FaultScore report
Owners have filed 49 complaints about the 2005 Ford F Super Duty with NHTSA between 2011 and 2018. The largest single group is the steering. Across this model's run it ranks 8 of 13 worst.
FaultScore 40/100
Higher is worse. Measured against the other years of the Ford F Super Duty.
How this is worked out49
Complaints
1
Crashes reported
0
Fires reported
1
Injuries reported
80,000 mi
Median mileage at failure
Half of reported failures happened before this
10%
Failed under 36,000 miles
Inside a typical bumper-to-bumper warranty
The letter says how bad. This says what kind — whether this year drew an unusual number of complaints, unusually dangerous ones, or failures that arrived unusually early.
Click any bar to open that year's report.
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
Median failure at 94,650 miles
Median failure at 78,000 miles
Median failure at 154,100 miles
Median failure at 84,825 miles
Median failure at 91,007 miles
Median failure at 168,500 miles
Median failure at 205,006 miles
Median failure at 73,000 miles
Median failure at 211,000 miles
Odometer readings owners gave when they filed. About half of all complaints include one.
A spike years after the car went on sale usually means a part wearing out on schedule across the whole fleet — the kind of pattern no single owner can see from inside their own car.
Reports where the owner recorded a crash, a fire, an injury or a death.
STEERING
THE STEERING BOX FAILED, THE STEERING FAILED CAUSING THE OPERATOR TO LOSE CONTROL AND THEN HITTING A SNOW BANK WHICH ULTIMATELY CAUSE A ROLL OVER.
NHTSA complaint #10567796 — an unverified report by a vehicle owner.
In the owners' own words, exactly as filed with NHTSA.
STEERING
AFTER DRIVING OVER ROAD IMPERFECTIONS (E.G. BUMPS, POT HOLES, DIPS, ETC.) AT SPEEDS ABOUT 40MPH OR ABOVE, THE FRONT OF THE TRUCK SHAKES VERY VIOLENTLY, AND THE STEERING WHEEL MOVES QUICKLY AND STRONGLY, ALTERNATING RAPIDLY BETWEEN CLOCKWISE AND COUNTER-CLOCKWISE MOVEMENTS. IT IS DIFFICULT TO MAINTAIN CONTROL OF THE TRUCK; CONTROL CAN ONLY BE REGAINED AFTER SLOWING THE VEHICLE TO BELOW ABOUT 35 MILES PER HOUR, WHICH IS WELL BELOW ACCEPTABLE SPEEDS ON AN EXPRESSWAY. THIS IS NOT A ONE-TIME INCIDENT, BUT HAPPENS ALMOST EVERY TIME A ROAD IMPERFECTION IS DRIVEN OVER. TIRE PRESSURE IS CONSTANTLY CHECKED AND MAINTAINED, THE TIRES ARE RELATIVELY NEW (I.E. LESS THAN 10,000 MILES), AND THE STEERING AND SUSPENSION EQUIPMENT HAS BEEN CHECKED BY A MECHANIC WITH NO OBVIOUS PROBLEMS.
NHTSA complaint #11076611 — an unverified report by a vehicle owner.
SUSPENSION
AFTER DRIVING OVER ROAD IMPERFECTIONS (E.G. BUMPS, POT HOLES, DIPS, ETC.) AT SPEEDS ABOUT 40MPH OR ABOVE, THE FRONT OF THE TRUCK SHAKES VERY VIOLENTLY, AND THE STEERING WHEEL MOVES QUICKLY AND STRONGLY, ALTERNATING RAPIDLY BETWEEN CLOCKWISE AND COUNTER-CLOCKWISE MOVEMENTS. IT IS DIFFICULT TO MAINTAIN CONTROL OF THE TRUCK; CONTROL CAN ONLY BE REGAINED AFTER SLOWING THE VEHICLE TO BELOW ABOUT 35 MILES PER HOUR, WHICH IS WELL BELOW ACCEPTABLE SPEEDS ON AN EXPRESSWAY. THIS IS NOT A ONE-TIME INCIDENT, BUT HAPPENS ALMOST EVERY TIME A ROAD IMPERFECTION IS DRIVEN OVER. TIRE PRESSURE IS CONSTANTLY CHECKED AND MAINTAINED, THE TIRES ARE RELATIVELY NEW (I.E. LESS THAN 10,000 MILES), AND THE STEERING AND SUSPENSION EQUIPMENT HAS BEEN CHECKED BY A MECHANIC WITH NO OBVIOUS PROBLEMS.
