2006 Ford Fusion electrical problems

ELECTRICAL SYSTEM

Faulty evap temperature sensor on my 06 Ford Fusion I purchased a couple of months ago. It is a huge safety issue, the vehicle thinks it’s running ICE COLD when it’s over 100 degrees outside. It emits hot or fluctuating air at random and it’s giving wrong readings which can cause the car to overheat or not sense when it is overheating. I do not know if the needle is correct and if it’s about to smoke or not.

NHTSA complaint #11432703 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

THE AIRBAGS NEVER WORKED THE CAR KEEPS SAYING CHECK CHARGING SYSTEM EVEN THOUGH MY BATTERY IS BRAND NEW AND ALSO MY FRONT RIGHT TIRE SOUNDS LIKE LOOSE METAL

NHTSA complaint #11404163 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

COMPUTER SHORT CIRCUITED CAUSING CAR TO MISFIRE MELTING THE COIL AND COULD HAVE SET THE CAR ON FIRE. THIS IS A SAFETY ISSUE. MY MECHANIC SAID THIS IS THE SECOND FORD HE HAS SEEN DO THIS. HE STATED IT IS DANGEROUS.

NHTSA complaint #11400176 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I GOT A 06 FORD FUSION THAT I READ ABOUT ,IT STAYED THAT FORD MOTORS WAS WELL AWARE OF THE E-VAP SENSOR FOR THE AIRCONDITON IT STOP MY COMPRESSOR FOR TURNING ON [THE CAUSE WAS EVAPORATOR DISCHARGE AIR TEMPERATURE SENSOR]FORD IS WELL AWARE THAT THE SENSORS ARE FAULTY"I THINK THIS IS A SAFETY MATTER BECAUSE OF THE HIGH HEAT TEMPERATURES. WHILE DRIVING WE SHOULD FEEL COMFORTABLE NOT TIRED FROM HEAT EXHAUSTION

NHTSA complaint #11339599 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

CITY OF DOWNEY CA L. DO NOT HAVE FIX PARKING PERMITS TO PARK AT THIS LOCATION? ADDRESS REQUIRES REPAVING DRIVE WAY...? AT: 11739 TRISTAN DR LOT#1234 BUCKLES ST DOWNEY, CA 90241-1551 USA

NHTSA complaint #11279655 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

DRIVERS SIDE FRONT TURN SIGNAL DOES NOT FLASH, STAYS SOLID. CHANGED THE BULB, DOES THE SAME THING.

NHTSA complaint #11113468 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE SMART JUNCTION BOX FAILED TO FUNCTION CAUSING THE BATTERY AND ALL OF THE TURN SIGNAL FUNCTIONS TO FAIL. A DEALER HAD NOT DIAGNOSED THE VEHICLE BUT AN INDEPENDENT MECHANIC DIAGNOSED THAT THE SMART JUNCTION BOX NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, PROVIDED NO SOLUTION, AND INDICATED THAT THERE WAS NO RECALL. THE CONTACT WAS CONCERNED IF THE PART WAS REPLACED THAT THE FAILURE WOULD CONTINUE. THE APPROXIMATE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA complaint #11081226 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* TAKATA RECALL. THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THERE WAS A BEEPING NOISE AND THE AIR BAG WARNING INDICATOR ILLUMINATED. ALSO, THE VEHICLE FAILED TO CRANK. THE BATTERY WAS RECHARGED, THE VEHICLE RESTARTED, AND THE WARNING INDICATOR DIMMED. THE DEALER (PARK FORD, 400 WEST AVE, TALLMADGE, OH 44278, (330) 633-6222) WAS NOTIFIED OF THE FAILURE AND DID NOT PROVIDE A SPECIFIC DIAGNOSIS. THE DEALER WAS ALSO UNABLE TO DETERMINE WHEN THE REMEDY AND REPAIR PART WOULD BE SUPPLIED TO SCHEDULE THE RECALL REPAIR FOR NHTSA CAMPAIGN NUMBER: 16V384000 (AIR BAGS). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA complaint #11054981 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

