1999 Ford F-350 fuel system problems

FUEL/PROPULSION SYSTEM

TAKATA RECALL. I WAS DRIVING DOWN THE ROAD AND MY TRUCK SHUT OFF RANDOMLY MY OVERDRIVE LIGHT STARTED FLASHING AFTER THIS AND CONTINUED TO FLASH AND STILL SHUTS OFF SO I REPLACED MY FUEL FILTER, CPS SENSOR AND IT STILL SHUTS OFF. IT'S LIKE I'M GOIN DOWN THE ROAD AND IT STALLS. IT DOES IT MORE THAN ONCE WHEN I'M DRIVING I JUST SHUT IT OFF AND START IT AGAIN.

NHTSA complaint #11111085 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

01/2016: VEHICLE WAS BEING DRIVEN HOME FROM WORK WHEN THERE WAS A LOSS OF ENGINE POWER. VEHICLE WAS ABLE TO ROLL TO A STOP IN THE PARKING LOT OF A CHURCH. LATER IT WAS DETERMINED THIS RESULTED FROM FAILURE OF #7 CYLINDER INJECTOR UNIT, BELIEVED TO HAVE FAILED DUE TO DELAMINATION INSIDE OF FUEL TANK. ABOUT 02/23/2014, 207980 MILES: FUEL TANK HAD BEEN REMOVED AND INTERNAL SCREENS CLEARED DUE TO THE ENGINE STALLING WHILE DRIVING PRIOR TO INJECTOR FAILURE. INTERNAL PICK-UP TUBE SCREENS WERE BLOCKED WITH DELAMINATION MATERIAL FROM THE INSIDE OF THE TANK. TWO NEW FUEL PUMPS HAD BEEN PURCHASED AND INSTALLED PRIOR TO CLEANING THE INTERNAL PICK-UP SCREENS. I HAVE RECEIPTS FOR WORK AND PARTS RELATING TO THE FUEL SYSTEM PROBLEM.

NHTSA complaint #10936826 — an unverified report by a vehicle owner.

FUEL SYSTEM, DIESEL

01/2016: VEHICLE WAS BEING DRIVEN HOME FROM WORK WHEN THERE WAS A LOSS OF ENGINE POWER. VEHICLE WAS ABLE TO ROLL TO A STOP IN THE PARKING LOT OF A CHURCH. LATER IT WAS DETERMINED THIS RESULTED FROM FAILURE OF #7 CYLINDER INJECTOR UNIT, BELIEVED TO HAVE FAILED DUE TO DELAMINATION INSIDE OF FUEL TANK. ABOUT 02/23/2014, 207980 MILES: FUEL TANK HAD BEEN REMOVED AND INTERNAL SCREENS CLEARED DUE TO THE ENGINE STALLING WHILE DRIVING PRIOR TO INJECTOR FAILURE. INTERNAL PICK-UP TUBE SCREENS WERE BLOCKED WITH DELAMINATION MATERIAL FROM THE INSIDE OF THE TANK. TWO NEW FUEL PUMPS HAD BEEN PURCHASED AND INSTALLED PRIOR TO CLEANING THE INTERNAL PICK-UP SCREENS. I HAVE RECEIPTS FOR WORK AND PARTS RELATING TO THE FUEL SYSTEM PROBLEM.

NHTSA complaint #10936826 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

DRIVING MY 1999 FORD F350 DIESEL DOWN THE HIGHWAY, APPROXIMATELY 50 MPH, HEARD A THUMP AND LOUD SCRAPING NOISE. COULD NOT PULL OVER DUE TO TRAFFIC, PULLED OVER WHEN TRAFFIC CLEARED, AROUND ANOTHER 100 FEET. I GOT OUT AND LOOKED AROUND AND UNDER TRUCK, TO DISCOVER FUEL TANK WAS DRAGGING ALONG THE HIGHWAY. REAR FUEL TANK STRAP HAD BROKEN.

