Owners have filed 89 complaints
about the 2012 Ford Flex with NHTSA between 2012 and 2025.
The largest single group is the steering.
Across this model's run it ranks 8 of 11 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 19
Against the median year of the Ford Flex. 50 means typical for this
model; 100 means roughly double.
Severity — 75
14.6% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 48
28% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
1,000 – 9,999 miles
1116.4%
10,000 – 24,999 miles
34.5%
25,000 – 49,999 miles
1420.9%
50,000 – 74,999 miles
811.9%
75,000 – 99,999 miles
69.0%
100,000 – 149,999 miles
1826.9%
150,000+ miles
710.4%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Aug 2012peak 5Dec 2025
Recalls on the 2012 Ford Flex
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 201928112,211 units in Canada
Suspension
Issue: On certain vehicles, a buildup of dirt and mud could cause the rear suspension toe links to break. This could result in a sudden loss of vehicle stability. Note: This problem affects vehicles operated in Alberta, Saskatchewan and Manitoba. The unique soil properties in this region could make a toe link more likely to break. Safety Risk: A loss of stability could increase the risk of a crash. Corrective Actions: The company will notify owners by mail and instruct them to take their vehicle to a dealer to install improved rear suspension toe links.
Recall 201522425,195 units in Canada
Steering
On certain vehicles, a fault in the Electric Power Steering (EPS) system could result in an immediate loss of power steering assist without warning to the driver. This would unexpectedly increase the steering effort force necessary to steer the vehicle at lower vehicle speeds, which could increase the risk of a crash causing injury and/or damage to property. Correction: Dealers will affect repairs as necessary and will reprogram the EPS controller with updated software. In the event that an EPS fault occurs, this updated software would allow for continued EPS function while displaying visual and audible warnings to the driver until the end of the drive cycle.
Reports where the owner recorded a crash, a fire, an injury or a death.
Oakland Park, FLCrash
STEERING
I went to my local dealership on request of the campaign recall for my associated vin The vehicle has a EPAS STEERING EFFORTS Details Description EPAS STEERING EFFORTS Campaign# 15N01 I was driving and lost control because the power steering went out brought it to my local Ford grieco fort Lauderdale and they diagnosed it as a bad power steering rack pinion which was included in the vin report recall however they stated it's 5 months over expiration which it should of never expired since it's a really bad safety issue. I called Ford directly they told me to contact you in regards to adding a valid recall back onto my vin
NHTSA complaint #11473310 — an unverified report by a vehicle owner.
at 40,000 milesRichmond, VACrash1 injured
AIR BAGS
TL* THE CONTACT OWNED A 2012 FORD FLEX. WHILE DRIVING 1 MPH, THE VEHICLE ACCELERATED BACKWARDS RAPIDLY AND CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED MINOR INJURIES TO THE KNEES, WHICH DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED AND TOWED TO RICHMOND FORD LINCOLN (4600 W BROAD ST, RICHMOND, VA 23230) WHERE THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.
NHTSA complaint #11057995 — an unverified report by a vehicle owner.
at 40,000 milesRichmond, VACrash1 injured
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNED A 2012 FORD FLEX. WHILE DRIVING 1 MPH, THE VEHICLE ACCELERATED BACKWARDS RAPIDLY AND CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED MINOR INJURIES TO THE KNEES, WHICH DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED AND TOWED TO RICHMOND FORD LINCOLN (4600 W BROAD ST, RICHMOND, VA 23230) WHERE THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.
NHTSA complaint #11057995 — an unverified report by a vehicle owner.