NHTSA complaint #11076611 — an unverified report by a vehicle owner.
STEERING
THIS TRUCK HAS EXPERIENCED SHIMMY, AKA DEATH WOBBLE, SINCE NEW. I HAVE HAD NO SUSPENSION MODIFICATIONS AND NOT RUNNING ANYTHING OTHER THAN RECOMMENDED SIZE AND QUALITY OF TIRE. WHEN CRUISING AT HIGHWAY SPEEDS AND YOU HIT A BUMP THE TRUCK HOPS AND SHAKES IN A DANGEROUS WAY. I HAVE ONLY GOTTEN LETTERS FROM FORD SAYING TO USE THE CORRECT TIRES AND PSI RATING. WHICH I HAVE AND IT STILL HAPPENS.
NHTSA complaint #11072649 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
WHILE DRIVING ON INTERSTATE THE VEHICLE TURNED OFF AND HAD NO STEERING NOR BRAKES AT 70 MPH LUCKILY TRAFFIC WASN'T TO BAD AND I WAS ABLE TO COAST TO SAFETY PUT THE TRUCK IN PARK RESTARTED THE VEHICLE IT TOOK A FEW TIMES TO CRANK GOT IT STARTED PULLED OF THE INTERSTATE AS I WAS TURNING AT THE EXIT THE VEHICLE SHUT OFF AGAIN LOOSING STEERING AND BRAKES AGAIN.
NHTSA complaint #10934033 — an unverified report by a vehicle owner.
ELECTRONIC STABILITY CONTROL (ESC)
WHILE DRIVING ON INTERSTATE THE VEHICLE TURNED OFF AND HAD NO STEERING NOR BRAKES AT 70 MPH LUCKILY TRAFFIC WASN'T TO BAD AND I WAS ABLE TO COAST TO SAFETY PUT THE TRUCK IN PARK RESTARTED THE VEHICLE IT TOOK A FEW TIMES TO CRANK GOT IT STARTED PULLED OF THE INTERSTATE AS I WAS TURNING AT THE EXIT THE VEHICLE SHUT OFF AGAIN LOOSING STEERING AND BRAKES AGAIN.
NHTSA complaint #10934033 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WHILE DRIVING ON INTERSTATE THE VEHICLE TURNED OFF AND HAD NO STEERING NOR BRAKES AT 70 MPH LUCKILY TRAFFIC WASN'T TO BAD AND I WAS ABLE TO COAST TO SAFETY PUT THE TRUCK IN PARK RESTARTED THE VEHICLE IT TOOK A FEW TIMES TO CRANK GOT IT STARTED PULLED OF THE INTERSTATE AS I WAS TURNING AT THE EXIT THE VEHICLE SHUT OFF AGAIN LOOSING STEERING AND BRAKES AGAIN.
NHTSA complaint #10934033 — an unverified report by a vehicle owner.
VEHICLE SPEED CONTROL
TURN KEY TO START AND RUN. START DRIVING DOWN THE ROAD AND ALL GAUGES GO DEAD (NO POWER) RADIO & CRUISE CONTROL & WINDOWS & INTAGRATED BRAKES ALL GO OUT. NO MATTER AT ANY SPEEDS. THE SCARY ONE IS WHEN WE HAVE OUR 44 FT SUNDOWNER RV COMBO HORSE TRAILER AT 70 MPH ON CRUISE CONTROL AND THIS HAPPENS AND YOU HAVE NO GAUGES OR TRAILER BRAKES, NO POWER TO WINDOWS, NO POWER TO UNLOCK DOORS EXCEPT MANUALLY.AND NONE OF THE GAUGES ARE WORKING. BUT THE TRUCK STILL RUNS FINE. DEALERSHIPS CANT LOCATE PROBLEM BUT CHARGE YOU 2 HOURS LABOR AND SAYS BRING IT BACK IF IT DOES IT AGAIN. HAVE BROUGHT IT IN 14 TIMES THIS MONTH.
