Owners have filed 49 complaints
about the 2020 Ford Fusion Energi with NHTSA between 2019 and 2026.
The largest single group is the electrical system.
Across this model's run it ranks 5 of 7 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 44
Against the median year of the Ford Fusion Energi. 50 means typical for this
model; 100 means roughly double.
Severity — 11
2% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
67% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2020 compares with every other Ford Fusion Energi
Odometer readings owners gave when they filed. About half of all
complaints include one.
1,000 – 9,999 miles
116.7%
25,000 – 49,999 miles
466.7%
50,000 – 74,999 miles
116.7%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Dec 2019peak 7Jul 2026
NHTSA investigations into the 2020 Ford Fusion Energi
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
DP22005Opened 27 Jan 2023Closed 7 Aug 2023ELECTRICAL SYSTEM:PROPULSION SYSTEM
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after Marc...
Complaints that involved harm
Reports where the owner recorded a crash, a fire, an injury or a death.
at 30,000 milesBayonne, NJFire
ENGINE
The contact stated their son owned a 2020 Ford Fusion. The contact stated that their son was driving at approximately 35 MPH, when the vehicle's instrument panel illuminated all possible warning lights. Then there was smoke emitting from the vehicle near the driver's feet. The driver pulled to the side of the road where they turned off the vehicle. The vehicle then caught on fire under the hood of the vehicle. The fire department was called and distinguished the fire. A fire report was filed. The vehicle was towed and deemed totaled. There were no injuries. The manufacturer was made aware of the failure and then opened a case regarding the failure. The approximate failure mileage was 30,000.
NHTSA complaint #11489756 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Springfield, VA
ELECTRICAL SYSTEM
I am filing a complaint regarding Ford Safety Recall 23S33 (NHTSA Campaign 23V440) for my 2020 Ford Fusion Energi. I brought my freshly purchased vehicle to my local authorized dealer, Sheehy Ford, to fix the high-voltage battery replacement recall. The dealership told me they had to order the part before they could schedule the repair. They have since stated that Ford corporate is experiencing low stock and is not allocating the necessary remedy parts to the dealer network, and referred me to call Ford corporate. Purchased this vehicle on 21 March 2026; took it to dealer to get the recall fixed on 23 March. Dealer said it would be delayed due to the recall being started in [XXX] (where the vehicle was shipped from via carmax, and sold to me in [XXX]). After a month, the dealer opened a case with Ford corporate (XXX). I called to check status, was put on hold for 20 minutes, then transferred, and was then disconnected. It has been 4 months since I took it in to get the recall repaired. The manufacturer is failing to provide a timely safety remedy as required by federal law, leaving me to drive a vehicle with a documented risk of fire and sudden loss of motive power. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11752722 — an unverified report by a vehicle owner.
Washington, DC
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
PLEASE SEE ATTACHMENT
NHTSA complaint #11709600 — an unverified report by a vehicle owner.
Palm Desert, CA
ELECTRICAL SYSTEM
The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11643358 — an unverified report by a vehicle owner.
at 45,541 milesStony Brook, NY
ELECTRICAL SYSTEM
The contact owns a 2020 Ford Fusion Hybrid. The contact was unable to charge the vehicle. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact called another local dealer, Ford of Smithtown (440 Middle Country Rd., St. James, NY 11780). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The manufacturer offered a buyback. The failure mileage was approximately 45,541. Parts distribution disconnect.
NHTSA complaint #11626444 — an unverified report by a vehicle owner.
Las Vegas, NV
ELECTRICAL SYSTEM
The contact owns a 2020 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11596180 — an unverified report by a vehicle owner.
Phoenix, AZ
ELECTRICAL SYSTEM
The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11590186 — an unverified report by a vehicle owner.
Millersburg, OR
ELECTRICAL SYSTEM
The center console display unit acts as though "ghost fingers" (internet term) are continuously exercising the display, since at least December 2023. If on climate, it will turn the climate controls on and off, and if on phone, it will attempt to delete phone contacts. The only screen that is safe to leave the display at, is navigation, so that it continually flickers and moves the map around the state, country and world. I cannot turn off the steering heater, or change climate direction to vent or floor without accessing the climate screen while driving. I have had to unpair my phone, and so 911-assist is no longer available. Periodically while driving, the screen will switch over to climate controls, and then I have to switch it back, pressing navigation multiple times until it responds, while driving. These actions make driving the vehicle UNSAFE. The dealer acknowledged an internal bulletin in January, that said a software update was needed to address this known issue, but none was available. They have been unwilling to provide any of that in writing. Please contact me for a 165Mb video of the the screen, which includes my attempts to access screen functions.
NHTSA complaint #11589483 — an unverified report by a vehicle owner.
Torrance, CA
ELECTRICAL SYSTEM
The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11587930 — an unverified report by a vehicle owner.
Las Vegas, NV
ELECTRICAL SYSTEM
I am aware of the recall on the ford fusion plug in hybrid and for that reason I do not plug it in. We are supposed to use this as a regular hybrid until the fix comes out. That said, my car turns off randomly in traffic. All the warning lights turn on and the car fully shuts down and has to restart. This happens without warning, while in traffic. Last week it happened 3 times on one single drive home from picking up the kids from school. This is not supposed to happen if we aren’t plugging it in, but it’s happening and ford said they think it’s related to the recall (they’re holding on to it for the next five days and I’m on my own for car rental fees). Totally unsafe to just stop working in traffic, even when not using EV mode. This is going to hurt someone.
NHTSA complaint #11585961 — an unverified report by a vehicle owner.
