2006 Ford Fusion engine problems

ENGINE

The contact owns a 2006 Ford Fusion. The contact became aware of an oil leak on the ground underneath the vehicle. The vehicle was taken to an independent mechanic who stated that oil was leaking from the engine. The mechanic was unsure where the leak originated. The vehicle was not repaired. The manufacturer was contacted but provided no assistance. The approximate failure mileage was 108,000.

NHTSA complaint #11526878 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2006 Ford Fusion. The contact stated that while driving at various speeds, there was an abnormal creaking sound coming from the front end of the vehicle. There was no warning light illuminated. The contact stated that the vehicle was repaired on several occasions due to the failure. The contact stated that each summer after the vehicle was repaired, the failure returned. The manufacturer was notified of the failure but provided no assistance. The vehicle was not repaired. The failure mileage was unknown.

NHTSA complaint #11525395 — an unverified report by a vehicle owner.

ENGINE

The serpentine belt keeps coming off or breaking. The idler pulley bolt keeps breaking off into the engine.

NHTSA complaint #11457506 — an unverified report by a vehicle owner.

ENGINE

2006 FORD FUSION: WHEN DRIVING AFTER THE CAR GETS WARM UP IT IS STARTS SLIPPING AND SHIFTING SOMEONE HARSHLY LIKE IT JUST GOT KICKED. I WAS ON THE FREEWAY AND COULDN'T SPEED UP ALMOST GOT REAR ENDED. I SEE OTHERS HAVE THE SAME ISSUE AFTER DOING A SEARCH I FOUND DIFFERENT ANSWER AS WHAT COULD BE WRONG. FOUND OUT WHAT THE ISSUE IS WITH THE AISIN TRANSMISSIONS SLIPPING WHICH WERE USED IN THE 2006 FUSION. IT IS DUE TO VALVE BORE WEAR IN THE MAIN CONTROL. IF THE TRANS FLUID ISNT BURNT (MEANING THERE IS INTERNAL TRANS CLUTCH DAMAGE) THEN YOU ARE LOOKING AT $800-$1000 TO REPLACE THE MAIN CONTROL. IF THE CLUTCHES ARE BURNT THE WHOLE TRANS WILL HAVE TO BE REPLACED COST??? SOMETHING LIKE $4000-$5000. THE PROBLEM IS THAT WHEN FORD BOUGHT THE AISIN TRANS, FORD DID NOT BUY THE SERVICE RIGHTS. SO THERE ARE NO SERVICE PARTS AVAILABLE OR TRAINING AVAIL ON HOW TO SERVICE THIS TRANS. THE ISSUE WITH THE MAIN CONTROL HAS BEEN SO COMMON THAT AISIN HAS AGREED TO SUPPLY FORD WITH SERVICE MAIN CONTROLS.THERE HAS BEEN A TECHNICAL SERVICE BULLETIN OUT THERE. SEE BELOW TSB BULLETIN DATE: FEB 2007 VARIOUS DRIVEABILITY/TRANSMISSION SYMPTOMS - PCM/TCM CALIBRATION UPDATES 3.0L - AISIN F21 AUTO TRANS. ( NHTSA ITEM NUMBER - 10021277 ) AS ONE PERSON POSTED. FORD NEEDS TO MAKE THIS RIGHT!!! VERY UNSAFE*** OUR CAR IS PARKED IN THE GARAGE WE CAN NOT AFFORD TO FIX IT OR SELL IT WITH A BAD TRANSMISSION .AMMCO SAID NEEDS NEW TRANSMISSION.

NHTSA complaint #11132958 — an unverified report by a vehicle owner.

ENGINE

TAKATA RECALL HAVE YET TO GET PAPERS AND GET PROBLEM FIXED. INTERMITTEN FAILURE OF THE ELECTRONIC THROTTLE BODY.

NHTSA complaint #11120049 — an unverified report by a vehicle owner.

