Owners have filed 170 complaints
about the 2005 Ford F-350 with NHTSA between 2006 and 2025.
The largest single group is the fuel & propulsion.
Across this model's run it ranks 13 of 21 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 48
Against the median year of the Ford F-350. 50 means typical for this
model; 100 means roughly double.
Severity — 61
11.8% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 41
24% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
10.7%
1,000 – 9,999 miles
118.2%
10,000 – 24,999 miles
96.7%
25,000 – 49,999 miles
1813.4%
50,000 – 74,999 miles
2216.4%
75,000 – 99,999 miles
2115.7%
100,000 – 149,999 miles
3425.4%
150,000+ miles
1813.4%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Oct 2006peak 9Apr 2025
NHTSA investigations into the 2005 Ford F-350
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
EA08007Opened 14 Mar 2008Closed 31 Mar 2009SUSPENSION
VIOLENT FRONT END OSCILLATION
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, T...
PE07057Opened 15 Nov 2007Closed 14 Mar 2008SUSPENSION
VIOLENT FRONT END OSCILLATION
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT...
Complaints that involved harm
Reports where the owner recorded a crash, a fire, an injury or a death.
at 228,000 milesGlen, MTCrash1 injured
AIR BAGS
The contact owns a 2005 Ford F-350. The contact stated while driving approximately 60-65 MPH and coming up to a bridge, the contact stated that the roadway was a bit wet from ice and rain, and the contact stated that the vehicle ahead entered the bridge and started skidding, so the contact let up off the accelerator pedal; however, when the vehicle entered the bridge, the vehicle started sliding and the contact lost control of the vehicle and crashed head-on into the concrete barrier surrounding the bridge and broke the two picking eyes that was welded unto the front sub frame of the vehicle. The contact stated that the front bumper was severely damaged, and he was concerned that that the air bags had failed to deploy. The contact stated that his chin struck the steering wheel, and his neck was hyper-extended. The contact sustained neck and shoulder injuries. The contact had not received medical treatment at the scene and was not transported to the local medical center for treatment. The contact stated that a Police report was filed and he received paperwork to request a copy of the Police report. The vehicle was towed to a local tow yard. The vehicle was later towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 228,000.
NHTSA complaint #11652135 — an unverified report by a vehicle owner.
Yuma, AZCrashFire
POWER TRAIN
[XXX] who performs automotive work out of his residence [XXX] and [XXX] of [XXX] have worked on this vehicle to spite the customer and to gouge the customer in unnecessary fraudulent repairs. They have deliberately set this vehicle up to fail with the braking system, the 6.0 engine being rebuilt to no avail, and constant driving problems such as pulling to the right and the left when brakes applied, constant overheating, constant oil temperature overheating, shuttering at highway speed, transmission failure, air conditioning failure, coolant system failure, electrical system failure, and every system that they have repaired, continues to fail. They specifically performed work on the electrical wiring and truck keeps blowing fuses. They performed work on the transmission and the transmission failed shortly after. They performed work on the engine and deleted illegally all the emissions EGR pollutant controls. They installed faulty wiring for the electric trailer brake controls and the electronic speed controls. They tampered with the air conditioning system causing the compressor to blow out, send metal through the a/c lines, and the belt stopped turning causing the serpentine belt to break, tear the fan shroud apart and shred. They also installed a trailer brake controller that was aftermarket and it caused brake loss and intermittent failure with the service brake system and speed control. Domingo also tuned the computer to make the truck output 550 horsepower which caused the new engine to fail prematurely and the transmission to fail as well. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11437093 — an unverified report by a vehicle owner.
