Owners have filed 272 complaints
about the 2009 Ford Flex with NHTSA between 2009 and 2026.
The largest single group is the engine & cooling.
Across this model's run it ranks 1 of 11 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 60
Against the median year of the Ford Flex. 50 means typical for this
model; 100 means roughly double.
Severity — 65
12.5% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 71
42% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
125.3%
1,000 – 9,999 miles
2611.5%
10,000 – 24,999 miles
2711.9%
25,000 – 49,999 miles
3917.3%
50,000 – 74,999 miles
3716.4%
75,000 – 99,999 miles
2711.9%
100,000 – 149,999 miles
4519.9%
150,000+ miles
135.8%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
These stars come from the pre-2011 crash test programme. NHTSA
rebuilt the programme for the 2011 model year and states that
ratings either side of that change are not comparable — so do
not read these against a 2011-or-newer car's stars.
Frontal crash test
Side barrier crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2009 Ford Flex 4-DR. w/SAB
—
—
—
15.1% risk
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Mar 2009peak 16Jul 2026
Recalls on the 2009 Ford Flex
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 201928112,211 units in Canada
Suspension
Issue: On certain vehicles, a buildup of dirt and mud could cause the rear suspension toe links to break. This could result in a sudden loss of vehicle stability. Note: This problem affects vehicles operated in Alberta, Saskatchewan and Manitoba. The unique soil properties in this region could make a toe link more likely to break. Safety Risk: A loss of stability could increase the risk of a crash. Corrective Actions: The company will notify owners by mail and instruct them to take their vehicle to a dealer to install improved rear suspension toe links.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 35 milesSanta Maria, CACrash1 injured
AIR BAGS
TAKATA RECALL THE AIR BAGS ARE OFF AND THE AIRBAG LIGHT FLASHES SOMETIMES WHEN DRIVING IT COMES IN MY DASHBOARD THO REMOVE ALL OBJECTS FROM BEHIND THE PASSENGER SIT OR DRIVER SIT WHEN THERE IS NOTHING THERE AND NOW IT DOESN'T WANNA ACELRATE MY CAR AT ALL IT PARKED NOW FOR 3 MONTHS
NHTSA complaint #11176673 — an unverified report by a vehicle owner.
at 35 milesSanta Maria, CACrash1 injured
VEHICLE SPEED CONTROL
TAKATA RECALL THE AIR BAGS ARE OFF AND THE AIRBAG LIGHT FLASHES SOMETIMES WHEN DRIVING IT COMES IN MY DASHBOARD THO REMOVE ALL OBJECTS FROM BEHIND THE PASSENGER SIT OR DRIVER SIT WHEN THERE IS NOTHING THERE AND NOW IT DOESN'T WANNA ACELRATE MY CAR AT ALL IT PARKED NOW FOR 3 MONTHS
NHTSA complaint #11176673 — an unverified report by a vehicle owner.
at 35 milesSanta Maria, CACrash1 injured
UNKNOWN OR OTHER
TAKATA RECALL THE AIR BAGS ARE OFF AND THE AIRBAG LIGHT FLASHES SOMETIMES WHEN DRIVING IT COMES IN MY DASHBOARD THO REMOVE ALL OBJECTS FROM BEHIND THE PASSENGER SIT OR DRIVER SIT WHEN THERE IS NOTHING THERE AND NOW IT DOESN'T WANNA ACELRATE MY CAR AT ALL IT PARKED NOW FOR 3 MONTHS
NHTSA complaint #11176673 — an unverified report by a vehicle owner.
Moorhead, MSFire
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2009 FORD FLEX. WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY, SMOKE APPEARED FROM THE HOOD AND THE VEHICLE SPONTANEOUSLY CAUGHT ON FIRE. THE CONTACT EXTINGUISHED THE FIRE AND DISCONNECTED THE BATTERY CABLES. THE AIR BAG WARNING INDICATOR WAS ILLUMINATED, BUT THE AIR BAGS DID NOT DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #11132720 — an unverified report by a vehicle owner.
