Owners have filed 148 complaints
about the 2019 Ford Fusion Energi with NHTSA between 2019 and 2025.
The largest single group is the electrical system.
Across this model's run it ranks 1 of 7 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 100
Against the median year of the Ford Fusion Energi. 50 means typical for this
model; 100 means roughly double.
Severity — 14
2.7% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 89
52% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2019 compares with every other Ford Fusion Energi
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
14.3%
1,000 – 9,999 miles
14.3%
10,000 – 24,999 miles
417.4%
25,000 – 49,999 miles
1356.5%
50,000 – 74,999 miles
313.0%
75,000 – 99,999 miles
14.3%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
Configuration
Overall
Front
Side
Rollover
2019 Ford Fusion Energi 4 DR FWD
—
—
—
10.9% risk
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jul 2019peak 19Jul 2025
NHTSA investigations into the 2019 Ford Fusion Energi
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
DP22005Opened 27 Jan 2023Closed 7 Aug 2023ELECTRICAL SYSTEM:PROPULSION SYSTEM
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after Marc...
Recalls on the 2019 Ford Fusion Energi
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
19V099000
HYBRID PROPULSION SYSTEM
Ford Motor Company (Ford) is recalling certain 2019 Fusion Energi Hybrid models. The affected vehicles may not adequately protect against direct and indirect contact of high voltage sources during normal operation. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 305, "Electric-Powered Vehicles: Electrolyte spillage and electrical shock protection."
Risk: Potential contact with high voltage sources increases the risk of injury.
Reports where the owner recorded a crash, a fire, an injury or a death.
Melbourne, FLFire
UNKNOWN OR OTHER
1. What component or system failed or malfunctioned, and is it available for inspection upon request? Answer: The Hybrid system/battery caught fire. The vehicle is with the Insurance company Allstate, I believe should be available for inspection upon request. 2. How was your safety or the safety of others put at risk? Answer: The vehicle caught fire after just dropping my kid in to his school, the school has to be evacuated as the vehicle burned near the building. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Answer: There is an existing recall "Phev battery cell degragation" from Ford. Here is the Campaign/NHTSA#: 23S33/23V440 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Answer: The Fire Marshall and the Police was present and we had Police report(case num: [XXX]) and Fire Marshall report(case num: [XXX]) 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Answer: I did notice an unusual behavior, like minutes before the fire the AC fan suddenly turned up blowing a non cold air, I attempted to turn off the vehicle 2 or 3 times until the fan and the vehicle completely turned off. I turned it back on to have AC again and it was good, after like less than 5 minutes I turned off the vehicle to get out of the car with my kid to drop him in his school. Minutes after I returned to the car, there was already smoke, had to call 911 after that. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11631314 — an unverified report by a vehicle owner.
Melbourne, FLFire
ELECTRICAL SYSTEM
1. What component or system failed or malfunctioned, and is it available for inspection upon request? Answer: The Hybrid system/battery caught fire. The vehicle is with the Insurance company Allstate, I believe should be available for inspection upon request. 2. How was your safety or the safety of others put at risk? Answer: The vehicle caught fire after just dropping my kid in to his school, the school has to be evacuated as the vehicle burned near the building. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Answer: There is an existing recall "Phev battery cell degragation" from Ford. Here is the Campaign/NHTSA#: 23S33/23V440 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Answer: The Fire Marshall and the Police was present and we had Police report(case num: [XXX]) and Fire Marshall report(case num: [XXX]) 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Answer: I did notice an unusual behavior, like minutes before the fire the AC fan suddenly turned up blowing a non cold air, I attempted to turn off the vehicle 2 or 3 times until the fan and the vehicle completely turned off. I turned it back on to have AC again and it was good, after like less than 5 minutes I turned off the vehicle to get out of the car with my kid to drop him in his school. Minutes after I returned to the car, there was already smoke, had to call 911 after that. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11631314 — an unverified report by a vehicle owner.
at 48,000 milesDoylestown, PA1 injured
ELECTRICAL SYSTEM
The contact owns a 2019 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. Recently while driving at 25 MPH, the contact stated that an abnormal, popping sound emitted from the vehicle. An unknown "red triangle" and an unknown warning message also appeared on the instrument panel. The cabin began to fill with heavy grayish smoke as the contact and her husband immediately exited the vehicle. The authorities were called to the scene and disconnected all electrical wires from the vehicle. No fire was reported. A police report was filed. The contact's husband, who recently had surgery on his left rotator cuff, fell on his left shoulder upon exiting the vehicle. The contact's husband sought medical treatment from a doctor who examined the shoulder; no additional injuries were discovered; however, the contact's husband sustained additional pain upon falling from the vehicle. The vehicle was initially towed to an independent mechanic where upon examination, the mechanic recommended that the vehicle be taken to a dealer. The vehicle was then towed to the dealer where it remained in their possession for an inspection. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The vehicle had yet to be repaired. The failure mileage was 48,000. VIN tool confirms parts not available.