"TAKATA RECALL" SND I WAS DRIVING VEHICLE WHEN TURN SIGNALS ON BOTH FRONT RIGHT AND LEFT SIDE STOPPED WORKING. RIGHT FRONT TURN SIGNAL JUST STAYED ON , SO I HAD TO DISCONNECT IT OTHERWISE IT WOULD HAVE DRAINED THE BATTERY. I REPLACED BOTH BULBS WITH NEW ONES, STILL DID NOT WORK. I GET A MESSAGE SAYING CHECK RIGHT FRONT AND LEFT FRONT TURN SIGNALS. I HAVE FOUND OUT THAT THIS HAS HAPPENED TO A LOT OF 2006 FORD FUSIONS, IT IS A SAFETY ISSUE WHEN CARS FRONT SIGNAL INDICATORS DONT WORK. I WAS TOLD THE SMART JUNCTION BOX NEEDS TO BE REPLACED. FORD HAS KNOWN ABOUT THIS PROBLEM,AND DONE NOTHING!

NHTSA complaint #11039865 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

WHILE DRIVING MY ENGINE INTERMITTENTLY SHUTS OFF. THE CAR WILL STILL BE "ON". IN THE SENSE THAT THE AC AND RADIO AND OTHER FEATURES ARE STILL WORKING, BUT THE CAR WILL NOT ACCELERATE OR MOVE. I HAVE TO PUT IT IN PARK. AND RESTART IT. "CHECK ENGINE" AND "CHECK CHARGING SYSTEM" INDICATOR LIGHTS POP UP ON THE DASH. I HAVE DONE SEVERAL THINGS, CHANGE BELTS, CHANGED ALTERNATORS, CHANGED CAM SHAFTS, AND FINALLY AFTER THAT THOUSAND DOLLARS WAS SPENT THE CODE I'M GETTING READ FROM MY MECHANIC IS FOR THE THROTTLE BODY SHUT DOWN.

NHTSA complaint #11014889 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2006 FORD FUSION. WHILE DRIVING 15 MPH, THE TURN SIGNALS BECAME INOPERABLE AND THE ENGINE STALLED. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SMART JUNCTION BOX FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 114,000.

NHTSA complaint #10969765 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

THE REAR TAIL LIGHT SOCKET AND BULB ARE CHARRED BLACK AS IF THEY CAUGHT FIRE. I FOUND THE ISSUE BECAUSE THE SIGNAL LIGHT FAILED. IT SMELLED BURNT. UNSURE IF THERE WAS ACTUAL FLAME OR NOT.

NHTSA complaint #10927571 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I WAS DRIVING HOME FROM WORK, WHEN BOTH OF MY FRONT TURN SIGNALS WENT OUT. MY DASH INDICATED TO CHECK LF TURN LAMP AND CHECK RF TURN LAMP. I STOPPED AT THE STORE TO PURCHASE NEW BULBS, THINKING THE BULBS WERE BAD. I GOT HOME, AND NOTICED THAT THE LEFT FRONT PARKING LAMP WAS ON. I SHUT THE CAR OFF, AND THE LIGHT REMAINED ON. I HAD TO DISCONNECT THE LIGHT, OTHERWISE IT WOULD HAVE DRAINED MY BATTERY. I HAD NO FRONT WORKING TURN SIGNALS AND NO WORKING HAZARDS IN THE FRONT. THE BACK SIGNALS AND HAZARDS WORK FINE, BUT BLINK FAST.

NHTSA complaint #10917205 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

DRIVING ON THE HIGHWAY AT 80 MPH THE CAR LOOSES ACCELERATION POWER AND AN ORANGE WRENCH SYMBOL SHOWS UP ON THE DASHBOARD. I HAVE TO SAFELY COAST MY VEHICLE TO A SAFE SPOT OFF THE ROAD. WHEN CAR COMES TO COMPLETE STOP IT IDLES REALLY ROUGH AND LOUD AND MAKES A LOUD NOISE WHEN PLACED INTO PARK. I HAVE TO SHUT CAR OFF THEN RESTART AND I'M ABLE TO CONTINUE DRIVING AS IF NOTHING EVER HAPPENED. THE PROBLEM KEEPS HAPPENING AND IS STARTING TO OCCUR MORE OFTEN BUT ALWAYS WHILE DRIVING ON THE HIGHWAY...PRAY TO GOD NOTHING SERIOUS EVER HAPPENS.