Yuma, AZCrashFire
SUSPENSION
[XXX] who performs automotive work out of his residence [XXX] and [XXX] of [XXX] have worked on this vehicle to spite the customer and to gouge the customer in unnecessary fraudulent repairs. They have deliberately set this vehicle up to fail with the braking system, the 6.0 engine being rebuilt to no avail, and constant driving problems such as pulling to the right and the left when brakes applied, constant overheating, constant oil temperature overheating, shuttering at highway speed, transmission failure, air conditioning failure, coolant system failure, electrical system failure, and every system that they have repaired, continues to fail. They specifically performed work on the electrical wiring and truck keeps blowing fuses. They performed work on the transmission and the transmission failed shortly after. They performed work on the engine and deleted illegally all the emissions EGR pollutant controls. They installed faulty wiring for the electric trailer brake controls and the electronic speed controls. They tampered with the air conditioning system causing the compressor to blow out, send metal through the a/c lines, and the belt stopped turning causing the serpentine belt to break, tear the fan shroud apart and shred. They also installed a trailer brake controller that was aftermarket and it caused brake loss and intermittent failure with the service brake system and speed control. Domingo also tuned the computer to make the truck output 550 horsepower which caused the new engine to fail prematurely and the transmission to fail as well. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11437093 — an unverified report by a vehicle owner.
Yuma, AZCrashFire1 injured
ELECTRICAL SYSTEM
[XXX], [XXX] approx age 40 lives and works at [XXX].[XXX] can also control the computers to cancel out and delete the use of catalytic converters, delete the use of DEF intake, delete the use of DPF particulate filters, and not react to controls such as manual braking or acceleration because the computer is controlling when and not the driver. [XXX] strictly states that he cannot have any emissions controls such as EGR, DEF, DPF, catalyst, or any pollutant controls. [XXX] intentionally set it up to have flaws and be dangerous for one reason: to get the customer to keep returning again and again with vehicle problems, wiring electrical problems, performance problems, overheating problems, and never ending engine problems not to mention transmission problems because the transmission could not handle the increased output of the engine. The hydroboost and ABS module and master cylinder that controls the brakes can be easily rigged so that when the driver stomps on the brakes, there is no braking action whatsoever for a 3-5 second delay before skidding the tires and locking the brakes. [XXX] altered the hydroboost and ABS module and master cylinder and the electronic controls to the braking system. [XXX] [XXX] partner admitted the hydrobooster and master cylinder was the problem because he admitted what [XXX] did as sabotage to the customer’s truck. [XXX] deletes the DPF and DEF and the electronics rewiring the truck. [XXX] has a pattern of keeping customers vehicles for excessively long periods of time: 42 days to change batteries, change fuel pump change PCM fusebox and rewire truck. [XXX] has removed the all the catalytic converters and he has removed all the EGR and emissions pollutant controls on [XXX]. [XXX] has sabotaged this truck’s braking system, electrical systems, fuse box wiring, electronic braking wiring, accelerator electronic control. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11437097 — an unverified report by a vehicle owner.
Yuma, AZCrashFire1 injured
ENGINE
[XXX], [XXX] approx age 40 lives and works at [XXX].[XXX] can also control the computers to cancel out and delete the use of catalytic converters, delete the use of DEF intake, delete the use of DPF particulate filters, and not react to controls such as manual braking or acceleration because the computer is controlling when and not the driver. [XXX] strictly states that he cannot have any emissions controls such as EGR, DEF, DPF, catalyst, or any pollutant controls. [XXX] intentionally set it up to have flaws and be dangerous for one reason: to get the customer to keep returning again and again with vehicle problems, wiring electrical problems, performance problems, overheating problems, and never ending engine problems not to mention transmission problems because the transmission could not handle the increased output of the engine. The hydroboost and ABS module and master cylinder that controls the brakes can be easily rigged so that when the driver stomps on the brakes, there is no braking action whatsoever for a 3-5 second delay before skidding the tires and locking the brakes. [XXX] altered the hydroboost and ABS module and master cylinder and the electronic controls to the braking system. [XXX] [XXX] partner admitted the hydrobooster and master cylinder was the problem because he admitted what [XXX] did as sabotage to the customer’s truck. [XXX] deletes the DPF and DEF and the electronics rewiring the truck. [XXX] has a pattern of keeping customers vehicles for excessively long periods of time: 42 days to change batteries, change fuel pump change PCM fusebox and rewire truck. [XXX] has removed the all the catalytic converters and he has removed all the EGR and emissions pollutant controls on [XXX]. [XXX] has sabotaged this truck’s braking system, electrical systems, fuse box wiring, electronic braking wiring, accelerator electronic control. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11437097 — an unverified report by a vehicle owner.