NHTSA complaint #10630896 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 1999 FORD F-350. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, THE MECHANIC NOTICED THAT THE FUEL STRAPS WERE DISCONNECTED AND COVERED WITH RUST. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 122,000. UPDATED 10/28/2014*LJ UPDATED 04/21/2015

NHTSA complaint #10626562 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

REAR FUEL TANK STRAP THAT HOLDS THE FUEL TANK IN POSITION FAILED. IN 2003 FORD HAD A RECALL ON THIS TRUCK TO INSTALL SAFETY STRAPS AROUND THE FUEL TANK IN CASE THERE WAS A FAILURE OF THE MAIN STRAPS. WHEN THE REAR STRAP FAILED THE SAFETY STRAP FAILED AND THE ONLY THING HOLDING THE TANK IN THE TRUCK WAS THE FUEL LINE. THE TANK WAS ABOUT 3/4 FULL IF IT HAD SEPARATED ALL TOGETHER IT WOULD HAVE BEEN A DISASTER AND PROBABLY A FIRE.

NHTSA complaint #10435373 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

TL* THE CONTACT OWNS A 1999 FORD F-350 PICK UP. THE CONTACT WAS DRIVING 60 MPH WHEN THE FUEL STRAPS DETACHED FROM THE FUEL TANK. THE VEHICLE WAS TOWED TO DEALER WHERE THE DEALER CONFIRMED THAT BOTH FUEL TANK STRAPS WERE RUSTED AND NEEDED REPLACEMENT. THE MANUFACTURER WAS CONTACTED AND THEY CONFIRMED THE VIN DID NOT QUALIFY FOR RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 99V311000 ( FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY). THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 121,000 AND THE CURRENT MILEAGE WAS 124,000.

NHTSA complaint #10432847 — an unverified report by a vehicle owner.

FUEL SYSTEM, DIESEL

FUEL DRAIN O RING FAILS ALLOWING FUEL LEAKAGE DURING OPERATION IN FORD AMBULANCES F350 BUILT IN 1999.

NHTSA complaint #10168598 — an unverified report by a vehicle owner.

FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP

THE LEFT REAR WHEEL SEPARATED FROM THE VEHICLE, WHICH CAUSED THE VEHICLE JERK FOWARD. *JB THE CONSUMER REQUESTED AN 03 VEHICLE OR REIMBURSEMENT FOR THE INCIDENTAL EXPENSES. AFTER THE PURCHASE OF THE VEHICLE, THE MANUAL, LOCKABLE HUB(S) BEGAN TO FAIL. THE DEALER CONVINCED THE CONSUMER(S) TO PURCHASE 8 PLY TIRES, BUT THIS DIDN'T REDUCE THE NOISE OR HUB PROBLEMS, THE CONSUMER ALSO EXPERIENCED ACCELERATION PROBLEM'S. THE DEALER COULDN'T FIND THE PROBLEM. THE ENGINE IDLED ROUGH AND THE ENGINE LIGHT HAD COME ON. A BAD CAM SENSOR WAS FOUND, AND A SOUND HAD COME FROM THE FUEL PUMP. AN ADAPTER TO THE METAL PLATE WAS BUILT IN, EXTENDING FROM THE UNDERDASH, TO THE FIREWALL, TO PROVIDE A BETTER GROUND SYSTEM. SCC

NHTSA complaint #10012068 — an unverified report by a vehicle owner.

FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP

CONSUMER STATES HE HAS PUT 6 FUEL PUMP ON HIS TRUCK SINCE 1999. HE ALSO STATES THAT THE FIRST PUMP LASTED APPROX 40,000 MILE, THE 2ND ON E LASTED UP TO 60,000 MILES, AND THE REST OF THEM HE CANNOT REMEMBER. HE STATES THAT THE LAST PUMP WAS PUT ON NOV 19 OR 20TH AND LASTED ONLY 10 DAYS. HE STATED TOO, THAT WHEN THE PUMPS GOES OUT HIS TRUCK STOPS AND IF HE IS ON THE MOUNTAIN OR ON A HILL, HE CANNOT BREAK OR STOP THE TRUCK BECAUSE OF THE WEIGHT THAT HE CARRIES. HE CARRIES STEEL AND IT IS HEAVY. HE STATES THAT THIS IS SCARRY, AND NOBODY SEEM TO BE ABLE TO HELP HIM.