Moorhead, MSFire
ENGINE
TL* THE CONTACT OWNS A 2009 FORD FLEX. WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY, SMOKE APPEARED FROM THE HOOD AND THE VEHICLE SPONTANEOUSLY CAUGHT ON FIRE. THE CONTACT EXTINGUISHED THE FIRE AND DISCONNECTED THE BATTERY CABLES. THE AIR BAG WARNING INDICATOR WAS ILLUMINATED, BUT THE AIR BAGS DID NOT DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #11132720 — an unverified report by a vehicle owner.
at 50,150 milesST. Peters, MOCrash1 injured
AIR BAGS
EXITING HWY AT 50 MPH, HIT BRAKE. HARD BRAKE PEDAL-NO BRAKES FOLLOWED BY ENGINE FULL THROTTLE ACCELERATION-VEHICLE WAS SENT TO THE FORD DEALER IN OCT FOR A CHECK ENG LIGHT THAT COULDN'T BE EXTINGUISHED. COMPUTER WAS REFLASHED WITH BASIC PROM. NO OTHER ISSUES UNTIL ACCIDENT
NHTSA complaint #11114580 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Goshen, IN
WHEELS
On February 26, 2026, I purchased a used 2009 Ford Flex VIN from Header’s Auto Sales. At time of delivery, the vehicle was equipped with tires that did not meet the manufacturer’s required load rating for this vehicle. A licensed mechanic provided a safety assessment confirming the tires were improperly load-rated and unsafe to carry the vehicle load. We were not informed of this issue at sale. To make the vehicle safe to drive, I replaced all 4 tires at my cost. Improper load-rated tires can result in tire failure, loss of vehicle control, and crash. Dealer sold vehicle "as-is" without disclosure of this safety defect.
NHTSA complaint #11750984 — an unverified report by a vehicle owner.
Canton, KS
UNKNOWN OR OTHER
You can be driving down the road, and all your gauges will stop working, and all the warning lights on the dash will light up. The first time this happened my wife got stuck at a gas station all the warning lights were on and the car would not start, people tried to jump it and it would not affected at all. I looked on the internet and found were someone said to beat on the passenger side floorboard, I called my wife and told her to try that, and when she did the car would start. It doesn't do it all the time, you never know when it's going to happen. We have to just stomp on the passenger floor to get everything to start working again. If I had not found this information from somebody else on the internet my wife would have been stuck about a hundred miles from home. I've taken it to the Ford house and they say they've never heard of anything like this but I know it's happened before two other people that's how I knew to stomp on the floorboard on the passenger side.
NHTSA complaint #11704068 — an unverified report by a vehicle owner.
Canton, KS
ELECTRICAL SYSTEM
You can be driving down the road, and all your gauges will stop working, and all the warning lights on the dash will light up. The first time this happened my wife got stuck at a gas station all the warning lights were on and the car would not start, people tried to jump it and it would not affected at all. I looked on the internet and found were someone said to beat on the passenger side floorboard, I called my wife and told her to try that, and when she did the car would start. It doesn't do it all the time, you never know when it's going to happen. We have to just stomp on the passenger floor to get everything to start working again. If I had not found this information from somebody else on the internet my wife would have been stuck about a hundred miles from home. I've taken it to the Ford house and they say they've never heard of anything like this but I know it's happened before two other people that's how I knew to stomp on the floorboard on the passenger side.
NHTSA complaint #11704068 — an unverified report by a vehicle owner.
Enfield, CT
UNKNOWN OR OTHER
Rear subframe rusted at bolt mount. Vehicle could have experienced catastrophic failure wihle driving. Independent service center diagnosed and documented rusted area and potential for failure. Noise would happen during acceleration/deceleration but not in wet weather conditions. Until diagnosed as unsafe to drive, vehicle drove with rear passenger side sitting on rear spring, potentially causing spring to rust prematurely.
NHTSA complaint #11647208 — an unverified report by a vehicle owner.
Clover, SC
UNKNOWN OR OTHER
The door ajar sensor malfunctions and is crazy expensive to fix. There are numerous posts and videos online of workarounds bcz it’s so common but they don’t seem safe since that’s a safety feature and the workarounds are simply a way to trick or bypass the warning sensors since the doors are actually closed in most cases. Ford needs to take ownership of this and issue a recall. There’s a tire pressure sensor failure as well.
