GONE THROUGH WITH THIS TRUCK, WE HAVE HAD NOTHING BUT TROUBLE WITH IT, IT IS UNRELIABLE.NO SAFETY DEFECT LISTED.

NHTSA complaint #765951 — an unverified report by a vehicle owner.

POWER TRAIN:AXLE ASSEMBLY

WE FEEL THIS TRUCK IS A LEMON AND WE WANT SOMEONE TO BE RESPONSIBLE FOR WHAT WE HAVE GONE THROUGH WITH THIS TRUCK, WE HAVE HAD NOTHING BUT TROUBLE WITH IT, IT IS UNRELIABLE.NO SAFETY DEFECT LISTED.

NHTSA complaint #765951 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

WHILE CLUTCH IS FULLEY DEPRESSED AND IN GEAR VEHICLE WILL TAKE OFF.CONTACTED DEALER. REPLACED PART, BUT PROBLEM REOCCURRED.

NHTSA complaint #8016661 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

THE TRANSMISSION SHIFTS HARD AND IS UNPREDICTABLE. NLM

NHTSA complaint #565475 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

WHILE DRIVING ON A FLAT SURFACE AT 15MPH, THE VEHICLE LOST ITS CLUTCH. MAKING IT HARD TO STOP THE VEHICLE. DEALER NOTIFIED. *AK THE CONSUMER STATED THAT THE ROLL PIN THAT HOLDS THE HYDRAULIC LINE TO THE SLAVE CYLINDER ON THE CLUTCH HAD COME OUT AND THE LINE DROPPED DOWN. (NO CLUTCH) *SCC

NHTSA complaint #8015732 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

VEHICLE WAS AT A COMPLETE STOP AND MANUAL CLUTCH WENT OUT. VEHICLE LURCHED FORWARD THROUGH A RED LIGHT.*AK.

NHTSA complaint #8012282 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

PLASTIC SPACER IN CLUTCH ASSEMBLY BROKE, CAUSING CLUTCH TO MALFUNCTION. PLEASE PROVIDE FURTHER INFORMATION.

NHTSA complaint #8011796 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

CLUTCH WAS REPLACED AT 40000 MILES, IT NEEDS TO BE REPLACED AGAIN. MANUFACTURER/DEALER HAVE BEEN NOTIFIED. *AK *SCC

NHTSA complaint #8011800 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

LOW CLUTCH ENGAGEMENT CAUSING THE CLUTCH TO RELEASE WITH PEDAL AGAINST DOWN STOP OR NOT TO RELEASE AT ALL. HAD TRUCK TOWED FOR SAFETY REASONS. WHEN THE CLUTCH DOESN'T RELEASE THIS COULD CAUSE AN ACCIDENT AND FAILURE TO BE ABLE TO STOP VEHICLE WHEN CLUTCH GOES ALL THE WAY TO THE FLOOR AND NOT DISENGAGE CLUTCH.

NHTSA complaint #8011111 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

CAB OF THE TRUCK VIBRATED VERY HARD AT ANY SPEED. TOOK TO MECHANIC AND THEY REPLACED TORQUE CONVERTER, THEN HUB, STILL SAME PROBLEM. TOOK TO FORD, FORD REPLACED TIRES, STILL SHAKING. THEN, THEY REPLACED DRIVESHAFT, STILL SHOOK. DEALER DID NOT KNOW WHAT THE PROBLEM WAS. PLEASE PROVIDE ANY FURTHER INFORMATION.

NHTSA complaint #8009239 — an unverified report by a vehicle owner.

POWER TRAIN:AXLE HUBS

CAB OF THE TRUCK VIBRATED VERY HARD AT ANY SPEED. TOOK TO MECHANIC AND THEY REPLACED TORQUE CONVERTER, THEN HUB, STILL SAME PROBLEM. TOOK TO FORD, FORD REPLACED TIRES, STILL SHAKING. THEN, THEY REPLACED DRIVESHAFT, STILL SHOOK. DEALER DID NOT KNOW WHAT THE PROBLEM WAS. PLEASE PROVIDE ANY FURTHER INFORMATION.

NHTSA complaint #8009239 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE:DRIVESHAFT

CAB OF THE TRUCK VIBRATED VERY HARD AT ANY SPEED. TOOK TO MECHANIC AND THEY REPLACED TORQUE CONVERTER, THEN HUB, STILL SAME PROBLEM. TOOK TO FORD, FORD REPLACED TIRES, STILL SHAKING. THEN, THEY REPLACED DRIVESHAFT, STILL SHOOK. DEALER DID NOT KNOW WHAT THE PROBLEM WAS. PLEASE PROVIDE ANY FURTHER INFORMATION.

NHTSA complaint #8009239 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

TRANSFER CASE SHIFTING FORK WORE OUT. TRUCK HAD ONLY BEEN IN FOUR WHEEL DRIVE ABOUT A DOZEN TIMES ALL IN SNOW CONDITIONS ON MAJOR HIWAYS. NO OFFROADING AT ALL. HAD TO REPLACE THE SHIFTING FORK, A PLANETARY GEAR AN A IMPUT SHAFT. THIS WAS THE ONLY WAY FORD WOULD SELL THE REPACEMENT PARTS. FORD HAS MADE A DESIGN CHANGE ON THE SHIFTING FORK.