Yuma, AZCrashFire
SERVICE BRAKES
[XXX] who performs automotive work out of his residence [XXX] and [XXX] of [XXX] have worked on this vehicle to spite the customer and to gouge the customer in unnecessary fraudulent repairs. They have deliberately set this vehicle up to fail with the braking system, the 6.0 engine being rebuilt to no avail, and constant driving problems such as pulling to the right and the left when brakes applied, constant overheating, constant oil temperature overheating, shuttering at highway speed, transmission failure, air conditioning failure, coolant system failure, electrical system failure, and every system that they have repaired, continues to fail. They specifically performed work on the electrical wiring and truck keeps blowing fuses. They performed work on the transmission and the transmission failed shortly after. They performed work on the engine and deleted illegally all the emissions EGR pollutant controls. They installed faulty wiring for the electric trailer brake controls and the electronic speed controls. They tampered with the air conditioning system causing the compressor to blow out, send metal through the a/c lines, and the belt stopped turning causing the serpentine belt to break, tear the fan shroud apart and shred. They also installed a trailer brake controller that was aftermarket and it caused brake loss and intermittent failure with the service brake system and speed control. Domingo also tuned the computer to make the truck output 550 horsepower which caused the new engine to fail prematurely and the transmission to fail as well. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11437093 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 228,000 milesGlen, MTCrash1 injured
AIR BAGS
The contact owns a 2005 Ford F-350. The contact stated while driving approximately 60-65 MPH and coming up to a bridge, the contact stated that the roadway was a bit wet from ice and rain, and the contact stated that the vehicle ahead entered the bridge and started skidding, so the contact let up off the accelerator pedal; however, when the vehicle entered the bridge, the vehicle started sliding and the contact lost control of the vehicle and crashed head-on into the concrete barrier surrounding the bridge and broke the two picking eyes that was welded unto the front sub frame of the vehicle. The contact stated that the front bumper was severely damaged, and he was concerned that that the air bags had failed to deploy. The contact stated that his chin struck the steering wheel, and his neck was hyper-extended. The contact sustained neck and shoulder injuries. The contact had not received medical treatment at the scene and was not transported to the local medical center for treatment. The contact stated that a Police report was filed and he received paperwork to request a copy of the Police report. The vehicle was towed to a local tow yard. The vehicle was later towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 228,000.
NHTSA complaint #11652135 — an unverified report by a vehicle owner.
Conway, AR
ELECTRICAL SYSTEM
Vehicle stalls while driving and wont start again suddenly while operating. Fuel injectors won’t feed fuel line to restart or operate. Occasional start but then stalls continuously until battery dies from trying. Will start when priming the carburetor however will not stay running and stalls out.
NHTSA complaint #11594346 — an unverified report by a vehicle owner.
Southlake, TX
STEERING
Twice today, traveling at 75mph on highway [XXX] (northbound and then several hours later southbound) just north of Ardmore OK, I experienced a violent shaking of the steering wheel/front wheel shimmy. The vehicle was difficult to control due to the violent shaking that did not stop until the vehicle slowed to approximately 20mph. Once the shaking stopped the vehicle was okay to drive. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11574799 — an unverified report by a vehicle owner.
Southlake, TX
SUSPENSION
Twice today, traveling at 75mph on highway [XXX] (northbound and then several hours later southbound) just north of Ardmore OK, I experienced a violent shaking of the steering wheel/front wheel shimmy. The vehicle was difficult to control due to the violent shaking that did not stop until the vehicle slowed to approximately 20mph. Once the shaking stopped the vehicle was okay to drive. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11574799 — an unverified report by a vehicle owner.