NHTSA complaint #11524140 — an unverified report by a vehicle owner.
Clover, SC
ELECTRICAL SYSTEM
The door ajar sensor malfunctions and is crazy expensive to fix. There are numerous posts and videos online of workarounds bcz it’s so common but they don’t seem safe since that’s a safety feature and the workarounds are simply a way to trick or bypass the warning sensors since the doors are actually closed in most cases. Ford needs to take ownership of this and issue a recall. There’s a tire pressure sensor failure as well.
NHTSA complaint #11524140 — an unverified report by a vehicle owner.
Springdale, MD
STEERING
Was driving and the steering wheel became stiff. I received no warnings indications or lights on the dash. I had to give it a hard turn to get it to a parking lot and have it towed to a dealership.
NHTSA complaint #11518395 — an unverified report by a vehicle owner.
Mullins, SC
ENGINE
About 5 miles from home with no warning.The car went from regular temp to hot then stopped.Water mixed with the oil.The tech said the water pump just failed.I did not have any problems with it running hot or anything.
NHTSA complaint #11469695 — an unverified report by a vehicle owner.
Sheboygan, WI
SUSPENSION
While driving around February 20th, 2022 we started swerving uncontrollably and almost ran into the curb and flipped while going about 40 MPH. My husband put on breaks but it felt like we were sliding on ice....without any ice on the road. We almost flipped and were very shaken, and lucky. We got vehicle to Firestone and they said our left rear toe link had broke. Supposedly our vehicle year is not part of the recall, I think it should be. Thank you
NHTSA complaint #11458320 — an unverified report by a vehicle owner.
at 160,000 milesGoodrich, MI
SERVICE BRAKES, HYDRAULIC
The contact owns a 2009 Ford Flex. The contact stated that after refueling the vehicle, the odor of fuel was present coming from the vehicle. After parking inside the garage, there was fuel leaking from the seam of the fuel tank on the passenger’s side. The cause of the failure was not yet determined. Also, while attempting to stop the vehicle, the brake pedal would extend to the floor and the vehicle would not immediately stop. The contact determined that the brake booster was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and an unknown dealer were notified of the failure. The failure mileage was approximately 160,000.
NHTSA complaint #11425398 — an unverified report by a vehicle owner.
Scottsdale, AZ
POWER TRAIN
My Flex has repeatedly lost power while driving. I can feel the car lose power, and the yellow wrench light comes on. After reading up on it, I learned that you have to turn the vehicle off, wherever you are, and restart it after a few minutes. The wrench light turns off, and the car runs as normal, with no records of codes. This is talked about over and over in online forums. The safety issue is that it has happened on the freeway several times while traveling at a high rate of speed. The car loses power, and you cannot accelerate. You have to find a way to stop immediately, put the car in park (and listen to the transmission clunk) and turn it off. This last instance put me in harms way on the freeway. The car lost power while traveling 70mph. I immediately lost speed and had to cross 3 lanes of traffic to pull over to turn the car off. All of the forums talk about the throttle body, but everyone says that’s not the issue. The OSS and TSS sensors are also discussed. The dealerships cannot find out what’s wrong because once the car is turned off and restarted, any codes are erased. The issue persists, and the car keeps losing power wherever and whenever. I am referencing the most recent incident on this form, however, this has happened at least 12 times since September, 2020. Please, please force a recall on this issue!
NHTSA complaint #11417809 — an unverified report by a vehicle owner.
