37 of the 170 complaints about the 2005 Ford F-350 are about the fuel system — 22% of everything reported for this model year. Half of the failures with a mileage on record happened before 98,000 miles.
37
Complaints
0
Crashes
1
Fires
0
Injuries
Filed with NHTSA, in their own words.
FUEL/PROPULSION SYSTEM
The all very common issues with the year f350 and the 6.0 l. Engines, are as such. The malfunctioning FICM. THE high and low oil coolers, the inter coolers and head studs. Also leaking break fluid .
NHTSA complaint #11462783 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WHILE DRIVING DOWN THE HIGHWAY(45-55MPH) VEHICLE DASH LIGHTS, RADIO, WINDOWS ALL STOP WORKING. THEY COME BACK ON RANDOMLY. NO CHANGE TO LITTLE CHANGE WHEN RE-STARTING. VEHICLE ALSO LOSES POWER AND THE ENGINE SEEMS TO PAUSE AND GO, OVER AND OVER LIKE IT'S STRUGGLING. I'VE TAKEN IT TO SEVERAL FORD CERTIFIED MECHANICS WHO ARE BAFFLED.
NHTSA complaint #11229388 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FICM AND ICP SENSOR. I WOULD BE DRIVING DOWN THE ROAD AND MY VEHICLE WOULD CUT OFF ON ME WHILE ON THE STREET. IT WOULD TAKE ABOUT FIFTEEN MINUTES OR MORE TO START BACK UP(HOT START). I'VE ONLY HAD THE VEHICLE FOR A YEAR.
NHTSA complaint #11115659 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
THE GAS TANK HAS A DEFECT IT EPOXY LINER IN GAS TANK CORRODES AND PLUGS UP THE FILTER EJECTOR AND SHUT TRUCK DOWN AND RUST OUT FILTERS. THE TRUCK WAS BEEN DRIVEN WHEN IT SHUT DOWN , TOOK TRUCK TO FORD DEALER, WAS TOLD GAS TANK IS ERODED AND HAS PLUG UP SYSTEM INCLUDING INJECTORS, WILL BE $8000.00 TO FIX, THAT THERE WASNT A CURRENT RECALL ON ITEM, BUT THAT FOR KNOW PROBLEM EXIST.
NHTSA complaint #11022343 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING APPROXIMATELY 65 MPH, THE ENGINE SEIZED WITHOUT WARNING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO LEIF JOHNSON FORD (501 E KOENIG LN #1, AUSTIN, TX 78751 (512) 454-3711) WHERE IT WAS DIAGNOSED THAT THE FUEL LINER IN THE FUEL TANK CAUSED THE VEHICLE TO SEIZE. THE FUEL TANK WAS CORRODED AND CLOGGED THE INJECTORS. THE CONTACT STATED THAT THE FUEL TANK, FUEL INJECTORS, AND FUEL FILTERS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ACKNOWLEDGED THE FAILURE, STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL, AND DID NOT OFFER ANY FURTHER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
NHTSA complaint #11022350 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED TO START. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL INJECTION CONTROL MODULE, SENSOR, AND TURBO HOSES FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. A DEALER WAS NOT CONTACTED. ALSO, WHILE DRIVING 30 MPH, THE ENGINE BEGAN TO REV AND THE CONTACT HAD TO BRAKE TO STOP THE VEHICLE FROM SURGING FORWARD AND COLLIDING WITH THE PRECEDING VEHICLE. THE VEHICLE CONTINUED TO SURGE AS THE CONTACT DROVE. THE CONTACT PULLED OVER AND TURNED OFF THE VEHICLE. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE INJECTION CONTROL PRESSURE SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF BOTH FAILURES AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
NHTSA complaint #11012498 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
CAME UP WITH A CODE TO REPLACE T.P.S. I REPLACED TPS NOW VEHICLE IS HAVING PROBLEMS IDLING . I CONTACTED FORD EXPLAINED TO THEM MY SITUATION. I WAS TOLD BY 3 DIFFERENT PEOPLE THAT WHENEVER PEOPLE WITH A 6.8 V10 HAVE THE CODE TO REPLACE T.P.S THEY END UP REPLACING THE WHOLE E.T.B. IS THERE A RECALL FOR THE THROTTLE BODY ?