NHTSA complaint #760241 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

TRANSFER CASE SHIFTING FORK WORE OUT. TRUCK HAD ONLY BEEN IN FOUR WHEEL DRIVE ABOUT A DOZEN TIMES ALL IN SNOW CONDITIONS ON MAJOR HIWAYS. NO OFFROADING AT ALL. HAD TO REPLACE THE SHIFTING FORK, A PLANETARY GEAR AN A IMPUT SHAFT. THIS WAS THE ONLY WAY FORD WOULD SELL THE REPACEMENT PARTS. FORD HAS MADE A DESIGN CHANGE ON THE SHIFTING FORK.

NHTSA complaint #760241 — an unverified report by a vehicle owner.

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT

TRANSFER CASE SHIFTING FORK WORE OUT. TRUCK HAD ONLY BEEN IN FOUR WHEEL DRIVE ABOUT A DOZEN TIMES ALL IN SNOW CONDITIONS ON MAJOR HIWAYS. NO OFFROADING AT ALL. HAD TO REPLACE THE SHIFTING FORK, A PLANETARY GEAR AN A IMPUT SHAFT. THIS WAS THE ONLY WAY FORD WOULD SELL THE REPACEMENT PARTS. FORD HAS MADE A DESIGN CHANGE ON THE SHIFTING FORK.

NHTSA complaint #760241 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION:COLUMN SHIFT ASSEMBLY

CONSUMER STATES WHILE DRIVING IN HOT WEATHER THE VEHICLE IS HARD TO SHIFT, THIS PROBLEM ALSO OCCURS OCCASIONALLY WHEN THE WEATER IS NOT HOT, AS A RESULT THE DRIVER HAS TO SHUT THE ENGINE OFF BEFORE AN ACCIDENT OCCURS. NLM

NHTSA complaint #8006376 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

CLUTCH PEDAL WILL NOT RETURN WHEN APPLIED. VEHICLE TAKEN TO DEALER, AND WAS INFORMED OF A YOKE FAILURE. REPAIRS WERE MADE AT CONSUMER'S COST. DEALER STATED THAT THIS IS NOT AN UNCOMMON PROBLEM. REPLACEMENT PARTS WERE FROM FORD, CONSUMER IS CONCERNED WHY FAILED YOKE IS NOT A MANUFACTURER DEFECT. *AK

NHTSA complaint #897189 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

WHENEVER DRIVING AT VARIOUS SPEEDS CLUTCH WOULD GO OUT. WOULD HAVE NO PRIOR WARNING. HAD TAKEN TO DEALERSHIP AT LEAST 4 TIMES, AND CLUTCH HAS BEEN CHANGED 4 TIMES. THERE ISN'T ANY INDICATION OF CAUSE OF PROBLEM. IT STILL EXISTS.

NHTSA complaint #896382 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

CLUTCH HYDRAULIC RELEASE SYSTEM FAILED CATASTROPHICALLY, CAUSING VEHICLE TO JUMP FORWARD IMMEDIATELY AND VIOLENTLY. FORTUNATELY THE CAR IN FRONT OF ME WAS FAR ENOUGH AWAY SO THAT I DIDN'T HIT IT, BEFORE GETTING VEHICLE STOPPED. ON INVESTIGATION, I FOUND THAT THE ROLL PIN WHICH HOLDS THE CLUTCH LINE INTO THE SLAVE CYLINDER HAD BACKED OUT, AND ALLOWED THE HIGH PRESSURE LINE TO DISCONNECT. WHEN THIS HAPPENED, THE CLUTCH ENGAGED VIOLENTLY, AND THE VEHICLE LURCHED FORWARD ON ENGINE POWER. THIS COULD HAVE CAUSED A MAJOR ACCIDENT, IF ANY OF THE CIRCUMSTANCES HAD BEEN DIFFERENT.

NHTSA complaint #751188 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

THE PARKING BRAKE WILL NOT HOLD WELL ON AN INCLINE. THIS IS ESPECIALLY NOTICED IN REVERSE, AS ON A BOAT RAMP WITH A BOAT THAT I AM TRYING TO LAUNCH. I CAN SET THE BRAKE AS HARD AS I CAN AND THE TRUCK WILL STILL ROLL BACK AGAINST THE PARKING PALL IN THE AUTOMATIC TRANSMISSION. IT BECOMES VERY DIFFICULT TO THEN SHIFT THE TRANSMISSION INTO GEAR. THE DEALER HAS LOOKED AT IT TWICE AND STATED THAT THEY DON'T SEE A PROBLEM BUT THEY CANNOT DUPLICATE THE CONDITIONS.

NHTSA complaint #750263 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

VEHICLE STALLS AT ANY SPEED/ ANY TIME. TAKEN TO DEALER NUMEROUS TIMES, CANNOT REMEDY SITUATION. *AK ALSO, TRANSMISSION JERKS WHEN SHIFTING GEARS.

NHTSA complaint #893273 — an unverified report by a vehicle owner.