Scottsdale, AZ
VEHICLE SPEED CONTROL
My Flex has repeatedly lost power while driving. I can feel the car lose power, and the yellow wrench light comes on. After reading up on it, I learned that you have to turn the vehicle off, wherever you are, and restart it after a few minutes. The wrench light turns off, and the car runs as normal, with no records of codes. This is talked about over and over in online forums. The safety issue is that it has happened on the freeway several times while traveling at a high rate of speed. The car loses power, and you cannot accelerate. You have to find a way to stop immediately, put the car in park (and listen to the transmission clunk) and turn it off. This last instance put me in harms way on the freeway. The car lost power while traveling 70mph. I immediately lost speed and had to cross 3 lanes of traffic to pull over to turn the car off. All of the forums talk about the throttle body, but everyone says that’s not the issue. The OSS and TSS sensors are also discussed. The dealerships cannot find out what’s wrong because once the car is turned off and restarted, any codes are erased. The issue persists, and the car keeps losing power wherever and whenever. I am referencing the most recent incident on this form, however, this has happened at least 12 times since September, 2020. Please, please force a recall on this issue!
NHTSA complaint #11417809 — an unverified report by a vehicle owner.
Scottsdale, AZ
ENGINE
My Flex has repeatedly lost power while driving. I can feel the car lose power, and the yellow wrench light comes on. After reading up on it, I learned that you have to turn the vehicle off, wherever you are, and restart it after a few minutes. The wrench light turns off, and the car runs as normal, with no records of codes. This is talked about over and over in online forums. The safety issue is that it has happened on the freeway several times while traveling at a high rate of speed. The car loses power, and you cannot accelerate. You have to find a way to stop immediately, put the car in park (and listen to the transmission clunk) and turn it off. This last instance put me in harms way on the freeway. The car lost power while traveling 70mph. I immediately lost speed and had to cross 3 lanes of traffic to pull over to turn the car off. All of the forums talk about the throttle body, but everyone says that’s not the issue. The OSS and TSS sensors are also discussed. The dealerships cannot find out what’s wrong because once the car is turned off and restarted, any codes are erased. The issue persists, and the car keeps losing power wherever and whenever. I am referencing the most recent incident on this form, however, this has happened at least 12 times since September, 2020. Please, please force a recall on this issue!
NHTSA complaint #11417809 — an unverified report by a vehicle owner.
at 138,000 milesDacula, GA
ENGINE
LAST NIGHT, I WENT TO BACK THE CAR OUT OF THE GARAGE AND WHILE IN REVERSE, THE ENGINE STARTED REVVING UP UNCONTROLLABLY AND EVEN THOUGH I HAD MY FOOT ON THE BRAKES, IT KEPT MOVING IN REVERSE. I QUICKLY PUT IT IN NEUTRAL AND THE REVVING CAME DOWN. SHUT DOWN THE CAR, RESTARTED IT AND THIS TIME, I PUT IT IN DRIVE AND THE SAME THING HAPPEN AGAIN ONLY TO START LUNGING FORWARD EVEN WHILE BRAKING. IF I WERE IN TRAFFIC OR AT A STOP LIGHT OR SIGN, I WOULD HAVE SURELY HIT THE PERSON(S) IN FRONT OR BEHIND ME. LATER MY WIFE EXPLAINED TO ME THIS HAPPENED WHILE DRIVING ON THE INTERSTATE AND SHE HAD A HARD TIME CONTROLLING THE SPEED, DUE TO REVVING, EVEN WHILE USING THE BRAKE. SHE MANAGED TO TAKE AN EXIT RAMP INTO A LARGE PARKING LOT USING EXTREME BRAKING (FORCEFUL) AND SHUT THE CAR OFF. SHE WAS ABLE TO MAKE IT HOME SHORTLY THEREAFTER. I WAITED UNTIL AFTER 8PM TO DRIVE WHEN THERE WAS LITTLE OR NO TRAFFIC TO DRIVE TO THE CLOSEST CAR REPAIR SHOP TO DROP IT OFF AND THERE HAPPENED TO BE A MECHANIC LEAVING AS I WAS PULLING UP. I DESCRIBED THE PROBLEM AND HE MENTIONED THAT IT WAS A DEFINITELY A SAFETY ISSUE AND ADVISED NOT TO DRIVE IT UNTIL IT GOT DIAGNOSED & REPAIRED. I'VE OWNED A LOT OF CARS IN MY LIFE AND EXPERIENCING UNCONTROLLABLE REVVING WHILST THE TRANSMISSION IS ENGAGED IS A FRIGHTENING EXPERIENCE. LUCKILY WE KEPT OUR WITS AND WERE ABLE TO RECOVER. I ALSO SEE WHERE THIS HAS ALREADY BEEN REPORTED ON THIS SITE. THIS IS A REAL SAFETY ISSUE AND I'M THANKFUL NO ONE WAS INJURED LAST NIGHT, INCLUDING MY WIFE AND CHILDREN. PLEASE, PLEASE CHECK INTO THIS AS THIS IS NOT NORMAL BEHAVIOR AND A SERIOUS SAFETY CONCERN.