NHTSA complaint #10992214 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE WALKING TOWARDS THE PARKED VEHICLE, THE CONTACT NOTICED THAT THE REAR PORTION OF THE FUEL TANK WAS SEPARATED FROM THE FRAME DUE TO A RUSTED FUEL TANK STRAP. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 174,000.
NHTSA complaint #10928997 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
POWER SURGE. STOPPED WAITING AT LIGHT FELT LIKE I WAS HIT FROM BEHIND, VERY QUICK UNEXPECTED SURGE FORWARD, IT ALSO OCCRURES WHILE DRIVING BUT THE EFFECT IS NOT STRONG, MORE NOTICEABLE WHEN BACKING.
NHTSA complaint #10894949 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
CPSC: 2005 F-350. CONSUMER STATED THE 6.0 DIESEL MOTOR IS NO LONGER WORKING DUE TO A BUILDUP IN THE GAS TANK, OR OIL SYSTEM. *SS THE CONSUMER STATED AFTER THE VEHICLE WAS FIXED, IT BROKE DOWN AGAIN.
NHTSA complaint #10838357 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
I HAVE A 2005 FORD F350 DIESEL POWERSTROKE THAT HAS THE FUEL TANK LINING FALLING OFF AND ITS GOTTEN TO MY FUEL LINES AND FUEL PUMP CAUSING THE TRUCK TO COME TO A COMPLETE STOP WHILE I WAS DRIVING DOWN THE FREEWAY HAULING A 12FT TRAILER WITH A 10000 LBS TRACTOR ON IT. I HAD TO GET IT TOWED TO A SHOP WHERE THEY REPLACED THE FUEL PUMP AND FILTERS. ONE MONTH LATER IT DID THE SAME THING WHILE ON THE HIGHWAY AGAIN IT JUST DIED THE MECHANIC SAYS MY FUEL TANK IS THE PROBLEM THE LINING INSIDE THE FUEL TANK IS CHIPPING AWAY AND IT HAS GOTTEN TO THE FUEL SYSTEM AGAIN THIS IS A FREQUENT PROBLEM WITH FORD DIESEL TANKS AND THEY WONT TAKE RESPONSIBILITY. THIS SECOND TIME AROUND I AM HAVING TO REPLACE FUEL INJECTORS AND THE FILTERS AGAIN.
NHTSA complaint #10676166 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING 65 MPH, THE VEHICLE DECELERATED ON ITS OWN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL SYSTEM NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,900.
NHTSA complaint #10670065 — an unverified report by a vehicle owner.
FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP
TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE ENGINE STALLED WITHOUT WARNING. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER ON SEVERAL OCCASIONS WHERE IT WAS DIAGNOSED THAT THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. ON ANOTHER OCCASION THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS DIAGNOSED THAT THE PRESSURE UNIT FOR THE DIESEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.
NHTSA complaint #10643953 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE ENGINE STALLED WITHOUT WARNING. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER ON SEVERAL OCCASIONS WHERE IT WAS DIAGNOSED THAT THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. ON ANOTHER OCCASION THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS DIAGNOSED THAT THE PRESSURE UNIT FOR THE DIESEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.