NHTSA complaint #10001075 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

RECEIVED SAFETY RECALL REGARDING FUEL TANK ASSEMBLY. TOOK VEHICLE IN. CALLED DEALER TO CHECK ON VEHICLE . DEALER INDICATED VEHICLE REPAIRS ALMOST DONE. COUPLE HOURS LATER, CALLED DEALER BACK AND DEALER INDICATED DID NOT HAVE PARTS. HAD TO TAKE VEHICLE BACK WHEN PARTS CAME IN.*AK

NHTSA complaint #8007474 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:STORAGE:AUXILLARY TANK:SELECTOR DEVICES

OWNER HAS DUAL FUEL TANKS. IF FRONT TANK DOES NOT STAY FULL GAS FROM REAR TANK GOES INTO FRONT TANK. FRONT TANK RECEIVES GAS FROM REAR TANK, AND IF GAS CAP IS OPENED, FUEL WILL SPRAY OUT. DEALER HAS NOT SEEN VEHICLE.

NHTSA complaint #882327 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

FUEL PUMP HAD BEEN BLOWING FUSES. DEALERS CONTACTED STATED PART (FUEL PUMP) WAS ON NATIONAL BACK ORDER WITH A 4 TO 6 WEEK DELAY. FUEL PUMP DIED COMPLETELY AT NIGHT WHILE ON AN INTERSTATE HIGHWAY IN OKLAHOMA. FORD THEN REPLACED THE FUEL PUMP THE NEXT DAY.

NHTSA complaint #741142 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

NHTSA RECALL 99V311000 AND MANUFACTURER'S RECALL 99S32/ FMVSS 301- FUEL SYSTEM INTEGRITY. PARTS WERE NOT AVAILABLE.

NHTSA complaint #860031 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

FUEL LINE WORN, CAUSED BY RUBBING AGAINST ANOTHER FUEL LINE, RESULTING IN LEAKAGE. *MJS

NHTSA complaint #9000197 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

WHILE TRAVELING WITH FRIENDS AND HORSES, AT HIGHWAY SPEEDS(65) THE FUEL GUAGE WAS SHOWING A LITTLE OVER A QUARTER AND THE TRIP COMPUTER WAS STILL SHOWING ABOUT 60 MILES TO EMPTY. THE TRUCK SPUTTERED AND ENGINE STALLED. IT WAS OUT OF FUEL. AFTER TRYING TO GET FORD ROADSIDE ASSISTANCE - WHO SAID WAIT 5-6 HRS TILL MORNING AND WE'LL GET SOMEONE OUT, AND AAA WHO DOESN'T TRANSPORT FUEL - ONLY GAS. THE NC HP WAS CONTACTED AND THEN TRANSPORTED TO TRUCK STOP AND BACK TO TRUCK WITH FUEL - THEN TRUCK RAN FINE.

NHTSA complaint #719193 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

DEALER REFUSED TO REPAIR NHTSA RECALL 99V311000/MANUFACTURER'S RECALL 99S32 BECAUSE OF A FIFTH WHEEL ON THIS VEHICLE. *AK

NHTSA complaint #857379 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

DEALER CLAIMS CANNOT PERFORM RECALL # 99S32 BECAUSE BRACKET FOR FIFTH WHEEL INTERFERS WITH RECALL.