NHTSA complaint #10749884 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
TURN KEY TO START AND RUN. START DRIVING DOWN THE ROAD AND ALL GAUGES GO DEAD (NO POWER) RADIO & CRUISE CONTROL & WINDOWS & INTAGRATED BRAKES ALL GO OUT. NO MATTER AT ANY SPEEDS. THE SCARY ONE IS WHEN WE HAVE OUR 44 FT SUNDOWNER RV COMBO HORSE TRAILER AT 70 MPH ON CRUISE CONTROL AND THIS HAPPENS AND YOU HAVE NO GAUGES OR TRAILER BRAKES, NO POWER TO WINDOWS, NO POWER TO UNLOCK DOORS EXCEPT MANUALLY.AND NONE OF THE GAUGES ARE WORKING. BUT THE TRUCK STILL RUNS FINE. DEALERSHIPS CANT LOCATE PROBLEM BUT CHARGE YOU 2 HOURS LABOR AND SAYS BRING IT BACK IF IT DOES IT AGAIN. HAVE BROUGHT IT IN 14 TIMES THIS MONTH.
NHTSA complaint #10749884 — an unverified report by a vehicle owner.
ELECTRONIC STABILITY CONTROL (ESC)
TURN KEY TO START AND RUN. START DRIVING DOWN THE ROAD AND ALL GAUGES GO DEAD (NO POWER) RADIO & CRUISE CONTROL & WINDOWS & INTAGRATED BRAKES ALL GO OUT. NO MATTER AT ANY SPEEDS. THE SCARY ONE IS WHEN WE HAVE OUR 44 FT SUNDOWNER RV COMBO HORSE TRAILER AT 70 MPH ON CRUISE CONTROL AND THIS HAPPENS AND YOU HAVE NO GAUGES OR TRAILER BRAKES, NO POWER TO WINDOWS, NO POWER TO UNLOCK DOORS EXCEPT MANUALLY.AND NONE OF THE GAUGES ARE WORKING. BUT THE TRUCK STILL RUNS FINE. DEALERSHIPS CANT LOCATE PROBLEM BUT CHARGE YOU 2 HOURS LABOR AND SAYS BRING IT BACK IF IT DOES IT AGAIN. HAVE BROUGHT IT IN 14 TIMES THIS MONTH.
NHTSA complaint #10749884 — an unverified report by a vehicle owner.
STEERING
MY TRUCKS FRONT END SHAKES AND BOUNCES WHEN I HIT A ROUGH AREA ON THE HWY TO POINT IT FORCES ME INTO OTHER LANES OR OFF THE ROAD. WHEN IT STARTS BOUNCING I HAVE HIT THE BREAKS HARD AND COME TO A STOP. REALLY DANGEROUS ON A WELL TRAVELED ROAD. THIS HAS HAPPENED SEVERAL TIMES. I'VE HAD THE TRUCK CHECK AFTER EACH INCIDENT AND AM TOLD EVERYTHING CHECKS OUT OK. THEY SAID TO KEEP TIRES AT 65 PSI AND THEN 75 PSI NEITHER HELPED. TODAY AFTER ALMOST HITTING ANOTHER CAR HEAD ON HWY 175 I DECIDED IT'S TIME TO REPORT IT.
NHTSA complaint #10712815 — an unverified report by a vehicle owner.
SUSPENSION
MY TRUCKS FRONT END SHAKES AND BOUNCES WHEN I HIT A ROUGH AREA ON THE HWY TO POINT IT FORCES ME INTO OTHER LANES OR OFF THE ROAD. WHEN IT STARTS BOUNCING I HAVE HIT THE BREAKS HARD AND COME TO A STOP. REALLY DANGEROUS ON A WELL TRAVELED ROAD. THIS HAS HAPPENED SEVERAL TIMES. I'VE HAD THE TRUCK CHECK AFTER EACH INCIDENT AND AM TOLD EVERYTHING CHECKS OUT OK. THEY SAID TO KEEP TIRES AT 65 PSI AND THEN 75 PSI NEITHER HELPED. TODAY AFTER ALMOST HITTING ANOTHER CAR HEAD ON HWY 175 I DECIDED IT'S TIME TO REPORT IT.
NHTSA complaint #10712815 — an unverified report by a vehicle owner.
ENGINE
SPARK PLUG SHOOTOUT/ SPARK PLUG THREAD FAILURE.
NHTSA complaint #10637838 — an unverified report by a vehicle owner.