Roseburg, OR
STEERING
My 2005 F350 Diesel Pick up has suffered from the Ford death wobble on and off for the last 15 years. While navigating a left hand corner at speeds over 40 it begins to shake uncontrollably after hitting a small bump or pot hole until speed is reduced to 30mph or less. I have replaced bearings, uppper & lower ball joints, torque arms and other suspension parts without finding a cure.
NHTSA complaint #11530347 — an unverified report by a vehicle owner.
Roseburg, OR
SUSPENSION
My 2005 F350 Diesel Pick up has suffered from the Ford death wobble on and off for the last 15 years. While navigating a left hand corner at speeds over 40 it begins to shake uncontrollably after hitting a small bump or pot hole until speed is reduced to 30mph or less. I have replaced bearings, uppper & lower ball joints, torque arms and other suspension parts without finding a cure.
NHTSA complaint #11530347 — an unverified report by a vehicle owner.
Electra, TX
STEERING
Multiple times driving the truck at speed limit and hit small bump or a little bumpy part of road triggers the death wobble. Have to almost come to complete stop on highway to stop wobble.
NHTSA complaint #11466661 — an unverified report by a vehicle owner.
Electra, TX
SUSPENSION
Multiple times driving the truck at speed limit and hit small bump or a little bumpy part of road triggers the death wobble. Have to almost come to complete stop on highway to stop wobble.
NHTSA complaint #11466661 — an unverified report by a vehicle owner.
Scottsdale, AZ
STEERING
The contact owns a 2005 Ford F-350. The contact stated while driving approximately 50 MPH, the vehicle started to shimmy. The contact stated that at the time of failure the steering wheel was very difficult to turn. The contact stated that after slowing down the vehicle operated normally. The contact stated that the brake warning light was illuminated. The vehicle was not repaired. The contact stated that she received notification in the mail of NHTSA Campaign Number: 20E090000 (Steering, Suspension, Equipment) however, her vehicle was not included in the recall. The contact stated that neither the dealer nor the manufacturer was notified of the failure. The failure mileage was unknown.
NHTSA complaint #11464386 — an unverified report by a vehicle owner.
Scottsdale, AZ
SUSPENSION
The contact owns a 2005 Ford F-350. The contact stated while driving approximately 50 MPH, the vehicle started to shimmy. The contact stated that at the time of failure the steering wheel was very difficult to turn. The contact stated that after slowing down the vehicle operated normally. The contact stated that the brake warning light was illuminated. The vehicle was not repaired. The contact stated that she received notification in the mail of NHTSA Campaign Number: 20E090000 (Steering, Suspension, Equipment) however, her vehicle was not included in the recall. The contact stated that neither the dealer nor the manufacturer was notified of the failure. The failure mileage was unknown.
NHTSA complaint #11464386 — an unverified report by a vehicle owner.
Aransas Pass, TX
ELECTRICAL SYSTEM
The all very common issues with the year f350 and the 6.0 l. Engines, are as such. The malfunctioning FICM. THE high and low oil coolers, the inter coolers and head studs. Also leaking break fluid .
NHTSA complaint #11462783 — an unverified report by a vehicle owner.
Aransas Pass, TX
ENGINE
The all very common issues with the year f350 and the 6.0 l. Engines, are as such. The malfunctioning FICM. THE high and low oil coolers, the inter coolers and head studs. Also leaking break fluid .
NHTSA complaint #11462783 — an unverified report by a vehicle owner.
Aransas Pass, TX
FUEL/PROPULSION SYSTEM
The all very common issues with the year f350 and the 6.0 l. Engines, are as such. The malfunctioning FICM. THE high and low oil coolers, the inter coolers and head studs. Also leaking break fluid .
NHTSA complaint #11462783 — an unverified report by a vehicle owner.