NHTSA complaint #11404610 — an unverified report by a vehicle owner.
Wyoming, MI
UNKNOWN OR OTHER
ELECTRIC SYSTEM
NHTSA complaint #11374622 — an unverified report by a vehicle owner.
Princess Anne, MD
ENGINE
TL* THE CONTACT OWNS A 2009 FORD FLEX. THE CONTACT STATED WHILE HIS WIFE WAS DRIVING 55 MPH, THE VEHICLE SHIFTED INDEPENDENTLY INTO NEUTRAL. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE DRIVER PULLED OVER ON THE SIDE OF THE ROAD. THE VEHICLE WAS RESTARTED AND DRIVEN TO HER DESTINATION. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER SAFFORD FORD LINCOLN OF SALISBURY LOCATED AT 1902 N SALISBURY BLVD, SALISBURY, MD 21801, (443) 210-4835, AND WAS DIAGNOSED. THE CONTACT WAS INFORMED THAT AN UNKNOWN PART NEEDED TO BE REPLACED ALONG WITH A SOFTWARE UPDATE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #11374357 — an unverified report by a vehicle owner.
at 132,000 milesBAY City, MI
VEHICLE SPEED CONTROL
WHILE BRAKING AND PARKING MY VEHICLE, MY VEHICLE HAD UNWANTED ACCELERATION. GOING AS HIGH AS 120MPH AND HOLDING THE BRAKE THE VEHICLE WAS STILL MOVING. I HAD TO HURRY AND SHIFT INTO PARK AND TURN OFF MY VEHICLE. OTHER TIMES THIS HAS HAPPENED WHILE COMING STOP AND IT WOULD GO UP TO ABOUT 40MPH AND I WOULD DESPERATELY HOLD THE BRAKE SCARED I WOULD HIT SOMEONE
NHTSA complaint #11366889 — an unverified report by a vehicle owner.
Indianapolis, IN
ENGINE
MY CRADLE IS RUSTED THROUGH ALL THE WAY TO THE LOWER CONTROL ARM AND HAS A VISIBLE CRACK. I'M TOLD THIS IS A SAFETY ISSUE AND CONCERN AS WELL AS A SAFETY HAZARD WHEN ONE CAN BE INJURED DUE TO THE ENGINE FALLING OUT TO NAME ONE. I'M TOLD BY A MECHANIC THIS IS A FACTORY DEFAULT.I AM VERY CONCERNED AND WOULD GREATLY APPRECIATE SOME ASSISTANCE WITH THIS MATTER. SINCERELY, [XXX] 09/05/2020 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11353314 — an unverified report by a vehicle owner.
at 170,000 milesLivonia, MI
STEERING
THIS IS THE THIRD TIME THE POWER STEERING HAS FAILED IN THIS VEHICLE. I WAS DRIVING 60 MPH AND WITHOUT WARNING THE STEERING SEIZED. LUCKILY I WAS DRIVING IN RIGHT LANE AND WAS ABLE TO GET VEHICLE SAFELY TO A LOT. THERE WAS NO WARNING, NO NOISES, NO DASHBOARD LIGHTS CAME ON. THE STEERING BECAME VERY TIGHT AND WAS EXTREMELY DIFFICULT TO TURN THE WHEEL.