ENGINE

THERMOSTAT STICKS OPEN (COLD) WHILE DRIVING. SUDDEN JUMPS TO NORMAL TEMPERATURE RANGE FOLLOWED BY DROP TO COLD AGAIN. VEHICLE HAS HARD TIME STARTING WHEN TEMPERATURE GAUGE IS ON COLD MARK AFTER RUNNING FOR ANY PERIOD OF TIME. THERMOSTAT HAS BEEN REPLACED WITH NO IMPROVEMENT. THROTTLE STICKS ON ACCELERATION CAUSING ENGINE TO BOG DOWN AND ALMOST CHOKE OUT FOLLOWED BY SUDDEN BURST OF ACCELERATION THAT COULD LEAD TO ACCIDENT.

NHTSA complaint #11093739 — an unverified report by a vehicle owner.

ENGINE

WHILE DRIVING THE CAR ON THE HIGHWAY AT TYPICAL HIGHWAY SPEEDS (60MPH-70MPH) THE WRENCH INDICATOR LIGHT COMES ON IN THE DASHBOARD AND THE CAR LOOSES THE ABILITY TO ACCELERATE ANY FASTER THAN ABOUT 10 MILES AN HOUR. WE PULL OVER, TURN THE CAR OFF AND START IT BACK UP AGAIN AND IT APPEARS TO RUN FINE. THIS CAN HAPPEN RANDOMLY ONE DAY AND THEN NOT HAPPEN AGAIN FOR A FEW WEEKS OR EVEN A MONTH OR TWO THEN IT DOES IT AGAIN. BASED ON MY RESEARCH COMPARING OTHER DRIVERS POSTING ABOUT THE SAME PROBLEM I BELIEVE THIS PROBLEM IS DUE TO A DEFECTIVE THROTTLE BODY OR WHAT IS SOMETIMES CALLED THE ETB = ELECTRONIC THROTTLE BODY. THE PROBLEM IS THE RESULT OF THE COMPUTER AND SENSORS SENDING BAD SIGNALS TO THE THROTTLE BODY MECHANISM WHICH THEN AFFECTS THE AIR/GAS MIXTURE AND ADVERSELY AFFECTS ACCELERATION, THIS IS DANGEROUS AND A SAFETY ISSUE. THERE WAS A RECALL ON DEFECTIVE THROTTLE BODIES FOR FORD FUSIONS BUT IT ONLY INCLUDED 2009 MODELS AND LATER MODELS, BUT IT DID NOT INCLUDE 2006 MODELS. I HAVE READ OF OTHER PEOPLE IN EARLIER MODEL CARS FROM AS EARLY AS 2005 POSTING ON FORUMS THAT THEY HAD THE SAME ISSUE, SO I BELIEVE THIS WASN'T ONLY A PROBLEM ON 2009'S AND LATER. FORD ISSUES AN EXTENDED WARRANTY ON THE FUSION OF TEN YEARS OR 150,000 MILES. I DON'T KNOW THE NAME OF THE SPECIFIC RECALL OTHER THAN A REFERENCE TO CONSUMER SATISFACTION PROGRAM 13N03. THE PROBLEM SOMETIMES IS REFERRED AS THE "LIMP HOME" MODE. IN CONCLUSION, I WOULD LIKE OUR 2006 FORD FUSION TO BE INCLUDED OR QUALIFIED IN THE RECALL SO I CAN FIX THIS PROBLEM OR AT LEAST GET REIMBURSED ONCE I GET IT FIXED SINCE IT IS A DEFECT WITH THE CAR.

NHTSA complaint #11022904 — an unverified report by a vehicle owner.

ENGINE

WHILE DRIVING MY ENGINE INTERMITTENTLY SHUTS OFF. THE CAR WILL STILL BE "ON". IN THE SENSE THAT THE AC AND RADIO AND OTHER FEATURES ARE STILL WORKING, BUT THE CAR WILL NOT ACCELERATE OR MOVE. I HAVE TO PUT IT IN PARK. AND RESTART IT. "CHECK ENGINE" AND "CHECK CHARGING SYSTEM" INDICATOR LIGHTS POP UP ON THE DASH. I HAVE DONE SEVERAL THINGS, CHANGE BELTS, CHANGED ALTERNATORS, CHANGED CAM SHAFTS, AND FINALLY AFTER THAT THOUSAND DOLLARS WAS SPENT THE CODE I'M GETTING READ FROM MY MECHANIC IS FOR THE THROTTLE BODY SHUT DOWN.