NHTSA complaint #855145 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

ENGINE DIED WHILE TRAVELING WITH WIFE AND SMALL CHILDREN IN TRUCK ON FREEWAY. FOLLOWING ENGINE FAILURE, BRAKES AND STEERING BECAME VERY DIFFICULT TO MANAGE WHILE COASTING OFF OF FREEWAY ONTO EXIT. TWO OF THESE INSTANCES OCCURRED WHILE DRIVING ON FREEWAY WITHIN 2 MONTHS OF EACH OTHER. ENGINE BEGAN SPUTTERING AND THEN DIED COMPLETELY WITHIN 10 SECONDS. THE TRUCK HAD TO BE TOWED TO SHAMROCK FORD IN DUBLIN AFTER EACH INCIDENT AND NO REPLACEMENT VEHICLE WAS OFFERED. AFTER BEING FIXED THE 1ST TIME THERE WAS A NOTICABLE LACK OF POWER AND FUEL CONSUMPTION INCREASED, LEADING TO THE SECOND FAILURE. I AM VERY FRUSTRATED THAT THE 40,000 DOLLAR "DREAM TRUCK" I PURCHASED IS A PILE OF UNRELIABLE JUNK. I BOUGHT A 5TH WHEEL TRAILER TO USE WITH THIS TRUCK AND IT IS SO UNRELIABLE THAT I AM AFRAID TO TOW IT ANYWHERE. I WILL NOT ALLOW MY WIFE, WHO WEIGHS 110 LBS, TO TAKE THE KIDS ANYWHERE FOR FEAR THAT SHE WOULD NOT BE ABLE TO CONTROL THE VEHICLE IF THIS OCCURRED AGAIN. DO I HAVE ANY RECOURSE? THANK YOU, TONY ZWETSLOOT

NHTSA complaint #717362 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

CONSUMER NOT COVER UNDER RECALL DUE TO VIN FOR THE FUEL TANK VAPOR RECOVERY VALVE (99V-311). *NLM

NHTSA complaint #549977 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM

AIR CLEANER PICKS UP DIRT PARTICULES FROMTHE LEFT FRONT TIRE, AND SHOULD BE SUCKING AIR OUT OF THE RADIATOR. DEALER WAS CONTACTED, AND STATED THAT WITHOUT A RECALL NUMBER THEY WOULD DO NOTHING ABOUT IT.

NHTSA complaint #853926 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

WHEN DRIVING THE VEHICLE STALLS AND DIES. THE DEALER HAS REPLAED TWO FUEL PUMPS .

NHTSA complaint #846407 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM

1. THE ENGINE IS STARVED OF AIR WHEN DRIVEN ON SNOW AND ICE. SNOW GETS PACKED IN THE AIR CLEANER BOX AND FREEZES. THE AIR INTAKE IS PULLED FROM THE WHEEL WELL. 2. ROAD DEBRIS AND ROCKS LOAD UP THE BOTTOM OF ALL DOORS. WEATHERSTRIPPING IS REQUIRED.

NHTSA complaint #704839 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

FUEL FILTER FAILURE RESULTED IN HIGH PRESSURE FUEL LEAK THAT FLOODED THE ENGINE COMPARTMENT WITH DIESEL FUEL. APPROXIMATELY 10 TO 12 GALLONS PUMPED FROM TANK AT HIGH PRESSURE, AND SPRAYED ALL OVER ENGINE AND ENGINE COMPARTMENT. PROBLEM WAS NOT NOTICED AFTER PICKING VEHICLE UP FROM ROUTINE SERVICE. NOTICED PUNGENT ODOR WHICH INTENSIFIED AS I WAS DRIVING HOME. DEALER STATED THEY DID NOT SERVICE FUEL FILTER. WHEN VEHICLE WAS PICKED TO BE RETURNED TO THE DEALER, DIESEL FUEL CAME SPILLING OFF THE TOP OF THE ENGINE. DIESEL FUEL HAS PENETRATED THE VENTILATION SYSTEM AND GOT ALL OVER FRONT SUSPENSION PARTS REMOVING PAINT FROM THESE PARTS. FAILURE OF FUEL FILTER AND RESULTANT LEAK COULD HAVE RESULTED IN A FIRE, THANK GOD IT DID NOT HAPPEN (NOTE- FUEL LEAK WAS OCCURING WHILE I WAS DRIVING HOME). WILL BE HAPPY TO DISCUSS THIS ISSUE VIA TELEPHONE TO GIVE MORE DETAILS.

NHTSA complaint #703553 — an unverified report by a vehicle owner.