NHTSA complaint #11328645 — an unverified report by a vehicle owner.
at 133,615 milesPalmyra, VA
ENGINE
I WAS DRIVING ABOUT 45 MILE PER HR. THEN MY FORD FLEX STARTED TO STALL SO I HAD IT TOWED TO A NEAR BY REPAIR SHOP , THEY LOOKED OVER MY VEHICLE AND THEY CAME TO THE CONCLUSION, THAT THE WATER PIMP HAD FAILED AND COOLANT ENTERED THE BLOCK, SO THERE FOR THE ENGINE NEEDED TO BE REPLACE. WE ARE NOW IN THE PROCESS OF THE REPAIR INVOICE 369486 02/28/2020
NHTSA complaint #11317747 — an unverified report by a vehicle owner.
Springdale, MD
ENGINE
WHEN DRIVING AND THE CAR BEGINS TO ACCELERATE PAST 40MPH THE CAR SHUDDERS AND JERKS. THIS HAS BEEN GOING ON FOR OVER A YEAR. THE FORD DEALER TEST DROVE IT AND COULDN'T DUPLICATE WHAT I EXPERIENCE OFTEN.
NHTSA complaint #11308909 — an unverified report by a vehicle owner.
at 120,000 milesOlympia, WA
ENGINE
THE VEHICLE OVER HEATS, AND JUST GETS TOO HOT. IF THE A/C IS RUNNING IT OVER HEATS JUST SITTING AT THE LIGHT. NOW THAT IT IS COOLER, THE HEATER IS ON AND IT OVER HEATS JUST SITTING AT THE LIGHT. I STOP THE CAR AND LET IT COOL DOWN BUT IT SHOULD NOT BE OPERATING LIKE THIS. THERE ARE MANY PROBLEMS DESCRIBING THIS SAME PROBLEM AND IT IS A FACTORY DEFECT AND NEEDS TO BE CORRECTED. NO REASON JUST SITTING AT A STOP LIGHT FOR THE CAR TO OVER HEAT.
NHTSA complaint #11282312 — an unverified report by a vehicle owner.
at 169,000 milesWillow Grove, PA
POWER TRAIN
TL* THE CONTACT OWNS A 2009 FORD FLEX. WHILE THE KEY WAS IN THE IGNITION, THE ANTI-LOCK WARNING INDICATOR ILLUMINATED. THE CONTACT WAS UNABLE TO START THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED, BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE DEALER STATED THAT THE SECURE LOCK SYSTEM NEEDED TO BE REPROGRAMMED BY THE DEALER. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND TRANSFERRED THE CONTACT TO NHTSA TO FILE A COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 169,000.
NHTSA complaint #11279599 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2009 FORD FLEX. WHILE THE KEY WAS IN THE IGNITION, THE ANTI-LOCK WARNING INDICATOR ILLUMINATED. THE CONTACT WAS UNABLE TO START THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED, BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE DEALER STATED THAT THE SECURE LOCK SYSTEM NEEDED TO BE REPROGRAMMED BY THE DEALER. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND TRANSFERRED THE CONTACT TO NHTSA TO FILE A COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 169,000.
NHTSA complaint #11279599 — an unverified report by a vehicle owner.
Detroit, MI
ELECTRICAL SYSTEM
WHEN DRIVING DOWN CITY HIGHWAY OR CITY ROADS THE ALL OF THE LIGHTS ON THE DASH BOARD WILL CUT OFF, (IE. RADIO, BLINKERS, HEAT & A/C CONTROLS) WILL SHUT OFF AND THE DRIVE CONTROL BUTTON WILL APPEAR WITH THE DOOR AJAR AND BRAKE LIGHTS. IT IS NOW STARTING TO MAKE A DINGING SOUND WHILE YOU DRIVE AS WELL AS SMELL LIKE SOMETHING IS ON FIRE. THE CAR IS COMPLETELY SHUT AND SEALED. THERE ISN'T A TIME OR INSTANT WHERE THIS IS HAPPENING. IT WILL JUST GO IN AND OUT! FORD YOU REALLY NEED TO FIX THIS PROBLEM SINCE FAMILIES ARE USING THESE VEHICLES. I'VE DONE SOME RESEARCH AND SEE THAT IT IS A COMMON PROBLEM WITH THE 09 FLEX.
NHTSA complaint #11229095 — an unverified report by a vehicle owner.