NHTSA complaint #10643953 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I HAVE A 40 FT TOY HAULER I PULL WITH THE F350, GOING UP HILL AND ALL SYSTEMS FAIL. BUT LEFT ON THE SIDE OF THE MOUNTAIN RD I WAS TRAVELING. A FUEL RAIL IS DISCOVED GONE BAD, BILLOWS OF WHITE SOME PRIOR TO SYSTEM SHUT DOWN. $2800.00 REPAIR. TWO WEEKS LATER ANOTHER MOUNTAIN PASS TRUCK OVER HEATS CAUSING SYSTEM FAILURE. COME TO FIND OUT $10,000 DOLLARS LATER IN REPAIRS ALONE NOT, TALKING HOTEL, RENTAL CAR, AND DELAY OF TRIP FOR NINE DAYS. BUT THE PHIL LONG FORD DEALERSHIP NEW ABOUT THE COSTLY REPAIRS AND FAILS TO INFORM CUSTMOR.. LEADING HIM TOO A TOTAL OF $7300.00 IN REPAIRS. TOTAL REPAIRS $10,100. THANKS PHIL LONG FORD, COLORADO SPRINGS, FOR NOT INFORMING CUSTOMERS OF THE COSTLY REPAIRS BUT KNOWING THEY WHERE THERE. DRAGING HARD WORKING AMERICANS THOUGH THE DIRT... GREAT BUNCH OF GUYS. NOT...
NHTSA complaint #10595441 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
TL* THE CONTACT OWNS A 2005 FORD F350. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE FUEL FILTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 55,000.
NHTSA complaint #10555448 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 FORD F-350 SUPER DUTY. THE CONTACT STATED WHILE AT A STOP LIGHT THE VEHICLE STALLED. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER OR A LOCAL MECHANIC. THE CONTACT CALLED THE MANUFACTURER REGARDING THE NHTSA CAMPAIGN NUMBER 05V266000 (FUEL SYSTEM); HOWEVER, THEY STATED THE VEHICLE DID NOT HAVE ANY RECALLS. THE FAILURE MILEAGE WAS 172,456.
NHTSA complaint #10547566 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
MERGED ON TO MCFARLAND BLVD. WITH SOUTH BOUND TRAFFIC TRUCK LOST POWER COULD NOT CONTROL VEHICLE OTHER TRAFFIC ALMOST RAN INTO THE TRUCK.HAD TRUCK TOWED TO DIESEL SHOP.COLUMBUS DIESEL SERVICE FOUND PAINT CHIPS IN FILTER REMOVED FUEL TANK ,COATING OF THE TANK WAS COMING OFF AND ENTERING THE FUEL SYSTEM THIS IS THE FACTORY TANK THAT CAME WITH THE TRUCK..
NHTSA complaint #10534606 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
TL* THE CONTACT OWNS A 2005 FORD F350 SUPER DUTY. THE CONTACT STATED THAT THE VEHICLE STALLED NUMEROUS TIMES WITHOUT WARNING WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES FOR THE FAILURE. THE DEALER REPLACED THE FUEL INJECTORS, THE TURBO CHARGER WAS REPLACED FOUR TIMES, THE HEAD GASKETS, AND THE REAR END RINGS HOWEVER THE FAILURE WAS NOT CORRECTED. THE VEHICLE CONTINUED TO STALL WITHOUT WARNING AND THE ENGINE COULD NO LONGER BE STARTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM: WIRING). THE FAILURE MILEAGE WAS 9,368 AND THE CURRENT MILEAGE WAS 175,000. UPDATED 8/21/12 *CN THE CONSUMER STATED THE HIGH PRESSURE OIL PUMP, FRONT END SEALS, END RINGS, FUEL INJECTORS, TURBO CHARGER, HEAD GASKETS AND EGR VALVE WERE REPALCED. THE TRANSMISSION WAS SLIPPIING WHEN THE VEHICLE WAS PUT IN REVERSE. THE ABS LIGHT ILLUMINATED.
NHTSA complaint #10465856 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
WHILE PULLING A 30 FOOT TRAVEL TRAILER TUCK SUDDENLY DIED CAUSING IMMEDIATE LOSS OF STEERING AND BRAKING POWER ON A VERY BUSY HIGHWAY NEARLY CAUSING AN ACCIDENT. HAD IT TOWED TO A DIESEL SHOP WHO SCANNED TO FIND IT TO BE THE HIGH PRESSURE OIL AND FUEL PUMPS. THEY SAID THEY HAVE DONE REPEATED REPAIRS ON THE SAME ENGINE WITH THE SAME PROBLEMS IN THE PAST. VERY COSTLY REPAIR OVER $3000 AND 5 DAYS TO DO.