NHTSA complaint #11014889 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2006 FORD FUSION. WHILE ACCELERATING FROM A STOP, THE VEHICLE'S SPEED INCREASED VERY SLOWLY AND SHIFTED ABNORMALLY. IN ADDITION, THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE ON THE REBUILT ENGINE WAS APPROXIMATELY 90,000 AND THE VEHICLE FAILURE MILEAGE WAS APPROXIMATELY 152,000.

NHTSA complaint #10910863 — an unverified report by a vehicle owner.

ENGINE

DRIVING ON THE HIGHWAY AT 80 MPH THE CAR LOOSES ACCELERATION POWER AND AN ORANGE WRENCH SYMBOL SHOWS UP ON THE DASHBOARD. I HAVE TO SAFELY COAST MY VEHICLE TO A SAFE SPOT OFF THE ROAD. WHEN CAR COMES TO COMPLETE STOP IT IDLES REALLY ROUGH AND LOUD AND MAKES A LOUD NOISE WHEN PLACED INTO PARK. I HAVE TO SHUT CAR OFF THEN RESTART AND I'M ABLE TO CONTINUE DRIVING AS IF NOTHING EVER HAPPENED. THE PROBLEM KEEPS HAPPENING AND IS STARTING TO OCCUR MORE OFTEN BUT ALWAYS WHILE DRIVING ON THE HIGHWAY...PRAY TO GOD NOTHING SERIOUS EVER HAPPENS.

NHTSA complaint #10910410 — an unverified report by a vehicle owner.

ENGINE

INTERIOR FRONT DOOR LATCHES BROKE AROUND THE 100,000 MILEAGE. ALL FOUR ELECTRIC WINDOW REGULATORS/MOTOR HAVE FAILED FROM THE 80,000-110,000 MILEAGE PERIOD. EACH OF THE REGULATORS PLASTIC ROLLERS WHERE THE CABLE GOES AROUND WERE BROKEN. TWO OF THE AUTOMATIC DOOR LOCKS QUIT WORKING AS WELL. ALL MOTOR MOUNTS HAVE BEEN REPLACED AT LEAST ONCE AND 2 HAVE BEEN REPLACED TWICE EACH. 4-CYLINDER. I HAVE SEEN 100'S OF COMPLAINTS ONLINE ABOUT THE MOTOR MOUNTS AND MANY FOR THE INTERIOR LATCHES AND WINDOW REGULATORS. I HAVE SPENT OVER A THOUSAND DOLLARS ON THE MOTOR MOUNT ISSUES.

NHTSA complaint #10871642 — an unverified report by a vehicle owner.

ENGINE

OUR FORD FUSION ENGINE SUDDENLY STARTED DYING IN TRAFFIC. WHEN STOPPING AT A LIGHT OR STOP SIGN IN TRAFFIC, THE IDLE WOULD DROP BELOW 5000 RPMS, THEN SUDDENLY THE ENGINE WOULD DIE. AFTER PLACING THE VEHICLE IN PARK, WE WOULD HAVE TO RESTART THE ENGINE. USUALLY WOULD DIE AFTER SITTING STILL AFTER ABOUT 10 SECONDS. SOMETIMES THE VEHICLE WOULDN'T START BACKUP RIGHT AWAY, SO WE WERE STUCK ON THE ROAD UNTIL IT FINALLY DECIDED TO START. NO CHECK ENGINE LIGHT OR WRENCH WOULD DISPLAY. WE TOOK IT IN TO FORD DEALER AND THEY DETERMINED THE THROTTLE BODY WAS DEFECTIVE. APPARENTLY THIS IS AN ISSUE WITH MOST FORD FUSIONS, AS WELL AS OTHER MODELS THAT USE THE SAME THROTTLE BODY. THE VEHICLE HAS 80,000 MILES ON IT. REPAIR COSTS WERE OVER $1000. WHEN IS FORD GOING TO ADDRESS THIS ISSUE FOR THE FUSIONS THAT WERE MADE BEFORE 2009? THANKS, [XXX] 'INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'

NHTSA complaint #10837714 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH, THE VEHICLE ACCELERATED AND DECELERATED INDEPENDENTLY AS THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ECM FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 121,759.