ENGINE
THIS WAS THE RECALL DRIVEABITITY. PERFORMED BY SELLING DEALER FORD OF WALLA WALLA UNDER WARRANTY. FORM WILL NOT ACCEPT PARTS. REPLACED EP SENSOR DID RECALL MAINTENANCE 59B01 AND RECALL DIESEL ENGINE01F0Z14.
NHTSA complaint #10583644 — an unverified report by a vehicle owner.
STEERING
ON APRIL 5, I WAS IN HE PROCESS OF STOPPING FOR A STOP SIGN, WHEN THE ENGINE STOPPED RUNNING. I WAS ABLE TO RESTART THE TRUCK. I DROVE LESS THAN 2 MILES, TURNED THE TRUCK OFF AND IT WOULD NOT RESTART. I HAD TRUCK TOWED TO AUTONATION FORD IN ST. PETERSBURG FL. MECHANIC NOT ON DUTY, BUT MONDAY (APRIL 7, 2014), SERVICE DEPARTMENT CALLED AND SAID NOTHING SHOWED UP ON THEIR COMPUTER CHECK, AND WAS STARTING FINE AFTER A MINOR ADJUSTMENT. I PICKED UP THE TRUCK, DROVE LESS THAN 2 MILES, WHEN IT STALLED AS I WAS IN THE PROCESS OF COMING TO A STOP, WHILE MY SPEED WAS ABOUT 30 MPH. LOST POWER STEERING BUT WAS ABLE TO MAINTAIN CONTROL. I WAS ABLE TO RESTART TRUCK AND RETURNED TO DEALER. TOLD THEM I DID NOT THINK I SHOULD HAVE TO PAY FOR A SECOND DIAGNOSTIC TEST, SINCE THEY HAD FAILED TO FIND OR FIX THE PROBLEM. ON APRIL 10, DEALER CALLED SAID THEY COULD NOT REPRODUCE THE PROBLEM AND SAID IT COULD BE EGR DIRTY OR TURBO BOOST. SINCE I HAD NOTICED TURBO WAS NOT KICKING IN PROPERLY DURING ACCELERATION FROM A STOP, I TOLD THEM TO DO BOTH BUT TO TAKE OFF THE $155 THEY HAD CHARGED ME FOR DIAGNOSIS. THEY AGREED AND MY TRUCK WAS RETURNED TO ME ON APRIL 12, 2014. ON APRIL 13, THE TRUCK STALLED WHEN COMING TO A STOP FOR A TRAFFIC SIGNAL. LOST POWER STEERING BUT WAS ABLE TO MAINTAIN CONTROL. LESS THAN A MILE LATER WHEN SLOWING TO MAKE A TURN, ENGINE SHUTDOWN AND I LOST POWER STEERING. I WAS BARELY ABLE TO MISS STRIKING A HOUSE AT THE INTERSECTION. TRUCK STALLED TWICE DURING THE NEXT 2 MILE TRIP. I THINK THIS IS A VERY DANGEROUS PROBLEM AND IT IS NOT BEING ADDRESSED BY FORD OR IT'S DEALER. PLEASE INVESTIGATE. *TR UPDATED 10/2/2014
NHTSA complaint #10579448 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
ON APRIL 5, I WAS IN HE PROCESS OF STOPPING FOR A STOP SIGN, WHEN THE ENGINE STOPPED RUNNING. I WAS ABLE TO RESTART THE TRUCK. I DROVE LESS THAN 2 MILES, TURNED THE TRUCK OFF AND IT WOULD NOT RESTART. I HAD TRUCK TOWED TO AUTONATION FORD IN ST. PETERSBURG FL. MECHANIC NOT ON DUTY, BUT MONDAY (APRIL 7, 2014), SERVICE DEPARTMENT CALLED AND SAID NOTHING SHOWED UP ON THEIR COMPUTER CHECK, AND WAS STARTING FINE AFTER A MINOR ADJUSTMENT. I PICKED UP THE TRUCK, DROVE LESS THAN 2 MILES, WHEN IT STALLED AS I WAS IN THE PROCESS OF COMING TO A STOP, WHILE MY SPEED WAS ABOUT 30 MPH. LOST POWER STEERING BUT WAS ABLE TO MAINTAIN CONTROL. I WAS ABLE TO RESTART TRUCK AND RETURNED TO DEALER. TOLD THEM I DID NOT