at 110,000 milesBattleboro, NCFire
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2012 FORD FLEX. WHILE THE VEHICLE WAS PARKED IN THE ENCLOSED GARAGE ATTACHED TO HIS HOME, A BURNING ELECTRICAL ODOR WAS NOTICED. THE CONTACT WENT TO THE GARAGE AND NOTICED FLAMES SURROUNDING THE FRONT OF THE VEHICLE. THE CONTACT OPENED THE HOOD AND FLAMES WERE VISIBLE BETWEEN THE REAR OF THE ENGINE AND WINDSHIELD. THE CONTACT EXTINGUISHED THE FIRE. THE FIRE AND POLICE DEPARTMENTS WERE NOT NOTIFIED. NO INJURIES WERE SUSTAINED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND ADVISED THE CONTACT TO CALL HIS AUTO INSURANCE COMPANY. NO FURTHER ASSISTANCE WAS OFFERED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHOM DETERMINED THE CAUSE OF THE FIRE AS BEING RELATED TO THE WIRING HARNESS LEADING TO THE POWER STEERING. THE VEHICLE WAS ALSO TOWED TO CAPITAL FORD LINCOLN OF ROCKY MOUNT (2012 STONE ROSE DR, ROCKY MOUNT, NC 27804 (252) 977-1234) WHERE THE WIRING HARNESS WAS DIAGNOSED AS THE CAUSE OF THE FAILURE AND REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000. CONSUMER STATED THE VEHICLE WAS NOT RUNNING, NOR WAS THERE A KEY IN THE IGNITION AT THE TIME OF THE FIRE. UPDATED 9/13/18
NHTSA complaint #11051705 — an unverified report by a vehicle owner.
at 110,000 milesBattleboro, NCFire
ENGINE
TL* THE CONTACT OWNS A 2012 FORD FLEX. WHILE THE VEHICLE WAS PARKED IN THE ENCLOSED GARAGE ATTACHED TO HIS HOME, A BURNING ELECTRICAL ODOR WAS NOTICED. THE CONTACT WENT TO THE GARAGE AND NOTICED FLAMES SURROUNDING THE FRONT OF THE VEHICLE. THE CONTACT OPENED THE HOOD AND FLAMES WERE VISIBLE BETWEEN THE REAR OF THE ENGINE AND WINDSHIELD. THE CONTACT EXTINGUISHED THE FIRE. THE FIRE AND POLICE DEPARTMENTS WERE NOT NOTIFIED. NO INJURIES WERE SUSTAINED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND ADVISED THE CONTACT TO CALL HIS AUTO INSURANCE COMPANY. NO FURTHER ASSISTANCE WAS OFFERED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHOM DETERMINED THE CAUSE OF THE FIRE AS BEING RELATED TO THE WIRING HARNESS LEADING TO THE POWER STEERING. THE VEHICLE WAS ALSO TOWED TO CAPITAL FORD LINCOLN OF ROCKY MOUNT (2012 STONE ROSE DR, ROCKY MOUNT, NC 27804 (252) 977-1234) WHERE THE WIRING HARNESS WAS DIAGNOSED AS THE CAUSE OF THE FAILURE AND REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000. CONSUMER STATED THE VEHICLE WAS NOT RUNNING, NOR WAS THERE A KEY IN THE IGNITION AT THE TIME OF THE FIRE. UPDATED 9/13/18
NHTSA complaint #11051705 — an unverified report by a vehicle owner.
at 50,000 milesSunnyside, WACrash
STEERING
POWER STEERING ASSIST FAILS; DRIVING AND THE POWER STEERING STOPS WORKING, SOMETIMES UNEXPECTEDLY. VERY DANGEROUS! IT IS SPORADIC--SOMETIMES IT WORKS AND OTHER TIMES IT DOES NOT WORK. USUALLY HAPPENS WHEN STATIONARY, AND TURNING IT ON--POWER STEERING WILL NOT ENGAGE FOR SEVERAL SECONDS. ONCE IT HAPPENED WHEN DRIVING AND I WAS LUCKY TO PULL OVER CAR. TURNED IT OFF AND BACK ON AND IT STARTED WORKING.
NHTSA complaint #11022692 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 180,000 milesDublin, GA
STEERING
The contact owns a 2012 Ford Flex. The contact stated that while driving at approximately 30 MPH, the ABS and the ESC warnings illuminated. The contact stated that she had recently heard an abnormal grinding sound while turning the steering wheel. The contact had taken the vehicle to an independent mechanic, where it was diagnosed and determined that the ABS sensor needed to be replaced. The contact stated that the mechanic had heard the abnormal sound coming from the steering wheel but had not run a diagnostic test. The vehicle was not repaired. The contact had researched online and had related the failure to NHTSA Campaign Number: 15V340000(Steering), however, the VIN was not included. The manufacturer was not informed of the failure. The failure mileage was approximately 180,000.
NHTSA complaint #11707853 — an unverified report by a vehicle owner.