NHTSA complaint #10452770 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
MY 2005 F350 HAS A FUEL FAILURE AND WHEN I TOOK IT TO THE DEALER THEY SAID THAT 5 INJECTORS HAD FAILED AND I NEEDED THEY BLAME IT ON BIOFUEL, I HAVE ONLY USED ON ROAD DIESEL AND I HAVE OWNED THIS TRUCK SINCE IT HAD 25,000 MILES ON IT. AT THIS POINT IT IS $6000 TO REPAIR AND OF COURSE THERE IS NO WARRANTY ON IT. THIS IS A MAJOR CONCERN BECAUSE THIS TRUCK CARRIES EXTREME LOADS AT HIGH SPEEDS AND A FUEL FAILURE AT 65 OR 70 WILL CAUSE YOU TO LOSE POWER STEERING AND BRAKING ABILITY. WHEN YOU ARE CARRYING A BACKHOE AND HAVE A TRAILER THAT WEIGHS 6000LBS THE TOTAL WEIGHT OF THE WHOLE RIG IS RIGHT AT 35,000 POUNDS. THAT IS ENOUGH TO TAKE OUT AT LEAST 6 OR 7 CARS THAT HAVE STOPPED IN FRONT OF YOU. THIS NEEDS TO BE FIXED ASAP.
NHTSA complaint #10450832 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING 20 MPH. UPON RESTART, THE VEHICLE OPERATED AS NORMAL. THE CONTACT EXAMINED THE VEHICLE AND STATED THAT THE FUEL TANK WAS DELAMINATING AND CLOGGING THE FUEL FILTERS. THE VEHICLE WAS NOT DIAGNOSED, NOR REPAIRED, BY THE DEALER. THE FAILURE MILEAGE WAS 49,500 AND THE CURRENT MILEAGE WAS 50,200.
NHTSA complaint #10448027 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS THE VEHICLE WOULD EITHER STALL OR DECELERATE TO APPROXIMATELY 5 MPH. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. AN INDEPENDENT MECHANIC THEN EXAMINED THE VEHICLE AND NOTICED THAT THERE WERE SILVER FLAKES SETTLING IN THE FUEL FILTER. THE INDEPENDENT REPAIR SHOP WAS THEN NOTIFIED AND THE CONTACT WAS INFORMED THAT THE SILVER FLAKES WERE A RESULT OF THE DELAMINATION OF THE FUEL TANK. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS INFORMED THAT DIESEL FUEL WAS CAUSING THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #10412284 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
2005 F350 SUPERDUTY POWERSTROKE 6.0 DIESEL WITH 53,000 MILES CONTINUED TO ACCELERATE WITHOUT OPERATOR CONTROL NEARLY CAUSING REAR-END COLLISION WHILE DRIVING. OPERATOR COMPLETED A TURN AND ACCELERATED TO THE SPEED LIMIT AND WHEN OPERATOR RELEASED THE THROTTLE THE VEHICLE "TOOK OFF" AS IF THE ACCELERATOR HAD BEEN DEPRESSED AGAIN. OPERATOR CAME CLOSE TO REAR ENDING A PASSENGER CAR IN FRONT OF THE OPERATOR SO THE OPERATOR IMMEDIATELY APPLIED BRAKES AND PULLED OUT OF TRAFFIC WHILE TRUCK CONTINUED ATTEMPT TO ACELERATE. WHILE TRUCK WAS REVING AT HIGH RPM OPERATOR PUT VEHICLE IN "PARK" POSITION AND TURNED KEY TO OFF SHUTTING DOWN ENGINE COMPLETLY. ENGINE RESTARTED AND CONTINUE TO OPERATE NORMALLY AND CONTACTED AND DELIVERED VEHICLE TO THE SERVICING FORD DEALERSHIP. OPERATOR STATES THAT THE VEHICLE HAD PRIOR "FAILURE TO SHUT DOWN" AND "FAILURE TO DECEL" ISSUES BUT NO "DIAGNOSTIC CODE" WAS ESTABLISHED FOR DEALER TO USE AS WITH POSSIBLE CURRENT EVENT.