NHTSA complaint #10910410 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

DRIVING BOTH HIGHWAY AND CITY STREETS. WHILE DRIVING TO WORK MY TURN LEFT SIGNAL BEGAN TO FLASH FASTER INDICATING A BURNED OUT BULB WHEN THE RIGHT TURN SIGNAL STARTED FLASHING FASTER. AFTER WORK I COULD NOT UNLOCK MY CAR AND HAD TO HAVE SECURITY UNLOCK MY CAR ONLY TO FIND MY BATTERY WAS DEAD. SECURITY THEN JUMPED STARTED THE CAR, I DROVE OFF TO BATTLE MY THRU RUSH HOUR WITH OUT TURN SIGNALS. THE NEXT MORNING THE CAR BATTERY WAS DEAD AGAIN, AFTER GETTING IT STARTED I NOTICED THE RIGHT FRONT TURN SIGNAL BULB STAYED ON EVEN WHEN THE CAR WAS TURNED OFF,UNTIL BATTERY WAS DRAINED. I TOOK IT TO MY MECHANIC HE SAID THE SMART BOX WOULD NEED TO BE REPLACED AND PROGRAMED, AND COST ABOUT $850! I WENT TO PICKUP THE VEHICLE HAD TROUBLE UNLOCKING THE DOOR AGAIN THIS TIME THE BATTERY WAS DEAD AGAIN AND NEEDED TO BE REPLACED.

NHTSA complaint #10894998 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH, THE VEHICLE ACCELERATED AND DECELERATED INDEPENDENTLY AS THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ECM FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 121,759.

NHTSA complaint #10824786 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

WHILE DRIVING MY FUSION ON 11/1/15, BOTH FRONT TURN SIGNALS STOPPED WORKING WHEN ATTEMPTING TO MAKE A TURN ONTO AN INTERSTATE. THE DASH INDICATED A WARNING THAT THE LEFT AND RIGHT FRONT TURN SIGNAL LAMP WAS NOT WORKING WHEN THE SIGNAL WAS ACTIVATED BY THE SWITCH. I ASSUMED A BULB HAD BURNT OUT. HOWEVER, ONCE MY CAR WAS TURNED COMPLETELY OFF, THE LEFT FRONT BULB REMAINED ON, DESPITE NO ONE BEING IN THE CAR. THE LIGHT REMAINED ON FOR MULTIPLE HOURS BEFORE I BECAME AWARE OF IT ONCE I RETURNED TO MY VEHICLE. DURING THIS TIME, IT WAS DRAINING THE BATTERY. I THE. HAD TO DRIVE MY CAR ON CITY STREETS AND THE INTERSTATE TO GET HOME. I TRIED PURCHASING NEW BULBS, BUT FOUND THAT BOTH BULBS CURRENTLY IN THE CAR WORKED FINE. NO WIRING WAS LOOSE OR FRAYED. LATER THAT WEEK, I BROUGHT IT TO A MECHANIC WHO DIAGNOSED IT AS A FAILED SMART JUNCTION BOX THAT HAS LED TO THE TURN SIGNAL NOT WORKING. I CONTACTED MY LOCAL DEALERSHIP IN ACCORDANCE WITH MY MECHANIC'S SUGGESTION. I WAS INFORMED THERE IS NO RECALL ON THIS PART. HOW IS THERE NO RECALL WHEN THIS IS CLEARLY A SAFETY ISSUE? MALFUNCTIONING TURN SIGNALS WHILE DRIVING WITH NO DIRECT CAUSE IS A PROBLEM. ESPECIALLY WHEN IT LEADS TO A LIGHT REMAINING ON LEADING TO KILLING THE CAR BATTERY. ACCORDING TO THE DEALERSHIP, THE ONLY SOLUTION IS PURCHASING A NEW JUNCTION BOX FROM THEM (NO LOCAL PARTS STORES CAN EVEN FIND ONE IN THEIR INVENTORY) AND HAVE IT INSTALLED AND PROGRAMMED BY THEM.