Stockton, CA
UNKNOWN OR OTHER
Oil leaking from more than 4 parts of the engine and was told it’s normal for this model. Also, when driving over a bump or uneven pavement the trucks steering and suspension drives out of control.
NHTSA complaint #11447083 — an unverified report by a vehicle owner.
Graniteville, SC
UNKNOWN OR OTHER
Once I get up to 55-60 mph it just shakes really bad, I have had ball joints replaced bought new tires and it still shakes
NHTSA complaint #11444537 — an unverified report by a vehicle owner.
Yuma, AZCrashFire
POWER TRAIN
[XXX] who performs automotive work out of his residence [XXX] and [XXX] of [XXX] have worked on this vehicle to spite the customer and to gouge the customer in unnecessary fraudulent repairs. They have deliberately set this vehicle up to fail with the braking system, the 6.0 engine being rebuilt to no avail, and constant driving problems such as pulling to the right and the left when brakes applied, constant overheating, constant oil temperature overheating, shuttering at highway speed, transmission failure, air conditioning failure, coolant system failure, electrical system failure, and every system that they have repaired, continues to fail. They specifically performed work on the electrical wiring and truck keeps blowing fuses. They performed work on the transmission and the transmission failed shortly after. They performed work on the engine and deleted illegally all the emissions EGR pollutant controls. They installed faulty wiring for the electric trailer brake controls and the electronic speed controls. They tampered with the air conditioning system causing the compressor to blow out, send metal through the a/c lines, and the belt stopped turning causing the serpentine belt to break, tear the fan shroud apart and shred. They also installed a trailer brake controller that was aftermarket and it caused brake loss and intermittent failure with the service brake system and speed control. Domingo also tuned the computer to make the truck output 550 horsepower which caused the new engine to fail prematurely and the transmission to fail as well. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11437093 — an unverified report by a vehicle owner.
Yuma, AZCrashFire
SUSPENSION
[XXX] who performs automotive work out of his residence [XXX] and [XXX] of [XXX] have worked on this vehicle to spite the customer and to gouge the customer in unnecessary fraudulent repairs. They have deliberately set this vehicle up to fail with the braking system, the 6.0 engine being rebuilt to no avail, and constant driving problems such as pulling to the right and the left when brakes applied, constant overheating, constant oil temperature overheating, shuttering at highway speed, transmission failure, air conditioning failure, coolant system failure, electrical system failure, and every system that they have repaired, continues to fail. They specifically performed work on the electrical wiring and truck keeps blowing fuses. They performed work on the transmission and the transmission failed shortly after. They performed work on the engine and deleted illegally all the emissions EGR pollutant controls. They installed faulty wiring for the electric trailer brake controls and the electronic speed controls. They tampered with the air conditioning system causing the compressor to blow out, send metal through the a/c lines, and the belt stopped turning causing the serpentine belt to break, tear the fan shroud apart and shred. They also installed a trailer brake controller that was aftermarket and it caused brake loss and intermittent failure with the service brake system and speed control. Domingo also tuned the computer to make the truck output 550 horsepower which caused the new engine to fail prematurely and the transmission to fail as well. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11437093 — an unverified report by a vehicle owner.