THINK I SHOULD HAVE TO PAY FOR A SECOND DIAGNOSTIC TEST, SINCE THEY HAD FAILED TO FIND OR FIX THE PROBLEM. ON APRIL 10, DEALER CALLED SAID THEY COULD NOT REPRODUCE THE PROBLEM AND SAID IT COULD BE EGR DIRTY OR TURBO BOOST. SINCE I HAD NOTICED TURBO WAS NOT KICKING IN PROPERLY DURING ACCELERATION FROM A STOP, I TOLD THEM TO DO BOTH BUT TO TAKE OFF THE $155 THEY HAD CHARGED ME FOR DIAGNOSIS. THEY AGREED AND MY TRUCK WAS RETURNED TO ME ON APRIL 12, 2014. ON APRIL 13, THE TRUCK STALLED WHEN COMING TO A STOP FOR A TRAFFIC SIGNAL. LOST POWER STEERING BUT WAS ABLE TO MAINTAIN CONTROL. LESS THAN A MILE LATER WHEN SLOWING TO MAKE A TURN, ENGINE SHUTDOWN AND I LOST POWER STEERING. I WAS BARELY ABLE TO MISS STRIKING A HOUSE AT THE INTERSECTION. TRUCK STALLED TWICE DURING THE NEXT 2 MILE TRIP. I THINK THIS IS A VERY DANGEROUS PROBLEM AND IT IS NOT BEING ADDRESSED BY FORD OR IT'S DEALER. PLEASE INVESTIGATE. *TR UPDATED 10/2/2014
NHTSA complaint #10579448 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
ON APRIL 5, I WAS IN HE PROCESS OF STOPPING FOR A STOP SIGN, WHEN THE ENGINE STOPPED RUNNING. I WAS ABLE TO RESTART THE TRUCK. I DROVE LESS THAN 2 MILES, TURNED THE TRUCK OFF AND IT WOULD NOT RESTART. I HAD TRUCK TOWED TO AUTONATION FORD IN ST. PETERSBURG FL. MECHANIC NOT ON DUTY, BUT MONDAY (APRIL 7, 2014), SERVICE DEPARTMENT CALLED AND SAID NOTHING SHOWED UP ON THEIR COMPUTER CHECK, AND WAS STARTING FINE AFTER A MINOR ADJUSTMENT. I PICKED UP THE TRUCK, DROVE LESS THAN 2 MILES, WHEN IT STALLED AS I WAS IN THE PROCESS OF COMING TO A STOP, WHILE MY SPEED WAS ABOUT 30 MPH. LOST POWER STEERING BUT WAS ABLE TO MAINTAIN CONTROL. I WAS ABLE TO RESTART TRUCK AND RETURNED TO DEALER. TOLD THEM I DID NOT THINK I SHOULD HAVE TO PAY FOR A SECOND DIAGNOSTIC TEST, SINCE THEY HAD FAILED TO FIND OR FIX THE PROBLEM. ON APRIL 10, DEALER CALLED SAID THEY COULD NOT REPRODUCE THE PROBLEM AND SAID IT COULD BE EGR DIRTY OR TURBO BOOST. SINCE I HAD NOTICED TURBO WAS NOT KICKING IN PROPERLY DURING ACCELERATION FROM A STOP, I TOLD THEM TO DO BOTH BUT TO TAKE OFF THE $155 THEY HAD CHARGED ME FOR DIAGNOSIS. THEY AGREED AND MY TRUCK WAS RETURNED TO ME ON APRIL 12, 2014. ON APRIL 13, THE TRUCK STALLED WHEN COMING TO A STOP FOR A TRAFFIC SIGNAL. LOST POWER STEERING BUT WAS ABLE TO MAINTAIN CONTROL. LESS THAN A MILE LATER WHEN SLOWING TO MAKE A TURN, ENGINE SHUTDOWN AND I LOST POWER STEERING. I WAS BARELY ABLE TO MISS STRIKING A HOUSE AT THE INTERSECTION. TRUCK STALLED TWICE DURING THE NEXT 2 MILE TRIP. I THINK THIS IS A VERY DANGEROUS PROBLEM AND IT IS NOT BEING ADDRESSED BY FORD OR IT'S DEALER. PLEASE INVESTIGATE. *TR UPDATED 10/2/2014
NHTSA complaint #10579448 — an unverified report by a vehicle owner.