Dublin, GA
STEERING
There is serious safety trouble occurring with the power steering components, and the brake system. I went to the Ford dealership and they said the recalls weren’t fixed back in 2015. And those recalls are the same issues that are occurring with my 2012 Ford Flex SE now. I just bought this vehicle and there is grinding noise when steering my vehicle and the ABS brake system comes on as soon as I crank up the vehicle and the brake goes down to the floor too loosely. The dealership says these potential recalls were noted for this 2012 Ford Flex in 2015. But the owner at the time didn’t have them fixed then because not all 2012 Ford Flex received the recalls at the same time. And the power steering components and brake system problems are very unsafe while I’m driving the vehicle and as I was told could cause a fatal car accident if not fixed.
NHTSA complaint #11707935 — an unverified report by a vehicle owner.
Dublin, GA
SERVICE BRAKES
There is serious safety trouble occurring with the power steering components, and the brake system. I went to the Ford dealership and they said the recalls weren’t fixed back in 2015. And those recalls are the same issues that are occurring with my 2012 Ford Flex SE now. I just bought this vehicle and there is grinding noise when steering my vehicle and the ABS brake system comes on as soon as I crank up the vehicle and the brake goes down to the floor too loosely. The dealership says these potential recalls were noted for this 2012 Ford Flex in 2015. But the owner at the time didn’t have them fixed then because not all 2012 Ford Flex received the recalls at the same time. And the power steering components and brake system problems are very unsafe while I’m driving the vehicle and as I was told could cause a fatal car accident if not fixed.
NHTSA complaint #11707935 — an unverified report by a vehicle owner.
Pollock Pines, CA
STEERING:ELECTRIC POWER ASSIST SYSTEM
Ford said the recall was fixed 10 years ago, however it went out on me last night. It's been towed to the Folsom Ford dealership in California, they quoted me $3,000 to fix my power steering assistant failure that had a Safety recall and it was a 'safety recall'. I couldn't steer my car. Very scary! please investigate this and make sure that it was fixed right the first time. it should not have gone out. I hardly drive my car. thank you
NHTSA complaint #11656456 — an unverified report by a vehicle owner.
at 40,000 milesEastvale, CA
STEERING
The contact owns a 2012 Ford Flex. The contact stated while the vehicle was parked, the vehicle intermittently became difficult to maneuver. The failure occurred on several occasions, including while the contact was driving. An unknown warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed that the power steering control module needed to be reprogrammed. The contact researched and was made aware of NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 40,000.
NHTSA complaint #11645654 — an unverified report by a vehicle owner.
Eastvale, CA
STEERING
vehicle power steering stops working. Manual steering is extremely difficult to operate.
NHTSA complaint #11644653 — an unverified report by a vehicle owner.
Laplace, LA
AIR BAGS
Front Passenger seat air bag light is on all the time. should I stop driving the car? Is this dangerous what does it mean? It is a 2012 Ford flex which I love and have not had any trouble with.
NHTSA complaint #11610567 — an unverified report by a vehicle owner.
at 108,000 milesEagle Point, OR
STEERING
The contact owns a 2012 Ford Flex. The contact stated while his granddaughter was driving 10 MPH and attempting to leave a parking lot, the steering wheel became difficult to maneuver. After the failure occurred, the "Power Steering Assist Fault" message was displayed. The vehicle was parked, and then the contact drove the vehicle to an independent mechanic. The contact was awaiting a diagnostic test from the independent mechanic but was informed that the rack and pinion might need to be replaced and the power train control module needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact researched online and became aware of NHTSA Campaign Numbers: 15V340000 (Steering) however, the VIN was not included in the recall. The failure mileage was approximately 108,000.
NHTSA complaint #11605133 — an unverified report by a vehicle owner.
South Wales, NY
WHEELS
I was driving around 55 and suddenly lost control and fish tailed to the right, then to the left over the center line, then back to the right. Luckily no other vehicles on the road. The rear driver side toe link broke. I discovered there's a recall for this exact problem with the exact possible worst case scenario that I went through. [FORD RECALL CODE: 2oSo4] This recall includes "2013-18 Ford Flex and Lincoln MKT vehicles built at Oakville Assembly Plant, Sept. 12, 2011, to June 1, 2017" My vehicle was manufactured at the same plant in 02/12 but for some reason is not qualified. I think my 2012 model needs to be included in this recall, obviously. I talked with Ford Dealer and Ford Customer Service and they said they would pass this info to NHTSA. I had both links replaced at a local mechanic and hope to get reimbursed in the future.
NHTSA complaint #11588893 — an unverified report by a vehicle owner.