NHTSA complaint #10788959 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

CAR WOULD CUT OFF AT ANY TIME, AND CUT OFF SEVERAL TIMES WHILE IN MOTION.. HAD TO BE TOWED TWICE AND FINALLY ON 10/1/14 TOOK IT TO A FORD DEALERSHIP AND THEY REPAIRED IT AT A COST TO ME OF $1,462.98. SINCE THE FOCUS HAS A RECALL I WONDER IF THIS SHOULD ALSO HAVE A RECALL.

NHTSA complaint #10780883 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

AFTER PARKING MY CAR OUTSIDE MY HOUSE, I OPENED MY DOOR AND THE HANDLE SHORT CIRCUITED AND EXPLODED BLOWING OUT A PIECE OF THE DOOR HANDLE OFF EXPOSING THE THE HANDLES SPRINGS AND WIRING.

NHTSA complaint #10714191 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

CAR DIES WHILST DRIVING. THIS IS A SAFETY ISSUE. AUTHORIZED FORD DEALER SERVICE DETERMINED ISSUE WAS CAUSED BY A DEFECTIVE THROTTLE BODY.

NHTSA complaint #10712343 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

MY BRAKE LIGHTS AND REAR BLINKERS ARE NO LONGER WORKING. ONE DAY THEY JUST WENT OUT. OF COURSE I TOOK IT TO MY MECHANIC RIGHT AWAY SINCE IT IS EXTREMELY DANGEROUS DRIVING AT NIGHT WITH NO BRAKE LIGHTS AND I HAD RECENTLY ENROLLED INTO NIGHT CLASSES FOR MY FALL SEMESTER. I LEFT MY CAR WITH MY MECHANIC FOR NEARLY A WEEK BECAUSE HE THOUGHT THE SWITCH NEEDED TO BE REPLACED. HE ORDERED A NEW ONE, BUT WHEN IT ARRIVED HE CALLED TO TELL ME THAT IT WASN'T WHAT HE THOUGHT IT WAS. HE LET ME KEEP THE NEW SWITCH FREE OF CHARGE SINCE HE WASN'T ABLE TO HELP ME AT ALL. I HAD TO WALK TO THE SHOP TO PICK UP MY CAR BECAUSE MY MECHANIC WAS JUST AS BAFFLED AS I WAS. SINCE SOMEONE WHO WENT TO SCHOOL FOR THIS KIND OF STUFF COULDN'T HELP ME, I FIGURED I WOULD GOOGLE THE ISSUE TO SEE IF THERE WERE ANY ANSWERS OUT THERE. I FOUND WEBSITES FULL OF PEOPLE HAVING SIMILAR ISSUES. ( HTTP://WWW.CARCOMPLAINTS.COM/FORD/FUSION/2006/LIGHTS/TURN_SIGNALS_DO_NOT_WORK.SHTML ; HTTP://WWW.FORDFUSIONFORUM.COM/TOPIC/4304-PARKLAMPSTURN-SIGNAL-ISSUES/ )

NHTSA complaint #10705030 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

MY BACK DOOR LOCK ON MY DRIVER SIDE STOPPED AUTOMATICALLY LOCKING AND UNLOCKING UNLESS I DO IT MANUALLY. IT WASN'T A HUGE ISSUE SINCE I DON'T HAVE A LOT OF PEOPLE IN MY BACKSEAT. LAST NIGHT, WHEN I GOT HOME FROM WORK, I REACHED TO OPEN MY DOOR AND NOTHING HAPPENED. I THOUGHT I WAS TIRED ENOUGH TO BE MISTAKEN, BUT IT HAPPENED. MY DOOR WILL NOW ONLY OPEN FROM THE OUTSIDE. THE LOCK STILL LOCKS AND UNLOCKS AUTOMATICALLY WHEN I USE THE BUTTON, BUT I HAVE TO ROLL DOWN MY WINDOW TO GET OUT. THIS CAN BE HAZARDOUS IF SOMEONE IS LOCKED IN THE CAR DURING A WRECK, FIRE, GAS LEAK, ETC.