ENGINE
ON APRIL 5, I WAS IN HE PROCESS OF STOPPING FOR A STOP SIGN, WHEN THE ENGINE STOPPED RUNNING. I WAS ABLE TO RESTART THE TRUCK. I DROVE LESS THAN 2 MILES, TURNED THE TRUCK OFF AND IT WOULD NOT RESTART. I HAD TRUCK TOWED TO AUTONATION FORD IN ST. PETERSBURG FL. MECHANIC NOT ON DUTY, BUT MONDAY (APRIL 7, 2014), SERVICE DEPARTMENT CALLED AND SAID NOTHING SHOWED UP ON THEIR COMPUTER CHECK, AND WAS STARTING FINE AFTER A MINOR ADJUSTMENT. I PICKED UP THE TRUCK, DROVE LESS THAN 2 MILES, WHEN IT STALLED AS I WAS IN THE PROCESS OF COMING TO A STOP, WHILE MY SPEED WAS ABOUT 30 MPH. LOST POWER STEERING BUT WAS ABLE TO MAINTAIN CONTROL. I WAS ABLE TO RESTART TRUCK AND RETURNED TO DEALER. TOLD THEM I DID NOT THINK I SHOULD HAVE TO PAY FOR A SECOND DIAGNOSTIC TEST, SINCE THEY HAD FAILED TO FIND OR FIX THE PROBLEM. ON APRIL 10, DEALER CALLED SAID THEY COULD NOT REPRODUCE THE PROBLEM AND SAID IT COULD BE EGR DIRTY OR TURBO BOOST. SINCE I HAD NOTICED TURBO WAS NOT KICKING IN PROPERLY DURING ACCELERATION FROM A STOP, I TOLD THEM TO DO BOTH BUT TO TAKE OFF THE $155 THEY HAD CHARGED ME FOR DIAGNOSIS. THEY AGREED AND MY TRUCK WAS RETURNED TO ME ON APRIL 12, 2014. ON APRIL 13, THE TRUCK STALLED WHEN COMING TO A STOP FOR A TRAFFIC SIGNAL. LOST POWER STEERING BUT WAS ABLE TO MAINTAIN CONTROL. LESS THAN A MILE LATER WHEN SLOWING TO MAKE A TURN, ENGINE SHUTDOWN AND I LOST POWER STEERING. I WAS BARELY ABLE TO MISS STRIKING A HOUSE AT THE INTERSECTION. TRUCK STALLED TWICE DURING THE NEXT 2 MILE TRIP. I THINK THIS IS A VERY DANGEROUS PROBLEM AND IT IS NOT BEING ADDRESSED BY FORD OR IT'S DEALER. PLEASE INVESTIGATE. *TR UPDATED 10/2/2014
NHTSA complaint #10579448 — an unverified report by a vehicle owner.
STEERING
THE STEERING BOX FAILED, THE STEERING FAILED CAUSING THE OPERATOR TO LOSE CONTROL AND THEN HITTING A SNOW BANK WHICH ULTIMATELY CAUSE A ROLL OVER.
NHTSA complaint #10567796 — an unverified report by a vehicle owner.
WHEELS
WHILE TRAVELING HOME WITH MY FAMILY WE HIT A SMALL POTHOLE AND THE TRUCKS FRONT END STARTED TO SHAKE VIOLENTLY UP AND DOWN AND SIDE TO SIDE. I CLASP THE WHEEL TIGHTLY TO TRY TO CONTROL THE SHAKE WHILE APPLYING THE BRAKES TO SLOW THE TRUCK DOWN (WHICH DIDN'T HELP).AS THE TRUCK SLOWED DOWN TO ABOUT 20 MPH I WAS ABLE TO REGAIN CONTROL AND PULL OFF TO SAFETY FOR A VISUAL INSPECTION. UPON INSPECTION I COULD SEE NOTHING IMMEDIATELY WRONG. WHEN RETURNING HOME I LOOKED ONLINE AND FOUND THAT THERE ARE MANY F250 OWNERS FROM 2005/ CURRENT THAT HAVE HAD THE SAME THING HAPPEN. PLEASE HELP. THANK YOU
NHTSA complaint #10557657 — an unverified report by a vehicle owner.