South Wales, NY
SUSPENSION
I was driving around 55 and suddenly lost control and fish tailed to the right, then to the left over the center line, then back to the right. Luckily no other vehicles on the road. The rear driver side toe link broke. I discovered there's a recall for this exact problem with the exact possible worst case scenario that I went through. [FORD RECALL CODE: 2oSo4] This recall includes "2013-18 Ford Flex and Lincoln MKT vehicles built at Oakville Assembly Plant, Sept. 12, 2011, to June 1, 2017" My vehicle was manufactured at the same plant in 02/12 but for some reason is not qualified. I think my 2012 model needs to be included in this recall, obviously. I talked with Ford Dealer and Ford Customer Service and they said they would pass this info to NHTSA. I had both links replaced at a local mechanic and hope to get reimbursed in the future.
NHTSA complaint #11588893 — an unverified report by a vehicle owner.
Mount Carmel, PA
STEERING
The contact owns a 2012 Ford Flex. The contact stated while driving 60 MPH, the steering wheel stiffened while attempting to steer the vehicle to the left. The power steering failure message was displayed. The contact used excessive force to steer the vehicle to the shoulder of the highway where the vehicle remained. The contact called the dealer and was informed that the VIN was not included in NHTSA Campaign Number: 15V340000 (Steering). The contact was referred to the manufacturer who then referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was unknown.
NHTSA complaint #11533612 — an unverified report by a vehicle owner.
Eastvale, CA
STEERING
Vehicle power steering will stop working while driving and notification of (power steering assist failure) will appear. Vehicle becomes extremely unsafe to operate as the steering wheel is very difficult to move. I reached out to Ford and was advised that the recall for this was already repaired and a second recall was opened for vehicles that still had the issue. They advised that the recall only extended the warranty to 10 years and my vehicle is a few months past the 10 year mark with exceptions only made for mileage. My vehicle only has 48,000 miles.
NHTSA complaint #11524479 — an unverified report by a vehicle owner.
at 110,000 milesDefiance, OH
STEERING
The contact owns a 2017 Ford Flex. The contact stated that while driving at an undisclosed speed, the steering wheel started to wobble back and forth then up and down. The contact stated that the steering wheel started to shift upward and downward. No warning lights were illuminated. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 110,000.
NHTSA complaint #11518318 — an unverified report by a vehicle owner.
Merced,, CA
STEERING
Recall on power steering rack and pinion but my model didn't get covered in this recall and this the second time my service advance track came on and it's totally hard to turn my steering and I took it to Ford dealership in merced ca just to see if the cam turn off my service advance traction they said no because the rack and pinion is bad. . .....
NHTSA complaint #11516737 — an unverified report by a vehicle owner.
Lyons, CO
STEERING
Complete loss of power steering and steering effectiveness. Warning message on display said “power steering assist fault”.
NHTSA complaint #11512341 — an unverified report by a vehicle owner.
Oakland Park, FLCrash
STEERING
I went to my local dealership on request of the campaign recall for my associated vin The vehicle has a EPAS STEERING EFFORTS Details Description EPAS STEERING EFFORTS Campaign# 15N01 I was driving and lost control because the power steering went out brought it to my local Ford grieco fort Lauderdale and they diagnosed it as a bad power steering rack pinion which was included in the vin report recall however they stated it's 5 months over expiration which it should of never expired since it's a really bad safety issue. I called Ford directly they told me to contact you in regards to adding a valid recall back onto my vin
NHTSA complaint #11473310 — an unverified report by a vehicle owner.
Hacienda Heights, CA
UNKNOWN OR OTHER
Bad design of water pump , under parts would fail one day , but the water pump is a bad design. It failed too soon and hurt the engine. Also lots of work to fix it. But even if it get fixed the problem is still there...bad water pump
NHTSA complaint #11462538 — an unverified report by a vehicle owner.