NHTSA complaint #11587651 — an unverified report by a vehicle owner.
Simi Valley, CAFire
ELECTRICAL SYSTEM
Vehicle stopped accelerating, heard pop in vehicle behind me, all lite dash symbols flash and displayed message, stop vehicle safely now. Next morning, turn on vehicle to place into neutral to load onto tow truck to take to dealer, kept going back to park, while pulling vehicle onto tow truck, cabin filled with smoke, opened trunk, filling with smoke and then call 911 and fire dept extinguished fire. Have fire report, video and photos. Opened case number with Ford, been over a month and they state it is with the office of general council, unable to make contact with that dept. and customer service at Ford states they can not talk to me besides note i call. It is case number CAS-40994553-Q9P8R4
NHTSA complaint #11510269 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Wantagh, NY
ELECTRICAL SYSTEM
The contact owns a 2019 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V44000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the vehicle was taken to the dealer where it was confirmed that the HV battery needed to be replaced. The contact was informed that the HV battery was ordered on June 6,2025. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact was informed that parts were on back order and there was no delivery date available. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11673691 — an unverified report by a vehicle owner.
st Louis, MO
FUEL/PROPULSION SYSTEM
re. recall 23V-440 Issued June 2023 as of March 2025 (one year and 9 months later), on remedy. they now claim one will be available 3Q25, but they also estimated a fix 3Q24. this is an UNACCEPTABLE amount of time to not have a fix and have a formal recommendation not to charge the vehicle.
NHTSA complaint #11648589 — an unverified report by a vehicle owner.
Watertown, WI
ELECTRICAL SYSTEM
The contact owns a 2019 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11642233 — an unverified report by a vehicle owner.
at 30,000 milesHampshire, TN
SEATS
The contact owns a 2019 Ford Fusion Energi. The contact stated that the battery was inoperable. The contact was unable to use the rapid charger. The contact was unable to charge the vehicle. The contact stated that the heated seats were inoperable. The check engine warning light was illuminated. The contact was concerned about using the vehicle. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was not diagnosed or repaired. The dealer informed the contact not to use the rapid charger. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 30,000. Parts distribution disconnect.
NHTSA complaint #11639549 — an unverified report by a vehicle owner.
at 30,000 milesHampshire, TN
ELECTRICAL SYSTEM
The contact owns a 2019 Ford Fusion Energi. The contact stated that the battery was inoperable. The contact was unable to use the rapid charger. The contact was unable to charge the vehicle. The contact stated that the heated seats were inoperable. The check engine warning light was illuminated. The contact was concerned about using the vehicle. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was not diagnosed or repaired. The dealer informed the contact not to use the rapid charger. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 30,000. Parts distribution disconnect.
NHTSA complaint #11639549 — an unverified report by a vehicle owner.
at 30,000 milesHampshire, TN
ENGINE
The contact owns a 2019 Ford Fusion Energi. The contact stated that the battery was inoperable. The contact was unable to use the rapid charger. The contact was unable to charge the vehicle. The contact stated that the heated seats were inoperable. The check engine warning light was illuminated. The contact was concerned about using the vehicle. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was not diagnosed or repaired. The dealer informed the contact not to use the rapid charger. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 30,000. Parts distribution disconnect.
NHTSA complaint #11639549 — an unverified report by a vehicle owner.
Stantonville, TN
VISIBILITY/WIPER
Window tint on passenger back side window and rear window is so bad that it impairs viewing
NHTSA complaint #11638392 — an unverified report by a vehicle owner.
Port St. Lucie, FL
ELECTRICAL SYSTEM
See attached document for complaint
NHTSA complaint #11636347 — an unverified report by a vehicle owner.
Peachtree City, GA
ELECTRICAL SYSTEM
The contact owns a 2019 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (ELECTRICAL SYSTEM) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11634706 — an unverified report by a vehicle owner.
Melbourne, FLFire
UNKNOWN OR OTHER
1. What component or system failed or malfunctioned, and is it available for inspection upon request? Answer: The Hybrid system/battery caught fire. The vehicle is with the Insurance company Allstate, I believe should be available for inspection upon request. 2. How was your safety or the safety of others put at risk? Answer: The vehicle caught fire after just dropping my kid in to his school, the school has to be evacuated as the vehicle burned near the building. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Answer: There is an existing recall "Phev battery cell degragation" from Ford. Here is the Campaign/NHTSA#: 23S33/23V440 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Answer: The Fire Marshall and the Police was present and we had Police report(case num: [XXX]) and Fire Marshall report(case num: [XXX]) 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Answer: I did notice an unusual behavior, like minutes before the fire the AC fan suddenly turned up blowing a non cold air, I attempted to turn off the vehicle 2 or 3 times until the fan and the vehicle completely turned off. I turned it back on to have AC again and it was good, after like less than 5 minutes I turned off the vehicle to get out of the car with my kid to drop him in his school. Minutes after I returned to the car, there was already smoke, had to call 911 after that. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11631314 — an unverified report by a vehicle owner.