STEERING
WHILE TRAVELING HOME WITH MY FAMILY WE HIT A SMALL POTHOLE AND THE TRUCKS FRONT END STARTED TO SHAKE VIOLENTLY UP AND DOWN AND SIDE TO SIDE. I CLASP THE WHEEL TIGHTLY TO TRY TO CONTROL THE SHAKE WHILE APPLYING THE BRAKES TO SLOW THE TRUCK DOWN (WHICH DIDN'T HELP).AS THE TRUCK SLOWED DOWN TO ABOUT 20 MPH I WAS ABLE TO REGAIN CONTROL AND PULL OFF TO SAFETY FOR A VISUAL INSPECTION. UPON INSPECTION I COULD SEE NOTHING IMMEDIATELY WRONG. WHEN RETURNING HOME I LOOKED ONLINE AND FOUND THAT THERE ARE MANY F250 OWNERS FROM 2005/ CURRENT THAT HAVE HAD THE SAME THING HAPPEN. PLEASE HELP. THANK YOU
NHTSA complaint #10557657 — an unverified report by a vehicle owner.
SUSPENSION
WHILE TRAVELING HOME WITH MY FAMILY WE HIT A SMALL POTHOLE AND THE TRUCKS FRONT END STARTED TO SHAKE VIOLENTLY UP AND DOWN AND SIDE TO SIDE. I CLASP THE WHEEL TIGHTLY TO TRY TO CONTROL THE SHAKE WHILE APPLYING THE BRAKES TO SLOW THE TRUCK DOWN (WHICH DIDN'T HELP).AS THE TRUCK SLOWED DOWN TO ABOUT 20 MPH I WAS ABLE TO REGAIN CONTROL AND PULL OFF TO SAFETY FOR A VISUAL INSPECTION. UPON INSPECTION I COULD SEE NOTHING IMMEDIATELY WRONG. WHEN RETURNING HOME I LOOKED ONLINE AND FOUND THAT THERE ARE MANY F250 OWNERS FROM 2005/ CURRENT THAT HAVE HAD THE SAME THING HAPPEN. PLEASE HELP. THANK YOU
NHTSA complaint #10557657 — an unverified report by a vehicle owner.
AIR BAGS
AIR BAG DEPLOYED OUT OF STEERING WHEEL UNEXPECTEDLY AFTER MAKING A LEFT TURN.
NHTSA complaint #10557470 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
VEHICLE ENGINE (6.0 DIESEL) UNEXPECTEDLY AND SUDDENLY DIED WHILE CLIMBING A NARROW MOUNTAIN STATE HIGHWAY, JUST IN BETWEEN SWITCHBACKS THAT HAD NO SHOULDERS; HAD ENOUGH SPEED TO JUST CLEAR ROAD ONTO A SHOULDER. NO WARNING LIGHTS, NO CHECK ENGINE LIGHT HAD EVER DISPLAYED PREVIOUSLY TO THIS INCIDENT. VEHICLE WOULD NOT START, TOWED TO LOCAL FORD DEALER. ENGINE TEARDOWN REVEALED LOSS OF HIGH PRESSURE OIL; AND FICM FAILURE AND GLOW PLUG MODULE FAULT BY OBD AND CHECK ENGINE LIGHT THAT NOW'S CONTINUOUSLY ILLUMINATED. STC FITTING REPLACED, DECLINED FICM AND GPM REPAIRS DUE TO COST AND VEHICLE ABLE TO RUN TO GET IT HOME. CHECK ENGINE LIGHT REMAINS ILLUMINATED. RESEARCH ON THE INTERNET REVEALS THESE 3 PARTS, AMONG OTHERS ON THE 6.0 ENGINE, HAVE EXTREMELY HIGH FAILURE RATES, ALL RESULTING IN AN IMMEDIATE LOSS OF POWER AND POTENTIAL STRANDING. THE MANUFACTURER AND DEALER WERE CONTACTED WITHOUT SATISFACTION. THE NHTSA NEEDS TO INVESTIGATE THIS AS A SAFETY AND INHERENT DEFECTIVE DESIGN OR MANUFACTURING ISSUE (AND COST!!!). IT MAY ALSO BE AN EMISSIONS CONTROL ISSUE AS THESE PARTS FAIL AND ARE NOT REPAIRED OR ARE REMOVED. THIS VEHICLE IS FACTORY STOCK AND DEALER MAINTAINED, HAD 6 YEAR, 75,000 MILE FORD EXTENDED WARRANTY.