Brownstown, MI
SUSPENSION
I am writing you in regards to NHTSA # 20V-072, Ford Recall # 20S04. I own a 2012 Ford Flex. It was not included in this recall. The recall included Ford Flex years 2013 through 2018. Though my SUV wasn’t included in the recall for the defective toe links, my SUV’s toe links were found to be defective on June 1, 2015 at Taylor Ford in Michigan. At that time my vehicle had 56,071 miles on it and was still under warranty. My toe links were replaced with part 5A972 which is the same part that is now the cause of Ford Recall 20S04. On 11-6-21 we took my SUV, with 96,930 miles, into Belle Tire for brake work and tire rotation. At that time we were told that the toe links were defective and needed to be replaced and that my tires were bad and needed replacement too. The tires and toe links had been replaced at Ford 40,859 miles prior! At this point we investigated and found the recall for the toe links. We had never been notified by Ford even though part 5A972 which was later found to be defective, had been put on our SUV in 2015. A Ford Part Employee has confirmed that this part is defective. The defective part is a welded part and the part Ford is using to replace this part is a forged part. Defective toe links are very dangerous. The defect can cause loss of steering/control of SUV. I have contacted multiple levels of Ford Customer Care with no response and no assistance offered. My SUV is currently at a Ford Service Center waiting for Ford to respond so that my SUV can be repaired. I'm unable to drive while waiting because this is very dangerous. It is also very expensive to repair.
NHTSA complaint #11443458 — an unverified report by a vehicle owner.
San Jose, CA
UNKNOWN OR OTHER
The water pump has faliure and is causing expensive repair. It seems to be a know defect. We some pending law suits.
NHTSA complaint #11435176 — an unverified report by a vehicle owner.
at 170,000 milesTucson, AZ
STRUCTURE:BODY
The contact owns a 2012 Ford Flex. The contact stated while rolling down the driver’s side window, she noticed some resistance and black marks at the bottom of the window. The contact stated that the seal around the window was deteriorating. The contact also stated that the failure was occurring on all the windows. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 170,000.
NHTSA complaint #11433798 — an unverified report by a vehicle owner.
at 170,000 milesTucson, AZ
VISIBILITY
The contact owns a 2012 Ford Flex. The contact stated while rolling down the driver’s side window, she noticed some resistance and black marks at the bottom of the window. The contact stated that the seal around the window was deteriorating. The contact also stated that the failure was occurring on all the windows. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 170,000.
NHTSA complaint #11433798 — an unverified report by a vehicle owner.
at 126,828 milesFlemington, WV
ENGINE
The contact owns a 2012 Ford Flex. The contact stated that the check engine warning light was illuminated. The vehicle was diagnosed and repaired however, the failure recurred and persisted. The contact was informed that the engine needed to be replaced. The manufacturer was informed of the failure but offered no assistance. The failure mileage was approximately 126,828.
NHTSA complaint #11425717 — an unverified report by a vehicle owner.
at 102,407 milesLitchfield, MI
SUSPENSION
MY VEHICLE WAS MANUFACTURED JUST A FEW MONTHS SHY OF A RECALL FOR BAD TOE LINKS IN THIS MAKE AND MODEL. I HAVE HAD MY CAR DIAGNOSED WITH HAVING BAD TOE LINKS AND WOULD LIKE TO SEE ABOUT GETTING MY VEHICLE INCLUDED IN THE RECALL SINCE IT WAS MANUFACTURED AROUND THE SAME TIME AS THE VEHICLES INCLUDED IN THE RECALL.
NHTSA complaint #11407044 — an unverified report by a vehicle owner.
at 95,000 milesAustin, TX
ENGINE
THROTTLE BODY HAS BEEN DIAGNOSED ON MY 2012 FORD FLEX. LOOKING AT VEHICLE HISTORY, THE SAME THROTTLE BODY HAS RECALLS FOR DIFFERENT MODELS. YESTERDAY, 9/252020, I HAD MY FLEX DIE ON ME THREE TIMES ON THE INTERSTATE DURING TRAFFIC. THE MILAGE IS UNDER 100K MILES. EVERY TIME THE VEHICLE DIES IS WHEN IM UNDER 30 MPH.
NHTSA complaint #11361256 — an unverified report by a vehicle owner.
at 84,500 milesGolden, CO
STEERING
WIFE RETURNED TO HER CAR AFTER A DAY OF DRIVING TO FIND THE POWER STEERING HAD SUDDENLY STOPPED WORKING. SHE DECIDED TO DRIVE IT HOME AND IT HAD MOMENTS WHERE THE POWER STEERING FUNCTIONED AND LUCKILY SHE GOT IT HOME. I CONTACTED FORD BUT THEY ADVISED ME THAT THERE IS NO ACTIVE BULLETIN FOR THIS PARTICULAR MODEL SO WE WOULD JUST NEED TO FIX IT.
NHTSA complaint #11360858 — an unverified report by a vehicle owner.