NHTSA complaint #10398376 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
I HAVE A 2005 FORD F-350 WITH A POWERSTOKE. IT ONLY HAS ABOUT 100,XXX MILES ON IT BUT THE FUEL TANK DELAMINATED AND CAUSED FIVE INJECTORS TO GO BAD THIS IS A SAFETY CONCERN. NOT TO MENTION A COSTLY FIX AND FORD CANT EVEN FILL THE TANK ORDERS ITS BEEN ON BACK ORDER FOR 6 WEEKS. THIS SHOULDN'T HAPPEN ON A TRUCK THAT IS ONLY 5 YEARS OLD.
NHTSA complaint #10396604 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
TL* THE CONTACT OWNS A 2005 FORD F-350 DIESEL. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WOULD NOT RESTART DESPITE THE ATTEMPTS OF THE CONTACT AND WAS TOWED TO AN AUTHORIZED DEALER. THE DEALER STATED THE FUEL TANK WAS DELAMINATED AND THE INTERIOR PAINT HAD CLOGGED THE ENGINE. THE DEALER REPLACED THE FUEL TANK, FUEL FILTERS AND SEVERAL FUEL INJECTORS DECEMBER 2007. THE FAILURE RECURRED MARCH 2011 AND THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE FUEL TANK WAS RUSTED FROM THE INSIDE OUT AND THE FUEL TANK, FUEL PUMP, FUEL FILTERS, FUEL INJECTORS, AND EGR VALVE WERE REPLACED AT A COST OF $4,200. THE CONTACT THEN CONTACTED THE MANUFACTURER AND FILED A COMPLAINT REGARDING THE FAILURE BUT NO FURTHER ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 24,000 AND THE CURRENT MILEAGE WAS 46,000. UPDATED 06/01/11*LJ UPDATED 06/02/11
NHTSA complaint #10393114 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
ISSUE 1 - FUEL SPILLING OUT OF COOLANT SYSTEM. FUEL SPILLING ONTO EXHAUST COMPONENTS AND COATING ENGINE AND UNDERSIDE OF VEHICLE. CREATED A FIRE HAZARD. CREATED AN ENVIRONMENTAL HAZARD. THIS COULD HAVE RESULTED IN SEVERE INJURY OR DEATH IF A FIRE HAD STARTED.
NHTSA complaint #10388628 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT THE FUEL TANK ON THE VEHICLE WAS ERODING AND CAUSING THE VEHICLE TO LOOSE POWER INTERMITTENTLY WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE FUEL TANK WOULD NEED TO BE REPLACED IN ORDER TO CORRECT THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 55,000.
NHTSA complaint #10375484 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
TL*THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, FOUR FUEL INJECTORS MALFUNCTIONED WHICH CAUSED THE EXHAUST TO EMIT SMOKE AND THE VEHICLE TO STALL. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE RADIATOR WAS REPLACED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 83,000.
NHTSA complaint #10366617 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
TL*THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH, THE DIESEL ENGINE OVERHEATED WITH SMOKE COMING FROM THE EXHAUST PIPE. THE VEHICLE WAS DRIVEN TO THE SIDE OF THE ROAD. THE ENGINE WAS TURNED OFF, AND RESTARTED AFTER WAITING UNTIL THE ENGINE COOLED DOWN. THE VEHICLE RESUMED OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE FAILURE WAS CONTRIBUTED TO THE OIL COOLER AND EXHAUST GAS RECIRCULATION (EGR). THE VEHICLE WAS REPAIRED. THE MECHANIC ADVISED REPLACEMENT OF THE OIL PUMP AND FUEL INJECTORS. THE FAILURE MILEAGE WAS 160,000. THE CURRENT MILEAGE WAS 160,200.
NHTSA complaint #10324373 — an unverified report by a vehicle owner.