Yuma, AZCrashFire1 injured
ELECTRICAL SYSTEM
[XXX], [XXX] approx age 40 lives and works at [XXX].[XXX] can also control the computers to cancel out and delete the use of catalytic converters, delete the use of DEF intake, delete the use of DPF particulate filters, and not react to controls such as manual braking or acceleration because the computer is controlling when and not the driver. [XXX] strictly states that he cannot have any emissions controls such as EGR, DEF, DPF, catalyst, or any pollutant controls. [XXX] intentionally set it up to have flaws and be dangerous for one reason: to get the customer to keep returning again and again with vehicle problems, wiring electrical problems, performance problems, overheating problems, and never ending engine problems not to mention transmission problems because the transmission could not handle the increased output of the engine. The hydroboost and ABS module and master cylinder that controls the brakes can be easily rigged so that when the driver stomps on the brakes, there is no braking action whatsoever for a 3-5 second delay before skidding the tires and locking the brakes. [XXX] altered the hydroboost and ABS module and master cylinder and the electronic controls to the braking system. [XXX] [XXX] partner admitted the hydrobooster and master cylinder was the problem because he admitted what [XXX] did as sabotage to the customer’s truck. [XXX] deletes the DPF and DEF and the electronics rewiring the truck. [XXX] has a pattern of keeping customers vehicles for excessively long periods of time: 42 days to change batteries, change fuel pump change PCM fusebox and rewire truck. [XXX] has removed the all the catalytic converters and he has removed all the EGR and emissions pollutant controls on [XXX]. [XXX] has sabotaged this truck’s braking system, electrical systems, fuse box wiring, electronic braking wiring, accelerator electronic control. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11437097 — an unverified report by a vehicle owner.
Yuma, AZCrashFire1 injured
ENGINE
[XXX], [XXX] approx age 40 lives and works at [XXX].[XXX] can also control the computers to cancel out and delete the use of catalytic converters, delete the use of DEF intake, delete the use of DPF particulate filters, and not react to controls such as manual braking or acceleration because the computer is controlling when and not the driver. [XXX] strictly states that he cannot have any emissions controls such as EGR, DEF, DPF, catalyst, or any pollutant controls. [XXX] intentionally set it up to have flaws and be dangerous for one reason: to get the customer to keep returning again and again with vehicle problems, wiring electrical problems, performance problems, overheating problems, and never ending engine problems not to mention transmission problems because the transmission could not handle the increased output of the engine. The hydroboost and ABS module and master cylinder that controls the brakes can be easily rigged so that when the driver stomps on the brakes, there is no braking action whatsoever for a 3-5 second delay before skidding the tires and locking the brakes. [XXX] altered the hydroboost and ABS module and master cylinder and the electronic controls to the braking system. [XXX] [XXX] partner admitted the hydrobooster and master cylinder was the problem because he admitted what [XXX] did as sabotage to the customer’s truck. [XXX] deletes the DPF and DEF and the electronics rewiring the truck. [XXX] has a pattern of keeping customers vehicles for excessively long periods of time: 42 days to change batteries, change fuel pump change PCM fusebox and rewire truck. [XXX] has removed the all the catalytic converters and he has removed all the EGR and emissions pollutant controls on [XXX]. [XXX] has sabotaged this truck’s braking system, electrical systems, fuse box wiring, electronic braking wiring, accelerator electronic control. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11437097 — an unverified report by a vehicle owner.
Yuma, AZCrashFire
SERVICE BRAKES
[XXX] who performs automotive work out of his residence [XXX] and [XXX] of [XXX] have worked on this vehicle to spite the customer and to gouge the customer in unnecessary fraudulent repairs. They have deliberately set this vehicle up to fail with the braking system, the 6.0 engine being rebuilt to no avail, and constant driving problems such as pulling to the right and the left when brakes applied, constant overheating, constant oil temperature overheating, shuttering at highway speed, transmission failure, air conditioning failure, coolant system failure, electrical system failure, and every system that they have repaired, continues to fail. They specifically performed work on the electrical wiring and truck keeps blowing fuses. They performed work on the transmission and the transmission failed shortly after. They performed work on the engine and deleted illegally all the emissions EGR pollutant controls. They installed faulty wiring for the electric trailer brake controls and the electronic speed controls. They tampered with the air conditioning system causing the compressor to blow out, send metal through the a/c lines, and the belt stopped turning causing the serpentine belt to break, tear the fan shroud apart and shred. They also installed a trailer brake controller that was aftermarket and it caused brake loss and intermittent failure with the service brake system and speed control. Domingo also tuned the computer to make the truck output 550 horsepower which caused the new engine to fail prematurely and the transmission to fail as well. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11437093 — an unverified report by a vehicle owner.