NHTSA complaint #10824786 — an unverified report by a vehicle owner.

ENGINE

WHILE REVERSING OUT OF MY PARKING SPOT AT WORK THE OTHER DAY, THE CAR COMPLETELY STALLED WHILE MY FOOT WAS ON THE GAS PEDAL. I WAS THANKFUL THAT NO ONE WAS BEHIND ME BECAUSE THE CAR COMPLETELY SHUT DOWN. I PUT IT IN PARK AND RESTARTED IT EASILY, BUT I WAS TOO NERVOUS TO DRIVE ON A HIGHWAY AFTER THE INCIDENT, AS THERE WAS NO INDICATION THE FIRST TIME THAT THE CAR WAS GOING TO SHUT DOWN. I DROVE DOWN A COUNTRY ROAD WITH MY FLASHERS ON UNTIL I GOT TO A SAFE PLACE WHERE I COULD CALL MY HUSBAND. WHILE I WAITED FOR HIM TO COME GET ME, I KEPT THE CAR IN IDLE AND RAN THE HEATER. THE CAR SHUT DOWN AGAIN, AND THIS TIME I WAS ABLE TO TAKE A PICTURE OF THE WARNING LIGHTS THAT ACCOMPANIED THE FAILURE. (SEE ATTACHED.) THE DASH SAID "CHECK CHARGING SYSTEM" AND THE OIL, EMISSIONS, AND BATTERY LIGHTS CAME ON. WE CALLED AND HAD IT TOWED TO A LOCAL SHOP BUT MAN THERE HAS NO IDEA WHAT THE PROBLEM IS AND TOLD US TO TOW IT TO THE DEALERSHIP. MY CAR HAS OVER 100,000 MILES, BUT I HAVE HAD TROUBLE WITH IT SINCE I BOUGHT IT. I HAVE HAD MECHANICS TELL ME THAT THE ELECTRICAL SYSTEM DOES NOT WORK WELL. I HAVE ALSO HAD THEM TELL ME THAT IT IS NORMAL FOR THE AIR-CONDITIONER IN THESE CARS TO JUST TURN ON RANDOMLY TO COOL THE ENGINE, WHICH MINE DOES FREQUENTLY. MOREOVER, THE BATTERY IN THE CAR NOW IS THE THIRD ONE I'VE HAD. BRAKE LIGHTS BURN OUT CONSTANTLY, AND THE TRANSMISSION MAKES TERRIBLE NOISES WHEN I START THE CAR AND PARTICULARLY WHEN I REVERSE. THIS NEW PROBLEM OF STOPPING UNEXPECTEDLY IS SIMPLY UNACCEPTABLE. I HATE TO GIVE UP MY FUSION BECAUSE WHEN IT'S RUNNING CORRECTLY, IT'S A GREAT CAR; HOWEVER, THIS LAST INSTANCE IS JUST TOO DANGEROUS. IF I WERE ON THE HIGHWAY, I COULD HAVE BEEN KILLED. THIS SAME THING HAS HAPPENED TO FRIENDS OF MINE WHO OWNED FORDS. I WILL BE CALLING FORD AND ASKING THEM ABOUT THROTTLE BODY AND PCM PROBLEMS THAT OTHERS HAVE NOTED IN THEIR COMPLAINTS.

NHTSA complaint #10820582 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2006 FORD FUSION. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED AND THE CHECK ENGINE LIGHT AND ELECTRONIC THROTTLE CONTROL WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC THROTTLE BODY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 159,070.

NHTSA complaint #10818419 — an unverified report by a vehicle owner.