Melbourne, FLFire
ELECTRICAL SYSTEM
1. What component or system failed or malfunctioned, and is it available for inspection upon request? Answer: The Hybrid system/battery caught fire. The vehicle is with the Insurance company Allstate, I believe should be available for inspection upon request. 2. How was your safety or the safety of others put at risk? Answer: The vehicle caught fire after just dropping my kid in to his school, the school has to be evacuated as the vehicle burned near the building. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Answer: There is an existing recall "Phev battery cell degragation" from Ford. Here is the Campaign/NHTSA#: 23S33/23V440 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Answer: The Fire Marshall and the Police was present and we had Police report(case num: [XXX]) and Fire Marshall report(case num: [XXX]) 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Answer: I did notice an unusual behavior, like minutes before the fire the AC fan suddenly turned up blowing a non cold air, I attempted to turn off the vehicle 2 or 3 times until the fan and the vehicle completely turned off. I turned it back on to have AC again and it was good, after like less than 5 minutes I turned off the vehicle to get out of the car with my kid to drop him in his school. Minutes after I returned to the car, there was already smoke, had to call 911 after that. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11631314 — an unverified report by a vehicle owner.
Thorofare, NJ
ELECTRICAL SYSTEM
The contact owns a 2019 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V440000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11629088 — an unverified report by a vehicle owner.
Chesterfield, MO
ELECTRICAL SYSTEM
RE: outstanding recall issued 7/17/23 unresolved as of 11/16/24 UNACCEPTABLE DURATION Unable to operate as intended using rechargeable battery which used to comprise 90% of my driving miles. Significantly increased fuel costs for 14 months and counting.
NHTSA complaint #11625677 — an unverified report by a vehicle owner.
Alliance, OH
ELECTRICAL SYSTEM
The contact owns a 2019 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11618639 — an unverified report by a vehicle owner.
Placentia, CA
ELECTRICAL SYSTEM
The contact owns a 2018 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V440000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the battery was unable to be recharged. The vehicle was taken to the dealer; however, the vehicle could not be repaired because parts were not yet available. The manufacturer was made aware of the issue. The failure mileage was unknown. Parts distribution disconnect.
NHTSA complaint #11617739 — an unverified report by a vehicle owner.
Holmes, NY
ELECTRICAL SYSTEM
This is my 2nd complaint on the non action to repair this recall. Ford's latest attempt to NOT repair the electrical defect is to buy my car. Their offer does meet the cost of buying a replacement car. Is Ford so inept that they cannot repair their own products? The offer to buy the car sends a red flag up. Is Ford's "solution" to buy my car an attempt to acquire cars to resell at a profit? If Ford cannot repair a defect that was diagnosed a long time ago, should they be allowed to continue to manufacture and sell cars in the United States? Has Ford been sanctioned in any way for this defect?
NHTSA complaint #11609784 — an unverified report by a vehicle owner.
Lake Mary, FL
ELECTRICAL SYSTEM
See attached document for complaint
NHTSA complaint #11608229 — an unverified report by a vehicle owner.
Lake Mary, FL
ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM)
See attached document for complaint
NHTSA complaint #11608229 — an unverified report by a vehicle owner.
San Marino, CA
ELECTRICAL SYSTEM
See attached document for complaint
NHTSA complaint #11607268 — an unverified report by a vehicle owner.
Hampshire, TN
ELECTRICAL SYSTEM
The contact owns a 2019 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V440000 (Electric System). However, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect
NHTSA complaint #11604300 — an unverified report by a vehicle owner.
at 43,000 milesPalos Hills, IL
ELECTRICAL SYSTEM
The contact owns a 2019 Ford Fusion Energi. The contact received advance notice notification from the dealer that a failure with the charging system might cause the vehicle to catch on fire however, the part to repair the charging system was not available. The dealer was contacted; however, the vehicle was not repaired. The contact had not experienced a failure. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 43,000.
NHTSA complaint #11602292 — an unverified report by a vehicle owner.
Hawthorne, CA
ELECTRICAL SYSTEM
The contact owns a 2019 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11596272 — an unverified report by a vehicle owner.
Haskell, NJ
ELECTRICAL SYSTEM
The contact owns a 2019 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11592342 — an unverified report by a vehicle owner.
Oxnard, CA
POWER TRAIN
The lane keep assist does not work basically , it can't detect the lines , due to the recall I can't charge my car which I paid much more than regular ford fusion. To be able to use the Electric miles and save on gas , also the 3G modem stopped working and ford has no fix for that , took it to different dealers and they say even if I replace the old modem with a new 4G, (paying out of my own pocket !!) most likely the app and remote connection will not work .
NHTSA complaint #11591440 — an unverified report by a vehicle owner.
Cupertino, CA
ELECTRICAL SYSTEM
The contact owns a 2019 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11591544 — an unverified report by a vehicle owner.