Yuma, AZCrashFire1 injured
SERVICE BRAKES
[XXX], [XXX] approx age 40 lives and works at [XXX].[XXX] can also control the computers to cancel out and delete the use of catalytic converters, delete the use of DEF intake, delete the use of DPF particulate filters, and not react to controls such as manual braking or acceleration because the computer is controlling when and not the driver. [XXX] strictly states that he cannot have any emissions controls such as EGR, DEF, DPF, catalyst, or any pollutant controls. [XXX] intentionally set it up to have flaws and be dangerous for one reason: to get the customer to keep returning again and again with vehicle problems, wiring electrical problems, performance problems, overheating problems, and never ending engine problems not to mention transmission problems because the transmission could not handle the increased output of the engine. The hydroboost and ABS module and master cylinder that controls the brakes can be easily rigged so that when the driver stomps on the brakes, there is no braking action whatsoever for a 3-5 second delay before skidding the tires and locking the brakes. [XXX] altered the hydroboost and ABS module and master cylinder and the electronic controls to the braking system. [XXX] [XXX] partner admitted the hydrobooster and master cylinder was the problem because he admitted what [XXX] did as sabotage to the customer’s truck. [XXX] deletes the DPF and DEF and the electronics rewiring the truck. [XXX] has a pattern of keeping customers vehicles for excessively long periods of time: 42 days to change batteries, change fuel pump change PCM fusebox and rewire truck. [XXX] has removed the all the catalytic converters and he has removed all the EGR and emissions pollutant controls on [XXX]. [XXX] has sabotaged this truck’s braking system, electrical systems, fuse box wiring, electronic braking wiring, accelerator electronic control. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11437097 — an unverified report by a vehicle owner.
Layton, UT
STEERING
When driving 50 mph or above and hitting a bump in the road such as a bridge apron the truck develops an uncontrollable shimmy in the front end. It requires a firm grip from both hands to control the steering and lasts until the truck is slowed to under 20 mph and often until it is completely stopped. Luckily there hasn’t been another vehicle in the lanes next to me when this has occurred. If there had been it may have caused an accident. Tires are relatively new and the alignment is spot on. It feels like the same problem I had as a teenager in my 1959 Ford F100 when the king pins were worn.
NHTSA complaint #11428417 — an unverified report by a vehicle owner.
at 220,000 milesSomerset, CA
STEERING
DEATH WOBBLE. TRUCK SHAKES VIOLENTLY WHEN TRAVELING +50 MPH, EMPTY, OR TOWING OR HAULING LOAD IN TRUCK BED. DOWNHILL BRAKING IS EXTREMELY DANGEROUS. TURNING WHILE BRAKING IS THE WORST.
NHTSA complaint #11319705 — an unverified report by a vehicle owner.
at 220,000 milesSomerset, CA
SUSPENSION
DEATH WOBBLE. TRUCK SHAKES VIOLENTLY WHEN TRAVELING +50 MPH, EMPTY, OR TOWING OR HAULING LOAD IN TRUCK BED. DOWNHILL BRAKING IS EXTREMELY DANGEROUS. TURNING WHILE BRAKING IS THE WORST.
NHTSA complaint #11319705 — an unverified report by a vehicle owner.
at 63,000 milesMT Holy, VT
ENGINE
TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT THE VEHICLE MISFIRED AND CAUSED THE STEERING WHEEL TO SEIZE. ALSO, WHILE DRIVING VARIOUS SPEEDS, THE BRAKE PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO IMMEDIATELY STOP. THE VEHICLE WAS TAKEN TO FORMULA FORD LINCOLN (4318 MIDDLE RD, RUTLAND, VT 05701, (802) 773-9168) WHERE THE CAM PHASERS WERE REPLACED; HOWEVER, THE FAILURE RECURRED AFTER 176 MILES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 63,000.
NHTSA complaint #11282161 — an unverified report by a vehicle owner.