NHTSA complaint #10554042 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
VEHICLE ENGINE (6.0 DIESEL) UNEXPECTEDLY AND SUDDENLY DIED WHILE CLIMBING A NARROW MOUNTAIN STATE HIGHWAY, JUST IN BETWEEN SWITCHBACKS THAT HAD NO SHOULDERS; HAD ENOUGH SPEED TO JUST CLEAR ROAD ONTO A SHOULDER. NO WARNING LIGHTS, NO CHECK ENGINE LIGHT HAD EVER DISPLAYED PREVIOUSLY TO THIS INCIDENT. VEHICLE WOULD NOT START, TOWED TO LOCAL FORD DEALER. ENGINE TEARDOWN REVEALED LOSS OF HIGH PRESSURE OIL; AND FICM FAILURE AND GLOW PLUG MODULE FAULT BY OBD AND CHECK ENGINE LIGHT THAT NOW'S CONTINUOUSLY ILLUMINATED. STC FITTING REPLACED, DECLINED FICM AND GPM REPAIRS DUE TO COST AND VEHICLE ABLE TO RUN TO GET IT HOME. CHECK ENGINE LIGHT REMAINS ILLUMINATED. RESEARCH ON THE INTERNET REVEALS THESE 3 PARTS, AMONG OTHERS ON THE 6.0 ENGINE, HAVE EXTREMELY HIGH FAILURE RATES, ALL RESULTING IN AN IMMEDIATE LOSS OF POWER AND POTENTIAL STRANDING. THE MANUFACTURER AND DEALER WERE CONTACTED WITHOUT SATISFACTION. THE NHTSA NEEDS TO INVESTIGATE THIS AS A SAFETY AND INHERENT DEFECTIVE DESIGN OR MANUFACTURING ISSUE (AND COST!!!). IT MAY ALSO BE AN EMISSIONS CONTROL ISSUE AS THESE PARTS FAIL AND ARE NOT REPAIRED OR ARE REMOVED. THIS VEHICLE IS FACTORY STOCK AND DEALER MAINTAINED, HAD 6 YEAR, 75,000 MILE FORD EXTENDED WARRANTY.
NHTSA complaint #10554042 — an unverified report by a vehicle owner.
ENGINE
VEHICLE ENGINE (6.0 DIESEL) UNEXPECTEDLY AND SUDDENLY DIED WHILE CLIMBING A NARROW MOUNTAIN STATE HIGHWAY, JUST IN BETWEEN SWITCHBACKS THAT HAD NO SHOULDERS; HAD ENOUGH SPEED TO JUST CLEAR ROAD ONTO A SHOULDER. NO WARNING LIGHTS, NO CHECK ENGINE LIGHT HAD EVER DISPLAYED PREVIOUSLY TO THIS INCIDENT. VEHICLE WOULD NOT START, TOWED TO LOCAL FORD DEALER. ENGINE TEARDOWN REVEALED LOSS OF HIGH PRESSURE OIL; AND FICM FAILURE AND GLOW PLUG MODULE FAULT BY OBD AND CHECK ENGINE LIGHT THAT NOW'S CONTINUOUSLY ILLUMINATED. STC FITTING REPLACED, DECLINED FICM AND GPM REPAIRS DUE TO COST AND VEHICLE ABLE TO RUN TO GET IT HOME. CHECK ENGINE LIGHT REMAINS ILLUMINATED. RESEARCH ON THE INTERNET REVEALS THESE 3 PARTS, AMONG OTHERS ON THE 6.0 ENGINE, HAVE EXTREMELY HIGH FAILURE RATES, ALL RESULTING IN AN IMMEDIATE LOSS OF POWER AND POTENTIAL STRANDING. THE MANUFACTURER AND DEALER WERE CONTACTED WITHOUT SATISFACTION. THE NHTSA NEEDS TO INVESTIGATE THIS AS A SAFETY AND INHERENT DEFECTIVE DESIGN OR MANUFACTURING ISSUE (AND COST!!!). IT MAY ALSO BE AN EMISSIONS CONTROL ISSUE AS THESE PARTS FAIL AND ARE NOT REPAIRED OR ARE REMOVED. THIS VEHICLE IS FACTORY STOCK AND DEALER MAINTAINED, HAD 6 YEAR, 75,000 MILE FORD EXTENDED WARRANTY.
NHTSA complaint #10554042 — an unverified report by a vehicle owner.