ENGINE

AFTER SLOWING DOWN JUST BEFORE THE STOP SIGN, MY CAR STARTED TO SPUTTER AND WHEN I TRIES TO ACCELERATE AFTER THE INTERSECTION IT STOPS ACCELERATING. I HAD TO LIMP ALONG TO GET HOME. LUCKILY, I WAS JUST ABOUT 1.5 MILES FROM HOME. I HAVE DONE FOR THIS CAR ALL SCHEDULED MAINTENANCE AND NEVER MISSED THE RECOMMENDED PERIODICAL OIL CHANGES. I DRIVE LESS THAN 5000 MILES A YEAR WITH THIS CAR AN IT HAS LESS 59,000 MILES ON IT. THIS MUST BE DUE TO A DEFECTIVE PART FROM THE FACTORY AND I SHOULD NOT PAY FOR IT. I HAVE LEFT IT PARKED ON MY DRIVEWAY UNTIL I HEAR FROM YOU AND BY WAY OF YOUR GOOD OFFICES HOPEFULLY FROM FORD. THANK YOU FOR KIND ASSISTANCE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #10745680 — an unverified report by a vehicle owner.

ENGINE

CAR DIES WHILST DRIVING. THIS IS A SAFETY ISSUE. AUTHORIZED FORD DEALER SERVICE DETERMINED ISSUE WAS CAUSED BY A DEFECTIVE THROTTLE BODY.

NHTSA complaint #10712343 — an unverified report by a vehicle owner.

ENGINE

WHEN DRIVING ON THE HIGHWAY AND ROADWAY, SUCH AS BRIDGES THIS SUMMER, MY VEHICLE STALLED SEVERAL TIMES, LOST POWER COMING ALMOST TO A COMPLETE STOP, PUTTING MY FAMILY AND I AT RISK. WHEN I PRESSED ON THE GAS TO ACCELERATE, THE ENGINE BEGIN TO RACE, CAUSING THE "CHECK ENGINE LIGHT" TO COME ON. IT ALSO JERKED AND SKIDDED AS I TRIED TO MANEUVER THE STEERING. TO AVOID ACCIDENTS ON THESE OCCASIONS, THE VEHICLE HAD TO BE PULLED OVER AND SUBSEQUENTLY, PARKED. HIGHWAY DRIVING WAS ALSO AVOIDED MOST OF THE SUMMER FOR SAFETY AND CONCERN. THERE IS ALSO AN ISSUE WITH THE FRONT DRIVER SIDE AIRBAG, AS RECENT AS THIS SUMMER, THE SEAL BECAME DISTORTED, TWISTED AND CRACKED IN THE DASHBOARD. LASTLY, ABOUT 2 WEEKS AGO, THE REAR DOOR LOCK ON THE DRIVER SIDE NO LONGER WORKS, THE DOOR MUST BE OPENED MANUALLY FROM THE INSIDE OF THE CAR. THESE ARE VALID VEHICLE DEFECTS AND SAFETY ISSUES AND FORD MUST STEP UP AND DO THE RIGHT THING FOR ALL PARTIES OF INTEREST.

NHTSA complaint #10659476 — an unverified report by a vehicle owner.

ENGINE

THIS VEHICLE LOSE POWER AND SLOWS DOWN, IT HAPPENED ON THE EXPRESS WAY MORE THAN 5 TIMES. I WAS ALMOST REAR ENDED BY A SEMI TRUCK. I ONLY DRIVE IT ON SIDE STREETS NOW. IT POPS INTO GEAR VERY HARD, THE WRENCH LIGHT AND THE CHECK ENGINE LIGHT IS ON. IT GETS STUCK IN SECOND GEAR AND BURNS A LOT OF GAS. IT STARTED SOON AFTER THE WARRANTY RAN OUT. I HAD A LOT OF REPAIRS DONE AND THE POWER TRAIN AND ENGINE IS NOT WORKING RIGHT AS OF YET, SOMETHING IS WRONG WITH THIS FORD FUSION 06 AND A LOT OF PEOPLE ARE HAVING THE SAME PROBLEMS WITH IT. WHY DOES IT TAKE THE DEATHS OF MANY INNOCENT PEOPLE FIRST BEFORE THERE'S A RECALL?