Las Vegas, NV
ENGINE
I am aware of the recall on the ford fusion plug in hybrid and for that reason I do not plug it in. We are supposed to use this as a regular hybrid until the fix comes out. That said, my car turns off randomly in traffic. All the warning lights turn on and the car fully shuts down and has to restart. This happens without warning, while in traffic. Last week it happened 3 times on one single drive home from picking up the kids from school. This is not supposed to happen if we aren’t plugging it in, but it’s happening and ford said they think it’s related to the recall (they’re holding on to it for the next five days and I’m on my own for car rental fees). Totally unsafe to just stop working in traffic, even when not using EV mode. This is going to hurt someone.
NHTSA complaint #11585961 — an unverified report by a vehicle owner.
Sacramento, CA
ELECTRICAL SYSTEM
The contact owns a 2020 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V440000 (Electric System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11585270 — an unverified report by a vehicle owner.
Morrisville, PA
ELECTRICAL SYSTEM
The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11581133 — an unverified report by a vehicle owner.
New Providence, PA
ELECTRICAL SYSTEM
Five months after buying our 2020 Ford Fusion Energi plug-in hybrid, Ford issued a recall stating that it was unsafe to plug it in. Now, going on 10 months later, Ford still has not corrected this safety issue. They continually say they're working on it, but I paid for a car that I didn't get. This car is not a plug-in hybrid if life-threatenting risk of fire or "loss of motive power" means I can't plug it in.
NHTSA complaint #11580854 — an unverified report by a vehicle owner.
Pine River, MN
ELECTRICAL SYSTEM
This is a PHEV Fusion. Prior to the recall I noticed a red light coming from the "box" that is part of the charging cord. I disconnected the charging cord from the wall outlet. Upon a closer inspection I found that there had been a fire inside the receptacle box that had burnt a hole in the box and destroyed the receptacle. I replaced the receptacle and box and continued charging the battery and suspected that there had been a fault in the receptacle. However, I received recall 23S33 in July 2023 and now think the fire I experienced might have been due to the Battery Energy Control Module as referenced in the recall. I no longer am charging the battery as suggested in the recall. It has been 8 months since I received the recall and the only thing I have heard from Ford is a check for $250.00 to help with the added fuel cost due to not being able to use the plug in capability.
NHTSA complaint #11580483 — an unverified report by a vehicle owner.
Pine River, MN
ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM):SOFTWARE
This is a PHEV Fusion. Prior to the recall I noticed a red light coming from the "box" that is part of the charging cord. I disconnected the charging cord from the wall outlet. Upon a closer inspection I found that there had been a fire inside the receptacle box that had burnt a hole in the box and destroyed the receptacle. I replaced the receptacle and box and continued charging the battery and suspected that there had been a fault in the receptacle. However, I received recall 23S33 in July 2023 and now think the fire I experienced might have been due to the Battery Energy Control Module as referenced in the recall. I no longer am charging the battery as suggested in the recall. It has been 8 months since I received the recall and the only thing I have heard from Ford is a check for $250.00 to help with the added fuel cost due to not being able to use the plug in capability.
NHTSA complaint #11580483 — an unverified report by a vehicle owner.
Philadelphia, PA
SERVICE BRAKES, HYDRAULIC
The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11578949 — an unverified report by a vehicle owner.
Sunnyvale, CA
ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM)
See attached document for complaint
NHTSA complaint #11576790 — an unverified report by a vehicle owner.
Oswego, NY
ELECTRICAL SYSTEM
The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11576533 — an unverified report by a vehicle owner.
Shingle Springs, CA
ELECTRICAL SYSTEM
The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11574479 — an unverified report by a vehicle owner.
Colorado Springs, CO
ELECTRICAL SYSTEM
The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11573338 — an unverified report by a vehicle owner.
Sj, CA
ELECTRICAL SYSTEM
Battery recall was sent out 6/2023, unable to charge vehicle and use as intended hybrid . $250 gas compensation in 8 months . Not being addressed in a reasonable timeframe .
NHTSA complaint #11572210 — an unverified report by a vehicle owner.
Galena, KS
ELECTRICAL SYSTEM
The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was made aware of the issue and confirmed that the parts were not yet available. The manufacturer was not notified of the issue. The contact had not experienced a failure. VIN tool confirms part not available.
NHTSA complaint #11570012 — an unverified report by a vehicle owner.
Titusville, NJ
ELECTRICAL SYSTEM
This car is a plug-in hybrid. Ford told owners NOT to charge their cars as of June 16, 2023, and they still don't have a solution. It's January 30, 2024. That's 228 days or 62% of a year or 7.6 months. I don't consider that a timely recall. Jun 16, 2023 Manufacturer Recall Number23S33 NHTSA Recall Number23V440 Recall Status Recall Incomplete, remedy not yet available
NHTSA complaint #11568684 — an unverified report by a vehicle owner.
Titusville, NJ
ENGINE
This car is a plug-in hybrid. Ford told owners NOT to charge their cars as of June 16, 2023, and they still don't have a solution. It's January 30, 2024. That's 228 days or 62% of a year or 7.6 months. I don't consider that a timely recall. Jun 16, 2023 Manufacturer Recall Number23S33 NHTSA Recall Number23V440 Recall Status Recall Incomplete, remedy not yet available
NHTSA complaint #11568684 — an unverified report by a vehicle owner.
Wallis, TX
ENGINE
Ford has issued a recall for which they have offered no remedy. The recall recommends not using the DEFINING feature of the vehicle; the entire purpose for which it was purchased: i.e. the short but meaningful electric range. Ford say the vehicle should not be charged due to an engineering fault that may lead to a fires. The issue has led to thousands of dollars in extra fuel cost and, in my state at least, Ford is refusing to buyback the vehicle.
NHTSA complaint #11568916 — an unverified report by a vehicle owner.