NHTSA complaint #10705033 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

THE POWER LOCKS, AND INTERIOR DOOR HANDLES TO OPEN THE DOOR IN BOTH THE FRONT AND REAR/DRIVER AND PASSENGER SIDES MALFUNCTION REGARDLESS OF USE/FORCE. THE INTERIOR DOOR HANDLE WARPS/BENDS AND BREAKS. THE LOCKING MECHANISM ALSO MALFUNCTIONS MAKING IT IMPOSSIBLE TO OPEN THE DOOR FROM THE INTERIOR. IN ONLY WAY TO EXIT THE VEHICLE IS TO ROLL DOWN THE WINDOW AND OPEN THE DOOR FROM THE OUTSIDE DOOR HANDLE. ONCE THE LOCKING MECHANISM HAS MALFUNCTIONED, IT IS IMPOSSIBLE TO LOCK THE VEHICLE VIA THE REMOTE ALARM OR WITH THE PHYSICAL KEY. THIS PRESENTS A MAJOR PROBLEM AS 1:IN THE EVENT THAT THE DRIVER AND OR PASSENGERS NEED TO EXIT THE VEHICLE IT IS IMPOSSIBLE UNLESS WINDOWS ARE ROLLED DOWN. 1B: IN THE EVENT THAT A CRASH OR WINDOWS MALFUNCTION, ALL OCCUPANTS ARE TRAPPED IN VEHICLE 2:THE VEHICLE IS WITHOUT PASSIVE ANTI-THEFT AS THE DOORS ARE UNABLE TO LOCK.

NHTSA complaint #10644179 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

RIGHT DIRECTIONAL SIGNAL DIDN'T WORK.

NHTSA complaint #10628793 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

THE FACTORY IGNITION COILS BEGAN TO SHORT AGAINST THE INTERIOR WALLS OF THE ENGINE HEAD ABOVE THE SPARK PLUGS. AS THEY SHORTED IT BURN THE POWER CONTROL MODULE (PCM). WITH NO PCM MY SPARK PLUGS FAILED TO LIGHT, CAUSING MY ENGINE BECOME FLOODED WITH GASOLINE, WHICH WASHED AWAY THE LUBRICANTS ON MY CYLINDER AND HEADS CAUSING ALL OF MY CYLINDERS AND HEADS TO BECOME DAMAGED. AS THIS HAPPENED BEFORE I WAS ABLE TO PULL OVER MY ENGINE SHUT OFF. CAUSING ME TO LOSE POWER STEERING AND ALL OF THE OTHER ELECTRICAL FUNCTIONING COMPONENTS. LUCKILY I WAS ON A FAIRLY QUIET ROAD AND AT SOMEWHAT LOW SPEEDS, BUT FOR THE MANY OTHERS THAT HAVE OR COULD EXPERIENCE THE SAME PROBLEM MIGHT NOT HAVE BEEN OR BE AS LUCKY. 2006 FORD FUSION 3.0L V6.

NHTSA complaint #10627360 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

MOTOR MOUNTS: ALL THREE MOUNTS HAVE BEEN REPLACED. 6 TOTAL. ONE HAS BEEN REPLACED TWICE. ONE THREE TIMES. ELECTRIC DOOR LOCKS & WINDOW REGULATORS: FRONT DRIVER AND REAR RIGHT PASSENGER HAVE FAILED. DRIVER FLOOR MAT: SLIDES.