NHTSA complaint #10653563 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE SUDDENLY DECELERATED AND FAILED TO ACCELERATE OVER 20 MPH. THE VEHICLE WAS RESTARTED AND THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN NOTICED THAT THE WRENCH WARNING LIGHT ILLUMINATED AND DIAGNOSED THAT THE DRIVE TRAIN AND THE THROTTLE BODY FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.

NHTSA complaint #10650325 — an unverified report by a vehicle owner.

ENGINE

VEHICLE IS HESITANT TO START AND GET UP PAST 5 MPH AND ENGINE LIGHT CAME ON. TOOK CAR TO LOCAL PEP BOYS WHERE THEY PLACED IT ON ENGINE MACHINE. PER PEP BOY CAR THROUGH THROTTLE BODY STUCK OPEN CODE. LOCAL DEALER CLOSED DROPPED CAR OFF FOR LOOK OVER. DEALER CONFIRMED MONDAY THAT THROTTLE BODY IS STUCK BUT STATE THAT THIS VEHICLE IS NOT A PART OF CURRENT THROTTLE BODY RECALL...IM WRITING THIS HERE SO IF FORD SHOULD DECIDE TO COVER THIS AT A FUTURE TIME I'LL BE ABLE TO FILE FOR A REFUND.

NHTSA complaint #10639820 — an unverified report by a vehicle owner.

ENGINE

THE FACTORY IGNITION COILS BEGAN TO SHORT AGAINST THE INTERIOR WALLS OF THE ENGINE HEAD ABOVE THE SPARK PLUGS. AS THEY SHORTED IT BURN THE POWER CONTROL MODULE (PCM). WITH NO PCM MY SPARK PLUGS FAILED TO LIGHT, CAUSING MY ENGINE BECOME FLOODED WITH GASOLINE, WHICH WASHED AWAY THE LUBRICANTS ON MY CYLINDER AND HEADS CAUSING ALL OF MY CYLINDERS AND HEADS TO BECOME DAMAGED. AS THIS HAPPENED BEFORE I WAS ABLE TO PULL OVER MY ENGINE SHUT OFF. CAUSING ME TO LOSE POWER STEERING AND ALL OF THE OTHER ELECTRICAL FUNCTIONING COMPONENTS. LUCKILY I WAS ON A FAIRLY QUIET ROAD AND AT SOMEWHAT LOW SPEEDS, BUT FOR THE MANY OTHERS THAT HAVE OR COULD EXPERIENCE THE SAME PROBLEM MIGHT NOT HAVE BEEN OR BE AS LUCKY. 2006 FORD FUSION 3.0L V6.

NHTSA complaint #10627360 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE IDLER PULLEY FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000.

NHTSA complaint #10627488 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

MOTOR MOUNTS: ALL THREE MOUNTS HAVE BEEN REPLACED. 6 TOTAL. ONE HAS BEEN REPLACED TWICE. ONE THREE TIMES. ELECTRIC DOOR LOCKS & WINDOW REGULATORS: FRONT DRIVER AND REAR RIGHT PASSENGER HAVE FAILED. DRIVER FLOOR MAT: SLIDES.

NHTSA complaint #10616144 — an unverified report by a vehicle owner.

ENGINE

CAR STARTED KNOCKING GO SLOW THAN WOULD SPEED UP, BRAKES WOULD WORK THAN NOT! GOT HOME CHECKED THE OIL IT WAS LOW, WHICH WAS FINE A WEEK BEFORE THAT. PUT OIL IN IT, MY SON SAW IT LEAKING AROUND OIL PAN. SO HAD IT TOWED TO A CAR REPAIR CHECKED IT OUT, THEY ARE TELLING ME IT'S THE TIMING CHAIN, NOW THEY SAY THE CODES COMING OFF THE MACHINE THEY ARE HOOKING IT UP WITH SAY IT NEEDS A NEW ENGINE. I DON'T EVEN HAVE A 100 THOUSAND MILES ON IT AND TAKE GOOD CARE OF MY CAR!

NHTSA complaint #10615172 — an unverified report by a vehicle owner.