NHTSA complaint #10616144 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE TRAVELING 60 MPH, SMOKE ENTERED THE VEHICLE FROM THE FRONT PANEL VENTS UNDERNEATH THE HOOD. THE CONTACT STATED THAT THE ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AND THE VEHICLE BEGAN TO STALL INTERMITTENTLY. THE FAILURE OCCURRED ON THREE SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 124,000 AND THE CURRENT MILEAGE 124,030. UPDATED 08/19/14*LJ UPDATED 8/30/2017

NHTSA complaint #10596750 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I HAVE HAD PROBLEMS WITH IT SINCE I BOUGHT IT, IT HAS PROBLEMS STARTING ESPECIALLY WHEN ITS COLD OUTSIDE. DRIVER HEATED SEAT CAUGHT FIRE AND MELTED MY SEAT, NOW MY HEATED SEAT DOESN'T WORK AND SEAT IS RUINED. TRANSMISSION IS POORLY MADE AND UNSAFE. WHILE DRIVING IT HAS PROBLEMS SHIFTING, SHOOTS THE RPMS ALL THE WAY UP. THE CAR SOUNDS LIKE ITS GOING TO BLOW UP. DOES IT MOSTLY WHEN SHOWING DOWN AND SPEEDING UP. NOT THE ONLY PERSON HAVING ISSUES, FORD NEEDS TO STOP BEING SO CHEAP AND RECALL THE 2006 HTTP://REPAIRPAL.COM/TRANSMISSION-PROBLEM-242.

NHTSA complaint #10594719 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I AM THE ORIGINAL OWNER OF A 2006 FORD FUSION WITH ONLY 65000 MILES. I RECENTLY HAD A VERY SCARY NEAR DEATH EXPERIENCE DUE TO A DEFECT IN THIS VEHICLE. AFTER MUCH RESEARCH ONLINE AND SPEAKING TO CERTIFIED MECHANICS I AM SURE FORD IS WELL AWARE OF THE PROBLEM THAT EXISTS WITH THE IGNITION COILS EXPLODING DUE TO A COMPUTER MALFUNCTION. THIS CAUSES THE CAR TO STOP. MY CAR HAPPENED TO STOP WHILE I WAS ON THE FREEWAY. I WON'T GO INTO A LOT OF DETAIL BUT IT WAS SCARY AND COULD HAVE POTENTIALLY COST ME MY LIFE. FORTUNATELY I WAS ABLE TO SAFELY COAST TO THE SHOULDER AND WAIT FOR AAA TO COME TO MY RESCUE. I TOOK MY CAR TO A MECHANIC WHO GOT THE CAR RUNNING AGAIN AFTER REPLACING TWO IGNITION COILS AND MY SPARK PLUGS, BUT IT BROKE DOWN AGAIN ON THE WAY HOME FROM THE MECHANIC. AGAIN, THE CAR JUST SHUTS OFF WITHOUT WARNING, BUT THIS TIME I WAS LEFT IN THE MIDDLE OF TRAFFIC WAITING FOR AAA. MY CAR IS NOW AT THE FORD DEALERSHIP AND THE BILL IS REALLY HIGH. BOTH, MY MECHANIC AND THE FORD SERVICE TECHNICIAN CONFIRMED THAT THERE IS AN ISSUE WITH THE COMPUTER THAT IS CAUSING IGNITION COILS TO "BURN UP" OR "EXPLODE". I UNDERSTAND THAT THERE IS AN 8 YEAR OR 80,000 MILE WARRANTY WITH COVERS THIS ISSUE, BUT UNFORTUNATELY I AM OVER THE 8 YEARS (BUT STILL 15,000 UNDER THE MILEAGE). THIS SHOULD BE A RECALL. SOMEONE COULD POTENTIALLY LOSE THEIR LIFE BECAUSE FORD CHOOSES TO OVERLOOK THIS TICKING TIME BOMB. I AM NOW HAVING TO SPEND $2200 TO REPAIR THIS ISSUE WHEN FORD SHOULD BE THE ONE COVERING THE COST TO MAKE IT RIGHT.

NHTSA complaint #10593524 — an unverified report by a vehicle owner.